Page 1
Page 2
Page 3
Page 4
Page 5
Page 6
Page 7
Page 8
Page 9
Page 10
Page 11
Page 12
ILLUSTRATION NOT AVAILABLE AT TIME OF PUBLICATION
GROUP 1 - CATALOG NOTICES
ILLUSTRATION TITLE GROUP-FIG. NO.
CJ-5,6,7,8, SCRAMBLER CHASSIS SECTION GROUP NUMBERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 1-100
CJ-5,6,7,8, SCRAMBLER BODY SECTION GROUP NUMBERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 1-200
XJ CHEROKEE, XJ WAGONEER, COMANCHE CHASSIS SECTION GROUP NUMBERS . . . . . . . . . . . . . . . Fig. 1-300
XJ CHEROKEE, XJ WAGONEER, COMANCHE BODY SECTION GROUP NUMBERS . . . . . . . . . . . . . . . . . Fig. 1-400
SJ CHEROKEE, SJ WAGONEER , J10, J20 CHASSIS SECTION GROUP NUMBERS . . . . . . . . . . . . . . . . . Fig. 1-500
SJ CHEROKEE, SJ WAGONEER, J10, J20 BODY SECTION GROUP NUMBERS . . . . . . . . . . . . . . . . . . . . . Fig. 1-600
Page 13
CJ-5,6,7,8, SCRAMBLER CHASSIS SECTION GROUP NUMBERS
Figure 1-100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
AMC PLATE N CHRYSLER GROUP
10.00.1 - 10.99 09 Engine
11.00.0 - 11.19 07 Cooling
11.20.0 - 12.09 09 Engine
12.10.0 - 13.39 14 Fuel
13.40.0 - 13.79 25 Emission Systems
13.80.0 - 13.84 19 Steering
13.85.0 - 13.89 24 Heater and Air Conditioning
13.90.0 - 15.99 09 Engine
16.00.0 - 16.29 08 Electrical
16.30.0 - 16.99 07 Cooling
17.00.0 - 18.99 08 Electrical
19.00.0 - 19.29 07 Cooling
19.30.0 - 19.49 14 Fuel
19.50.0 - 19.79 11 Exhaust
19.80.0 - 19.99 09 Engine
20.00.0 - 20.99 06 Clutch
21.00.0 - 21.29 21M Transmission, Manual
21.30.0 - 21.39 06 Clutch
21.40.0 - 22.99 21M Transmission, Manual
23.00.0 - 24.89 21A Transmission, Automatic
24.90.0 - 24.99 07 Cooling
25.00.0 - 25.99 21M Transmission, Manual
26.00.0 - 26.09 16 Prop Shaft and U-Joints
26.10.0 - 26.99 02 Front Suspension
27.00.0 - 27.09 16 Prop Shafts
27.10.0 - 29.99 03 Rear Axles
30.00.0 - 30.99 13 Frame, Bumpers
31.00.0 - 31.39 02 Front Suspension and Drive
31.40.0 - 31.99 05 Service Brake
32.00.0 - 32.29 02 Front Suspension
32.30.0 - 32.99 05 Service Brake
33.00.0 - 33.39 17 Rear Suspension
33.40.0 - 33.99 05 Service Brake
34.00.0 - 34.09 17 Rear Suspension
34.10.0 - 34.29 03 Rear Axle
34.30.0 - 34.99 05 Service Brake
35.00.0 - 35.99 22 Wheels
36.00.0 - 36.99 19 Steering
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 14
CJ-5,6,7,8, SCRAMBLER CHASSIS SECTION GROUP NUMBERS
Figure 1-100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
37.00.0 - 37.29 05 Service Brake
37.30.0 - 37.39 06 Clutch
37.40.0 - 37.59 14 Fuel
37.60.0 - 37.99 05 Service Brake
38.00.0 - 38.19 04 Parking Brake
38.20.0 - 38.22 21M Transmission, Manual
38.23.0 - 38.24 21A Transmission, Automatic
38.25.0 - 38.99 21M Transmission, Manual
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 15
CJ-5,6,7,8, SCRAMBLER BODY SECTION GROUP NUMBERS
Figure 1-200
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
AMC PLATE N CHRYSLER GROUP
------- ------- --------------
39.00.0 - 39.99 13 Frame
40.00.0 - 46.99 23A Body - Sheet Metal Except Doors
47.00.0 - 48.99 23C Body - Doors and Related Parts
49.00.0 - 49.79 13 Frame
49.80.0 - 49.99 23A Body - Sheet Metal except Doors
50.00.0 - 54.99 23C Body - Doors, Misc.
55.00.0 - 55.19 13 Frame, Bumpers
55.20.0 - 55.79 23 Body - Exterior Ornamentation
55.80.0 - 55.99 07 Cooling
56.00.0 - 56.19 23 Body - Exterior Ornamentation
56.20.0 - 56.99 23C Body - Doors, Misc.
57.00.0 - 57.99 8A Body - Instrument Panel
58.00.0 - 58.29 23A Body - Sheet Metal
58.30.0 - 59.39 8A Body - Instrument Panel
58.40.0 - 59.79 IT Interior Trim
59.80.0 - 59.81 13 Frame, Bumpers
59.82.0 - 59.84 09 Engine
59.85.0 - 59.85 23 Body - Exterior Ornamentation
59.86.0 - 59.99 13 Frame, Bumpers
60.00.0 - 63.99 24 Heater, Air Conditioning
64.00.0 - 64.99 23A Body - Sheet Metal
65.00.0 - 67.99 23C Body - Doors, Misc.
68.00.0 - 68.99 23A Body - Sheet Metal
69.00.0 - 71.19 IT Interior Trim
71.20.0 - 71.89 23A Body - Sheet Metal
71.90.0 - 79.99 IT Interior Trim
80.00.0 - 82.99 08 Electrical
83.00.0 - 83.39 8A Body - Instrument Panel
83.40.0 - 83.99 14 Fuel
84.00.0 - 84.99 08 Electrical
85.00.0 - 86.19 23D Body - Miscellaneous
86.20.0 - 86.29 08 Electrical
86.30.0 - 86.99 8A Body - Instrument Panel
87.00.9 - 99.99 08 Electrical
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 16
XJ CHEROKEE, XJ WAGONEER, COMANCHE CHASSIS SECTION GROUP NUMBERS
Figure 1-300
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
AMC PLATE N CHRYSLER GROUP
10.00.1 - 10.99 09 Engine
11.00.0 - 11.19 07 Cooling
11.20.0 - 12.09 09 Engine
12.10.0 - 13.39 14 Fuel
13.40.0 - 13.79 25 Emission Systems
13.80.0 - 13.84 19 Steering
13.85.0 - 13.89 24 Heater and Air Conditioning
13.90.0 - 15.99 09 Engine
16.00.0 - 16.29 08 Electrical
16.30.0 - 16.99 07 Cooling
17.00.0 - 18.99 08 Electrical
19.00.0 - 19.29 07 Cooling
19.30.0 - 19.49 14 Fuel
19.50.0 - 19.79 11 Exhaust
19.80.0 - 19.99 09 Engine
20.00.0 - 20.99 06 Clutch
21.00.0 - 21.29 21M Transmission, Manual
21.30.0 - 21.39 06 Clutch
21.40.0 - 22.99 21M Transmission, Manual
23.00.0 - 24.89 21A Transmission, Automatic
24.90.0 - 24.99 07 Cooling
25.00.0 - 25.99 21M Transmission, Manual
26.00.0 - 26.09 16 Prop Shaft and U-Joints
26.10.0 - 26.99 02 Front Suspension
27.00.0 - 27.09 16 Prop Shafts
27.10.0 - 29.99 03 Rear Axles
30.00.0 - 30.99 13 Frame, Bumpers
31.00.0 - 31.39 02 Front Suspension and Drive
31.40.0 - 31.99 05 Service Brake
32.00.0 - 32.29 02 Front Suspension
32.30.0 - 32.99 05 Service Brake
33.00.0 - 33.39 17 Rear Suspension
33.40.0 - 33.99 05 Service Brake
34.00.0 - 34.09 17 Rear Suspension
34.10.0 - 34.29 03 Rear Axle
34.30.0 - 34.99 05 Service Brake
35.00.0 - 35.99 22 Wheels
36.00.0 - 36.99 19 Steering
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 17
XJ CHEROKEE, XJ WAGONEER, COMANCHE CHASSIS SECTION GROUP NUMBERS
Figure 1-300
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
37.00.0 - 37.29 05 Service Brake
37.30.0 - 37.39 06 Clutch
37.40.0 - 37.59 14 Fuel
37.60.0 - 37.99 05 Service Brake
38.00.0 - 38.19 04 Parking Brake
38.20.0 - 38.22 21M Transmission, Manual
38.23.0 - 38.24 21A Transmission, Automatic
38.25.0 - 38.99 21M Transmission, Manual
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 18
XJ CHEROKEE, XJ WAGONEER, COMANCHE BODY SECTION GROUP NUMBERS
Figure 1-400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
AMC PLATE N CHRYSLER GROUP
------- ------- --------------
39.00.0 - 39.99 13 Frame
40.00.0 - 46.99 23A Body - Sheet Metal Except Doors
47.00.0 - 48.99 23C Body - Doors and Related Parts
49.00.0 - 49.79 13 Frame
49.80.0 - 49.99 23A Body - Sheet Metal except Doors
50.00.0 - 54.99 23C Body - Doors, Misc.
55.00.0 - 55.19 13 Frame, Bumpers
55.20.0 - 55.79 23 Body - Exterior Ornamentation
55.80.0 - 55.99 07 Cooling
56.00.0 - 56.19 23 Body - Exterior Ornamentation
56.20.0 - 56.99 23C Body - Doors, Misc.
57.00.0 - 57.99 8A Body - Instrument Panel
58.00.0 - 58.29 23A Body - Sheet Metal
58.30.0 - 59.39 8A Body - Instrument Panel
58.40.0 - 59.79 IT Interior Trim
59.80.0 - 59.81 13 Frame, Bumpers
59.82.0 - 59.84 09 Engine
59.85.0 - 59.85 23 Body - Exterior Ornamentation
59.86.0 - 59.99 13 Frame, Bumpers
60.00.0 - 63.99 24 Heater, Air Conditioning
64.00.0 - 64.99 23A Body - Sheet Metal
65.00.0 - 67.99 23C Body - Doors, Misc.
68.00.0 - 68.99 23A Body - Sheet Metal
69.00.0 - 71.19 IT Interior Trim
71.20.0 - 71.89 23A Body - Sheet Metal
71.90.0 - 79.99 IT Interior Trim
80.00.0 - 82.99 08 Electrical
83.00.0 - 83.39 8A Body - Instrument Panel
83.40.0 - 83.99 14 Fuel
84.00.0 - 84.99 08 Electrical
85.00.0 - 86.19 23D Body - Miscellaneous
86.20.0 - 86.29 08 Electrical
86.30.0 - 86.99 8A Body - Instrument Panel
87.00.9 - 99.99 08 Electrical
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 19
SJ CHEROKEE, SJ WAGONEER , J10, J20 CHASSIS SECTION GROUP NUMBERS
Figure 1-500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
AMC PLATE N CHRYSLER GROUP
10.00.1 - 10.99 09 Engine
11.00.0 - 11.19 07 Cooling
11.20.0 - 12.09 09 Engine
12.10.0 - 13.39 14 Fuel
13.40.0 - 13.79 25 Emission Systems
13.80.0 - 13.84 19 Steering
13.85.0 - 13.89 24 Heater and Air Conditioning
13.90.0 - 15.99 09 Engine
16.00.0 - 16.29 08 Electrical
16.30.0 - 16.99 07 Cooling
17.00.0 - 18.99 08 Electrical
19.00.0 - 19.29 07 Cooling
19.30.0 - 19.49 14 Fuel
19.50.0 - 19.79 11 Exhaust
19.80.0 - 19.99 09 Engine
20.00.0 - 20.99 06 Clutch
21.00.0 - 21.29 21M Transmission, Manual
21.30.0 - 21.39 06 Clutch
21.40.0 - 22.99 21M Transmission, Manual
23.00.0 - 24.89 21A Transmission, Automatic
24.90.0 - 24.99 07 Cooling
25.00.0 - 25.99 21M Transmission, Manual
26.00.0 - 26.09 16 Prop Shaft and U-Joints
26.10.0 - 26.99 02 Front Suspension
27.00.0 - 27.09 16 Prop Shafts
27.10.0 - 29.99 03 Rear Axles
30.00.0 - 30.99 13 Frame, Bumpers
31.00.0 - 31.39 02 Front Suspension and Drive
31.40.0 - 31.99 05 Service Brake
32.00.0 - 32.29 02 Front Suspension
32.30.0 - 32.99 05 Service Brake
33.00.0 - 33.39 17 Rear Suspension
33.40.0 - 33.99 05 Service Brake
34.00.0 - 34.09 17 Rear Suspension
34.10.0 - 34.29 03 Rear Axle
34.30.0 - 34.99 05 Service Brake
35.00.0 - 35.99 22 Wheels
36.00.0 - 36.99 19 Steering
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 20
SJ CHEROKEE, SJ WAGONEER , J10, J20 CHASSIS SECTION GROUP NUMBERS
Figure 1-500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
37.00.0 - 37.29 05 Service Brake
37.30.0 - 37.39 06 Clutch
37.40.0 - 37.59 14 Fuel
37.60.0 - 37.99 05 Service Brake
38.00.0 - 38.19 04 Parking Brake
38.20.0 - 38.22 21M Transmission, Manual
38.23.0 - 38.24 21A Transmission, Automatic
38.25.0 - 38.99 21M Transmission, Manual
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 21
SJ CHEROKEE, SJ WAGONEER, J10, J20 BODY SECTION GROUP NUMBERS
Figure 1-600
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
AMC PLATE N CHRYSLER GROUP
------- ------- --------------
39.00.0 - 39.99 13 Frame
40.00.0 - 46.99 23A Body - Sheet Metal Except Doors
47.00.0 - 48.99 23C Body - Doors and Related Parts
49.00.0 - 49.79 13 Frame
49.80.0 - 49.99 23A Body - Sheet Metal except Doors
50.00.0 - 54.99 23C Body - Doors, Misc.
55.00.0 - 55.19 13 Frame, Bumpers
55.20.0 - 55.79 23 Body - Exterior Ornamentation
55.80.0 - 55.99 07 Cooling
56.00.0 - 56.19 23 Body - Exterior Ornamentation
56.20.0 - 56.99 23C Body - Doors, Misc.
