Kenwood K5020 Service Manual

DVD VCD CD PLAYER

70%

STANDBY

VIRTUAL

SURROUND

OPEN/CLOSE

DIGITAL OUTPUT (PCM/BIT STREAM) OPTICAL COAXIAL

AUDIO OUTPUT VIDEO OUTPUT

VIDEO OUTPUT

SELECTION

COMPONENT

VIDEO OUTPUT

Cr

Cb Y

S-VIDEO

AC IN~

L

R

DV-303/DVF-5020/K5020

SERVICE MANUAL

REVISED

Please use this manual instead of DV-303's manual (B51-5561-00), when repair of DV-303.

Front panel (A60-1788-08)

Leg (J02-1468-08)

Power button (K27-2389-08)

Tray top (A29-1088-08)

Front cover (B10-3573-08)

Top cover (A01-3749-08)

Oscillating module (W02-2736-08)

In compliance with Federal Regulations, following are reproductions of labels on, or inside the product relating to laser product safety.

KENWOOD-Crop. certifies this equipment conforms to DHHS Regulations No. 21 DFR 1040. 10, Chapter 1, Subchapter J.

DANGER : Laser radiation when open and interlock defeated. AVOID DIRECT EXPOSURE TO BEAM

RCA jack (E63-1134-08)

Pin jack (E63-1135-08)

Switch (S90-0134-08)

Y/C connector (E40-8534-08)

Pin jack (E63-1133-08)

Connector (E40-8535-08)

Figure is DV-303.

Caution : No connection of ground line if disassemble

NOTE : Please use the remote controller

the unit. Please connect the ground line on rear panel, PCBs, Chassis and some others.

for self-diagnosis and tilt adjustment.

DV-303/DVF-5020/K5020

(A70-1353-08): K,K1,Y (A70-1369-08): M

(E30-2937-08): K,K1 (E30-2946-08): Y,M

(E30-2938-08) (E30-2365-05)

Remote control unit . . . . . . . . . 1

for remote control unit [size "AA"]

Batteries. . . . . . . . . . . . . . . . . . . . 2 AC cord. . . . . . . . . . . . . . . . . . . .. . 1

Video/audio cable. . . . . . . . . . . . 1 Digital cord. . . . . . . . . . . . . . . . . . . 1

(E03-0115-05): M

Ac plug adapter. . . . . . . . . . . . . . . 1

Use to adapt the plug

on the power cord to the shape of the wall outlet.

(Accessory only for regions where use is necesary.)

CONTENTS / ACCESSORIES

Accessories

How to read the schematic diagram

Connection of "from" or "to".

• There are some destinations in this schematic.

Port name

• Figures which is more than 20,000 is omitted first digit in Mic jack and Mic volume circuit. (Example) R4001

2

î R24001

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

1. Assembling and Disassembling the Casing and Checking C.B.A.s (DV-303)

1-1 Casing Parts and C.B.A. Positions

1-2 Service Positions

Note To inspect the loading base unit, position the left side

upward (as viewed from the front).

1-4 Disassembling the Front Panel

1. Release the 3 tabs on the bottom.

2. Release the 2 tabs on the left and right.

3. Release the 2 tabs.

4. Disconnect the 2 flexible cables.

Extension cable (B)x2

Extension cable (A)

1-3 Disassembling the Tray

1. Turn the lever clockwise.

2. Move the tray in the direction of the arrow until it locks.

3. Release the tab locks on the left and right, then pull out the tray.

1-5 Disassembling the Loading Base Unit

1. Remove the 4 screws.

2. Pull out the loading base unit vertically.

Note

There is a danger of damaging the connectors.

3

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

1-6 Checking the Module C.B.A.

1. Remove the 2 screws.

2. Connect the module C.B.A. to the mother C.B.A. with the extension cables for inspection.

• Extension cable (B)x2 Mother C.B.A. Module C.B.A.

PP24201-PS4201 PP23201-PS3201

2. Release the two tabs on the left and right.

1-8 Checking the Power Supply C.B.A.

1. Remove the 3 screws.

Note

Be sure to initialize the player whenever you replace a C.B.A. (Refer to page21/4-1 Initializing the DVD Player.)

1-7 Disassembling the Rear Panel,

1. Remove all of the screws connected to the rear panel. (The number of screws varies according to the model).

2. Carefully pull out the power supply C.B.A.

Note

There is a danger of damaging the connectors.

3. Connect the power supply C.B.A. and the mother C.B.A. with the extension cable for inspection.

• Extension cable(A) (connects the power supply C.B.A. PS1101 and the mother C.B.A. PP21101)

Extension cable(A)

4

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

1-9 Checking the Mother C.B.A.

1. Remove the 5 screws.

2. Release the 2 tabs.

3. Checked by connecting the module C.B.A. and the mother C.B.A. with the extension cables.

Extension cable (B)x2 Module C.B.A. Mother C.B.A. PS3201-PP23201 PS4201-PP24201

2. To preserve the quality of the optical pickup replacement parts during transport and installation, the terminals of the laser diode are short-circuited. After replacing the parts, use the proper procedure to return the laser diode to its original condition. (Refer to page9/2-12 Assembling the Optical Pickup.)

3. Testers cannot be used to check the laser diode of the optical pickup. The power supply inside the tester can easily damage the laser diode.

4. Take care when handling the flexible cable because excessive force can cause it to break.

5. You cannot adjust the semifixed resistor for laser power adjustment. Do not turn it.

2-2 Disassembly Procedure

Use the following procedure to replace major parts. For the assembly procedure, follow the flow chart in reverse.

Extension cable(B)

Extension

cable(B)

Note

Be sure to initialize the player whenever you replace a C.B.A. (Refer to page21/4-1, Initializing the DVD player.)

2. Assembling and Disassembling the Optical Pickup (Mechanical Parts)

The optical pickup can be damaged by static electricity from your body. Be sure to take static electricity countermeasures when working around the optical pickup.

2-1 Handling the Optical Pickup

The optical pickup can be damaged by static electricity from your body. Be sure to take static electricity countermeasures when working around the optical pickup.

1. The optical pickup is an extremely high-precision mechanism. Do not subject it to strong impact.

5

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

2-3Lubricating the Loading Base Unit

When replacing parts, lubricate the parts maked “xxx” in the diagram

Grease 410-0013-05 Grease EM-30LG

6

Part number Service Tool

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

2-4 Static Electricity Countermeasures

The laser diode inside the traverse unit (optical pickup) can be damaged by static electricity from your body. Be sure to take static electricity countermeasures when working around the optical pickup.

2-4-1 Static Electricity Countermeasure Methods

1. Ground yourself Use an anti-static wrist strap to discharge static electrici-

ty from your body.

2. Ground the workbench Lay a conductive material (sheet) or steel sheet on the

surface where the traverse unit (optical pickup) is to be placed, then ground the sheet.

2-5 Disassembling the Clamp Base Unit

Remove the 2 screws.

2-6 Disassembling the Clamper Weight, Clamper

Yoke, Magnet and Clamper

1. Release the tab, and pull out the clamper.

2-4-2 Short-circuit the laser diode

Solder the land in the flexible cable of the optical pickup.

Notes

• Be sure to do this befer disconnecting the flexible cable of the optical pickup from the module C.B.A.

• Use an anti-static soldering iron to short-circuit and unshort-circuit laser diode.

(Recommended soldering iron: Hakko with ESD countermeasure)

• After you have finished repairing the laser diode, follow the correct procedure to remove the solder from the short-circuit location. (Refer to page5/2. Assembling and Disassembling the Optical Pickup (Mechanical Parts).)

2. Release the 3 tabs on the clamper.

7

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

2-7 Disassembling the Traverse Unit

1. Remove the 3 screws.

Note

Be sure to take static electricitiy countermeasures befer disconnecting the flexible cable.(Refer to page7/2-4 Static Electricity Countermeasures.)

2. Disconnect the 2 flexible cables.

2-8 Disassembling the Stepping Motor Unit

1. Disconnect the flexible cable.

2. Remove the 2 screws.

Note

Take care when handling the flexible cable because it can be broken by excessive force.

2-9 Disassembling the Optical Pickup Unit

1. Remove the hook of the FPC holder, then remove the FPC holder itself.

2. Remove the screw.

3. Release the tab, then remove spring holder 1.

Note

Be sure not to lose the spring.

4. Remove the guide shaft.

Note

Be sure to adjust the optical pickup tilt after replacing the optical pickup.

(Refer to page10/2-14 Opitcal Pickup Tilt Adjustment.)

8

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

2-10 Disassembling the Nut Unit

1. Remove the screw.

Notes

• The nut unit is not part of the optical pickup. Before replacing the optical pickup, remove the nut unit

for use with the new optical pickup.

• After installation, use screw lock to lock the screw in position.

• When reassembling, use screw lock to lock the screw in position after attaching it.

2-12 Assembling the Optical Pickup

1. Install the optical pickup.

Note

Take care not ot attach the tilt spring and guide shaft in the wrong order.

2-11 Disassembling the Sub-Shaft Preload Spring

1. Remove the screw.

Notes

• Handle the sub-shaft preload spring carefully because the shape of the tip is easily deformed.

• The sub-shaft preload spring is not part of the optical pickup. Before replacing the optical pickup, remove the sub-sahft preload spring for use with the new optical pickup.

• After installation, use screw lock to lock the screw in position.

2. Fit the protruding part of the pickup FPC into the convexpart of the FPC holder to install it.

9

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

3. Insert the pickup FPC into connector FP5201 on the module C.B.A.

4. Remove the solder from the pickup FPC's soldered shortcircuit.

2-14 Optical Pickup Tilt Adjustment

5. Adjust the optical pickup tilt after removing the solder. (Refer to page10/2-14 Optical Pickup Tilt Adjustment.)

2-13 Disassembling the Spindle Motor Unit

1. Remove the three screws.

Note

Be sure to adjust the optical pickup tilt after replacing the spindle motor unit.

10

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

Notes

• Adjustment is generally unnecessary after replacing other parts of the traverse unit. However, adjust if there is a noticeable degradation in picture quality.

• Optical adjustments cannot be made inside the optical pickup.

• Adjustment is generally unnecessary after replacing the traverse unit.

11

DV-303/DVF-5020/K5020

DISASSEMBLY FOR REPAIR

2-15 Disassembling the Intermediate Chassis

1. Push the stopper downward, then rotate it until it contacts the Vertical cam.

2. Release the 2 tabs.

2-17 Disassembling the Pulley Gear and Decelera-

tion Gear

1. Remove the screw.

2. Remove the pulley gear.

3. Remove the belt.

4. Remove the deceleration gear.

2-16 Disassembling the Vertical cam and Drive

gear

1. Rotate the Vertical cam until it reaches the contact position.

2. Lift the Vertical cam straight upward to pull it out.

3. Remove the Drive gear.

2-18 Disassembling the Mechanism Loading

C.B.A.

1. Remove the 2 screws.

2. Remove the 2 screws.

3. Release the three tabs.

12

27MHz

RGB VIDEO/COMPONENT VIDEO OUT MODEL ONLY

ONLY

MODEL

5.1ch

AUDIO

AUDIO DIGITAL OUT

IC3201

MOTHER C.B.A.

PAL MODEL ONLY

IC3061

IC3051

IC6001

IC2511

IC2501

MECHANISM UNIT

MODULE C.B.A.

CR(R)

CB(B)

Y(G)

S-VIDEO OUT

VIDEO OUT

IC3531

IC4221

IC4211

IC4201

CNT

SW

SL

SR

FR

FL

CONVERTER

D/A

VIDEO

DRIVER

VIDEO

CONVERTER

D/A

AUDIO

CONVERTER

D/A

AUDIO

CONVERTER

D/A

AUDIO

IC3001IC7001IC2001IC5202

(AV DEC)

DECODER

AV

SRAM

4BIT

(ODC)

CONTROLLER

DISC

OPTICAL

SRAM

16BIT

COIL

TRACKING

COIL

FOCUS

MOTOR

STEPPING

CPU

SUB

KEY

REMOCON

LED

OSD

FL

(DSC)

CONTROLLER

SERVO

DIGITAL

IC6302

IC6201

CPU

MAIN

DRAM

4M

16.9MHz

DRIVE

MOTOR

4ch

MOTOR

LOADING

DRIVE

MOTOR

SPINDLE

MOTOR

SPINDLE

(FEP)

PROCESSOR

END

FRONT

UNIT

PICK UP

OPTICAL

OVERALL BLOCK DIAGRAM

DV-303/DVF-5020/K5020

13

14

(0.5sec./DIV.)

CLOSE 2.5Vp-p

IC2501-25(UP),IC2501-27(DOWN)

5.0Vp-p(20usec./div.)

IC2501-24

7.2Vp-p(20usec./div.)

IC2511-11,12,13,14

(0.5sec./DIV.)

OPEN 2.5Vp-p

IC2501-25(UP),IC2501-27(DOWN)

RF SIGNAL

SPINDLE MOTOR DRIVE SIGNAL STEPPING MOTOR DRIVE SIGNAL

TRACKING ERROR SIGNAL

FOCUS ERROR SIGNAL

BRK

FIN

RIN

SS

FGC

FG

EC

ECR

OPIN2-

OPIN1-

OPIN3-

OPIN4-

TRAY CLOSE

TRAY OPEN

BRK

TRAY SET2

TRAY SET1

SS

FGC

FG

EC

ECR

TRV-SW

FOCUS DRIVE

TRAKING DRIVE

TRSDRV-B

TRSDRV-A

X TRON

OFTR

BDO

JIT OUT

LDONA

LDONB

FBAL

FE

TBAL

TE

RDCKP

RDCKN

RDTP

RDTN

VIN4

VIN3

VIN2

VIN1

VIN5

VIN6

STNBY

STD1

SCK

SEN

DAT3

DAT2

DAT1

DAT0

SBI1

SBO1

SBT1

CPUIRQ

CPCEN

CPSEN

OUT2

OUT1

A3

A2

A1

H1+

H1-

H2+

H2-

H3+

H3-

VO2-

VO2+

VO1-

VO1+

VO4+

VO4-

VO3+

VO3-

Q

C

D

OPTICAL PICK UP UNIT

PHOTO DETECTOR

B3B4

B2B1

A3A2A4

A1

LASER DIODE

AMP

HEAD

Q5201

LD DRIVE

4

3

IC6303

(EEPROM)

AMP

115

114

113

112

71

76

50

60

52

72

70

55

2

6

5

IC6201

(CPU)

IC7001

(ODC)

INTERFACE

BALANCE

FOCUS

BALANCE

TRACKING

22

21

20

19

97

96

95

94

92

91

2

3

2

1

9

23

66

65

64

12

13

28

50

49

48

47

(FEP)

IC5202

61

63

62

60

38

37

36

35

34

33

128

107

44

81

98

93

20

91

43

42

41

40

1

7

8

13

12

16

14

111

120

121

11

103

102

105

104

23

26

9

2

3

4

5

6

7

16

11

10

15

12

19

18

25

27

23

26

28

11

12

13

14

15

16

17

18

6

3

(DSC)

IC2001

QR2502

5

4

1

3

AMP

QR2503

QR2501

AMP

5

4

1

3

AMP

(MOTOR DRIVE)

(SPINDLE MOTOR DRIVE)

IC2501

IC2511

M2601

LOAD M-

LOAD M+

MOTOR

LOADING

S2601

TRAY OPEN

TRAY CLOSE

M3

M2

M1

H1-

HALL1

H1+

H2-

H2+

HALL2

H3+

H3-

TRV-SW

HALL3

TRAVERSE SWITCH

ACT T-

ACT T+

ACT F-

ACT F+

STEPPING MOTOR UNIT

STEPPING MOTOR

LOADING MOTOR UNIT

SPINDLE MOTOR UNIT

OPTICAL PICK UP UNIT

ACTUATOR

COIL

TRACKING

COIL

FOCUS

DV-303/DVF-5020/K5020

SERVO BLOCK DIAGRAM

EXCEPT A112U,A115U

A115U

A112U,

EXCEPT

VGOUT

196

Q3221

Q3231

AMP

SERIES MODEL ONLY

EXCEPT A770,A360

EXCEPT A770,A360 SERIES

1.2Vp-p(20usec/div)

IC3001-201

1.5Vp-p(20usec/div)

IC3001-206

1.2Vp-p(20usec./div.)

IC3201-23

2.2Vp-p(20usec./div.)

IC3531-19

2.2Vp-p(20usec./div.)

IC3531-16

1.5Vp-p(20usec./div.)

IC3201-25

1.2Vp-p(20usec./div.)

IC3531-14

0.64Vp-p(20usec./div.)

IC3201-32

0.68Vp-p(20usec./div.)

IC3201-29

6.0Vp-p(20usec./div.)

IC3001-161 to 168

MODULE C.B.A. MOTHER C.B.A.

(AV DECORDER)

IC3001

A770,A360,SERIES MODEL ONLY

XRST

122

IC6201-79PIN

FROM

NRST

XRESET

45

VCOUT

VYOUT

C

Y

201

206

Q3211

AMP

Q3201

FL3501

B.P.F.

L.P.F.

FL3511

Q3501

AMP

Q3511

Q3502

AMP

Q3512

VR3511

VR3501

C ADJ.

Y ADJ.

A770,A360 SERIES MODEL ONLY

Q3601

AMP

Q3602

AMP

QR3601

NR

IC6201-80PIN

FROM

AMP

Q3513

AMP

Q3603

VIDEO OUT

(VIDEO DRIVER)

IC3531

14

16

19

COUT

VOUT

C

YOUT

3Y

11

VD7

VD0

168

167

166

165

164

163

162

161

(VIDEO D/A CONVERTER)

IC3201

IC6201-10PIN

FROM

SDATA

IC6201-9PIN

FROM

SCLOCK

P7

P0

SDATA

SCLOCK

20

19

9

8

7

6

5

4

3

2

CB/B ADJ

VR3201

CR/R

CB/B

Y/G

C

Y

DAC-C

DAC-B

DAC-A

DAC-F

DAC-E

38

29

32

35

23

25

ONLY

EUROPE MODEL

AMP

Q3221

AMP

Q3231

AMP

Q3241

FL3561

FL3551

B.P.F.

AMP

Q3571

AMP

Q3561

Q3551

AMP

(VIDEO AMP)

IC3581

10

13

15

7

4

2

OUTC

OUTB

OUTA

INC

INB

INA

MODEL

EXCEPT EUROPE

CR/R

CB/B

Y/G

JAPAN MODEL ONLY

QR3521 QR3522

WIDE1

IC6201-53PIN

FROM

IC6201-5PIN

FROM

WIDE2

S-VIDEO OUT

VIDEO BLOCK DIAGRAM

DV-303/DVF-5020/K5020

15

AMP

AMP AMP

AMPAMP

AMP

AMPAMP

AMP

AMP AMP

AMPAMP

AMP

AMPAMPAMPAMP

AMP

A115 SERIES

EXCEPT A112

A270,K520 SERIES ONLY

A112,A115,A120

IC4461

0.7Vp-p(0.5msec./div.)

0.6Vp-p(0.5msec./div.)

IC4201-13,15

6.4Vp-p(10usec./div.)

IC3001-185

A560 ONLY

T4761

A770,A560,A360,A270,A120 SERIES ONLY

K570 ONLY

3

IC4781

OPTICAL

DIGITAL AUDIO OUT

COAXIAL

DIGITAL AUDIO OUT

JK4771

6

4

3

1

IC4751

5

3

IC4751

2

6

K4751

IC4751

7

1

IC4241

4

2

IEC OUT

174

SW OUT

CNT OUT

SR OUT

SL OUT

Rch OUT

Lch OUT

FR OUT

FL OUT

2

1

IC44717IC4471

6

S4501

FROM

ATTENUATOR

IC6201-3PIN

FROM

A MUT

Q4431

IC4421

21

22

IC4392

IC4251-12PIN

FROM

K4384

SW SEL

9

15

2

1

IC4382

Q4421

IC4421

4

3

IC4392

IC4251-10PIN

FROM

10

CNT SEL

K4383

4

3

5

IC4382

S4501

FROM

ATTENUATOR

A MUT

IC6201-3PIN

FROM

S4501

FROM

ATTENUATOR

A MUT

IC6201-3PIN

FROM

2

1

Q4411

IC4401

21

22

IC4391

IC4251-12PIN

FROM

SUR SEL

K4381

9

15

2

1

IC4381

A360 SERIES

Except A770,A560,

K4442

K4441

S4501

FROM

ATTENUATOR

IC6201-3PIN

FROM

A MUT

6

7

IC4401

Q4401

4

3

IC4391

6

IC4451

7

2

IC4451

1

+

IC4441

2

1

+

7

IC4441

6

IC4251-12PIN

FROM

SUR SEL

10

K4382

4

3

5

IC4381

+

SERIES ONLY

A770,A560,A360

A360 SERIES

Except A770,A560,

A360 SERIES

Except A770,A560,

1

IC4451

2

6

IC4451

7

1

IC4306

2

7

IC4321

6

IC4361

7

1

IC4361

2

1

IC4605

2

EXTL

10

IC4601

17

DSP

KARAOKE

IC4341

FS MUT

SLVIR

IC4251-8PIN

FROM

K570 ONLY

IC4251-8PIN

FROM

FS MUT

SRVIR

IC4341

DSP

KARAOKE

21

IC4601

14

EXTR

6

IC4605

7

2

IC4341

1

7

IC4341

6

KARAOKE MODEL ONLY

1

IC4321

2

7

IC4691

6

+

IC6001-50PIN

FROM

MIC MUT

+

KARAOKE MODEL ONLY

ECHO MUT

IC6001-49PIN

FROM

7

IC4306

6

VR4952

1

9

2

IC4952

2

IC6001-51PIN

TO

VOICE DET

IC4951

AMP

ECHO

DET

LEVEL

MIC

7

6

IC4952

1

2

IC4691

+

VR4692

7

5

IC4671

MIC2

VR4691

1

3

IC4671

MIC1

NRST

IC6201-79PIN

FROM

SBO1

IC6201-72PIN

FROM

SBT1

IC6201-70PIN

FROM

SW

STBDAC

CNT

13

16

IC6201-59PIN

FROM

(AUDIO D/A CONVERTER)

IC4221

28272622

IC4251-9PIN

FROM

DACMUT

1

3

2

IC4251-7PIN

FROM

10

DSPTHURU

IC4602

3

1

3

4

2

IC4612

42

IC4601

45

AOUT2

183

A770,A560,A360 SERIES ONLY

NRST

IC6201-79PIN

FROM

SBO1

IC6201-72PIN

FROM

SBT1

IC6201-70PIN

FROM

SR

STBDAC

SL

13

16

IC6201-59PIN

FROM

(AUDIO D/A CONVERTER)

IC4211

28272622

IC4251-9PIN

FROM

DACMUT

1

3

2

IC6001-75PIN

FROM

GAIN SEL

DACMUT

IC4251-9PIN

FROM

NRST

IC6201-79PIN

FROM

SBO1

IC6201-72PIN

FROM

SBT1

IC6201-70PIN

FROM

IC6201-59PIN

FROM

STBDAC

FR

FL

13

16

(AUDIO D/A CONVERTER)

IC4201

28272622

1

3

2

IC4251-7PIN

FROM

9

DSPTHURU

IC4602

4

5

6

3

IC4612

41

IC4601

44

IC4251-7PIN

FROM

DSPTHURU

11

IC4602

14

13

124043

IC4601IC4612

8

9

A360 SERIES

Except A770,A560,

K4203

K4201

K4202

AOUT1

184

179

LRCK

SRCK

181

IC3001

AOUT0

185

16

DV-303/DVF-5020/K5020

AUDIO BLOCK DIAGRAM

DV-303/DVF-5020/K5020

CIRCUIT DESCRIPTION

1. Optical Pickup Self-Diagnosis and Replacement Procedure

The optical pickup self-diagnosis function and tilt adjustment check function have been newly added to this player. When repairing, use the following procedure for effective Self-diagnosis and tilt adjustment.

