How it Works
Keeprite
Loading...
KHPHG 60Hz
Installation Manual
24 pgs1.24 Mb0
Table of contents
Loading...

Keeprite KHPHG 60Hz Installation Manual

Download
Page 1
High Profile Unit Cooler
PRODUCT DATA & INSTALLATION
Bulletin K30-KHPHG-PDI-1
1081591
We are on the Internet
www.keepriterefrigeration.com
Electrical Power: 208-230/3/60, 460/3/60, 575/3/60
CONTENTS
Page
Nomenclature....................................................................................................................... 2
Features & Options............................................................................................................. 2
Standard V elocity Units....................................................................................................... 3 - 6
Capacity Data.............................................................................................................. 3
Electrical Data............................................................................................................. 4 - 6
Wiring Diagram................................................................................................................... 7
Piping Schematic................................................................................................................. 8
Dimensional Data................................................................................................................ 9, 10
Specifications................................................................................................................. ...... 11, 12
Installation Instructions........................................................................................................ . 13, 14
High Velocity Unit s............................................................................................................. . . 15 - 20
Capacity Data................................................................................................................ 15 - 17
Electrical Data............................................................................................................... 18 - 20
Service Parts List................................................................................................................. 21
Warranty....................................................................................................................... ........ 23
Project Information.............................................................................................................. 23
“As Built” Service Parts List............................................................................................... BACK
Project Information................................................................................................................ BACK
Page 2

NOMENCLATURE

K HP 216 L E - T5 A - S B
K = KeepRite High Profile Unit Cooler
Nominal Capacity x 1000
(standard motor/fan blade) @ 10°F TD
Application Range
H = Hi / Medium Temp 7 FPI (0°F to 35°F Evap Temp) M = Medium Temp 6 FPI (0°F to 35°F Evap Temp) P = Medium Temp 4 FPI (0°F to 35°F Evap Temp) L = Low Temp 6 FPI (-5°F to -40°F Evap Temp) V = Low Temp 4 FPI (-5°F to -40°F Evap Temp)
Defrost
A = Air E = Electric T = 3 Pipe Hot Gas w/ Heater G = Reverse Cycle Hot Gas w/ Heater H = 3 Pipe Hot gas w/ Loop R = Reverse Cycle Hot Gas w/ Loop

STANDARD FEATURES

• Heavy gauge textured aluminum cabinet
with galvanized steel hangers, support channels and end plates
• Hinged access panels with removable hinge
pins and captive fasteners.
• Rugged heavy-gauge galvanized steel rail
motor mount / support
Throw Boosters:
N = None B = Booster
Motor Option:
S = Standard T = TEFC V = High Velocity
† Not available on above +15°F Evap. Temp. models
Generation
st
A = 1
Voltage:
T3 = 208-230/3/60 T4 = 460/3/60 T5 = 575/3/60 T7 = 200-220/3/50 T9 = 380-400/3/50
†
• Drain pan heaters
• Fixed fan delay thermostat (all low
temperature models)
• Adjustable fan delay thermostat (all medium
temperature models)
• St ackable design
• Adjustable defrost termination thermostat
• Heater safety thermostat (on models with heaters)
OPTIONAL FEATURES
• Factory mounted TX valve, solenoid valve
and thermostat
• Throw boosters
• Insulated drain pan
• 3 HP 1750 RPM motor with cast aluminum
fan blade ideal for blast applications
• Schrader fitting and external equalizer line
• Factory installed solenoid valve wire harness
• Unit shipped upright for convenient handling
and quick installation.
• Hot gas drain pan loop
• TEFC motors
• Optional fin spacing
• Optional fin materials
• Optional coil coating
- 2 -
Page 3