57.00.0 - 57.99 8A Body - Instrument Panel
58.00.0 - 58.29 23A Body - Sheet Metal
58.30.0 - 59.39 8A Body - Instrument Panel
58.40.0 - 59.79 IT Interior Trim
59.80.0 - 59.81 13 Frame, Bumpers
59.82.0 - 59.84 09 Engine
59.85.0 - 59.85 23 Body - Exterior Ornamentation
59.86.0 - 59.99 13 Frame, Bumpers
60.00.0 - 63.99 24 Heater, Air Conditioning
64.00.0 - 64.99 23A Body - Sheet Metal
65.00.0 - 67.99 23C Body - Doors, Misc.
68.00.0 - 68.99 23A Body - Sheet Metal
69.00.0 - 71.19 IT Interior Trim
71.20.0 - 71.89 23A Body - Sheet Metal
71.90.0 - 79.99 IT Interior Trim
80.00.0 - 82.99 08 Electrical
83.00.0 - 83.39 8A Body - Instrument Panel
83.40.0 - 83.99 14 Fuel
84.00.0 - 84.99 08 Electrical
85.00.0 - 86.19 23D Body - Miscellaneous
86.20.0 - 86.29 08 Electrical
86.30.0 - 86.99 8A Body - Instrument Panel
87.00.9 - 99.99 08 Electrical
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 22
ILLUSTRATION NOT AVAILABLE AT TIME OF PUBLICATION
GROUP 2 - FRONT SUSPENSION & DRIVE
ILLUSTRATION TITLE GROUP-FIG. NO.
FRONT SUSPENSION
BAR, FRONT STABILIZER CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-100
BAR, FRONT STABILIZER XJ CHEROKEE, XJ WAGONEER COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-200
BAR, FRONT STABILIZER SJ CHEROKEE, SJ WAGONEER J10, J20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-300
FRONT SPRING ASSEMBLIES AND LEAVES CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-400
FRONT SPRING COMPONENTS AND SHOCK ABSORBERS CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . Fig. 2-500
FRONT SPRING AND SHOCK ABSORBER XJ CHEROKEE, XJ WAGONEER COMANCHE . . . . . . . . . . . . . Fig. 2-600
FRONT SUSPENSION ARMS XJ CHEROKEE, XJ WAGONEER COMANCHE . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-700
FRONT SPRING AND SHOCK ABSORBER SJ CHEROKEE, SJ WAGONEER J10, J20 . . . . . . . . . . . . . . . . Fig. 2-800
DUAL FRONT SHOCK ABSORBERS SJ CHEROKEE, J10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-900
FRONT AXLES
AXLE ASSEMBLY, FRONT CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-1000
HOUSING, FRONT AXLE CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-1100
DIFFERENTIAL, FRONT AXLE CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-1200
SHAFTS, FRONT AXLE CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-1300
AXLE ASSEMBLY, FRONT FOUR WHEEL DRIVE XJ CHEROKEE, XJ WAGONEER, COMANCHE . . . . . . . . Fig. 2-1400
HOUSING, FRONT AXLE FOUR WHEEL DRIVE WITHOUT DISCONNECT XJ CHEROKEE, XJ WAGONEER,
COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-1500
HOUSING, FRONT AXLE FOUR WHEEL DRIVE WITH DISCONNECT XJ CHEROKEE, XJ WAGONEER,
COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-1600
HOUSING, FRONT AXLE TWO WHEEL DRIVE XJ CHEROKEE, XJ WAGONEER, COMANCHE . . . . . . . . . . Fig. 2-1700
DIFFERENTIAL, FRONT AXLE XJ CHEROKEE, XJ WAGONEER COMANCHE . . . . . . . . . . . . . . . . . . . . . . Fig. 2-1800
SHAFTS, FRONT AXLE WITHOUT DISCONNECT, WITH CARDAN XJ CHEROKEE, XJ WAGONEER,
COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-1900
SHAFTS, FRONT AXLE WITHOUT DISCONNECT, WITH CONSTANT VELOCITY XJ CHEROKEE, XJ
WAGONEER, COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-2000
SHAFTS, FRONT AXLE WITH DISCONNECT, WITH CARDAN XJ CHEROKEE, XJ WAGONEER,
COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-2100
SHAFTS, FRONT AXLE WITH DISCONNECT, WITH CONSTANT VELOCITY XJ CHEROKEE, XJ
WAGONEER, COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-2200
AXLE ASSEMBLY, FRONT SJ CHEROKEE, SJ WAGONEER J10, J20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-2300
HOUSING, FRONT AXLE WITHOUT DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10, J20 . . . . . . . . . . Fig. 2-2400
HOUSING, FRONT AXLE WITH DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10 . . . . . . . . . . . . . . . . . Fig. 2-2500
DIFFERENTIAL, FRONT AXLE SJ CHEROKEE, SJ WAGONEER J10, J20 . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 2-2600
SHAFTS, FRONT AXLE WITHOUT DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10, J20 . . . . . . . . . . . Fig. 2-2700
SHAFTS, FRONT AXLE WITH DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10 . . . . . . . . . . . . . . . . . . Fig. 2-2800
»
Page 23
GROUP 2 - FRONT SUSPENSION & DRIVE
ILLUSTRATION TITLE GROUP-FIG. NO.
LOCKING HUBS
LOCKING HUB, SELECTIVE DRIVE WARN MODEL M-253 CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . Fig. 2-2900
LOCKING HUB, SELECTIVE DRIVE WARN MODEL M-75E SJ CHEROKEE, SJ WAGONEER, J10, J20 . . . . Fig. 2-3000
LOCKING HUB, SELECTIVE DRIVE WARN MODEL M-247 SJ CHEROKEE, SJ WAGONEER, J10, J20 . . . . Fig. 2-3100
«
Page 24
BAR, FRONT STABILIZER CJ-5,6,7,8, SCRAMBLER
Figure 2-100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 BRACKET, Link
J535 9012 1 Right
J535 9011 1 Left
2 SUPPORT, Link Bracket
J535 6921 1 Right
J535 6920 1 Left
3 J400 5823 4 NUTSERT ***
4 J400 5822 4 BOLT
5 J999 7503 2 BOLT
6 J535 6958 2 SPACER
7 J400 5702 2 WASHER
8 J400 3956 6 NUT
9 J536 1651 1 STABILIZER ***
10 J536 1674 2 CUSHION
11 J535 2703 2 CLAMP
12 J018 0145 2 BOLT
13 J400 4175 2 PUSHNUT ***
14 LINK, Stabilizer Bar
J535 5604 2 Used with Light Springs
J535 5317 2 Used with Heavy Springs
J536 4122 2 Used with Light Springs
J536 4121 2 Used with Heavy Springs
15 J535 2787 2 PIN
16 J535 0644 2 WASHER
17 J942 1085 2 NUT
18 J941 5543 2 WASHER
19 J400 4311 2 PUSHNUT ***
1981
1982-86
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 25
BAR, FRONT STABILIZER XJ CHEROKEE, XJ WAGONEER COMANCHE
Figure 2-200
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 STABILIZER BAR ***
5200 1128 1 1984-85
5200 1143 1 1986
2 CUSHION, Stabilizer
5200 1185 2 Blue
5200 1129 2 Green
5200 1144 2 Orange
J536 5098 2 Yellow
3 5200 1085 2 CLAMP
4 3420 1321 4 BOLT
5 BOLT
1150 5098 2 1984-85
3420 1949 2 1986
6 5200 1130 2 LINK
7 1150 2813 AR NUT
8 5200 1131 4 RETAINER
9 5200 1132 4 GROMMET
10 1150 0424 2 NUT
11 5200 0609 1 BAR, Track
12 3420 1492 1 BOLT
13 S243 6163 1 WASHER
14 1150 1850 1 NUT
15 J010 3375 1 PIN
16 J027 4428 1 NUT
17 3420 2037 2 BOLT
18 5200 1275 1 REINFORCEMENT
19 NUT
1150 1033 2 M10-1.5
1150 2813 2 M12-1.75
20 BOLT
1150 2606 2 M10-1.5x25
3420 2472 2 M12-1.75x30
21 5200 0611 1 BRACKET, Track Bar
22 3420 2097 2 STUD
23 5200 1493 1 PLATE
24 5200 1407 1 BRACKET, Track Bar w/Diesel
25 3420 1964 1 BOLT
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 26
BAR, FRONT STABILIZER SJ CHEROKEE, SJ WAGONEER J10, J20
Figure 2-300
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 STABILIZER BAR ***
J535 5593 1 15,16,1 1981-84
J535 5593 1 25,26 1981-84
5200 1995 1 15,26 1985-86
J535 2705 1 27 1981-86
2 CUSHION
J535 5315 2 15,16,1 1981-84
J535 5315 2 25,26 1981-84
5200 1996 2 15,26 1985-86
J535 2702 2 27 1981-86
3 J535 2703 2 CLAMP
4 J012 0383 4 WASHER
5 BOLT
J027 4902 4 15,16,1
J027 4902 4 25,26
J400 5824 4 27
6 BRACKET, Link
J535 9585 1 Right
Left
J536 3864 1 With Disconnect Axle
J535 9584 1 Without Disconnect Axle
7 J012 0389 4 WASHER
8 J027 4655 2 NUT
9 LINK, Stabilizer Bar
J535 5594 1 15,16,1
J535 5594 1 25,26
J535 2788 1 27
10 J535 2787 1 PIN
11 J535 0644 2 WASHER
12 J942 1085 2 NUT
13 J013 7190 2 PIN, Cotter
14 BRACKET
J535 5597 1 Right
J535 5596 1 Left
15 J099 4880 2 SPACER
16 5200 1985 1 15 BAR, Track
17 5200 1989 1 15 BRACKET
18 3420 1465 1 15 BOLT
19 J448 8495 1 15 WASHER
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 27
BAR, FRONT STABILIZER SJ CHEROKEE, SJ WAGONEER J10, J20
Figure 2-300
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
20 1150 2723 1 15 NUT
21 1150 5068 1 15 BOLT
22 1150 2812 1 15 NUT
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 28
FRONT SPRING ASSEMBLIES AND LEAVES CJ-5,6,7,8, SCRAMBLER
Figure 2-400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SPRING ASSEMBLY, Four Leaf, Light Duty ***
Four Cylinder Gas
J536 1024 2 85,86,8 1981: Up to Vehicle Sequence 057506
J536 3227 2 85 1981: After Vehicle Sequence 057506
J536 3228 2 86,87,8 1981: After Vehicle Sequence 057506
J536 3227 2 85 1982-86
J536 3632 2 87 1982-86: Limited, Soft Ride
Six Cylinder
J535 4890 2 85,86,8 1981: Manual Transmission up to Vehicle Sequence 057506
J536 3228 2 85 1981: After Vehicle Sequence 057506
J536 3228 2 85 1982-86
J536 3229 2 86,87,8 1981: After Vehicle 057506
J536 3229 2 87,88 1982-86
J536 3933 2 87 1982-86: Limited, Soft Ride
J535 4890 2 87 1981: Automatic Transmission, without Hardtop, up to Vehicle
J535 5581 2 87 1981: Automatic Transmission, with Hardtop, up to Vehicle
Eight Cylinder
J535 5581 2 85,86,8 1981: Up to Vehicle Sequence 057506
J536 3229 2 85 1981: After Vehicle Sequence 057506
J536 3230 2 87 1981: After Vehicle Sequence 057506
Diesel
J535 5581 2 85,87,8 1981: EXPORT, Up to Vehicle Sequence 057506
J536 3228 2 85 1981: EXPORT, After Vehicle Sequence 057506
J536 3229 2 86,87,8 1981: EXPORT, After Vehicle Sequence 057506
J536 3228 2 85 1982-86: EXPORT
SPRING ASSEMBLY, Four Leaf, Heavy Duty ***
Diesel
J536 3229 2 87,88 1982-86: EXPORT
2 SPRING ASSEMBLY, Five Leaf, Heavy Duty ***
Four Cylinder
J536 3297 2 85 1981: After Vehicle Sequence 057506
J536 3851 2 85 1982-86
J536 3298 2 86,87,8 1981: After Vehicle Sequence 057506
J536 3852 2 87,88 1982-86
Six Cylinder
J536 3298 2 85 1981: After Vehicle Sequence 057506
J536 3852 2 85 1982-86
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Sequence 057506
Sequence 057506
RETURN TO GROUP INDEX
«
»
Page 29
FRONT SPRING ASSEMBLIES AND LEAVES CJ-5,6,7,8, SCRAMBLER
Figure 2-400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
Diesel
J536 3298 2 85,86,8 1981: EXPORT, After Vehicle Sequence 057506
3 SPRING ASSEMBLY, Six Leaf, Heavy Duty ***
Four Cylinder
J536 1275 2 85,86,8 1981: Up to Vehicle Sequence 057506
J536 4385 2 85,86,8 1982-86
Six or Eight Cylinder
J535 8939 2 85,86,8 1981: Up to Vehicle Sequence 057506
J536 3226 2 85,86,8 1981: After Vehicle Sequence 057506
J536 4385 2 85 1982-86
J536 3850 2 87,88 1982-86
Diesel
J536 3226 2 85,86,8 1981: EXPORT, After Vehicle Sequence 057506
4 SPRING ASSEMBLY, Seven Leaf, Heavy Duty ***
Diesel
J535 4892 2 85,86,8 1981: EXPORT
J536 4230 2 85,87,8 1982-86: EXPORT
J536 4230 2 87,88 1983-86: EXPORT, Severe Use
5 SPRING, Front Leaf No. 1, with Five Leaf Assembly
Four Cylinder
J813 4742 2 85 1981: After Vehicle Sequence 057506