Be sure to use the self-diagnosis function before replacing the optical pickup when "NO DISC" is displayed. As a guideline, you should replace the optical pickup when the value of the laser drive current is more than 50.

Note

Press the power button to turn on the power, and check the value before the unit warms up (within three minutes).

17

DV-303/DVF-5020/K5020

CIRCUIT DESCRIPTION

2. Self-Diagnosis Function and Service Modes

2-1 Service Mode Table

The service modes can be activated by pressing various button combinations on the player and remote control unit.

Player Remote control

buttons unit buttons

0 Displaying the UHF display F_ _ _ Refer to spage18/2-2 Self-

5 Tilt adjustment Refer to

PAUSE 6 Checking the region numbers and broadcast system

+ 7 Checking the program version Check the IC6302

OPEN/CLOSE FLASH ROM program.

9 Lighting Confirmation Fanction of Display Tube

ON SCREEN Checking the laser drive current Refer to page17/1.

PAUSE Writing the laser drive current value after replacing

the optical pickup (do not use for anything other than optical pickup replacement)

PAUSE Initializing the DVD player Refer to page20/4-1

4 (restoring factory preset settings) Initializing the DVD Player

OPEN/CLOSE *Use when replaceing a microprocessor, microprocessor

peripheral parts, or C.B.A.

Application Note

Diagnosis Function (UHF Display).

Optical Pickup Tilt Adjustment.

Optical Pickup Self-Diagnosis and Replacement Procedure.

2-2 Self-Diagnosis Function (UHF Display)

This unit incorporates a convenient self-diagnosis function for use in troubleshooting.

Display method Display Diagnosis Checkpoints

Service numbers U11 Focus error IC2001,IC2511,IC5201,pickup displayed H01 Tray loading error IC2001, IC2511, loading motor during use H02 Spindle servo error Spindle motor, IC2501, IC2001

H03 Traverse error Stepping motor, IC2511, IC2001 H04 Tracking servo error IC2001, IC2501, IC5201, pickup, disc H05 Seek error Stepping motor, IC2511, IC2001 H06 Power supply error IC1021, IC1121, IC1151, IC6001

Press the "0" button on the remote control unit while pressing the "PAUSE" and "OPEN/CLOSE"

button on the player.

F0** Disc format error F1** Disc code error F2** Decoder LSI error F3** SDRAM error F4** IIC BUS error F5** DSC F6** ECC error F7** Microprocessor error F8** Microprocessor error

If this type of error occurs, refer to page19/2-4 Examples of Repairs Using Error Codes.

2-3 Self-Diagnosis Display Function

18

DV-303/DVF-5020/K5020

CIRCUIT DESCRIPTION

2-4 Examples of Repairs Using Error Codes

Refer to this section when carrying out repairs.

Error display Malfunction example

F0** Disc, IC7001 F103 Disc, IC7001 F4FF IC6001 F500 Optical pickup, IC2001, IC5201, IC2511, IC2501 F501 IC2001, IC6201 F502 IC2501, IC2511, IC2001, IC5202 F504 IC5202, IC2001 F505 Disc, IC2501, IC2511, IC5202, IC2001 F506 Disc, Optical pickup, IC2001 F600 Disc, IC7001, IC5202, IC2001 F601 Disc, IC7001 F602 Disc, IC5202, IC2001 F603 Disc, IC5202, IC2001 F610 IC7001 F611 IC7001, IC5202, IC2001 F612 IC7001, IC15202, IC2001 F620 Laser drive circuit F621 Laser drive circuit F700 IC6201 F701 IC6201 F702 IC6201 F880 IC6201 F890 IC6201 F891 IC6201 F8A0 IC6201 F893 IC6302 F894 IC6303

2-5 Sales Demonstration Lock Function

This function prevents discs from being lost when the unit is used for sales demonstrations, by disabling the disc eject function. "LOCKED" is displayed on the unit, and ordinary operation is disabled.

2-5-1 Setting Method

The sales demonstration lock function is set by simultaneously pressing the "POWER" button of DVD Player on the remote control unit and the "STOP" button on the main unit. ("LOCKED" is displayed when the lock function is engaged.)

2-5-2 Release Method

The function can be released using the same procedure as for setting. If the remote control unit is not at hand, the function can be released by using the same method as for player initialization (pressing the "PAUSE," "4" and "OPEN/CLOSE" buttons simultaneously).

19

DV-303/DVF-5020/K5020

CIRCUIT DESCRIPTION

3. Service Tools and Equipment

3-1 Service Tools and Equipment Table

Application Name Number

General DVD disc (Include the color bar 75%) Tilt adjustment Hex wrench (ø1.27mm) Inspection Extension cables (power supply C.B.A. to mother C.B.A.) Extension cable(A)

Extension cable (module C.B.A. to mother C.B.A.) Extension cable(B)

Others Screw lock

Grease 410-0013-05

Confirmation CD disc

VCD disc

Electrical adjustment Oscilloscope

Probe AV cable

TV monitor General General tools (Screw driver. etc) Static electricity countermeasures Soldering iron (with ESD countermeasure)

Anti-static wrist strap

Conductive material (conductive sheet)

DVD disc (Include 75% color bar)

3-2 Storing and Handling DVD Discs

Surface precision is vital for DVD discs. Be sure to store and handle them carefully.

1. Do not place discs directly onto the workbench, etc., after use.

2. Handle discs carefully in order to maintain their flatness. Place them into their case after use and store them vertically. Store discs in a cool place where they are not exposed to direct sunlight or air from air conditioners.

3. Accurate adjustment will not be possible if the disc is warped from being placed on a surface made of glass, etc. If this happens, use a new test disc to make optical adjustments.

4. If adjustment is done using a warped disc, the adjustment will be incorrect and some discs will not be playable.

4. Service Precautions

4-1 Initializing the DVD Player

Initialize the DVD player whenever you replace a microprocessor, microprocessor peripheral parts, module C.B.A or mother C.B.A.

4-1-1Precautions

The customer settings will return to factory preset settings when the player is initialized. Make a note of the settings and reset them after initializing. When resetting, see the Initial Settings in the Operating Instructions.

4-1-2 Initialization Method

The player will be initialized (return to the factory preset condition) when you press the "PAUSE", "4" and "OPEN/CLOSE" buttons simultaneously. When the DVD player is initialized, "All Clear" appears on screen, it also displays "INITIALIZE".

20

DV-303/DVF-5020/K5020

ADJUSTMENT

1. Video Output (Luminance Signal) Adjustment

Do this adjustment after replacing a C.B.A.

Measurement point Adjustment point Mode Disc

Video output terminal VR3501 (mother C.B.A.) Color bar 75% DVD disc (Color bar 75%)

Measuring equipment, tools Adjustment value

Screwdriver, Oscilloscope 1000mVp-p±20mV

200mV/div, 10µsec/div

Purpose: To maintain video signal output compatibility.

1. Connect the oscilloscope to the video output terminal and terminate at 75 ohms.

2. Adjust VR3501 so that the luminance signal (Y+S) level becomes 1000 mVp-p±20 mV.

2. Video Output (Chrominance Signal) Adjustment

Do this adjustment after replacing a C.B.A.

Measurement point Adjustment point Mode Disc

Video output terminal VR3511 (mother C.B.A.) Color bar 75% DVD disc (Color bar 75%)

Measuring equipment, tools Adjustment value

Screwdriver, Oscilloscope 675mVp-p±13mV

200mV/div, 10µsec/div

Purpose: To maintain video signal output compatibility.

1. Connect the oscilloscope to the video output terminal and terminate at 75 ohms.

2. Adjust VR3511 so that the chrominance signal (C) level becomes 675 mVp-p±13 mV.

21

DV-303/DVF-5020/K5020

ADJUSTMENT/ABBREVIATION

3. Video Component Signal (CB) Output Adjustment

Do this adjustment after replacing a C.B.A.

Measurement point Adjustment point Mode Disc

Video output terminal VR3041 (mother C.B.A.) Color bar 75% DVD disc (Color bar 75%)

Measuring equipment, tools Adjustment value

Screwdriver, Oscilloscope 525mVp-p±11mV

100mV/div, 10µsec/div

Purpose: To maintain video signal output compatibility.

1. Connect the oscilloscope to the video component output terminal and terminate at 75 ohms.

2. Apply the trigger at the Y output terminal signal.

3. Adjust VR3041 so that the video component signal (CB) level becomes 525 mVp-p ±11 mV.

4. Abbreviations

INITIAL/LOGO ABBREVIATIONS

A A0~UP ADDRESS

ACLK AUDIO CLOCK AD0~UP ADDRESS BUS ADATA AUDIO PES PACKET DATA ALE ADDRESS LATCH ENABLE AMUTE AUDIO MUTE AREQ AUDIO PES PACKET REQUEST ARF AUDIO RF ASI SERVO AMP INVERTED INPUT ASO SERVO AMP OUTPUT ASYNC AUDIO WORD DISTINCTION SYNC

B BCK BIT CLOCK (PCM)

BCKIN BIT CLOCK INPUT BDO BLACK DROP OUT BLKCK SUB CODE BLOCK CLOCK BOTTOM CAP. FOR BOTTOM HOLD BYP BYPATH BYTCK BYTE CLOCK

C CAV CONSTANT ANGULAR VELOCITY

CBDO CAP. BLACK DROP OUT CD COMPACT DISC CDSCK CD SERIAL DATA CLOCK CDSRDATA CD SERIAL DATA CDRF CD RF (EFM) SIGNAL CDV COMPACT DISC-VIDEO CHNDATA CHANNEL DATA CKSL SYSTEM CLOCK SELECT CLV CONSTANT LINEAR VELOCITY COFTR CAP. OFF TRACK

22

CPA CPU ADDRESS

INITIAL/LOGO ABBREVIATIONS

C CPCS CPU CHIP SELECT

CPDT CPU DATA CPUADR CPU ADDRESS LATCH CPUADT CPU ADDRESS DATA BUS CPUIRQ CPU INTERRUPT REQUEST CPRD CPU READ ENABLE CPWR CPU WRITE ENABLE CS CHIP SELECT CSYNCIN COMPOSITE SYNC IN CSYNCOUT COMPOSITE SYNC OUT

D DACCK D/A CONVERTER CLOCK

DEEMP DEEMPHASIS BIT ON/OFF DEMPH DEEMPHASIS SWITCHING DIG0~UP FL DIGIT OUTPUT DIN DATA INPUT DMSRCK DM SERIAL DATA READ CLOCK DMUTE DIGITAL MUTE CONTROL DO DROP OUT DOUT0~UP DATA OUTPUT DRF DATA SLICE RF (BIAS) DRPOUT DROP OUT SIGNAL DREQ DATA REQUEST DRESP DATA RESPONSE DSC DIGITAL SERVO CONTROLLER DSLF DATA SLICE LOOP FILTER DVD DIGITAL VIDEO DISC

E EC ERROR TORQUE CONTROL

ECR ERROR TORQUE CONTROL

REFERENCE

ENCSEL ENCODER SELECT

DV-303/DVF-5020/K5020

ABBREVIATION

INITIAL/LOGO ABBREVIATIONS

E ETMCLK EXTERNAL M CLOCK

(81MHz/40.5MHz)

ETSCLK EXTERNAL S CLOCK

(54MHz)

F FBAL FOCUS BALANCE

FCLK FRAME CLOCK FE FOCUS ERROR FFI FOCUS ERROR AMP INVERTED

INPUT FEO FOCUS ERROR AMP OUTPUT FG FREQUENCY GENERATOR FSC FREQUENCY SUB CARRIER FSCK FS (384 OVER SAMPLING) CLOCK

G GND COMMON GROUNDING (EARTH) H HA0~UP HOST ADDRESS

HD0~UP HOST DATA HINT HOST INTERRUPT HRXW HOST READ/WRITE

I IECOUT IEC958 FORMAT DATA OUTPUT

IPFRAG INTERPOLATION FLAG IREF I (CURRENT) REFERENCE ISEL INTERFACE MODE SELECT

L LDON LASER DIODE CONTROL

LPC LASER POWER CONTROL LRCK L CH/R CH DISTINCTION CLOCK

M MA0~UP MEMORY ADDRESS

MCK MEMORY CLOCK MCKI MEMORY CLOCK INPUT MCLK MEMORY SERIAL COMMAND CLOCK MDATA MEMORY SERIAL COMMAND DATA MDQ0~UP MEMORY DATA INPUT/OUTPUT MDQM MEMORY DATA I/O MASK MLD MEMORY SERIAL COMMAND LOAD MPEG MOVING PICTURE EXPERTS GROUP

O ODC OPTICAL DISC CONTROLLER

OFTR OFF TRACKING OSCI OSCILLATOR INPUT OSCO OSCILLATOR OUTPUT OSD ON SCREEN DISPLAY

P P1~UP PORT

PCD CD TRACKING PHASE DIFFERENCE PCK PLL CLOCK PDVD DVD TRACKING PHASE

DIFFERENCE PEAK CAP. FOR PEAK HOLD PLLCLK CHANNEL PLL CLOCK PLLOK PLL LOCK PWMCTL PWM OUTPUT CONTROL PWMDA PULSE WAVE MOTOR DRIVE A PWMOA, B” PULSE WAVE MOTOR OUT A, B”

INITIAL/LOGO ABBREVIATIONS

R RE READ ENABLE

RFENV RF ENVELOPE RFO RF PHASE DIFFERENCE OUTPUT RS (CD-ROM) REGISTER SELECT RSEL RF POLARITY SELECT RST RESET RSV RESERVE

S SBI0, 1 SERIAL DATA INPUT

SBO0 SERIAL DATA OUTPUT SBT0, 1 SERIAL CLOCK SCK SERIAL DATA CLOCK SCKR AUDIO SERIAL CLOCK RECEIVER SCL SERIAL CLOCK SCLK SERIAL CLOCK SDA SERIAL DATA SEG0~UP FL SEGMENT OUTPUT SELCLK SELECT CLOCK SEN SERIAL PORT ENABLE SIN1, 2 SERIAL DATA IN SOUT1, 2 SERIAL DATA OUT SPDI SERIAL PORT DATA INPUT SPDO SERIAL PORT DATA OUTPUT SPEN SERIAL PORT R/W ENABLE SPRCLK SERIAL PORT READ CLOCK SPWCLK SERIAL PORT WRITE CLOCK SQCK SUB CODE Q CLOCK SQCX SUB CODE Q DATA READ CLOCK SRDATA SERIAL DATA SRMADR SRAM ADDRESS BUS SRMDT0~7 SRAM DATA BUS 0~7 SS START/STOP STAT STATUS STCLK STREAM DATA CLOCK STD0~UP STREAM DATA STENABLE STREAM DATA INPUT ENABLE STSEL STREAM DATA POLARITY SELECT STVALID STREAM DATA VALIDITY SUBC SUB CODE SERIAL SBCK SUB CODE CLOCK SUBQ SUB CODE Q DATA SYSCLK SYSTEM CLOCK

T TE TRACKING ERROR

TIBAL BALANCE CONTROL TID BALANCE OUTPUT 1 TIN BALANCE INPUT TIP BALANCE INPUT TIS BALANCE OUTPUT 2 TPSN OP AMP INPUT TPSO OP AMP OUTPUT TPSP OP AMP INVERTED INPUT TRCRS TRACK CROSS SIGNAL TRON TRACKING ON TRSON TRAVERSE SERVO ON

23

DV-303/DVF-5020/K5020

ABBREVIATION/VOLTAGE CHART

INITIAL/LOGO ABBREVIATIONS

V VBLANK V BLANKING

VCC COLLECTOR POWER SUPPLY

VOLTAGE

VCDCONT VIDEO CD CONTROL (TRACKING

BALANCE) VDD DRAIN POWER SUPPLY VOLTAGE VFB VIDEO FEED BACK VREF VOLTAGE REFERENCE VSS SOURCE POWER SUPPLY VOLTAGE

W WAIT BUS CYCLE WAIT

WDCK WORD CLOCK WEH WRITE ENABLE HIGH WSR WORD SELECT RECEIVER

X X X'TAL

XALE X ADDRESS LATCH ENABLE XAREQ X AUDIO DATA REQUEST XCDROM X CD ROM CHIP SELECT

5. VOLTAGE CHART

5-1 POWER SUPPLY C.B.A.

INITIAL/LOGO ABBREVIATIONS

X XCS X CHIP SELECT

XCSYNC X COMPOSITE SYNC XDS X DATA STROBE XHSYNCO X HORIZONTAL SYNC OUTPUT XHINT XH INTERRUPT REQUEST XI X'TAL OSCILLATOR INPUT XINT X INTERRUPT XMW X MEMORY WRITE ENABLE XO X'TAL OSCILLATOR OUTPUT XRE X READ ENABLE XSRMCE X SRAM CHIP ENABLE XSRMOE X SRAM OUTPUT ENABLE XSRMWE X SRAM WRITE ENABLE XVCS X V-DEC CHIP SELECT XVDS X V-DEC CONTROL BUS STROBE XVSYNCO X VERTICAL SYNC OUTPUT

5-2 MODULE C.B.A.

24

DV-303/DVF-5020/K5020

VOLTAGE CHART

25

DV-303/DVF-5020/K5020

VOLTAGE CHART

26

DV-303/DVF-5020/K5020

VOLTAGE CHART

5-3 MOTHER C.B.A.

27

DV-303/DVF-5020/K5020

VOLTAGE CHART

5-4 MIC JACK C.B.A.

28

5-5 MIC VOLUME C.B.A.

DV-303/DVF-5020/K5020

VOLTAGE CHART

5-6 VIDEO COMPONENT C.B.A.

29

30

DV-303/DVF-5020/K5020

WIRING DIAGRAM (DV-303/DVF-5020)

WIRING DIAGRAM (DVF-K5020)

DV-303/DVF-5020/K5020

31

7

+

RAK

R1101

R1102

15

18

10

5

1

PS1101

C1117

C1121

R1181

R1161

C1154

IC1101

C1101

R1104

R1105

R1106

R1103

Q1041

D1031

R1041

D1042

C1031

C1041

D1041

R1053

D1052

R1054

C1053

R1052

D1032

R1024

C1116

ZA1121

C1143

IC1121

1234

K1121

L1111

C1114

C1112

C1141

C1171

D1161

C1131

D1131

D1111

AKA

D1141

C1115

R1112

K1172

QR1111

Q1111

G

D

S

D1121

R1111

R1001

C1133

L1131

L1141

C1111

C1153

L1151

C1151

D1151

D1171

PR1161

PR1171

D1152

D1162

C1161

1 2

4 3

4

2

5

1

3

IC1151

10

118

7

5

3

2

12

13

14

15

16

17

18

6

4

2

7

5

3

1

IC1021

R1025

R1033

C1052

D1051

R1051

LB1022

R1023

LB1024

D1021

C1022

R1032

R1056

R1055

R1031

R1021

D1022

C1019

C1011

D1001

C1021

LB1021

C1010

32

41

D1011

C1003

1

2

4

3

34

21

L1001

C1008

C1005

D1002

DZ1001

F1001

T1021

P1001

L1002

1

2

HOT

COLD

W001

W003

W002

W154

W102

W201

K1001

W202

W052

W301

W153

L1112

W005

W051

W104

W103

W251

W302

W101

W152

W004

W151

12

THE STRIPED FRAME INDICATES THE PRIMARY CIRCUIT TO DISTINGUISH THE PRIMARY FROM THE SECONDARY CIRCUIT. PAY ATTENTION NOT TO RECEIVE AN ELECTRIC SHOCK DURING REPAIR AND SERVICE OF THE PRODUCTS.

CAUTION

POWER SUPPLY C.B.A.

6

5

4

3

2

1

32

Refer to the schematic diagram for the value of resistors and capacitors.

