Kenmore 415157030 Owner’s Manual

SAVE FOR FUTURE REFERENCE

OWNER'S

MANUAL

Model No. 415157030

i

Caution:

Read and followall
Safety Statements,Assembly

Instructions,and Use and Care
Directions before attempting

to assembleand cook.

Installer/assembler: Leave

these instructions with

consumer.

To Consumer:Keepthis
manual for future reference.

,_ Some parts may

contain sharp edges

especially as noted in the

manual! Wear protective
gloves if necessary.

NATURAL GAS GRILL

• Safety Rules

• Assembly Instructions

- Use and Care

• Troubleshooting
, Parts List

If you have questions or need assistance during assembly,
please call t-800-241-7548 You will be speaking to a
representative of the Grill manufacturer and not a Sears
employee If you would like to order replacement parts, please

contact Sears at 1-800-366-PART as noted on the back of this
manual

This Grill is for Outdoor Use Only

Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A

For your safety please read all the assembly instructions
and use and care directions before proceeding with
assembly or operation It is your responsibility to properly:

FOR YOUR SAFETY

1. Do not store or use gasoline or other

flammable vapors and liquids in the
vicinity of this or any other appliance.

2. An LP Tank not connected for use shall
not be stored in the vicinity of this or any

other appliance.

FOR YOUR SAFETY
If you smell gas:
1, Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, immediately call your

gas supplier or your fire department.

Safety Symbols

• The symbols and boxes shown below explain what each
heading means Read and follow al! of the messages found

throughout the manual

. Assemble

• Install

• Leak check
oOperate

• Care for your gas grill

lfyou have questions or need assistance in missing parts

during the assembly, please call 1-80Q-24 t-7548, You will
be speaking to a representative of the grill manufacturer and

not a Sears employee,

All components referenced in the Parts List may be
ordered from 1-800-366-PART or any Sears Service Center
and most Sears Stores When requesting service or repair
parts for your grill you must mention your Model Number;

415.157030

When ordering repair parts always give the following
information:

• The Model Number

• The Name of the Item

• The Part Description

• The Part Number

If the parts you need are not stocked localty, your order

will be transmitted to a Sears Repair Parts Distribution
Centerforhandling

• DANGER: Indicatesan imminentlyhazardoussituation
which, if not avoided, will result in death or serious

injury.

nil nl nnlll

I, WARNING: Be alert to the possibility of serious bodily I
i injury if the instructions arenot followed Be sure to

i read and carefully fo!!ow,a!!,,o[,,themessages,

CAUTION

,,,,,,,,,,,,,,,,,,,,,,,,,,,, ...........

• CAUTION: Indicatesa potentiallyhazardoussituation
which, if not avoided, may result in minor or moderate

injury

2 • 4638003

ModelNumber

Date Purchased

UPC Label Lot # GG

!

ii,,,i,illUl i in i

415.15703O

!

Gdils protectedunderone or rno_eof these US PaPerers:4,989,579; 4,955,358;

5.220,764; 5.421,319; &441,226; 5.556,606; 5.931,149; 5,996,573; D291.768;
D341,292 Assembly Instructions © 1998 Sears Corporation, All Rights Reserved

Warnings, ................................... 2

Introduction ........................................................... 2

Installation of gdtl must conform with local codes, or in
absence of local codes, with National Fuel Gas Code,
NFPA 541 ANSI Z223.1-1atestedition. Grill is not for use in or
on recreational vehicles and/or boats.

Warranty Information ................................................. 2

Table ofContents ............................... 3

Installation Safety Precautions ..................................... 3

Before Beginning Assembly ................................... 3

Parts List ................................ 4

Parts Diagram ............................. 5

Assembly Instructions ........................................ 6-14

Use and Care ...................................................... 15-19

Troubleshooting ...................................... 20

Warranty .......................................... 21

Recipes .......................................................... 22-29

if externa! electrical source is utilized with accessories (such
as rotisserie), they must be electrically grounded in

accordance with local codes or, in the absence of local
codes, with the National Electrical Code, ANSI I NFPA 70-
latest edition. Keep any electrical cords andlor fuel supply
hoses away from any heated surfaces

Gdlt is for natural gas use at 7 inch water column supply

pressure Verify supply pressure with your local gas company
Not for use with LP gas.

,ik ReadallassemblyinstructionsThepicturesareonlyforreference;

theydonotcontainalltheinformationneededtocorrectlyassembly
yourgrill

•& Metaledgescanbesharp,Usecautionduringassemblyanduse

A Necessarytootsforassembtyofyourgrillincludescrewdrivers

(flatheadandPhillips@),pliersandadjustablewrench A3t8"and
7116"nutdriverwouldbeideal

Assembly Instructions _t999 W C Bradley Co, AIIRights Reserved

4638003 ° 3

Item No. Description _ Part No.

