Page 1
SERVICE MANUAL
DIGITAL VIDEO CAMERA
GR-DVL805KR
Regarding service information other than these sections, refer to the GR-DVL805U service manual (No.86550).
Also, be sure to note important safety precautions provided in the service manual.
VICTOR COMPANY OF JAPAN, LIMITED
VIDEO DIVISION
S40894
SPECIFICATIONS
Camcorder
For General
Power supply : DC 6.3 V (Using AC Power Adapter/Charger)
Power consumption
LCD monitor off, viewfinder on : Approx. 4.3 W
LCD monitor on, viewfinder off : Approx. 5.3 W
Video light : Approx. 3.5 W
Dimensions (W x H x D) : 80 mm x 96 mm x 159 mm (3-3/16" x 3-13/16" x 6-5/16")
Weight : Approx. 580 g (1.3 lbs)
Operating temperature :0°C to 40°C (32°F to 104°F)
Operating humidity : 35% to 80%
Storage temperature : –20°C to 50°C (–4°F to 122°F)
Pickup : 1/4" CCD
Lens : F 1.8, f = 3.6 mm to 36 mm, 10:1 power zoom lens
Filter diameter : ø37 mm
LCD monitor : 3.5" diagonally measured, LCD panel/TFT active matrix system
Viewfinder : Electronic viewfinder with 0.44" color LCD
Speaker : Monaural
For Digital Video Camera
Format : DV format (SD mode)
Signal format : NTSC standard
Recording/Playback format : Video: Digital component recording
Cassette : Mini DV cassette
Tape speed : SP: 18.8 mm/s
Maximum recording time : SP: 80 min.
(using 80 min. cassette) LP: 120 min.
For Digital Still Camera
Storage media : Built-in flash memory, 2 Mbyte
Compression system : JPEG (compatible)
File size : VGA: 640 x 480 pixels
Picture quality : 2 modes (FINE/STANDARD)
Approximate number of storable images
FINE :30
STANDARD :60
DC 7.2 V (Using battery pack)
(with the LCD monitor closed and the viewfinder pushed down)
: Audio: PCM digital recording, 32 kHz 4-channel (12-bit),
48 kHz 2-channel (16-bit)
LP: 12.5 mm/s
For Connectors
S :Y:1 V (p-p), 75Ω , analog output
AV
Video output :1 V (p-p), 75Ω , analog
Audio output : 300 mV (rms), 1 kΩ, analog, stereo
DV
Input/output : 4-pin, IEEE 1394 compliant
PC (DIGITAL PHOTO)
Digital still output : ø2.5 mm, 3-pole
JLIP/EDIT : ø3.5 mm, 4-pole
C : 0.29 V (p-p), 75Ω , analog output
AC Power Adapter/Charger AA-V40KR
Power requirement : AC 110 V to 220 V`, 60 Hz
Power consumption : 23 W
Output
Charge : DC 7.2 V
VTR : DC 6.3 V , 1.8 A
Dimensions (W x H x D) : 68 mm x 38 mm x 110 mm (2-11/16" x 1-1/2" x 4-3/8")
Weight : Approx. 250 g (0.56 lbs)
Specifications shown are for SP mode unless otherwise indicated. E & O.E. Design and specifications subject
to change without notice.
, 1.2 A
Printed in Japan
No.86563
July 2000
Page 2
TABLE OF CONTENTS
DIFFERENT TABLE
4. CHARTS AND DIAGRAMS
4.1 MAIN (TG/VGR) SCHEMATIC DIAGRAM .............................................................................................................. 4-1
4.2 BOARD INTERCONNECTION ............................................................................................................................... 4-2
4.3 CAMERA DSP SCHEMATIC DIAGRAM ................................................................................................................ 4-4
4.4 JACK CIRCUIT BOARD ......................................................................................................................................... 4-6
4.4 JUNCTION CIRCUIT BOARD ................................................................................................................................ 4-7
4.5 REAR CIRCUIT BOARD ........................................................................................................................................ 4-7
4.6 MAIN CIRCUIT BOARD ........................................................................................................................................ 4-8
5. PARTS LIST
5.1 PACKING ASSEMBLY <M1> ................................................................................................................................ 5-1
5.2 FINAL ASSEMBLY <M2> ..................................................................................................................................... 5-3
6. AC POWER ADAPTER
6.1 CABINET ASSEMBLY <MA> ................................................................................................................................ 6-1
6.2 SCHEMATIC DIAGRAM ........................................................................................................................................ 6-2
6.3 CIRCUIT BOARD................................................................................................................................................... 6-4
6.4 ELECTRICAL PARTS LIST ..................................................................................................................................... 6-5
The following table indicate main different points between models GR-DVL805U and GR-DVL805KR.
