How it Works
JVC
Loading...
HR-S5600KR
Service Manual
20 pgs4.79 Mb0

JVC HR-S5600KR Service Manual

SERVICE MANUAL
VIDEO CASSETTE RECORDER
HR-S5600KR
m
ULTImARQUE
CABLE
/SAT
VCR
TV
TV/VCR
AUDIO
ENTER/ENTREE
123
2
456
DAILY/QTDN.
WEEKLY/HEBDO
VPS/PDC
89
7
AUX
0000
4
0
START
STOP
TV
DATE
DEBUT
FIN
PROG
EXPRESS
PROG
30 SEC
1
MENU
3
U
O
N
K
E
M
O
R
G
P
V
+
T
T V
+
–
V
T
–
T
G
V
O
P
R
LP20303-011
S-VIDEO
VIDEO (MONO)L—AUDIO—R
STANDBY/ON
OK
S-VHS ET
CH
REC LINK
+ 8 4
SP
0
6
15dB NORM
VCR
PLAY
STOP/EJECT
PAUSE
REC
TV/VCR
SP/EP
Regarding service information other than these sections, refer to the HR-S3600U/S4600U service manual (No. 82717). Also, be sure to note important safety precautions provided in the service manual.
FF
REW
JOG
SHUTTLE
G
-CODE
GENERAL
Power requirement : AC 110 – 220 V` , 60 Hz Power consumption
Power on : 19 W Power off : 4.0 W
Temperature
Operating : 5°C to 40°C
Storage : –20°C to 60°C Operating position : Horizontal only Dimensions (W x H x D) : 400 x 94 x 347 mm Weight : 3.8 kg Format : S-VHS/VHS NTSC standard Maximum recording time
SP : 210 min. with ST-210 video cassette
EP : 630 min. with ST-210 video cassette
VIDEO/AUDIO
Signal system : NTSC-type color signal and EIA
monochrome signal, 525 lines/60
fields Recording/ Playback system : DA-4 (Double Azimuth) head helical
scan system Signal-to-noise ratio : 45 dB Horizontal resolution : 240 lines (VHS)
400 lines (S-VHS) Frequency range
Normal audio : 70 Hz to 10,000 Hz Hi-Fi audio : 20 Hz to 20,000 Hz
Input/Output : RCA connectors (IN x 2, OUT x 1)
: S-Video connectors (IN x 2, OUT x 1)
TUNER
Tuning system : Frequency-synthesized tuner Channel coverage
VHF : Channels 2–13 UHF : Channels 14–69 CATV : 113 Channels
RF output : Channel 3 or 4 (switchable;
preset to Channel 3 when shipped) 75 ohms, unbalanced
TIMER
Clock reference : Quartz Program capacity : 1-year programmable timer/
8 programs
Memory backup time : Approx. 6 months
Estimated figure based on supplied fresh battery; actual performance may differ.
ACCESSORIES
Provided accessories : RF cable,
Infrared remote control unit, "AA" battery x 2, S-Video cable (4-pin)
Specifications shown are for SP mode unless otherwise specified. E. & O.E. Design and specifications subject to change without notice.
COPYRIGHT © 1999 VICTOR COMPANY OF JAPAN, LTD.
No. 82769
September 1999
TABLE OF CONTENTS
4. CHARTS AND DIAGRAMS
4.10 MAIN AND A/C HEAD CIRCUIT BOARDS............................................................................................................................. 4-23
4.14 DEMODULATOR SCHEMATIC DIAGRAM ............................................................................................................................ 4-33
4.15 DEMODULATOR CIRCUIT BOARD ...................................................................................................................................... 4-35
4.19 SWITCH/DISPLAY, REC SAFETY, JACK AND JOG CIRCUIT BOARDS .............................................................................. 4-41
4.20 FDP GRID ASSIGNMENT AND ANODE CONNECTION ....................................................................................................... 4-43
4.21 REMOTE CONTROL SCHEMATIC DIAGRAM ...................................................................................................................... 4-44
5. PARTS LIST
5.2 CABINET AND CHASSIS ASSEMBLY <M2> ............................................................................................................................. 5-2
The following table indicate main different points between models HR-S4600U and HR-S5600KR.