J813 4752 2 85 1982-86
J813 4751 2 86,87,8 1981: After Vehicle Sequence 057506
J813 4421 2 87,88 1982-86
Six Cylinder
J813 4751 2 85 1981: After Vehicle Sequence 057506
J813 4421 2 85 1982-86
Diesel
J813 4751 2 85,86,8 1981: EXPORT, After Vehicle Sequence 057506
SPRING, Front Leaf No. 1, with Six Leaf Assembly
Four Cylinder
J813 4751 2 85,86,8 1981: Up to Vehicle Sequence 057506
J813 4421 2 85,86,8 1982-86
Six or Eight Cylinder
J813 4751 2 85,86,8 1981: Up to Vehicle Sequence 057506
J813 4741 2 85,86,8 1981: After Vehicle Sequence 057506
J813 4421 2 85 1982-86
J813 4751 2 87,88 1982-86
Diesel
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
« »
Page 30
FRONT SPRING ASSEMBLIES AND LEAVES CJ-5,6,7,8, SCRAMBLER
Figure 2-400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
J813 4741 2 85,86,8 1981: EXPORT, After Vehicle Sequence 057506
SPRING, Front Leaf, No. 1, with Seven Leaf Assembly
J813 4351 2 85,86,8 1981-86: Diesel, EXPORT
J813 4351 2 87,88 1983-86: EXPORT, Severe Use
6 SPRING, Front Leaf, No. 2, with Seven Leaf Assembly
J813 4352 2 85,86,8 1981: Diesel, EXPORT ***
J813 4352 2 85,87,8 1982-86: EXPORT
J813 4352 2 87,88 1983-86: EXPORT, Severe Use
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 31
FRONT SPRING COMPONENTS AND SHOCK ABSORBERS CJ-5,6,7,8, SCRAMBLER
Figure 2-500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHOCK ABSORBER
1981
J813 3289 2 Standard Duty
J813 3290 2 Heavy Duty, EXPORT
1982-86
J813 4102 2 Limited, Soft Ride
J813 4100 2 Standard Duty
J813 4101 2 Heavy Duty, EXPORT
8350 0176 2 Severe Use
2 J448 8495 4 WASHER
3 J400 4311 4 NUT
4 J063 7936 4 BUSHING
5 PLATE
1981
J535 9012 1 Right
J535 9011 1 Left
1982-86
J536 4022 1 Right
J536 4021 1 Left
6 J942 1085 8 NUT
7 J535 0644 8 WASHER
8 J535 3851 2 BUSHING
9 J400 3979 4 NUT
10 S941 9209 2 BOLT
11 J535 5689 2 BRACKET
12 J018 0147 4 WASHER
13 J400 4809 4 BOLT
14 SHACKLE
J535 7620 2 1981
15 J535 5966 8 BUSHING
16 PLATE
J535 7497 2 1981
17 NUT, Lock
S941 6532 4 1981
18 U-BOLT ***
J813 0369 4 3.06" Wide
J813 0370 4 3.75" Wide
19 PLATE
J536 4404 4 1982-86
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 32
FRONT SPRING COMPONENTS AND SHOCK ABSORBERS CJ-5,6,7,8, SCRAMBLER
Figure 2-500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
20 BOLT
S941 8072 4 1982-86
21 TUBE
J536 4405 4 1982-86
22 NUT
S941 3266 4 1982-86
23 BRACKET, Front Spring Mounting
J535 5689 2 Front
J812 7712 2 Rear
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 33
FRONT SPRING AND SHOCK ABSORBER XJ CHEROKEE, XJ WAGONEER COMANCHE
Figure 2-600
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHOCK ABSORBER
8350 0313 2 XJ Light Duty, Stamped 8952001209
8350 0312 2 XJ Standard Duty, Stamped 8952001207
8350 0314 2 XJ Heavy Duty, Stamped 8952001208
8350 2509 2 MJ Standard Duty, Stamped 8952000949
8350 2510 2 MJ Heavy Duty, Stamped 8952000814
8350 2511 2 Heavy Duty, Off Road, Stamped 8952002388
8350 4211 2 Heavy Duty, Off Road, Stamped 8952003288
2 J420 0402 4 BOLT
3 1150 2811 4 NUT
4 J012 0369 2 NUT
5 J316 5076 2 RETAINER
6 J321 6638 4 GROMMET
7 J314 6809 2 RETAINER
8 SPRING, Front Coil
Light Duty
5200 1104 2 Tagged EC
5200 1105 2 Tagged ED
5200 1106 2 Tagged EE
5200 1107 2 Tagged EF
5200 1108 2 Tagged EG
5200 1109 2 Tagged EH
5200 1110 2 Tagged EJ
5200 1111 2 Tagged EK
5200 1784 2 Tagged EL
5200 1785 2 Tagged EM
5200 1786 2 Tagged EN
5200 1787 2 Tagged EP
5200 1788 2 Tagged ER
Standard Duty
5200 1112 2 Tagged FC
5200 1113 2 Tagged FD
5200 1114 2 Tagged FE
5200 1115 2 Tagged FF
5200 1116 2 Tagged FG
5200 1117 2 Tagged FH
5200 1118 2 Tagged FJ
5200 1119 2 Tagged FK
5200 1789 2 Tagged FL
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 34
FRONT SPRING AND SHOCK ABSORBER XJ CHEROKEE, XJ WAGONEER COMANCHE
Figure 2-600
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
5200 1790 2 Tagged FM
5200 1791 2 Tagged FN
5200 1792 2 Tagged FP
Heavy Duty
5200 1120 2 Tagged GD
5200 1121 2 Tagged GE
5200 1122 2 Tagged GF
5200 1123 2 Tagged GG
5200 1124 2 Tagged GH
5200 1125 2 Tagged GJ
5200 1793 2 Tagged GK
5200 1794 2 Tagged GL
5200 1795 2 Tagged GM
5200 1796 2 Tagged GN
9 5300 0899 2 BRACKET
10 CUSHION
5200 0230 2 1984-85
1986
5200 2732 2 80mm High
5200 2387 2 106mm High
11 5200 0229 2 ISOLATOR
12 S150 0086 2 SCREW
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 35
FRONT SUSPENSION ARMS XJ CHEROKEE, XJ WAGONEER COMANCHE
Figure 2-700
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 ARM, Suspension, Upper
5200 0213 2
5200 2535 2 Economic Commission of Europe
2 BUSHING, Upper Arm
5200 0211 4
5200 2536 4 Economic Commssion of Europe
3 ARM, Suspension, Lower
5200 1162 2
5200 2538 2 Economic Commission of Europe
4 BUSHING, Lower Arm
5200 1161 4
5200 2539 4 Economic Commission of Europe
5 5200 0532 2 CLEVIS ***
6 3420 1492 4 BOLT
7 1150 6007 4 NUT
8 3420 1334 4 BOLT
9 1150 2814 4 NUT
10 5200 0234 AR SHIM
11 1150 2811 4 NUT
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 36
FRONT SPRING AND SHOCK ABSORBER SJ CHEROKEE, SJ WAGONEER J10, J20
Figure 2-800
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHOCK ABSORBER
Light Duty
J813 3734 2 15,16,1 1981-86
Standard Duty
J813 3732 2 15,16,1 1981-84
J813 3732 2 25,26,2 1981-86
8350 1877 2 15 1985-86
Heavy Duty
J812 9467 2 15,16,1 1981-86: EXPORT
J812 9467 2 25,26 1981-86: EXPORT
Extra Heavy Duty
J813 3288 2 15,16,1 1981: EXPORT
J813 3288 2 25,26 1981: EXPORT
J813 3288 2 27 1981
J813 4104 2 15,16,1 1982-86: EXPORT
J813 4104 2 25,26 1982-86: EXPORT
J813 4104 2 27 1982-86
Right Hand Drive
J813 4629 2 15,16,1 1982-86
J813 4629 2 27 1982-86
2 J018 1709 2 BOLT
3 J400 4311 4 NUT
4 J013 1016 4 WASHER
5 J063 7936 4 BUSHING
6 SPRING ASSEMBLY ***
J535 8997 2 Three Leaf
J805 1247 2 Four Leaf
J536 2950 2 Five Leaf
J536 2949 2 Six Leaf
SPRING ASSEMBLY, Seven Leaf ***
Light Duty
J536 2954 2 15,16,1 Six Cylinder, Soft Ride
J536 2953 2 15,16,1 Eight Cylinder, Soft Ride
J536 2951 2 27
Heavy Duty
J536 2951 2 15,16,1 Six Cylinder, EXPORT
J536 2951 2 25,26 Six Cylinder, EXPORT
J536 2952 2 15,16,1 Eight Cylinder, EXPORT
J536 2952 2 25,26 Eight Cylinder, EXPORT
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 37
FRONT SPRING AND SHOCK ABSORBER SJ CHEROKEE, SJ WAGONEER J10, J20
Figure 2-800
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
J536 2952 2 27 EXPORT
7 BRACKET
J535 9583 1 Right
J535 9582 1 Left
8 U-BOLT ***
J812 9475 4 A=3.40" B=5.50" C=3.00"
J812 9474 4 A=4.20" B=6.75" C=4.00"
J812 9476 4 A=3.60" B=6.00" C=3.00"
J536 3631 4 A=4.40" B=6.00" C=2.00"
9 J535 2079 2 BUSHING
10 J094 4870 2 BUSHING
11 BUSHING
J535 5369 2 1.5" O.D.
J535 8985 2 2.0" O.D.
12 J400 3979 2 NUT
13 S941 9209 2 BOLT
14 J400 5198 4 NUT
15 J400 4120 4 BOLT
16 J942 0350 8 NUT
17 J400 4806 8 WASHER
18 SHACKLE
J535 2863 2 15,16,1
J535 2863 2 25,26
J535 2251 2 27
19 SPRING, Front Leaf No. 1
J813 4730 2 With Five Leaf Assembly
J813 4729 2 With Six Leaf Assembly
SPRING, Front Leaf No. 1, with Seven Leaf Assembly
Light Duty
J813 4738 2 15,16,1 Six Cylinder, Soft Ride
J813 4735 2 15,16,1 Eight Cylinder, Soft Ride
J813 4731 2 27
Heavy Duty
J813 4731 2 15,16,1 Six Cylinder, EXPORT
J813 4731 2 25,26 Six Cylinder, EXPORT
J813 4734 2 15,16,1 Eight Cylinder, EXPORT
J813 4734 2 25,26 Eight Cylinder, EXPORT
J813 4734 2 27 EXPORT
20 SPRING, Front Leaf No. 2, with Seven Leaf Assembly
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
« »
Page 38
FRONT SPRING AND SHOCK ABSORBER SJ CHEROKEE, SJ WAGONEER J10, J20
Figure 2-800
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
Light Duty
J813 4737 2 15,16,1 Six Cylinder, Soft Ride
J813 4736 2 15,16,1 Eight Cylinder, Soft Ride
J813 4732 2 27
Heavy Duty
J813 4732 2 15,16,1 Six Cylinder, EXPORT
J813 4732 2 25,26 Six Cylinder, EXPORT
J813 4733 2 15,16,1 Eight Cylinder, EXPORT
J813 4733 2 25,26 Eight Cylinder, EXPORT
J813 4733 2 27 EXPORT
21 J812 9561 2 BRACKET, Front Spring Mounting
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 39
DUAL FRONT SHOCK ABSORBERS SJ CHEROKEE, J10
Figure 2-900
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J813 3286 2 SHOCK ABSORBER, Inner
2 J813 3297 2 SHOCK ABSORBER, Outer
3 S018 1650 2 BOLT
4 J536 2462 2 SPACER
5 J941 1783 2 NUT
6 BRACKET
J536 2458 1 Right
J536 2459 1 Left
7 J941 3215 2 NUT
8 J400 5702 2 WASHER
9 J536 2457 2 BRACKET
10 J018 0120 4 BOLT
11 J400 4008 4 NUT
12 S018 2786 2 BOLT
13 J400 4311 2 NUT
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 40
AXLE ASSEMBLY, FRONT CJ-5,6,7,8, SCRAMBLER
Figure 2-1000
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 AXLE ASSEMBLY, Front ***
J813 3060 1 1981: 2.72 Ratio, Tagged 5361879
J813 3687 1 1981: 2.72 Ratio, Tagged 5363137
J813 3061 1 1981: 3.31 Ratio, Tagged 5361880
J813 3688 1 1981: 3.31 Ratio, Tagged 5363138
J813 3595 1 1981: 3.54 Ratio, Tagged 5362979
J813 3689 1 1981: 3.54 Ratio, Tagged 5363143
J813 3062 1 1981: 3.73 Ratio, Tagged 5361882
J813 3690 1 1981: 3.73 Ratio, Tagged 5363140
J813 3898 1 85 1982-83: 2.72 Ratio, Tagged 5363426
J813 3899 1 85 1982-83: 3.31 Ratio, Tagged 5363427
J813 3900 1 85 1982-83: 3.54 Ratio, Tagged 5363428
J813 3901 1 85 1982-83: 4.09 Ratio, Tagged 5363429
J813 3866 1 87,88 1982-86: 2.72 Ratio, Tagged 5363733, 8953004037 or
J813 3881 1 87,88 1982-86: 3.31 Ratio, Tagged 5363734, 8953004038 or
J813 3882 1 87,88 1982-86: 3.54 Ratio, Tagged 5363735, 8953004039 or
J813 3883 1 87,88 1982-86: 4.09 Ratio, Tagged 5363736, 8953004040 or
J813 4384 1 87,88 1982-86: 4.56 Ratio, Tagged 5364002, 8953004041 or
J813 3687 1 1981: 2.72 Ratio, Tagged 5363142
J813 3688 1 1981: 3.31 Ratio, Tagged 5363141
J813 3690 1 1981: 3.73 Ratio, Tagged 5363139
J813 3898 1 85 1982-83: 2.72 Ratio, Tagged 5363430
J813 3899 1 85 1982-83: 3.31 Ratio, Tagged 5363431
J813 3901 1 85 1982-83: 4.09 Ratio, Tagged 5363432
J813 3866 1 87,88 1982-86: 2.72 Ratio, Tagged 5363737, 8953004228 or
J813 3881 1 87,88 1982-86: 3.31 Ratio, Tagged 5363738, 8953004229 or
J813 3883 1 87,88 1982-86: 4.09 Ratio, Tagged 5363739, 8953004230 or
J813 4384 1 87,88 1982-86: 4.56 Ratio, Tagged 5364781
Left Hand Drive
8953004231
8953004232
8953004233
8953004234
8953004235
Right Hand Drive
8953004236
8953004237
8953004238
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 41
HOUSING, FRONT AXLE CJ-5,6,7,8, SCRAMBLER
Figure 2-1100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J812 8147 2 SPINDLE ASSEMBLY ***