PC BOARD

A BDCE

(

Component side view

) DV-303/DVF-5020

7

MODULE C.B.A. (1/2)

22 12

11 1

TC4014

TC4001

TP6201

TP6207 TP6209

TC6311

TP6203

TP5201

TC5230

TC5203

TC5201

TC5235

TC5256

TC5202

TC5204

TC5205

TC5208

TC5211

TC5206

TC5209

TC5212

TC5207

TC5210

TC5214

TC5213

TC5215

TC5219

TC5216

TC2512

TC2518

TC2515

TC2513

TC2511

TC5218

TC2516

TC2514

TC2525

TC2524

TC2526

TC2523

TC2522

TC2520

TC2521

TC2519

TC2517

TC5232

TC5233

TC5259

TC5231

TC5258

TC2020

TC5257

CP2036

CP2037

CP2035

CP5203

CP2033

TC2014

TC2007

TC2006

TC2005

TC2003

TC2002

TC2015

TC4288

TC2001

TC2507

TC2505TC2503

TC2502 TC2504

TC2506

TC2010

TC2011

TC2012

TC2013

TC2016

TC2017

TC2021

TC2018

TC2019

TC2004

TC5217

TC5236

TC5260

TP5208

TP5207

TP5206

TP6206

TC6201

TP6210 TP6205

TP6208

TC4002TC4003 TC4004 TC4005 TC4006 TC4007

TC4013

TC4012

TC4011

TC4010

TC4009

TC4008

LB4001

LB4014

LB4002

LB4003

LB4004

LB4005

LB4006

LB4007

PS4201

C4650

R4617 R4616 R4612 R4611

R4601

R6208

R5226

R2027

R2039

R2009

R2008

R2034

R5225

R5224

R2033

R6202

R6201

R4602

R4603

R4272

R4274

R4231

R7002

R3005

R3003

R6544

R6501

R6502

R3013

R3232

C3071

R3033

R3040 R3039

R3201

R3202

R3221

R3222

R3211

R3212

R3213

R3223

R3203

R3233

R6542

R4273

R4607

R4606

R4605

R6207

C4602

C4608

C4651

C4271C4276C4275

C4654

C6303

C7302

C7014

C7301

C5225

C2045

C2042

C5205

C2007

C2003

C2002

C2004

C2005

C2015

C2012

C2513

C2509

C2512 C2511 C2510

C2504 C2503

C2016

R2032

R2031

R2025

R2035

R2024

R2016

C2030

C2508

C2506

C2028C2010

R2023

R2022

R2014

R2502

R2511

R2520

R2521

R2515

R2028

R2026

C2040

C2038

C2037

C5206

K5204

C6304

C5250

C5235

C5239

C5228

C5223

C5220

C5217

C5216

LB5210

C5248

C5203

C5202

C6204

C6207

C6206

C6202

C4653

C4652

C4649

C4608

C4272

C4274

C4208

C4205

C4657

C4601

C7007

C7008

C4661

C4202

C6565

C4203

C4277

C4201

C6542

C6505

C6511

C4618

C6504

C6512

C6601

D6511

C6502

C6513

C6541

C6544

C6564

C6584

C3013

C3043

C3231

C3073

C3046

C3072

RA3002

C3202

C6255

C3211

C6251

C3221

C3040

C3201

W3001

C3041

C3033

C3034

C3004

C3005

C3048

C3012

C3014

C3020

C3019

C3018

C3017

C3016

C3015

C6522

LB4271

C4273

C4664

C4663

C4662

C4613

1 2 354

IC4271

1 2 354

IC4273

1 2 354

IC4272

451

8

IC6303

514

32

IC7302

IC6302

IC5201

IC5202

QR5202

QR5203

514

32

IC7301

C

E B

QR4601

IC4602

IC4201

IC6522

IC6542

IC6563

1816

9

C4207 C4204

1

14

28

15

CP7002

CP6503

RA7002

CP7004

CP7011

CP7009

CP7001

CP7005

CP7006

CP7007

CP7010

CP7012

CP6501

CP6502

CP3001

CP3002

CP3003

CP3005

TP6502

TP6503

TC3201

TC3205

TC3203

TC3202

CP3010

TP6252

TP6257 TP6255 TP6253

TP6254

FL6252

FL6251

FL6253 FL6254

TP6251

TP6258 TP6256

TC3204

22 12

11 1

52

105

1

156

104

53

157

208

TP6501

CP7008

CP7003

71

82

RA7001

71

82

LB6563

LB6565

LB6586

D3001

LB6584

LB6564

LB4201

LB6543

LB6582

LB6511

L4602

L6501

L4201

L6502

LB6501

LB6504

LB6542

LB6583

LB3201

LB3203

LB3204

LB3202

LB3205

LB6562

LB6523

LB6525

148

5

1 2 354

IC6562

IC6511

1 2 354

IC6582

IC3001

IC2511

IC3071

Q3211

Q3221

Q3231

Q3201

PS3201

1 2 354

TP6204

TP6202

123 654

LB6213

132

4

RA6201

1

24

48

25

C

E B

K5205

K5203

K5202

K5201

LB5203

LB5213

LB2508

LB2506

LB2504

LB2502

LB5215

LB2509 LB2511

LB2520

LB2519

LB5217

LB5219

C5208

135

4

2

51

75

50

76

25

1

26

100

C

BE

117

FP2501

C

E B

C

E B

C

E B

C

E B

D3071

123

654

132

4

1

14

28

15

IC2501

1

14

8

7

28

15

21

22

17

FP2511

6

5

4

3

2

1

Refer to the schematic diagram for the value of resistors and capacitors.

33

PC BOARD

FHJGI

(

Component side view

) DV-303/DVF-5020

7

MODULE C.B.A. (2/2)

TL5209

TL5201

TL5205

TL5204

TL5203

TL5202

TL5208

TL2001

TL6202

TL6204

TL6201

TL6203

TL6207

TL6209

TL6208

TL6206

TL6205

TL6210

CP6301

CP6202

CP6201

R6205

CP6203

CP6205

CP6206

CP6207

CP6208

C5251

C6203

C6201

26

50

100

76

75

1

51

25

C6205

C7009

C7003

C6521C6585

C6507

C6506

LB6502

1

25

50

26

8

16 9

C7004

C7005

C7006

D6311

QR6311

IC6301

C6301

C4603

C4281

C6503

C3056

C3011

C3010

C3009

C3008

C3007

C3006

C3045

C3051 C3052

C3053

C3054

C4604C4605C4606

C7012

R6301

C7011

C6302

C4619

C6508

C4614 C4612

C7016C7017

C7019

C7018

C5209

C5221

C5219

C5218

C5213

C2514

C2043

C2044

C2505

C2507

C5212

C5204

C5243

C5231

C5232

C5224

C5238

C5226

C5222

C5230

LB5201

C5229

C5236

C5252

C5237

C5244

C5246

C5241

C5242

C5247

C5245

C5227

C5211 C5210

C5214

C2019

C7015

C2029

CP3007

CP3009

C3021

C3022

C3023

C4242

C2025

C2001

C2022

L2002

C3024

C3025

C3026

C3037

C3003

C3042

C3039

C3032

C3036

C3035

C3038

C3044

C7020

C7013

C2024

C2027

C2031

C2023

R2038

C2036

C2021

C2034

C2033

C2032

C7010

C5215

C5249

C2008

C5233

C5240

L6201

L5201

IC6201

132

4

RA6203

CP6214

CP6213

RA6204

L4601

CP6211

CP6212

CP6210

CP7016

CP7014

CP7013 CP7015

CP7018

CP7017

CP7019

CP2008

CP5202

CP6204

CP2020

CP2021

C7002

CP2022

CP2023 CP2024

CP2019

CP2016

CP2034

CP2032

CP2031

CP2030

CP2038

CP2039

CP2015

CP3006CP3004

CP3008

RA2002

CP2026

CP2014

CP2029

CP2025

CP2003

CP2027

CP2028

R2019

R2030R2029

R3009

R4241

R3008

R3037

R3038

R3035

R3036

R3031

R3042

VR3041

R3041

R3010

R3032

R3006

R2020 C2026 C2041 C2020

R2021

R2012

R7003

R6303

K4202

R4640

LB4012

R6302

R7001

R3001

R3002

R4281

R6204

R6206

R6203

R7006

R5217

R5212

R2003

R5213

R5223

R2004

R2001

R2010

R2005

R2503

R2510

R2504

R2513

R2501

R2522

R2519 R2523 R2524 R2518

R2507 R2508 R2516 R2517

R2505 R2512 R2506 R2509

R2036

R2037

R2006

R5211

R5205

R5206

R5220

L5202

R5209

R5208

R5210

R5214

R5216

R5215

R5203

R5202

R5201

R5221

R5219

R5222

R5218

C

E B

13

24

RA6205

13

24

RA6206

C4607

RA6202

1

132

4

3

24

3 2 145

IC4607

3

2

145

IC4606

3

2

145

IC4605

IC4601

3

2

145

IC4604

3

2

145

C4609

C7001

L7001

L7002

K4201

K4203

LB6522

W6501

K3023

LB6521

X6501

LB6585

148

5

IC6521

IC7001

148

5

IC6583

1105

6

PS6201

IC6501

IC3051

C3055

36

73

1

108

37

72

144

109

IC2001

QR2501

QR2503

QR5201

QR2001

Q5201

96

1

65

32

97

128

64

33

LB5211

LB5216 LB5218 LB2507

LB2517

LB5205

LB5206

LB5207

LB5208

LB5209

LB2505

LB2515

LB2514

LB2513

LB2512

L2501

LB2503

LB2501

LB2510

LB2521

LB2518

LB5214

LB5202

LB5204

CP5206

CP5204

CP5201

CP2005

CP5205

FP5201

LB5212

C

E B

21 135791113151719

2468101214161820

C5234

C5201

231

CP2002

CP2006

C5207

CP2013

CP2012

CP2040

RA2001

CP2001

CP2010

CP2011

CP2009

CP2502

CP2501

13

24

C

E

B

24 86 13 75

RA3001 24 86 13 75

C2006

C3286

C6501 C6514

C4615

C4616

C4611

C4610

C4617

C2501

C4206

C6253

C6252

C3002

C3001

C3031

C2502

C6254

L2001

L3281

NJ3201

L3001

D3002

46 60

30 16

145

1531

LB4013

LB4011

LB4010

LB4009

LB4008

123

54

QR2502

123

54

C

B

E

13

224

4

RA2501

RA2502

6

5

4

3

2

1

34

Refer to the schematic diagram for the value of resistors and capacitors.

PC BOARD

K LNMO

(

Foil side view

) DV-303/DVF-5020

7

LB3592

13

1 5 10 30252015 35 40 45 5450

IC6003

MOTHER C.B.A.

W107

W110

W307

W117

W015

W049

W119

W014

R6016

R6017

R6018

C6008

W108 W109

W403

W404 W405 W406

W504 W505 W506

W507 W508

W509

W204

W004

W205 W206

W207 W208

W106

W103

W006

W202

W203

W401

W402

W502

W503

R3571 R3561

VR3511

VR3501

W306

W305

W310

W610 W611

W211

W219

W122

W605 W606 W607 W608

W609

W123

W018W017

W215

W216

W218

W217

W613

W615

W616

W617

W618

W604

W408

QR4591

QR4592 QR4593 QR4594

W510

W111

C6005

L6002

L6008

D6001

C6044 C6045

LB6016

LB6015

LB6005

LB6012

LB6011

LB6014 LB6013

LB6017

L6003

L6004

L6006

L6007

FP26002

1

210 20

51519

D4591

D4597

D4593

R4595

R4598

R6024

R6039

R6064

R4593

D4595

R4592

R4599

R4591

R4596

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

R6022

R6021

R6014

R6013

R6012

R6063

R6061

R6062

R6020

C6009

C6010

C6011

R6065

R6011

R6009

R6010

R6008

R6035

R6005

R6025

R6029

R6030

R6031

R6032

R6033

R6006

R6007

C6004

C6013

C6014

C6015

1

12

43

35413

54

IC6004

IC6005

1

84

80

75

70

6463

60

55

50

45

43

5

10

15

20

2122

25

30

35

40

42

IC6001

IC6002

R6019

DL6001

C6021

C6002

C6003

C6001

L6001

X6001

W021

W136

D6013 D6014 ST-BY

VSS

C

B

E

C

B

E

QR6002

W022

W019

W020

W517

W516

W313

W312

W311

W118

W514

W511

W005

K4591

W612

W314

W220

W035

W043

W047

W045

W044

W032

W031

W033

W034

W127

W317

W036

W126

W133

W135

W132

W042

W229

W134

W230

W225

W226

W046

W048

W221

W518

W519

W222

K6022

K6009

K6001

K6005

K6006

K6010

K6002K6011

K6007

K6003

K6004

K6008

K6012

K6015

K6014

K6013

K6020

R6015

K6021

W320

W524

R6023

D6002

D6003

D6004

C4591

D4592

W409

W515

D4596

D4594

N

C4592

R4594

R4597

QR4595

W104

W105

QR6008

E

Q6009

E

Q4911

E

Q4302

Q4303

E

Q4912

151011

12 15 20 22

PP24201

C3549

L3532

C3532

C3542

C3536

R3555

R3521 R3526

R3518

R3566

L3531

C3539

C3537

C3535

R3534

R3533

R3531

R3544

R3532

R3543

LB3543

LB3544

R3546

LB3545

R4504

R4502

LB4501

R3545

IC3531

1511

12 15 2220

10

S6007 S6003

OPEN/CLOSE

STOP

S6005

RVS-SKIP

S6001 PAUSE

S6006

FWD-SKIP

S6002

PLAY

S6004

VSS

R6046

R6045

R6044 R6049 R6052 R6041 R6042 R6043

R6037

R4903

R4913

R4912

R4911

R4902

R4901

R6038

R6036

R6050

R6053

R6047

R6004

R6057

LB6008

LB6009 LB6010

LB6004

R6001 R6002 R6003 LB6001

LB6003 R6056 LB6002 R6055

R6054

LB6006

LB6005LB6007

14 10 2

1513

FP26001 C6041 C6042 C6043

C6006

C

B

E

QR6003

C

B

E

C

B

E

C

B

E

QR6007

C

B

E

C

B

E

QR4901

QR4913

C

B

E

C

B

E

C

B

E

Q4311

Q4301

QR6005

QR6006

QR6004

IC4901

R6027

R6026 R6028

15

C4911

C4912

C4901

D4901

12

PR4911

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

QR4303

QR4302

C4311C4301

R4310

R4462

R4463

R4302

R4467

R4466

R4315

R4481

R4316

R4318

C4303

C4306

R4308

R4307

R4317

R4312

R4305

R3582

W301

W302

W303

W304

W512

W513

R3511

R3512

R3504

C3512 R3514 R3516 R3517

R3515

W012

C3511

W011

R3562

R3505 C3504

R3563

R3572

R3519

R3556

R3507

R3520

R3508

R3557

R3592

LB3591

LB3593

R3575

L3551

C3562

C3572

C3551

C3552

C3501

C3554

C3581

C3583

R3565

C3584

R3573

R3574

Q3571

R3564

W013

W007

R3581

C3533

R3506 C3505

R3502

R3503

R3501

R3583

FL3501

R4303

R4461

R4482

R4313

R4465

R4306

R4309

R4304 R4314

R4311R4301

D4301

W131

W129

W027

W128

W040

W038

W039 W319

W318

C4753

C4761

R4761

C4763

C4764

C4751

C4752

31 45

W228

W415

W041

W522

W619

W621

W620

W523

W413

W029

W030

W028

W037

W025

W026

W411

W614

W520

W521

W024

W023

W016

W121

W309

W120

W308

C3531

C3534

C3514

C3506

C3538

W214

W116

W212

W213

W315

W125

W124

W227

W316

W224

W412

W130

C4782

C4462

C4314

C4465

C4302

C4315

C4312

C4305

C4304

C4461

C4467

C4466

C4701

C4463

R4562

LB4501

LB4511

LB3546

C4561

C4588

C4511

C4501

C3547

C4585

D3546

D3545

D3543

D3544

LB4571

C4571

R4572

C4702

C4586

C3540

C4468

Q4313

Q4312

58

41

14

85

58

41

IC4461

IC4306

58

41

IC4751

C4464

QR4311

QR4301

C

B

E

C

B

E

C

B

E

Q4562

Q4501

Q4571

Q4572

Q4515

Q4561

Q4511

Q3501

QR3581

Q3511

Q3561

Q3502

Q3503

Q3513

Q3512

IC4752

L4781

L3581

C3513

L3501

L4761

C4781

11223

IC4781

JK4771

13 64

T4761

C4772

R4771

C4773

C4771

LB4771

LB4772

C4774

W414

IC4701

R4468

R4563

R4561

R4571

R4564

R4565

R4573

R4515

R4511

R4513

R4503

R4501

R4464

R4575

R4574

R4514

R4512

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

QR3521

QR4501

Q4505

1

1346

52

3

2

FL3511

31

2

FL3561

PP23201 11 10 5 1 12 15 20 22

W101

W102

W003

W002

W114

W209

W010

W210

W113

W115

W112

W001

W201

W602

W501

W603

C3500

C3588

C3550

C3587

R3591

R3593

D3592

D3591

D3593

C3582

C3502

C3586

C3585

158

161510

9

IC3581

W601

1

10

15

5

18

PP21101

JK3591

14

562

S3581

13 46

C

B

E

C

B

E

C

B

E

C

B

E

W407

R4507 R4506

R4505 R4517

CP4502

CP4501

13 46

S4501

89 34 6251710

11

JK3541

147

895623

JK4501

6

5

4

3

2

1

Refer to the schematic diagram for the value of resistors and capacitors.

35

PC BOARD

PRTQS

(

Component side view

) DV-303/DVF-5020

7

+

RAK

R1101

R1102

15

18

10

5

1

PS1101

C1117

C1121

R1181

R1161

C1154

IC1101

C1101

R1104

R1105

R1106

R1103

Q1041

D1031

R1041

C1031

C1041

D1041

R1053

D1052

R1054

C1053

R1052

D1032

R1024

C1116

C1143

IC1121

1234

K1121

L1111

C1114

C1112

C1141

C1171

D1161

C1131

D1131

D1111

AKA

D1141

C1115

R1112

K1172

QR1111

Q1111

G

D

S

D1121

R1111

C1133

L1131

L1141

C1111

C1153

L1151

C1151

D1151

D1171

PR1161

PR1171

D1152

D1162

C1161

1 2

4 3

4

2

5

1

3

IC1151

10

118

7

5

3

2

12

13

14

15

16

17

18

6

4

2

7

5

3

1

IC1021

R1025

R1033

C1052

D1051

R1051

LB1022

R1023

LB1024

D1021

C1022

R1032

R1056

R1055

R1031

R1021

D1022

C1018

C1011

D1001

C1021

LB1021

C1010

32

41

D1011

R1002

C1003

1

2

4

3

34

21

L1001

C1008 C1005

F1001

T1021

P1001

L1002

1

2

HOT

COLD

W001

W003

W002

W154

W102

W201

K1001

W202

W052

W301

W153

L1112

W005

W051

W104

W103

W251

W302

W101

W152

W004

W151

E C B

12

THE STRIPED FRAME INDICATES THE PRIMARY CIRCUIT TO DISTINGUISH THE PRIMARY FROM THE SECONDARY CIRCUIT. PAY ATTENTION NOT TO RECEIVE AN ELECTRIC SHOCK DURING REPAIR AND SERVICE OF THE PRODUCTS.

CAUTION

POWER SUPPLY C.B.A.

6

5

4

3

2

1

36

Refer to the schematic diagram for the value of resistors and capacitors.

PC BOARD

U VXWY

(

Component side view

) DVF-K5020

7

C6504

C6506

C6601

C6507

LB6503

LB6543

C6502

C6503

C6521 LB6521

LB6523

C6522

IC6522

LB6525

C6542

R6207

C6206

R6561

C6562

LB6504

R6564

LB6563

RA7001

1234567

8

CP6502

C3019

CP3001

CP3002

CP3003

CP3005

LB6562

C6564

R6581

IC6581

R6582 C6582

C3012

C6565

C7008

C7007

LB6565

C6563 LB6561

R6562

IC6561

K6542 K6541

C6541

IC6303

R6541

C6505

L6502

C6512

LB6541

LB6502 LB6501

LB6542

IC6542

C6544

LB6522

C6561

K6562

LB6564

IC6563

LB6586

R3003R3005

R7002

C6581

LB6582

C6583

LB6581

LB6583

C6584

C3017

LB4013

LB4014

C3014

C3015

C3016

C3018

C3020

C3013

IC6582

LB6584

C7301

C6303

C7302

R6544

C6543

R6208

R6210

C6204

R6209

C6207

R6202

R6542

TP6204

TP6501

TP6502

IC6521

TP6202

26 14

113

TC4006

TC4003

TC4005

TC4011

TC4019

TC4018

TC4008 TC4012 TC4014 TC4016

TC4007

TC4021

TC4020

TC4001

TC4002

TC4004

TC4010

TC4017

TC4009 TC4013 TC4015

PS4201

+

231

45

2

IC6541

31

45

231

45

IC6562

231

45

23145231

45

TP6201

12

D6541

12

1485148

5

D6561

148

5

TP6503

D3001

12

CP7010

CP7001

CP7003

CP7008

CP7006

CP6503

CP7004

CP7002

CP7011

CP7009

CP7007

CP7005

CP7012

RA7002

1234567

8

2

IC7301

31

45

2

IC7302

31

45

TC6311

1

4

8

5

TP6208

TP6210 TP6205

TP6206

TP6209

TP6207

TC6201

132

4

RA7003

C7014

53

104

208

157

105 156

52 1

IC3001

TC7001

TC7002

TC7003

TC7004

LB7001

LB7002

LB7003

C3046

C3041

C3047

R3011

R3012

R3013

LB3207

LB3206

LB3209

LB3205

LB3204

LB3203

C3005

C3211

R3213

C3201

R3203

C3221

R3221

R3222

R3231

R3333

R3314

R3313

R6603

R3232

R3241

R3242

C3304

C3306

R3223

C3231

R3233

C3241

R3243

R3302

R3301

L3281

R3334

C6255

C3284

C3282

C3285

R3311

Q3304

R3319 R3312

C3326

R3316

R3327

R3326

R3328

R3329

R3315 R3317

C3324 R3324

R3325

R3323

C3323 C3321 R3321

R3309

K3071

IC3301

C3048

C3004

TC3201

TC3202

TC3207

TC3206

TC3208

TC3209

TC3205

TC3204

TC3203

26

1

14

13

PS3201

TP6252

TP6257

TP6258

TP6255

TP6256

TP6253

TP6254

TP6251

C6251

FL6251

FL6254

FL6253

FL6252

C3043

K3203 K3201

C3033

R3033 C3040 R3040

C3072

D3071

K3202 K3204

C3301

R3303

R3306

R3310

D3302

R3318

R3307

R3308

C2001

R3305

C3303

R3304

K3301

R3039

RA3002

C3073

C3071

R3211

LB3001

K3206

R3212

R3201

R3202

C3034

CP3010

CP6504

132

4

16342

5

IC3071

+

12

Q3211

C

EB

Q3201

C

EB

Q3221

C

EB

Q3231

C

EB

Q3241

C

EB

Q3302

C

EB

Q3331

C

EB

Q3303

C

EB

Q3301

C

EB

IC3281

1

D3301

2

12

C

EB

451

8

2

IC3322

31

45

Q3322

C

EB

Q3321

C2506

R2502

C2508

R2511

R2520

R2521

C2504

C2512 C2511 C2510

C2509

R2515

C2503

C

EB

Q3305

C

EB

C6604

R6601

C6603

C2030

R2014

C2016

C2010

R2016

R2024

R2026

R2028

C2037

C2038

C2005

C2040

R2033

C5205

C2002

C2003

LB2508

LB2506

LB2504

LB2502

R5224

R5225

C2007

C2004

R2031

R2035

R2025

R2034

R2008

R2009

C2042

R2039

C5206

R2027

C2045

R2032

C2015

C2012

R2023

C2028

R2022

R6602

R6604

IC6601

LB6601C6606

C6602

81

54

TC2015

TC4288

TC2001

TC2016

TC2012

TC2017 TC2010 TC2011

TC2014

TC2013

IC2501

15

21

22

28

14

8

7

1

IC2511

1

14

28

15

TC2507

TC2506

TC2002TC2005

TC2003

TC2007

TC2006

TC2020

TC2505TC2503

TC2501

TC2504TC2502

17

FP2511

117

FP2501

CP2033

CP2036

CP2037

TC2019

CP2035

TC2021

TC2018

TC5257

TC5258

TC5256

TC5235

TC5231

TC5233

TC2004

TC5216

TC5236

TC5201

TC5230

TC5260

TC5203

TC5202

TC5214TC5212TC5210TC5208TC5206TC5204

TC5213TC5211TC5209TC5207TC5205

TC5217

TC5215

TC5219

TC5218 TC5242

TC5246

TC5250

TC5248

TC5240

TC5247

TC5249

TC5252

TC5251

TC5254

TC5253

TC5255

TC5241

TC5244

TC5245

TC5243

TC5232

TC5259

LB5215

LB5217

LB2509

LB2519

LB2520

LB2511

QR5202

C

EB

K5201

K5202

K5203

K5204

C5225

LB5213

LB5210

C5216C5220C5228

C5217C5223

K5205

C5203

C5202

C5239

C5248

1

100

76

26

50

25

75

51

IC5202

12

IC5201

3

54

C5208

LB5219

LB5203

+

TP5208

TP5206

TP5207TP5201

TP6203

C6304

+

LB6213C6202

R6201

132

4

RA6201

1

24

48

25

IC6302

C

EB

QR5203

C5235

R5226

MODULE C.B.A. (1/2)

6

5

4

3

2

1

Refer to the schematic diagram for the value of resistors and capacitors.

