International Comfort Products RGS036KDAA0AAAA, RGS036KLAA0AAAA, RGS036KDBA0AAAA, RGS036KLBA0AAAA, RGS036KDAB0AAAA User Manual
...
Parts List, Charging Chart,Wiring
Diagrams
RGS 3 − 10 TON SERIES
1 & 3 Phase
R−410A PACKAGE GAS ELECTRIC
UNITS
Printed in U.S.A.
TABLE OF CONTENTS
PARTS −−−−−−−− SEE PAGE 2
PARTS DRAWING −−−118−138
CHARGING CHART−−139−145
WIRING DIAGRAM −−146−154
509 04 3502 00
6/26/09
RGS Parts List
3 Ton 208 / 230v 1Phase 3 − 8
4 Ton 208 / 230v 1Phase 9 − 17
5 Ton 208 / 230v 1Phase 18 − 26
3 Ton 208 / 230v 3Phase 27 − 30
4 Ton 208 / 230v 3Phase 31 − 34
5 Ton 208 / 230v 3Phase 35 − 42
6 Ton 208 / 230v 3Phase 43 − 46
3 Ton 460v 3Phase 47 − 50
4 Ton 460v 3Phase 51 − 57
5 Ton 460v 3Phase 58 − 64
6 Ton 460v 3Phase 65 − 68
PAGE
3 Ton 575v 3Phase 69 − 72
4 Ton 575v 3Phase 73 − 76
5 Ton 575v 3Phase 77 − 80
6 Ton 575v 3Phase 81 − 84
7.5 Ton 208 / 230v 3Phase 85 − 88
8.5 Ton 208 / 230v 3Phase 89 − 92
10 Ton 208 / 230v 3Phase 93 − 96
7.5 Ton 460v 3Phase 97 − 100
8.5 Ton 460v 3Phase 101 − 104
10 Ton 460v 3Phase 105 − 108
7.5 Ton 575 3Phase 109 − 111
8.5 Ton 575 3Phase 112 − 114
10 Ton 575 3Phase 115 − 117
2
509 04 3502 00
RGS 3 Ton 208/230v 1Phase PARTS LIST
KEY
NO.
DESCRIPTION FAST PARTS NO.
RGS036KLAA0AAAA
RGS036KDAA0AAAA
RGS036KLBA0AAAA
RGS036KDBA0AAAA
RGS036KLAB0AAAA
RGS036KDAB0AAAA
RGS036KDBB0AAAA
LOW HEAT
01 COMP ZP31K5E-PFV-830 ZP31K5EPFV130 1 1 1 1 1 1 1 1
03 COIL ASY COND 3 TON AL/CU 1178038 1 1 1 1 1 1 1 1
04 COIL ASY EVAP 3 TON AL/CU 1178037 1 1 1 1 1 1 1 1
05 MTR BLW 208/230/1 1 1620 1176336 1 1 1 1 1 1 1 1
06 MTR CND 1/230 1/4 1100 1178026 1 1 1 1 1 1 1 1
07 FAN C 22" 3B 1/2" 24 INT 1178035 1 1 1 1 1 1 1 1
08 CAP RN RD 370V 5+45 1172124 1 1 1 1 1 1 1 1
10 CONTACTOR 1P 40A 24V 1176763 1 1 2 2 1 1 2 2
11 CAP RN OV 370V 15 1172505 1 1 1 1 1 1 1 1
12 MODULE IGN UT 1068-11 1171166 1 1 1 1 1 1 1 1
13 TRANS 208/230>24 75VA 1178027 1 1 1 1 1 1 1 1
14 WHEEL BLOWER 10" X 5/8 BORE 1175318 1 1 1 1 1 1 1 1
15 WHEEL SI5.75x.938x5/16 CCW 1171049 1 1 1 1 1 1 1 1
16 FAN C 3.25" 12B 5/16" 1171222 1 1 1 1 1 1 1 1
17 TERMINAL BOARD 1178030 1 1 1 1 1 1 1 1
18 SWITCH LMT 195-80 1171325 1 1 1 1 1 1 1 1
19 REGULATOR FLAME 1175855 1 1 1 1 1 1 1 1
20 SWITCH TEMP ACT 1175306 1 1 1 1 1 1 1 1
21 SENSOR FLAME 1171449 1 1 1 1 1 1 1 1
22 IGNITER ASY 1171306 1 1 1 1 1 1 1 1
23 MANIFOLD ASY 1175852 1 1 1 1 1 1 1 1
24 BURNER ASY 1171095 2 2 2 2 2 2 2 2
26 RING INSERT 1171439 2 2 2 2 2 2 2 2
27 VALVE GAS 1 STAGE 1178163 1 1 1 1 1 1 1 1
28 SPUD ORIFICE 1172226 2 * 2 * 2 * 2 *
28 SPUD ORIFICE 1172235 * 2 * 2 * 2 * 2
29 MOTOR ASY (INDUCED DRAFT) 1171314 1 1 1 1 1 1 1 1
30 SENSOR HALL EFFECT (HS) 1171450 1 1 1 1 1 1 1 1
31 MOTOR (IDM) 1171348 1 1 1 1 1 1 1 1
32 BAFFLE FLUE LWNX 1176211 * 1 * 1 * 1 * 1
33 HT EX TUBLR 2-1 SS 1176229 1 * 1 * 1 * 1 *
33 HT EX TUBLR 2-1 SS LWNX 1176231 * 1 * 1 * 1 * 1
34 BAFFLE LWNX 1175987 * 2 * 2 * 2 * 2
38 FILTER DRIER 1178033 1 1 1 1 1 1 1 1
39 GROUND LUG 1172300 1 1 1 1 1 1 1 1
40 CAP RN OV 370V 4 1175500 1 1 1 1 1 1 1 1
42 BEARING 1175424 2 2 2 2 2 2 2 2
43 KEY BLOWER 1175493 1 1 1 1 1 1 1 1
44 PULLEY BLOWER 1178034 1 1 * * 1 1 * *
44 PULLEY BLOWER 1175830 * * 1 1 * * 1 1
45 PULLEY MOTOR 1175849 1 1 1 1 1 1 1 1
46 BELT V 1178127 1 1 * * 1 1 * *
46 BELT V 1178179 * * 1 1 * * 1 1
47 SHAFT FAN 1175422 1 1 1 1 1 1 1 1
48 SWITCH PRESSURE (LPS) 1178029 1 1 1 1 1 1 1 1
50 SWITCH PRESSURE (HPS) 1178028 1 1 1 1 1 1 1 1
51 KEY MOTOR 1175300 1 1 1 1 1 1 1 1
52 ACTUATOR DAMPER MOTOR 1176280 * * * * 1 1 1 1
53 CONTROLLER 1176282 * * * * 1 1 1 1
54 SHAFT ACTUATOR 1178103 * * * * 1 1 1 1
RGS036KLBB0AAAA
509 04 3502 00
3
RGS 3 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS036KLAA0AAAA
RGS036KDAA0AAAA
RGS036KLBA0AAAA
RGS036KDBA0AAAA
RGS036KLAB0AAAA
RGS036KDAB0AAAA
RGS036KDBB0AAAA
LOW HEAT
55 SENSOR (DISCHARGE)SUPPLY AIR(MIXED) 1176279 * * * * 1 1 1 1
56 SENSOR LOW AMBIENT 1176283 * * * * 1 1 1 1
57 SENSOR OUTDOOR-AIR TEMPERATURE 1176281 * * * * 1 1 1 1
A FILTER AIR 1175312 2 2 2 2 2 2 2 2
B BOOT PROTECTIVE 1171842 1 1 1 1 1 1 1 1
C BRACKET BASERAIL CORNER 1171071 2 2 2 2 2 2 2 2
D BRACKET COIL 1171070 1 1 1 1 1 1 1 1
E CHANNEL INDUCED DRAFT MOTOR 1171112 1 1 1 1 1 1 1 1
F STRAP CAPACITOR 1171552 2 2 2 2 2 2 2 2
G COVER ASY TOP 1178042 1 1 1 1 1 1 1 1
H BRACKET SUPPORT GAS VALVE 1176209 1 1 1 1 1 1 1 1
J COVER ASY RETURN AIR 1175227 1 1 1 1 1 1 1 1
K COVER ASY SUPPLY 1175228 1 1 1 1 1 1 1 1
L GASKET REGULATOR 1175268 1 1 1 1 1 1 1 1
M GRILLE OUTLET 1171267 1 1 1 1 1 1 1 1
N GROMMET 1171270 4 4 4 4 4 4 4 4
P GUARD BASERAIL INDOOR END 1175263 1 1 1 1 1 1 1 1
R GUARD LIMIT SWITCH 1171271 1 1 1 1 1 1 1 1
S WIND CAP ASY 1173617 1 1 1 1 1 1 1 1
T HOUSING FAN 1171301 1 1 1 1 1 1 1 1
V INSULATION 1171317 1 1 1 1 1 1 1 1
W PAN ASY CONDENSATE 1175243 1 1 1 1 1 1 1 1
X PANEL ACCESS CONTROL BOX 1178168 1 1 1 1 1 1 1 1
Y PANEL ACCESS COMPRESSOR 1178046 1 1 1 1 1 1 1 1
Z PANEL ASY FILTER LOWER 1175242 1 1 1 1 * * * *
AA PANEL ASY DOOR FILTER UPPER 1175241 1 1 1 1 * * * *
AB PANEL ASY INDOOR END 1175226 1 1 1 1 1 1 1 1