CAPACITY DATA - STANDARD MODELS

Medium Temperature Models - Capacity @ 6 F.P.I.
sledoM.pmeTmuideM#M860#M180#M290#M801#M321#M531#M261#M181#M122#M342#M172
yticapaC
HUTB
)STTAW(
F° )C°(
wolFriAMFC ( )S
pavE
.pmeT
52 )9.3
01 )2.21-(
/L *egrahCtnaregirfeR.BL )GK(
-(
00976
)88891(
00566
)87491(
00861
)8297(
02 )9( 72 )21( 33 )51( 04 )81( 04 )81( 05 )32( 06 )72( 88 )04( 8
Low Temperature Models - Capacity @ 6 F.P.I.
sledoM.pmeTwoL#L560#L870#L980#L490#L811#L431#L341#L161#L571#L891#L612#L822
pavE
yticapaC
HUTB
F°
)STTAW(
)C°(
wolFri
AMFC ( )S/L
tnaregirfeR
**egrahC
0
)8.7
1-(
01-
.pmeT
)3.32-(
02-
)1.62-(
03-
)4.43-(
04-
)04-(
.BL
)GK(
00917
)06012(
00886
)25102(
00346
)33881(
00795
)68471(
00545
)36951(
00981
)9198(
12
)01(
00478
00738 00287 00
627
00266
00871
92
)31(
00318
)31832(
00797
)44332(
00651
)2637(
)99552(
)61542( )50922(
)56212(
)09391(
)0048(
00599
00259 00098 00728 00457 00961
)5797(
63
)61(
00519
)00862(
00798
)37262(
00741
)7396(
)44192(
)48872( )86062(
)32242(
)58022(
002501
)31803(
007001
)59492(
00149
)26572(
00478
)99552(
00797
)44332(
03951
)7157(
34
)91(
000801
)33613(
008501
)98903(
00951
)3057(
009131
)43683(
003621
)39963(
000811
)26543(
006901
)20123(
00999
)16
292(
03762
)41621(
34
)9
1(
000321
)72063(
5021
00
)49253(
00432
)24011(
008941
)67834(
004341
)20024(
000431
)94293(
005421
)66463(
005311
)44233(
01352
)44911(
45
)42(
60Hz
000531
)24593(
000231
)36683(
00022
)28301(
008951
)50864(
000351
)41844(
0
00341
)58814(
008231
)79883(
001121
)07453(
09832
)47211(
46
)92(
000261
)05474(
008851
)31564(
00932
)87211(
009971
)39625(
003271
)76405(
000161
)75174(
006941
)81834(
004631
)25993(
08062
)70321(
59
)34(
000181
)5103
5(
004771
)06915(
00162
)71321(
006591
)19275(
003781
)06845(
000571
)85215(
006261
)62674(
002841
)80434(
0183
0
)97971(
48
)83(
000122
)13746(
006612
)24436(
00363
)0
3171(
9 )54( 811 )45( 751 )17(
003122
)91846(
009112
)66026(
000891
)49975(
009381
)46835(
007761
)91194(
09263
)52171(
501
)84(
000342
)57117(
001832
)93796(
00843
)22461(
004142
)60707(
001132
76(
)986
000612
)66236(
007002
)58785(
000381
)10635(
07743
)80461(
811
)45(
000172
)67397(
006562
)49777(
00023
)10151(
008452
)13647(
000442
)86417(
000822
)18766(
008112
)63026(
001391
)95565(
00023
)10151(
751
)17(
Medium Temperature Models - Capacity @ 4 F.P.I.
sledoM.pmeTmuideM#P950#P270#P380#P190#P901#P221#P731#P051#P461#P002#P222#P652
yticapaC
HUTB
)STTAW(
F° )C°(
MFC
wolFriA
( )S/L
tnaregirfeR
*egrahC
52
pavE
)9.3-(
.pmeT
01
)2.21-(
.BL
)GK(
00095
)18271(
00875
)03961(
00571
)8528(
02
)9(
00027
00607 00561
)6877(
72
)21(
00628
)98012(
)97602(
)49142(
00908
(
)69632
00651
)2637(
33
)51(
00019
)45662(
00298
)72162(
00841
)4896(
04
)81(
000901
)62913(
008601
)28213(
00842
)30711(
04
)81(
000221
)43753(
006911
)13053(
322
00432
)24011(
05
)32(
Low Temperature Models - Capacity @ 4 F.P.I.
sledoM.pmeTwoL#V550#V660#V670#V780#V001#V411#V721#V541#V271#V781#V712
0
)8.71-(
01-
yticapaC
HUTB
wolFriA
pavE
)STTAW(
**egrahC
.pmeT
F° )C°(
MFC
( )S/L
tnaregirfeR
)3.32-(
02-
)1.62-(
03-
)4.43-(
04-
)04-(
.BL
)GK(
* Estimated, based on R404A at +25° S.S.T. with coil 30% full. ** Estimated, based on R404A at -20° S.S.T. with coil 30% full. Derate capacity by 0.92 and CFM by .85 for Throw Booster Option. # = T / G / H / R
00516
)31081(
00985
)25271(
00055
)
01161(
00115
)76941(
00664
)94631(
00591
)2029(
12
)01(
00837
)61612(
00607
)97602(
00066
)13391(
00316
)55971(
00
955
)37361(
00681
)7778(
92
)31
(
00948
)76842(
00318
)31832(
00067
)06222(
00607
)97602(
00446
)36881(
00871
)0048(
63
)61(
00279
)07482(
00139
)96272(
00078
)28452(
00808
)66632(
00737
)78512(
00071
)2208(
34
)91(
008111
)64723(
000701
)04313(
000001
)09292(
00929
)01272
(
00748
)90842(
00972
)66131(
34
)91(
00669 00762
621(
45
)42(
000731
)72104(
003431
)63393(
00
)32501(
65
)52(
004721
)51373(
000221
)43753(
000411
)19333(
009501
)81013( )49282( )00
000051
)53934(
000741
)65034(
00682
)69431(
47
)33(
009141
)36514(
009531
)50893(
000721
)89173(
000811
)26543(
006701
)61513(
00552
)33021(
46
)92(
000461
)63084(
007061
)96074(
00572
)77921(
88
)04(
001261
)97474(
002551
)85454(
000541
)17424(
007431
)45493(
008221
)86953(
00472
)03921(
59
)34(
000002
)08585(
000691
)80475(
00183
)97971(
89
)54(
002291
)59265(
000481
)49835(
000271
)97305(
008951
)50864(
007541
)67624(
00183
)97971(
501
)84(
000222
)42056(
006712
)53736(
00663
)27271(
811
)45(
000902
)61216(
001002
)90685(
000781
)27745(
007371
)77805(
004851
)59364(
00663
)27271(
621
)75(
000652
)28947(
009052
)98437(
00443
)33261(
751
)17(
005242
)82017(
002232
)11086(
000712
)95536(
006102
)94095(
008381
)53835(
00443
)33261(
751
)17(
Average Air Throw - ft (m)
NAFDRADNATS
ROTOMDNA
011 )33( 051 )64(
†
LANOITPO
RETSOOBWORHT
† Measured in open space. Actual throw may be less in real
applications.
- 3 -
Page 4
ELECTRICAL DATA
STANDARD MODELS - 208-230/3/60
LEDOMIPF
A3T-#M860PHK A3T-#M180PHK A3T-#M290PHK A3T-#M801PHK A3T-#M321PHK A3T-#
M531PHK
A3T-#M261PHK A3T-#M181PHK
2PHK
HK
A3T-#M12 A3T-#M342PHK A3T-#M172PHK A3T-#L560P
6
A3T-#L870PHK A3T-#L980PHK
A3T-#L490PHK A3T-#L811PHK A3T-#L431PHK A3T-#L341PHK A3T-#L161PHK A3T-#L571PHK A3T-#L891PHK A3T-#L612PHK A3T-#L822PHK A3T-#P950PHK A3T-#P270PHK A3T-#P380PHK A3T-#P190PHK
P901PHK
A3T-# A3T-#P221PHK A3T-#P731PHK A3T-#P051PHK A3T-#P461PHK A3T-#P002PHK A3T-#P222PHK A3T-#P652PHK
4
A3T-#V550PHK A3T-#V660PHK A3T-#V670PHK A3T-#V780PHK A3T-#V001PHK A3T-#V411PHK A3T-#V721PHK A3T-#V541PHK A3T-#V271PHK A3T-#V781PHK A3T-#V712PHK
ROTOMNAF
YTQ
21 6.98.015105375.811.3252 21 6.98.015105375.811 21 6.98.015105375.811.3252
25.12.116.215105375.811.3252 31 4.416.5102005014.620.3353 31 4.416.5102005014.620.3353
35.18.611.0252005014.620.3353 +35.18.611.0252008011.729.3353
45.14.221.5203001414.532.4405
45.14.221.5203001414.532.4405
45.14.221.5203001414.532.4405
25.12.116.215105375.811.3252
25.12.116.215105375.811.3252
25.12.116.215105375.811.3252
25.12
35.18.611.0252005014.620.3353
35.18.611.0252005014.620.3353
35.18.611 +35.18.611.0252008011.729.3353
45.14.221.5203001414.532.4405
45.14.221.
45.14.221.5203001414.532.4405
45.14.221.5203001414.532.4405
21 6.98.015105 21 6.98.015105375.811.3252 21 6.98.015105375.811.3252 21 6.98.015105375.811.3252 31 4.416.5102005014.620.3353 31 4.416.5102005014.620.3353 31 4.416.5102005014.620.333
+35 +35.18.611.0252008011.729.3353
45.14.221.5203001414.532.4405
45.
45.14.221.5203001414.532.4405
25.12.116.215105375.811.3252
25.12.1
25.12.116.215105375.811.3252
25.12.116.215105375.811.3252
35.18.611.02520
35.18.611.0252005014.620.3353
35.18.611.0252005014.620.3353 +35.18.611.025200
45.14.221.5203001414.532.4405
45.14.221.5203001414.532.4405
45.14.221.52030014
PH
.116.215105375.811.3252
.18.611.0252008011.729.3353
14.221.5203001414.532.4405
16.215105375.811.3252
NOTE: 3+ indicates 3-fan “long” configuration (see dimensional data for details)
SROTOMNAF )ELBACILPPAFI(SRETAEHNAPNIARD
ALFROTOM
LATOT
.CRIC.NIM
)A(YTICAPMA
.0252005014.620.3353
5203001414.532.4405
60Hz
ESUF.XAM
PMA(
)S
STTAWSPMA
375.811.3252
05014.620.3353
8011.729.3353
14.532.4405
.CRIC.NIM
)A(YTICAPMA
.3252
ESUF.XAM
)SPMA(
- 4 -
Page 5
ELECTRICAL DATA
STANDARD MODELS - 460/3/60
60Hz
LEDOMIPF
A4T-#M860PHK A4T-#M180PHK A4T-#M290PHK A4T-#M801PHK A4T-#M321PHK A4T-#M531PHK A4T-#M261PHK A4T-#M181PHK A4T-#M122PHK A4T-#M342PHK
A4T-#M172PHK A4T-#L560PHK A4T-#L870PHK A4T-#L980PHK A4T-#L490PHK A4T-#L811PHK A4T-#L431PHK A4T-#L341PHK A4T-#L161PHK A4T-#L571PHK A4T-#L891PHK A4T-#L612PHK A4T-#L822PHK A4T-#P950PHK A4T-#P270PHK
-#P380PHK
A4T A4T-#P190PHK A4T-#P901PHK A4T-#P221PHK A4T-#P731PHK A4T-#P051PHK A4T-#P461PHK A4T-#P002PHK A4T-#P222PHK A4T-#P652PHK
T-#V550PHK
A4 A4T-#V660PHK A4T-#V670PHK A4T-#V780PHK A4T-#V001PHK A4T-#V411PHK A4T-#V721PHK A4T-#V541PHK A4T-#V271PHK A4T-#V781PHK A4T-#V712PHK
SROTOMNAF )ELBACILPPAFI(SRETAEHNAPNIARD
ROTOMNAF
YTQ
21 8.44.55105372.95.1151 21 8.44.55105372.95.1151 21 8.44.55105372.95.1151
25.16.53.65105372.95.1151 31 2.78.751005012.315.6102 31 2.78.
35.14.81.951005012.315.6102 +35.14.81.951008016.319.6102
45.12.119.11510014
45.12.119.1151001417.711.2252
45.12.119.1151001417.711.2252
6
4
25.16.53.65105372.95.1
25.16.53.65105372.95.1151
25.16.53.65105372.95.1151
25.16.53.65105372.95.1151
35.14.81.951005012.315.6102
35.14.81.951005012.315.6102
35.14.81.951005012.315.6102 +35.14.81.95
45.12.119.1151001417.711.2252
45.12.119.1151001417.711.2252
45.12.119.115100
45.12.119.1151001417.711.2252
21 8.44.55105372.95.1151 21 8.44.55105372.95.1151 21 8.44.55105372.95.1151 21 8.44.55105372.95.1151 31 2.78.751005012.315.6102 31 2.78.7510050 31 2.78.751005012.315.6102
+35.14.81.951008016.319.6102 +35.14.81.951008016.319.6102
45.12.119.1151001417.711.2252
45.12.119.1151001417.711.2252
45.12.119.1151001417.711.2252
25.16.53.65105372.95.1151
25.16.53.65105372.95.1151
25.16.53.65105372.95.1151
25.16.
35.14.81.951005012.315.6102
35.14.81.951005012.315.6102
35.14.81.951005012.3 +35.14.81.951008016.319.6102
45.12.119.1151001417.711.2252
45.12.119.1151001417.711.2
45.12.119.1151001417.711.2252
PH
ALFROTOM
LATOT
53.65105372.95.1151
.CRIC.NIM
)A(YTICAPMA
751005012.315.6102
ESUF.XAM
PMA(
)S
1008016.319.6102
STTAWSPMA
17.711.2252
1417.711.2252
12.315.6102
15.6102
.CRIC.NIM
)A(YTICAPMA
151
252
ESUF.XAM
)SPMA(
NOTE: 3+ indicates 3-fan “long” configuration (see dimensional data for details)
- 5 -
Page 6
ELECTRICAL DATA
STANDARD MODELS - 575/3/60
LEDOMIPF
A5T-#M860PHK A5T-#M180PHK
T-#M290PHK
A5 A5T-#M801PHK A5T-#M321PHK A5T-#M531PHK A5T-#M261PHK A5T-#M181PHK A5T-#M122PHK A5T-#M342PHK A5T-#M172PHK
A5T-#L560PHK
6
HK
HK
A5T-#L870P A5T-#L980PHK A5T-#L490PHK A5T-#L811PHK A5T-#L431PHK A5T-#L341PHK A5T-#L161PHK
#L571PHK
A5T­A5T-#L891PHK A5T-#L612PHK A5T-#L822PHK A5T-#P950PHK A5T-#P270PHK A5T-#P380PHK
-#P190PHK
A5T A5T-#P901PHK A5T-#P221PHK A5T-#P731PHK A5T-#P051PHK A5T-#P461PHK A5T-#P002PHK A5T-#P222PHK A5T-#P652PHK
4
A5T-#V550PHK A5T-#V660P A5T-#V670PHK A5T-#V780PHK A5T-#V001PHK A5T-#V411PHK A5T-#V721PHK A5T-#V541PHK
#V271PHK
A5T­A5T-#V781PHK A5T-#V712PHK
ROTOMNAF
YTQ
21 8.44.55105374.72.951 21 8.44.55105374.72.951 21 8.44.55105374.72.951
25.16.42.55105374.72.951 31 2.78.751005015.012.3151 31 2.78.751005
35.19.65.751005015.012.3151
35.19.65.751008018.016.3151
45.12.98.951001412.417.710
45.12.98.951001412.417.7102
45.12.98.951001412.417.7102
25.16.42.55105374.72.951
25.16.42.55105374.72.951
25.16.42.55105374.72.951
25.16.42.55105374.72.951
35.19.65.751005015.012
35.19.65.751005015.012.3151
35.19.65.751005015.012.3151
35.19.65.751008018.016.3151
45.12.98.951001412.417.7102
45.12.98.951001412.417.7102
45.12.98.951001412.417.7102
45.12.98.951001412.417.7102 21 8.44.55105374.72.951 21 8.44.55105374.72.951 21 8.44.55105374.72.951 21 8.44.55105374.72.951 31 2.78.751005015.012.3151 31 2.78.751005015.012.3151 31 2.78.751005
35.19.65.751008018.016.3151
35.19.65.751008018.016.3151
45.12.98.951001412.417.710
45.12.98.951001412.417.7102
45.12.98.951001412.417.7102
25.16.42.55105374.72.951
25.16.42.55105374.72.951
25.16.42.55105374.72.951
25.16.42.55105374.72.951
35.19.65.751005015.012
35.19.65.751005015.012.3151
35.19.65.751005015.012.3151
35.19.65.751008018.016.3151
45.12.98.951001412.417.7102
45.12.98.951001412.417.7102
45.12.98.951001412.417.7102
PH
SROTOMNAF )ELBACILPPAFI(SRETAEHNAPNIARD
ALFROTOM
LATOT
.CRIC.NIM
)A(YTICAPMA
ESUF.XAM
PMA(
)S
STTAWSPMA
015.012.3151
015.012.3151
60Hz
.CRIC.NIM
)A(YTICAPMA
2
.3151
2
.3151
ESUF.XAM
)SPMA(
NOTE: 3+ indicates 3-fan “long” configuration (see dimensional data for details)
- 6 -
Page 7

