Karma KM-5000 recliner Series Owner's Manual

KM-5000reclinerSeries

GENERAL WARNING

zDO maintain your chair well, in particular check the tyre(tire) pressure since

this affects the efficiency of the brakes.

zDO make sure both brakes are applied before getting in or out of the chair.
zDO make sure both brakes are applied when the chair is not being pushed or

used.

zDO take care when climbing kerb(curb) or turning on slopes.
zDO avoid steep or uneven surfaces that may cause the chair to tip over.
zDO avoid soft surfaces because the castors(casters) may become bogged

down.

zDO travel smoothly in all conditions.
zDO look well ahead to anticipate hazards such as furniture, doors, potholes,

slopes, kerbs(curbs), doorways etc.

zDO make sure that both feet are safely on the footrests and that clothing is

safely tucked out of the way so that it cannot get caught in the wheels.

zDO take care when travelling up or down or across inclines.
zDO keep both hands on the push handles to control the chair, if you are the

attendant.

zDO pay attention to keep the chair’s balance.
zDO check the frame and components regularly and refer to this user guide

during and after the warranty period.

zDO, when upholstery is loose, replace it with a new part.
zDO equip with anti-tippers to avoid falling backwards.
zDO equip with a seat belt designed for disabled people.
zDO equip with "heel loops" for disabled people.
zDO be far away of flame, it might injury user and damage the chair.
zDON'T overload the chair under any circumstances.
zDON'T hang anything heavy on the back of the chair that could cause the

chair to become unstable, particularly when negotiating inclines.

zDON'T allow more than one user at a time.
zDON'T use with an unconscious patient.
zDON'T use other transport to pull the wheelchair.
zDON'T do "wheelies", since you my fall or tip over backwards and suffer a

severe injury.

zDON'T go too fast or turn too quickly.
zDON’T travel across a slope greater than 7 degrees.
zDON'T stand on the footplates when getting in or out of the chair.
zDON'T go down steps forward.
zDON'T attempt to lift the wheelchair by any removable (detachable) parts.

Lifting by means of any removable (detachable) parts of the wheelchair may
result in injury to the user and/or attendant or damage to the wheelchair.

zDON’T use the wheelchair when back joint folded. This alters the centre of

gravity and may cause the wheelchair to tip backwards. It should only be
folded for storage or transport of the wheelchair.

zDON’T hang anything on the back joint that could cause the backrest to fold

suddenly and may cause injury.

i

YOU AND YOUR KARMA SERVICE PROVIDER

zNo tools are required for assembly. Your wheelchair should be set up by

your authorized Karma dealer. Your authorized Karma dealer is also your
service provider. Unauthorized repairs, upgrades and add-ons will negate
your warranty and may lead to injury. Any adjustments to the rear wheel
position should be carried out by your authorized Karma service provider.
Your Karma service provider has the necessary service/maintenance manual
for your wheelchair.

zIf you have any defective parts or lose any parts, please contact your dealer

for repair and/or replacement. Please only use parts authorized by Karma.
Use of parts that are not authorized by Karma will negate your warranty.

zCustomers should order parts through their dealer as well as all repairs and

scheduled maintenance.

zCustomers should go to their dealership for all service needs to guarantee

their warranty is not nullified. Always go to an authorized service provider.
Unauthorized repairs will nullify your warranty. Procedures other than those
described in this manual must be performed by a qualified technician. They
also have the service manual with a complete list of maintenance required to
keep your Karma wheelchair in good working order. Check the warranty
section of this manual to find out what Karma guarantees and what
maintenance and parts you will have to pay for.

zKarma does not have an official list of service providers at this time. Please

contact your dealer for service. If you cannot contact your dealer, please
contact another authorized Karma dealer for service. If this is not possible
please contact us and we will arrange for a service repair. Please note that
there will be a charge for collection and delivery of your wheelchair.

ii

CE MARKING

This wheelchair complies with the requirements of the Medical Devices
Directive 93/42/EEC.

CAUTION:

Before purchasing and using a Karma wheelchair, please consult a
qualified professional to ensure that you choose a suitable product and
receive training in how to use it. It may also be necessary to fit additional
equipment to your wheelchair or change your wheelchairs set up. Please
consult your service provider.

iii

TABLE OF CONTENTS

1. PREFACE .........................................................................1

2. SAFETY ............................................................................2

3. INTENDED USE & PARTS ...............................................6

4. OPERATION .....................................................................8

5. INSPECTION AND MAINTENANCE...............................20

6. OPTION AND ACCESSARIES........................................22

7. TROUBLESHOOTING ....................................................24

8. SPECIFICATIONS...........................................................25

9. CLEANING & RECYCLING.............................................26

10. WARRANTY..................................................................27

1. PREFACE

Please carefully read this owner's manual before using the wheelchair.
Improper use of the wheelchair could result in harm or injury. Therefore, for
safe and enjoyable use of the wheelchair, please read this owner's manual.

zThis owner's manual includes operation instructions for the aspects of the

wheelchair, unfolding/folding instructions and instructions on how to deal with
possible accidents.

zThis owner's manual is written for Karma wheelchair: KM-5000 recliner.
zThe symbols used in this manual are explained below. Pay special attention to

the parts marked with these symbols.