37

PC BOARD

ZABADAA AC

(

Component side view

) DVF-K5020

7

C3271

C3257

C3258

D3002

L3001

123

54

C3307

IC3302

RA3251 RA3252

IC3201

IC2001

36

110

25

37 24

48

13

1

FP2512

17

62

1

12

31

42

1

25

26

1

50

2

3

115

357

2468

12

K3205

K3332

C3322R3322

R2510

R2522

C2507

R2519 R2523 R2524 R2518

R2507 R2508 R2516 R2517

LB2514

LB2515

LB2516

R2505

C2041

R2037

C2044

C2043

R2036

R2503

C2020

C2025 C2026

R2020

C2021

R2038

R2029 R2030 C2029

C3022

C3023

C2023

C2031

C2027

C2024

C7010C7013

R2012

C2032

C2033

C2034

C2036

R2021

R2512 R2506 R2509

C2505

QR2503

R2501

CP2501

QR2501

1

C

EB

23

54

CP2502

R2504

R2513

R3254

R3251

C3255

C3254

C3253

C3252

R3259

C3251

R3258

LB3202

LB3201

NJ3001

R3036

R3035

C3038

R3031

VR3201

R3006

C3272

C3260

R3255

RA3253

L7002

L7001

L5201

L6201

L5202

L2001

L2002

L2501

C3024

C4242 R4241

R3009 C3044

C3021

R2019

C2019

C7019

C5214

R5212

C5215

C5211 C5210

C5222 C5226

LB5204 LB5201

C5229

R5215

R5203 R5202

C5247

C6201

R6203

R6205

TL2001

R5201

Q5201

C5236

C5237

C5246

C5241

C5242

C5233

C5240

R5218

K7002

C5227

R5222

C5245

R5219

R5217

R5221

C5244

C5230

R5216

R2005

LB2501

LB2503

LB2505

C5213

R5208

C5209

R5211

R5205

R5206

R5210

R5214

C5218

C5219

C5221

C5224

C5238

LB5202 R5209

C5243 R5220

K6301

C7201

LB5209

LB5208

LB5207

LB5206

LB5205

LB5214

R2001

R2006

C5204

R5223

R5213

C5212

R2004

C2008

R2003

LB5216

LB5212

C5249

LB5218 LB2507

R2010

LB2517

C7018

C7017 C7016

C7012

C6205

R6301

C6302

R6303

LB6511

X6501

L6501

C6511

123

654

C6301

C7003

C7004

C7005

C7006

R7001

R3002

R3001

LB6526

LB4001

LB4002

LB4003

LB4010

LB4017

LB4018

LB4019

LB4016

PS6201

LB4004

LB4005

LB4006

LB4007

LB4008

LB4009

LB4012

C3056

LB6585 C6585

C6513

R6501

R6502

R6302

R6204

R6206

C7009

R7006

C7011

R7003

C7015

C7020

C4241

LB4241

IC4241

C3064

C3025

C3026

R3008

C3037

C3042

C3003

FP3202

R3256

R3257

C 3261

R3032

LB7004

R3037 R3038

IC3061

C3039

C3036

C3063 C3062

C3035

C3061

C3051

C3066

C3052

C3053

C3065

C3054

R3010

C3045

C3006

C3007

C3008

C3009

C3010

C3011

C3259

R3253

R3252

NJ3201

C3256

LB2521

LB5211

FP5201

LB2510

LB2518

C3032

P6251

C6254

C6252

IC3321

81

16 9

18

16 9

1357

2468

RA3001

1357

2468

+

R2018

1357

2468

+

C3001

+

C3002

+

C2502

+

C3031

+

C6607

+

C5207

+

C3302

+

C3305

+

C6253

+

C3281

+

C3283

+

C2006

+

C2501

+

C5234

+

C5232

+

C6203

+

C5201

+

C3286

+

D6311

12

21

D6511

12

31 42

RA2502

24 13

RA2501

24

1

137

36 2

3

R2011

24

13

RA6204

24

13

RA6205

24

13

RA6206

C6514

+

C6501

IC6511

24

13

RA6203

15

FP7001

126

FP4202

321

6596

128

33

132

64

97

25

26

1

50

IC3051

C3055

+

CP2003

CP2030

CP2038

CP2015

CP2039

CP2023 CP2024

CP2022

CP2021

CP3009 CP3008

CP3004

CP3007

CP2020

CP6204

CP5202

CP5203

CP2001

CP2040

CP2009

CP2010

CP2011

CP2013

CP2012

CP2008

CP7014

CP7013

CP6215

CP7016

CP7015

CP7018

CP7017

CP6214

CP6213

CP6211 CP6210

CP6212

IC6301

CP6501

CP2006 CP2002

CP2005

CP5205

CP5206

CP5201

CP5204

CP6301

CP6201

CP6203

CP6202

CP6205

CP6208

CP6206

CP6207

CP7019

CP2025

CP2026

CP2027

CP2014

CP2028

CP2029

CP3006

CP2016 CP2019

CP2031

CP2032

CP2034

QR2502

123

54

C2022

C5231

QR2001

C

EB

QR6311

C

EB

QR5201

C

BE

LB2512

LB2513

IC7001

IC6201

136

10873

37

144

72 109

125

75

51

26

100

50

76

IC7201

18 45

IC6583

18 45

45

321

TL5208

TL5202

TL5203

TL5204

TL5205

TL5201

TL5209

TL6210

TL6205

TL6206

TL6208

TL6209

TL6207

TL6203

TL6202

TL6204

TL6201

18

16 9

IC6501

X6502

21

X6503

21

15

106

C7001

+

C7002

+

MODULE C.B.A. (2/2)

6

5

4

3

2

1

38

Refer to the schematic diagram for the value of resistors and capacitors.

PC BOARD

AE AF AHAG AI

(

Foil side view

) DVF-K5020

7

D4903

C4920

C4919

C4917

R4482

R4481

C4918

1

3

2

1

3

2

R4916

Q4915

Q4914

R4917

C4915

C4914

R4914

R4751

C4434

C4423

C4464

R4464

C4465

R4467

R4456

R4455

C4452

C4453

C4321

R4321

C4332

R4332

R4323

R4322

R4441 R4442 R4445

R4465

C4463

R4461

R4471

R4472

R4473

R4401

R4411

C4413

C4475

R4331

R4333

C4331

C4462

C4461

R4462

R4403

C4402

R4402

R4412C4412

R4413

C4411

Q4411

Q4401

R4477 C4476 R4476

R4463

C4401

IC4471

IC4321

C4322

C4466

R4454

C4451

R4452

R4453

R4451

IC4461

IC4451

C4403

IC4751

C4913

C4752

R4915

C4916

R4424

D4902

58

4

1 2

1

L4781

C4751

C4781

C4782

C4774

R4582

Q4551

C4551

R4584

Q4541

Q4562

Q4572

Q4552

Q4542

R4515

R4575

R4571

R4555

Q4571

Q4561

Q4502

C3537

Q4512

R4518

C4571

C4581

LB4771

R4771

LB4531

R4522

C4532

C4531

C4773

C4772

C4771

C4763

C4764

Q4532

64

13

T4761

R4532

R4524

R4404

R4458

R4448

C4441

C4467

R4525

R4535 R4521

Q4531

Q4521

Q4522

R4523

R4533

R4553

C4582

C4587

LB4571

C4588

R4562

C4589

LB4772

R4583

R4554

R4541

R4544

R4574

R4564

R4565R4561

C4701

R4543

C4541

R4542

LB4541

R4572

R4563

R4573

C4586

C4511

R4502

C4501

LB3546

LB4501

C4585

R3546

R3545

R3526

C3542

R3525

R3541

R3542

R3523

R4505

R4517

R4507

LB3543

LB3545

R3543

R3524

LB4511

R4501

R4508

R3531

R3532

R4519

C3538

R3534

C3539

LB4551

PD4202

R4761

R4434

R4531

R4534

R4414

R4459

R4468

K4441

R4443

R4446

R4444

Q4313

R4304

Q4312

R4316

K4442

C4454

C4442

R4449R4457

R4551

L4761

151011

1222 20 15

184

5

184

5

85

1

14

85

Q4301

C4213 C4205

C4212

C4211

C4208

W615

W208

W050

W084

LB4271

C4278

C4277

C4206

C4311

14

85

4

IC4401

58

41

14

85

IC4441

R4447

1

3

2

1

3

2

C4303

R4311 R4312

Q4311

R4314

R4313

C4312

C4314

C4315

R4303

C4301

C4219

C4215

C4222

C4221 R4282

C4216

C4305

C4304

C4302

R4306

QR4311

QR4301

R4355 C4352 R4351

R4354 R4353 C4353 R4356

Q4341

Q4351

D4341

R4352

C4306

QR4312

R4301

R4305

R4302

1 2 3

Q4303

R4318

Q4302

R4319 R4317

R4307

K4382

R4308

1

85

1

IC4701

C3549

C4702

R3535

4

23

IC4242

L4201

IC3531

R4513

R4503

R4504

D4301

C4351

C4341

C4371

184

5

R4346

R4344 R4341

R4342

C4343

R4343

R4345

R4375 R4374 C4372C4373

C4342

R4371

R4372

1

C4362

R4361

R4309

R4310

C4363 R4365

R4364 R4383 R4382

R4366

R4363

R4362

C4361

4

85

VSS PLAY PAUSE RVS-

SKIP

FWD-

SKIP

OPEN/ CLOSE

STOP

VSS STADBY

C4422

R4423

R4433

R4432

R4431

R4421

C4393C4394

C4398

C4397C4399

C4390

R4435

Q4432

K4384

R4381

K4381

C4431

C4432

QR4381

R4422

1

185

16912

185

16912

4

85

IC4421

1 2 3

C4433R4436

R4437

Q4431

Q4421

C4421

C4391

C4392

C4395

C4396

C4912

C4911

Q4901

R4903

E C B

Q4913

R4912

Q4911

R6004

LB6005

Q4912

R4911

R4901

R4902

D4901

C4901

R4913

1

24201513

512 10

1

24201513

512 10

IC4391

IC4392

15

IC4901

PR4911

LB6001

R6003

R6002

R6001

R6057

R6056

R6055

LB6003

LB6002

LB6004

R6054

R6046

R6045

S6004 S6002 S6006 S6001 S6005

S6003

S6007

15 13

14102

FP6001

LB6006

LB6007

LB6010

R6027

R6026

R6028

R6043

W233

W087

W237

W151

W865

R6041

R6053

R6052

C6043

R6042

R6049

R6044

C6041

C6042

R6037

C6006

R6038

R6035

LB6009

LB6008

QR6007

QR6006

QR6005

R6047

R6050

QR6003

QR6004

QR6001

QR6002

R6034 R6036

QR4431

QR4382

QR4383

QR4302

QR4303

K4383

IC4382

IC4381

D4361

Q4371

Q4361

D6014 D6013

C6021 R6007 R6008 R6011

X6001

R6017

R6016

R6018

C6008

C6011

R4631

C4631

C4643

C4644

R4629

R4630

C4632

R4632

C6005

L6002

W076

W232

C6009

C6010

R6014

R6013

R6012

R6063

R6062

R6061

R6019

C6004K6023

C6007

R6006

R6005

C6002

K6005

K6001

K6002

K6003

K6007

K6011

K6004

K6008R6031

R6029

R6030

R6032

R6033

K6010

K6012

K6013

K6014

K6015

R6024

C6014

C6013

K6006

K6009

K6020

R6015

C6001

L6001

C6003

1

21

15

10

5

22

25

30

35

42

43

45

50

55

60

63

64

70

75

80

84

IC6001

R6009 R6010

13

2

IC6002

R6021 R6020

IC4611

C4634

R4636

C4636

K4602

K4601

C4638

R4639

C4625

R4615

C4624

C4620

C4611

C4612

R4642

C4648

C4616

C4614

R4640

C4663

R4606

W616

W617

W618

W223

W730

W851

W864

W729

W356

W847

W526

C4662

R4607

C4613

C4664

LB6016

LB6014

L6004

W437

L6003

R4616 R4617

C4637

C4621

R4610

R4612

C4635

R4637

R4644

R4643

L6006

L6005

LB6012

LB6013

LB6011

C6044

L6007

C6045

LB6015

LB6017

LB6019

LB6018

L6008

R4635

R4633

R4634

C4633

85

14

Q4604

C4647

Q4603

R4638

C4626

C4622 R4611

C4645C4623

R4608

R4614

R4613

184

5

IC4606

R6025

C4227

C4283

C4228

C4225

W810

W703

W505

W504

W444

W075

R4283

IC4221

151014

28252015

IC4232

14

85

C4232

R4233

C4641

R4628

R4627

R4626

R4622

C4642

R4624

C4630

C4627

C4607

C4610

R4601

R4602

R4603

C4652

C4653

C4654

R4604

C4606

C4649

C4609

R4232

R4231

K4232

C4224

C4282

C4217

C4218

151014

28252015

IC4211

151014

28252015

IC4201

C4214

C4207

C4281

R4281

C4201

C4204

C4202

C4203

C4280

K4201

K4203 K4202

C4271

C4272

R4258

R4271

R4272

157

14 10 8

IC4266

R4273

C4273

R4275

R4274

C4274

W841

W808

R3508

C3601

W202

C4275

C4251

R4257

R4256

W426

W080

W071

W845

R4254

R4253

R4252

R4251

101418

951

IC4251

C4629

C4628 R4619

L4601

R4620

58

41

IC4610

Q4601

Q4602

R4623

R4621 C4646

D4604

R4618

R4609

C4619

R4641

C4651

W852

C4608

1

5

10

15 16

20

25

30

31

35

40

45

46

50

55

60

IC4601

L4602

C4615

C4617

C4618

C4650

1

5

15

21

22

10

2

FP4701

R4593C4659

13 54

IC4613

R4647

LB4601

C4658

R4605

751

158

16 12 9

81014

IC4612

C4665

C4655 R4645

R4646

C4656

C4601

C4661

C4657

IC4602

D4594

11223

FL3501

R3501

R3503

Q3501

Q3503

C3506

R3502

C3503

R3505

R3504

C3504

D4591 D4593

C4591

QR4592

R4595

QR4593

QR4594

R4598

C4592

K4591

QR4595

QR4591

D4596

R4592

R4599

D4597

R4597

R4596

R4594

R4591

D4595

D6004

D6003

D6002

R6023

R6022

13 54

IC6005

IC6004

54 53 50 45 40 36 17 15 10 5 2 1

321

DL6001

IC6003

K4241

LB4241

C4279

C3609

C3532

L3531

R3610

R3611

R3604

R3609

C3604

R3606

R3519

C3514

R3521

C3552

R3564

R3575R3574

R3551

C3553

K3502

K3501

R3552

R3553

R3555

R3565

R3562

R3527

C3502

R3608

R3607

D3601

C3607

C3606

L3501

R4276

C4276

12

PP4203

C3531

Q3603

Q3602

R3605

Q3512

QR3601

Q3513

Q3561

Q3551

Q3571

C3572

L3551

C3551

C3512

Q3511

R3603

R3506

R3602

R3520

C3603

R3518

C3602

C3505

R3601

VR3501

VR3511

C3501

R3507

Q3601

C3533

C3608

C3605

C3534

R3612

L3532

C3535

C3540

C3536

R3533

11013

142026

5

PP3201

D3546 D3545 D3543 D3544 D3541 D3542

LB3544

LB3541

LB3542

CP4501

CP4502

R4506

QR4501

Q4505

123

456

S4501

1

7106

98

52

3265

14

98

7

32

1

65

1

2

13

4

34

IC4781

JK4771 JK4502 JK4501 JK3541

Q4501

Q4511

R3516

R3515

R3511R3512

R3522

C3513

C3511

FL3511

QR3523

QR3521

QR3522

R3561

R3571

R3562

C3571

FL3561

1

134526

3

2

FL3551

R6064

K6024

R6039

QR6008

E C B

Q6009

R3554

R3573

R3572

C3554

C3500

C3550

1

10

5

15

18

PP1101

15101520

PP3801

Q3502

D4592

R4373 R4376

LB4521

2

31

14

131051

2026

PP4201

W229

W078

W531

W608

W619

W225

W072

W610

W540

W532

W430

W717

W722

W351

W855

W727

W728

W607

W606

W047

W355

W222

W539

W070

W220

J4

W518

W425

W515

W219

W218

W340

W339

W516

W517

W519

W427

W712

W221

C4672

W338

W217

W520

W524

W521

W522

W523

W507

W508

W439

W343

W446

W441

W428

W429

W345

W211

W725

W605

W718

W719

W720

W348

W431

W854

W721

W052

W858

W859

W856

W341 W611 W350

W231W224

W716

W230

W713

W715

W530 W436 W432

W614

W863

W857

W073

W227

W226

W046

W228

W077

W525

J3

W079

W353

W609

W853

W347

W527

W612

W723

W301

L4671

W731

W433

W215

W068

W067

W216

W844

W822

W846

W034

W201

W337

W424

W200

R4255

W613

W604 W710 W708

W709

W081

W204

W214

W205 W206

W207

W212

W534 W442 W443

W440

W085

W850

W438

W706

W066

W514

W834

W838

W833

W832

W053

W421

W422

W423

W332

W056

W057

W058

W061

W062

W086

W065

W199

W064

W336

W434 W435

W335

W197

W334

W862

W836

W835

W063

W705

W420

W866

W033

W344

W236

C3541

R3544

W054 W055

W190 W191 W192

W059 W060

W193

W194

W195

W082

W196

W511 W512 W513

R3563

R3517

W837

W506

W601

W602

W401

W714

W349

W049

W051

W048

W533

W346

W342

W235 W234

W213

C4223

W801

W811

W038

W809

W404

W802

W806

W302

W303

W803

W805

W804

W304

W732

W045

W153

W002

W807

W001

W152

W502

W501

W155

W305W154

W702

W701

W044

W043

W042

W503

W402

W403

W161

W536

W405

J2

W164 W163

W312

W352

W537

W813

W311

W310

W860

W041

W162

W535

W408

W039

W317 W316

W315 W314

W313

W165

W210

W166

W812

W307

W406

W318

W319

W320

W321

W327

W322

W323

W410

W167

W168

W170

W040

W814

W306

W818

W817

W309

W603

W157

W003

W159 W158

W005

W004

W816 W815

W156

W726

W541

W308

W035

W037 W036

W819 W820

W029

W026

W027

W823

W209

W028

W088

W821

W169

W032

W171

W031

W030

W013

W014

W010

W413

W008

W407

W328

W707

W711

W417

W178

W412

W416

W538

W324

W411

W016

W174

W183

W187

W184

W185

W418

W419

W330

W020

W829

W019

W179

W830

W509

W173

W329

W354

W172

W025

W447

R4475

C4471

W861

W009

W006

W011

W012

W007

W160

W825

W842

R4466

W414

W415

W188

W069

W083

W704

W074

C4761

W826 W827

W177

W176

W175

W182

W186

W180

W018

W024

W181

W017

W015

W021

W325

W326

R4315

W843

W828

W023

W022

R4509

R4514

R4511

W445

W331

W189

W620

R4552

R4581

W510

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

C3561

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

EB

C

R4512

LB4561

W831

EB

C

EB

C

EBCEB

C

EB

C

EB

C

EBCEBCEB

C

EB

C

R3514

EB

C

EB

C

EB

C

EB

C

EB

C

C4639

R4625

C4640

EB

C

EBCEBCEB

C

EBCEB

C

EB

C

EB

C

EBCEB

C

EB

C

EB

C

EB

C

IC4341

IC4361

EB

C

EB

C

IC4306

R4545

Q4515

C4561

MOTHER C.B.A.

C4671

6

5

4

3

2

1

Refer to the schematic diagram for the value of resistors and capacitors.

39

PC BOARD

AJ AL ANAK AM

(

Component side view

) DVF-K5020

7

FP24692

15

26

R4694

15

JA

8

15

JAA

8

R4695

C4693

R4974

C4978 R4973

R4972

R4693

REF. NO. 20000 SERIES

REF. NO. 20000 SERIES REF. NO. 20000 SERIES

R4965

R4969

C4694

IC4691

184

5

W001

C4696

C4692

W201

W002

D4951

W003

W004

W005

W007

W008

W006

W103

W101

W104

W105

W106

W107

W108

W102

W205

W204

W203

W202

C4695

C4972

C4974

C4968

C4683

C4682

C4681

C4971

C4979

C4969

C4691

IC4671

184

5

IC4953

548

1

IC4952

548

1

IC4951

1

16

8

9

FP24721

1

QR4951

51517

21016

C

B

E

R4963

R4964

C4965

R4966

C4966

R4968

R4967

C4967

C4960

C4980

R4956

C4953

R4955

R4954

C4959

C4958C4957

R4692

C4955

C4973

R4962

R4961

C4961

R4957

R4958

C4956

LB4673

R4677

C4963

R4960

C4962

R4959

R4964

C4970

C4977

D4953

R4976

R4975

R4678

C4678

LB4671

R4673

R4680

C4679

R4679

R4674C4676

C4675

R4681

R4675

C4671

LB4672

C4677

R4676

C4954

C4952

R4953

R4696

R4691

R4952

C4951

ECOH

VR4693

13

R4951

C4975

R4970

R4971

C4976

C4977

MIC2

VR4692

13

MIC1

VR4691

13

MIC1

J4671

MIC2

J4672

POWER

S6411

FP26411

15

26

D4952

MIC VOLUME C.B.A.