AC PANEL ASY INDOOR BLOWER ACCESS 1178040 1 1 1 1 1 1 1 1
AD PANEL OUTDOOR END 1178024 1 1 1 1 1 1 1 1
AE PLATE FAN 1175484 1 1 1 1 1 1 1 1
AF PLATE FAN 1175299 1 1 1 1 1 1 1 1
AG STRAP CAPACITOR 1172734 1 1 1 1 1 1 1 1
AH POST CENTER FILTER ACCESS SIDE 1178023 1 1 1 1 1 1 1 1
AJ POST CENTER CONTROL BOX SIDE 1178167 1 1 1 1 1 1 1 1
AK POST CORNER COIL 1175256 1 1 1 1 1 1 1 1
AL POST CORNER CONTROL BOX 1178043 1 1 1 1 1 1 1 1
AM POST CORNER INDOOR END 1175230 2 2 2 2 2 2 2 2
AN CONDUIT 1171428 1 1 1 1 1 1 1 1
AP RAIL BASE FILTER ACCESS 1175266 1 1 1 1 1 1 1 1
AQ RAIL BASE INDOOR FAN ACCESS 1175265 1 1 1 1 1 1 1 1
AR RAIL BASE OUTDOOR END 1175334 1 1 1 1 1 1 1 1
AS RETAINER FLAME 1175854 1 1 1 1 1 1 1 1
AT PANEL COIL 1178104 1 1 1 1 1 1 1 1
AV PLATE MOTOR 1175844 1 1 1 1 1 1 1 1
AW SCROLL FAN 1175260 1 1 1 1 1 1 1 1
AX SUPPORT ASY INDUCER & HEAT EXCH 1175237 1 1 1 1 1 1 1 1
AY SUPPORT BURNER 1175296 1 1 1 1 1 1 1 1
AZ SUPPORT HEAT EXCHANGER BRACKET 1175258 1 1 1 1 1 1 1 1
BA BOLT HEX HEAD 1171056 4 4 4 4 4 4 4 4
BB SEAL DRAIN LINE ROUND 1171447 1 1 1 1 1 1 1 1
RGS036KLBB0AAAA
4
509 04 3502 00
RGS 3 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS036KLAA0AAAA
RGS036KDAA0AAAA
RGS036KLBA0AAAA
RGS036KDBA0AAAA
RGS036KLAB0AAAA
RGS036KDAB0AAAA
RGS036KDBB0AAAA
LOW HEAT
BC BRACKET MTR MTG 1175842 1 1 1 1 1 1 1 1
BD BRACKET ASY 1175423 2 2 2 2 2 2 2 2
BE BLOWER ASY STD STATIC 1175283 1 1 1 1 1 1 1 1
BF BASE PAN ASY INDOOR 1175231 1 1 1 1 1 1 1 1
BG BASE PAN ASY OUTDOOR 1175232 1 1 1 1 1 1 1 1
BH COVER ASY GAS HEAT 1178165 1 1 1 1 1 1 1 1
BJ DECK FAN 1175259 1 1 1 1 1 1 1 1
BL PANEL ACCESS 1178166 1 1 1 1 1 1 1 1
BM HANDLE SNAP-IN PLASTIC 1178036 3 3 3 3 3 3 3 3
BN SEAL DRAIN LINE SQUARE 1171202 1 1 1 1 1 1 1 1
BP GROMMET WIRE PARTITION 1176613 2 2 2 2 2 2 2 2
BQ PLATE ASY COMP MOUNTING 1175843 1 1 1 1 1 1 1 1
BR PLATE BLOCKOFF 1175294 1 1 1 1 1 1 1 1
BS FRAME ASY 1175238 1 1 1 1 1 1 1 1
BT RETAINER FILTER 1175273 1 1 1 1 1 1 1 1
BV RETAINER FILTER 1175274 1 1 1 1 1 1 1 1
BW RETAINER FILTER 1175275 2 2 2 2 2 2 2 2
BX BRACKET INDOOR 1175262 1 1 1 1 1 1 1 1
BZ SHIELD 1171453 1 1 1 1 1 1 1 1
CA SUPPORT 1175271 1 1 1 1 1 1 1 1
CB INSULATION 1175272 1 1 1 1 1 1 1 1
CC ANGLE BLOCKOFF 1175267 1 1 1 1 1 1 1 1
CH PANEL LOWER 1176276 * * * * 1 1 1 1
CJ PANEL UPPER 1176277 * * * * 1 1 1 1
CK HOOD LF SIDE 0640045A * * * * 1 1 1 1
CL FILTER (AL) (15.31 X 29.44 X 1) 1176284 * * * * 1 1 1 1
CM HOOD RT SIDE 0640040A * * * * 1 1 1 1
CN HOOD DIVIDER 0640014A * * * * 1 1 1 1
PARTS NOT SHOWN
)( PAINT (16-OZ CAN) (STERLING GRAY) 1171357 1 1 1 1 1 1 1 1
)( HARNESS ASY IFM 1178022 1 1 1 1 1 1 1 1
)( PLUG ASY SHORTING 1171405 1 1 1 1 1 1 1 1
)( PLUG ASY COMP 1178032 1 1 1 1 1 1 1 1
)( HARNESS ASY (J2) (YAC CONTROL) 1178161 1 1 1 1 1 1 1 1
)( HARNESS ASY(CLO1/COMP1) TERM BD 1178160 1 1 1 1 1 1 1 1
)( HARNESS ASY (PL6) (ECONOMIZER) 1178162 1 1 1 1 1 1 1 1
)( KIT WIRING 1175246 1 1 1 1 1 1 1 1
)( IGNITION CABLE 1175498 1 1 1 1 1 1 1 1
RGS036KLBB0AAAA
509 04 3502 00
5
RGS 3 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
DESCRIPTION FAST PARTS NO.
RGS036KEAA0AAAA
RGS036KEBA0AAAA
RGS036KMAA0AAAA
RGS036KMBA0AAAA
RGS036KEAB0AAAA
RGS036KEBB0AAAA
RGS036KMAB0AAAA
MED HEAT
01 COMP ZP31K5E-PFV-830 ZP31K5EPFV130 1 1 1 1 1 1 1 1
03 COIL ASY COND 3 TON AL/CU 1178038 1 1 1 1 1 1 1 1
04 COIL ASY EVAP 3 TON AL/CU 1178037 1 1 1 1 1 1 1 1
05 MTR BLW 208/230/1 1 1620 1176336 1 1 1 1 1 1 1 1
06 MTR CND 1/230 1/4 1100 1178026 1 1 1 1 1 1 1 1
07 FAN C 22" 3B 1/2" 24 INT 1178035 1 1 1 1 1 1 1 1
08 CAP RN RD 370V 5+45 1172124 1 1 1 1 1 1 1 1
10 CONTACTOR 1P 40A 24V 1176763 1 1 2 2 1 1 2 2
11 CAP RN OV 370V 15 1172505 1 1 1 1 1 1 1 1
12 MODULE IGN UT 1068-11 1171166 1 1 1 1 1 1 1 1
13 TRANS 208/230>24 75VA 1178027 1 1 1 1 1 1 1 1
14 WHEEL BLOWER 10" X 5/8 BORE 1175318 1 1 1 1 1 1 1 1
15 WHEEL SI5.75x.938x5/16 CCW 1171049 1 1 1 1 1 1 1 1
16 FAN C 3.25" 12B 5/16" 1171222 1 1 1 1 1 1 1 1
17 TERMINAL BOARD 1178030 1 1 1 1 1 1 1 1
18 SWITCH LMT 195-80 1171325 1 1 1 1 1 1 1 1
19 REGULATOR FLAME 1175869 1 1 1 1 1 1 1 1
20 SWITCH TEMP ACT 1175306 1 1 1 1 1 1 1 1
21 SENSOR FLAME 1171449 1 1 1 1 1 1 1 1
22 IGNITER ASY 1171306 1 1 1 1 1 1 1 1
23 MANIFOLD ASY 1175234 1 1 1 1 1 1 1 1
24 BURNER ASY 1171095 2 2 2 2 2 2 2 2
25 BURNER ASY 1171087 1 1 1 1 1 1 1 1
26 RING INSERT 1171439 3 3 3 3 3 3 3 3
27 VALVE GAS 1 STAGE 1178163 1 1 1 1 1 1 1 1
28 SPUD ORIFICE 1172226 3 * 3 * 3 * 3 *
28 SPUD ORIFICE 1172235 * 3 * 3 * 3 * 3
29 MOTOR ASY (INDUCED DRAFT) 1171314 1 1 1 1 1 1 1 1
30 SENSOR HALL EFFECT (HS) 1171450 1 1 1 1 1 1 1 1
31 MOTOR (IDM) 1171348 1 1 1 1 1 1 1 1
32 BAFFLE FLUE LWNX 1176044 * 1 * 1 * 1 * 1
33 HT EX TUBLR 3-2 SS 1176230 1 * 1 * 1 * 1 *
33 HT EX TUBLR 3-2 SS LWNX 1176232 * 1 * 1 * 1 * 1
34 BAFFLE LWNX 1175987 * 3 * 3 * 3 * 3
38 FILTER DRIER 1178033 1 1 1 1 1 1 1 1
39 GROUND LUG 1172300 1 1 1 1 1 1 1 1
40 CAP RN OV 370V 4 1175500 1 1 1 1 1 1 1 1
42 BEARING 1175424 2 2 2 2 2 2 2 2
43 KEY BLOWER 1175493 1 1 1 1 1 1 1 1
44 PULLEY BLOWER 1178034 1 1 * * 1 1 * *
