Lang Manufacturing R30S Parts List

Installation,

Operation, and

Maintenance Instructions

Models:

R30S

Electric Range

Star Manufacturing International 10 Sunnen Drive St. Louis, MO.63143-3800
Part Number: 2M-W1098 Ph: 314-781-2777 Fax: [phone]

Rev.-

WWW.STAR-MFG.COM March 27, 2007

Safety

THE GRIDDLE IS EXTREMELY HEAVY. FOR SAFE

HANDLING, INSTALLER SHOULD OBTAIN HELP AS
NEEDED, OR EMPLOY APPROPRIATE MATERIALS
HANDLING EQUIPMENT (SUCH AS A FORKLIFT,
DOLLY, OR PALLET JACK) TO REMOVE THE UNIT
FROM THE SKID AND MOVE IT TO THE PLACE OF
INSTALLATION.

CAUTION ANY STAND, COUNTER OR OTHER DEVICE ON

WHICH GRIDDLE WILL BE LOCATED MUST BE
DESIGNED TO SUPPORT THE WEIGHT OF THE
GRIDDLE.

SHIPPING STRAPS ARE UNDER TENSION AND CAN

SNAP BACK WHEN CUT.

DANGER: THIS APPLIANCE MUST BE GROUNDED AT THE

TERMINAL PROVIDED. FAILURE TO GROUND THE
APPLIANCE COULD RESULT IN ELECTROCUTION
AND DEATH.

WARNING INSTALLATION OF THE UNIT MUST BE DONE BY

PERSONNEL QUALIFIED TO WORK WITH
ELECTRICITY. IMPROPER INSTALLATION CAN
CAUSE INJURY TO PERSONNEL AND/OR DAMAGE
TO EQUIPMENT. UNIT MUST BE INSTALLED IN
ACCORDANCE WITH ALL APPLICABLE CODES.

NOTICE The data plate is on top of the control box. The

griddle voltage, wattage, serial number, wire size,
and clearance specifications are on the data plate.
This information should be carefully read and
understood before proceeding with the installation.

NOTICE The installation of any components such as a vent

hood, grease extractors, fire extinguisher systems,
must conform to their applicable National, State and
locally recognized installation standards.

NOTICE During the first few hours of operation, you may

notice a small amount of smoke coming off the unit,
and a faint odor from the smoke. This is normal for a
new griddle and will disappear after the first few
hours of use.

CAUTION ALWAYS KEEP THE AREA NEAR THE APPLIANCE

FREE FROM COMBUSTIBLE MATERIALS.

CAUTION KEEP FLOOR IN FRONT OF EQUIPMENT CLEAN

AND DRY. IF SPILLS OCCUR, CLEAN IMMEDIATELY,
TO AVOID THE DANGER OF SLIPS OR FALLS.

WARNING KEEP WATER AND SOLUTIONS OUT OF

CONTROLS. NEVER SPRAY OR HOSE
CONTROL CONSOLE, ELECTRICAL
CONNECTIONS, ETC.

CAUTION

MOST CLEANERS ARE HARMFUL TO THE SKIN, EYES,

MUCOUS MEMBRANES AND CLOTHING.
PRECAUTIONS SHOULD BE TAKEN TO WEAR RUBBER
GLOVES, GOGGLES OR FACE SHIELD AND
PROTECTIVE CLOTHING. CAREFULLY READ THE
WARNING AND FOLLOW THE DIRECTIONS ON THE
LABEL OF THE CLEANER TO BE USED.

NOTICE Service on this or any other Lang appliance must be

performed by qualified personnel only. Consult your
Lang Authorized Service Agent Directory. You can call
our toll free number 1-800-807-9054 or visit our website

WWW.STAR-MFG.COM for the service agent nearest you.

WARNING BOTH HIGH AND LOW VOLTAGES ARE PRESENT

INSIDE THIS APPLIANCE WHEN THE UNIT IS
PLUGGED/WIRED INTO A LIVE RECEPTACLE. BEFORE
REPLACING ANY PARTS, DISCONNECT THE UNIT
FROM THE ELECTRIC POWER SUPPLY.

CAUTION USE OF ANY REPLACEMENT PARTS OTHER THAN

THOSE SUPPLIED BY LANG OR THEIR AUTHORIZED
DISTRIBUTORS CAN CAUSE BODILY INJURY TO THE
OPERATOR AND DAMAGE TO THE EQUIPMENT AND
WILL VOID ALL WARRANTIES.

OPERATING INSTRUCTIONS

RANGE TOPS

Electric range tops consist of various top arrangements, depending upon the specific
models purchased.

Options include 1.) 12" x24" hot plates

2.) Round speed units

3.) Griddles

Three position switches, thermostats, or infinite controls independently control these
units.

All thermostats are used in conjunction with a red indicator or pilot lamp. When the light
is on the elements are energized and bringing the plate to the temperature set on the
thermostat. When the light is off the plate has reached the temperature set on the
thermostat. Griddle pilot lights should be allowed to cycle at least twice before usage.

Recommended Usage:

1.) 12" x 24" hot plates. - Heavy stockpots and kettles.

2.) Round speed units - Light duty saucepans and small stockpots. (NOT
recommended for large stockpots.)

3.) Griddles - Used for grilling product directly on surface.

CAUTION

All hot plates and speed units should be turned to the low or off position when not in use.
Allowing these elements to stay in the full on or high position with nothing on top to
absorb and dissipate the heat is detrimental to element life. Lang warranty provisions do
not cover abuse of this nature.