2 J812 1402 2 BEARING
3 J812 1397 2 SEAL
4 J812 7348 2 SPACER
5 J941 1783 12 NUT
6 J812 9655 1 KNUCKLE, Steering, Left
7 J812 4333 2 SOCKET PACKAGE ***
8 J812 8490 12 BOLT
9 J812 1392 2 PIN
10 J812 1364 2 NUT, Castle
11 J812 1365 2 RING, Split
12 HOUSING, Front Axle
J813 3594 1 1981: Tagged 5361879, 5361880, 5361882, 5362979
J813 3691 1 1981: Tagged 5363137, 5363138, 5363143 or 5363140
J813 3897 1 85 1982-83
J813 3868 1 87,88 1982-86
13 J812 1391 2 NUT
14 J813 0382 2 BOLT
15 S011 4494 2 NUT
16 J812 4362 2 RING, Snap
17 S017 9890 4 BOLT
18 J899 3317 1 SEALER ***
19 J099 1546 10 BOLT
20 S010 3869 1 PLUG
21 J812 6498 1 COVER PACKAGE
22 J812 9654 1 KNUCKLE, Steering, Right
23 J535 3495 1 VENT
24 J812 5823 1 HOSE, Bulk
25 J535 2955 1 BREATHER ***
26 J014 0780 1 CLIP
27 J322 3227 1 STRAP
28 J322 7851 1 CLAMP
29 J400 3556 1 SCREW
30 SHIELD, Splash
J535 8619 1 1981
J536 3380 1 1982-86
J535 8619 1 1981
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Right
Left
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 42
HOUSING, FRONT AXLE CJ-5,6,7,8, SCRAMBLER
Figure 2-1100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
J536 3379 1 1982-86
31 J812 2496 2 SOCKET, Lower
32 J812 2495 2 SOCKET, Upper
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 43
DIFFERENTIAL, FRONT AXLE CJ-5,6,7,8, SCRAMBLER
Figure 2-1200
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J080 1367 1 NUT
2 YOKE, Pinion
J813 3241 1 1981-86: With Dust Slinger on Yoke
8350 3388 1 1986: Without Dust Slinger on Yoke
3 SEAL, Pinion
J099 8092 1 1981-86: With Dust Slinger on Yoke
8350 3390 1 1986: Without Dust Slinger on Yoke
4 J005 2878 1 CONE, Bearing
5 J005 2879 1 CUP, Bearing
6 J063 6566 1 SLINGER, Dust
7 J063 6568 1 SHIELD, Dust
8 J063 6570 1 WASHER
9 J093 4937 1 BAFFLE ***
10 J315 6066 1 CONE, Bearing
11 J315 6065 1 CUP, Bearing
12 J091 6372 1 SLINGER, Oil
13 GEAR PACKAGE, Front Axle Ring and Pinion
J813 3063 1 2.72 Ratio
J813 2601 1 3.31 Ratio
J812 6518 1 3.54 Ratio
J094 5345 1 3.73 Ratio
J812 6494 1 4.09 Ratio
J813 4385 1 4.56 Ratio
14 J064 9454 10 BOLT
15 J063 6360 1 PIN
16 J812 6506 1 SHIM PACKAGE (8), Case ***
17 J812 6503 1 SHIM PACKAGE (14), Pinion ***
18 J812 6497 1 GEAR PACKAGE, Front Axle Differential
19 J812 0832 2 WASHER
20 J812 0831 2 WASHER
21 J812 0833 1 SHAFT
22 CASE, Front Axle Differential
J812 6513 1 2.72, 3.31, 3.54 or 3.73 Ratios
J812 6495 1 4.09 or 4.56 Ratios
23 J315 6052 2 CONE, Bearing
24 J317 1166 2 CUP, Bearing
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 44
SHAFTS, FRONT AXLE CJ-5,6,7,8, SCRAMBLER
Figure 2-1300
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHAFT, Axle, Left
J812 7599 1 1981
J812 7599 1 85 1982-83
J813 4293 1 87,88 1982-86
2 SHAFT, Axle, Right
J812 7598 1 1981
J812 7598 1 85 1982-83
J813 4294 1 87,88 1982-86
3 J090 9453 8 RING, Snap
4 J812 6637 2 SPIDER ASSEMBLY ***
5 J812 1781 2 SEAL
6 J812 8285 2 RETAINER, Outer
7 J812 6232 2 RETAINER, Inner
8 J812 7350 2 SEAL
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 45
AXLE ASSEMBLY, FRONT FOUR WHEEL DRIVE XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 2-1400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 AXLE ASSEMBLY, Front, Without Disconnect ***
8350 1446 1 1984-85: 3.31 Ratio, Tagged 8953002091, 8953001326,
8350 1447 1 1984-85: 3.73 Ratio, Tagged 8953002092, 8953001327,
8350 2630 1 1986: 3.54 Ratio, Tagged 8953003435 or 8953004459
8350 4205 1 1986: 3.55 Ratio, Tagged 8953005045
8350 2631 1 1986: 4.10 Ratio, Tagged 8953003436 or 8953004458
2 AXLE ASSEMBLY, Front, With Disconnect ***
Without System Sentry
8350 1162 1 1984-85: 3.31 Ratio, Tagged 8953000931 or 8953003715
8350 1162 1 1984-86: 3.31 Ratio, Tagged 8953000932
8350 1163 1 ‘ 1984-85: 3.73 Ratio, Tagged 8953000396, 8953000395 or
8350 3564 1 1986: 3.07 Ratio, Tagged 8953000930
8350 2356 1 1986: 3.54 Ratio, Tagged 8953000393
8350 4304 1 1986: 3.55 Ratio Tagged 8953005043
8350 2354 1 1986: 4.10 Ratio, Tagged 8953000394 or 8953004244
8350 3567 1 1986: 4.56 Ratio, Tagged 8953003497
With System Sentry
8350 0185 1 1985: 3.31 Ratio, Tagged 8953001214, 8953001215 or
8350 0186 1 1985: 3.73 Ratio, Tagged 8953001218, 8953001219 or
8953002093 or 8953001364
8953002094 or 8953001366
8953003720
8953003716
8953003714
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 46
HOUSING, FRONT AXLE FOUR WHEEL DRIVE WITHOUT DISCONNECT XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 2-1500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 HOUSING, Front Axle
8350 5517 1 1984-86: Without System Sentry
8350 5519 1 1985: With System Sentry
2 S017 9890 4 BOLT
3 8350 0194 1 COVER PACKAGE
4 J099 546 10 BOLT
5 S010 3869 1 PLUG
6 J899 3317 1 SEALER ***
7 J812 1781 2 SEAL
8 JA00 0821 2 BOLT
9 S011 4494 2 NUT
10 3420 1535 6 BOLT
11 8350 0202 1 SOCKET PACKAGE ***
12 8350 0203 2 RING, Split
13 J012 5258 1 NUT
14 J812 1392 2 PIN, Cotter
15 J812 3318 2 NUT
16 1101 0069 2 PIN, Cotter
17 J812 5823 1 HOSE, Bulk
18 J322 7851 1 CLAMP
19 J535 2955 1 BREATHER ***
20 J014 0780 1 CLIP
21 1150 1608 1 SCREW
22 KNUCKLE, Steering
5300 0626 1 Right
5300 0625 1 Left
23 8350 0330 1 VENT
24 3300 0322 1 GASKET
25 J400 1712 1 STRAP
26 8350 0271 1 PLUG PACKAGE ***
27 3420 1788 2 STRAP
28 J400 3084 1 PUSHNUT ***
29 5300 1441 1 BRACKET
30 5300 0376 1 SENSOR, System Sentry
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 47
HOUSING, FRONT AXLE FOUR WHEEL DRIVE WITH DISCONNECT XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 2-1600
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 HOUSING, Front Axle
8350 5518 1 1984-86: Without System Sentry
8350 5520 1 1985: With System Sentry
2 S017 9890 4 BOLT
3 8350 0194 1 COVER PACKAGE
4 J099 1546 10 BOLT
5 S010 3869 1 PLUG
6 J899 3317 1 SEALER ***
7 J812 1781 1 SEAL
8 JA00 0821 2 BOLT
9 S011 4494 2 NUT
10 3420 1535 6 BOLT
11 8350 0202 2 SOCKET PACKAGE ***
12 8350 0203 2 RING, Split
13 J012 5258 2 NUT
14 J812 1392 2 PIN, Cotter
15 J812 3318 2 NUT
16 1101 0069 2 PIN, Cotter
17 J812 5823 1 HOSE, Bulk
18 J322 7851 1 CLAMP
19 J535 2955 1 BREATHER ***
20 J014 0780 1 CLIP
21 1150 1608 1 SCREW
22 KNUCKLE, Steering
5300 0626 1 Right
5300 0625 1 Left
23 8350 0330 1 VENT
24 8350 3113 1 MOTOR PACKAGE ***
25 J813 3708 1 PAD PACKAGE ***
26 J813 4214 1 COLLAR, Axle Shaft
27 8350 0197 1 FORK, Axle Shift
28 J813 3618 1 RING, Snap, Inner
29 J813 3619 1 RING, Snap, Outer
30 J813 3709 1 GASKET
31 8350 0195 1 COVER, Axle Shift
32 J813 3624 4 WASHER
33 J813 3623 4 BOLT
34 J813 3620 1 O-RING
35 SEAL
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 48
HOUSING, FRONT AXLE FOUR WHEEL DRIVE WITH DISCONNECT XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 2-1600
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
8350 0199 1 2.290" O.D.
8350 3504 1 2.125" O.D.
36 8350 0271 1 PLUG PACKAGE ***
37 3300 0322 1 GASKET
38 J400 1712 1 STRAP
39 3420 1788 2 STRAP
40 8350 0200 1 GUIDE, Axle Shaft
41 J400 3084 1 PUSHNUT ***
42 5300 0376 1 SENSOR, System Sentry
43 5300 1441 1 BRACKET
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 49
HOUSING, FRONT AXLE TWO WHEEL DRIVE XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 2-1700
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 8350 2081 1 HOUSING, Front Axle
2 KNUCKLE, Steering
5300 2932 1 Right
5300 2931 1 Left
3 J812 1392 2 PIN, Cotter
4 JA00 0821 2 BOLT
5 S011 4494 2 NUT
6 J012 5258 2 NUT
7 8350 0202 2 SOCKET PACKAGE ***
8 1101 0069 2 PIN, Cotter
9 J812 3318 2 NUT
10 3420 1535 2 BOLT
11 8350 0203 2 RING, Split
12 KNUCKLE, Steering
12 5300 0626 1 Right
5300 0625 1 Left
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 50
DIFFERENTIAL, FRONT AXLE XJ CHEROKEE, XJ WAGONEER COMANCHE
Figure 2-1800
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J080 1367 1 NUT, Pinion
2 J063 6570 1 WASHER
3 YOKE, Pinion
J813 3241 1 1984-86: With Dust Slinger on Yoke
8350 3388 1 1986: Without Dust Slinger on Yoke
4 SEAL, Pinion
J099 8092 1 1984-86: With Dust Slinger on Yoke
8350 3390 1 1986: Without Dust Slinger on Yoke
5 J063 6566 1 SLINGER, Dust
6 J812 4052 1 BEARING PACKAGE, Outer
7 J093 4937 1 BAFFLE ***
8 J812 6499 1 BEARING PACKAGE, Inner
9 J091 6372 1 SLINGER, Oil
10 GEAR SET, Front Axle Ring and Pinion
8350 0187 1 3.07 Ratio
8350 0188 1 3.31 Ratio
8350 2355 1 3.54 Ratio
8350 4206 1 3.55 Ratio
8350 0189 1 3.73 Ratio
8350 2353 1 4.10 Ratio
8350 3424 1 4.56 Ratio
11 J899 3317 1 SEALER ***
12 J813 0763 1 RING, Snap
13 J064 9454 10 BOLT
14 J813 3724 2 WASHER, Side Gear
15 J812 0831 2 WASHER, Pinion Gear
16 J094 6384 1 SHAFT
17 J063 6360 1 PIN
18 J812 6500 1 BEARING PACKAGE, Case
19 8350 0190 1 GEAR SET, Front Axle Differential
20 CASE ASSEMBLY ***
8350 0168 1 3.07, 3.31, 3.54, 3.55 Ratios
8350 0169 1 3.73, 4.10, 4.56 Ratios
21 8350 0192 1 SHIM PACKAGE (13), Pinion ***
22 8350 0191 1 SHIM PACKAGE (8), Case ***
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 51
SHAFTS, FRONT AXLE WITHOUT DISCONNECT, WITH CARDAN XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 2-1900
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 5300 2134 1 SHAFT, Axle, Right
2 5300 0684 1 SHAFT, Axle, Left
3 8350 0201 2 SLINGER, Dust
4 J812 1781 2 SEAL
5 8350 0184 2 SHAFT, Outer
6 J812 6637 2 SPIDER ASSEMBLY ***
7 J812 6232 2 SLINGER, Oil
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 52
SHAFTS, FRONT AXLE WITHOUT DISCONNECT, WITH CONSTANT VELOCITY XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 2-2000
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 5300 2128 1 SHAFT, Axle, Right
2 5300 0227 1 SHAFT, Axle, Left
3 J812 1781 2 SEAL
4 8350 0201 2 SLINGER, Dust
5 8350 0696 2 JOINT ASSEMBLY
6 8350 0698 2 BOOT PACKAGE
7 8350 0699 2 RING, Spacer
8 8350 0697 2 RING, Retaining
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 53
SHAFTS, FRONT AXLE WITH DISCONNECT, WITH CARDAN XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 2-2100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 5300 0224 1 SHAFT, Axle, Right
2 5300 0684 1 SHAFT, Axle, Left
3 8350 0198 1 SHAFT, Intermediate
4 J812 1781 1 SEAL
5 J813 4213 1 BEARING
6 J813 3622 1 BEARING
7 J812 6232 2 SLINGER, Oil
8 J812 6637 2 SPIDER ASSEMBLY ***
9 8350 0184 2 SHAFT, Outer
10 8350 0201 2 SLINGER, Dust
11 SEAL
8350 0199 1 2.290" O.D.
8350 3504 1 2.125" O.D.