44 PULLEY BLOWER 1175830 * * 1 1 * * 1 1
45 PULLEY MOTOR 1175849 1 1 1 1 1 1 1 1
46 BELT V 1178127 1 1 * * 1 1 * *
46 BELT V 1178179 * * 1 1 * * 1 1
47 SHAFT FAN 1175422 1 1 1 1 1 1 1 1
48 SWITCH PRESSURE (LPS) 1178029 1 1 1 1 1 1 1 1
50 SWITCH PRESSURE (HPS) 1178028 1 1 1 1 1 1 1 1
51 KEY MOTOR 1175300 1 1 1 1 1 1 1 1
52 ACTUATOR DAMPER MOTOR 1176280 * * * * 1 1 1 1
53 CONTROLLER 1176282 * * * * 1 1 1 1
RGS036KMBB0AAAA
6
509 04 3502 00
RGS 3 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS036KEAA0AAAA
RGS036KEBA0AAAA
RGS036KMAA0AAAA
RGS036KMBA0AAAA
RGS036KEAB0AAAA
RGS036KEBB0AAAA
RGS036KMAB0AAAA
MED HEAT
54 SHAFT ACTUATOR 1178103 * * * * 1 1 1 1
55 SENSOR (DISCHARGE)SUPPLY AIR(MIXED) 1176279 * * * * 1 1 1 1
56 SENSOR LOW AMBIENT 1176283 * * * * 1 1 1 1
57 SENSOR OUTDOOR-AIR TEMPERATURE 1176281 * * * * 1 1 1 1
A FILTER AIR 1175312 2 2 2 2 2 2 2 2
B BOOT PROTECTIVE 1171842 1 1 1 1 1 1 1 1
C BRACKET BASERAIL CORNER 1171071 2 2 2 2 2 2 2 2
D BRACKET COIL 1171070 1 1 1 1 1 1 1 1
E CHANNEL INDUCED DRAFT MOTOR 1171112 1 1 1 1 1 1 1 1
F STRAP CAPACITOR 1171552 2 2 2 2 2 2 2 2
G COVER ASY TOP 1178042 1 1 1 1 1 1 1 1
H BRACKET SUPPORT GAS VALVE 1176209 1 1 1 1 1 1 1 1
J COVER ASY RETURN AIR 1175227 1 1 1 1 1 1 1 1
K COVER ASY SUPPLY 1175228 1 1 1 1 1 1 1 1
L GASKET REGULATOR 1175268 1 1 1 1 1 1 1 1
M GRILLE OUTLET 1171267 1 1 1 1 1 1 1 1
N GROMMET 1171270 4 4 4 4 4 4 4 4
P GUARD BASERAIL INDOOR END 1175263 1 1 1 1 1 1 1 1
R GUARD LIMIT SWITCH 1171271 1 1 1 1 1 1 1 1
S WIND CAP ASY 1173617 1 1 1 1 1 1 1 1
T HOUSING FAN 1171301 1 1 1 1 1 1 1 1
V INSULATION 1171317 1 1 1 1 1 1 1 1
W PAN ASY CONDENSATE 1175243 1 1 1 1 1 1 1 1
X PANEL ACCESS CONTROL BOX 1178168 1 1 1 1 1 1 1 1
Y PANEL ACCESS COMPRESSOR 1178046 1 1 1 1 1 1 1 1
Z PANEL ASY FILTER LOWER 1175242 1 1 1 1 * * * *
AA PANEL ASY DOOR FILTER UPPER 1175241 1 1 1 1 * * * *
AB PANEL ASY INDOOR END 1175226 1 1 1 1 1 1 1 1
AC PANEL ASY INDOOR BLOWER ACCESS 1178040 1 1 1 1 1 1 1 1
AD PANEL OUTDOOR END 1178024 1 1 1 1 1 1 1 1
AE PLATE FAN 1175484 1 1 1 1 1 1 1 1
AF PLATE FAN 1175299 1 1 1 1 1 1 1 1
AG STRAP CAPACITOR 1172734 1 1 1 1 1 1 1 1
AH POST CENTER FILTER ACCESS SIDE 1178023 1 1 1 1 1 1 1 1
AJ POST CENTER CONTROL BOX SIDE 1178167 1 1 1 1 1 1 1 1
AK POST CORNER COIL 1175256 1 1 1 1 1 1 1 1
AL POST CORNER CONTROL BOX 1178043 1 1 1 1 1 1 1 1
AM POST CORNER INDOOR END 1175230 2 2 2 2 2 2 2 2
AN CONDUIT 1171428 1 1 1 1 1 1 1 1
AP RAIL BASE FILTER ACCESS 1175266 1 1 1 1 1 1 1 1
AQ RAIL BASE INDOOR FAN ACCESS 1175265 1 1 1 1 1 1 1 1
AR RAIL BASE OUTDOOR END 1175334 1 1 1 1 1 1 1 1
AS RETAINER FLAME 1175287 1 1 1 1 1 1 1 1
AT PANEL COIL 1178104 1 1 1 1 1 1 1 1
AV PLATE MOTOR 1175844 1 1 1 1 1 1 1 1
AW SCROLL FAN 1175260 1 1 1 1 1 1 1 1
AX SUPPORT ASY INDUCER & HEAT EXCH 1175237 1 1 1 1 1 1 1 1
AY SUPPORT BURNER 1175296 1 1 1 1 1 1 1 1
AZ SUPPORT HEAT EXCHANGER BRACKET 1175258 1 1 1 1 1 1 1 1
BA BOLT HEX HEAD 1171056 4 4 4 4 4 4 4 4
RGS036KMBB0AAAA
509 04 3502 00
7
RGS 3 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS036KEAA0AAAA
RGS036KEBA0AAAA
RGS036KMAA0AAAA
RGS036KMBA0AAAA
RGS036KEAB0AAAA
RGS036KEBB0AAAA
RGS036KMAB0AAAA
MED HEAT
BB SEAL DRAIN LINE ROUND 1171447 1 1 1 1 1 1 1 1
BC BRACKET MTR MTG 1175842 1 1 1 1 1 1 1 1
BD BRACKET ASY 1175423 2 2 2 2 2 2 2 2
BE BLOWER ASY STD STATIC 1175283 1 1 1 1 1 1 1 1
BF BASE PAN ASY INDOOR 1175231 1 1 1 1 1 1 1 1
BG BASE PAN ASY OUTDOOR 1175232 1 1 1 1 1 1 1 1
BH COVER ASY GAS HEAT 1178165 1 1 1 1 1 1 1 1
BJ DECK FAN 1175259 1 1 1 1 1 1 1 1
BL PANEL ACCESS 1178166 1 1 1 1 1 1 1 1
BM HANDLE SNAP-IN PLASTIC 1178036 3 3 3 3 3 3 3 3
BN SEAL DRAIN LINE SQUARE 1171202 1 1 1 1 1 1 1 1
BP GROMMET WIRE PARTITION 1176613 2 2 2 2 2 2 2 2
BQ PLATE ASY COMP MOUNTING 1175843 1 1 1 1 1 1 1 1
BR PLATE BLOCKOFF 1175294 1 1 1 1 1 1 1 1
BS FRAME ASY 1175238 1 1 1 1 1 1 1 1
BT RETAINER FILTER 1175273 1 1 1 1 1 1 1 1
BV RETAINER FILTER 1175274 1 1 1 1 1 1 1 1
BW RETAINER FILTER 1175275 2 2 2 2 2 2 2 2
BX BRACKET INDOOR 1175262 1 1 1 1 1 1 1 1
BZ SHIELD 1171453 1 1 1 1 1 1 1 1
CA SUPPORT 1175271 1 1 1 1 1 1 1 1
CB INSULATION 1175272 1 1 1 1 1 1 1 1
CC ANGLE BLOCKOFF 1175267 1 1 1 1 1 1 1 1
CH PANEL LOWER 1176276 * * * * 1 1 1 1
CJ PANEL UPPER 1176277 * * * * 1 1 1 1
CK HOOD LF SIDE 0640045A * * * * 1 1 1 1
CL FILTER (AL) (15.31 X 29.44 X 1) 1176284 * * * * 1 1 1 1
CM HOOD RT SIDE 0640040A * * * * 1 1 1 1
CN HOOD DIVIDER 0640014A * * * * 1 1 1 1
PARTS NOT SHOWN
)( PAINT (16-OZ CAN) (STERLING GRAY) 1171357 1 1 1 1 1 1 1 1
)( HARNESS ASY IFM 1178022 1 1 1 1 1 1 1 1
)( PLUG ASY SHORTING 1171405 1 1 1 1 1 1 1 1
)( PLUG ASY COMP 1178032 1 1 1 1 1 1 1 1
)( HARNESS ASY (J2) (YAC CONTROL) 1178161 1 1 1 1 1 1 1 1
)( HARNESS ASY(CLO1/COMP1) TERM BD 1178160 1 1 1 1 1 1 1 1
)( HARNESS ASY (PL6) (ECONOMIZER) 1178162 1 1 1 1 1 1 1 1
)( KIT WIRING 1175246 1 1 1 1 1 1 1 1
)( IGNITION CABLE 1175498 1 1 1 1 1 1 1 1
RGS036KMBB0AAAA
8
509 04 3502 00
RGS 4 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
DESCRIPTION FAST PARTS NO.
