Loctite B1613330 User Manual

Material Safety Data Sheet

Revision Number: 001.1 Issue date: 08/30/2012

1. PRODUCT AND COMPANY IDENTIFICATION

Product name: Loctite Super Glue Ultra Control
Product type:

Company address: Contact information:

Henkel Corporation
One Henkel Way
Rocky Hill, Connecticut 06067

Liquid

Cyanoacrylate

2. HAZARDS IDENTIFICATION

EMERGENCY OVERVIEW
HMIS:
Physical state:
Color:
Odor:

WARNING:

Liquid
Colorless, Transparent
Sharp

COMBUSTIBLE LIQUID AND VAPOR.
BONDS SKIN IN SECONDS.
MAY CAUSE EYE AND RESPIRATORY TRACT IRRITATION.

Relevant routes of exposure:
Potential Health Effects

Inhalation:
Skin contact:

Eye contact:
Ingestion:

Existing conditions aggravated by
exposure:

Skin, Inhalation, Eyes

Exposure to vapors above the established exposure limit results in respiratory irri tation, which
may lead to difficulty in breathing and tightness in the chest.
Bonds skin in seconds. May cause skin irritation. Cyanoacrylates have been reported t o cause
allergic reaction but due to rapid polymerization at the skin surface, an allergic response is rare.
Cyanoacrylates generate heat on solidification. In rare circumstances a large drop will burn the
skin. Cured adhesive does not present a health hazard even if bonded to the skin.
Irritating to eyes. Causes excessive tearing. Eyelids m ay bond.
Not expected to be harmful by ingestion. Rapidly polymerizes (solidifies ) and bonds i n mouth. It
is almost impossible to swallow.

Eye, skin, and respiratory disorders.

This product is considered hazardous under 29 CFR 1910.1200 (Hazard Communication).

See Section 11 for additional toxicological information.

3. COMPOSIT ION / INFORMATION ON INGRED IENTS

Hazardous components CAS NUMBER %

Ethyl 2-cyanoacrylate 7085-85-0 60 - 100
Thickener Proprietary 5 - 10

IDH number:

Region:

Telephone: [phone]
MEDICAL EMERGENCY Phone: Poison Control Center
1-877-671-4608 (toll free) or 1-303-592-1711
TRANSPORT EMERGENCY Phone: CHEMTREC
1-800-424-9300 (toll free) or 1-703-527-3887
Internet: www.henkelna.com

HEALTH:
FLAMMABILITY:
PHYSICAL HAZARD:
Personal Protection:

1647358

United States

2
2

1

See MSDS Section 8

IDH number: 1647358 Product name: Loctite Super Glue Ultra Control Liquid

Page 1 of 5

4. FIRST AID MEASURES

Inhalation:
Skin contact:

Eye contact:

Ingestion:

Notes to physician:

Move to fresh air. If symptoms persist, seek medical advice.
Do not pull bonded skin apart. Soak in warm soapy water. Gently peel apart

using a blunt instrument. If skin is burned due to the rapid generation of heat
by a large drop, seek medical attention. If lips are bonded, apply warm water
to the lips and encourage wetting and pressure from saliva in mouth. Peel or
roll lips apart. Do not pull lips apart with direct opposing force.

Immediately flush with plenty of water for at least 15 minutes. Get medical
attention. If eyelids are bonded closed, release eyelashes with warm water by
covering with a wet pad. Do not force eye open. Cyanoacrylate will bond to
eye protein and will cause a lachrymatory effect which will help to debond the
adhesive. Keep eye covered until debonding is complete, usually within 1-3
days. Medical attention should be sought in case solid particles of polymerized
cyanoacrylate trapped behind the eyelid caused abrasive damage.

Ensure breathing passages are not obstructed. The product will polymerize
rapidly and bond to the mouth making it almost impossible to swallow. Saliva
will separate any solidified product in several hours. Prevent the patient from
swallowing any separated mass.

Surgery is not necessary to separate accidentally bonded tissues. Experience
has shown that bonded tissues are best treated by passive, non-surgical first
aid. If rapid curing has caused thermal burns they should be treated
symptomatically after adhesive is removed.

5. FIRE FIGHTING MEASURES

Flash point:
Autoignition temperature:
Flammable/Explosive limits - lower:
Flammable/Explosive limits - upper:
Extinguishing media:
Special firefighting procedures:

Unusual fire or explosion hazards:
Hazardous combustion products:

80 - 93.4 °C (176°F - 200.12 °F)
485 °C (905°F)
Not available.
Not available.
Dry powder. foam Carbon dioxide.
Fire fighters should wear positive pressure self-contained breathing apparatus

(SCBA).
Not available.
Trace amounts of toxic and/or irritating fumes may be released and the use of

breathing apparatus is recommended.

6. ACCIDENTAL RELEASE MEASURES

Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected

Environmental precautions:
Clean-up methods:

Do not allow product to enter sewer or waterways.
Do not use cloths for mopping up. Flood with water to complete

polymerization and scrape off the floor. Cured material can be disposed of as
non-hazardous waste.

personnel.

IDH number: 1647358 Product name: Loctite Super Glue Ultra Control Li qui d

Page 2 of 5