12 8350 0200 1 GUIDE, Axle Shaft
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 54
SHAFTS, FRONT AXLE WITH DISCONNECT, WITH CONSTANT VELOCITY XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 2-2200
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 5300 0686 1 SHAFT, Axle, Right
2 5300 0227 1 SHAFT, Axle, Left
3 8350 0198 1 SHAFT, Intermediate
4 8350 0201 2 SLINGER
5 8350 0696 2 SPIDER ASSEMBLY ***
6 8350 0698 2 BOOT PACKAGE
7 8350 0699 2 RING, Snap
8 8350 0697 2 RING, Retaining
9 J813 3622 1 BEARING
10 J813 4213 1 BEARING
11 J812 1781 1 SEAL
12 8350 0199 1 SEAL
13 8350 0200 2 GUIDE, Axle Shaft
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 55
AXLE ASSEMBLY, FRONT SJ CHEROKEE, SJ WAGONEER J10, J20
Figure 2-2300
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 AXLE ASSEMBLY, Without Disconnect ***
J813 1913 1 15,16,1 1981-84: 2.73 Ratio, Tagged 5359667
8350 1402 1 15,16,1 1981-84: 3.31 Ratio, Tagged 5359666
J813 3596 1 17,25,2 1981-86: 2.73 Ratio, Tagged 5359664, 8953004006 or
J813 3597 1 17,25,2 1981-86: 3.31 Ratio, Tagged 5359663, 8953004007 or
J813 3600 1 27 1981-86: 3.73 Ratio, Tagged 5359661, 8953004010 or
J813 1924 1 27 1981-86: 4.88 Ratio, Tagged 5359670, 8953004011 or
8350 1399 1 15,16,1 1985-86: 2.73 Ratio, Tagged 5365152, 8953004003 or
8350 1402 1 15,16,1 1985-86: 3.31 Ratio, Tagged 5365153, 8953004004 or
2 AXLE ASSEMBLY, With Disconnect ***
J813 4260 1 15,16,1 1982-84: 2.73 Ratio, Tagged 3241253
J813 4261 1 15,16,1 1982-84: 3.31 Ratio, Tagged 3241255
J813 4263 1 17,25,2 1982-84: 2.73 Ratio, Tagged 3241254
J813 4262 1 17,25,2 1982-84: 3.31 Ratio, Tagged 3241256
8953004207
8953004209
8953004211
8953004212
8953004206
8953004208
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 56
HOUSING, FRONT AXLE WITHOUT DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10, J20
Figure 2-2400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J812 8767 2 SPINDLE ASSEMBLY ***
2 J812 7356 2 BEARING PACKAGE
3 SHIELD, Splash, Left
8350 1982 1 15,16,1
8350 1982 1 25,26
J537 0115 1 27
4 J812 1397 2 SEAL
5 8350 1113 2 SPACER
6 J812 8611 1 KNUCKLE, Steering, Left
7 J812 4333 2 SOCKET PACKAGE ***
8 J812 4847 12 STUD
9 J812 1392 2 PIN, Cotter
10 J812 1364 2 NUT
11 J812 1365 2 RING, Split
12 HOUSING, Front Axle
J813 2705 1 15,16,1 1981-84
8350 1401 1 15 1985-86
J813 2706 1 17,25,2 1981-86
13 J812 1391 2 NUT
14 JA00 0821 2 BOLT
15 S011 4494 2 NUT
16 J812 4362 2 RING, Snap
17 S017 9890 4 BOLT
18 J899 3317 1 SEALER ***
19 J099 1546 10 BOLT
20 S010 3869 1 PLUG
21 J812 4352 1 COVER PACKAGE
22 J812 8610 1 KNUCKLE, Steering, Right
23 J535 3495 1 VENT
24 J812 5823 1 HOSE, Bulk
25 J535 2955 1 BREATHER ***
26 J014 0780 1 CLIP
27 J322 3227 1 STRAP
28 J322 7851 1 CLAMP
29 SHIELD, Splash, Right
8350 1982 1 15,16,1
8350 1982 1 25,26
J537 0116 1 27
30 SEAL
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 57
HOUSING, FRONT AXLE WITHOUT DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10, J20
Figure 2-2400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
J812 9096 1 2.625" O.D.
8350 1873 1 2.250" O.D.
31 J400 3556 1 SCREW
32 J941 1783 12 NUT
33 J812 2495 2 SOCKET, Upper
34 J812 2496 2 SOCKET, Lower
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 58
HOUSING, FRONT AXLE WITH DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10
Figure 2-2500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J812 8767 1 SPINDLE ASSEMBLY, Right ***
2 8350 0950 1 BEARING PACKAGE, Right
3 SHIELD, Splash, Left
8350 1982 1 15,16,1
8350 1982 1 25,26
4 J812 1397 2 SEAL
5 8350 1113 2 SPACER
6 J812 8611 1 KNUCKLE, Steering, Left
7 J812 4333 2 SOCKET PACKAGE ***
8 J812 4847 12 STUD
9 J812 1392 2 PIN, Cotter
10 J812 1364 2 NUT
11 J812 1365 2 RING, Split
12 HOUSING, Front Axle
J813 4223 1 15,16,1
J813 4220 1 17,25,2
13 J812 1391 2 NUT
14 JA00 0821 2 BOLT
15 S011 4494 2 NUT
16 J812 4362 2 RING, Snap
17 S017 9890 4 BOLT
18 J899 3317 1 SEALER ***
19 J099 1546 10 BOLT
20 S010 3869 1 PLUG
21 8350 0435 1 COVER PACKAGE
22 J812 8610 1 KNUCKLE, Steering, Right
23 J535 3495 1 VENT
24 J812 5823 1 HOSE, Bulk
25 J535 2955 1 BREATHER ***
26 J014 0780 1 CLIP
27 J322 3227 1 STRAP
28 J322 7851 1 CLAMP
29 SHIELD, Splash, Right
8350 1982 1 15,16,1
8350 1982 1 25,26
30 SEAL, Inner Axle, Right
8350 1009 1 15,16,1
8350 1873 1 17,25,2
31 J400 3556 1 SCREW
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 59
HOUSING, FRONT AXLE WITH DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10
Figure 2-2500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
32 J941 1783 12 NUT
33 J812 2495 2 SOCKET, Upper
34 J812 2496 2 SOCKET, Lower
35 8350 0443 1 NUT
36 8350 0438 1 PIN
37 8350 0440 1 RING, Snap
38 8350 0437 1 LEVER
39 8350 0441 1 STUD
40 8350 0439 1 PIN
41 8350 0434 1 FORK
42 8350 0436 1 PAD PACKAGE ***
43 J813 4632 1 MOTOR, Vacuum
44 8350 0447 1 SEAL
45 8350 0448 1 WASHER
46 8350 0442 1 NUT
47 J813 4216 1 SEAL, Axle Shaft, Left
48 J813 4218 1 SPINDLE, Left
49 8350 0950 1 SPACER, Left
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 60
DIFFERENTIAL, FRONT AXLE SJ CHEROKEE, SJ WAGONEER J10, J20
Figure 2-2600
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J080 1367 1 NUT, Pinion
2 YOKE, Pinion
J813 3241 1 1981-86: With Dust Slinger on Yoke
8350 3388 1 1986: Without Dust Slinger on Yoke
3 SEAL, Pinion
J099 8092 1 1981-86: With Dust Slinger on Yoke
8350 3390 1 1986: Without Dust Slinger on Yoke
4 J005 2878 1 BEARING
5 J005 2879 1 CUP, Bearing
6 J063 6566 1 SLINGER, Dust
7 J063 6568 1 SHIELD, Dust
8 J063 6570 1 WASHER
9 J080 7266 1 CONE, Bearing
10 J005 2877 1 CUP, Bearing
11 J091 6373 1 BAFFLE ***
12 J091 6372 1 SLINGER, Oil
13 GEAR SET, Front Axle Ring and Pinion
J813 2704 1 1981-84: 2.73 Ratio, without Disconnect
J813 4222 1 1982-84: 2.73 Ratio, with Disconnect
J813 4222 1 1985-86: 2.73 Ratio
J813 4219 1 3.31 Ratio
J812 4777 1 3.73 Ratio
J812 4386 1 4.88 Ratio
14 J064 9454 10 BOLT
15 J063 6360 1 PIN
16 J812 9222 1 SHIM PACKAGE (8), Case ***
17 J812 9221 1 SHIM PACKAGE (13), Pinion ***
18 GEAR SET, Front Axle Differential
J812 9228 1 1981-84: Without Disconnect
J813 4225 1 1982-84: With Disconnect
J812 9228 1 1985-86
19 J064 5789 2 WASHER, Side Gear
20 J064 5790 2 WASHER, Pinion Gear
21 J080 5327 1 SHAFT, Differential
22 J812 4071 1 BEARING PACKAGE
23 CASE, Front Axle Differential
J812 4038 1 1981-84: 2.73 or 3.31 Ratio, without Disconnect
J813 4224 1 1982-84: 2.73 or 3.31 Ratio, with Disconnect
J812 4038 1 1985-86: 2.73 or 3.31 Ratio
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
XJ=Wagoneer(1984-86), Cherokee(1984-86)
RETURN TO GROUP INDEX
«
»
Page 61
DIFFERENTIAL, FRONT AXLE SJ CHEROKEE, SJ WAGONEER J10, J20
Figure 2-2600
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
J812 4038 1 3.73 Ratio
J812 9244 1 4.88 Ratio
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 62
SHAFTS, FRONT AXLE WITHOUT DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10, J20
Figure 2-2700
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHAFT, Front Axle, Right
J813 2912 1 15,16,1
J813 2915 1 17,25,2
2 J812 7350 2 SEAL
3 J090 9453 8 RING, Snap
4 J812 6638 2 SPIDER ASSEMBLY ***
5 SEAL, Axle Inner
J812 9096 2 2.625" O.D.
8350 1873 2 2.250"
6 J812 8285 2 RETAINER
7 SHAFT, Front Axle, Left
J813 2913 1 15,16,1
J813 2916 1 17,25,2
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 63
SHAFTS, FRONT AXLE WITH DISCONNECT SJ CHEROKEE, SJ WAGONEER, J10
Figure 2-2800
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 Shaft, Front Axle, Right ***
J813 2912 1 15,16,1
J813 2915 1 17,25,2
2 SHAFT, Front Axle, Left
J813 4226 1 15,16,1
J813 4217 1 17,25,2
3 J812 7350 2 SEAL
4 J812 8285 2 RETAINER
5 SEAL, Inner Axle, Right
8350 1009 1 15,16,1
8350 1873 1 17,25,2
6 J812 6638 2 SPIDER ASSEMBLY ***
7 J090 9453 8 RING, Snap
8 J813 4216 1 SEAL, Inner Axle, Left
9 J813 4215 1 BEARING
10 J813 4214 1 COLLAR
11 J813 4213 1 BEARING
12 J813 4212 1 SHAFT
13 J813 0763 1 RING, Snap
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 64
LOCKING HUB, SELECTIVE DRIVE WARN MODEL M-253 CJ-5,6,7,8, SCRAMBLER
Figure 2-2900
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J813 1273 2 HUB ASSEMBLY ***
2 J813 1274 2 CAP
3 J813 1275 2 HUB
4 J813 1276 2 SERVICE PACKAGE ***
5 J018 0125 10 BOLT
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 65
LOCKING HUB, SELECTIVE DRIVE WARN MODEL M-75E SJ CHEROKEE, SJ WAGONEER, J10, J20
Figure 2-3000
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J812 3949 2 HUB ASSEMBLY ***
2 J812 3951 2 BODY REPAIR PACKAGE ***
3 J812 3645 2 RING, Snap
4 J812 3649 2 RING, Snap
5 J812 3962 2 NUT PACKAGE ***
6 J812 3950 2 SERVICE PACKAGE ***
7 J812 3801 2 RING, Snap
8 J812 3952 2 CAP REPAIR PACKAGE ***
9 J206 4000 2 SEAL
10 J206 4002 2 O-RING
11 J812 3639 2 CLUTCH ***
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 66
LOCKING HUB, SELECTIVE DRIVE WARN MODEL M-247 SJ CHEROKEE, SJ WAGONEER, J10, J20
Figure 2-3100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 5300 4806 2 HUB ASSEMBLY ***
2 J813 1252 2 BODY REPAIR PACKAGE ***
3 J813 1232 2 CAP REPAIR PACKAGE ***
4 J813 1251 2 SERVICE PACKAGE ***
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 67
ILLUSTRATION NOT AVAILABLE AT TIME OF PUBLICATION
GROUP 3 - REAR AXLE
ILLUSTRATION TITLE GROUP-FIG. NO.
CJ
AXLE ASSEMBLY, REAR CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-100
AXLE HOUSING, REAR AMC LARGE AXLE CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-200
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, NON-LOCKING CJ-5,6,7,8, SCRAMBLER . . Fig. 3-300
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, LOCKING CJ-5,6,7,8, SCRAMBLER . . . . . . Fig. 3-400
SHAFTS, REAR AXLE AMC LARGE AXLE CJ-5,6,7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-500
AXLE HOUSING, REAR DANA MODEL 44 CJ-7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-600
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, NON-LOCKING CJ-7,8, SCRAMBLER . . . . . . Fig. 3-700
DIFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, LOCKING CJ-7,8, SCRAMBLER . . . . . . . . . . . Fig. 3-800
SHAFTS, REAR AXLE DANA MODEL 44 CJ-7,8, SCRAMBLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-900
XJ CHEROKEE, XJ WAGONEER, COMANCHE
AXLE ASSEMBLY, REAR AMC OR DANA MODEL 35 XJ CHEROKEE, XJ WAGONEER, COMANCHE . . . . . Fig. 3-1000
AXLE HOUSING, REAR AMC OR DANA MODEL 35 XJ CHEROKEE, XJ WAGONEER, COMANCHE . . . . . . Fig. 3-1100
DIFFERRENTIAL AND GEARS, REAR AXLE AMC OR DANA MODEL 35, NON-LOCKING XJ CHEROKEE,
XJ WAGONEER, COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-1200
DIFFERRENTIAL AND GEARS, REAR AXLE AMC OR DANA MODEL 35, LOCKING XJ CHEROKEE, XJ
WAGONEER, COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-1300
SHAFT, REAT AXLE AMC OR DANA MODEL 35 XJ CHEROKEE, XJ WAGONEER, COMANCHE . . . . . . . . Fig. 3-1400
AXLE ASSEMBLY, REAR AMC LARGE AXLE COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-1500
AXLE ASSEMBLY, REAR AMC LARGE AXLE COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-1600
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, NON-LOCKING COMANCHE . . . . . . . . . . . Fig. 3-1700
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, LOCKING COMANCHE . . . . . . . . . . . . . . . Fig. 3-1800
SHAFT, REAR AXLE AMC LARGE AXLE COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-1900
AXLE ASSEMBLY, REAR DANA MODEL 44 COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-2000
AXLE HOUSING, REAR DANA MODEL 44 COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-2100
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, NON-LOCKING COMANCHE . . . . . . . . . . . . Fig. 3-2200
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, LOCKING COMANCHE . . . . . . . . . . . . . . . . Fig. 3-2300
SHAFTS, REAR AXLE DANA MODEL 44 COMANCHE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-2400
SJ CHEROKEE, SJ WAGONEER, J10, J20
AXLE ASSEMBLY, REAR AMC LARGE, DANA 44, DANA 60 SJ CHEROKEE, SJ WAGONEER, J10, J20 . . . Fig. 3-2500
AXLE HOUSING, REAR AMC LARGE AXLE SJ CHEROKEE, SJ WAGONEER, J10, J20 . . . . . . . . . . . . . . . Fig. 3-2600
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, NON-LOCKING SJ CHEROKEE, SJ
WAGONEER, J10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-2700
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, LOCKING SJ CHEROKEE, SJ WAGONEER,
J10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-2800
SHAFTS, REAR AXLE AMC LARGE AXLE SJ CHEROKEE, SJ WAGONEER, J10 . . . . . . . . . . . . . . . . . . . . Fig. 3-2900
»
Page 68
GROUP 3 - REAR AXLE
ILLUSTRATION TITLE GROUP-FIG. NO.