RGS048KLAA0AAAA
RGS048KDAA0AAAA
RGS048KLBA0AAAA
RGS048KDBA0AAAA
RGS048KLAB0AAAA
RGS048KDAB0AAAA
RGS048KDBB0AAAA
LOW HEAT
01 COMP ZP42K5E-PFV-130 ZP42K5EPFV130 1 1 1 1 1 1 1 1
02 HEATER CRANKCASE 40W 240V 1178075 1 1 1 1 1 1 1 1
03 COIL ASY COND 4-5 TON AL/CU 1178039 1 1 1 1 1 1 1 1
04 COIL ASY EVAP 4 TON AL/CU 1178041 1 1 1 1 1 1 1 1
05 MTR BLW 208/230/1 1 1620 1176336 1 1 1 1 1 1 1 1
06 MTR CND 1/230 1/4 1100 1178026 1 1 1 1 1 1 1 1
07 FAN C 22" 3B 1/2" 24 INT 1178035 1 1 1 1 1 1 1 1
08 CAP RN RD 370V 5+70 1172163 1 1 1 1 1 1 1 1
10 CONTACTOR 2P 40A 24V 1176763 1 1 1 1 1 1 1 1
11 CAP RN OV 370V 15 1172505 1 1 1 1 1 1 1 1
12 MODULE IGN UT 1068-11 1171166 1 1 1 1 1 1 1 1
13 TRANS 208/230>24 75VA 1178027 1 1 1 1 1 1 1 1
14 WHEEL BLOWER 10" X 5/8 BORE 1175318 1 1 1 1 1 1 1 1
15 WHEEL SI5.75x.938x5/16 CCW 1171049 1 1 1 1 1 1 1 1
16 FAN C 3.25" 12B 5/16" 1171222 1 1 1 1 1 1 1 1
17 TERMINAL BOARD 1178030 1 1 1 1 1 1 1 1
18 SWITCH LMT 195-80 1171325 1 1 1 1 1 1 1 1
19 REGULATOR FLAME 1175855 1 1 1 1 1 1 1 1
20 SWITCH TEMP ACT 1175306 1 1 1 1 1 1 1 1
21 SENSOR FLAME 1171449 1 1 1 1 1 1 1 1
22 IGNITER ASY 1171306 1 1 1 1 1 1 1 1
23 MANIFOLD ASY 1175852 1 1 1 1 1 1 1 1
24 BURNER ASY 1171095 2 2 2 2 2 2 2 2
26 RING INSERT 1171439 2 2 2 2 2 2 2 2
27 VALVE GAS 1 STAGE 1178163 1 1 1 1 1 1 1 1
28 SPUD ORIFICE 1172226 2 * 2 * 2 * 2 *
28 SPUD ORIFICE 1172235 * 2 * 2 * 2 * 2
29 MOTOR ASY (INDUCED DRAFT) 1171314 1 1 1 1 1 1 1 1
30 SENSOR HALL EFFECT (HS) 1171450 1 1 1 1 1 1 1 1
31 MOTOR (IDM) 1171348 1 1 1 1 1 1 1 1
32 BAFFLE FLUE LWNX 1176211 * 1 * 1 * 1 * 1
33 HT EX TUBLR 2-1 SS 1176229 1 * 1 * 1 * 1 *
33 HT EX TUBLR 2-1 SS LWNX 1176231 * 1 * 1 * 1 * 1
34 BAFFLE LWNX 1175987 * 2 * 2 * 2 * 2
38 FILTER DRIER 1178033 1 1 1 1 1 1 1 1
39 GROUND LUG 1172300 1 1 1 1 1 1 1 1
40 CAP RN OV 370V 4 1175500 1 1 1 1 1 1 1 1
42 BEARING 1175424 2 2 2 2 2 2 2 2
43 KEY BLOWER 1175493 1 1 1 1 1 1 1 1
44 PULLEY BLOWER 1178034 1 1 * * 1 1 * *
44 PULLEY BLOWER 1175830 * * 1 1 * * 1 1
45 PULLEY MOTOR 1175849 1 1 1 1 1 1 1 1
46 BELT V 1178127 1 1 * * 1 1 * *
46 BELT V 1178179 * * 1 1 * * 1 1
47 SHAFT FAN 1175422 1 1 1 1 1 1 1 1
48 SWITCH PRESSURE (LPS) 1178029 1 1 1 1 1 1 1 1
50 SWITCH PRESSURE (HPS) 1178028 1 1 1 1 1 1 1 1
51 KEY MOTOR 1175300 1 1 * * 1 1 * *
52 ACTUATOR DAMPER MOTOR 1176280 * * * * 1 1 1 1
53 CONTROLLER 1176282 * * * * 1 1 1 1
RGS048KLBB0AAAA
509 04 3502 00
9
RGS 4 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS048KLAA0AAAA
RGS048KDAA0AAAA
RGS048KLBA0AAAA
RGS048KDBA0AAAA
RGS048KLAB0AAAA
RGS048KDAB0AAAA
RGS048KDBB0AAAA
LOW HEAT
54 SHAFT ACTUATOR 1178103 * * * * 1 1 1 1
55 SENSOR (DISCHARGE)SUPPLY AIR(MIXED) 1176279 * * * * 1 1 1 1
56 SENSOR LOW AMBIENT 1176283 * * * * 1 1 1 1
57 SENSOR OUTDOOR-AIR TEMPERATURE 1176281 * * * * 1 1 1 1
A FILTER AIR 1175312 2 2 2 2 2 2 2 2
B BOOT PROTECTIVE 1171842 1 1 1 1 1 1 1 1
C BRACKET BASERAIL CORNER 1171071 2 2 2 2 2 2 2 2
D BRACKET COIL 1171070 1 1 1 1 1 1 1 1
E CHANNEL INDUCED DRAFT MOTOR 1171112 1 1 1 1 1 1 1 1
F STRAP CAPACITOR 1171552 2 2 2 2 2 2 2 2
G COVER ASY TOP 1178042 1 1 1 1 1 1 1 1
H BRACKET SUPPORT GAS VALVE 1176209 1 1 1 1 1 1 1 1
J COVER ASY RETURN AIR 1175227 1 1 1 1 1 1 1 1
K COVER ASY SUPPLY 1175228 1 1 1 1 1 1 1 1
L GASKET REGULATOR 1175268 1 1 1 1 1 1 1 1
M GRILLE OUTLET 1171267 1 1 1 1 1 1 1 1
N GROMMET 1171270 4 4 4 4 4 4 4 4
P GUARD BASERAIL INDOOR END 1175263 1 1 1 1 1 1 1 1
R GUARD LIMIT SWITCH 1171271 1 1 1 1 1 1 1 1
S WIND CAP ASY 1173617 1 1 1 1 1 1 1 1
T HOUSING FAN 1171301 1 1 1 1 1 1 1 1
V INSULATION 1171317 1 1 1 1 1 1 1 1
W PAN ASY CONDENSATE 1175243 1 1 1 1 1 1 1 1
X PANEL ACCESS CONTROL BOX 1178168 1 1 1 1 1 1 1 1
Y PANEL ACCESS COMPRESSOR 1178046 1 1 1 1 1 1 1 1
Z PANEL ASY FILTER LOWER 1175242 1 1 1 1 * * * *
AA PANEL ASY DOOR FILTER UPPER 1175241 1 1 1 1 * * * *
AB PANEL ASY INDOOR END 1175226 1 1 1 1 1 1 1 1
AC PANEL ASY INDOOR BLOWER ACCESS 1178040 1 1 1 1 1 1 1 1
AD PANEL OUTDOOR END 1178047 1 1 1 1 1 1 1 1
AE PLATE FAN 1175484 1 1 1 1 1 1 1 1
AF PLATE FAN 1175299 1 1 1 1 1 1 1 1
AG STRAP CAPACITOR 1172735 1 1 1 1 1 1 1 1
AH POST CENTER FILTER ACCESS SIDE 1178023 1 1 1 1 1 1 1 1
AJ POST CENTER CONTROL BOX SIDE 1178167 1 1 1 1 1 1 1 1
AK POST CORNER COIL 1175256 1 1 1 1 1 1 1 1
AL POST CORNER CONTROL BOX 1178043 1 1 1 1 1 1 1 1
AM POST CORNER INDOOR END 1175230 2 2 2 2 2 2 2 2
AN CONDUIT 1171428 1 1 1 1 1 1 1 1
AP RAIL BASE FILTER ACCESS 1175266 1 1 1 1 1 1 1 1
AQ RAIL BASE INDOOR FAN ACCESS 1175265 1 1 1 1 1 1 1 1
AR RAIL BASE OUTDOOR END 1175334 1 1 1 1 1 1 1 1
AS RETAINER FLAME 1175854 1 1 1 1 1 1 1 1
AT PANEL COIL 1178104 1 1 1 1 1 1 1 1
AV PLATE MOTOR 1175844 1 1 1 1 1 1 1 1
AW SCROLL FAN 1175260 1 1 1 1 1 1 1 1
AX SUPPORT ASY INDUCER & HEAT EXCH 1175237 1 1 1 1 1 1 1 1
AY SUPPORT BURNER 1175296 1 1 1 1 1 1 1 1
AZ SUPPORT HEAT EXCHANGER BRACKET 1175258 1 1 1 1 1 1 1 1
BA BOLT HEX HEAD 1171056 4 4 4 4 4 4 4 4
RGS048KLBB0AAAA
10
509 04 3502 00
RGS 4 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS048KLAA0AAAA
RGS048KDAA0AAAA
RGS048KLBA0AAAA
RGS048KDBA0AAAA
RGS048KLAB0AAAA
RGS048KDAB0AAAA
RGS048KDBB0AAAA
LOW HEAT
BB SEAL DRAIN LINE ROUND 1171447 1 1 1 1 1 1 1 1
BC BRACKET MTR MTG 1175842 1 1 1 1 1 1 1 1
BD BRACKET ASY 1175423 2 2 2 2 2 2 2 2
BE BLOWER ASY STD STATIC 1175283 1 1 * * 1 1 * *
BF BASE PAN ASY INDOOR 1175231 1 1 1 1 1 1 1 1
BG BASE PAN ASY OUTDOOR 1175232 1 1 1 1 1 1 1 1
BH COVER ASY GAS HEAT 1178165 1 1 1 1 1 1 1 1
BJ DECK FAN 1175259 1 1 1 1 1 1 1 1
BL PANEL ACCESS 1178166 1 1 1 1 1 1 1 1
BM HANDLE SNAP-IN PLASTIC 1178036 3 3 3 3 3 3 3 3
BN SEAL DRAIN LINE SQUARE 1171202 1 1 1 1 1 1 1 1
BP GROMMET WIRE PARTITION 1176613 2 2 2 2 2 2 2 2
BQ PLATE ASY COMP MOUNTING 1175843 1 1 1 1 1 1 1 1
BR PLATE BLOCKOFF 1175294 1 1 1 1 1 1 1 1
BS FRAME ASY 1175238 1 1 1 1 1 1 1 1
BT RETAINER FILTER 1175273 1 1 1 1 1 1 1 1
BV RETAINER FILTER 1175274 1 1 1 1 1 1 1 1
BW RETAINER FILTER 1175275 2 2 2 2 2 2 2 2
BX BRACKET INDOOR 1175262 1 1 1 1 1 1 1 1
BZ SHIELD 1171453 1 1 1 1 1 1 1 1
CA SUPPORT 1175271 1 1 1 1 1 1 1 1
CB INSULATION 1175272 1 1 1 1 1 1 1 1
CC ANGLE BLOCKOFF 1175267 1 1 1 1 1 1 1 1
CH PANEL LOWER 1176276 * * * * 1 1 1 1
CJ PANEL UPPER 1176277 * * * * 1 1 1 1
CK HOOD LF SIDE 0640045A * * * * 1 1 1 1
CL FILTER (AL) (15.31 X 29.44 X 1) 1176284 * * * * 1 1 1 1
CM HOOD RT SIDE 0640040A * * * * 1 1 1 1
CN HOOD DIVIDER 0640014A * * * * 1 1 1 1
PARTS NOT SHOWN
)( PAINT (16-OZ CAN) (STERLING GRAY) 1171357 1 1 1 1 1 1 1 1
)( HARNESS ASY IFM 1178022 1 1 1 1 1 1 1 1
)( PLUG ASY SHORTING 1171405 1 1 1 1 1 1 1 1
)( PLUG ASY COMP 1178032 1 1 1 1 1 1 1 1
)( HARNESS ASY (J2) (YAC CONTROL) 1178161 1 1 1 1 1 1 1 1
)( HARNESS ASY(CLO1/COMP1) TERM BD 1178160 1 1 1 1 1 1 1 1
)( HARNESS ASY (PL6) (ECONOMIZER) 1178162 1 1 1 1 1 1 1 1
)( KIT WIRING 1175246 1 1 1 1 1 1 1 1
)( IGNITION CABLE 1175498 1 1 1 1 1 1 1 1
RGS048KLBB0AAAA
509 04 3502 00
11
RGS 4 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
DESCRIPTION FAST PARTS NO.