ITEM
MODEL
HR-S4600U HR-S5600KR
POWER VOLTAGE 120V, 60Hz 110 – 220V(60Hz)
FRONT PANEL COLOR BLACK CHAMPAGNE GOLD
FE HEAD USED NOT USED
HEAD CLEANER NOT USED USED
ASSEMBLE EDIT ZFE A.F.E.
INSERT EDIT USED NOT USED
AUDIO DUBBING USED NOT USED
STEREO DECODER MTS A2(KOREAN)
HiFi LEVEL METER NOT USED USED
SUMMER TIME ADJ. USED NOT USED
CHILD LOCK USED NOT USED
VCR Plus+ VCR+C3 G-CODE
REC RESUME NOT USED USED
AUTO CLOCK USED NOT USED
JUST CLOCK USED NOT USED
CABLE&DBS BOX CTL USED NOT USED
CM/MV ADVANCE USED NOT USED
ILLUMI FUNCTION USED NOT USED
The following table indicate different parts number between models HR-S4600U and HR-S5600KR.
PACKING AND ACCESSORY ASSEMBLY <M1>
REF. MODEL
!
NO ITEM
301 PACKING CASE LP30575-003B LP30575-024B
306 REMOTE CONTROLLER LP20303-009A LP20303-011B
! 310 INST BOOK(EN) LPT0190-001A — ! INST BOOK(KO) — LPT0294-001A
313 PIN CORD PEAC0359-120 —
315 LED CABLE ASSY PEAC0370 —
316 WARRANTY CARD — BT-56009-2M
317 Q.S.SHEET LPT0190-002A —
319 REGIST.CARD BT-51020-2 —
Notes : Mark — is not used.
1
HR-S4600U HR-S5600KR
CABINET AND CHASSIS ASSEMBLY <M2>
REF. MODEL
!
NO ITEM
! 501 FRONT PANEL ASSY LP10217-004D LP10217-023A
501A CASSETTE DOOR LP20342-031C LP20342-043A 501C DISPLAY WINDOW LP30531-002B LP30531-019A
! 502 TOP COVER PQ11676-83 PQ11676-81
503 TAP SCREW QYTDSF3010M QYTDSF3010R 505 DRUM SUB ASSY LP20617-008A LP20617-006A 505A UPPER DRUM ASSY LP20030-015A LP20616-003A
! 511 BOTTOM CHASSIS LP10116-001E LP10116-003G
518 CLEANER ASSY — LP40369-001D 518A CLEANER ROLLER — PQ46418-1-2 518B CLEANER — PQ46419-1-2 518C CLEANER ARM — LP30407-001D
! 523 POWER CORD QMPD190-170-K PQ21730N
529 KNOB(JOG) LP30121-007A LP30121-005A 530 KNOB SHUTTLE LP30120-007A LP30120-005A 533 SPECIAL SCREW, MECHA
MAIN BOARD ASSEMBLY <03>
REF. MODEL
!