SJ CHEROKEE, SJ WAGONEER, J10, J20 (Continued)
SHAFTS, REAR AXLE AMC LARGE AXLE SJ CHEROKEE, SJ WAGONEER, J10 . . . . . . . . . . . . . . . . . . . . Fig. 3-2900
AXLE HOUSING, REAR DANA MODEL 44 SJ CHEROKEE, SJ WAGONEER, J10 . . . . . . . . . . . . . . . . . . . . Fig. 3-3000
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, NON-LOCKING SJ CHEROKEE, SJ
WAGONEER, J10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-3100
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, LOCKING SJ CHEROKEE, SJ WAGONEER,
J10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-3200
SHAFTS, REAR AXLE DANA MODEL 44 SJ CHEROKEE, SJ WAGONEER, J10 . . . . . . . . . . . . . . . . . . . . . Fig. 3-3300
AXLE HOUSING, REAR DANA MODEL 60 J20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-3400
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 60, NON-LOCKING J20 . . . . . . . . . . . . . . . . . . . Fig. 3-3500
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 60, LOCKING J20 . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-3600
SHAFTS, REAR AXLE DANA MODEL 60 J20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fig. 3-3700
«
Page 69
AXLE ASSEMBLY, REAR CJ-5,6,7,8, SCRAMBLER
Figure 3-100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 AXLE ASSEMBLY REAR, AMC, Without Locking Differential ***
J536 2050 1 1981: 2.73 Ratio, Stamped AA or D
J536 2048 1 1981: 3.31 Ratio, Stamped BB or B
J536 2046 1 1981: 3.73 Ratio, Stamped GG or H
J536 2050 1 85,86 1982-83: 2.73 Ratio, Stamped AA or D
J536 3718 1 87,88 1982-86: 2.73 Ratio, Stamped AA or D
J536 2048 1 85,86 1982-83: 3.31 Ratio, Stamped BB or B
J536 3716 1 87,88 1982-86: 3.31 Ratio, Stamped BB or B
J536 0148 1 85,86 1982-86: 3.54 Ratio, Stamped A
J536 3723 1 87,88 1982-86: 3.54 Ratio, Stamped A
J536 0150 1 85,86 1982-83: 4.10 Ratio, Stamped L or C
J536 3721 1 87,88 1982-86: 4.10 Ratio, Stamped L or C
J536 4025 1 87,88 1982-86: 4.56 Ratio, Stamped G
J536 2051 1 1981: 2.73 Ratio, Stamped DD
J536 2049 1 1981: 3.31 Ratio, Stamped CC
J536 2047 1 1981: 3.73 Ratio, Stamped HH
J536 2051 1 85,86 1982-83: 2.73 Ratio, Stamped DD
J536 3719 1 87,88 1982-86: 2.73 Ratio, Stamped DD
J536 2049 1 85,86 1982-83: 3.31 Ratio, Stamped BB or CC
J536 3717 1 87,88 1982-86: 3.31 Ratio, Stamped BB or CC
J536 0149 1 85,86 1982-83: 3.54 Ratio, Stamped N or AA
J536 3722 1 87,88 1982-86: 3.54 Ratio, Stamped N or AA
J536 0151 1 85,86 1982-83: 4.10 Ratio, Stamped M or CC
J536 3720 1 87,88 1982-86: 4.10 Ratio, Stamped M or CC
J536 4436 1 87,88 1982-86: 4.56 Ratio, Stamped GG
2 AXLE ASSEMBLY REAR, DANA 44, Without Locking Differential ***
8350 3072 1 87,88 1986: 2.73 Ratio, Tagged 8953004106
8350 3079 1 87,88 1986: 3.31 Ratio, Tagged 8953004104
8350 3081 1 87,88 1986: 3.54 Ratio, Tagged 8953004100
8350 3083 1 87,88 1986: 4.10 Ratio, Tagged 8953004102
8350 3085 1 87,88 1986: 4.56 Ratio, Tagged 8953004108
8350 3078 1 87,88 1986: 2.73 Ratio, Tagged 8953004107
8350 3080 1 87,88 1986: 3.31 Ratio, Tagged 8953004105
8350 3082 1 87,88 1986: 3.54 Ratio, Tagged 8953004101
8350 3084 1 87,88 1986: 4.10 Ratio, Tagged 8953004103
8350 3086 1 87,88 1986: 4.56 Ratio, Tagged 8953004109
AXLE ASSEMBLY REAR, AMC, With Locking Differential ***
AXLE ASSEMBLY REAR, DANA 44, With Locking Differential ***
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 70
AXLE HOUSING, REAR AMC LARGE AXLE CJ-5,6,7,8, SCRAMBLER
Figure 3-200
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 HOUSING, Axle
J813 0994 1 1981
J813 0994 1 85,86 1982-83
J813 3887 1 87,88 1982-86
2 J400 6554 4 BOLT
3 J942 6241 1 SCREW
4 J317 2122 1 GASKET
5 J400 4751 1 PLUG
6 J317 0700 2 SEAL
7 J099 1546 12 BOLT
8 J321 5943 1 COVER
9 J014 0780 1 CLIP
10 J535 2955 1 BREATHER
11 J322 7851 1 CLAMP
12 J535 3494 1 VENT
13 J812 5823 1 HOSE
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 71
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, NON-LOCKING CJ-5,6,7,8, SCRAMBLER
Figure 3-300
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J318 2601 1 NUT, Pinion
2 YOKE, Pinion
J813 2702 1 1981-85: With Dust Slinger on Yoke
8350 2058 1 1985-86: Without Dust Slinger on Yoke
3 SEAL, Pinion
J320 8474 1 1981-85: With Dust Slinger On Yoke
5300 2642 1 1985-86: Without Dust Slinger on Yoke
4 J317 2135 1 CONE, Bearing
5 J317 2134 1 CUP, Bearing
6 J318 5971 1 SPACER
7 J320 5567 1 SHIM PACKAGE (18), Pinion ***
8 J317 2564 1 CUP, Bearing
9 J317 2563 1 CONE, Bearing
10 GEAR SET, Rear Axle Ring and Pinion
J813 2699 1 2.73 Ratio
J813 2700 1 3.31 Ratio
J813 3179 1 3.73 Ratio
J448 6825 1 3.54 Ratio
J812 7072 1 4.10 Ratio
J813 4410 1 4.56 Ratio
11 J448 6828 1 BOLT PACKAGE ***
12 CASE ASSEMBLY, Differential
J322 8921 1 2.73 Ratio
J323 6220 1 3.31, 3.54, 3.73, 4.10, 4.56 Ratios
13 J812 7092 1 GEAR SET, Differential
14 J322 0250 2 WASHER, Side Gear
15 J322 2999 2 WASHER, Pinion Gear
16 J321 8195 1 SHAFT, Differential
17 S045 5313 1 PIN
18 J320 5532 1 SHIM PACKAGE (18), Case ***
19 J317 2565 2 CONE, Bearing
20 J317 2566 2 CUP, Bearing
21 J316 2323 1 BLOCK
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 72
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, LOCKING CJ-5,6,7,8, SCRAMBLER
Figure 3-400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J318 2601 1 NUT, Pinion
2 YOKE, Pinion
J813 2702 1 1981-85: With Dust Slinger on Yoke
8350 2058 1 1985-86: Without Dust Slinger on Yoke
3 SEAL, Pinion
J320 8474 1 1981-85: With Dust Slinger on Yoke
5300 2642 1 1985-86: Without Dust Slinger On Yoke
4 J317 2135 1 CONE, Bearing
5 J317 2134 1 CUP, Bearing
6 J318 5971 1 SPACER
7 J320 5567 1 SHIM PACKAGE (18), Pinion ***
8 J317 2564 1 CUP, Bearing
9 J317 2563 1 CONE, Bearing
10 GEAR SET, Rear Axle Ring And Pinion
J813 2699 1 2.73 Ratio
J813 2700 1 3.31 Ratio
J813 3179 1 3.73 Ratio
J448 6825 1 3.54 Ratio
J812 7072 1 4.10 Ratio
J813 4410 1 4.56 Ratio
11 J448 6828 1 BOLT, Package
12 CASE ASSEMBLY, Differential
J323 9844 1 2.73 Ratio
J321 2192 1 3.31, 3.54, 3.73, 4.10, 4.56 Ratios
13 J812 0326 1 GEAR SET, Differential
14 J812 0325 1 DISC PACKAGE, Differential ***
15 J320 5532 1 SHIM PACKAGE (18), Case ***
16 J317 2565 2 CONE, Bearing
17 J317 2566 2 CUP, Bearing
18 J812 1787 2 RING, Snap
19 J316 2323 1 BLOCK
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 73
SHAFTS, REAR AXLE AMC LARGE AXLE CJ-5,6,7,8, SCRAMBLER
Figure 3-500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHAFT, Axle
Right
J812 7071 1 1981
J812 7071 1 85,86 1982-83
J813 3886 1 87,88 1982-86
Left
J812 7070 1 1981
J812 7070 1 85,86 1982-83
J813 3885 1 87,88 1982-86
2 J400 1239 8 NUT
3 J315 0046 2 CONE, Bearing
4 J536 0955 2 CUP, Bearing
5 SPACER
J314 1319 AR .003" Thick
J314 1320 AR .010" Thick
6 J448 5691 2 SEAL
7 J318 4573 2 RETAINER
7 J318 4573 2 RETAINER
8 J314 3794 8 BOLT
9 J317 0700 2 SEAL
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 74
AXLE HOUSING, REAR DANA MODEL 44 CJ-7,8, SCRAMBLER
Figure 3-600
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 8350 3071 1 HOUSING, Axle
2 8350 1515 4 BOLT
3 J899 3317 AR SEALER
4 J014 0780 2 CLIP
5 8350 1571 1 PLUG
6 8350 3058 1 COVER
7 J099 1546 10 BOLT
8 J012 0361 1 NUT
9 J322 7851 1 CLAMP
10 J318 7999 1 HOSE
11 J812 5823 1 HOSE
12 J535 2955 1 BREATHER
13 J400 5063 1 SCREW
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 75
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, NON-LOCKING CJ-7,8, SCRAMBLER
Figure 3-700
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J080 1367 1 NUT, Pinion
2 YOKE, Pinion
J813 3241 1 With Dust Slinger on Yoke
8350 3388 1 Without Dust Slinger on Yoke
3 SEAL, Pinion
J099 8092 1 With Dust Slinger on Yoke
8350 3390 1 Without Dust Slinger on Yoke
4 J005 2878 1 CONE, Bearing
5 J005 2879 1 CUP, Bearing
6 J063 6566 1 SLINGER
7 J812 9221 1 SHIM PACKAGE (15), Pinion ***
8 J005 2877 1 CUP, Bearing
9 J080 7266 1 CONE, Bearing
10 GEAR SET, Rear Axle Ring and Pinion
J813 4222 1 2.72 Ratio
J813 4219 1 3.31 Ratio
J812 9217 1 3.54 Ratio
J812 9225 1 4.09 Ratio
8350 3087 1 4.56 Ratio
11 J064 9454 10 BOLT
12 CASE ASSEMBLY, Differential
8350 3073 1 2.72, 3.31, 3.54 Ratios
8350 3067 1 4.09, 4.56 Ratios
13 8350 3068 1 GEAR SET, Differential
14 J080 5325 2 WASHER, Side Gear
15 J064 5790 2 WASHER, Pinion Gear
16 8350 3069 1 SHAFT, Differential
17 J063 6360 1 PIN
18 J812 9222 1 SHIM PACKAGE (8), Case ***
19 J812 4071 1 BEARING PACKAGE ***
20 J063 6570 1 WASHER
21 J899 3317 1 SEALER
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 76
DIFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, LOCKING CJ-7,8, SCRAMBLER
Figure 3-800
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J080 1367 1 NUT, Pinion
2 YOKE, Pinion
J813 3241 1 With Dust Slinger on Yoke
8350 3388 1 Without Dust Slinger on Yoke
3 SEAL, Pinion
J099 8092 1 With Dust Slinger on Yoke
8350 3390 1 Without Dust Slinger on Yoke
4 J005 2878 1 CONE, Bearing
5 J005 2879 1 CUP, Bearing
6 J063 6566 1 Slinger ***
7 J812 9221 1 SHIM PACKAGE (15), Pinion ***
8 J005 2877 1 CUP, Bearing
9 J080 7266 1 CONE, Bearing
10 GEAR SET, Rear Axle Ring and Pinion
J813 4222 1 2.72 Ratio
J813 4219 1 3.31 Ratio
J812 9217 1 3.54 Ratio
J812 9225 1 4.09 Ratio
8350 3087 1 4.56 Ratio
11 J064 9454 10 BOLT
12 CASE ASSEMBLY, Differential
J812 9218 1 2.72, 3.31, 3.54 Ratios
J812 9232 1 4.09, 4.56 Ratios
13 GEAR SET, Differential
J812 9220 1 Cross Shaft secured by two Retaining Rings
8350 5432 1 Cross Shaft Secured by a Roll Pin
14 J099 4345 1 DISC PACKAGE, Differential ***
15 J812 9222 1 SHIM PACKAGE (8), Case ***
16 J812 4071 1 BEARING PACKAGE ***
17 J064 5790 2 WASHER, Pinion Gear
18 8350 3070 2 RING, Snap
19 J899 3317 1 SEALER
20 J063 6570 1 WASHER
21 8350 3069 1 SHAFT, Secured by two Retaining Rings
22 J063 6360 1 PIN, Cross Shaft
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 77
SHAFTS, REAR AXLE DANA MODEL 44 CJ-7,8, SCRAMBLER
Figure 3-900
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHAFT, Axle
8350 3074 1 Right
8350 3075 1 Left
2 8350 3077 2 RING, Retaining
3 J535 5719 10 STUD, Wheel
4 8350 4190 2 RETAINER
5 J324 0086 2 SEAL
6 J323 0115 2 BEARING
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 78
AXLE ASSEMBLY, REAR AMC OR DANA MODEL 35 XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 3-1000
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 XJ AXLE ASSEMBLY, Without Locking Differential ***