RGS048KEAA0AAAA
RGS048KEBA0AAAA
RGS048KMAA0AAAA
RGS048KMBA0AAAA
RGS048KEAB0AAAA
RGS048KEBB0AAAA
RGS048KMAB0AAAA
MED HEAT
01 COMP ZP42K5E-PFV-130 ZP42K5EPFV130 1 1 1 1 1 1 1 1
02 HEATER CRANKCASE 40W 240V 1178075 1 1 1 1 1 1 1 1
03 COIL ASY COND 4-5 TON AL/CU 1178039 1 1 1 1 1 1 1 1
04 COIL ASY EVAP 4 TON AL/CU 1178041 1 1 1 1 1 1 1 1
05 MTR BLW 208/230/1 1 1620 1176336 1 1 1 1 1 1 1 1
06 MTR CND 1/230 1/4 1100 1178026 1 1 1 1 1 1 1 1
07 FAN C 22" 3B 1/2" 24 INT 1178035 1 1 1 1 1 1 1 1
08 CAP RN RD 370V 5+70 1172163 1 1 1 1 1 1 1 1
10 CONTACTOR 2P 40A 24V 1176763 1 1 1 1 1 1 1 1
11 CAP RN OV 370V 15 1172505 1 1 1 1 1 1 1 1
12 MODULE IGN UT 1068-11 1171166 1 1 1 1 1 1 1 1
13 TRANS 208/230>24 75VA 1178027 1 1 1 1 1 1 1 1
14 WHEEL BLOWER 10" X 5/8 BORE 1175318 1 1 1 1 1 1 1 1
15 WHEEL SI5.75x.938x5/16 CCW 1171049 1 1 1 1 1 1 1 1
16 FAN C 3.25" 12B 5/16" 1171222 1 1 1 1 1 1 1 1
17 TERMINAL BOARD 1178030 1 1 1 1 1 1 1 1
18 SWITCH LMT 195-80 1171325 1 1 1 1 1 1 1 1
19 REGULATOR FLAME 1175869 1 1 1 1 1 1 1 1
20 SWITCH TEMP ACT 1175306 1 1 1 1 1 1 1 1
21 SENSOR FLAME 1171449 1 1 1 1 1 1 1 1
22 IGNITER ASY 1171306 1 1 1 1 1 1 1 1
23 MANIFOLD ASY 1175234 1 1 1 1 1 1 1 1
24 BURNER ASY 1171095 2 2 2 2 2 2 2 2
25 BURNER ASY 1171087 1 1 1 1 1 1 1 1
26 RING INSERT 1171439 3 3 3 3 3 3 3 3
27 VALVE GAS 1 STAGE 1178163 1 1 1 1 1 1 1 1
28 SPUD ORIFICE 1172226 3 * 3 * 3 * 3 *
28 SPUD ORIFICE 1172235 * 3 * 3 * 3 * 3
29 MOTOR ASY (INDUCED DRAFT) 1171314 1 1 1 1 1 1 1 1
30 SENSOR HALL EFFECT (HS) 1171450 1 1 1 1 1 1 1 1
31 MOTOR (IDM) 1171348 1 1 1 1 1 1 1 1
32 BAFFLE FLUE LWNX 1176044 * 1 * 1 * 1 * 1
33 HT EX TUBLR 3-2 SS 1176230 1 * 1 * 1 * 1 *
33 HT EX TUBLR 3-2 SS LWNX 1176232 * 1 * 1 * 1 * 1
34 BAFFLE LWNX 1175987 * 3 * 3 * 3 * 3
38 FILTER DRIER 1178033 1 1 1 1 1 1 1 1
39 GROUND LUG 1172300 1 1 1 1 1 1 1 1
40 CAP RN OV 370V 4 1175500 1 1 1 1 1 1 1 1
42 BEARING 1175424 2 2 2 2 2 2 2 2
43 KEY BLOWER 1175493 1 1 1 1 1 1 1 1
44 PULLEY BLOWER 1178034 1 1 * * 1 1 * *
44 PULLEY BLOWER 1175830 * * 1 1 * * 1 1
45 PULLEY MOTOR 1175849 1 1 1 1 1 1 1 1
46 BELT V 1178127 1 1 * * 1 1 * *
46 BELT V 1178179 * * 1 1 * * 1 1
47 SHAFT FAN 1175422 1 1 1 1 1 1 1 1
48 SWITCH PRESSURE (LPS) 1178029 1 1 1 1 1 1 1 1
50 SWITCH PRESSURE (HPS) 1178028 1 1 1 1 1 1 1 1
51 KEY MOTOR 1175300 1 1 * * 1 1 * *
52 ACTUATOR DAMPER MOTOR 1176280 * * * * 1 1 1 1
RGS048KMBB0AAAA
12
509 04 3502 00
RGS 4 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS048KEAA0AAAA
RGS048KEBA0AAAA
RGS048KMAA0AAAA
RGS048KMBA0AAAA
RGS048KEAB0AAAA
RGS048KEBB0AAAA
RGS048KMAB0AAAA
MED HEAT
53 CONTROLLER 1176282 * * * * 1 1 1 1
54 SHAFT ACTUATOR 1178103 * * * * 1 1 1 1
55 SENSOR (DISCHARGE)SUPPLY AIR(MIXED) 1176279 * * * * 1 1 1 1
56 SENSOR LOW AMBIENT 1176283 * * * * 1 1 1 1
57 SENSOR OUTDOOR-AIR TEMPERATURE 1176281 * * * * 1 1 1 1
A FILTER AIR 1175312 2 2 2 2 2 2 2 2
B BOOT PROTECTIVE 1171842 1 1 1 1 1 1 1 1
C BRACKET BASERAIL CORNER 1171071 2 2 2 2 2 2 2 2
D BRACKET COIL 1171070 1 1 1 1 1 1 1 1
E CHANNEL INDUCED DRAFT MOTOR 1171112 1 1 1 1 1 1 1 1
F STRAP CAPACITOR 1171552 2 2 2 2 2 2 2 2
G COVER ASY TOP 1178042 1 1 1 1 1 1 1 1
H BRACKET SUPPORT GAS VALVE 1176209 1 1 1 1 1 1 1 1
J COVER ASY RETURN AIR 1175227 1 1 1 1 1 1 1 1
K COVER ASY SUPPLY 1175228 1 1 1 1 1 1 1 1
L GASKET REGULATOR 1175268 1 1 1 1 1 1 1 1
M GRILLE OUTLET 1171267 1 1 1 1 1 1 1 1
N GROMMET 1171270 4 4 4 4 4 4 4 4
P GUARD BASERAIL INDOOR END 1175263 1 1 1 1 1 1 1 1
R GUARD LIMIT SWITCH 1171271 1 1 1 1 1 1 1 1
S WIND CAP ASY 1173617 1 1 1 1 1 1 1 1
T HOUSING FAN 1171301 1 1 1 1 1 1 1 1
V INSULATION 1171317 1 1 1 1 1 1 1 1
W PAN ASY CONDENSATE 1175243 1 1 1 1 1 1 1 1
X PANEL ACCESS CONTROL BOX 1178168 1 1 1 1 1 1 1 1
Y PANEL ACCESS COMPRESSOR 1178046 1 1 1 1 1 1 1 1
Z PANEL ASY FILTER LOWER 1175242 1 1 1 1 * * * *
AA PANEL ASY DOOR FILTER UPPER 1175241 1 1 1 1 * * * *
AB PANEL ASY INDOOR END 1175226 1 1 1 1 1 1 1 1
AC PANEL ASY INDOOR BLOWER ACCESS 1178040 1 1 1 1 1 1 1 1
AD PANEL OUTDOOR END 1178047 1 1 1 1 1 1 1 1
AE PLATE FAN 1175484 1 1 1 1 1 1 1 1
AF PLATE FAN 1175299 1 1 1 1 1 1 1 1
AG STRAP CAPACITOR 1172735 1 1 1 1 1 1 1 1
AH POST CENTER FILTER ACCESS SIDE 1178023 1 1 1 1 1 1 1 1
AJ POST CENTER CONTROL BOX SIDE 1178167 1 1 1 1 1 1 1 1
AK POST CORNER COIL 1175256 1 1 1 1 1 1 1 1
AL POST CORNER CONTROL BOX 1178043 1 1 1 1 1 1 1 1
AM POST CORNER INDOOR END 1175230 2 2 2 2 2 2 2 2
AN CONDUIT 1171428 1 1 1 1 1 1 1 1
AP RAIL BASE FILTER ACCESS 1175266 1 1 1 1 1 1 1 1
AQ RAIL BASE INDOOR FAN ACCESS 1175265 1 1 1 1 1 1 1 1
AR RAIL BASE OUTDOOR END 1175334 1 1 1 1 1 1 1 1
AS RETAINER FLAME 1175287 1 1 1 1 1 1 1 1
AT PANEL COIL 1178104 1 1 1 1 1 1 1 1
