SERVICE MANUAL
PUSH JOG
VIDEO CASSETTE RECORDER
HR-J7007UM
CABLE
/SAT
VCR
TV
AUDIO
TV/VCR
123
2
456
DAILY/QTDN.
WEEKLY/HEBDO
VPS/PDC
89
7
0000
AUX
4
0
STOP
START
DATE
PR
FIN
DEBUT
EXPRESS
1
PROG
30 SEC
E
N
T
E
R
/
E
N
T
R
E
E
3
U
O
N
K
E
M
TV PR +
TV
+
V
–
T
TV PR –
POWER
+
VIDEO (MONO)L—AUDIO—R
¢
PUSH JOG
SP EP
–
VCR
4
CH
Regarding service information other than these sections, refer to the HR-VP68U service manual (No. 82777).
Also, be sure to note important safety precautions provided in the service manual.
SPECIFICATIONS
GENERAL
Power requirement : AC 110 V – 220 V` , 50/60 Hz
Power consumption
Power on : 19 W
Power off : 2.5 W
Temperature
Operating : 5°C to 40°C (41°F to 104°F)
Storage : –20°C to 60°C (–4°F to140°F)
Operating position : Horizontal only
Dimensions (W x H x D) : 400 mm x 94 mm x 278 mm
3
/4" x 3-3/4" x 10-15/16")
(15Weight : 3.2 kg (7.1 lbs)
Format : VHS NTSC standard
Maximum recording time
SP : 210 min. with ST-210 video
cassette
EP : 630 min. with ST-210 video
cassette
VIDEO/AUDIO
Signal system : NTSC-type color signal and
EIA monochrome signal,
525 lines/60 fields
Recording/
Playback system : DA-4 (Double Azimuth) head
helical scan system
Signal-to-noise ratio : 45 dB
Horizontal resolution : 230 lines
Frequency range
Normal audio : 70 Hz to 10,000 Hz
Hi-Fi audio : 20 Hz to 20,000 Hz
Input/Output : RCA connectors
(IN x 1, OUT x 1)
TUNER
Tuning system : Frequency-synthesized tuner
Channel coverage
VHF : Channels 2–13
UHF : Channels 14–69
CATV : 113 Channels
RF output : Channel 3 or 4 (switchable; preset to
TIMER
Clock reference : Quartz
Program capacity : 1-year programmable timer/
Memory backup time : Approx. 6 months
ACCESSORIES
Supplied accessories : RF cable,
Specifications shown are for SP mode unless otherwise specified.
E. & O.E. Design and specifications subject to change without notice.
PLAY
MENU
FF
REW
REC PAUSESTOP/EJECT
OK
Channel 3 when shipped) 75 Ω,
unbalanced
8 programs
Estimated figure based on
supplied fresh battery; actual
performance may differ.
Infrared remote control unit,
Lithium battery CR2025,
Conversion plug,
"AA" battery x 2
This service manual is made from all recycled paper.
COPYRIGHT © 2000 VICTOR COMPANY OF JAPAN, LTD.
No. 82795
April 2000
TABLE OF CONTENTS
DIFFERENT TABLE .............................................................................................................................................................. 1, 2
4. CHARTS AND DIAGRAM (4-1 only)
4.1 REMOTE CONTROL SCHEMATIC DIAGRAM ............................................................................................................ 4-1
5. PARTS LIST (5-1 to 5-3)
5.1 PACKING AND ACCESSORY ASSEMBLY <M1> ........................................................................................................ 5-1
5.2 CABINET AND CHASSIS ASSEMBLY <M2> ............................................................................................................... 5-2
The following table indicate main different points between models HR-VP68U and HR-J7007UM.