MIC JACK C.B.A.

1

4

2

5

1

4

2

5

N

C4680

N

POWER SW C.B.A.

6

5

4

3

2

1

40

Refer to the schematic diagram for the value of resistors and capacitors.

PC BOARD

AO AP ARAQ AS

(

Component side view

) DVF-K5020

ACEGIBDFHJ

Power supply

1

2

3

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indi-

4

cates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading

5

measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

6

7

DV-303/DVF-5020

Y22-8200-10

K LNPRTMOQS

ADSC SECTION : (1/7), SRV SECTION : (2/7),

AVDEC SECTION : (3/7), AUDIO SECTION : (4/7)

FEP SECTION : (5/7), CPU SECTION :(6/7), ODC SECTION : (7/7)

ADSC/module (1/7)

1

2

3

4

CAUTION: For continued safety, replace safety critical components only with manufacturer's recom-

5

mended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending

6

on the measuring instruments used or on the product.

7

DV-303/DVF-5020

Y22-8200-10

UWYAAACVXZABAD

ADSC SECTION : (1/7), SRV SECTION : (2/7), AVDEC SECTION : (3/7), AUDIO SECTION : (4/7) FEP SECTION : (5/7), CPU SECTION :(6/7), ODC SECTION : (7/7)

1

2

3

SRV/module (2/7)

4

5

6

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

7

DV-303/DVF-5020

Y22-8200-10

AE AF AH AJ AL ANAG AI AK AM

AVDEC/module (3/7)

1

2

3

4

5

6

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

7

DV-303/DVF-5020

Y22-8200-10

AO AQ AS AU AWAP AR AT AV AX

AUDIO/module (4/7)

1

2

3

ADSC SECTION : (1/7), SRV SECTION : (2/7),

AVDEC SECTION : (3/7), AUDIO SECTION : (4/7)

FEP SECTION : (5/7), CPU SECTION : (6/7), ODC SECTION : (7/7)

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

4

5

6

7

DV-303/DVF-5020

Y22-8200-10

AY AZ BB BD BF BHBA BC BE BG

ADSC SECTION : (1/7), SRV SECTION : (2/7),

1

FEP/module (5/7)

2

3

FEP SECTION : (5/7), CPU SECTION :(6/7), ODC SECTION : (7/7)

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

AVDEC SECTION : (3/7), AUDIO SECTION : (4/7)

4

5

6

DTA123JK UN5213 2SB1218A 2SB709A 2SB709A-R 2SD1328

UN5212 TC7SH08FU BA5983FM

TC7SHU04FU PCM1716E

UN4213 UPC1093J

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

7

DV-303/DVF-5020

Y22-8200-10

BI BK BM BO BQBJ BL BN BP BR

CPU/module (6/7)

1

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

2

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

3

4

5

6

7

DV-303/DVF-5020

Y22-8200-10

BS BT BV BX BZ CBBU BW BY CA

ADSC SECTION : (1/7), SRV SECTION : (2/7),

AVDEC SECTION : (3/7), AUDIO SECTION : (4/7)

FEP SECTION : (5/7), CPU SECTION :(6/7), ODC SECTION : (7/7)

1

2

3

ODC/module (7/7)

CAUTION: For continued safety, replace safety critical compo-

nents only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

4

5

6

7

DV-303/DVF-5020

Y22-8200-10

CC CE CG CI CKCD CF CH CJ CL

VIDEO OUT/mother (1/3)

1

2

3

VOUT SECTION : (1/3), AO SECTION : (2/3), OP SECTION : (3/3)

4

5

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply

6

circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

7

DV-303/DVF-5020

Y22-8200-10

AUDIO/

mother (2/3)

1

2

3

CM CN CP CR CT CVCO CQ CS CU

VOUT SECTION : (1/3), AO SECTION : (2/3), OP SECTION : (3/3)

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

4

5

6

7

DV-303/DVF-5020

Y22-8200-10

OUT SECTION : (1/3), AO SECTION : (2/3), OP SECTION : (3/3)

CW CY DA DC DECX CZ DB DD DF

OPERATION/mother (3/3)

1

2

3

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

4

5

6

7

DV-303/DVF-5020

Y22-8200-10

Power supply

1

2

3

DG DH DJ DL DN DPDI DK DM DO

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

4

5

6

7

DVF-K5020

Y22-8200-10

DQ DS DU DW DYDR DT DV DX DZ

ADSC/module (1/8)

1

2

3

4

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against

5

risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

6

7

DVF-K5020

Y22-8200-10

EA EB ED EF EH EJEC EE EG EI

SRV/module (2/8)

1

2

3

4

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before

5

6

the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

7

DVF-K5020

Y22-8200-10

EK EM EO EQ ESEL EN EP ER ET

AVDEC/module (3/8)

1

2

3

4

5

6

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same

7

type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

DVF-K5020

Y22-8200-10

EU EV EX EZ FB FDEW EY FA FC

VDAC/module (4/8)

1

2

3

4

5

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

6

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indi- cates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the

7

risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

DVF-K5020

Y22-8200-10

FE FG FI FK FMFF FH FJ FL FN

FEP/module (5/8)

1

2

3

4

5

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the

6

appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

7

DVF-K5020

Y22-8200-10

FO FP FR FT FV FXFQ FS FU FW

CPU/module (6/8)

1

2

3

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

4

5

6

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indi- cates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the

7

risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

DVF-K5020

Y22-8200-10

FY GA GC GE GGFZ GB GD GF GH

CLK/module (7/8)

1

2

3

4

5

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same

6

type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

7

DVF-K5020

Y22-8200-10

GI GJ GL GN GP GRGK GM GO GQ

ODC/module (8/8)

1

2

3

ADSC SECTION : (1/8), SRV SECTION : (2/8), AVDEC SECTION : (3/8), VDAC SECTION : (4/8) FEP SECTION : (5/8), CPU SECTION : (6/8), CLK SECTION : (7/8), ODC SECTION : (8/8)

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

4

5

6

7

DVF-K5020

Y22-8200-10

GS GU GW GY HAGT GV GX GZ HB

Ref. No. 23500-23699 VIDEO-out/mother (1/5)

1

2

3

4

5

6

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

7

DVF-K5020

Y22-8200-10

HC HD HF HH HJ HLHE HG HI HK

Ref. No. 24201-24299 AUDIO-DAC/mother (2/5)

1

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measure-

2

ment value may vary depending on the measuring instruments used or on the product.

3

4

5

6

7

DVF-K5020

Y22-8200-10

HM HO HQ HS HUHN HP HR HT HV

Ref. No. 24301-24499 AUDIO-AC3/mother (3/5)

1

2

3

4

5

6

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

7

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

DVF-K5020

Y22-8200-10

HW HX HZ IB ID IFHY IA IC IE

Ref. No. 24501-24599 Ref. No. 24701-24799 Ref. No. 24901-24949

1

2

3

AUDIO-out/mother (4/5)

4

5

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components.

6

For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

7

DVF-K5020

Y22-8200-10

IG II IK IM IOIH IJ IL IN IP

Ref. No. 26001-26199 OPR&f1-out/mother (5/5)

1

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

2

3

4

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

5

6

7

DVF-K5020

Y22-8200-10

MIC JACK

1

2

3

IQ IR IT IV IX IZIS IU IW IY

CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only

4

with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.

The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product.

5

6

7

DVF-K5020

Y22-8200-10

DV-303/DVF-5020/K5020

EXPLODED VIEW (MECHANISM)

A B

1

2

3

Parts with exploded numbers larger than 700 are not supplied.

93

DV-303/DVF-5020/K5020

EXPLODED VIEW (MECHANISM)

C D

1

2

3

94

Parts with exploded numbers larger than 700 are not supplied.

B1 B1 B2 B3 B4 B4 B5 B6 B7 B8 B9 B9 B11 B12

3x8 3x8 3x8 3x8 3x8 3x8 4x10 3x12 3x20 3x25

2.6x10 3x8 3x10

2.6x10

: : : : : : : : : : : : : :

N09-5183-08 (K1,M) N09-5149-08 (K,Y) N09-5150-08 N09-5150-08 N09-5153-08 (K) N09-5184-08 (Y,M,K1) N09-5185-08 (M) N09-5154-08 N09-5155-08 N09-5156-08 N09-5157-08 (K,K1,Y) N09-5186-08 (M) N09-5158-08 N09-5157-08 (M)

B4x4

B6

B2

P1001

AC IN

B9/B12(M)

B11x2

B6

M TYPE

EXCEPT M TYPE

B7x2

B8x2

B1x2

B8x2

ATTENUA T OR AUDIO OUT PUT

DVF-K5020

DIGITAL

JK4771

OUT PUT COAXIAL

IC4781

OUT PUT OPTICAL

JK4501

AUDIO/ VIDEO OUT PUT

S4501

OUT PUT

VIDEO-S

JK3541

JK3591

COMPONET VIDEO OUT PUT

S6002

PLAY

S6006

FWD SKIP

S6001

PAUSE

S6005

RVS SKIP

S6003

STOP

S6007

OPEN/ CLOSE

S6401

POWER

DL6001

DVF-5020 (Y) / K5020

B3

B5

B9

B12

x2

J4671

MC1

J4672

MC2

VR4961

MC1 VOLUME

MC2 VOLUME

ECHO

VR4962 VR4963

B3x2

B3x5

708

701

740

739

704

706

601

631

636

627

635

703

628

632

612

607

629

612

(17P)

(6P)

(7P)

(17P)

(6P)

632

711

741

610

605

619

632

731

626

618

609

625

602x

4

61

(17P)

634

Parts with exploded numbers larger than 700 are not supplied.

E

F

G

1

2

EXPLODED VIEW (UNIT)

DV-303/DVF-5020/K5020

95

96

DV-303/DVF-5020/K5020

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

ress

New

Parts

Parts No.

Description

Desti-

nation

1

Re-

marks

DV-303:K/DV-303(S):K1/DVF-5020(Y)/DVF-K5020(M)

601 1E ✽ A01-3749-08 TOP COVER VGM1591 KY 601 1E ✽ A01-3754-08 TOP COVER VGM1639 K1M 602 2F ✽ J02-1468-08 LEG VYK5504 605 2E ✽ K27-2389-08 POWER BUTTON VGU8284 KY 605 2E ✽ K27-2400-08 POWER BUTTON VGU8288 K1M

607 2G ✽ J30-1405-08 SPACER VMD3305 609 2E ✽ A29-1088-08 TRAY TOP VYF2637 KY 609 2E ✽ A29-1094-08 TRAY TOP VYF2638 K1M 610 2E ✽ G02-1702-08 EARTH PLATE VMC1501 M 612 2E,1F E35-2561-08 17P FLEX CABLE VWJ1292 M

618 2E ✽ J19-6058-08 HOLDER VGL0812 619 2E ✽ K29-7764-08 VOLUME KNOB VGU8286 M 625 2E ✽ B10-3573-08 FRONT COVER VKW2709 626 2E ✽ A60-1788-08 FRONT PANEL VYP7389 K 626 2E ✽ A60-1821-08 FRONT PANEL VYP7398 M

626 2E ✽ A60-1822-08 FRONT PANEL VYP7451 K1 626 2E ✽ A60-1823-08 FRONT PANEL VYP7392 Y 627 1E ✽ A70-1353-08 REMOTE CONTROL UNIT,VEQ2324 KK1Y 627 1E ✽ A70-1369-08 REMOTE CONTROL UNIT,VEQ2325 M 628 2F ✽ J26-0102-08 MODULE CBA VEP96556B KK1Y

628 2F ✽ J26-0105-08 MODULE CBA VEP96541R M 629 2E ✽ E35-2508-08 LOADING FFC(7P) VWJ1278 631 1E E03-0115-05 PLUG ADAPTER VJP2974 YM 632 2E,1F ✽ E35-2509-08 6P FLEX CABLE VWJ06C9170BB KK1Y 632 2E,1F ✽ E35-2563-08 6P FLEX CABLE VWJ06A0130BB M

634 1E E30-2365-05 DIGITAL CORD VJA1114 635 1E ✽ E30-2937-08 AC CORD VJA1095 KK1 635 1E ✽ E30-2946-08 AC CORD VJA0664 YM 636 1E ✽ E30-2938-08 A/V CORD VJA1062

- B46-0328-03 WARRANTY CARD(BLUE) KK1Y

- B46-0347-03 WARRANTY CARD KK1

- B58-0964-13 CAUTION CARD Y

- B58-0966-13 CAUTION CARD M

- B59-1104-00 SERVICE STATIONS' LIST Y

- ✽ B60-4414-08 OPERATING INSTRUCT,VQT8204 KK1

- ✽ B60-4417-08 OPERATING (EN,ES,TC),VQT8206 M

- ✽ B60-4421-08 OPERATING INST(EN),VQT8205 Y

- ✽ H09-0133-08 ACCEESSORY CASE,VPK1891Z

- ✽ H10-7642-08 CUSHION(L) VPN5241

- ✽ H10-7643-08 CUSHION(R) VPN5242

- ✽ H25-1664-08 POLYETHYLENE BAG,VPF0731

- ✽ H50-3502-08 PACKING CASE VPG0B00 K1

- ✽ H50-3503-08 PACKING CASE VPG0A51 Y

- ✽ H50-3504-08 PACKING CASE VPG0A54 M

- ✽ H50-3582-08 PACKING CASE VPG0A50 K B1 1E ✽ N09-5149-08 SCREW VHD1041 KY

B1 1E ✽ N09-5183-08 SCREW VHD1094 K1M B2 1E ✽ N09-5150-08 SCREW VHD0690 B3 2G ✽ N09-5150-08 SCREW VHD0690 B4 2F ✽ N09-5153-08 SCREW XTV3+8G K

B4 2F ✽ N09-5184-08 SCREW XTV3+8GFZ YMK1 B5 ✽ N09-5185-08 SCREW XTN4+10FFC M B6 1F,1G ✽ N09-5154-08 SCREW XYE3+EF12

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

B7 1F ✽ N09-5155-08 SCREW XTE3+EF20 B8 1F ✽ N09-5156-08 SCREW XYE3+EF25 B9 2E ✽ N09-5157-08 SCREW XTBS26+10J KK1Y B9 2E ✽ N09-5186-08 SCREW XTV3+8J M B11 2F ✽ N09-5158-08 SCREW XTV3+10G

B12 2E ✽ N09-5157-08 SCREW XTBS26+10J M

Add-

ress

Parts

Parts No.

Description

Destination

2

Re-

marks

ELECTRIC PARTS

999 EYF52BC FUSE HOLDER EYF52BC C1003 ✽ C90-3891-08 MF-C 0.068UF J KK1 C1003 ✽ C90-3913-08 MF-C 0.01UF J MY C1005 ✽ C90-3914-08 CERAMIC 470PF J MY C1005 ✽ C90-3915-08 CERAMIC 0.001UF J KK1

C1008 ✽ C90-3914-08 CERAMIC 470PF J MY C1008 ✽ C90-3915-08 CERAMIC 0.001UF J KK1 C1010 ✽ C90-3892-08 MF-C 2200PF J KK1 C1010 ✽ C90-3920-08 CERAMIC 1000P J MY C1011 ✽ C90-3891-08 MF-C 0.068UF J KK1

C1011 ✽ C90-3913-08 MF-C 0.01UF J MY C1018 ✽ C90-3921-08 ELECTRO 68UF 400WV MY C1019 ✽ C90-3870-08 ELECTRO 100UF 250WV KK1 C1021 CK45FB2H103K CERAMIC 0.010UF K C1022 ✽ C90-3871-08 CHIP C 120PF J

C1031 CE04EW1V470M ELECTRO 47UF 35WV C1041 CQ93FMG1H103J MYLAR 0.010UF J C1052 CK45FB1H102K CERAMIC 1000PF K C1053 CE04KW0J331M ELECTRO 330UF 6.3WV C1101 CQ93FMG1H104J MYLAR 0.10UF J

C1111,12 ✽ C90-3872-08 ELECTRO 1800UF 10WV C1114 CE04KW1A222M ELECTRO 2200UF 10WV C1115 ✽ C90-3873-08 CHIP C 0.01UF Z C1116,17 CE04KW1A221M ELECTRO 220UF 10WV C1121 CE04KW0J102M ELECTRO 1000UF 6.3WV

C1131 ✽ C90-3874-08 ELECTRO 150UF 35WV C1133 CE04KW1E330M ELECTRO 33UF 25WV C1141 ✽ C90-3874-08 ELECTRO 150UF 35WV C1143 CE04KW1E330M ELECTRO 33UF 25WV C1151 ✽ C90-3875-08 ELECTRO 270UF 25WV KK1

C1151 ✽ C90-3922-08 ELECTRO 390UF 25WV MY C1153 CE04KW1E221M ELECTRO 220UF 25WV C1154 CE04KW1C221M ELECTRO 220UF 16WV C1161 ✽ C90-3876-08 ELECTRO 82UF 50WV C1171 CE04KW1A331M ELECTRO 330UF 10WV

C2001 CK73EB1A335K CHIP C 3.3UF K C2002-05 CK73GB1C393K CHIP C 0.039UF K C2006 ✽ C90-3923-08 ELECTRO 100UF 6.3WV C2007,08 CK73GB1C104Z CHIP C 0.10UF Z C2009 CC73GCH1H470J CHIP C 47PF J

C2010 CK73GB1C104Z CHIP C 0.10UF Z C2012 CC73GCH1H331J CHIP C 330PF J C2015 CC73GCH1H330J CHIP C 33PF J C2016 CK73GB1C104K CHIP C 0.10UF K C2019-21 CK73GB1C104Z CHIP C 0.10UF Z

C2022 CK73EB1A335K CHIP C 3.3UF K C2023,24 CK73GB1C104Z CHIP C 0.10UF Z

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

PARTS LIST

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

C2025,26 CK73GB1H102K CHIP C 1000PF K C2027 CK73GB1C104Z CHIP C 0.10UF Z C2028 CK73GB1H102K CHIP C 1000PF K C2029 CK73GB1C104Z CHIP C 0.10UF Z C2030 CK73GB1H102K CHIP C 1000PF K

C2031 CK73GB1C104Z CHIP C 0.10UF Z C2032,33 CC73GCH1H821J CHIP C 820PF J C2034 CC73GCH1H271J CHIP C 270PF J C2036 CC73GCH1H471J CHIP C 470PF J C2037 CC73GCH1H331J CHIP C 330PF J

C2038 CC73GCH1H821J CHIP C 820PF J C2040 CK73GB1H392K CHIP C 3900PF K C2041,42 CK73GB1C104Z CHIP C 0.10UF Z C2043,44 CK73GB1C823K CHIP C 0.082UF K C2045 CK73GB1C104K CHIP C 0.10UF K

C2501 ✽ C90-3923-08 ELECTRO 100UF 6.3WV C2502 C90-3885-08 ELECTRO 330UF 6.3WV C2503-05 CK73GB1H103K CHIP C 0.010UF K C2506 CK73GB1C104Z CHIP C 0.10UF Z C2507,08 CK73GB1C104K CHIP C 0.10UF K

C2509 CK73GB1C104Z CHIP C 0.10UF Z C2510-12 CK73GB1C104K CHIP C 0.10UF K C2513,14 CK73GB1C104Z CHIP C 0.10UF Z KK1Y C3001,02 C90-3885-08 ELECTRO 330UF 6.3WV C3003-26 CK73GB1C104Z CHIP C 0.10UF Z

C3031 C90-3885-08 ELECTRO 330UF 6.3WV C3032-34 CK73FB1A105K CHIP C 1.0UF K C3035-43 CK73GB1C104Z CHIP C 0.10UF Z C3044,45 CC73GCH1H220J CHIP C 22PF J C3046 CK73GB1C104Z CHIP C 0.10UF Z KK1Y

C3048 CC73GCH1H220J CHIP C 22PF J C3051-54 CK73GB1C104Z CHIP C 0.10UF Z C3055 ✽ C90-3877-08 CHIP TAN 10UF 10WV C3056 CK73GB1C104Z CHIP C 0.10UF Z C3061-64 CK73GB1C104Z CHIP C 0.10UF Z M

C3065 C90-3877-08 CHIP TAN 10UF 10WV M C3066 CK73GB1C104Z CHIP C 0.10UF Z M C3071 ✽ C90-3877-08 CHIP TAN 10UF 10WV C3072,73 CK73GB1C104Z CHIP C 0.10UF Z C3201 CK73GB1C104Z CHIP C 0.10UF Z

C3202 CK73GB1C104Z CHIP C 0.10UF Z KK1Y C3211 CK73GB1C104Z CHIP C 0.10UF Z C3221 CK73GB1C104Z CHIP C 0.10UF Z KK1Y C3231 CK73GB1C104Z CHIP C 0.10UF Z KK1Y C3271,72 CK73GB1C104Z CHIP C 0.10UF Z M

C3286 ✽ C90-3923-08 ELECTRO 100UF 6.3WV C3500 CE04KW0J471M ELECTRO 470UF 6.3WV C3501 CE04KW0J221M ELECTRO 220UF 6.3WV C3502 CK73FB1H103Z CHIP C 0.010UF Z C3504-06 CK73FB1H103Z CHIP C 0.010UF Z

C3511 CK73FB1H103K CHIP C 0.010UF K C3512-14 CK73FB1H103Z CHIP C 0.010UF Z C3531 CE04KW0J221M ELECTRO 220UF 6.3WV C3532 CK73FB1H103Z CHIP C 0.010UF Z C3533 CE04EW1C470M ELECTRO 47UF 16WV

ress

New

Parts

Parts No.