WIRING DIAGRAM

- 7 -
Page 8

PIPING SCHEMATIC

- 8 -
Page 9

DIMENSIONAL DATA

2 Fan Models
Drain connections 1-1/4” FPT .
3 Fan Models
- 9 -
Page 10
DIMENSIONAL DATA
3 Fan (Long) Models
Drain connections 1-1/4” FPT .
4 Fan Models
- 10 -
Page 11
SPECIFICATIONS -
6 F.P.I. MODELS
Medium Temperature Models - 6 F.P.I.
sledoMIPF6.pmeTmuideM#M860#M180#M290#M801#M321#M531#M261#M181#M122#M342#M172
snaFfOrebmuN
.nnoCrotubirtsiD
O(
oL
)taewSD
epiP3
naPniarD
-.nnoCtroPediS
)taewSDO(
-.nnoCtroPediS
elcyCesreveR
)taewSDO(
-.nnoCpo
)taewSDO(
.nnoCnoitcuS
)taewSDO(
.BL
thgieWteN.xorppA
Low Temperature Models - 6 F.P.I.
sledoMIPF6.pmeTwoL#L560#L870#L980#L490#L811#L431#L341#L161#L571#L891#L612#L822
snaFfOrebmuN
.nnoCrotubirtsiD
DO(
(
)taewS
epiP3
naPniarD
-.nnoCtroPediS
)taewSDO(
-.nnoCtroPediS
elcyCesreveR
)taewSDO
-.nnoCpooL
)taewSDO(
.nnoCnoitcuS
)taewSDO(
.BL
thgieWteN.xorppA
22223333444
sehcnI
)mm(
sehcnI
)mm(
sehcnI
)mm(
sehcnI
)mm(
sehcnI
)mm(
)GK(
sehcnI
)mm(
sehcnI
)mm(
sehcnI
)mm(
sehcnI
)mm(
sehcnI
)mm(
)GK(
8/1-1
)92(
8/7
)22(
8/7
)22(
8/3-1
)53(
8/3-1
)53(
986
)313(
222233334444
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/1-
2
)45(
986
)313(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/5-1
)14(
137
)233(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/1-2
)45(
137
)233(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/5-1
)14(
477
)253(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/1-2
)45(
477
)253(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/1-2
)45(
618
)173(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/1-2
)45(
618
)173(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/5-1
)14(
8/1-2
)45(
9401
)774(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/5-1
)14(
8/5-2
)76(
9401
)774(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/5-1
)14(
8/1
-2
)45(
3111
)705(
8/5-1
)14(
8/3-1
)53(
8/3-1
)53(
8
/5-1
)14(
8/5-2
)76(
3111
)705(
8/3-1
)53(
8
/1-1
)92(
8/1-1
)92(
8/5-1
)14(
8/1-2
)45(
7711
)535(
8/5-1
)14(
8/3-1
)53(
8/3-1
)53(
8/5-1
)14(
8/5-2
)76(
7711
)535(
8/3-1
)53(
8/3-1
)53(
8/1-1
)92(
8/5-1
)14(
8/1-2
)45(
2721
)775(
8/3-1
**)53(
8/3-1
)53(
8/3-1
)53(
8/5-1
)14(
8/5-2
)76(
2721
)775(
)14( *
6(
8/3-1
)53(
8/3-1
)53(
8/1-1
)92(
*8/5-1
)1
4(
8/5-2
)76(
8551
)707(
8/5-1
)14(
8/5-1
)14(
8/3-1
)53(
8/5-1
8/5-2
)76(
2541
)95
8/5-1
)14(
8/5-1
)14(
8/3-1
)53(
8/5-1
)14( *
8/1-3
)08(
8551
8/3-1
)53
(
8/3-1
)53(
8/1-1
)92(
*8/5-1
)14(
8/5-2
)76(
4661
)557(
8/5-1
)14(
8/5-1
)14(
8/3-1
)53(
8/5-1
)14( *
8/1-3
)08(
)707(
4661
)557(
8/5-1
)14(
8/3-1
)53(
8/3-1
)53(
*8/5-1
)14(
8/5-2
)76(
6781
)158(
8/5-1
)14(
8/5-1
)14(
8/3-1
)53(
8/5-1
)14( *
8/1-3
)
08(
6781
)158(
* Drain pan loop will have connections at opposite ends of the unit. ** Reverse Cycle 1-3/8 (35), 3 -Pipe 1-5/8 (41). Note: Distributor and / or circuiting may change with each application.
- 1 1 -
Page 12
SPECIFICATIONS -
4 F.P.I. MODELS
Medium Temperature Models - 4 F.P.I.
sledoMIPF4.pmeTmuideM#P950#P270#P380#P190#P901#P221#P731#P051#P461#P002#P222#P652
snaFfOrebmuN
ewSDO(
epiP3
naPniarD
.xorppA
.nnoCrotubirtsiD
)ta
-.nnoCtroPediS
)taewSDO(
-.nnoCtroPediS
elcyCesreveR
)taewSDO(
-.nnoCpooL
)taewSDO(
.nnoCnoitcuS
)taewSDO(
nI
thgieWteN
Low Temperature Models - 4 F.P.I.
sledoMIPF4.pmeTwoL#V550#V660#V670#V780#V001#V411#V721#V541#V271#V781#V712
snaFfOrebmuN
.nnoCrotubirtsiD
)taewSDO(
epiP3
naPniarD
CpooL
-.nnoCtroPediS
)taewSDO(
-.nnoCtroPediS
elcyCesreveR
)taewSDO(
-.nno
)taewSDO(
.nnoCnoitcuS
)taewSDO(
ehcnI
thgieWteN.xorppA
222233333444
sehcnI
)mm(
sehcnI
)mm(
sehc
)mm(
sehcnI
)mm(
sehcnI
)mm(
.BL
)GK(
s
)mm(
sehcnI
)mm(
sehcnI
)mm(
sehcnI
)mm(
sehcnI
)mm(
.BL
)GK(
8/1-1
)92(
8/7
)52(
8/7
)52(
8/3-1
)53(
8/3-1
)53(
986
)313(
22223333444
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/1-2
)45(
876
)703(
8/1-1
)92(
8/7
)52(
8/7
)52(
8/3-1
)53(
8/5-1
)1
4(
137
)233(
8/3-1
)53(
8/1-1
)92(
8/
1-1
)92(
8/3-1
)53(
8/1-2
)45(
017
8/1-1
)92(
8/7
)52(
8/7
)52(
8/3-1
)53(
8/5-1
)14(
477
)253(
)223(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/5-1
)14(
618
)173(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/1-2
)45(
247
)733(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/5-1
)14(
8/1-2
)45(
9401
)774(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/3-1
)53(
8/1-2
)45(
487
)653(
8/3-1
)53(
/1-1
8
)92(
8/1-1
)92(
8/5-1
)14(
8/1-2
)45(
3111
)705(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/5-1
)14(
8/5-2
)76(
8101
)164(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
-1
8/5
)14(
8/1-2
)45(
7711
)535(
8/5-1
)14(
8/3-1
)53(
8/1-1
)92(
8/5-1
)14(
8/5-2
)76(
1701
)584(
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/5-1
)14(
8/1-2
)45(
2721
)775(
8/5-1
)14(
8/3-1
)53(
8/1-1
)92(
8/5-1
)14(
8/5-2
)76(
4211
)015(
)53( **
8/3-1
)53(
8/1-1
)92(
8/1-1
)92(
8/5-1
)14(
8/1-2
)45(
2541
)956(
8/3-1
8/3-1
)53(
8/3-1
)53(
8/5-1
)14(
8/5-2
)76(
9121
)255(
8/3-
1
)53(
8/3-1
)53(
8/1-1
)92(
8/5-1
)14( *
8/5-2
)76(
8551
)707(
8/5-1
)14(
8/5-1
)14(
8/3-1
)53(
8/5-1
)14( *
8/5-2
)76(
5051
)386(
)14( *
8/3-1
)53(
8/3-1
)53(
8/1-1
)92(
8/5-1
)14( *
8/5-2
)76(
4
661
)557(
8/5-1
)14(
8/5-1
)14(
8/3-1
)53(
8/5-1
8/1-3
)08(
1061
)627(
8/5-1
)14(
8/3-1
)53(
8/3-1
)53(
8/5-1
)14( *
8/5-2
)76(
6781
)158(
8/5-1
)14(
8/5-1
)14(
8/3-1
)53(
8/5-1
)14( *
8/1-3
)08(
0871
)808(
* Drain pan loop will have connections at opposite ends of the unit. ** Reverse Cycle 1-3/8 (35), 3 -Pipe 1-5/8 (41). Note: Distributor and / or circuiting may change with each application.
- 12 -
Page 13