ITEM
MODEL
HR-VP68U HR-J7007UM
JOG/SHUTTEL DIAL ON DECK NOT USED USED
POWER VOLTAGE(RATING) 120V,60Hz 110-220V,50/60Hz
POWER PLUG UL,CSA SASO
POWER SAVE USED NOT USED
FRONT PANEL COLOR DARK GRAY LIGHT SILVER
AUTO PICTURE AUTO PICTURE A.V.CALIBRATION
BACKUP TIME 3MIN 6Month(Li Batt)
VCR PLUS+ USED NOT USED
AUTO CLOCK USED NOT USED
CABLE BOX & DBS RECEIVER CONTROL USED NOT USED
AUDIO/VIDEO IN for REAR USED NOT USED
ILLUMI FUNC. USED NOT USED
CABLE MOUSE USED NOT USED
The following table indicate different parts number between models HR-VP68U and HR-J7007UM.
PACKING AND ACCESSORY ASSEMBLY <M1>
REF. MODEL
NO ITEM
301 PACKING CASE LP30708-007A LP30658-017B
302 CUSHION ASSY LP30671-001C LP30718-001A
303 POLY BAG PQM30021-92 PQM30021-93
306 REMOTE CONTROLLER LP20303-015A LP20878-004A
306A COVER(BATTERY) LP40225-002A LP40610-002A
! 309 LT. BATTERY — PECA0903
! 310 INST.BOOK(EN.SP) LPT0345-001B LPT0373-001A
312 RF CABLE PEAC0294-04 PEAC0446-120
! 313 CONVERSION PLUG — PEMC1012
317 REGIST.CARD BT-51020-2 —
318 Q.S.SHEET LPT0345-002A —
320 CONNECTION SHEET — PU36560-2
HR-VP68U HR-J7007UM
CABINET AND CHASSIS ASSEMBLY <M2>
REF. MODEL
NO ITEM
! 501 FRONT PANEL ASSY LP10293-003D LP10289-032B
501A CASSETTE DOOR LP20868-003A LP20868-007A
501C DISPLAY WINDOW LP20869-015A LP20869-042A
! 502 TOP COVER PQ11898-26-18 LP10013-027C
! 511 BOTTOM CHASSIS LP20262-010B LP10108-009C
! 517 POWER CORD QMPD190-170-K QMP73J0-170
518 CLEANER ASSY — LP40369-001D
518A CLEANER ROLLER — PQ46418-1-2
518B CLEANER — PQ46419-1-2
518C CLEANER ARM — LP30407-001D
520 CAP,LT. BATTERY — LP30336-001A
HR-VP68U HR-J7007UM
Notes : Mark — is not used.
1
MAIN BOARD ASSEMBLY <03>
REF. MODEL
NO ITEM
PW1 MAIN BOARD ASSY LPA10088-06E1 LPA10088-10C1
IC3004 IC M24C04-BN6 M24C02-BN6
Q3005 TRANSISTOR UN521K —
Q5101 POWER MOS FET 2SK3048-LT 2SK2632-CB14
Q6501 DIGI TRANSISTOR DTC143TU —
Q6502 DIGI TRANSISTOR DTC143TU —
Q7201 TRANSISTOR 2SA720/RS/-T —
D3007 SI DIODE 1SS355 —
D3008 SB DIODE — RB721Q-40
D5105 SI DIODE — 1SS133
R107 RESISTOR ——
R2007 MG RESISTOR NRSA02J-393X —
R2010 MG RESISTOR NRSA02J-123X —
R2219 MG RESISTOR NRSA02J-393X —
R2224 MG RESISTOR NRSA02J-123X —
R2603 MG RESISTOR NRSA02J-101X —
R3003 MG RESISTOR NRSA02J-102X —
R3013 MG RESISTOR NRSA02J-102X —
R3236 MG RESISTOR NRS181J-103X —
R3082 MG RESISTOR NRSA02J-102X —
R3235 RESISTOR — QRE141J-102Y
! R5001 RESISTOR QRZ9046-475Z —
R5108 MG RESISTOR NRSA02J-152X NRSA02J-222X
R5111 MG RESISTOR — NRSA02J-821X
R5112 MG RESISTOR — NRSA02J-221X