AV PLATE MOTOR 1175844 1 1 1 1 1 1 1 1
AW SCROLL FAN 1175260 1 1 1 1 1 1 1 1
AX SUPPORT ASY INDUCER & HEAT EXCH 1175237 1 1 1 1 1 1 1 1
AY SUPPORT BURNER 1175296 1 1 1 1 1 1 1 1
AZ SUPPORT HEAT EXCHANGER BRACKET 1175258 1 1 1 1 1 1 1 1
RGS048KMBB0AAAA
509 04 3502 00
13
RGS 4 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS048KEAA0AAAA
RGS048KEBA0AAAA
RGS048KMAA0AAAA
RGS048KMBA0AAAA
RGS048KEAB0AAAA
RGS048KEBB0AAAA
RGS048KMAB0AAAA
MED HEAT
BA BOLT HEX HEAD 1171056 4 4 4 4 4 4 4 4
BB SEAL DRAIN LINE ROUND 1171447 1 1 1 1 1 1 1 1
BC BRACKET MTR MTG 1175842 1 1 1 1 1 1 1 1
BD BRACKET ASY 1175423 2 2 2 2 2 2 2 2
BE BLOWER ASY STD STATIC 1175283 1 1 * * 1 1 * *
BF BASE PAN ASY INDOOR 1175231 1 1 1 1 1 1 1 1
BG BASE PAN ASY OUTDOOR 1175232 1 1 1 1 1 1 1 1
BH COVER ASY GAS HEAT 1178165 1 1 1 1 1 1 1 1
BJ DECK FAN 1175259 1 1 1 1 1 1 1 1
BL PANEL ACCESS 1178166 1 1 1 1 1 1 1 1
BM HANDLE SNAP-IN PLASTIC 1178036 3 3 3 3 3 3 3 3
BN SEAL DRAIN LINE SQUARE 1171202 1 1 1 1 1 1 1 1
BP GROMMET WIRE PARTITION 1176613 2 2 2 2 2 2 2 2
BQ PLATE ASY COMP MOUNTING 1175843 1 1 1 1 1 1 1 1
BR PLATE BLOCKOFF 1175294 1 1 1 1 1 1 1 1
BS FRAME ASY 1175238 1 1 1 1 1 1 1 1
BT RETAINER FILTER 1175273 1 1 1 1 1 1 1 1
BV RETAINER FILTER 1175274 1 1 1 1 1 1 1 1
BW RETAINER FILTER 1175275 2 2 2 2 2 2 2 2
BX BRACKET INDOOR 1175262 1 1 1 1 1 1 1 1
BZ SHIELD 1171453 1 1 1 1 1 1 1 1
CA SUPPORT 1175271 1 1 1 1 1 1 1 1
CB INSULATION 1175272 1 1 1 1 1 1 1 1
CC ANGLE BLOCKOFF 1175267 1 1 1 1 1 1 1 1
CH PANEL LOWER 1176276 * * * * 1 1 1 1
CJ PANEL UPPER 1176277 * * * * 1 1 1 1
CK HOOD LF SIDE 0640045A * * * * 1 1 1 1
CL FILTER (AL) (15.31 X 29.44 X 1) 1176284 * * * * 1 1 1 1
CM HOOD RT SIDE 0640040A * * * * 1 1 1 1
CN HOOD DIVIDER 0640014A * * * * 1 1 1 1
PARTS NOT SHOWN
)( PAINT (16-OZ CAN) (STERLING GRAY) 1171357 1 1 1 1 1 1 1 1
)( HARNESS ASY IFM 1178022 1 1 1 1 1 1 1 1
)( PLUG ASY SHORTING 1171405 1 1 1 1 1 1 1 1
)( PLUG ASY COMP 1178032 1 1 1 1 1 1 1 1
)( HARNESS ASY (J2) (YAC CONTROL) 1178161 1 1 1 1 1 1 1 1
)( HARNESS ASY(CLO1/COMP1) TERM BD 1178160 1 1 1 1 1 1 1 1
)( HARNESS ASY (PL6) (ECONOMIZER) 1178162 1 1 1 1 1 1 1 1
)( KIT WIRING 1175246 1 1 1 1 1 1 1 1
)( IGNITION CABLE 1175498 1 1 1 1 1 1 1 1
RGS048KMBB0AAAA
14
509 04 3502 00
RGS 4 Ton 208/230v 1Phase PARTS LIST
KEY
NO.
DESCRIPTION FAST PARTS NO.
RGS048KFAA0AAAA
RGS048KFBA0AAAA
RGS048KNAA0AAAA
RGS048KFAB0AAAA
RGS048KNBA0AAAA
RGS048KFBB0AAAA
RGS048KNAB0AAAA
HIGH HEAT
01 COMP ZP42K5E-PFV-130 ZP42K5EPFV130 1 1 1 1 1 1 1 1
02 HEATER CRANKCASE 40W 240V 1178075 1 1 1 1 1 1 1 1
03 COIL ASY COND 4-5 TON AL/CU 1178039 1 1 1 1 1 1 1 1
04 COIL ASY EVAP 4 TON AL/CU 1178041 1 1 1 1 1 1 1 1
05 MTR BLW 208/230/1 1 1620 1176336 1 1 1 1 1 1 1 1
06 MTR CND 1/230 1/4 1100 1178026 1 1 1 1 1 1 1 1
07 FAN C 22" 3B 1/2" 24 INT 1178035 1 1 1 1 1 1 1 1
08 CAP RN RD 370V 5+70 1172163 1 1 1 1 1 1 1 1
10 CONTACTOR 2P 40A 24V 1176763 1 1 1 1 1 1 1 1
11 CAP RN OV 370V 15 1172505 1 1 1 1 1 1 1 1
12 MODULE IGN UT 1068-11 1171166 1 1 1 1 1 1 1 1
13 TRANS 208/230>24 75VA 1178027 1 1 1 1 1 1 1 1
14 WHEEL BLOWER 10" X 5/8 BORE 1175318 1 1 1 1 1 1 1 1
15 WHEEL SI5.75x.938x5/16 CCW 1171049 1 1 1 1 1 1 1 1
16 FAN C 3.25" 12B 5/16" 1171222 1 1 1 1 1 1 1 1
17 TERMINAL BOARD 1178030 1 1 1 1 1 1 1 1
18 SWITCH LMT 195-80 1171325 1 1 1 1 1 1 1 1
19 REGULATOR FLAME 1175288 1 1 1 1 1 1 1 1
20 SWITCH TEMP ACT 1175306 1 1 1 1 1 1 1 1
21 SENSOR FLAME 1171449 1 1 1 1 1 1 1 1
22 IGNITER ASY 1171306 1 1 1 1 1 1 1 1
23 MANIFOLD ASY 1175234 1 1 1 1 1 1 1 1
24 BURNER ASY 1171095 2 2 2 2 2 2 2 2
25 BURNER ASY 1171087 1 1 1 1 1 1 1 1
26 RING INSERT 1171439 3 3 3 3 3 3 3 3
27 VALVE GAS 1 STAGE 1178163 1 1 1 1 1 1 1 1
28 SPUD ORIFICE 1171461 3 * 3 * 3 * 3 *
28 SPUD ORIFICE 1171782 * 3 * 3 * 3 * 3
29 MOTOR ASY (INDUCED DRAFT) 1171314 1 1 1 1 1 1 1 1
30 SENSOR HALL EFFECT (HS) 1171450 1 1 1 1 1 1 1 1
31 MOTOR (IDM) 1171348 1 1 1 1 1 1 1 1
32 BAFFLE FLUE LWNX 1176044 * 1 * 1 * 1 * 1
33 HT EX TUBLR 3-3 SS 1175734 1 * 1 * 1 * 1 *
33 HT EX TUBLR 3-3 SS LWNX 1176258 * 1 * 1 * 1 * 1
34 BAFFLE LWNX 1175987 * 3 * 3 * 3 * 3
35 BAFFLE HEAT 1175290 1 1 1 1 1 1 1 1
38 FILTER DRIER 1178033 1 1 1 1 1 1 1 1
39 GROUND LUG 1172300 1 1 1 1 1 1 1 1
40 CAP RN OV 370V 4 1175500 1 1 1 1 1 1 1 1
42 BEARING 1175424 2 2 2 2 2 2 2 2
43 KEY BLOWER 1175493 1 1 1 1 1 1 1 1
44 PULLEY BLOWER 1178034 1 1 * * 1 1 * *
44 PULLEY BLOWER 1175830 * * 1 1 * * 1 1
45 PULLEY MOTOR 1175849 1 1 1 1 1 1 1 1
46 BELT V 1178127 1 1 * * 1 1 * *
46 BELT V 1178179 * * 1 1 * * 1 1
47 SHAFT FAN 1175422 1 1 1 1 1 1 1 1
48 SWITCH PRESSURE (LPS) 1178029 1 1 1 1 1 1 1 1
50 SWITCH PRESSURE (HPS) 1178028 1 1 1 1 1 1 1 1
51 KEY MOTOR 1175300 1 1 * * 1 1 * *
RGS048KNBB0AAAA