INSTALLATION INSTRUCTIONS

The installation and start-up of Unit Coolers should only be performed by qualified refrigeration mechanics. This equipment should be installed in accordance with all applicable codes, ordinances and local by-laws
INSPECTION
Inspect all equipment before unpacking for visible signs of damage or loss. Check shipping list against material received to ensure shipment is complete.
IMPORTANT: Remember , you, the consignee, must make any claim necessary against the transportation company . Shipping damage or missing parts, when discovered at the outset, will prevent later unnecessary and costly delays.
If damage or loss during transport is evident, make claim to carrier, as this will be their responsibility, not the manufacturer’s.
Should carton be damaged, but damage to equipment is not obvious, a claim should be filed for “concealed dam­age” with the carrier. IMPORTANT: The electrical characteristics of the unit should be checked at this time to make sure they corre­spond to those ordered and to electrical power available at the job site. Save all shipping papers, tags and instruction sheets for reference by installer and owner .
LOCATION
The unit location in the room should be selected to ensure uniform air distribution throughout the entire space to be refrigerated. Be sure that the unit does not draw air in, or blow directly out, through an opened door and that the product does not obstruct the free circulation of air. Consideration should be given to the coil location in order to minimize the piping run length to the condensing unit and floor drain
CLEARANCES
This evaporator draws air through the coil and discharges air from the fan side, and thus adequate clearance should be made on the entering face of the coil to ensure even unrestricted air flow through the coil. This distance should be equal to the height of the coil or more. Ensure enough room is left at the ends of the coil for servicing.
MOUNTING
This evaporator is supplied with shipping legs to allow units to be shipped in an upright position. Units can be lifted into place with shipping skid attached to mounting legs. Hanger brackets take up to 5/8” (15.9 mm) hanger rods. After the evaporator is hung in place, remove the bolts attaching the skid to the legs.
DRAIN LINE
If the evaporator is mounted flush to ceiling, the stag­gered hanger will provide a positive pitch for drainage.
If units are suspended below the ceiling, the installer must provide adequate pitch to the unit by adjusting the location of the hanger rod nuts.
Note: Check for adequate drainage by pouring water into the drain pan.
Ensure that the drain pan has sufficient slope for proper drainage (prevention of ice build up / blockage in pan).
Insulated copper tube should be run from the drain connection, sloping at least 4” (102mm) per foot. A trap located outside of the room should be provided to prevent warm air entering through the tubing. Connection should be made to proper drainage facilities that comply with local regulations.
If room temperatures are below freezing, it is necessary to heat the drain line to prevent condensate from freezing in the drain line. Electric heating cable or electric tape (by others) is used for this purpose. The drain line heater should be connected for continuous operation; it is also recommended that the drain line be insulated. A heat output of 20 watt s per lineal foot of 1” (25mm) drain line in a 0°F (-18 °C) room is usually satisfactory . 1 15 volt cable and tape is available from your local refrigeration wholesaler. Two 1 15 volt s heaters (by others) of the same wattage may be wired in series for use on 230 volt system
- 13 -
Page 14
INSTALLATION INSTRUCTIONS
PIPING
Refrigerant line sizes are important and may not be the same size as the coil connections (depends on the length of run). If in doubt, consult “Recommended refrigerant line sizes” charts.
WIRING
Wire system in accordance with governing standards and local codes. Enclosed typical wiring diagrams are for reference only . Refer to unit data plate for operating current, minimum ampacity and maximum fuse sizing for fan motors.
NOTE: Electrical wiring is to be sized in accordance with minimum ampacity rating.
For ease of identifying the proper wiring terminals, unit wiring is colour coded and terminal block connections are identified. When fan delay thermostats (combina­tion fan delay and defrost termination) are installed, on start-up, the fans do not operate until the coil tempera­ture is reduced to approximately 20 °F (-6.7 °C). It is
normal for the fans to cycle a few times until the room temperature is brought down. At higher evaporating temperatures this control is of an adjustable type, and proper adjustment is required.
The defrost termination control is adjustable and may be set at a minimum of 40 °F (4.4 °C) (fully CW) to a maximum of 75 °F (23.8 °C) (fully CCW). Normal setting is 55 °F (12.8 °C). This can be increased if the defrost heaters are terminated too soon (frost still left) or if terminated too long (steaming of coil). Time clock should be set for a fail-safe termination of approximately 45 minutes.
A hinged end panel provides quick access to the electri­cal compartment.
SYSTEM CHECK
Before Start-Up:
1. All wiring should be in accordance with local codes.
2. All refrigerant lines should be properly sized.
3. Electric defrost systems should include a liquid line solenoid valve.
4. Thorough evacuation and dehydration has been performed.
5. The suction, discharge and receiver service valves must be open.
6. The system should include a liquid line drier moisture indicator and suction filter.
7. Pour enough water into the drain pan to allow a good check on drainage and seal the trap.
After Start-Up:
1. If necessary, temporarily by-pass fan delay control to
run fans until room temp is lowered. (Run jumper wire from terminal N to F on circuit terminal block).
2. Check the compressor oil level to ensure the correct
oil charge.
3. Be sure that the expansion valve is properly set to
provide the correct amount of superheat (should be around 70% of operating T .D.)
4. Heavy moisture loads are usually encountered when
starting the system for the first time. If the coil temperature is below freezing, this will cause a rapid build-up of frost on the coil. During the initial pull down, frost build-up should be watched and defrosted manually as required.
5. Check for proper evaporator fan blade rotation.
MAINTENANCE
1. Periodic checking and cleaning of the coil surface when necessary should be done, using a whisk or brush. Drain pans are hinged to provide convenient access to the inside coil surface (except hot gas loop pans).
2. Ensure coil and pan does not have any excessive ice build-up from improper defrost operation. Any build-up of ice can cause fins and refrigerant tubes to be crushed. When replacing heater elements, first remove heater slot covers and heater clips