R5306 MG RESISTOR NRSA02J-823X NRSA02J-563X
R7025 MG RESISTOR — NRSA02J-472X
R7202 MG RESISTOR NRSA02J-471X —
R7203 MG RESISTOR NRSA02J-222X —
R7204 RESISTOR QRE123J-100X —
C3018 TRIM CAPACITOR — QAT3725-300Z
C3019 CAPACITOR NDC21HJ-180X NDC21HJ-100X
C3055 E CAPACITOR QEKJ0JM-337 —
! C5004 CAPACITOR QCZ9094-472 QCZ9071-222
C5006 E CAPACITOR QETM2DM-826 QEZ0374-826
C5106 CAPACITOR — QCBB1HJ-271Y
C5304 M CAPACITOR QFLC1HJ-823Z QFLC1HJ-563Z
C5310 M CAPACITOR QFLC1HJ-393Z —
C7206 E CAPACITOR QETF0JM-227Z —
L7201 P COIL QQL29BJ-101Z —
! TB1 TERMINAL BOARD LP20316-001B LP20316-003B
FW3001 PARA RIBON WIRE QUM022-13A4A4 —
FW3002 PARA RIBON WIRE QUM022-30A4A4 —
FW7106 PARA RIBON WIRE — QUM022-30A4A4
! SG5001 SURGE ABSORBER QAF0046-242Z —
! VA5001 VARISTOR QAF0023-431Z —
! VA5002 VARISTOR QAF0023-431Z —
! VA5003 VARISTOR — QAF0026-621
! PC5101 IC(PHOTO COUPLER) PS2501-1 PS2561L1-1/WL/
! F5001 FUSE QMF51N2-1R25J1 QMF51E2-2R0
J1 PIN JACK,A/V IN QNN0285-002 —
S7008 TACT SWITCH,PLAY — QSW0456-002Z
HR-VP68U HR-J7007UM
R.PAUSE BOARD ASSEMBLY <06>
REF. MODEL
NO ITEM
PW2 R.PAUSE BOARD ASSY LPA10088-01A2 —
HR-VP68U HR-J7007UM
C.BOX BOARD ASSEMBLY <92>
REF. MODEL
NO ITEM
PW3 C.BOX BOARD ASSY LPA10088-01A3 —
HR-VP68U HR-J7007UM
LT. BATTERY BOARD ASSEMBLY <93>
REF. MODEL
NO ITEM
PW4 LT. BATTERY BOARD ASSY — LPA10088-01A4
BT3001 BATTERY HOLDER — QNZ0032-001
HR-VP68U HR-J7007UM
Notes : Mark — is not used.
2
SECTION 4
CHARTS AND DIAGRAM
4.1
REMOTE CONTROL SCHEMATIC DIAGRAM
5
+
)
CH
(
PROG
CANCEL
VCR
-/--
OPERATE
CABLE/SAT
-
)
CH
(
PROG
AUDIO/MUTE
/TV PROG+
OK/ENTER
/TV PROG-
4
3
2
1
4-1
ABCD
SECTION 5
PARTS LIST
SAFETY PRECAUTION
Parts identified by the symbol are critical for safety. Replace only with specified part numbers.
5.1 PACKING AND ACCESSORY ASSEMBLY <M1>
The instruction manual to be provided with this product will differ according to the destination.
307
312
306
306A
ADHESIVE
TAPE
309
313
302
CABINET & CHASSIS ASSY
<M2>
311
308
310
320
303
302
301
# REF No. PART No. PART NAME, DESCRIPTION # REF No. PART No. PART NAME, DESCRIPTION
--------------- ----------------------- ----------------------------------------------------- ---------------- ----------------------- ------------------------------------------------------
✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽
PACKING AND ACCESSORY ASSEMBLY <M1>
301 LP30658-017B PACKING CASE
302 LP30718-001A CUSHION ASSY
303 PQM30021-93 POLY BAG
306 LP20878-004B REMOTE CONTROLLER
306A LP40610-002A COVER(BATTERY)
!