Description

Desti-

nation

3

Re-

marks

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

C3534 CK73FB1H103K CHIP C 0.010UF K C3535 CE04KW0J221M ELECTRO 220UF 6.3WV C3536 CK73FB1H103Z CHIP C 0.010UF Z C3537 CE04EW1C100M ELECTRO 10UF 16WV C3538 CE04KW0J102M ELECTRO 1000UF 6.3WV

C3539 CE04EW1C100M ELECTRO 10UF 16WV C3540 CE04KW0J102M ELECTRO 1000UF 6.3WV C3541 CK73FB1H103K CHIP C 0.010UF K M C3542 CK73FB1H103K CHIP C 0.010UF K C3549,50 CK73FB1H103Z CHIP C 0.010UF Z

C3551 CE04KW0J221M ELECTRO 220UF 6.3WV KK1Y C3552 CK73FB1H103Z CHIP C 0.010UF Z KK1Y C3554 CE04KW0J471M ELECTRO 470UF 6.3WV KK1Y C3562 CK73FB1H103Z CHIP C 0.010UF Z KK1Y C3572 CK73FB1H103Z CHIP C 0.010UF Z KK1Y

C3581 CE04KW0J221M ELECTRO 220UF 6.3WV KK1Y C3582 CK73FB1H103Z CHIP C 0.010UF Z KK1Y C3583 CE04KW0J471M ELECTRO 470UF 6.3WV KK1Y C3584 CE04EW1C220M ELECTRO 22UF 16WV KK1Y C3585 CE04KW0J471M ELECTRO 470UF 6.3WV KK1Y

C3586 CE04EW1C220M ELECTRO 22UF 16WV KK1Y C3587 CE04KW0J471M ELECTRO 470UF 6.3WV KK1Y C3588 CE04EW1C220M ELECTRO 22UF 16WV KK1Y C3608 CE04EW0J471M ELECTRO 470UF 6.3WV M C3609 CK73FB1H103Z CHIP C 0.010UF Z M

C4201 CK73GB1H104Z CHIP C 0.10UF Z MY C4202,03 CK73GB1C104Z CHIP C 0.10UF Z C4204 CE04KW1C100M ELECTRO 10UF 16WV M C4204 ✽ C90-3877-08 CHIP TAN 10UF 10WV KK1Y C4205 CK73GB1C104Z CHIP C 0.10UF Z

C4206 CE04KW0J102M ELECTRO 1000UF 6.3WV C4207 ✽ C90-3877-08 CHIP TAN 10UF 10WV C4208 CK73GB1C104Z CHIP C 0.10UF Z C4241 CK73GB1C104Z CHIP C 0.10UF Z M C4242 CC73GCH1H220J CHIP C 22PF J KK1Y

C4242 CC73GCH1H390J CHIP C 39PF J M C4251 CK73FB1H104Z CHIP C 0.10UF Z M C4271 CC73FCH1H220J CHIP C 22PF J M C4271 CK73GB1C104Z CHIP C 0.10UF Z KK1Y C4272-74 CC73GCH1H220J CHIP C 22PF J

C4275 CK73FB1H104Z CHIP C 0.10UF Z M C4275-77 CK73GB1C104Z CHIP C 0.10UF Z KK1Y C4276 CC73FCH1H470J CHIP C 47PF J M C4277 CK73FB1H104Z CHIP C 0.10UF Z M C4281 CK73GB1C104Z CHIP C 0.10UF Z

C4301 CE04EW0J470M ELECTRO 47UF 6.3WV C4302 ✽ C90-3878-08 CHIP C 100PF J C4303 CK73FB1H104Z CHIP C 0.10UF Z M C4304 CE04KW1A221M ELECTRO 220UF 10WV C4305 CK73FB1H103Z CHIP C 0.010UF Z

C4306 CK73FB1H104Z CHIP C 0.10UF Z M C4311 CE04EW0J470M ELECTRO 47UF 6.3WV C4312 ✽ C90-3878-08 CHIP C 100PF J C4314 CE04KW1A221M ELECTRO 220UF 10WV C4315 CK73FB1H103Z CHIP C 0.010UF Z

Add-

ress

Parts

Parts No.

Description

nation

Desti-

4

Re-

marks

PARTS LIST

DV-303/DVF-5020/K5020

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

97

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

98

DV-303/DVF-5020/K5020

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

C4451,52 CQ93FMG1H223J MYLAR 0.022UF J M C4461 CK73FB1H102J CHIP C 1000PF J C4462 CC73FCH1H101J CHIP C 100PF J C4463 CK73FB1H104Z CHIP C 0.10UF Z C4464 CE04KW1C470M ELECTRO 47UF 16WV

C4465 CK73FB1H102J CHIP C 1000PF J C4466 CC73FCH1H101J CHIP C 100PF J C4467 CE04KW1C470M ELECTRO 47UF 16WV C4468 CK73FB1H104Z CHIP C 0.10UF Z KK1Y C4501 CK73FB1H102J CHIP C 1000PF J

C4511 CK73FB1H102J CHIP C 1000PF J C4561 CK73FB1H102J CHIP C 1000PF J C4571 CK73FB1H102J CHIP C 1000PF J C4585,86 CK73FB1H104Z CHIP C 0.10UF Z C4587 CK73FB1H104Z CHIP C 0.10UF Z M

C4588 CK73FB1H104Z CHIP C 0.10UF Z C4589 CK73FB1H104Z CHIP C 0.10UF Z M C4591 CE04EW0J101M ELECTRO 100UF 6.3WV C4592 CE04EW1E100M ELECTRO 10UF 25WV C4671 CK73FB1H104Z CHIP C 0.10UF Z M

C4675 CK73FB1H102K CHIP C 1000PF K M C4676 CK73FB1H103Z CHIP C 0.010UF Z M C4677 CC73FCH1H560J CHIP C 56PF J C4678 CK73FB1H102K CHIP C 1000PF K M C4679 CC73FCH1H560J CHIP C 56PF J M

C4680,01 CE04EW1H010M ELECTRO 1.0UF 50WV M C4682,83 CE04EW1C220M ELECTRO 22UF 16WV M C4691 CQ93FM1H823J MYLAR 0.082UF J M C4692 CK73FB1H104Z CHIP C 0.10UF Z M C4693 CK73FB1H680J CHIP C 68PF J M

C4694 CK73FB1H104Z CHIP C 0.10UF Z M C4695,96 CE04EW1C220M ELECTRO 22UF 16WV M C4701,02 CK73FB1H104Z CHIP C 0.10UF Z C4751 CK73FB1H104Z CHIP C 0.10UF Z C4752 CE04EW0J101M ELECTRO 100UF 6.3WV

C4753 CK73FB1H104Z CHIP C 0.10UF Z KK1Y C4761 CC73FCH1H271J CHIP C 270PF J C4763 CK73FB1H104Z CHIP C 0.10UF Z C4764 CE04EW1H4R7M ELECTRO 4.7UF 50WV C4771 CK73FB1H103Z CHIP C 0.010UF Z KK1Y

C4771 CK73FB1H104Z CHIP C 0.10UF Z M C4772 CC73FCH1H470J CHIP C 47PF J KK1Y C4772,73 CC73FCH1H151J CHIP C 150PF J M C4773 CC73FCH1H820J CHIP C 82PF J KK1Y C4774 CK73FB1H102J CHIP C 1000PF J M

C4774 CK73FB1H104Z CHIP C 0.10UF Z KK1Y C4781 CE04EW1H4R7M ELECTRO 4.7UF 50WV C4782 CK73FB1H104Z CHIP C 0.10UF Z C4901 CE04KW1C470M ELECTRO 47UF 16WV C4911 CE04KW1E221M ELECTRO 220UF 25WV

C4912 CE04KW1C470M ELECTRO 47UF 16WV C4951 CK73FB1H103K CHIP C 0.010UF K M C4952 CK73FB1H222K CHIP C 2200PF K M C4953 CK73FB1H223K CHIP C 0.022UF K M C4954,55 CK73FB1H104Z CHIP C 0.10UF Z M

ress

New Parts

Parts No.

Description

Desti-

nation

5

Re-

marks

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

C4956 CK73FB1H472K CHIP C 4700PF K M C4957 CK73FB1H104Z CHIP C 0.10UF Z M C4958,59 CK73FB1H224Z CHIP C 0.22UF Z M C4960 CK73FB1H223K CHIP C 0.022UF K M C4961 CK73FB1H472K CHIP C 4700PF K M

C4962 CK73FB1H104Z CHIP C 0.10UF Z M C4963 CK73FB1H223K CHIP C 0.022UF K M C4964 CK73FB1H104Z CHIP C 0.10UF Z M C4965 CK73FB1H333K CHIP C 0.033UF K M C4966 CK73FB1H103K CHIP C 0.010UF K M

C4967 CK73FB1H222K CHIP C 2200PF K M C4968 CE04EW1H010M ELECTRO 1.0UF 50WV M C4969,70 CE04EW0J470M ELECTRO 47UF 6.3WV M C4971 CE04EW1H010M ELECTRO 1.0UF 50WV M C4972 CE04EW1C100M ELECTRO 10UF 16WV M

C4973,74 CE04EW1A101M ELECTRO 100UF 10WV M C4975 CK73FB1H683K CHIP C 0.068UF K M C4976 CC73FCH1H390J CHIP C 39PF J M C4977,78 CK73FB1H104Z CHIP C 0.10UF Z M C4979 CE04EW1H4R7M ELECTRO 4.7UF 50WV M

C4980 CE04EW1H010M ELECTRO 1.0UF 50WV M C5201 ✽ C90-3924-08 ELECTRO 47UF 6.3WV C5202 ✽ C90-3877-08 CHIP TAN 10UF 10WV C5203-06 CK73GB1C104K CHIP C 0.10UF K C5207 ✽ C90-3925-08 ELECTRO 10UF 16WV

C5208 C90-3879-08 CHIP TAN 10UF 16WV C5209 CC73GCH1H101J CHIP C 100PF J C5210 CK73GB1C104K CHIP C 0.10UF K C5211 CC73GCH1H560J CHIP C 56PF J C5212 CC73GCH1H101J CHIP C 100PF J

C5213 CK73GB1C104K CHIP C 0.10UF K C5214 ✽ C90-3880-08 CHIP C 0.18UF K C5215 CK73GB1C104K CHIP C 0.10UF K C5216 CK73GB1C104Z CHIP C 0.10UF Z C5217 CK73GB1A224K CHIP C 0.22UF K

C5218,19 CK73GB1C104K CHIP C 0.10UF K C5220 CK73GB1H222K CHIP C 2200PF K C5221 CK73GB1H392K CHIP C 3900PF K C5222 CK73GB1C104K CHIP C 0.10UF K C5223 CC73GCH1H820J CHIP C 82PF J

C5224 CK73GB1C104K CHIP C 0.10UF K C5225 CK73GB1C104Z CHIP C 0.10UF Z C5226 CK73GB1C104K CHIP C 0.10UF K C5227,28 CK73GB1H104Z CHIP C 0.10UF Z C5229 ✽ C90-3881-08 CHIP C 220PF J

C5230 CK73GB1C104K CHIP C 0.10UF K C5231 CK73EB1A335K CHIP C 3.3UF K C5232 ✽ C90-3882-08 ELECTRO 33UF 6.3WV C5233 ✽ C90-3883-08 CHIP C 0.33UF K C5234 ✽ C90-3882-08 ELECTRO 33UF 6.3WV

C5235 CK73EB1A335K CHIP C 3.3UF K C5236 CK73GB1C104K CHIP C 0.10UF K C5237 CC73GCH1H102K CHIP C 1000PF K C5238 CK73GB1A224K CHIP C 0.22UF K C5239-41 CK73GB1C104Z CHIP C 0.10UF Z

Add-

ress

Parts

Parts No.

Description

Desti-

nation

6

Re-

marks

PARTS LIST

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

C5242 CC73GCH1H121J CHIP C 120PF J C5243,44 CC73GCH1H221J CHIP C 220PF J C5245,46 CK73GB1C104K CHIP C 0.10UF K C5247,48 CK73GB1C104Z CHIP C 0.10UF Z C5249 ✽ C90-3884-08 CHIP C 680PF J

C5250-52 CK73GB1C104Z CHIP C 0.10UF Z KK1Y C6001 CE04EW0J331M ELECTRO 330UF 6.3WV C6002 CK73FB1H104Z CHIP C 0.10UF Z C6003 CE04EW1H100M ELECTRO 10UF 50WV M C6003 CE04EW1H330M ELECTRO 33UF 50WV KK1Y

C6004 CK73FB1H104Z CHIP C 0.10UF Z C6005 CE04EW0J470M ELECTRO 47UF 6.3WV C6006 CK73FB1H104Z CHIP C 0.10UF Z C6007 CK73FB1H104Z CHIP C 0.10UF Z M C6010 CK73FB1H104Z CHIP C 0.10UF Z M

C6011 CC73FCH1H221J CHIP C 220PF J C6013,14 CK73FB1H104Z CHIP C 0.10UF Z C6015 CE04EW0J331M ELECTRO 330UF 6.3WV KK1Y C6021 CK73FB1H103Z CHIP C 0.010UF Z C6041-43 CK73FB1H103Z CHIP C 0.010UF Z

C6044,45 CK73FB1H104Z CHIP C 0.10UF Z C6201,02 CK73GB1C104Z CHIP C 0.10UF Z C6203 C90-3882-08 ELECTRO 33UF 6.3WV C6204-07 CK73GB1C104Z CHIP C 0.10UF Z C6251 CK73GB1C104Z CHIP C 0.10UF Z

C6252 C90-3882-08 ELECTRO 33UF 6.3WV C6253 ✽ C90-3923-08 ELECTRO 100UF 6.3WV C6254 ✽ C90-3885-08 ELECTRO 330UF 6.3WV C6255 CK73GB1H103K CHIP C 0.010UF K C6301 CC73GCH1H101J CHIP C 100PF J

C6302 CK73GB1C104K CHIP C 0.10UF K C6303,04 CK73GB1C104Z CHIP C 0.10UF Z C6501 C90-3882-08 ELECTRO 33UF 6.3WV C6502,03 CK73GB1C104Z CHIP C 0.10UF Z C6504,05 CK73FB1H104Z CHIP C 0.10UF Z M

C6504,05 ✽ C90-3886-08 CHIP C 1.0UF Z KK1Y C6506 ✽ C90-3877-08 CHIP TAN 10UF 10WV C6507 CK73GB1C104Z CHIP C 0.10UF Z C6508 CK73GB1C104Z CHIP C 0.10UF Z KK1Y C6511 CK73GB1C104Z CHIP C 0.10UF Z

C6512 ✽ C90-3877-08 CHIP TAN 10UF 10WV C6513 CK73GB1C104Z CHIP C 0.10UF Z C6514 ✽ C90-3882-08 ELECTRO 33UF 6.3WV C6521,22 CK73GB1C104Z CHIP C 0.10UF Z C6541,42 CC73GCH1H120J CHIP C 12PF J

C6544 CK73GB1C104K CHIP C 0.10UF K C6564,65 CK73GB1C104Z CHIP C 0.10UF Z C6584,85 CK73GB1C104Z CHIP C 0.10UF Z C6601 CK73GB1C104Z CHIP C 0.10UF Z C7001,02 ✽ C90-3923-08 ELECTRO 100UF 6.3WV

C7003-19 ✽ C90-3887-08 CHIP C 0.1UF Z C7020 ✽ C90-3888-08 CHIP C 0.01UF Z C7301,02 CK73GB1C104Z CHIP C 0.10UF Z D1001 ✽ ENC221D5ATRB DIODE ENC221D5ATRB KK1 D1001 ✽ ENC471D5ATRB DIODE ENC471D5ATRB MY

ress

New Parts

Parts No.

Description

Desti-

nation

7

Re-

marks

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

D1002 ✽ ENC471D5ATUB DIODE ENC471D5ATUB KK1 D1011 ✽ S1WBA80 DIODE D1021 ✽ AP01C DIODE D1022 ✽ RD100E ZENER DIODE D1031 AU01Z DIODE

D1032 ✽ MA7300B DIODE D1041 MA165 DIODE D1042 MA165 DIODE KK1 D1051 MA700 DIODE D1052 ✽ MA4200H DIODE

D1111 ✽ MA7D49 DIODE KK1 D1111 ✽ MA7D50 DIODE M D1111 ✽ MA7D55 DIODE Y D1121 11ES1 DIODE D1131 ✽ 11EQS06 DIODE KK1

D1131 11EQS10 DIODE MY D1141 ✽ 11EQS06 DIODE KK1 D1141 11EQS10 DIODE MY D1151,52 ✽ 11EQS06 DIODE KK1 D1151,52 11EQS10 DIODE MY

D1161 AU01Z DIODE D1162 ✽ MA4030 DIODE MY D1162 ✽ MA4030M DIODE KK1 D1171 ✽ AK04 DIODE D3001 ✽ MA8030-H DIODE

D3002 MA111 DIODE D3071 MA111 DIODE D4301 MA152WA DIODE M D4591 1SS355 DIODE D4592 MA3047M ZENER DIODE

D4593 1SS355 DIODE D4594 ✽ MA152A DIODE KK1Y D4594 MA152K DIODE M D4595 MA152WA DIODE D4596 ✽ MA153A DIODE

D4597 1SS355 DIODE D4901 ✽ AK04WS DIODE D4951,52 MA152A DIODE M D4953 MA3047M ZENER DIODE M D6001 ✽ AK04WS DIODE KK1Y

D6002-04 1SS355 DIODE D6013,14 ✽ LN28RCPL DIODE D6311 MA728 DIODE D6511 MA111 DIODE DL6001 ✽ VSL0519 DISPLAY TUBE

DZ1001 ✽ VSQ1003 SURGE ABSORBER 2.7KV KK1 F1001 ✽ F50-0165-08 FUSE VSF0248C16 KK1 F1001 ✽ F50-0167-08 FUSE XBA2C16TB0 MY FL3501 ✽ B11-1502-08 FILTER ELB4K163B FL3511 ✽ B11-1503-08 FILTER ELB4K164B

FL3561 ✽ B11-1504-08 FILTER ELB4L182B KK1Y FL6251-54 L92-0087-08 FILTER ELKE103FA FP2511 E40-8545-08 CONNECTOR 7P VJS4241B007W FP2601 E40-8545-08 CONNECTOR 7P VJS4241B007W FP4692 ✽ E40-8547-08 CONNECTOR 6P VJS3537A006G M

Add-

ress

Parts

Parts No.

Description

Desti-

nation

8

Re-

marks

PARTS LIST

DV-303/DVF-5020/K5020

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

99

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

100

DV-303/DVF-5020/K5020

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

FP4701 ✽ E40-8591-08 CONNECTOR 17P VJS3537A017G M FP4721 ✽ E40-8591-08 CONNECTOR 17P VJS3537A017G M FP6002 ✽ E40-8546-08 CONNECTOR 6P VJS3537B006G KK1Y FP6401 ✽ E40-8547-08 CONNECTOR 6P VJS3537A006G KK1Y FP6411 ✽ E40-8547-08 CONNECTOR 6P VJS3537A006G M

IC1021 ✽ STRM6559LF IC MY IC1021 ✽ STRM6559LF14 IC KK1 IC1101 UPC1093J IC(REGULATOR) IC1121 ✽ PQ3RD13 IC IC1151 ✽ SI-3090FLF11 IC

IC2001 ✽ MN67705EA IC IC2501 ✽ AN8485SB IC IC2511 BA5983FM IC(ANALOGUE IC) IC3001 ✽ MN677511DD IC K1Y IC3001 ✽ MN677511DE IC KM

IC3051 MNX7160BT1 IC IC3061 ✽ HM5241605T12 IC M IC3071 ✽ PQ1R33 IC IC3531 ✽ AN3581S IC IC3581 ✽ BA7660FS IC KK1Y

IC4201 PCM1716E IC(DAC) KK1Y IC4201 ✽ PCM1734UB IC(DAC) M IC4241 TC7ST04FU IC M IC4251 ✽ BU2092F IC M IC4266 ✽ TC74HCT7007A IC M

IC4271-73 ✽ TC7ST08FU IC KK1Y IC4306 NJM4580M IC IC4461 NJM4580M IC IC4671 NJM4580M IC M IC4691 NJM4580M IC M

IC4751 TC7W04F IC(INVERTER) M IC4751 TC7W08F IC KK1Y IC4752 ✽ AHCT1G08DBV IC KK1Y IC4781 ✽ W02-2736-08 OPTICAL RECEIVING,T0TX178A IC4901 ✽ PQ09DZ1U IC

IC4951 ✽ M65850FP IC M IC4952,53 NJM4558M IC(OP AMP X2) M IC5201 ✽ RN5RZ20BA-TR IC KK1Y IC5201 RN5RZ33BA IC M IC5202 ✽ AN8706FHQ IC

IC6001 ✽ MN1872423CE IC IC6002 ✽ PST7040-MT IC M IC6002 ✽ S80840ANNP IC KK1Y IC6003 ✽ PNA4611M02VT IR RECEIVER UNIT IC6004,05 ✽ AHCT1G08DBV IC

IC6201 ✽ MN102L25DFA IC IC6301 ✽ PST596JNR IC IC6302 ✽ JZS0649462C IC JZS0649462C K IC6302 ✽ JZS0649497C IC K1MY IC6303 ✽ AT25020NS127 IC K1MY

IC6303 ✽ X25020S-2R7 IC K IC6501 ✽ BU2185F IC IC6511 ✽ PQ1R33 IC IC6521 ✽ TC7WH157FU IC IC6522 TC7SHU04FU IC(INVERTER) KK1Y

ress

New

Parts

Parts No.