3. Motors are permanently lubricated type and require no further lubrication.
- 14 -
Page 15
CAPACITY DATA -
HIGH VELOCITY MODELS
Medium Temperature - 6 F.P.I. with 3 HP Motor @ 0” External Static Pressure
sledoM.pmeTmuideM#M860#M180#M290#M801#M321 #M531#M261#M181#M122#M342#M172
yticapaC
HUTB
)STTAW(
wolFriAMFC ( )S/L
Low Temperature - 6 F.P.I. with 3 HP Motor @ 0” External Static Pressure
yticapaC
HUTB
)STTAW(
wo
lFriAMFC ( )S/L
**egrahC
pavE
.pmeT
F° )C°(
sledoM.pmeTwoL#L560#L870#L980#L490#L811#L431#L341#L161#L571#L891#L612#L822
pavE
.pmeT
F°
)C°(
tnaregirfeR
*egrahCtnaregirfeR.BL )GK(
0
)8.7
1-(
01-
)3.32-(
02-
)1.62-(
03-
)4.43-(
04-
)04-(
.BL
)GK(
01
)2.21-(
(
12
)01(
00097
)93132(
00832
11(
)132
02 )9(
00067
)06222(
00827
)32312(
00086
)71991(
00236
)11581
00675
)17861(
00832
)13211(
92
)31(
00079
)11482(
00822
)95701(
72 )21( 33 )51( 04 )81( 04 )81( 05 )32( 06 )72( 88 )04( 89 )54( 811 )45( 751 )17(
00169
)84182(
00029
)74962(
2(
00068
)98152(
00997
)30432(
00827
)32312(
00822
)95701(
00049 00378 00697 00712
63
)61(
000211
823(
)50
00712
)04201(
001501
)48703(
006001
)6649 )33572( )07552( )51332( )04201(
003711
004211
000501 00579 00988 00802
)6189(
34
)
91(
000221
)43753(
00802
)6189(
)75343(
)22923( )55703( )85582( )93062(
007931
008331 000521 001611
1
00950
00243
34
)91(
000641
)36724(
00243
)93161(
)81904(
)09193( )31663( )60043( )81013( )93161(
003461
)32184(
003751
)37064(
000741
)6503
4(
006631
)01004(
005421
)66463(
00623
)48351(
45
)42(
000461
)63084(
00623
)48351(
003381
)98635(
005571
)40415(
000461
)63084(
004251
)83644(
009831
)48604(
00213
)32741(
46
)92(
000281
)80335(
00213
)32741(
002102
)13985(
006291
)31465(
000081
)22725(
002761
)37984(
005251
)76644(
00923
62551(
)
59
)34(
000502
)54006(
00923
)62551(
005402
)89895(
008591
)05375(
000381
)10635(
000071
)39794(
000551
)00454(
00274
)47222(
48
)83(
60Hz
000152
)81537(
00554
)17412(
002932
)26007(
000922
)47076(
000412
)18626(
008891
)92285(
003181
)30135(
00554
)17412(
501
)84(
000772
)33118(
00834
)96602(
002862
)65587(
008652
)71257(
000042
)69207(
000322
)71356(
003302
)74595(
00834
)96602(
811
)45(
000703
)02998(
00904
)10391(
008282
)23828(
007072
)88297(
000352
)40147(
000532
)23886(
003412
)86726(
00904
)10391(
751
)17(
Medium Temperature - 4 F.P.I. with 3 HP Motor @ 0” External Static Pressure
sledoM.pmeTmuideM#P950#P270#P380#P190#P901#P221#P731#P051#P461#P002#P222#P652
yticapaC
pavE
HUTB
)STTAW(
F° )C°(
MFC
wolFriA
( )S/L
tnaregirfeR
*egrahC
01
.pmeT
)2.21-(
.BL
)GK(
00076
)42691(
00442
)41511(
02
)9(
00038
00632
72
)21(
00049
)11342(
)73111(
)33572(
22
008
)95701(
33
)51(
000701
)04313(
00912
)53301(
04
)81(
000521
)31663(
00453
)50761(
04
)81(
000741
)65034(
00143
)29061(
05
)32(
000161
)75174(
00923
)62551(
65
)52(
000561
)92384(
00453
)50761(
47
)33(
000781
)27745(
00343
)68161(
88
)04(
000812
)25836(
00274
)47222(
89
)54(
000642
)35027(
00854
612(
)31
8
11
)45(
Low Temperature - 4 F.P.I. with 3 HP Motor @ 0” External Static Pressure
sledoM.pmeTwoL#V550#V660#V670#V780#V001#V411#V721#V541#V271#V781#V712
0956
0
)8.71-(
)3.32-( )1.62-( )4.43-(
)20391(
00136
)28481(
5
0009
)18271(
00845
)15061(
00005
(
)54641
00442
)41511(
12
)0
1(
yticapaC
HUTB
wolFriA
)STTAW(
F° )C°(
MFC
( )S/L
tnaregirfeR
*egrahC*
0
01-
pavE
02-
.pmeT
03-
04-
)04-(
.BL
)GK(
* Estimated, based on R404A at +25° S.S.T. with coil 30% full. ** Estimated, based on R404A at -20° S.S.T. with coil 30% full. Derate capacity by 0.92 and CFM by .85 for Throw Booster Option. # = T / G / H / R
Average Air Throw - ft (m)
NAFDRADNATS
ROTOMDNA
041 )24( 061 )84(
00397
)72232(
00067
)06222(
00017
)69702(
00066
)13391(
00106
)30671(
00632
)73111(
92
)31(
00059
)62872(
00019
)45662(
00058
)79842(
00097
)93132(
00027
)98012(
00822
)95701(
63
)61(
003701
)82413(
007201
)18003(
00069
)81182(
00298
)72162(
00318
)31832(
00912
)53301(
34
)91(
001421
)94363(
11
0088
)79743(
000111
)21523(
001301
103(
)89
00049
)33572(
00453
)50761(
34
)91(
004641
)18824(
002041
)56014(
000131
)07383(
007121
)64653(
000111
)21523(
00143
)29061(
45
)42(
001351
)34844(
006641
)93924(
000731
)72104(
003721
)68273(
000611
)67933(
00923
)62551(
46
)92(
001181
)44035(
003371
)06705(
000261
)05474(
005051
)18044(
002731
)68104(
00343
)68161(
59
)34(
007512
)97136(
005602
)48406(
000391
)03565(
003971
)71525(
005361
)98874(
00274
)47222(
501
)84(
004142
)60707(
001132
)98676(
000612
)66236(
007002
)58785(
000381
)10635(
00854
)31612(
621
)75(
†
LANOITPO
RETSOOBWORHT
† Measured in open space. Actual throw may be less in real
applications.
000882
)55348(
00234
)68302(
751
)17(
005072
)92297(
009852
)23857(
000242
)28807(
008422
)44856(
000502
)54006(
00234
)68302(
751
)17(
- 15 -
Page 16
CAPACITY DATA -
HIGH VELOCITY MODELS
Medium Temperature - 6 F.P.I. with 3 HP Motor @ .25” External Static Pressure
sledoM.pmeTmuideM#M860#M180#M290#M801#M321 #M531#M261#M181#M122#M342#M172
yticapaC
HUTB
)STTAW(
wolFriAMFC ( )S/L
Low Temperature - 6 F.P.I. with 3 HP Motor @ .25” External Static Pressure
yticapaC
HUTB
)STTAW(
FriAMFC ( )S/L
wol
*egrahC*
pavE
.pmeT
F° )C°(
sledoM.pmeTwoL#L560#L870#L980#L490#L811#L431#L341#L161#L571#L891#L612#L822
pavE
.pmeT
F°
)C°(
tnaregirfeR
*egrahCtnaregirfeR.BL )GK(
0
)8.7
1-(
01-
)3.32-(
02-
)1.62-(
03-
)4.43-(
04-
)04-(
.BL
)GK(
01
)2.21-(
12
)01(
00067
)06222(
00322
01(
)325
02
)9(
00837
)61612(
00607
)97602(
00066
)13391(
00316
)55971(
00955
)37361(
00322
)32501(
00829
00888 00038 00177 00307 00212
92
)31(
00039
)04272(
00212
)40001(
72
)21(
)18172(
)01062( )11342( )38522( )19502( )40001(
007101
00479
(
00019 00548 00177 00102
)5849(
63
)61(
000701
313(
)04
00102
)5849(
33
)51(
)88792(
)82582 )45662( )05742( )38522(
000411
)19333(
001901
)55913(
000201
)67892(
00849
)76772(
00468
)70352(
00291
)0609(
34
)91(
000711
)96243(
00291
)0609(
04
)81(
002531
)00693(
005921
)13973(
000121
)14453(
004211
)22923(
005201
)22003(
00713
)95941(
34
)91(
000141
)99214(
00713
)95941(
04
)81(
006751
)16164(
009051
)99144(
000141
(
)99214
000131
)07383(
004911
)27943(
00103
)40241(
45
)42(
000851
)87264(
00103
)50241(
05
)32(
005571
)40415(
000861
)70294(
000751
)58954(
009541
)43724(
000331
)65983(
00782
)44531(
46
)92(
000471
)56905(
00782
)44531(
06
)72(
002291
)59265(
000481
)49835(
000271
)97305(
008951
)50864(
007541
)67624(
00203
)15
241(
59
)34(
000691
)80475(
00203
)15241(
88
)04(
008791
)63975(
004981
)57455(
000771
)34815(
004461
)35184(
009941
)60934(
00634
)57502(
48
)83(
60Hz
000042
)69207(
00914
)37791(
89
)54(
002032
)62476(
004022
)55546(
000602
)73306(
004191
)16065(
005471
)11115(
00914
)37791(
501
)84(
000462
00304
811
)45(
000752
)57257(
001642
)38027(
000032
)76376(
007312
)39526(
008491
)75075(
00304
)81091(
811
)45(
)62377(
00573
)81091(
751
)17(
006172
)25597(
000062
)45167(
000342
)57117(
007522
)80166(
008502
)97206(
00573