MODEL
ITEM
AC ADAPTER CHARGER AA-V40U AA-V40KR
GR-DVL805U
GR-DVL805KR
The following table indicate different parts number between models GR-DVL805U and GR-DVL805KR.
PACKING ASSEMBLY <M1>
REF NO.
1 PACKING CASE LY31631-008B LY31631-026A
5 INST. BOOK LYT0575-001B
6 INST. BOOK (SOFT, SET UP) LYT0576-001A
9 Q.CARD (JCA) YU10350 ––
10 WRRANTY INF. BT-51005-4 ––
11 REGIST. CARD BT-51020-2 ––
15 IB (CAPTURE) LYT0576-002A
16 IB (PICNAVI) LYT0576-003A
23 LENS CAP LY42182-001A LY42182-002A
29 AC POWER ADAPTER, CHAGER LY20591-001B
ITEM
MODEL
GR-DVL805U
(ENGLISH)
(ENGLISH)
(ENGLISH)
(ENGLISH)
(AA-V40U)
GR-DVL805KR
LYT0615-001A (KOREA)
LYT0616-001A (KOREA)
LYT0615-002A (KOREA)
LYT0616-003A (KOREA)
LY20591-010A
(AA-V40KR)
Note : Mark –– is not used.
1
Page 3
FINAL ASSEMBLY <M2>
REF NO.
101 LOWER CASE ASSY LY20560-001B LY20560-004B
104 CASS. COVER ASSY LY31609-001A LY31609-003C
104B BKT (E.KNOB) * LY42173-001A LY42173-001B
108 REAR COVER ASSY LY31596-001A LY31596-003B
111 UPPER CASE (3) ASSY LY20550-002A LY20550-006C
139 SCREW * LY30018-096A QYSPSPT1725R
143 SCREW * LY30018-059A QYSPSGT1760R
150 HOLDER (MECHA) ASSY * LY31618-001B LY31618-001C
150B SPECIAL SCREW LY30018-056A LY300180B4A
168 SHEET * –– LY42583-001A
ITEM
MODEL
GR-DVL805U
GR-DVL805KR
Note : Mark –– is not used.
Note : Mark * is GR-DVL-805U was also changed.
ELECTRONIC VIEWFINDER ASSEMBLY <M4>
REF NO.
300 COLOR VF UNIT * LY20596-001A LY20596-001B
306 HINGE (VF) ASSY * LY31602-001A LY31602-001C
ITEM
MODEL
GR-DVL805U
GR-DVL805KR
Note : Mark * is GR-DVL-805U was also changed.
MONITOR ASSEMBLY <M5>
REF NO.
501 MONITOR COVER ASSY * LY20565-006A LY20565-006B
ITEM
MODEL
GR-DVL805U
GR-DVL805KR
Note : Mark * is GR-DVL-805U was also changed.
2
Page 4
MAIN BOARD ASSEMBLY <01>
REF NO.
PW1 MAIN BOARD ASSY * YB10277F-02 YB10277F-05
R1077 MG RESISTOR * NRVA6AD-473W NRSA6AD-473W
R2102-
R2105 MG RESISTOR * NRSA6AJ-0R0W ––
R2205
R3007
R3201
R3202
R3215 MG RESISTOR * NRSA6AJ-0R0W ––
R3235
R3309
R3330
R3706 MG RESISTOR * NRSA6AJ-152W NRSA6AJ-102W
C2203
C2205
C2214
C2623
C3702 C CAPACITOR * NCFA1AZ-104W NCB30JK-105X
L2601-
L2603
IC5601 IC * –– TC7S32FU-X
IC5602 IC * –– TC7S04FU-X
R5602 MG RESISTOR * –– NRSA6AJ-0R0W
C5601
C5602
ITEM
C CAPACITOR * NBP21CM-105X NCB11CK-105X
MG RESISTOR * NRSA63J-0R0X ––
C CAPACITOR * –– NCBAIAK-104W
MODEL
GR-DVL805U
GR-DVL805KR
Note : Mark –– is not used.
Note : Mark * is GR-DVL-805U was also changed.
JUNCTION BOARD ASSEMBLY <05>
REF NO.
PW2 JUNCTION BOARD ASSY * YB10278A2-01 YB10278A2-02
ITEM
MODEL
GR-DVL805U
GR-DVL805KR
Note : Mark * is GR-DVL-805U was also changed.
JACK BOARD ASSEMBLY <06>
REF NO.
PW1 JACK BOARD ASSY * YB10287A2-01 YB10267A2-02
ITEM
MODEL
GR-DVL805U
GR-DVL805KR
Note : Mark * is GR-DVL-805U was also changed.
REAR BOARD ASSEMBLY <07>
REF NO.
PW3 REAR BOARD ASSY * YB10278A3-01 YB10278A3-02
ITEM
MODEL
GR-DVL805U
GR-DVL805KR
Note : Mark * is GR-DVL-805U was also changed.
3
Loading...