!
!
SPEC OF BARCODE
307 – BATTERY,X2(“AA”TYPE)
308 QPC02202230P POLY BAG
309 PECA0903 LT.BATTERY
310 LPT0373-001B INST.BOOK(EN,SP)
311 QPC02503530P POLY BAG
312 PEAC0446-120 RF CABLE
313 PEMC1012 CONVERSION PLUG
320 PU36560-2 CONECTION SHEET
5-1
5.2 CABINET AND CHASSIS ASSEMBLY <M2>
BEWARE OF BOGUS PARTS
Parts that do not meet specifications may cause trouble
in regard to safety and performance. We recommend that
genuine JVC parts be used.
509
510
516
505
505F
505E
508
507
507
505D
505C
505H
525
506
505B
505A
505G
WR1
A
K
518
518B
518A
518C
K
510
522
B
WR2
515
512
503
MAIN BOARD
ASSY <03>
522
524
LT BATTERY
BOARD ASSY <93>
H
H
B
A
C
504
502
503
(Incl. <03>)
520
517
501C
MECHANISM
ASSY <M4>
516
514
D
501A
501B
513
501
D
SPEC OF BARCODE
511
MINI FRONT
BOARD ASSY <28>
523
WR3
C
5-2
# REF No. PART No. PART NAME, DESCRIPTION # REF No. PART No. PART NAME, DESCRIPTION
--------------- ----------------------- ----------------------------------------------------- ---------------- ----------------------- ------------------------------------------------------
✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽
CABINET AND CHASSIS ASSEMBLY
!
501 LP10289-032B FRONT PANEL ASSY
501A LP20868-007A CASSETTE DOOR
501B PQ46448 TORSION SPRING
501C LP20869-042A DISPLAY WINDOW
!
502 LP10013-027C TOP COVER
503 QYTDSF3010M SCREW,X2 TOP COVER(SIDE)
504 QYTDSF3010M SCREW,TOP COVER(REAR)
505 LP20617-001A DRUM SUB ASSY
505A LP20616-001A UPPER DRUM ASSY
505B PDM4439 CAP
505C PDM4444-19-2 WASHER
505D LP40572-001A COLLAR ASSY
505E LP40323-001A CONTACT
505F LP30004-014A COMPRESSION SPRING
505G LP40174-001B FPC PLATE
505H LP20615-001A LOWER DRUM ASSY
506 PDZ0179-1-4 ROTOR ASSY
507 QYSPSP3006Z SCREW,X2
!
508 QAR0119-001 STATOR ASSY
509 QYSPSPH2606Z SCREW,X2
510 QYTDST2610Z SCREW,X3 DRUM
!
511 LP10108-009C BOTTOM CHASSIS
512 QYTDSF3010Z SCREW,MAIN
513 LP30312-001B BRACKET(CHASSIS)
514 QYTDSF3010Z SCREW,X2
515 QYTDSF4012Z SCREW,MECHA
516 QYTDSF3010Z SCREW,X2 MECHA
!
517 QMP73J0-170 POWER CORD
518 LP40369-001D CLEANER ASSY
518A PQ46418-1-2 CLEANER ROLLER
518B PQ46419-1-2 CLEANER
518C LP30407-001D CLEANER ARM
520 LP30336-001A CAP.LT.BATTERY
522 LP40226-001A PC SUPPORT,X2
523 LP40628-001A PC SUPPORT
524 LP40253-001B STOPPER
525 PQ40413 SPECIAL SCREW,MECHA
WR1 QUQ212-0518CG FFC WIRE,DRUM CN3002
WR2 WJT0005-002A E-CARD WIRE,A/C HEAD CN2001
WR3 QUQ112-0914CG FFC WIRE,FRONT CN7001
<M2>
E. & O. E. No. 82795
(Sanwa)-V13D15
5-3
VICTOR COMPANY OF JAPAN, LIMITED
VIDEO DIVISION
S40894
Printed in Japan
Loading...