)69671(
751
)17(
000192
)43258(
)69671(
Medium Temperature - 4 F.P.I. with 3 HP Motor @ .25” External Static Pressure
sledoM.pmeTmuideM#P950#P270#P380#P190#P901#P221#P731#P051#P461#P002#P222#P652
yticapaC
pavE
HUTB
)STTAW(
F° )C°(
MFC
wolFriA
( )S/L
tnaregirfeR
*egrahC
01
.pmeT
)2.21-(
.BL
)GK(
00056
)93091(
00032
)45801(
02
)9(
00018
00122
72
)21(
00019
)52732(
)92401(
)45662(
002
12
)40001(
33
)51(
000201
)67892(
00302
)0859(
04
)81(
000121
)14453(
00133
)02651(
04
)81(
000141
)99214(
00713
)95941(
05
)32(
000451
)70154(
00403
)64341(
65
)52(
000951
)17564(
00723
)13451(
47
)33(
000771
)34815(
00613
)21941(
88
)04(
000012
)90516(
00634
)57502(
89
)54(
000532
)23886(
00224
)41991(
81
1
)45(
000472
)55208(
00793
)43781(
751
)17(
Low Temperature - 4 F.P.I. with 3 HP Motor @ .25” External Static Pressure
sledoM.pmeTwoL#V550#V660#V670#V780#V001#V411#V721#V541#V271#V781#V712
0846
0
)08981(
00126
)98181(
00085
)88961(
00935
)78751(
00194
)18341(
00032
)45801(
12
)01(
yticapaC
HUTB
wolFriA
)STTAW(
F° )C°(
MFC
( )S/L
tnaregirfeR
*egrahC*
0
)8.71-(
01-
pavE
.pmeT
)3.32-(
02-
)1.62-(
03-
)4.43-(
04-
)04-(
.BL
)GK(
* Estimated, based on R404A at +25° S.S.T. with coil 30% full. ** Estimated, based on R404A at -20° S.S.T. with coil 30% full. Derate capacity by 0.92 and CFM by .85 for Throw Booster Option. # = T / G / H / R
Average Air Throw - ft (m)
NAFDRADNATS
ROTOMDNA
041 )24( 061 )84(
00287
)50922(
00947
)83912(
00007
)30502(
00056
)93091(
00395
)96371(
00122
)92401(
92
)31(
00619
)03862(
00778
)78652(
00028
)81042(
00267
)91322(
00596
)75302(
00212
)40001(
63
)61(
009301
)23403(
00599
)44192(
00039
)04272(
00468
)70352(
00887
)18032(
00302
)0859(
34
)91(
007021
)35353(
1
00651
)95833(
000801
)33613(
003001
92(
)873
00519
)00862(
00133
)02651(
34
)91(
008041
)04214(
008431
)38493(
000621
)50963(
001711
)99243(
007601
)25213(
713
00
)95941(
45
)42(
008941
)67834(
004341
)20024(
000431
)94293(
005421
)66463(
005311
)44233(
00403
)64341(
46
)92(
002371
)03705(
009561
)29584(
000551
)00454(
000441
)87124(
003131
)85483(
00613
)21941(
59
)34(
008602
)27506(
000891
)49975(
000581
)78145(
009171
)05305(
007651
)79854(
00634
)57502(
501
)84(
003132
)84776(
005122
)77846(
000702
)03606(
003291
)52365(
003571
)54315(
00224
)41991(
621
)75(
002852
)72657(
002742
)50427(
000132
)06676(
006412
)65826(
007591
)12375(
00793
)43781(
751
)17(
†
LANOITPO
RETSOOBWORHT
† Measured in open space. Actual throw may be less in real
applications.
- 16 -
Page 17
CAPACITY DATA -
HIGH VELOCITY MODELS
Medium Temperature - 6 F.P.I. with 3 HP Motor @ .50” External Static Pressure
sledoM.pmeTmuideM#M860#M180#M290#M801#M321 #M531#M261#M181#M122#M342#M172
yticapaC
HUTB
)STTAW(
wolFriAMFC ( )S/L
Low Temperature - 6 F.P.I. with 3 HP Motor @ .50” External Static Pressure
yticapaC
HUTB
)STTAW(
wolFriAMFC ( )S/L
*egrahC*
pavE
.pmeT
F° )C°(
*egrahCtnaregirfeR
sledoM.pmeTwoL#L560#L870#L980#L490#L811#L431#L341#L161#L571#L891#L612#L822
1-(
pavE
.pmeT
F°
)C°(
tnaregirfeR
01
)2.21-(
.BL
)GK(
0
)8.7
01-
)3.32-(
02-
)1.62-(
03-
)4.43-(
04-
)04-(
.BL
)GK(
12
00037
)28312(
00402
9(
)726
02
)9
(
00627
)56212(
00696
)68302(
00056
)93091(
437
00406
)19671(
00155
)93161(
00402
)7269(
)01(
92
00098
)86062(
00291
)0609(
72
)21(
00388
)36852(
00548
)05742(
00097
)93132(
00
)99412(
00966
)59591(
00291
)0609(
)31(
63
)61(
000101
592(
)38
00381
)6368(
33
)51(
00279
)07482(
00139
)96272(
00078
)28452(
00808
)66632(
00737
)78512(
00381
)6368(
34
)91(
000111
)21523(
00571
)8528(
04
)81(
004801
)05713(
008301
)30403(
00079
)11482(
00109
)09362(
00228
)67042(
00571
)8528(
00199
092(
00982
34
)91
(
000431
)94293(
00982
)83631(
04
)81(
008031
)11383(
002521
)17663(
000711
)96243(
007801
)83813(
)62
)83631(
009051
005441
000531
004521
003411
00572
45
)42(
000051
)53934(
00572
)77921(
05 )32(
006761
)99144(
)42324(
)24593(
)03763(
)87433(
)77921(
005061
00051
0
004931
001721
00362
46
)92(
000661
)12684(
00362
)11421(
06
)72(
001181
35(
)09094(
)01074(
)53934(
)03804(
)82273(
)11421(
)440
003371
)06705(
000261
)05474(
005051
)18044(
002731
)68104(
00372
)38821(
59
)34(
000481
)49835(
00372
)38821(
88
)04(
000091
)15655(
009181
)97235(
000071
)39794(
009751
)94264(
000441
)87124(
00593
)04681(
48
)83(
60Hz
000722
)88466(
00873
)83871(
89
)54(
501
)84(
811
)45(
000912
)54146(
007902
86(
)12416(
000691
)80475(
001281
)73335(
000661
)12684(
00873
)83871(
000842
)93627(
00363
)03171(
005242
002232
)110
000712
)95536(
006102
)94095(
008381
)53835(
00363
)03171(
811
)45(
000272
)96697(
00733
)30951(
751
)17(
000752
)82017(
)57257(
001642
)38027(
000032
)76376(
007312
)39526(
008491
)75075(
00733
)30951(
751
)17(
Medium Temperature - 4 F.P.I. with 3 HP Motor @ .50” External Static Pressure
sledoM.pmeTmuideM#P950#P270#P380#P190#P901#P221#P731#P051#P461#P002#P222#P652
yticapaC
pavE
HUTB
)STTAW(
F° )C°(
MFC
wolFriA
( )S/L
tnaregirfeR
*egrahC
01
.pmeT
)2.21-(
.BL
)GK(
00026
)06181(
00212
)40001(
02
)9(
00077
00102
)5849(
72
)21(
00078
)35522(
)28452(
00291
)0609(
33
)51(
00079
)11482(
00581
)0378(
04
)81(
000611
)67933(
00203
)15241(
04
)81(
000431
)94293(
00982
)83631(
05
)32(
000741
)65034(
00772
)27031(
65
)52(
000051
53934(
)
00692
)86931(
47
)33(
000761
)41984(
00682
)69431(
88
)04(
000991
)78285(
00593
)04681(
89
)54(
000222
)42056(
00183
)97971(
811
)4
5(
000652
)28947(
00753
)74861(
751
)17(
Low Temperature - 4 F.P.I. with 3 HP Motor @ .50” External Static Pressure
sledoM.pmeTwoL#V550#V660#V670#V780#V001#V411#V721#V541#V271#V781#V712
0516
0
)8.71-(
01-
yticapaC
HUTB
wolFriA
pavE
)STTAW(
**egrahC
.pmeT
F° )C°(
MFC
( )S/L
tnaregirfeR
)3.32-(
02-
)1.62-(
03-
)4.43-(
04-
)04-(
.BL
)GK(
0
)31081(
00985
)25271(
00055
01161(
)
00115
)76941(
00664
)94631(
00212
)40001(
12
)01(
* Estimated, based on R404A at +25° S.S.T. with coil 30% full. ** Estimated, based on R404A at -20° S.S.T. with coil 30% full. Derate capacity by 0.92 and CFM by .85 for Throw Booster Option. # = T / G / H / R
Average Air Throw - ft (m)
NAFDRADNATS
ROTOMDNA
041 )24( 061 )84(
00947
)83912(
00717
)10012(
00076
)42691(
00226
)81281(
765
00
)70661(
00102
)5849(
92
31(
)
00388
)36852(
00548
)05742(
00097
)93132(
00437
)99412(
00966
)59591(
00291
)0609(
63
)61(
00389
)29782(
00249
)19572(
00088
)57752(
00818
)95932(
00547
)12812(
00581
)0378(
34
)91(
001511
)31733(
002011
)87223(
000301
)96103(
00759
(
)13082
00278
)14552(
00203
)15241(
34
)91(
000331
)65983(
003721
)68273(
000911
)55843(
006011
)59323(
008001
)42592(
00982
83631(
)
45
)42(
001341
)41914(
000731
)72104(
000821
)19473(
009811
)62843(
004801
)05713(
00772
)27031(
46
)92(
003461
)32184(
003751
)37064(
000741
)65034(
006631
)01004(
005421
)66463(
00682
)69431(
59
)34(
006591
)19275(
003781
)06845(
000571
)85215(
006261
)62674(
002841
)80434(
00593
)04681(
501
)84(
000912
)54146(
007902
)12416(
000691
)80475(
001281
)73335(
000661
)12684(
00183
)97971(
621
)75(
006342
)05317(
003332
)43386(
000812