509 04 3502 00
15
RGS 4 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS048KFAA0AAAA
RGS048KFBA0AAAA
RGS048KNAA0AAAA
RGS048KFAB0AAAA
RGS048KNBA0AAAA
RGS048KFBB0AAAA
RGS048KNAB0AAAA
HIGH HEAT
52 ACTUATOR DAMPER MOTOR 1176280 * * * * 1 1 1 1
53 CONTROLLER 1176282 * * * * 1 1 1 1
54 SHAFT ACTUATOR 1178103 * * * * 1 1 1 1
55 SENSOR (DISCHARGE)SUPPLY AIR(MIXED) 1176279 * * * * 1 1 1 1
56 SENSOR LOW AMBIENT 1176283 * * * * 1 1 1 1
57 SENSOR OUTDOOR-AIR TEMPERATURE 1176281 * * * * 1 1 1 1
A FILTER AIR 1175312 2 2 2 2 2 2 2 2
B BOOT PROTECTIVE 1171842 1 1 1 1 1 1 1 1
C BRACKET BASERAIL CORNER 1171071 2 2 2 2 2 2 2 2
D BRACKET COIL 1171070 1 1 1 1 1 1 1 1
E CHANNEL INDUCED DRAFT MOTOR 1171112 1 1 1 1 1 1 1 1
F STRAP CAPACITOR 1171552 2 2 2 2 2 2 2 2
G COVER ASY TOP 1178042 1 1 1 1 1 1 1 1
H BRACKET SUPPORT GAS VALVE 1176209 1 1 1 1 1 1 1 1
J COVER ASY RETURN AIR 1175227 1 1 1 1 1 1 1 1
K COVER ASY SUPPLY 1175228 1 1 1 1 1 1 1 1
L GASKET REGULATOR 1175268 1 1 1 1 1 1 1 1
M GRILLE OUTLET 1171267 1 1 1 1 1 1 1 1
N GROMMET 1171270 4 4 4 4 4 4 4 4
P GUARD BASERAIL INDOOR END 1175263 1 1 1 1 1 1 1 1
R GUARD LIMIT SWITCH 1171271 1 1 1 1 1 1 1 1
S WIND CAP ASY 1173617 1 1 1 1 1 1 1 1
T HOUSING FAN 1171301 1 1 1 1 1 1 1 1
V INSULATION 1171317 1 1 1 1 1 1 1 1
W PAN ASY CONDENSATE 1175243 1 1 1 1 1 1 1 1
X PANEL ACCESS CONTROL BOX 1178168 1 1 1 1 1 1 1 1
Y PANEL ACCESS COMPRESSOR 1178046 1 1 1 1 1 1 1 1
Z PANEL ASY FILTER LOWER 1175242 1 1 1 1 * * * *
AA PANEL ASY DOOR FILTER UPPER 1175241 1 1 1 1 * * * *
AB PANEL ASY INDOOR END 1175226 1 1 1 1 1 1 1 1
AC PANEL ASY INDOOR BLOWER ACCESS 1178040 1 1 1 1 1 1 1 1
AD PANEL OUTDOOR END 1178047 1 1 1 1 1 1 1 1
AE PLATE FAN 1175484 1 1 1 1 1 1 1 1
AF PLATE FAN 1175299 1 1 1 1 1 1 1 1
AG STRAP CAPACITOR 1172735 1 1 1 1 1 1 1 1
AH POST CENTER FILTER ACCESS SIDE 1178023 1 1 1 1 1 1 1 1
AJ POST CENTER CONTROL BOX SIDE 1178167 1 1 1 1 1 1 1 1
AK POST CORNER COIL 1175256 1 1 1 1 1 1 1 1
AL POST CORNER CONTROL BOX 1178043 1 1 1 1 1 1 1 1
AM POST CORNER INDOOR END 1175230 2 2 2 2 2 2 2 2
AN CONDUIT 1171428 1 1 1 1 1 1 1 1
AP RAIL BASE FILTER ACCESS 1175266 1 1 1 1 1 1 1 1
AQ RAIL BASE INDOOR FAN ACCESS 1175265 1 1 1 1 1 1 1 1
AR RAIL BASE OUTDOOR END 1175334 1 1 1 1 1 1 1 1
AS RETAINER FLAME 1175287 1 1 1 1 1 1 1 1
AT PANEL COIL 1178104 1 1 1 1 1 1 1 1
AV PLATE MOTOR 1175844 1 1 1 1 1 1 1 1
AW SCROLL FAN 1175260 1 1 1 1 1 1 1 1
AX SUPPORT ASY INDUCER & HEAT EXCH 1175237 1 1 1 1 1 1 1 1
AY SUPPORT BURNER 1175296 1 1 1 1 1 1 1 1
RGS048KNBB0AAAA
16
509 04 3502 00
RGS 4 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS048KFAA0AAAA
RGS048KFBA0AAAA
RGS048KNAA0AAAA
RGS048KFAB0AAAA
RGS048KNBA0AAAA
RGS048KFBB0AAAA
RGS048KNAB0AAAA
HIGH HEAT
AZ SUPPORT HEAT EXCHANGER BRACKET 1175258 1 1 1 1 1 1 1 1
BA BOLT HEX HEAD 1171056 4 4 4 4 4 4 4 4
BB SEAL DRAIN LINE ROUND 1171447 1 1 1 1 1 1 1 1
BC BRACKET MTR MTG 1175842 1 1 1 1 1 1 1 1
BD BRACKET ASY 1175423 2 2 2 2 2 2 2 2
BE BLOWER ASY STD STATIC 1175283 1 1 * * 1 1 * *
BF BASE PAN ASY INDOOR 1175231 1 1 1 1 1 1 1 1
BG BASE PAN ASY OUTDOOR 1175232 1 1 1 1 1 1 1 1
BH COVER ASY GAS HEAT 1178165 1 1 1 1 1 1 1 1
BJ DECK FAN 1175259 1 1 1 1 1 1 1 1
BL PANEL ACCESS 1178166 1 1 1 1 1 1 1 1
BM HANDLE SNAP-IN PLASTIC 1178036 3 3 3 3 3 3 3 3
BN SEAL DRAIN LINE SQUARE 1171202 1 1 1 1 1 1 1 1
BP GROMMET WIRE PARTITION 1176613 2 2 2 2 2 2 2 2
BQ PLATE ASY COMP MOUNTING 1175843 1 1 1 1 1 1 1 1
BR PLATE BLOCKOFF 1175294 1 1 1 1 1 1 1 1
BS FRAME ASY 1175238 1 1 1 1 1 1 1 1
BT RETAINER FILTER 1175273 1 1 1 1 1 1 1 1
BV RETAINER FILTER 1175274 1 1 1 1 1 1 1 1
BW RETAINER FILTER 1175275 2 2 2 2 2 2 2 2
BX BRACKET INDOOR 1175262 1 1 1 1 1 1 1 1
BZ SHIELD 1171453 1 1 1 1 1 1 1 1
CA SUPPORT 1175271 1 1 1 1 1 1 1 1
CB INSULATION 1175272 1 1 1 1 1 1 1 1
CC ANGLE BLOCKOFF 1175267 1 1 1 1 1 1 1 1
CH PANEL LOWER 1176276 * * * * 1 1 1 1
CJ PANEL UPPER 1176277 * * * * 1 1 1 1
CK HOOD LF SIDE 0640045A * * * * 1 1 1 1
CL FILTER (AL) (15.31 X 29.44 X 1) 1176284 * * * * 1 1 1 1
CM HOOD RT SIDE 0640040A * * * * 1 1 1 1
CN HOOD DIVIDER 0640014A * * * * 1 1 1 1
PARTS NOT SHOWN
)( PAINT (16-OZ CAN) (STERLING GRAY) 1171357 1 1 1 1 1 1 1 1
)( HARNESS ASY IFM 1178022 1 1 1 1 1 1 1 1
)( PLUG ASY SHORTING 1171405 1 1 1 1 1 1 1 1
)( PLUG ASY COMP 1178032 1 1 1 1 1 1 1 1
)( HARNESS ASY (J2) (YAC CONTROL) 1178161 1 1 1 1 1 1 1 1
)( HARNESS ASY(CLO1/COMP1) TERM BD 1178160 1 1 1 1 1 1 1 1
)( HARNESS ASY (PL6) (ECONOMIZER) 1178162 1 1 1 1 1 1 1 1
)( KIT WIRING 1175246 1 1 1 1 1 1 1 1
)( IGNITION CABLE 1175498 1 1 1 1 1 1 1 1
RGS048KNBB0AAAA
509 04 3502 00
17
RGS 5 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
DESCRIPTION FAST PARTS NO.