Standard No.

1 ....... Post assembly ...................... I .... 4504606

2 ......... Bolt, 318"-!6 x 2-1t2". ......... 4 ........4080677

3 ....... Flat washer, 3/8" ............ 4 ........4080641

4 ....... Hex nut, 3/8L16 ............. 6 .... 4080633

5 . Gas supptytube ............... 1 ....... 4156394

6 ........ Bolt,3t8"-!6 x 1-1/2" .............. 2 .... 4080676

7 ........ Support tube .......................... I ........ 4502219

8 ........ Console ...................... 1 ........ 4525809

9 ..........Hex nut, #10424(keps) ..... 14 .......4080208

10.... Bolt, #I0-24 x t-1f2" ........................ 4080303 ..........STD511015

11 ...... Valve assembly ..................... 1 4524056

12 ....... Bolt, #10-24 x 318"................. 2 ....... 4080379 ..... STD51 t003

13 ..... Bolt, 114"-20x 1-1t2". ........... 2 ........ 4080324 ...... STD512515

14 ...... Grill bottom ..................... 1 ........4581041

15 ..... Ignitor .................................... I ..... 4153713

16 ...... Knobs ................................... 2 ........4154203

17 ........ Hex nut, 1/4"-20................... 2 .........4080656 ...... STD541025

18 ........ Fire grate ........................ 1 .........4157101

19 ..... Burner assembly .................. 1 ........4505010

20 .... Electrode ................................ 1 ..... 5156119

2I ........ Ignitor Wire ............................... 1 .........4153720

22 ........ Screw, #6x3t8 .............. 1 ........ 4080264

23 ...... Collector box ..................... 1.........4501543

24 .......Screw, self-tap, #10 x 1f2" ....... 1........ 4080652 ..........STD611005

25 ....... Screw, self4ap, #10 x 1-112".._8 ....... 4080756

26 ........ Side shelf tube ............... 2 .........4502212

27 .... Side shelf .............................. 2 .....4154282

28 ...... End cap, 1". ............................ 4 .......4080642

29 ...... Drip VapoRISER Bar ................ 1 ....... 4156418

30 ...... Bolt, #10-24 x 3/4" .............. 8 .........4080301

31 ...... Grill lid .................................... 1 ...... 4581712

32 ........ Hitch pin, 3t4". ..................... 2 ........ 4156515

33 ........ Hinge pin, 1/4"x 1-1t8"........ 2 ........ 4156513

34 ..... Handle ............................ 1 ....... 4069516

35 ....... Bolt, #I0-24 x 1" .................... 3 ...... 4080302 ...........STD511010

36 ....... Logo plate ...................... 1.........4157122

37 ....... Pal nut,3t16" ........................... 2 ...... 4153096

38 .........Heat indicator / bracket ........... 1 ........4156800

39 ........ Swing-grid .................. ! .........4156455

40 ....... Bolt, swing-grid, 1-3/4....................... 4080663

4! ...... Hex nut, 1/4"-20....................... 2 ........4080664

42 ....... Briquets .......................... - - -. ..... 4'159300

43 ..... Cooking grate .............................. 4152741

44 ....... Grease clip............................. 1 ...... 5156607

You may have hardware left over after completing assembly of your grill This is normal as in some cases we have included exta
hardware to ensure that you have enough. Size and type of hardware used in assembly of yourgrill may vary but will notaffectgrill

integrity, performance or assembly

4 • 4638003

38

34

9

36

31

__37

9

24

\

27

28

28

25

26

2--

10

J

15

2

12

4

.8

16

4638003 • 5

OPTIONALBASE POSTGROUNDMOUNT

In-ground mounting option for your new gril!° The accessory needed for this mounting option is available

through the retailer where your grill was originally purchased, or by calling 1-800-241-8981 and ordering

=

AttachingGrillto Wood Deck

Tip: Usethe PostAssemblybaseasa

tempiatefordrillingholesintodeck

3

Qty.4

Model # 4989050, Base Post Assembly.

to right

A. Wrench tighten ali hex nuts_Makesurepost

assembly isfully securedand plumb before

proceeding.

2

Qtyo4

4

Qtyo4

jl PostAssembty

®

®

®

..-----Gas Supply Tube

®

®

Wood

Deck

, 4538003

'0

Qty,2

Support Tube

4

9

Qty,2

Qty.2

6

10

(BEack)

Qty,2

Console

10

Support

, Tube

9

4638003 , 7