)25836(
005202
)21395(
006481
)96045(
00753
)74861(
751
)17(
†
LANOITPO
RETSOOBWORHT
† Measured in open space. Actual throw may be less in real
applications.
- 17 -
Page 18
ELECTRICAL DATA - HIGH VELOCITY
MODELS - 208-230/3/60
60Hz
LEDOMIPF
A3T-#M860PHK A3T-#M180PHK A3T-#M290PHK A3T-#M801PHK A3T-#M321PHK
#M531PHK
A3T­A3T-#M261PHK A3T-#M181PHK
K
1PHK
HK
A3T-#M122PH A3T-#M342PHK A3T-#M172PHK
A3T-#L560PHK
6
A3T-#L870PHK A3T-#L980PHK A3T-#L490PHK A3T-#L811PHK A3T-#L431PHK A3T-#L341PHK A3T-#L16 A3T-#L571PHK A3T-#L891PHK A3T-#L612PHK A3T-#L822PHK A3T-#P950PHK A3T-#P270PHK A3T-#P380PHK A3T-#P190PHK A3T-#P901PHK
-#P221PHK
A3T A3T-#P731PHK A3T-#P051PHK A3T-#P461P A3T-#P002PHK A3T-#P222PHK A3T-#P652PHK
4
A3T-#V550PHK A3T-#V660PHK A3T-#V670PHK A3T-#V780PHK A3T-#V001PHK A3T-#V411PHK
721PHK
A3T-#V A3T-#V541PHK A3T-#V271PHK A3T-#V781PHK A3T-#V712PHK
ROTOMNAF
YTQ
23 6.718.915205375.811.3252 23 6.718.915205375. 23 6.718.915205375.811.3252 23 6.718.915205375.811.3252 33 4.626.8253005014.620.3353 33 4.626.8253005014.620.3353 33 4.626.8253005014.620.3353
+33 4.626.8253008011.729.3353 43 2.534.7354001414.532.4405 43 2.534.7354001414.532.4405 43 2.534.7354001414.532.4405
23 6.718.915 23 6.718.915205375.811.3252 23 6.718.915205375.811.3252 23 6.718.915205375.811.3252 33 4.626.8253005014.620.3353 33 4.626.8253005014.620.3353 33 4.626.8253005014.620.3353
+33 4.626.8253008011.729.3353 43 2.534.7354001414.532.4405 43 2.534.7354001414.532.4405 43 2.5 43 2.534.7354001414.532.4405
23 6.718.915205375.811.3252 23 6.718.915205375 23 6.718.915205375.811.3252 23 6.718.915205375.811.3252 33 4.626.8253005014.620.3353 33 4.626.8253005014.620.3353 33 4.626.8253005014.620.3353
+33 4.626.8253008011.729.3353
+33 4.626.8253008011.729.3353 43 2.534.7354001414.532.4405 43 2.534.7354001414.532.4405 43 2.534.
23 6.718.915205375.811.3252 23 6.718.915205375.811.3252 23 6.718.915205375.811. 23 6.718.915205375.811.3252 33 4.626.8253005014.620.3353 33 4.626.8253005014.620.3353
+33 4.626.8253005014.620.3353
33 4.626.8253008011.729.3353 43 2.534.7354001414.532.4405 43 2 43 2.534.7354001414.532.4405
PH
34.7354001414.532.4405
.534.7354001414.532.4405
SROTOMNAF )ELBACILPPAFI(SRETAEHNAPNIARD
ALFROTOM
LATOT
.CRIC.NIM
)A(YTICAPMA
7354001414.532.4405
205375.811.3252
NOTE: 3+ indicates 3-fan “long” configuration (see dimensional data for details)
ESUF.XAM
PMA(
)S
STTAWSPMA
811.3252
.811.3252
.CRIC.NIM
)A(YTICAPMA
3252
ESUF.XAM
)SPMA(
- 18 -
Page 19
ELECTRICAL DATA - HIGH VELOCITY
MODELS - 460/3/60
SROTOMNAF )ELBACILPPAFI(SRETAEHNAPNIARD
ALFROTOM
LATOT
.CRIC.NIM
)A(YTICAPMA
1PHK
1PHK
LEDOMIPF
A4T-#M860PHK
A4T-#M180PHK
A4T-#M290PHK
A4T-#M801PHK
A4T-#M321PHK
A4T-#M53
A4T-#M261PHK
A4T-#M181PHK
A4T-#M122PHK
A4T-#M342PHK
A4T-#M172PHK
A4T-#L560PHK
A4T-#L870PHK
A4T-#L980PHK
A4T-#L490PHK
A4T-#L81
A4T-#L431PHK
A4T-#L341PHK
A4T-#L161PHK
A4T-#L571PHK
A4T-#L891PHK
A4T-#L612PHK
A4T-#L822PHK
A4T-#P950PHK
A4T-#P270PHK
-#P380PHK
A4T
A4T-#P190PHK
A4T-#P901PHK
A4T-#P221PHK
A4T-#P731PHK
A4T-#P051PHK
A4T-#P461PHK
A4T-#P002PHK
A4T-#P222PHK
A4T-#P652PHK
A4T-#V550PHK
A4T-#V660PHK
A4T-#V670PHK
A4T-#V780PHK
A4T-#V001PHK
A4T-#V411PHK
A4T-#V721PHK
A4T-#V541PHK
A4T-#V271PHK
A4T-#V781PHK
A4T-#V712PHK
6
4
ROTOMNAF
YTQ
23 6.718.915205372.95.1151
23 6.718.915205372.95
23 6.718.915205372.95.1151
23 6.718.915205372.95.1151
33 4.626.8253005012.315.6102
33 4.626.8253005012.315.6102
33 4.626.8253005012.315.6102
+33 4.626.8253008016.319.6102
43 2.5
43 2.534.7354001417.711.2252
43 2.534.7354001417.711.2252
23 6.718.915205372
23 6.718.915205372.95.1151
23 6.718.915205372.95.1151
23 6.718.915205372.95.1151
33 4.626.8253005012.315.6102
33 4.626.8253005012.315.6102
33 4.626.8253005012.315.6102
+33 4.6
43 2.534.7354001417.711.2252
43 2.534.7354001417.711.2252
43 2.534.73540014
43 2.534.7354001417.711.2252
23 6.718.915205372.95.1151
23 6.718.915205372.95.1151
23 6.718.915205372.95.1151
23 6.718.915205372.95.1151
33 4.626.8253005012.315.6102
33 4.6
33 4.626.8253005012.315.6102
+33 4.626.8253008016.319.6102
+33 4.626.825300
43 2.534.7354001417.711.2252
43 2.534.7354001417.711.2252
43 2.534.7354001417.711.2
23 6.718.915205372.95.1151
23 6.718.915205372.95.1151
23 6.718.915205372.95.1151
23 6.718.915205372.95.1151
33 4.626.8253005012.315.6102
33 4.626.8253005012.315.6102
33 4.626.8253005
+33 4.626.8253008016.319.6102
43 2.534.7354001417.711.2252
43 2.534.7354001417.711.2
43 2.534.7354001417.711.2252
PH
34.7354001417.711.2252
26.8253008016.319.6102
26.8253005012.315.6102
NOTE: 3+ indicates 3-fan “long” configuration (see dimensional data for details)
60Hz
ESUF.XAM
PMA(
)S
STTAWSPMA
.95.1151
17.711.2252
8016.319.6102
012.315.6102
.CRIC.NIM
)A(YTICAPMA
.1151
252
252
ESUF.XAM
)SPMA(
- 19 -
Page 20
ELECTRICAL DATA - HIGH VELOCITY
MODELS - 575/3/60
SROTOMNAF )ELBACILPPAFI(SRETAEHNAPNIARD
ALFROTOM
LATOT
.CRIC.NIM
)A(YTICAPMA
.5102001412.417.7102
PHK
1PHK
90PHK
0PHK
71PHK
LEDOMIPF
A5T-#M860PHK A5T-#M180PHK A5
T-#M290PHK
A5T-#M801PHK A5T-#M321PHK A5T-#M531PHK A5T-#M261PHK A5T-#M181PHK A5T-#M122PHK A5T-#M342PHK
A5T-#M172PHK A5T-#L560PHK A5T-#L870 A5T-#L980PHK A5T-#L490PHK A5T-#L811PHK
5T-#L431PHK
A A5T-#L341PHK A5T-#L161PHK A5T-#L57 A5T-#L891PHK A5T-#L612PHK A5T-#L822PHK A5T-#P950PHK A5T-#P270PHK A5T-#P380PHK A5T-#P1 A5T-#P901PHK A5T-#P221PHK A5T-#P731PHK A5T-#P051PHK A5T-#P461PHK A5T-#P002PHK A5T-#P222PHK A5T-#P652PHK A5T-#V550PHK A5T-#V66 A5T-#V670PHK A5T-#V780PHK A5T-#V001PHK A5T-#V411PHK A5T-#V721PHK A5T-#V541PHK A5T-#V2 A5T-#V781PHK A5T-#V712PHK
6
4
ROTOMNAF
YTQ
23 2.71.85105374.72.951 23 2.71.85105374.72.951 23 2.71.85105374.72.951 23 2.71.85105374.72.951 33 8.017.1151005015.012.3151 33 8.017.11510 33 8.017.1151005015.012.3151
+33 8.017.1151008018.016.3151 43 4.413.5102001412.417 43 4.413.5102001412.417.7102 43 4.413.5102001412.417.7102
23 2.71.85105374.72.951 23 2.71.85105374.72.951 23 2.71.85105374.72.951 23 2.71.85105374.72.951 33 8.017.1151005015.012.3151 33 8.017.1151005015.012.3151 33 8.017.1151005015.012.3151
+33 8.017.1151008018.016.3151 43 4.413.5102001412.417.7102 43 4.413.5102001412.417.7102 43 4.413.5102001412.417.7102 43 4.413
23 2.71.85105374.72.951 23 2.71.85105374.72.951 23 2.71.85105374.72.951 23 2.71.85105374.72.951 33 8.017.1151005015.012.3151 33 8.017.1151005015.012.3151 33 8.017.11510
+33 8.017.1151008018.016.3151
+33 8.017.1151008018.016.3151 43 4.413.5102001412.4 43 4.413.5102001412.417.7102 43 4.413.5102001412.417.7102
23 2.71.85105374.72.951 23 2.71.85105374.72.951 23 2.71.85105374.72.951 23 2.71.85105374.72.951 33 8.017.1151005015.012.3151 33 8.017.1151005015.012.3151 33 8.017.1151005015.012.3151
+33 8.017.1151008018.016.3151 43 4.413.5102001412.417.7102 43 4.413.5102001412.417.7102 43 4.413.5102001412.417.7102
PH
NOTE: 3+ indicates 3-fan “long” configuration (see dimensional data for details)
60Hz
ESUF.XAM
PMA(
)S
STTAWSPMA
05015.012.3151
05015.012.3151
17.7102
.CRIC.NIM
)A(YTICAPMA
.7102
ESUF.XAM
)SPMA(
- 20 -
Page 21