NO ITEM
PW1 MAIN BOARD ASSY LPA10048-04C1 LPA10048-17D1 IC201 IC(OSD) LC74785N-9762 LC74788N-9612 IC2201 IC AN3650NFBP AN3651FBP IC3001 IC(MCU) HD6432194A05F HD6432193A18F Q34 TRANSISTOR — 2SC4081/S/-X Q35 TRANSISTOR — 2SC4081/S/-X Q36 TRANSISTOR — 2SC4081/S/-X Q37 TRANSISTOR — 2SC4081/S/-X Q203 DIGI TRANSISTOR UN521E — Q208 TRANSISTOR 2SC4081/QRS/-X 2SD1819A/QRS/-X Q401 TRANSISTOR 2SA1576A/QR/-X — Q402 DIGI TRANSISTOR UN521E — Q403 DIGI TRANSISTOR UN521E — Q404 TRANSISTOR 2SA1576A/QR/-X — Q405 TRANSISTOR 2SA1576A/QR/-X — Q2061 TRANSISTOR 2SC4081/QRS/-X — Q2062 TRANSISTOR 2SA1576A/QR/-X — Q2063 DIGI TRANSISTOR DTC144WU — Q2103 TRANSISTOR 2SC4081/QRS/-X — Q5101 FET 2SK2043-CB14 2SK2632-CB14 Q6551 TRANSISTOR 2SC1740S/QRS/-T — Q7201 TRANSISTOR 2SD1292/QR/-T — D204 SI DIODE 1SS355 — D5105 SI DIODE — 1SS133-T2 D5201 DIODE AU01Z AK04-T2 D6551 ZENER DIODE MTZJ10B-T2 — R60 MG RESISTOR NRSA02J-0R0X — R73 MG RESISTOR — NRSA02J-683X R120 MG RESISTOR — NRSA02J-102X R121 MG RESISTOR — NRSA02J-102X R202 MG RESISTO — NRSA02J-103X R203 MG RESISTOR — NRSA02J-103X R204 MG RESISTOR — NRSA02J-103X R207 MG RESISTOR NRSA02J-0R0X —
*
HR-S4600U HR-S5600KR
PQ40413
HR-S4600U HR-S5600KR
Notes : Mark — is not used.
Nark Mark
is same as left.
HR-S4600U was also changed.
*
2
REF. MODEL
!
NO ITEM
HR-S4600U HR-S5600KR
R208 MG RESISTOR NRSA02J-222X NRSA02J-0R0X R215 MG RESISTOR NRSA02J-103X — R216 MG RESISTOR — NRSA02J-103X R217 MG RESISTOR NRSA02J-103X — R219 MG RESISTOR NRSA02J-102X — R223 MG RESISTOR NRSA02J-0R0X — R401 MG RESISTOR NRSA02J-473X — R402 MG RESISTOR NRSA02J-472X — R403 MG RESISTOR NRSA02J-473X — R404 MG RESISTOR NRSA02J-683X — R405 MG RESISTOR NRSA02J-473X — R408 MG RESISTOR NRSA02J-681X — R409 MG RESISTOR NRSA02J-102X — R410 MG RESISTOR NRSA02J-221X — R2054 MG RESISTOR NRSA02J-153X NRSA02J-123X R2056 MG RESISTOR NRSA02J-101X NRSA02J-820X R2061 MG RESISTOR NRSA02J-273X — R2062 MG RESISTOR NRSA02J-3R3X — R2063 RESISTOR QRE141J-151Y QUY153-050Y R2064 MG RESISTOR NRSA02J-473X — R2065 MG RESISTOR NRSA02J-183X — R2106 MG RESISTOR NRSA02J-103X — R2107 MG RESISTOR NRSA02J-102X — R3232 MG RESISTOR — NRSA02J-103X R3242 MG RESISTOR — NRSA02J-0R0X R3247 MG RESISTOR NRSA02J-0R0X — R3252 MG RESISTOR — NRSA02J-0R0X
! R5001 RESISTOR QRZ9046-475Z —
R5107 RESISTOR QRE121J-561Y QRE121J-331Y R5108 RESISTOR QRE141J-152Y QRE141J-222Y R5111 MG RESISTOR — NRSA02J-821X R5112 MG RESISTOR — NRSA02J-221X R5301 RESISTOR QUY153-050 Y QRE141J-2R7Y R6032 MG RESISTOR NRSA02J-123X — R6508 MG RESISTOR NRSA02J-0R0X NRSA02J-682X R6509 MG RESISTOR — NRSA02J-682X R6510 MG RESISTOR NRSA02J-0R0X NRSA02J-682X R6511 MG RESISTOR — NRSA02J-682X R6551 MG RESISTOR NRSA02J-331X — R6552 MG RESISTOR NRSA02J-101X — R6553 MG RESISTOR QRE141J-471Y — R6554 MG RESISTOR NRSA02J-471X — R7202 MG RESISTOR NRSA02J-221X — R7203 MG RESISTOR NRSA02J-472X — R7204 OMF RESISTOR QRL01DJ-100X — R7211 MG RESISTOR NRSA02J-101X — R7531 MG RESISTOR — NRSA02J-0R0X R7532 MG RESISTOR — NRSA02J-101X R7533 MG RESISTOR — NRSA02J-101X C3 CAPACITOR NCF21CZ-105X NCB21HK-103X C5 CAPACITOR NCF21CZ-105X NCB21HK-103X C9 CAPACITOR NCF21CZ-105X NCB21HK-103X C11 CAPACITOR NCF21CZ-105X NCB21HK-103X C164 CAPACITOR — NCB21HK-221X C165 CAPACITOR — NCB21HK-221X
Notes : Mark — is not used.