Description

Desti-

nation

9

Re-

marks

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

IC6522 TC7WH74FU IC M IC6542 ✽ AHC1GU04HDCK IC IC6562 ✽ AHC1GU04HDCK IC IC6563 TC7WH74FU IC IC6582 ✽ AHC1GU04HDCK IC

IC6583 TC7WH74FU IC IC7001 ✽ MN103007BGA IC IC7301 TC7SH08FU IC(2ch AND GATE) IC7302 ✽ TC7SH32FU IC J4672,73 ✽ E11-0912-08 MIC JACK VJJ0584 M

JK3541 ✽ E40-8534-08 Y/C CONNECTOR-1,VJJ0544 JK3591 ✽ E63-1133-08 PIN JACK (3P) VJJ0598 KK1Y JK4501 ✽ E63-1134-08 RCA JACK (6P) VJJ0644 JK4771 ✽ E63-1135-08 PIN JACK (1P) VJJ0537-B KM JK4771 ✽ E63-1152-08 PIN JACK (1P) VJJ0537 K1Y

K3023 RK73GB1J000J CHIP R 0.0 J 1/16W KK1Y K3201 RK73GB1J000J CHIP R 0.0 J 1/16W M K3203 RK73GB1J000J CHIP R 0.0 J 1/16W M K4201 RK73FB2A000J CHIP R 0.0 J 1/10W M K4201-03 RK73GB1J000J CHIP R 0.0 J 1/16W KK1Y

K4232 RK73FB2A000J CHIP R 0.0 J 1/10W M K4241 RK73FB2A000J CHIP R 0.0 J 1/10W M K4591 RK73FB2A000J CHIP R 0.0 J 1/10W KK1Y K5201-05 RK73GB1J000J CHIP R 0.0 J 1/16W K6003 RK73FB2A000J CHIP R 0.0 J 1/10W

K6008 RK73FB2A000J CHIP R 0.0 J 1/10W K6009 RK73FB2A000J CHIP R 0.0 J 1/10W KK1Y K6010 RK73FB2A000J CHIP R 0.0 J 1/10W M K6021,22 RK73FB2A000J CHIP R 0.0 J 1/10W K6541,2 RK73GB1J000J CHIP R 0.0 J 1/16W M

K7002 RK73GB1J000J CHIP R 0.0 J 1/16W M L1001,02 ✽ L79-1257-08 LINE FILTER ELF15N005A L1111 ✽ L90-0332-08 COIL VLQ0611K100 KK1 L1111 ✽ L90-0349-08 COIL VLQ0655K100 MY L1112 ✽ L33-0595-08 INDUCTOR ELELN100KA

L1131 ✽ L90-0333-08 COIL VLQEL05S330K L1141 ✽ L90-0333-08 COIL VLQEL05S330K L1151 ✽ L90-0334-08 COIL VLQ0611K220 KK1 L1151 ✽ L90-0350-08 COIL VLQ0655K220 MY L2001,02 L33-0572-08 COIL VLQ0779K100 M

L2001,02 ✽ L90-0335-08 COIL ELJFA100KB KK1Y L2501 R90-1308-08 CHIP R 0.0 J 1/4W L3001 R90-1308-08 CHIP R 0.0 J 1/4W L3281 L33-0572-08 COIL VLQ0779K100 M L3281 ✽ L90-0335-08 COIL ELJFA100KB KK1Y

L3501 ✽ L33-0596-08 INDUCTOR ELESE220JA KK1Y L3501 ✽ L90-0336-08 INDUCTOR VLQEL05S220J M L3531,32 ✽ L33-0596-08 INDUCTOR ELESE220JA KK1Y L3531,32 ✽ L90-0336-08 INDUCTOR VLQEL05S220J M L3551 ✽ L90-0336-08 COIL VLQEL05S220J KK1Y

L3581 ✽ L33-0596-08 INDUCTOR ELESE220JA KK1Y L4201 ✽ L90-0337-08 COIL ELJFA220KB KK1Y L4201 ✽ L90-0351-08 COIL VLQEL05S101J M L4761 ✽ L90-0338-08 COIL ELJNDR10JF L4781 ✽ L90-0336-08 COIL VLQEL05S220J

Add-

ress

Parts

Parts No.

Description

nation

Desti-

0

Re-

marks

PARTS LIST

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

L5201,02 L33-0572-08 COIL VLQ0779K100 M L5201,02 ✽ L90-0335-08 COIL ELJFA100KB KK1Y L6001 ✽ L33-0597-08 INDUCTOR ELESE101JA KK1Y L6001 ✽ L90-0351-08 COIL VLQEL05S101J M L6002 ✽ L33-0598-08 INDUCTOR ELESE221JA KK1Y

L6002 ✽ L90-0352-08 COIL VLQEL05S221J M L6003 ✽ L90-0351-08 COIL VLQEL05S101J M L6004 ✽ L90-0353-08 COIL VLQEL05S470J M L6005 ✽ L90-0351-08 COIL VLQEL05S101J M L6006,07 ✽ L90-0353-08 COIL VLQEL05S470J M

L6008 ✽ L90-0351-08 COIL VLQEL05S101J M L6201 R90-1308-08 CHIP R 0.0 J 1/4W L6501,02 ✽ L90-0337-08 COIL ELJFA220KB L7001 L33-0572-08 COIL VLQ0779K100 M L7001 ✽ L90-0335-08 COIL ELJFA100KB KK1Y

L7002 R90-1308-08 CHIP R 0.0 J 1/4W LB1021,22 ✽ L90-0339-08 COIL VLP0083 LB1024 ✽ L90-0340-08 COIL VLP0056 LB2501-08 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB2509-13 ✽ L90-0342-08 COIL JALBK2HS470T

LB2514,15 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB2516 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T M LB2517 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB2518-21 ✽ L90-0342-08 COIL JALBK2HS470T LB3001 L92-0084-08 COIL VLP0155 M

LB3201,02 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB3203-05 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T KK1Y LB3206-09 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T M LB3543-46 ✽ L90-0343-08 COIL VLP0145 LB3591-93 ✽ L90-0343-08 COIL VLP0145 KK1Y

LB4001-03 L92-0084-08 COIL VLP0155 M LB4001-04 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T KK1Y LB4006,07 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T M LB4008 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB4010,11 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T

LB4012 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T KK1Y LB4013,14 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB4016-19 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T M LB4201 RK73GB1J000J CHIP R 0.0 J 1/16W KK1Y LB4241 ✽ L90-0354-08 COIL VLP0153 M

LB4271 L92-0085-08 COIL VLP0157 KK1Y LB4501 ✽ L90-0343-08 COIL VLP0145 LB4511 ✽ L90-0343-08 COIL VLP0145 LB4561 ✽ L90-0343-08 COIL VLP0145 LB4571 ✽ L90-0343-08 COIL VLP0145

LB4672,73 ✽ L90-0343-08 COIL VLP0145 M LB4771,72 ✽ L90-0345-08 CHIP BEAD VLF1148A121 LB5201 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T M LB5201 RK73GB1J000J CHIP R 0.0 J 1/16W KK1Y LB5202 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T

LB5203 ✽ L90-0342-08 COIL JALBK2HS470T LB5204-10 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB5211 ✽ L90-0342-08 COIL JALBK2HS470T LB5212-14 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB5215 ✽ L90-0342-08 COIL JALBK2HS470T

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

101

ress

New

Parts

Parts No.

Description

Desti-

nation

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

!

Re-

marks

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

LB5216 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB5217 ✽ L90-0342-08 COIL JALBK2HS470T LB5218 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB5219 ✽ L90-0342-08 COIL JALBK2HS470T LB6011-16 ✽ L90-0354-08 CHIP VLP0153 M

LB6213 L92-0084-08 COIL VLP0155 M LB6213 L92-0085-08 COIL VLP0157 KK1Y LB6501,02 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB6504 L92-0084-08 COIL VLP0155 M LB6504 L92-0085-08 COIL VLP0157 KK1Y

LB6511 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB6521 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB6522 L92-0084-08 COIL VLP0155 M LB6522 L92-0085-08 COIL VLP0157 KK1Y LB6523 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T

LB6525 L92-0085-08 COIL VLP0157 KK1Y LB6525,26 L92-0084-08 COIL VLP0155 M LB6542 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB6543 L92-0084-08 COIL VLP0155 M LB6543 L92-0085-08 COIL VLP0157 KK1Y

LB6562 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB6563,4 L92-0085-08 COIL VLP0157 KK1Y LB6563,64 L92-0084-08 COIL VLP0155 M LB6565 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB6582 L92-0084-08 COIL VLP0155 M

LB6582 L92-0085-08 COIL VLP0157 KK1Y LB6583 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T LB6584 L92-0084-08 COIL VLP0155 M LB6584 L92-0085-08 COIL VLP0157 KK1Y LB6585 ✽ L90-0341-08 CHIP INDUCTOR VLP0323A601T

LB6586 L92-0084-08 COIL VLP0155 M LB6586 L92-0085-08 COIL VLP0157 KK1Y P1001 ✽ E40-8535-08 CONNECTOR (FL) VJS2986 KK1 P1001 ✽ E40-8593-08 CONNECTOR (FL) VJS3166 MY PF2501 ✽ E40-8590-08 CONNECTOR 17P VJS4241B017W

PF5201 ✽ E40-8592-08 CONNECTOR 21P VJS3913A021 PP1101 ✽ E40-8536-08 CONNECTOR (ML)18P,VJP4223E018B

PP3201 ✽ E40-8537-08 CONNECTOR (ML)22P,VJP4284A022B KK1Y PP3201 ✽ E40-8594-08 CONNECTOR (ML)26P,VJP4222E026B M PP4201 ✽ E40-8537-08 CONNECTOR (ML)22P,VJP4284A022B KK1Y

PP4201 ✽ E40-8594-08 CONNECTOR (ML)26P,VJP4222E026B M PR1161 ✽ F09-0147-08 IC PROTECTOR VSF0015A025 PR1171 ✽ F50-0163-08 IC PROTECTOR VSF0015A10 PR4911 ✽ F50-0163-08 IC PROTECTOR VSF0015A10 PS1101 ✽ E40-8538-08 CONNECTOR (FL)18P,VJS4223A018T K

PS1101 ✽ E40-8596-08 CONNECTOR (FL)18P,VJS4223A018 K1MY PS3201 ✽ E40-8539-08 CONNECTOR (FL)22P,VJS4222C022B KK1Y PS3201 ✽ E40-8597-08 CONNECTOR (FL)26P,VJS4222A026B M PS4201 ✽ E40-8539-08 CONNECTOR (FL)22P,VJS4222C022B KK1Y PS4201 ✽ E40-8597-08 CONNECTOR (FL)26P,VJS4222A026B M

PS6201 ✽ E40-8540-08 CONNECTOR (FL)10P,VJS2961A010 Q1041 ✽ PS2561L1 PHOTO COUPLER PS2561L1 MY Q1041 ✽ T95-0170-08 PHOTO COUPLER PS2501-1H KK1 Q1111 ✽ 2SJ525 TRANSISTOR Q3201 2SB1218A TRANSISTOR

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

Add-

ress

Parts

Parts No.

Description

Desti-

nation

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

@

Re-

marks

PARTS LIST

DV-303/DVF-5020/K5020

102

DV-303/DVF-5020/K5020

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

Q3211 2SB1218A TRANSISTOR Q3221 2SB1218A TRANSISTOR KK1Y Q3231 2SB1218A TRANSISTOR KK1Y Q3501 2SB709A TRANSISTOR Q3502 2SD601A TRANSISTOR

Q3503 2SB709A TRANSISTRR Q3511 2SB709A TRANSISTOR Q3512 2SD601A TRANSISTOR Q3513 2SB709A TRANSISTOR Q3561 2SD601A TRANSISTOR KK1Y

Q3571 2SD601A TRANSISTOR KK1Y Q3603 ✽ 2SA1022-B TRANSISTOR M Q4301 2SD1328 TRANSISTOR M Q4303 ✽ 2SJ498CTA TRANSISTOR M Q4311 2SD1328 TRANSISTOR M

Q4313 ✽ 2SJ498CTA TRANSISTOR M Q4501 2SD1328 TRANSISTOR Q4505 2SD601A TRANSISTOR M Q4511 2SD1328 TRANSISTOR Q4515 2SD601A TRANSISTRR M

Q4561 2SD1328 TRANSISTOR Q4562 2SD601A TRANSISTOR M Q4571 2SD1328 TRANSISTOR Q4572 2SD601A TRANSISTOR M Q4901 2SB709A-R TRANSISTOR

Q4911 2SB1434 TRANSISTOR Q4912 ✽ 2SB1320A-R TRANSISTOR Q4913 2SD601A TRANSISTOR Q5201 2SB1115-T TRANSISTOR Q6009 ✽ 2SD1996-S TRANSISTOR

QR1111 UN4213 TRANSISTOR-RESISTOR QR2001 UN5213 TRANSISTOR-RESISTOR QR2501,02 ✽ XP1213 TRANSISTOR-RESISTOR QR2503 UN5213 TRANSISTOR-RESISTOR QR3581 UN2212 TRANSISTOR-RESISTOR KK1Y

QR4302 UN2111 TRANSISTOR-RESISTOR M QR4303 UN2212 TRANSISTOR-RESISTOR M QR4311 UN2212 TRANSISTOR-RESISTOR M QR4501 UN2111 TRANSISTOR-RESISTOR M QR4591 UN2211 TRANSISTOR-RSEISTOR

QR4592 ✽ UN2115 TRANSISTOR-RESISTOR QR4593 UN2211 TRANSISTOR-RESISTOR QR4594,95 UN2111 TRANSISTOR-RESISTOR QR4951 UN2211 TRANSISTOR-RESISTOR M QR5201,02 UN5212 TRANSISTOR-RESISTOR

QR5203 UN5112 TRANSISTOR-RESISTOR QR6002,03 DTA123JK TRANSISTOR-RESISTOR QR6004 UN2212 TRANSISTOR-RESISTOR QR6008 UN2111 TRANSISTOR-RESISTOR QR6311 UN5212 TRANSISTOR-RESISTOR

R1001 ✽ R92-1929-08 RD 6.8M K 1/2W KK1 R1002 RD14BB2H334K RD 330K K 1/2W MY R1021 ✽ R92-1930-08 METAL FI 39K J 1W R1023 ✽ R92-1931-08 METAL FI 0.82 J 1W R1033 RD14BB2H100J RD 10 J 1/2W

ress

New

Parts

Parts No.

Description

Desti-

nation

#

Re-

marks

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

R1055 ✽ R92-1932-08 RD 3.9M J 1/2W R1056 RD14BB2H475J RD 4.7M J 1/2W R2001 RK73GB1J103J CHIP R 10K J 1/16W R2003 RK73GB1J223J CHIP R 22K J 1/16W R2004 RK73GB1J123J CHIP R 12K J 1/16W

R2005 RK73GB1J183J CHIP R 18K J 1/16W R2006 RK73GB1J822J CHIP R 8.2K J 1/16W R2008-10 RK73GB1J473J CHIP R 47K J 1/16W R2011 ✽ R90-0996-08 RADDER RESISTOR,EXBV4V473J M R2012 RK73GB1J472J CHIP R 4.7K J 1/16W

R2014 RK73GB1J472J CHIP R 4.7K J 1/16W R2016 RK73GB1J102J CHIP R 1.0K J 1/16W R2018 ✽ R90-1307-08 RADDER RESISTOR,EXBV8VR000 M R2019 RK73GB1J000J CHIP R 0.0 J 1/16W M R2019 RK73GB1J331J CHIP R 330 J 1/16W KK1Y

R2020-23 RK73GB1J103J CHIP R 10K J 1/16W R2024 RK73GB1J333J CHIP R 33K J 1/16W R2025 RK73GB1J223J CHIP R 22K J 1/16W R2026 RK73GB1J000J CHIP R 0.0 J 1/16W R2027 RK73GB1J123J CHIP R 12K J 1/16W

R2028 RK73GB1J473J CHIP R 47K J 1/16W R2029,30 RK73GB1J103J CHIP R 10K J 1/16W R2031 RK73GB1J683J CHIP R 68K J 1/16W R2032 RK73GB1J103J CHIP R 10K J 1/16W R2033 RK73GB1J000J CHIP R 0.0 J 1/16W

R2034 RK73GB1J103J CHIP R 10K J 1/16W R2035 RK73GB1J333J CHIP R 33K J 1/16W R2036,37 RK73GB1J103J CHIP R 10K J 1/16W R2038 RK73GB1J683J CHIP R 68K J 1/16W R2039 RK73GB1J362J CHIP R 3.6K J 1/16W

R2501 RK73GB1J473J CHIP R 47K J 1/16W R2502,03 RK73GB1J183J CHIP R 18K J 1/16W R2504-06 RK73GB1J103J CHIP R 10K J 1/16W R2507,08 RK73GB1J123J CHIP R 12K J 1/16W R2509 RK73GB1J273J CHIP R 27K J 1/16W

R2510,11 RK73GB1J271J CHIP R 270 J 1/16W R2512 RK73GB1J273J CHIP R 27K J 1/16W R2513 RK73GB1J103J CHIP R 10K J 1/16W R2515 ✽ R92-1933-08 RD 0.39 J 1/4W R2516,17 RK73GB1J123J CHIP R 12K J 1/16W

R2518,19 RK73GB1J243J CHIP R 24K J 1/16W R2520 RK73GB1J562J CHIP R 5.6K J 1/16W R2521 RK73GB1J563J CHIP R 56K J 1/16W R2522-24 RK73GB1J103J CHIP R 10K J 1/16W R3001 RK73GB1J220J CHIP R 22 J 1/16W

R3002 RK73GB1J000J CHIP R 0.0 J 1/16W R3003 RK73GB1J392J CHIP R 3.9K J 1/16W R3005 RK73GB1J103J CHIP R 10K J 1/16W R3006 RK73GB1J473J CHIP R 47K J 1/16W R3008 RK73GB1J473J CHIP R 47K J 1/16W

R3009,10 RK73GB1J221J CHIP R 220 J 1/16W R3013 RK73GB1J221J CHIP R 220 J 1/16W R3031,32 RK73GB1J752J CHIP R 7.5K J 1/16W R3033 RK73GB1J684J CHIP R 680K J 1/16W M R3033 RK73GB1J752J CHIP R 7.5K J 1/16W KK1Y

Add-

ress

Parts

Parts No.

Description

Desti-

nation

$

Re-

marks

PARTS LIST

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

R3035,36 RK73GB1J102J CHIP R 1.0K J 1/16W R3037,38 RK73GB1J102J CHIP R 1.0K J 1/16W M R3039,40 RK73GB1J102J CHIP R 1.0K J 1/16W M R3041,42 RK73GB1J102J CHIP R 1.0K J 1/16W KK1Y R3201 RK73GB1J750J CHIP R 75 J 1/16W

R3202 RK73GB1J330J CHIP R 33 J 1/16W R3203 RK73GB1J102J CHIP R 1.0K J 1/16W R3211 RK73GB1J750J CHIP R 75 J 1/16W R3212 RK73GB1J330J CHIP R 33 J 1/16W R3213 RK73GB1J102J CHIP R 1.0K J 1/16W

R3221 RK73GB1J750J CHIP R 75 J 1/16W KK1Y R3222 RK73GB1J330J CHIP R 33 J 1/16W KK1Y R3223 RK73GB1J102J CHIP R 1.0K J 1/16W KK1Y R3232 RK73GB1J330J CHIP R 33 J 1/16W KK1Y R3233 RK73GB1J102J CHIP R 1.0K J 1/16W KK1Y

R3501 RK73FB2A561J CHIP R 560 J 1/10W R3502 RK73FB2A103J CHIP R 10K J 1/10W R3503 RK73FB2A101J CHIP R 100 J 1/10W R3504 RK73FB2A222J CHIP R 2.2K J 1/10W R3505 RK73FB2A330J CHIP R 33 J 1/10W

R3506 RK73FB2A182J CHIP R 1.8K J 1/10W R3507 RK73FB2A330J CHIP R 33 J 1/10W R3508 RK73FB2A222J CHIP R 2.2K J 1/10W R3511 RK73FB2A561J CHIP R 560 J 1/10W R3512 RK73FB2A272J CHIP R 2.7K J 1/10W

R3514,15 RK73FB2A223J CHIP R 22K J 1/10W R3516 RK73FB2A222J CHIP R 2.2K J 1/10W R3517 RK73FB2A330J CHIP R 33 J 1/10W R3518 RK73FB2A182J CHIP R 1.8K J 1/10W KK1Y R3518 RK73FB2A331J CHIP R 330 J 1/10W M

R3519 RK73FB2A330J CHIP R 33 J 1/10W R3520 RK73FB2A222J CHIP R 2.2K J 1/10W R3531-33 RK73FB2A102J CHIP R 1.0K J 1/10W R3534 RK73FB2A471J CHIP R 470 J 1/10W R3535 RK73FB2A103J CHIP R 10K J 1/10W M

R3543,44 ✽ R92-1934-08 CHIP R 71.5 J 1/10W R3545,46 RK73FB2A750J CHIP R 75 J 1/10W R3555 RK73FB2A000J CHIP R 0.0 J 1/10W KK1Y R3556 RK73FB2A333J CHIP R 33K J 1/10W KK1Y R3557 RK73FB2A682J CHIP R 6.8K J 1/10W KK1Y

R3561 RK73FB2A561J CHIP R 560 J 1/10W KK1Y R3562 RK73FB2A183J CHIP R 18K J 1/10W KK1Y R3563 RK73FB2A471J CHIP R 470 J 1/10W KK1Y R3564 RK73FB2A223J CHIP R 22K J 1/10W KK1Y R3565 RK73FB2A331J CHIP R 330 J 1/10W KK1Y

R3566 RK73FB2A000J CHIP R 0.0 J 1/10W KK1Y R3571 RK73FB2A561J CHIP R 560 J 1/10W KK1Y R3572 RK73FB2A183J CHIP R 18K J 1/10W KK1Y R3573 RK73FB2A471J CHIP R 470 J 1/10W KK1Y R3574 RK73FB2A223J CHIP R 22K J 1/10W KK1Y

R3575 RK73FB2A331J CHIP R 330 J 1/10W KK1Y R3576 RK73FB2A000J CHIP R 0.0 J 1/10W KK1Y R3581 RK73FB2A102J CHIP R 1.0K J 1/10W KK1Y R3582 RK73FB2A682J CHIP R 6.8K J 1/10W KK1Y R3583 RK73FB2A102J CHIP R 1.0K J 1/10W KK1Y

ress

New Parts

Parts No.