5300 1317 1 1984-85: 3.31 Ratio, With System Sentry, Stamped T
5300 0934 1 1984-85: 3.31 Ratio, Without System Sentry, Stamped T
5300 1319 1 1984-85: 3.73 Ratio, With System Sentry, Stamped S
5300 0462 1 1984-85: 3.73 Ratio, Without System Sentry, Stamped S
5300 0934 1 1986: 3.31 Ratio, Stamped T or Tagged 8953004215
8350 3024 1 1986: 3.31 Ratio, Tagged 8953004512
8350 3009 1 1986: 3.31 Ratio, Tagged 8953004043
5300 0463 1 1986: 3.54 Ratio, Stamped E or Tagged 8953004216
8350 3025 1 1986: 3.54 Ratio, Tagged 8953004513
8350 3011 1 1986: 3.54 Ratio, Tagged 8953003692
5300 0464 1 1986: 4.11 Ratio, Stamped K or Tagged 8953004217
8350 3026 1 1986: 4.11 Ratio, Tagged 8953004514
8350 3012 1 1986: 4.11 Ratio, Tagged 8953003695
2 XJ AXLE ASSEMBLY, With Locking Differential ***
5300 0984 1 1984-85: 3.31 Ratio, Without System Sentry, Stamped TT
5300 0985 1 1984-85: 3.73 Ratio, Without System Sentry, Stamped SS
5300 3483 1 1986: 4.11 Ratio, Stamped KK or Tagged 8953004218
8350 3027 1 1986: 4.11 Ratio, Tagged 8953004515
8350 3013 1 1986: 4.11 Ratio, Tagged 8953003693
3 MJ AXLE ASSEMBLY, Without Locking Differential ***
5300 3878 1 3.31 Ratio, Stamped T or Tagged 8953004219
8350 3029 1 3.31 Ratio, Tagged 8953004516
8350 3015 1 3.31 Ratio, Tagged 8953004045 or 8953004768
5300 1686 1 3.54 Ratio, Stamped E or Tagged 8953004220
8350 3030 1 3.54 Ratio, Tagged 8953004517
8350 3016 1 3.54 Ratio, Tagged 8953003697
8350 3391 1 3.55 Ratio. Tagged 8953004697
5300 1687 1 4.11 Ratio, Stamped K or Tagged 8953004221
8350 3031 1 4.11 Ratio, Tagged 8953004518
8350 3017 1 4.11 Ratio. Tagged 8953003699
4 MJ AXLE ASSEMBLY, With Locking Differential ***
5300 3880 1 4.11 Ratio, Stamped KK or Tagged 8953004222
8350 3032 1 4.11 Ratio, Tagged 8953004519
8350 3020 1 4.11 Ratio, Tagged 8953003698
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 79
AXLE HOUSING, REAR AMC OR DANA MODEL 35 XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 3-1100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 XJ HOUSING, Axle
8350 0139 1 1984-85
8350 3023 1 1986: Stamped T,E,K,KK or Tagged 8953004215, 8953004216,
8350 3008 1 1986: Tagged 8953003692, 8953004043 or 8953003693
2 MJ HOUSING, Axle
8350 2507 1 Stamped T,E,K,KK or Tagged 8953004516, 8953004517,
8350 3014 1 Tagged 8953004045, 8953003697, 8953003698, 8953003699,
3 J899 3317 1 SEALER
4 8350 5125 1 COVER PACKAGE
5 J400 5725 1 PLUG
6 J400 4514 10 BOLT
7 SEAL
5300 0476 2 XJ 1984-85
5300 0476 2 XJ 1986: Stamped T,E,K,KK or Tagged 8953004215, 8953004216,
8350 3010 2 XJ 1986: Tagged 8953003692, 8953004043 or 8953003693
5300 0476 2 MJ Stamped T,E,K,KK or Tagged 8953004219, 8953004220,
8350 3010 1 MJ Tagged 8953004045, 8953003697, 8953003698, 8953003699,
8 J318 7999 1 VENT
9 J322 7851 1 CLAMP
10 J318 7627 1 HOSE, Vent
11 J535 2955 1 BREATHER
12 J942 6241 1 SCREW
13 J012 0526 1 CLIP
14 J400 6553 4 BOLT
15 J322 9429 1 GASKET
16 5300 0376 1 SENSOR, System Sentry
17 3300 0322 1 GASKET
18 8350 0271 1 PLUG PACKAGE, Without System Sentry ***
19 5300 1425 1 SHIELD, System Sentry Sensor
20 5300 1440 1 BRACKET
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
8953004217, 8953004218, 8953004512, 8953004513,
8953004514, 8353003695 or 8953004515
8953004518 or 8953004519
8953004697 or 8953004768
8953004217, 8953004218, 8953004512, 8953004513,
8353003695 or 8953004515
8953004221, 8953004222, 8953004516, 8953004517,
8953004518 or 8953004519
8953004697 or 8953004768
RETURN TO GROUP INDEX
«
»
Page 80
AXLE HOUSING, REAR AMC OR DANA MODEL 35 XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 3-1100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
21 3420 1871 1 SCREW
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 81
DIFFERRENTIAL AND GEARS, REAR AXLE AMC OR DANA MODEL 35, NON-LOCKING XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 3-1200
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J318 2601 1 NUT, Pinion
2 8350 3318 1 YOKE, Pinion
3 5300 2642 1 SEAL, Pinion
4 J315 6063 1 CONE, Bearing
5 J315 6062 1 CUP, Bearing
6 J317 5779 1 SPACER, Pinion
7 8350 3003 1 SHIM PACKAGE (8), Pinion ***
8 J315 6065 1 CUP, Bearing
9 J317 0947 1 CONE, Bearing
10 GEAR SET, Rear Axle Ring and Pinion
J448 7814 1 3.31 Ratio
J813 0782 1 3.54 Ratio
8350 3197 1 3.55 Ratio
8350 0257 1 3.73 Ratio
8350 2486 1 4.11 Ratio
8350 3432 1 4.56 Ratio
11 J320 2890 1 BOLT PACKAGE ***
12 5300 0561 1 CASE ASSEMBLY, Differential
13 8350 0138 1 GEAR SET, Differential
14 J323 7817 2 WASHER, Side Gear
15 J323 7818 2 WASHER, Pinion Gear
16 J322 4231 1 SHAFT, Differential
17 S045 5313 1 PIN
18 8350 3004 1 SHIM PACKAGE (16), Case ***
19 J315 6052 2 CONE, Bearing
20 J317 1166 2 CUP, Bearing
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 82
DIFFERRENTIAL AND GEARS, REAR AXLE AMC OR DANA MODEL 35, LOCKING XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 3-1300
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J318 2601 1 NUT, Pinion
2 8350 3318 1 YOKE, Pinion
3 5300 2642 1 SEAL, Pinion
4 J315 6063 1 CONE, Bearing
5 J315 6062 1 CUP, Bearing
6 J317 5779 1 SPACER, Pinion
7 8350 3003 1 SHIM PACKAGE (8), Pinion ***
8 J315 6065 1 CUP, Bearing
9 J317 0947 1 CONE, Bearing
10 GEAR SET, Rear Axle Ring and Pinion
J448 7814 1 3.31 Ratio
8350 3197 1 3.55 Ratio
8350 0257 1 3.73 Ratio
8350 2486 1 4.11 Ratio
11 J320 2890 1 BOLT PACKAGE ***
12 5300 0986 1 CASE ASSEMBLY, Differential
13 8350 0262 1 GEAR SET, Differential
14 8350 0263 1 DISC PACKAGE, Differential ***
15 8350 3004 1 SHIM PACKAGE (16), Case ***
16 J315 6052 2 CONE, Bearing
17 J317 1166 2 CUP, Bearing
18 8350 1445 2 RING, Snap
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 83
SHAFT, REAT AXLE AMC OR DANA MODEL 35 XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 3-1400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHAFT, Axle
Right
5300 0404 1 XJ 1984-85
5300 0404 1 XJ 1986: Stamped T,E,K,KK or Tagged 8953004215, 8953004216,
5300 0404 1 MJ Stamped T,E,K,KK or Tagged 8953004219, 8953004220,
Left
5300 0403 1 XJ 1984-85
5300 0403 1 XJ 1986: Stamped T,E,K,KK or Tagged 8953004215, 8953004216,
5300 0403 1 MJ Stamped T,E,K,KK or Tagged 8953004219, 8953004220,
2 J322 0275 10 STUD, Wheel
3 5300 0460 2 PLATE, Guide
4 RETAINER, Seal
5300 0459 2 XJ 1984-85
5300 0459 2 XJ 1986: Stamped T,E,K,KK or Tagged 8953004215, 8953004216,
5300 0459 2 MJ Stamped T,E,K,KK or Tagged 8953004219, 8953004220,
8350 3022 2 XJ Tagged 8953004512, 8953004513, 8953004514, 8953004515,
8350 3022 2 MJ Tagged 8953004516, 8953004517, 8953004518 or 8953004519
5 5300 0477 2 SEAL
6 5300 0475 2 BEARING
7 RING, Retaining
5300 2527 2 XJ 1984-85
5300 2527 2 XJ 1986: Stamped T,E,K,KK or Tagged 8953004215, 8953004216,
5300 2527 2 MJ Stamped T,E,K,KK or Tagged 8953004219, 8953004220,
8 SHAFT, Axle
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
8953004217, 8953004218, 8953004512, 8953004513,
8953004514 or 8953004515
8953004221, 8953004222, 8953004516, 8953004517,
8953004518 or 8953004519
8953004217, 8953004218, 8953004512, 8953004513,
8953004514 or 8953004515
8953004221, 8953004222, 8953004516, 8953004517,
8953004518 or 8953004519
8953004217 or 8953004218
8953004221 or 8953004222
8953004043, 8953003692 or 8953003693
8953004217, 8953004218, 8953004512, 8953004513,
8953004514 or 8953004515
8953004221, 8953004222, 8953004516, 8953004517,
8953004518 or 8953004519
RETURN TO GROUP INDEX
«
»
Page 84
SHAFT, REAT AXLE AMC OR DANA MODEL 35 XJ CHEROKEE, XJ WAGONEER, COMANCHE
Figure 3-1400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
Right
8350 2882 1 XJ 1986: Tagged 8953004043, 8953003692 or 8953003693
8350 2882 1 MJ Tagged 8953004045, 8953003697, 8953003698, 8953003699
Left
8350 2883 1 XJ 1986: Tagged 8953004043, 8953003692 or 8953003693
8350 2883 1 MJ Tagged 8953004045, 8953003697, 8953003698, 8953003699
9 8350 3053 10 STUD, Wheel
10 RETAINER, Seal
8350 3022 2 XJ 1986: Tagged 8953004043, 8953003692 or 8953003693
8350 3022 2 MJ Tagged 8953004045, 8953003697, 8953003698, 8953003699
11 RING, Retaining
8350 3054 2 XJ 1986: Tagged 8953004043, 8953003692 or 8953003693
8350 3054 2 MJ Tagged 8953004045, 8953003697, 8953003698, 8953003699
or 8953004768
or 8953004768
or 8953004768
or 8953004768
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
«
Page 85
AXLE ASSEMBLY, REAR AMC LARGE AXLE COMANCHE
Figure 3-1500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 AXLE ASSEMBLY, Without Locking Differential ***
5300 1536 1 1986: 4.10 Ratio, Stamped C
2 AXLE ASSEMBLY, With Locking Differential ***
5300 1539 1 1986: 4.10 Ratio, Stamped CC
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 86
AXLE ASSEMBLY, REAR AMC LARGE AXLE COMANCHE
Figure 3-1500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 8320 2504 1 HOUSING, Axle
2 J400 6554 4 BOLT
3 J942 6241 1 SCREW
4 J317 2122 1 GASKET
5 J400 4751 1 PLUG
6 J323 5929 1 SEAL
7 J400 6708 12 BOLT
8 J321 5943 1 COVER
9 J012 0526 1 CLIP
10 J535 2955 1 BREATHER
11 J322 7851 1 CLAMP
12 J318 7999 1 VENT
13 J318 7627 1 HOSE
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 87
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, NON-LOCKING COMANCHE
Figure 3-1700
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J318 2601 1 NUT, Pinion
2 8350 2058 1 YOKE, Pinion
3 5300 2642 1 SEAL, Pinion
4 J317 2135 1 CONE, Bearing
5 J317 2134 1 CUP, Bearing
6 J317 5971 1 SPACER, Pinion
7 J320 5567 1 SHIM PACKAGE (18), Pinion ***
8 J317 2564 1 CUP, Bearing
9 J317 2563 1 CONE, Bearing
10 J812 7072 1 GEAR SET, Rear Axle Ring and Pinion
11 J448 6828 1 BOLT PACKAGE ***
12 J323 5502 1 CASE ASSEMBLY, Differential
13 J812 7092 1 GEAR SET, Differential
14 J322 0250 2 WASHER, Side Gear
15 J322 2999 2 WASHER, Pinion Gear
16 J321 8195 1 SHAFT, Differential
17 S045 5313 1 PIN
18 J320 5532 1 SHIM PACKAGE (18), Case ***
19 J317 2565 2 CONE, Bearing
20 J317 2566 2 CUP, Bearing
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 88
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, LOCKING COMANCHE
Figure 3-1800
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J318 2601 1 NUT, Pinion
2 8350 2058 1 YOKE, Pinion
3 5300 2642 1 SEAL, Pinion
4 J317 2135 1 CONE, Bearing
5 J317 2134 1 CUP, Bearing
6 J318 5971 1 SPACER, Pinion
7 J320 5567 1 SHIM PACKAGE (18), Pinion ***