WARNING: Improper use could lead to serious injury or death.

CAUTION:

Improper use could lead to serious injury and/or
damage to your wheelchair.

SUGGESTION:

Follow these instructions to keep the wheelchair in
good condition.

zThis manual includes a repair and maintenance chart as well as details of your

warranty.

zIf someone else uses the wheelchair, make sure that you give them this owner's

manual for his or her reference.

zAs designs change, some illustrations and pictures in this manual may not

correspond to the wheelchair that you purchased. We reserve the right to make
design modifications without further notice. This manual will be updated
regularly please refer to the Karma website for the latest version.

1

2. SAFETY

2.1 Doorways

The safest way to operate the chair is on level floors that are free of obstacles.
Whenever possible use a ramp to enter or exit a facility. Keeping your hands
on the push rims will allow you to maintain maximum balance. Do not try to
force yourself over an obstruction by propulsion and never use the sides of a
doorway to pull yourself through a passageway.

2.2 Leaning

Do not lean over the side of your wheelchair since such an action may cause
your to lose balance and fall. (See Figure 2.1)

2.3 Navigating Inclines

¾Never turn on a hill due to the danger of tipping.
¾When pushing a wheelchair, go straight up a slope. If you need to go down,

walk backwards until user is on level ground. (See Figures 2.2 and 2.3)

¾Avoid stopping on an incline; it can potentially cause you to lose control of the

chair.

¾Do not use the parking brakes to slow down or stop the wheelchair; this could

cause it to seize up or pull to on side, causing you to lose control of the
wheelchair.

¾Whenever possible, navigate inclines with an attendant.

2.4 Kerbs(Curbs)

¾Whenever possible get help from an assistant/attendant (if you have assistance

make sure that your chair is equipped with push handles).

¾Avoid hard impacts when descending a kerb(curb). A hard impact could

adversely affect the chair.

¾Never try to scale or descend kerb(curb) that exceed a normal height (30-50mm).
¾Always be careful when climbing kerb(curb) and never move up or down a

kerb(curb) in reverse without an assistant.

2.5 Stairs

¾Always use two or more assistants. Tilt the wheelchair to its point of equilibrium.

One assistant (at the back) holds the wheelchair up against the first step,
gripping the handles firmly to lift. The second assistant, holding firmly a fixed
part of the front frame, lifts the wheelchair above the stairs and holds it while the
first attendant places one foot on the following step and repeat the operation
(See below Figure)

¾Never go down steps forwards.
¾Never use an escalator for transport, use an elevator.

2

2.6 Streets

¾Always use extreme caution when crossing streets. Reflective tape on the chair

and/or your clothing will make you more visible to drivers.

¾Avoid potholes and rough terrain that might cause the castors(casters) to

become stuck. (See Figure 2.4)

2.7 General

¾Always make sure BOTH brakes are applied before getting in or out of the chair.
¾Never stand on the footplates when getting in or out of the chair.
¾Never carry more than one passenger. Karma wheelchairs are designed for

one user.

¾Please make sure your clothing does not get caught in the rear wheels.

2.8 Upholstery

¾When cleaning the upholstery, use warm water and a mild soap.
¾Upholstery cleaner/foam can also be used, but avoid other cleaning solvents.

2.9 Anti-tippers

Please purchase anti-tippers and always use them to avoid personal injury.
The distance between the rear wheel and the anti-tip wheel should be not less
than 5cm. The anti-tip should not be more than 5cm above the ground.

3

2.10 Maximum User Weight Limit

The KM-5000 series is suitable for users weighing not more than 115kg.
Please note loads exceeding maximum capacity can damage your wheelchair
and cause malfunctions creating a safety hazard. The warranty does not
cover damage caused by improper operation of the wheelchair.

2.11 Avoid General Misuse:

¾Please note any vehicle can cause injury if used incorrectly. This user guide

contains a number of cautions. Please follow these guidelines to increase your
safety. Please be aware that careless use endangers your own safety as well as
that of others. ALWAYS follow the Highway Code when outdoors and the
guidelines written in this manual. Your wheelchair will give years of safe use if
used sensibly and carefully.

¾Do not let children stand or play on the wheelchair. (See Figure 2.5)

Figure 2.1 Figure 2.2 Figure 2.3

Figure 2.4 Figure 2.5

4

2.12 Labelling

Please carefully read all the labelling on the wheelchair before using it.
Please do not remove them and protect them for future reference.

5