3
REF. MODEL
!
NO ITEM
HR-S4600U HR-S5600KR
C202 CAPACITOR NCB21CK-224X — C209 CAPACITOR — NCB21CK-224X C220 CAPACITOR NCB21HK-103X — C402 CAPACITOR NCB21HK-103X — C403 CAPACITOR NDC21HJ-220X — C404 CAPACITOR NCS21HJ-681X — C405 CAPACITOR NDC21HJ-220X — C406 CAPACITOR NDC21HJ-180X — C407 CAPACITOR NCB21HK-223X — C408 CAPACITOR NDC21HJ-151X — C409 CAPACITOR NCB21HK-103X — C2052 M CAPACITOR QFLC1HJ-333Z QFLC1HJ-823Z C2053 CAPACITOR NCB21HK-332X NCB21HK-472X C2054 CAPACITOR NCB21HK-103X NCB21HK-223X C2061 M CAPACITOR QFLC1HJ-333Z — C2062 CAPACITOR NCB21HK-332X — C2063 CAPACITOR NCB21HK-103X — C2064 E CAPACITOR QEKJ1CM-106Z — C2216 E CAPACITOR — QEKJ1HM-105Z C2217 E CAPACITOR — QEKJ1HM-105Z C2262 CAPACITOR NDC21HJ-101X — C2263 CAPACITOR NDC21HJ-101X — C3011 E CAPACITOR QETL0JM-478 QETL0JM-338 C3024 CAPACITOR NDC21HJ-120X NDC21HJ-220X C3025 TRIM CAPACITOR — QAT3725-300Z C3041 CAPACITOR NDC21HJ-100X —
! C5004 CAPACITOR QCZ9073-472 —
C5005 CAPACITOR — QCZ9071-222 C5006 E CAPACITOR QETM2DM-157 QEZ0374-826 C5106 CAPACITOR — QCBB1HJ-271 C6037 E CAPACITOR QEKJ1CM-106Z — C6519 CAPACITOR — NCB21EK-223X C6520 CAPACITOR — NCB21EK-223X C7202 E CAPACITOR QETN0JM-477 — L205 COIL/IM BUS WIRE QQL071J-4R7Y QUY153-050Y L402 INDUCTOR QQL231J-150Y — L7201 P COIL QQL01BJ-101Z — CN1 FPC CONNECTOR QGF1028C1-13 QGF1028C1-11 HS1 HEAT SINK, Q5101 LP40090-001A LP40515-001A
! F5001 FUSE QMF51N2-1R25J1 QMF51E2-2R0J1
OT3 TAP SCREW, Q5101 QYTDST3006Z QYTDST3008Z T2051 OSC TRANSFORMER PELN0860 PELN0832 T2052 OSC TRANSFORMER PELN0861 —
! TB1 TERMINAL BOARD ASSY LP30560-003C LP30560-013C
TU6001
!
SG5001
!
VA5001
!
VA5002
!
PC5101
TUNER QAU0113-002 QAU0125-001 SURGE ABSORBER QAF0046-242Z — VARISTOR QAF0023-431Z QAF0026-621 VARISTOR QAF0023-431Z — PH COUPLER PS2501-1 PS2561L-1(WL)
X3001 CRYSTAL QAX0444-001 QAX0445-001
Notes : Mark — is not used.
