INSTALLATION MANUAL
AIR CONDITIONER
•Please read this installation manual completely before installing the product.
•Installation work must be performed in accordance with the national wiring standards by authorized personnel only.
•Please retain this installation manual for future reference after reading it thoroughly.
TYPE : CEILING CASSETTE
www.lg.com
P/NO : 3828A10001Y
Ceiling Cassette Air Conditioner Installation Manual
TABLE OF CONTENTS
Installation
Required Parts
Requirements
Safety Precautions............................ |
3 |
Introduction........................................ |
8 |
Symbols used in this Manual.......... |
8 |
Features ........................................... |
8 |
Installation .......................................... |
9 |
Installation Tools............................... |
9 |
Installation of Indoor, Outdoor |
|
Unit ................................................ |
10 |
Air purging...................................... |
22 |
Test running................................. |
24 |
Optional operation ..................... |
26 |
Installation guide at the seaside ... |
29 |
Connecting cable
Pipes: Gas side Liquid side
Hanging Bolt
(W 3/8 or M10 length 650mm)
Insulated drain hose
Additional Drain hose (Inner Dia.............32mm)
Required Tools
Horizontal meter
Screw driver
Electric drill
Hole core drill (ø70mm)
Flaring Tools set
Torque Wrenches
Hexagonal Wrench (4mm, 5mm)
Gas-leak detector
Owner’s Manual
Installation Manual
Thermometer
2 Ceiling Cassette Air Conditioner
|
|
|
|
Safety Precautions |
|
|
|
|
|
|
|
|
||
|
Safety Precautions |
|
||
To prevent injury to the user |
damage, the following instructions |
|||
must be followed. |
|
|||
■ Incorrect operation due |
harm or damage. The seriousness |
|||
is classified by the following |
|
|||
|
|
|
This |
of death or serious injury. |
|
|
|
||
|
|
|
|
|
|
|
|
This |
of injury or damage. |
|
|
|
||
■ Meanings of symbols used |
below. |
not to do.
the instruction.
■ Installation
Do not use a defective or underrated circuit breaker. Use this appliance on a dedicated circuit.
•There is risk of fire or electric shock.
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
For electrical work, contact |
Always ground the product. |
||||
the dealer, seller, a qualified |
|
|
|
|
|
electrician, or an Authorized |
|
|
|
|
|
Service Center. |
|
|
|
|
|
• Do not disassemble or repair the |
• There is risk of fire or electric |
||||
product. There is risk of fire or |
shock. |
||||
electric shock. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Install the panel and the cover |
Always install a dedicated |
Use the correctly rated breaker |
of control box securely. |
circuit and breaker. |
or fuse. |
•There is risk of fire or electric shock.
•Improper wiring or installation may cause fire or electric shock
•There is risk of fire or electric shock.
Installation Manual 3
Safety Precautions
Do not modify or extend the power cable.
Do not install, remove, or re- |
Be cautious when unpacking |
install the unit by yourself |
and installing the product. |
(customer). |
|
•There is risk of fire or electric shock.
•There is risk of fire, electric shock, explosion, or injury.
•Sharp edges could cause injury. Be especially careful of the case edges and the fins on the condenser and evaporator.
For installation, always contact the dealer or an Authorized Service Center.
•There is risk of fire, electric shock, explosion, or injury.
Do not install the product on a defective installation stand.
•It may cause injury, accident, or damage to the product.
Be sure the installation area does not deteriorate with age.
•If the base collapses, the air conditioner could fall with it, causing property damage, product failure, and personal injury.
Use a vacuum pump or Inert (nitrogen) gas when doing leakage test or air purge. Do not compress air or Oxygen and Do not use Flammable gases. Otherwise, it may cause fire or explosion.
• There is the risk of death, injury, fire or explosion.
■ Operation
Do not let the air conditioner run for a long time when the humidity is very high and a door or a window is left open.
•Moisture may condense and wet or damage furniture.
Do not plug or unplug the power supply plug during operation.
•There is risk of fire or electric shock.
Take care to ensure that power cable could not be pulled out or damaged during operation.
•There is risk of fire or electric shock.
Do not touch(operate) the product with wet hands.
•There is risk of fire or electrical shock.
Do not place anything on the power cable.
•There is risk of fire or electric shock.
Do not place a heater or other appliances near the power cable.
•There is risk of fire and electric shock.
4 Ceiling Cassette Air Conditioner
Safety Precautions
Do not allow water to run into electric parts.
•It may cause There is risk of fire, failure of the product, or electric
shock.
Do not store or use flammable gas or combustibles near the product.
•There is risk of fire or failure of product.
Gasolin
Do not use the product in a tightly closed space for a long time.
• Oxygen deficiency could occur.
When flammable gas leaks, turn off the gas and open a window for ventilation before turn the product on.
•Do not use the telephone or turn switches on or off.
There is risk of explosion or fire
Do not open the inlet grill of the product during operation.
(Do not touch the electrostatic filter, if the unit is so equipped.)
•There is risk of physical injury, electric shock, or product failure.
If strange sounds, or small or smoke comes from product. Turn the breaker off or disconnect the power supply cable.
•There is risk of electric shock or fire.
When the product is soaked (flooded or submerged), contact an Authorized Service Center.
•There is risk of fire or electric shock.
Stop operation and close the window in storm or hurricane. If possible, remove the product from the window before the hurricane arrives.
•There is risk of property damage, failure of product, or electric shock.
Be cautious that water could not enter the product.
•There is risk of fire, electric shock, or product damage.
Ventilate the product from time to time when operating it together with a stove, etc.
• There is risk of fire or electric shock.
Turn the main power off when cleaning or maintaining the product.