8 J317 2564 1 CUP, Bearing
9 J317 2563 1 CONE, Bearing
10 J812 7072 1 GEAR SET, Rear Axle Ring and Pinion
11 J448 6828 1 BOLT PACKAGE ***
12 J323 0153 1 CASE ASSEMBLY, Differential
13 J812 0326 1 GEAR SET, Differential
14 J812 0325 1 DISC PACKAGE, Differential ***
15 J320 5532 1 SHIM PACKAGE (18), Case ***
16 J317 2565 2 CONE, Bearing
17 J317 2566 2 CUP, Bearing
18 J812 1787 2 RING, Snap
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 89
SHAFT, REAR AXLE AMC LARGE AXLE COMANCHE
Figure 3-1900
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 5300 1262 2 SHAFT, Axle
2 J322 0275 10 STUD
3 5300 0460 2 PLATE
4 5300 1953 2 RETAINER
5 J324 0086 2 SEAL
6 J323 0115 2 BEARING
7 J323 9074 2 RING, Retaining
8 5300 1524 2 SHAFT ASSEMBLY, Axle
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 90
AXLE ASSEMBLY, REAR DANA MODEL 44 COMANCHE
Figure 3-2000
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 AXLE ASSEMBLY, Without Locking Differential ***
8350 3056 1 1986: 4.09 Ratio, Tagged 8953003701 or 8953004695
2 AXLE ASSEMBLY, With Locking Differential ***
8350 3057 1 1986: 4.09 Ratio, Tagged 8953003700
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 91
AXLE HOUSING, REAR DANA MODEL 44 COMANCHE
Figure 3-2100
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 8350 3055 1 HOUSING, Axle
2 8350 3058 1 COVER
3 J899 3317 1 SEALER
4 8350 1571 1 PLUG
5 J099 1546 10 BOLT
6 8350 1515 4 BOLT
7 J318 7627 1 HOSE, Vent
8 J942 6241 1 SCREW
9 J012 0526 1 CLIP
10 J535 2955 1 BREATHER
11 J322 7851 1 CLAMP
12 J318 7999 1 VENT
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 92
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, NON-LOCKING COMANCHE
Figure 3-2200
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J080 1367 1 NUT, Pinion
2 YOKE, Pinion
J813 3241 1 With Dust Slinger on Yoke
8350 3388 1 Without Dust Slinger on Yoke
3 SEAL, Pinion
J099 8092 1 With Dust Slinger on Yoke
8350 3390 1 Without Dust Slinger On Yoke
4 J005 2878 1 CONE, Bearing
5 J005 2879 1 CUP, Bearing
6 J063 6566 1 SLINGER
7 J812 9221 1 SHIM PACKAGE (15), Pinion ***
8 J005 2877 1 CUP, Bearing
9 J080 7266 1 CONE, Bearing
10 8350 3059 1 GEAR SET, Rear Axle Ring and Pinion
11 J064 9454 10 BOLT
12 8350 3067 1 CASE ASSEMBLY, Differential
13 8350 3068 1 GEAR SET, Differential
14 J080 5325 2 WASHER, Side Gear
15 J064 5790 2 WASHER, Pinion Gear
16 8350 3069 1 SHAFT, Differential
17 J063 6360 1 PIN
18 J812 9222 1 SHIM PACKAGE (8), Case ***
19 J812 4071 1 BEARING PACKAGE ***
20 J063 6570 1 WASHER
21 J899 3317 1 SEALER
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 93
DIFFERENTIAL AND GEARS, REAR AXLE DANA MODEL 44, LOCKING COMANCHE
Figure 3-2300
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J080 1367 1 NUT, Pinion
2 J813 3241 1 YOKE, Pinion
3 J099 8092 1 SEAL, Pinion
4 J005 2878 1 CONE, Bearing
5 J005 2879 1 CUP, Bearing
6 J063 6566 1 SLINGER
7 J812 9221 1 SHIM PACKAGE (15), Pinion ***
8 J005 2877 1 CUP, Bearing
9 J081 7266 1 CONE, Bearing
10 8350 3059 1 GEAR SET, Rear Axle Ring and Pinion
11 J064 9454 10 BOLT
12 J812 9232 1 CASE ASSEMBLY, Differential
13 J812 9220 1 GEAR SET, Differential
14 J099 4345 1 DISC PACKAGE, Differential ***
15 J812 9222 1 SHIM PACKAGE (8), Case ***
16 J812 4071 1 BEARING PACKAGE ***
17 J064 5790 2 WASHER, Pinion Gear
18 8350 3070 2 RING, Snap
19 J899 3317 1 SEALER
20 J063 6570 1 WASHER
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 94
SHAFTS, REAR AXLE DANA MODEL 44 COMANCHE
Figure 3-2400
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHAFT, Axle
8350 3060 1 Right
8350 3061 1 Left
2 J322 0275 10 STUD
3 8350 4190 2 RETAINER
4 8350 3063 2 SEAL
5 8350 3064 2 BEARING
6 8350 3077 2 RING, Retaining
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 95
AXLE ASSEMBLY, REAR AMC LARGE, DANA 44, DANA 60 SJ CHEROKEE, SJ WAGONEER, J10, J20
Figure 3-2500
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 AXLE ASSEMBLY, AMC Large Without Locking Differential ***
J536 1201 1 15,16,1 1981-84: 2.73 Ratio Stamped AA or D
J536 5158 1 15 1985-86: 2.73 Ratio Stamped D
J536 1211 1 25,26 1981-86: 2.73 Ratio Stamped AA or D
J536 1203 1 15,16,1 1981-84: 3.31 Ratio Stamped B or BB
J536 5159 1 15 1985-86: 3.31 Ratio Stamped B
J536 1208 1 17 1981-83: 3.31 Ratio Stamped B or BB
J536 1213 1 25,26 1981-86: 3.31 Ratio Stamped B or BB
2 AXLE ASSEMBLY, AMC Large With Locking Differential ***
J536 1202 1 15,16,1 1981-84: 2.73 Ratio Stamped DD
J536 5160 1 15 1985-86: 2.73 Ratio Stamped DD
J536 1212 1 25,26 1981-86: 2.73 Ratio Stamped DD
J536 1204 1 15,16,1 1981-84: 3.31 Ratio Stamped BB or CC
J536 5161 1 15 1985-86: 3.31 Ratio Stamped BB
J536 1209 1 17 1981-83: 3.31 Ratio Stamped BB or CC
J536 1214 1 25,26 1981-86: 3.31 Ratio Stamped BB or CC
3 AXLE ASSEMBLY, DANA Model 44 Without Locking Differential ***
8350 3092 1 15 1986: 2.73 Ratio Tagged 8953004028
8350 3098 1 26 1986: 2.73 Ratio Tagged 8953004032
8350 3089 1 15 1986: 3.31 Ratio Tagged 8953004030
8350 3096 1 26 1986: 3.31 Ratio Tagged 8953004034
4 AXLE ASSEMBLY, DANA Model 44 With Locking Differential ***
8350 3093 1 15 1986: 3.31 Ratio Tagged 8953004031
8350 3099 1 26 1986: 3.31 Ratio Tagged 8953004035
5 AXLE ASSEMBLY, DANA Model 60 Without Locking Differential ***
J813 1928 1 27 1981-86: 3.73 Ratio Tagged 5359531, 5363417 or 8953004087
6 AXLE ASSEMBLY, DANA Model 60 With Locking Differential ***
J813 1927 1 27 1981-86: 3.73 Ratio Tagged 5359532, 5363418 or 8953004086
J813 1931 1 27 1981-86: 4.88 Ratio Tagged 5359528, 5363419 or 8953004088
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 96
AXLE HOUSING, REAR AMC LARGE AXLE SJ CHEROKEE, SJ WAGONEER, J10, J20
Figure 3-2600
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 HOUSING, Axle
J813 0993 1 15,16,1 1981-84
8350 1400 1 15 1985-86
J813 0991 1 17 1981-83
J813 0992 1 25,26 1981-86
2 J400 6554 4 BOLT
3 J400 5063 1 SCREW
4 J317 2122 1 GASKET
5 J400 4751 1 PLUG
6 J323 5929 2 SEAL
7 J099 1546 12 BOLT
8 J321 5943 1 COVER
9 J012 0525 1 CLIP
10 J535 2955 1 BREATHER
11 J322 7851 1 CLAMP
12 J535 3494 1 VENT
13 J812 5823 1 HOSE
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 97
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, NON-LOCKING SJ CHEROKEE, SJ WAGONEER, J10
Figure 3-2700
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J318 2601 1 NUT, Pinion
2 YOKE, Pinion
J813 2702 1 1981-85: With Dust Slinger on Yoke
8350 2058 1 1985-86: Without Dust Slinger on Yoke
3 SEAL, Pinion
J320 8474 1 1981-85: With Dust Slinger on Yoke
5300 2642 1 1985-86: Without Dust Slinger on Yoke
4 J317 2135 1 CONE, Bearing
5 J317 2134 1 CUP, Bearing
6 J318 5971 1 SPACER
7 J320 5567 1 SHIM PACKAGE (18), Pinion ***
8 J317 2564 1 CUP, Bearing
9 J317 2563 1 CONE, Bearing
10 GEAR SET, Rear Axle Ring and Pinion
J813 2699 1 2.73 Ratio
J813 2700 1 3.31 Ratio
11 J448 6828 1 BOLT PACKAGE ***
12 CASE ASSEMBLY, Differential
J323 5503 1 2.73 Ratio
J323 5502 1 3.31 Ratio
13 J812 7092 1 GEAR SET, Differential
14 J322 0250 2 WASHER, Side Gear
15 J322 2999 2 WASHER, Pinion Gear
16 J321 8195 1 SHAFT, Differential
17 S045 5313 1 PIN
18 J320 5532 1 SHIM PACKAGE (18), Case ***
19 J317 2565 2 CONE, Bearing
20 J317 2566 2 CUP, Bearing
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 98
DIFFERENTIAL AND GEARS, REAR AXLE AMC LARGE AXLE, LOCKING SJ CHEROKEE, SJ WAGONEER, J10
Figure 3-2800
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 J318 2601 1 NUT, Pinion
2 YOKE, Pinion
J813 2702 1 1981-85: With Dust Slinger on Yoke
8350 2058 1 1985-86: Without Dust Slinger on Yoke
3 SEAL Pinion ***
J320 8474 1 1981-85: With Dust Slinger on Yoke
5300 2642 1 1985-86: Without Dust Slinger On Yoke
4 J317 2135 1 CONE, Bearing
5 J317 2134 1 CUP, Bearing
6 J318 5971 1 SPACER
7 J320 5567 1 SHIM PACKAGE (18), Pinion ***
8 J317 2564 1 CUP, Bearing
9 J317 2563 1 Cone, Bearing ***
10 GEAR SET, Rear Axle Ring and Pinion
J813 2699 1 2.73 Ratio
J813 2700 1 3.31 Ratio
11 J448 6828 1 BOLT PACKAGE ***
12 CASE ASSEMBLY, Differential
J323 6264 1 2.73 Ratio
J323 0153 1 3.31 Ratio
13 J812 0326 1 GEAR SET, Differential
14 J812 0325 1 DISC PACKAGE, Differential ***
15 J320 5532 1 SHIM PACKAGE (18), Case ***
16 J317 2565 2 CONE, Bearing
17 J317 2566 2 CUP, Bearing
18 J812 1787 2 RING, Snap
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 99
SHAFTS, REAR AXLE AMC LARGE AXLE SJ CHEROKEE, SJ WAGONEER, J10
Figure 3-2900
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 SHAFTS, Rear Axle ***
Right
J323 5806 1 15,16,1
J323 5810 1 17
J323 5808 1 25,26
Left
J323 5807 1 15,16,1
J323 5811 1 17
J323 5809 1 25,26
2 J323 0413 12 STUD
3 J323 9073 2 RETAINER
4 J324 0086 2 SEAL
5 J323 0115 2 BEARING
6 J323 9074 2 RING
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Page 100
AXLE HOUSING, REAR DANA MODEL 44 SJ CHEROKEE, SJ WAGONEER, J10
Figure 3-3000
PART
ITEM NUMBER QTY BODY MODEL DESCRIPTION
1 HOUSING, Axle
8350 3088 1 15
8350 3097 1 26
2 8350 1515 4 BOLT
3 J899 3317 1 SEALER
4 PLUG
8350 1571 1 3/4"-14 NPT
S044 4588 1 1/2"-14 NPT
5 J099 1546 10 BOLT
6 8350 3058 1 COVER PACKAGE
7 J942 6241 1 SCREW
8 J812 5823 1 HOSE
9 J012 0525 1 CLIP
10 J535 2955 1 BREATHER
11 J322 7851 1 CLAMP
12 J318 7999 1 VENT
RETURN TO GROUP INDEX
«
—————————————————————————————————————————————————————————————————————————
MODEL CODES
16=Cherokee 2 Dr.(1981-83) 78=Cherokee 4WD-4 Dr.(1984-86) 64=Comanche 2WD-6 Ft. Box(1986) 25=J-10 Truck 7 Ft. Box(1981-84)
17=Cherokee 2 Dr.(1981-83) 85=CJ-5 (1981-83) 66=Comanche 2WD-7 Ft. Box(1986) 26=J10 Truck 8 Ft. Box(1981-86)
73=Cherokee 2WD-2 Dr.(1984-86) 86=CJ-6(1981) 63=Comanche 4WD-6 Ft. Box(1986) 27=J-20 Truck 8 Ft. Box(1981-86)
74=Cherokee 2WD-4 Dr.(1984-86) 87=CJ-7(1981-86) 65=Comanche 4WD-7 Ft. Box(1986) 15=Wagoneer 4 Dr.(1981-83)
18=Cherokee 4 Dr.(1981-83) 88=CJ-8, Scrambler(1981-86) 15=Grand Wagoneer 4 Dr.(1984-86) 75=Wagoneer 4WD-4 Dr.(1984-86)
77=Cherokee 4WD-2 Dr.(1984-86)
—————————————————————————————————————————————————————————————————————————
BODY STYLES
CJ=CJ-5, CJ-6, CJ-7, CJ-8, Scrambler(1981-86) SJ=Wagoneer(1981-83), Grand Wagoneer(1984-86),
MJ=Comanche Pickup(1986) Cherokee(1981-83), J-10, J-20(1981-86)
XJ=Wagoneer(1984-86), Cherokee(1984-86)
AR = Use as Required - = Non Illustrated Part P.A.R. = Paint as Required
Loading...