Description

Desti-

nation

%

Re-

marks

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

R3591 ✽ R92-1934-08 CHIP R 71.5 J 1/10W KK1Y R3592,93 RK73FB2A750J CHIP R 75 J 1/10W KK1Y R3609 RK73FB2A221J CHIP R 220 J 1/10W M R3610,11 RK73FB2A103J CHIP R 10K J 1/10W M R3612 RK73FB2A102J CHIP R 1.0K J 1/10W M

R4231 RK73FB2A222J CHIP R 2.2K J 1/10W M R4241 RK73GB1J101J CHIP R 100 J 1/16W KK1Y R4241 RK73GB1J151J CHIP R 150 J 1/16W M R4255 RK73FB2A332J CHIP R 3.3K J 1/10W M R4271 RK73FB2A221J CHIP R 220 J 1/10W M

R4272-74 RK73GB1J221J CHIP R 220 J 1/16W R4276 RK73FB2A151J CHIP R 150 J 1/10W M R4281 RK73GB1J331J CHIP R 330 J 1/16W R4301 RK73FB2A101J CHIP R 100 J 1/10W R4302 RK73FB2A103J CHIP R 10K J 1/10W

R4303 RK73FB2A203J CHIP R 20K J 1/10W R4304 RK73FB2A821J CHIP R 820 J 1/10W M R4306 RK73FB2A682J CHIP R 6.8K J 1/10W M R4307 RK73FB2A103J CHIP R 10K J 1/10W M R4308 RK73FB2A104J CHIP R 100K J 1/10W M

R4309,10 RK73FB2A222J CHIP R 2.2K J 1/10W M R4311 RK73FB2A101J CHIP R 100 J 1/10W R4312 RK73FB2A103J CHIP R 10K J 1/10W R4313 RK73FB2A203J CHIP R 20K J 1/10W R4314 RK73FB2A821J CHIP R 820 J 1/10W M

R4316 RK73FB2A682J CHIP R 6.8K J 1/10W M R4317 RK73FB2A103J CHIP R 10K J 1/10W M R4318 RK73FB2A104J CHIP R 100K J 1/10W M R4461 RK73FB2A752J CHIP R 7.5K J 1/10W R4462 RK73FB2A103J CHIP R 10K J 1/10W

R4463 RK73FB2A752J CHIP R 7.5K J 1/10W R4464 RK73FB2A473J CHIP R 47K J 1/10W R4465 RK73FB2A752J CHIP R 7.5K J 1/10W R4466 RK73FB2A103J CHIP R 10K J 1/10W R4467 RK73FB2A752J CHIP R 7.5K J 1/10W

R4468 RK73FB2A473J CHIP R 47K J 1/10W R4501 RK73FB2A821J CHIP R 820 J 1/10W R4502 RK73FB2A221J CHIP R 220 J 1/10W R4503 RK73FB2A821J CHIP R 820 J 1/10W R4504 RK73FB2A821J CHIP R 820 J 1/10W M

R4505,06 RK73FB2A103J CHIP R 10K J 1/10W M R4507 RK73FB2A222J CHIP R 2.2K J 1/10W M R4511 RK73FB2A821J CHIP R 820 J 1/10W R4512 RK73FB2A221J CHIP R 220 J 1/10W R4513 RK73FB2A821J CHIP R 820 J 1/10W

R4514,15 RK73FB2A821J CHIP R 820 J 1/10W M R4517 RK73FB2A332J CHIP R 3.3K J 1/10W M R4561 RK73FB2A821J CHIP R 820 J 1/10W R4562 RK73FB2A221J CHIP R 220 J 1/10W R4563 RK73FB2A821J CHIP R 820 J 1/10W

R4564,65 RK73FB2A821J CHIP R 820 J 1/10W M R4571 RK73FB2A821J CHIP R 820 J 1/10W R4572 RK73FB2A221J CHIP R 220 J 1/10W R4573 RK73FB2A821J CHIP R 820 J 1/10W R4574,75 RK73FB2A821J CHIP R 820 J 1/10W M

Add-

ress

Parts

Parts No.

Description

Desti-

nation

^

Re-

marks

PARTS LIST

DV-303/DVF-5020/K5020

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

103

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

104

DV-303/DVF-5020/K5020

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

R4591 RK73FB2A223J CHIP R 22K J 1/10W R4592 RK73FB2A333J CHIP R 33K J 1/10W R4593 RK73FB2A331J CHIP R 330 J 1/10W R4594 RK73FB2A103J CHIP R 10K J 1/10W R4595 RK73EB2B102J CHIP R 1.0K J 1/8W

R4596 RK73FB2A223J CHIP R 22K J 1/10W R4597 RK73FB2A221J CHIP R 220 J 1/10W R4598 RK73FB2A223J CHIP R 22K J 1/10W R4599 RK73FB2A103J CHIP R 10K J 1/10W R4673,74 RK73FB2A102J CHIP R 1.0K J 1/10W M

R4675 RK73FB2A123J CHIP R 12K J 1/10W M R4676 RK73FB2A224J CHIP R 220K J 1/10W M R4677 RK73FB2A102J CHIP R 1.0K J 1/10W M R4678 RK73FB2A223J CHIP R 22K J 1/10W M R4679 RK73FB2A123J CHIP R 12K J 1/10W M

R4680 RK73FB2A224J CHIP R 220K J 1/10W M R4681 RK73FB2A223J CHIP R 22K J 1/10W M R4691,92 RK73FB2A393J CHIP R 39K J 1/10W M R4693 RK73FB2A334J CHIP R 330K J 1/10W M R4694-96 RK73FB2A473J CHIP R 47K J 1/10W M

R4761 RK73FB2A100J CHIP R 10 J 1/10W R4761 RK73FB2A220J CHIP R 22 J 1/10W M R4771 RK73FB2A750J CHIP R 75 J 1/10W R4901 RK73FB2A822J CHIP R 8.2K J 1/10W R4902 RK73FB2A152J CHIP R 1.5K J 1/10W

R4903 RK73FB2A333J CHIP R 33K J 1/10W R4911 RK73FB2A822J CHIP R 8.2K J 1/10W R4912 RK73FB2A331J CHIP R 330 J 1/10W R4913 RK73FB2A103J CHIP R 10K J 1/10W R4951 RK73FB2A682J CHIP R 6.8K J 1/10W M

R4952 RK73FB2A333J CHIP R 33K J 1/10W M R4953 RK73FB2A682J CHIP R 6.8K J 1/10W M R4954 RK73FB2A223J CHIP R 22K J 1/10W M R4955 RK73FB2A153J CHIP R 15K J 1/10W M R4956 RK73FB2A392J CHIP R 3.9K J 1/10W M

R4957 RK73FB2A822J CHIP R 8.2K J 1/10W M R4958 RK73FB2A103J CHIP R 10K J 1/10W M R4959 RK73FB2A104J CHIP R 100K J 1/10W M R4960 RK73FB2A103J CHIP R 10K J 1/10W M R4961 RK73FB2A472J CHIP R 4.7K J 1/10W M

R4962 RK73FB2A153J CHIP R 15K J 1/10W M R4963 RK73FB2A272J CHIP R 2.7K J 1/10W M R4964 RK73FB2A331J CHIP R 330 J 1/10W M R4965 RK73FB2A473J CHIP R 47K J 1/10W M R4966 RK73FB2A222J CHIP R 2.2K J 1/10W M

R4967 RK73FB2A333J CHIP R 33K J 1/10W M R4968 RK73FB2A682J CHIP R 6.8K J 1/10W M R4969 RK73FB2A224J CHIP R 220K J 1/10W M R4970 RK73FB2A223J CHIP R 22K J 1/10W M R4971 RK73FB2A394J CHIP R 390K J 1/10W M

R4972 RK73FB2A683J CHIP R 68K J 1/10W M R4973 RK73FB2A472J CHIP R 4.7K J 1/10W M R4974 RK73FB2A393J CHIP R 39K J 1/10W M R4975 RK73FB2A103J CHIP R 10K J 1/10W M R4976 RK73FB2A222J CHIP R 2.2K J 1/10W M

ress

New Parts

Parts No.

Description

Desti-

nation

&

Re-

marks

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

R4977 RK73FB2A103J CHIP R 10K J 1/10W M R5201 ✽ R92-1935-08 RD 27 J 1/2W R5202 RK73GB1J2R2J CHIP R 2.2 J 1/16W R5203 RK73GB1J223J CHIP R 22K J 1/16W R5205,06 RK73GB1J103J CHIP R 10K J 1/16W

R5208 RK73GB1J823J CHIP R 82K J 1/16W R5209 RK73GB1J123J CHIP R 12K J 1/16W R5210 RK73GB1J272J CHIP R 2.7K J 1/16W R5211 RK73GB1J393J CHIP R 39K J 1/16W R5212 RK73GB1J123J CHIP R 12K J 1/16W

R5213 RK73GB1J393J CHIP R 39K J 1/16W R5214 RK73GB1J223J CHIP R 22K J 1/16W R5215 RK73GB1J822J CHIP R 8.2K J 1/16W R5216 RK73GB1J183J CHIP R 18K J 1/16W R5217 RK73GB1J223J CHIP R 22K J 1/16W

R5218 RK73GB1J103J CHIP R 10K J 1/16W R5219 RK73GB1J153J CHIP R 15K J 1/16W R5220,21 RK73GB1J474J CHIP R 470K J 1/16W R5222 RK73GB1J332J CHIP R 3.3K J 1/16W R5223 RK73GB1J752J CHIP R 7.5K J 1/16W

R5224 RK73GB1J154J CHIP R 150K J 1/16W R5225 RK73GB1J564J CHIP R 560K J 1/16W R5226 RK73GB1J155J CHIP R 1.5M J 1/16W R6003,04 RK73FB2A473J CHIP R 47K J 1/10W KK1Y R6005-11 RK73FB2A473J CHIP R 47K J 1/10W

R6014 RK73FB2A473J CHIP R 47K J 1/10W M R6015 RK73FB2A473J CHIP R 47K J 1/10W R6016-18 RK73FB2A221J CHIP R 220 J 1/10W M R6019 RK73FB2A221J CHIP R 220 J 1/10W R6023 RK73FB2A221J CHIP R 220 J 1/10W

R6029-33 RK73FB2A104J CHIP R 100K J 1/10W R6035,36 RK73FB2A221J CHIP R 220 J 1/10W R6037-39 RK73FB2A103J CHIP R 10K J 1/10W R6041-43 RK73FB2A103J CHIP R 10K J 1/10W R6044 RK73FB2A821J CHIP R 820 J 1/10W

R6045 RK73FB2A102J CHIP R 1.0K J 1/10W R6046 RK73FB2A122J CHIP R 1.2K J 1/10W R6049 RK73FB2A821J CHIP R 820 J 1/10W R6050 RK73FB2A102J CHIP R 1.0K J 1/10W R6052 RK73FB2A821J CHIP R 820 J 1/10W

R6053 RK73FB2A102J CHIP R 1.0K J 1/10W R6054-57 RK73FB2A221J CHIP R 220 J 1/10W M R6061 RK73FB2A221J CHIP R 220 J 1/10W M R6064 RK73FB2A473J CHIP R 47K J 1/10W R6065 RK73FB2A331J CHIP R 330 J 1/10W KK1Y

R6201 RK73GB1J103J CHIP R 10K J 1/16W R6202-04 RK73GB1J473J CHIP R 47K J 1/16W R6205 RK73GB1J222J CHIP R 2.2K J 1/16W R6206 RK73GB1J473J CHIP R 47K J 1/16W R6207 RK73GB1J473J CHIP R 47K J 1/16W M

R6208 RK73GB1J473J CHIP R 47K J 1/16W R6209 RK73GB1J103J CHIP R 10K J 1/16W M R6301 RK73GB1J103J CHIP R 10K J 1/16W R6302,03 RK73GB1J472J CHIP R 4.7K J 1/16W R6501,02 RK73GB1J103J CHIP R 10K J 1/16W

Add-

ress

Parts

Parts No.

Description

Desti-

nation

*

Re-

marks

PARTS LIST

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

Add-

Ref. No

R6542 RK73GB1J105J CHIP R 1.0M J 1/16W R6544 RK73GB1J101J CHIP R 100 J 1/16W R7001,02 RK73GB1J102J CHIP R 1.0K J 1/16W R7003 RK73GB1J473J CHIP R 47K J 1/16W R7006 RK73GB1J473J CHIP R 47K J 1/16W

RA2001 ✽ R90-0996-08 RADDER RESISTOR,EXBV4V473J KK1Y RA2002 ✽ R90-0994-08 RADDER RESISTOR,EXBV8V331J KK1Y RA2501,02 ✽ R90-0997-08 RADDER RESISTOR,EXBV4V103J RA3001 ✽ R90-0995-08 RADDER RESISTOR,EXBV8V473J RA3002 ✽ R90-0996-08 RADDER RESISTOR,EXBV4V473J

RA6201 ✽ R90-0997-08 RADDER RESISTOR,EXBV4V103J RA6202 ✽ R90-0996-08 RADDER RESISTOR,EXBV4V473J KK1Y RA6203-06 ✽ R90-0996-08 RADDER RESISTOR,EXBV4V473J RA7001,02 ✽ R90-0995-08 RADDER RESISTOR,EXBV8V473J S3581 ✽ S90-0134-08 SWITCH ESD177211 KK1Y

S4501 ✽ S90-0134-08 SWITCH ESD177211 M S6001-03 ✽ S70-0080-08 SWITCH EVQ11A07R S6005-07 ✽ S70-0081-08 SWITCH EVQ11U07M S6401 ✽ S70-0082-08 SWITCH EVQQS307K KK1Y S6411 ✽ S70-0084-08 SWITCH EVQ11G07K M

T1021 ✽ L07-2830-08 POWER TRSNSFORMER,ETE28K119AZ KK1 T1021 ✽ L07-2856-08 POWER TRSNSFORMER,ETS29AD4H6AC MY T4761 ✽ L13-0019-08 INPUT TRSNSFORMER,VLQ0790 VR3041 ✽ R39-0024-08 POTENTIOMETER VRV0293B102T KK1Y VR3501 ✽ R32-0091-08 TRIMMER POT EVNCYAA03B13

VR3511 ✽ R32-0091-08 TRIMMER POT EVNCYAA03B13 VR4691-93 ✽ R39-0026-08 POTENTIOMETER EVUE2KFK3B53 M W077 ✽ AK04WS DIODE AK04WS M W201-205 RK73FB2A000J CHIP R 0.0 J 1/10W M W801-838 RK73FB2A000J CHIP R 0.0 J 1/10W M

W841-847 RK73FB2A000J CHIP R 0.0 J 1/10W M W850-861 RK73FB2A000J CHIP R 0.0 J 1/10W M W863-866 RK73FB2A000J CHIP R 0.0 J 1/10W M W3001 RK73GB1J000J CHIP R 0.0 J 1/16W KK1Y W6501 RK73FB2A000J CHIP R 0.0 J 1/10W KK1Y

X6001 ✽ L78-0710-08 CERAMIC OSCILLATOR,EF0EC8004A4 X6501 ✽ L77-2280-08 CRYSTAL OSCILLATOR,VSX1044

ress

New

Parts

Parts No.

Description

Desti-

nation

MECHANISM PARTS

41 1B ✽ A11-1171-08 INTERMEDIATE CHASSIS,VMD3270 42 1A ✽ J99-0819-08 TRAY VMD3265 43 2A ✽ D13-1978-08 PULLEY GEAR VDG1308 44 2A ✽ D13-1979-08 DECELERATION GEAR,VDG1309 45 2A ✽ D13-1980-08 DRIVE GEAR VDG1310

46 2B ✽ A11-1172-08 VERTCAL CAM VDK0156 47 2A ✽ D16-0745-08 BELT VDV0373 49 3B ✽ A10-3504-08 LOADING BASE VMD3266 50 1A ✽ A11-1173-08 CLAMPER BASE VMD3263 51 1A ✽ T99-0637-08 MAGNET JSM0048

52 1A ✽ T50-1086-08 CLAMPER BACK YOKE,VMA9535 53 1A ✽ J11-0857-08 CLAMPER VMD3264 54 1A ✽ N19-1507-08 CLAMPER WEIGHT VMA0B93 55 3A ✽ T42-0964-08 LOADING MOTOR UNIT,VEM0664 56 3B ✽ S64-0047-08 DOUBLE SWITCH VSH0170

61 2C ✽ E35-2510-08 SPINDLE FFC(17P), VWJ1277

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

105

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

(

Re-

marks

✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert.

New

Ref. No

62 1C ✽ T42-0965-08 SPINDLE MOTOR UNIT,VWM0665 63 2D ✽ T42-0966-08 STEPPING MOTOR UNIT,VEM0666 64 2D ✽ G01-4184-08 TILT SPRING VMB3278 65 3D ✽ G02-1696-08 SUB-SHAFT TILT SPRING,VMC1487 66 2D ✽ G02-1697-08 SPRING HOLDER 1,VMC1488

67 2D ✽ G02-1698-08 SPRING HOLDER 2,VMC1489 68 3D ✽ J19-6059-08 FPC HOLDER VMD3261 69 2C,3C ✽ J02-1469-08 FLOATING RUBBER,VMG1166 70 3C ✽ A11-1174-08 TRAVERSE CHASSIS,VMK0474 71 1C ✽ J90-0872-08 GUIDE SHAFT 1 VMS6471

72 1D ✽ J90-0873-08 GUIDE SHAFT 2 VMS6472 73 1D ✽ J91-0504-08 OPTCAL PICK-UP VED0402-1 KK1Y 73 1D ✽ J91-0505-08 OPTCAL PICK-UP VED0402 M 74 1D ✽ G02-1699-08 SUB-SHAFT PRELOAD SP,VMC1491 75 1D ✽ G02-1700-08 NUT VMC1490

76 1D ✽ J21-6791-08 NUT VMD3260 B41 1B ✽ N09-5159-08 SCREW VHD1223 B42 2A ✽ N09-3456-08 SCREW XQNQC17+3 B43 3A ✽ N09-5158-08 SCREW XTV3+10G B44 2A ✽ N09-5160-08 SCREW XTW2+12T

B45 1A ✽ N09-5158-08 SCREW XTV3+10G B46 1A ✽ N09-5161-08 SCREW XTS3+6J B61 1A,2D ✽ N09-5162-08 SCREW VHD1224 B62 3C ✽ N09-5163-08 SCREW VHD1295 B63 1D ✽ N09-3462-08 SCREW VHD1057

B64 1D ✽ N09-3456-08 SCREW XQNQC17+3 B65 3D ✽ N09-5164-08 SCREW XXE26C6FN B66 3C ✽ N09-5165-08 SCREW XSN26+4 KK1Y

L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G :Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

Add-

ress

Parts

Parts No.

Description

Desti-

nation

DV-303 : K ,DV-303(S) : K1 DVF-5020 : Y,DVF-K5020 :M

)

Re-

marks

PARTS LIST

DV-303/DVF-5020/K5020

SPECIFICATIONS

Note:

Component and circuit are subject to modification to insure best operation under differing local conditions. This manual is based on Europe (E) standard, and provides information on regional circuit modification through use of alternate schematic diagrams, and information on regional component variations through use of parts list.

14-6,Dogenzaka 1-chome, Shibuya-ku, Tokyo, 150-8501 Japan

KENWOOD SERVICE CORPORATION

P.O BOX 22745, 2201 East Dominguez St., Long Beach, CA 90801-5745, U.S.A.

KENWOOD ELECTRONICS CANADA INC.

6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8

KENWOOD ELECTRONICS LATIN AMERICA S.A.

P.O BOX 55-2791, Piso 6 plaza Chase, Cl. 47 y Aquilino de la Guardia Panama, Republic de Panama

KENWOOD ELECTRONICS BRASIL LTDA.

Av. Moema, 170-17˚, Andar-Cobertura “B”, Ed. Maximum Service Center, 04077-020 Moema, São Paulo-SP-Brasil

KENWOOD ELECTRONICS U.K. LIMITED

KENWOOD House, Dwight Road, Watford, Herts., WD1 8EB., United Kingdom

KENWOOD ELECTRONICS BELGUM N.V.

Meachelsesteenweg 418, B-1930 Zaventem, Belgium

KENWOOD ELECTRONICS DEUTSCHLAND GMBH

Rembrücker Str. 15, 63150 Heusenstamm, Germany

KENWOOD ELECTRONICS FRANCE S.A.

13 Boulevard Ney, 75018 Paris, France

KENWOOD ELECTRONICS ITALIA S.p.A.

Via G. Sirtori, 7/9 20129, Milano, ltaly

KENWOOD IBÉRICA S.A.

Bolivia, 239-08020 Barcelona, Spain

KENWOOD ELECTRONICS AUSTRALIA PTY. LTD.

(A.C.N. 001 499 074) 16 Giffnock Avenue, North Ryde, N.S.W. 2113, Australia

KENWOOD ELECTRONICS (HONG KONG) LTD.

Unit 3712-3724, Level 37, Tower 1, Metroplaza, 223 Hing Fong Road, Kwai Fong N.T., Hong Kong

KENWOOD ELECTRONICS GULF FZE

P.O.Box 61318, Jebel Ali, Dubai, U.A.E.

KENWOOD ELECTRONICS SINGAPORE PTE LTD.

No. 1 Genting Lane #02-02, KENWOOD Building, Singapore, 349544

KENWOOD ELECTRONICS (MALAYSIA) SDN BHD.

#4.01 Level 4, Wisma Academy Lot 4A, Jalan 19/1 46300 Petaling Jaya Selangor Darul Ehsan Malaysia

KENWOOD ELECTRONICS (THAILAND) CO., LTD.

2019 New Pechburi Road, Bangkapi, Huaykwang, Bangkok, 10320 Thailand

Kenwood K5020 Service Manual

Specifications and Main Features

Frequently Asked Questions

User Manual

CONTENTS / ACCESSORIES

Contents

Accessories

How to read the schematic diagram

DISASSEMBLY FOR REPAIR

1. Assembling and Disassembling the Casing and Checking C.B.A.s (DV-303)

2. Assembling and Disassembling the Optical Pickup (Mechanical Parts)

OVERALL BLOCK DIAGRAM

SERVO BLOCK DIAGRAM

VIDEO BLOCK DIAGRAM

AUDIO BLOCK DIAGRAM

CIRCUIT DESCRIPTION

1. Optical Pickup Self-Diagnosis and Replacement Procedure

2. Self-Diagnosis Function and Service Modes

3. Service Tools and Equipment

4. Service Precautions

ADJUSTMENT

1. Video Output (Luminance Signal) Adjustment

2. Video Output (Chrominance Signal) Adjustment

3. Video Component Signal (CB) Output Adjustment

4. Abbreviations

5. VOLTAGE CHART

POWER SUPPLY C.B.A.

PC BOARD

Component side view

MODULE C.B.A. (1/2)

MODULE C.B.A. (2/2)

Foil side view

MOTHER C.B.A.

POWER SUPPLY C.B.A.

MODULE C.B.A. (1/2)

MODULE C.B.A. (2/2)

MOTHER C.B.A.

MIC VOLUME C.B.A.

MIC JACK C.B.A.

POWER SW C.B.A.

Power supply

ADSC/module (1/7)

SRV/module (2/7)

AVDEC/module (3/7)

AUDIO/module (4/7)

FEP/module (5/7)

CPU/module (6/7)

ODC/module (7/7)

VIDEO OUT/mother (1/3)

OPERATION/mother (3/3)

Power supply

ADSC/module (1/8)

SRV/module (2/8)

AVDEC/module (3/8)

VDAC/module (4/8)

FEP/module (5/8)

CPU/module (6/8)

CLK/module (7/8)

ODC/module (8/8)

AUDIO-out/mother (4/5)

MIC JACK

DV-303:K/DV-303(S):K1/DVF-5020(Y)/DVF-K5020(M)

ELECTRIC PARTS

PARTS LIST

MECHANISM PARTS

SPECIFICATIONS