• There is risk of electric shock.
Installation Manual 5
When the product is not be used for a long time, disconnect the power supply plug or turn off the breaker.
•There is risk of product damage or failure, or unintended operation.
Take care to ensure that nobody could step on or fall onto the outdoor unit.
•This could result in personal injury and product damage.
■ Installation
Always check for gas (refrigerant) leakage after installation or repair of product.
•Low refrigerant levels may cause failure of product.
|
|
|
|
|
|
Install the drain hose to |
Keep level even when |
|
ensure that water is drained |
installing the product. |
|
away properly. |
|
|
• A bad connection may cause |
• To avoid vibration or water |
|
water leakage. |
leakage. |
90˚
Do not install the product where the noise or hot air from the outdoor unit could damage the neighborhoods.
Use two or more people to lift and transport the product.
Do not install the product where it will be exposed to sea wind (salt spray) directly.
• It may cause a problem for your |
• Avoid personal injury. |
• It may cause corrosion on the product. |
||||
neighbors. |
|
|
|
Corrosion, particularly on the condenser |
||
|
|
|
|
|
and evaporator fins, could cause product |
|
|
|
|
|
|
malfunction or inefficient operation. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
■ Operation
Do not expose the skin directly to cool air for long periods of time.
(Don't sit in the draft.)
• This could harm to your health.
Do not use the product for special purposes, such as preserving foods, works of art, etc. It is a consumer air conditioner, not a precision refrigeration system.
• There is risk of damage or loss of property.
6 Ceiling Cassette Air Conditioner
Do not block the inlet or outlet of air flow.
• It may cause product failure.
Do not step on or put anyting on the product. (outdoor units)
•There is risk of personal injury and failure of product.
Do not drink the water drained from the product.
Use a soft cloth not use harsh solvents, etc.
•There is risk of shock, or parts of the
Always insert the filter securely. Clean the filter every two weeks or more often if necessary.
•A dirty filter reduces the efficiency of the air conditioner and could cause product malfunction or damage.
Use a firm stool or ladder when cleaning or maintaining the product.
• It is not sanitary and could cause |
• Be careful and avoid personal |
serious health issues. |
injury. |
Do not insert hands or other objects through the air inlet or outlet while the product is operated.
•There are sharp and moving parts that could cause personal injury.
Replace the all batteries in the remote control with new ones of the same type. Do not mix old and new batteries or different types of batteries.
• There is risk of fire or explosion
Do not recharge or disassemble the batteries. Do not dispose of batteries in a fire.
• They may burn or explode.
If the liquid from the batteries gets onto your skin or clothes, wash it well with clean water. Do not use the remote if the batteries have leaked.
•The chemicals in batteries could cause burns or other health hazards.
Introduction
Introduction
SymbolsusedinthisManual
This symbol alerts you to the risk of electric shock.
This symbol alerts you to hazards that may cause harm to the air conditioner.
NOTICE This symbol indicates special notes.
Features
Heat Pump Model
Anti-bacteria
Signal Receptor
Air
Intake |
Cooling Model |
Air Outlet |
|
|
Remote |
|
Controller |
|
Signal Receptor |
8 Ceiling Cassette Air Conditioner
Installation
Installation
InstallationTools
Figure |
Name |
Figure |
Name |
|
Screw driver |
|
Ohmmeter |
Electric drill |
Hexagonal wrench |
Measuring tape, Knife |
Ammeter |
Hole core drill |
Gas-leak detector |
|
Spanner |
Thermometer, |
|
Horizontal meter |
||
|
Torque wrench |
Flaring tool set |
Installation Manual 9
Installation
InstallationofIndoor,OutdoorUnit
Selection of the best location
1)Indoor unit
•There should not be any heat source or steam near the unit.
•There should not be any obstacles to prevent the air circulation.
•A place where air circulation in the room will be good.
•A place where drainage can be easily obtained.
•A place where noise prevention is taken into consideration.
•Do not install the unit near the door way.
•Ensure the spaces indicated by arrows from the wall, ceiling, or other obstacles.
•The indoor unit must keep the maintenance space.
Ceiling |
|
|
|
<![if ! IE]> <![endif]>more |
Ceiling Board |
|
Ceiling Board |
|
|
|
<![if ! IE]> <![endif]>or |
|
|
|
|
|
<![if ! IE]> <![endif]>30 |
|
|
|
|
|
|
|
|
<![if ! IE]> <![endif]>less |
|
50 or |
|
<![if ! IE]> <![endif]>or more |
|
|
50 or |
<![if ! IE]> <![endif]>30 or |
more |
<![if ! IE]> <![endif]>100 |
<![if ! IE]> <![endif]>250 |
<![if ! IE]> <![endif]>less |
more |
||
|
|
|||||
|
|
|
<![if ! IE]> <![endif]>Above |
<![if ! IE]> <![endif]>400 or |
|
Unit:cm |
|
|
|
|
|
|
|
|
|
|
|
Floor |
|
|
2) Outdoor unit |
More |
|
Sunroof |
|
• If an awning is built over the unit to prevent |
|
|||
30cm |
|
|||
direct sunlight or rain exposure, be careful that |
|
|
||
|
|
|
||
heat radiation from the condenser is not |
|
|
More than |
|
restricted. |
|
|
||
Fence |
|
30cm |
||
• There should not be any animals or plants |
or |
|
||
which could be affected by hot air discharged. |
|
|||
|
|
|||
• Ensure the spaces indicated by arrows from |
obstacles |
More than 50cm |
||
the wall, ceiling, fence or other obstacles. |
||||
|
|
|||
|
|
More than 70cm |
||
|
|
|
10 Ceiling Cassette Air Conditioner