4
2D SVHS BOARD ASSEMBLY <05>
REF. MODEL
!
NO ITEM
PW1 2D SVHS BOARD ASSY LPA10017-10B LPA10017-11B R1007 MG RESISTOR NRSA02J-0R0X NRSA02J-473X R1035 MG RESISTOR — NRSA02J-0R0X
DEMOD BOARD ASSEMBLY <14>
REF. MODEL
!
NO ITEM
PW1 DEMOD BOARD ASSY PB11076A PB11091A IC1501 IC UPC1852AGT KA2268 Q1501 TRANSISTOR — 2SC1740S/QRS/-T Q1502 DIGI TRANSISTOR — DTC144WSA-T R1501 MG RESISTOR QRE141J-102Y NRSA02J-471X R1502 MG RESISTOR QRE141J-334Y NRSA02J-102X R1503 MG RESISTOR QRE141J-124Y NRSA02J-822X R1504 MG RESISTOR QRE141J-302Y NRSA02J-103X R1505 MG RESISTOR QRE141J-512Y NRSA02J-473X R1506 MG RESISTOR QRE141J-333Y NRSA02J-101X R1507 MG RESISTOR QRE141J-333Y NRSA02J-102X R1508 MG RESISTOR QRE141J-392Y NRSA02J-273X R1509 MG RESISTOR QRE141J-122Y NRSA02J-103X R1510 MG RESISTOR QRE141J-392Y NRSA02J-563X R1511 MG RESISTOR QRE141J-122Y NRSA02J-562X R1512 MG RESISTOR — NRSA02J-332X R1513 MG RESISTOR — NRSA02J-123X R1514 MG RESISTOR — NRSA02J-123X R1515 MG RESISTOR — NRSA02J-562X R1516 MG RESISTOR — NRSA02J-273X R1517 MG RESISTOR QRE141J-123Y NRSA02J-103X R1518 MG RESISTOR — NRSA02J-102X R1520 MG RESISTOR — NRSA02J-102X R1521 MG RESISTOR — NRSA02J-471X VR1501 V RESISTOR — QVPA606-103Z VR1502 V RESISTOR — QVPA606-683Z C1501 CAPACITOR QETC1CM-226Z NCB21EK-473X C1502 E CAPASITOR QETC1HM-104Z QEKC1CM-106Z C1503 CAPACITOR QTEC1HM-105Z NCB21HK-471X C1504 E CAPASITOR QTEC1HM-475Z — C1505 CAPACITOR QTEC1HM-225Z NDC21HJ-470X C1506 CAPACITOR QTEC1HM-104Z NDC21HJ-470X C1507 CAPACITOR QFV11HJ-473Z NCB21EK-104X C1508 MF CAPACITOR QETC1HM-474Z QFV11HJ-124Z C1509 CAPACITOR QETC1HM-104Z NCB21EK-104X C1510 CAPACITOR QETC1HM-105Z NCB21EK-473X C1511 E CAPASITOR QETC1HM-105Z — C1512 CAPACITOR QETC1HM-105Z NCB21EK-683X C1513 E CAPASITOR QEE81CJ-335Z QEKC1EM-475Z C1514 E CAPASITOR QEE81CJ-106Z QEKC1EM-475Z C1515 M CAPASITOR QETC1HM-105Z QFLC1HJ-683Z C1516 CAPACITOR QETC1HM-106Z NCB21EK-473X C1517 E CAPASITOR QETC1HM-106Z QETC1CM-227Z C1518 E CAPASITOR QETC1HM-105Z QEKC1CM-106Z C1519 E CAPASITOR — QEKC1CM-106Z
Notes : Mark — is not used.
5
HR-S4600U HR-S5600KR
HR-S4600U HR-S5600KR
Loading...
+ 14 hidden pages
Buy Points How it Works FAQ Contact Us Questions and Suggestions Privacy Policy Cookie Policy Terms of Use