SERVICE PARTS

zH05/06-SROTOM.DTSSLEDOM#TRAPPDO#TRAPCFET
06/3/032-802MPR058PH1
)05/3/022-002(
06/3/032-802MPR0411PH5.1
)05/3/022-002(
06/3/064MPR058PH1
)05/3/004-083(
06/3/064MPR0411PH5.1
)05/3/004-083(
06/3/575MPR058PH1
06/3/575MPR0411PH5.1
zH05/06
)05/3/022-002(
)05/3/004-083(
SEDALBNAFSLEDOM#TRAP
SROTOMPH1ROF
SROTOMPH3ROF
-SROTOMCFETPH3LANOITPO
06/3/032-802MPR0571PH3
6/3/064MPR0571PH3
0
06/3/575MPR0571PH3
SROTOMPH5.1ROF
180,860
,261,801
950,321,290,180,860
,181,261,801
70,950,321,290,180,860
181,261,801
LP
SLEDOM#TRAP
LLA
LLA
LLA
LLA
SLEDOM'V'&'L'LLASULP
SLEDOM'V'&'L'LLASULP
SLEDOM'V'&'L'LLASU
SLEDOM'V'&'L'LLASULP
731,531,221,901,190,380,270,
652,222,002,461,051,172,342,122
731,531,221,901,190,380,2
652,222,002,461,051,172,342,122,
731,531,221,901,190,380,270,950,321,290,
652,222,002,461,051,172,342,122,181,261,801
73
1,531,221,901,190,380,270,950,321,290,180,860 652,222,002,461,051,172,342,122,181
73708011470801
93708013470801
73708011470801
93708013470801
83708012470801
04708014470801
7470801
7470801
8470801
9470801
0570801
1570801
.CSIMSLEDOM#TRAP
DRAUGNAF
LANOITPO
NIMRET
RETSOOBWORHT
SROTOM-KCOLBLANIMRET
SRETAEH-KCOLBLANIMRET
TIUCRICLORTNOC-KCOLBLA
YALEDNAFDEXIF
YALEDNAFELBATSUJDA
ANIMRETTSORFEDELBATSUJDA
NOIT
YTEFASRETAEH
NAPNIARD:PMALCRETAEH
LLA LLA LLA LLA LLA
SLEDOM'V'dna'L'LLA
SLEDOM'P'dna'M'LLA
LLA
SRETAEHNAPNIARDHTIWSLEDOMLLA SRETAEHNAPNIARDHTIWSLEDOMLLA
4358701 6258701 7105401 7477701 0600701 0420401
1463701 0168401 4610401 8618601
SRETAEHNAPNIARD
SLEDOM
V022-002/V032
)RETAEHV032(
780,670,660,550,490,980,870,560,190,380,270,950,801,290,180,860
721,411,001,341,431,811,731,221,901,261,531,321
541,161,461,051,181
712,781,271,822,612,891,571,652,222,002,172,342,122
100-4980801100-4980801200-498080
300-4980801300-4980801400-4980801
-4980801500-4980801600-4980801
500
700-4980801700-498080180
V004-083/V064
SRETAEHV032-2(
)SEIRESNI
V575
SRETAEHV882-2(
SEIRESNI
)
1
0-4980801
- 21 -
Page 22
NOTES
- 22 -
Page 23
FINISHED GOODS WARRANTY
The terms and conditions as described below in the General Warranty Policy cover all products
manufactured by National Refrigeration.
GENERAL WARRANTY POLICY
Subject to the terms and conditions hereof, the Company warrants all Products, including Service Parts, manufactured by the Company to be free of defects in material or workmanship, under normal
use and application for a period of one (1) year from the original date of installation, or eighteen (18) months from the date of shipment from the Company, whichever occurs first. Any replacement part(s) so supplied will be warranted for the balance of the product’s original warranty. The part(s) to be replaced must be made available in exchange for the replacement part(s) and reasonable proof of the original installation date of the product must be presented in order to establish the effective date of the warranty , failing which, the ef fective date will be based upon the date of manufacture plus thirty (30) days. Any labour, material, refrigerant, transportation, freight or other charges incurred in con­nection with the performance of this warranty will be the responsibility of the owner at the current rates and prices then in effect. This warranty may be transferred to a subsequent owner of the product.
THIS WARRANTY DOES NOT COVER
(a) Damages caused by accident, abuse, negligence, misuse, riot, fire, flood, or Acts of God (b) damages caused by operating the product in a corrosive atmosphere (c) damages caused by any unauthorized alteration or repair of the system affecting the product’s reliability or performance (d) damages caused by improper matching or application of the product or the product’s components (e) damages caused by failing to provide routine and proper maintenance or service to the product (f) expenses incurred for the erecting, disconnecting, or dismantling the product (g) parts used in connection with normal maintenance, such as filters or belts (h) products no longer at the site of the original installation (i) products installed or operated other than in accordance with the printed instructions, with the local installation or building codes and with good trade practices (j) products lost or stolen.
No one is authorized to change this WARRANTY or to create for or on behalf of the Company any other obligation or liability in connection with the Product(s). There is no other representation, warranty or condition in any respect, expressed or implied, made by or binding upon the Company other than the above or as provided by provincial or state law and which cannot be limited or excluded by such law , nor will we be liable in any way for incidental, consequential, or special damages however caused.
The provisions of this additional written warranty are in addition to and not a modification of or subtraction from the statutory warranties and other rights and remedies provided by Federal, Provincial or State laws.
PROJECT INFORMATION
metsyS
rebmuNledoM pU-tratSfoetaD
rebmuNlaireS rotcartnoCecivreS
tnaregirfeRenohP
ylppuSlacirtcelExaF
- 23 -
Page 24
“AS BUILT” SERVICE PARTS LIST
06/29/2007
Service Parts ListService Parts List
Service Parts List
Service Parts ListService Parts List
LL
abelabel
L
abel
LL
abelabel
TT
o Be Ao Be A
T
o Be A
TT
o Be Ao Be A
HEREHERE
HERE
HEREHERE
ttachedttached
ttached
ttachedttached
NA TIONAL REFRIGERA TION & AIR CONDITIONING CANADA CORP.
CANADA
159 ROY BL VD., BRANTFORD, ONT ARIO, CANADA N3R 7K1 PHONE: 1-800-463-9517 (519)751-0444 FAX (519)753-1140
Due to National Refrigeration’s policy of continuous product improvement, we reserve the right to make changes without notice.
USA
985 WHEELER WA Y, LANGHORNE, PA. 19047 USA PHONE:1-888-KEEPUS1 OR 1-888-533-7871
Loading...
Buy Points How it Works FAQ Contact Us Questions and Suggestions Privacy Policy Cookie Policy Terms of Use