RGS060KLAA0AAAA
RGS060KDAA0AAAA
RGS060KLBA0AAAA
RGS060KDBA0AAAA
RGS060KLAB0AAAA
RGS060KDAB0AAAA
RGS060KDBB0AAAA
LOW HEAT
01 COMP ZP54K5E-PFV-830 ZP54K5EPFV130 1 1 1 1 1 1 1 1
02 HEATER CRANKCASE 40W 240V 1178075 1 1 1 1 1 1 1 1
03 COIL ASY COND 4-5 TON AL/CU 1178039 1 1 1 1 1 1 1 1
04 COIL ASY EVAP 5 TON AL/CU 1178025 1 1 1 1 1 1 1 1
05 MTR BLW 208/230/1 1 1620 1176336 1 1 * * 1 1 * *
05 MTR BLW 1.5,1725,208/230/1 1176388 * * 1 1 * * 1 1
06 MTR CND 1/230 1/4 1100 1178026 1 1 1 1 1 1 1 1
07 FAN C 22" 3B 1/2" 24 INT 1178035 1 1 1 1 1 1 1 1
08 CAP RN RD 370V 5+80 1172113 1 1 1 1 1 1 1 1
10 CONTACTOR 2P 40A 24V 1176763 1 1 1 1 1 1 1 1
11 CAP RN OV 370V 15 1172505 1 1 * * 1 1 * *
12 MODULE IGN UT 1068-11 1171166 1 1 1 1 1 1 1 1
13 TRANS 208/230>24 75VA 1178027 1 1 1 1 1 1 1 1
14 WHEEL BLOWER 10" X 5/8 BORE 1175318 1 1 * * 1 1 * *
14 WHEEL BLOWER 11" X 5/8 BORE 1178085 * * 1 1 * * 1 1
15 WHEEL SI5.75x.938x5/16 CCW 1171049 1 1 1 1 1 1 1 1
16 FAN C 3.25" 12B 5/16" 1171222 1 1 1 1 1 1 1 1
17 TERMINAL BOARD 1178030 1 1 1 1 1 1 1 1
18 SWITCH LMT 195-80 1171325 1 1 1 1 1 1 1 1
19 REGULATOR FLAME 1175855 1 1 1 1 1 1 1 1
20 SWITCH TEMP ACT 1175306 1 1 1 1 1 1 1 1
21 SENSOR FLAME 1171449 1 1 1 1 1 1 1 1
22 IGNITER ASY 1171306 1 1 1 1 1 1 1 1
23 MANIFOLD ASY 1175852 1 1 1 1 1 1 1 1
24 BURNER ASY 1171095 2 2 2 2 2 2 2 2
26 RING INSERT 1171439 2 2 2 2 2 2 2 2
27 VALVE GAS 1 STAGE 1178163 1 1 1 1 1 1 1 1
28 SPUD ORIFICE 1172226 2 * 2 * 2 * 2 *
28 SPUD ORIFICE 1172235 * 2 * 2 * 2 * 2
29 MOTOR ASY (INDUCED DRAFT) 1171314 1 1 1 1 1 1 1 1
30 SENSOR HALL EFFECT (HS) 1171450 1 1 1 1 1 1 1 1
31 MOTOR (IDM) 1171348 1 1 1 1 1 1 1 1
33 HT EX TUBLR 2-1 SS 1176229 1 * 1 * 1 * 1 *
33 HT EX TUBLR 2-1 SS LWNX 1176231 * 1 * 1 * 1 * 1
34 BAFFLE LWNX 1175987 * 2 * 2 * 2 * 2
38 FILTER DRIER 1178033 1 1 1 1 1 1 1 1
39 GROUND LUG 1172300 1 1 1 1 1 1 1 1
40 CAP RN OV 370V 4 1175500 1 1 1 1 1 1 1 1
42 BEARING 1175424 2 2 2 2 2 2 2 2
43 KEY BLOWER 1175493 1 1 1 1 1 1 1 1
44 PULLEY BLOWER 1175830 1 1 1 1 1 1 1 1
45 PULLEY MOTOR 1175849 1 1 * * 1 1 * *
45 PULLEY MOTOR 1175832 * * 1 1 * * 1 1
46 BELT V 1178179 1 1 * * 1 1 * *
46 BELT V 1178200 * * 1 1 * * 1 1
47 SHAFT FAN 1175422 1 1 1 1 1 1 1 1
48 SWITCH PRESSURE (LPS) 1178029 1 1 1 1 1 1 1 1
50 SWITCH PRESSURE (HPS) 1178028 1 1 1 1 1 1 1 1
51 KEY MOTOR 1175300 1 1 * * 1 1 * *
52 ACTUATOR DAMPER MOTOR 1176280 * * * * 1 1 1 1
RGS060KLBB0AAAA
18
509 04 3502 00
RGS 5 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS060KLAA0AAAA
RGS060KDAA0AAAA
RGS060KLBA0AAAA
RGS060KDBA0AAAA
RGS060KLAB0AAAA
RGS060KDAB0AAAA
RGS060KDBB0AAAA
LOW HEAT
53 CONTROLLER 1176282 * * * * 1 1 1 1
54 SHAFT ACTUATOR 1178103 * * * * 1 1 1 1
55 SENSOR (DISCHARGE)SUPPLY AIR(MIXED) 1176279 * * * * 1 1 1 1
56 SENSOR LOW AMBIENT 1176283 * * * * 1 1 1 1
57 SENSOR OUTDOOR-AIR TEMPERATURE 1176281 * * * * 1 1 1 1
A FILTER AIR 1175312 2 2 2 2 2 2 2 2
B BOOT PROTECTIVE 1171842 1 1 1 1 1 1 1 1
C BRACKET BASERAIL CORNER 1171071 2 2 2 2 2 2 2 2
D BRACKET COIL 1171070 1 1 1 1 1 1 1 1
E CHANNEL INDUCED DRAFT MOTOR 1171112 1 1 1 1 1 1 1 1
F STRAP CAPACITOR 1171552 2 2 2 2 2 2 2 2
G COVER ASY TOP 1178042 1 1 1 1 1 1 1 1
H BRACKET SUPPORT GAS VALVE 1176209 1 1 1 1 1 1 1 1
J COVER ASY RETURN AIR 1175227 1 1 1 1 1 1 1 1
K COVER ASY SUPPLY 1175228 1 1 1 1 1 1 1 1
L GASKET REGULATOR 1175268 1 1 1 1 1 1 1 1
M GRILLE OUTLET 1171267 1 1 1 1 1 1 1 1
N GROMMET 1171270 4 4 4 4 4 4 4 4
P GUARD BASERAIL INDOOR END 1175263 1 1 1 1 1 1 1 1
R GUARD LIMIT SWITCH 1171271 1 1 1 1 1 1 1 1
S WIND CAP ASY 1173617 1 1 1 1 1 1 1 1
T HOUSING FAN 1171301 1 1 1 1 1 1 1 1
V INSULATION 1171317 1 1 1 1 1 1 1 1
W PAN ASY CONDENSATE 1175243 1 1 1 1 1 1 1 1
X PANEL ACCESS CONTROL BOX 1178168 1 1 1 1 1 1 1 1
Y PANEL ACCESS COMPRESSOR 1178046 1 1 1 1 1 1 1 1
Z PANEL ASY FILTER LOWER 1175242 1 1 1 1 * * * *
AA PANEL ASY DOOR FILTER UPPER 1175241 1 1 1 1 * * * *
AB PANEL ASY INDOOR END 1175226 1 1 1 1 1 1 1 1
AC PANEL ASY INDOOR BLOWER ACCESS 1178040 1 1 1 1 1 1 1 1
AD PANEL OUTDOOR END 1178047 1 1 1 1 1 1 1 1
AE PLATE FAN 1175484 1 1 1 1 1 1 1 1
AF PLATE FAN 1175299 1 1 1 1 1 1 1 1
AG STRAP CAPACITOR 1172735 1 1 1 1 1 1 1 1
AH POST CENTER FILTER ACCESS SIDE 1178023 1 1 1 1 1 1 1 1
AJ POST CENTER CONTROL BOX SIDE 1178167 1 1 1 1 1 1 1 1
AK POST CORNER COIL 1175256 1 1 1 1 1 1 1 1
AL POST CORNER CONTROL BOX 1178043 1 1 1 1 1 1 1 1
AM POST CORNER INDOOR END 1175230 2 2 2 2 2 2 2 2
AN CONDUIT 1171428 1 1 1 1 1 1 1 1
AP RAIL BASE FILTER ACCESS 1175266 1 1 1 1 1 1 1 1
AQ RAIL BASE INDOOR FAN ACCESS 1175265 1 1 1 1 1 1 1 1
AR RAIL BASE OUTDOOR END 1175334 1 1 1 1 1 1 1 1
AS RETAINER FLAME 1175854 1 1 1 1 1 1 1 1
AT PANEL COIL 1178104 1 1 1 1 1 1 1 1
AV PLATE MOTOR 1175844 1 1 * * 1 1 * *
AV PLATE ASY MOTOR 1175664 * * 1 1 * * 1 1
AW SCROLL FAN 1175260 1 1 1 1 1 1 1 1
AX SUPPORT ASY INDUCER & HEAT EXCH 1175237 1 1 1 1 1 1 1 1
AY SUPPORT BURNER 1175296 1 1 1 1 1 1 1 1
RGS060KLBB0AAAA
509 04 3502 00
19
RGS 5 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS060KLAA0AAAA
RGS060KDAA0AAAA
RGS060KLBA0AAAA
RGS060KDBA0AAAA
RGS060KLAB0AAAA
RGS060KDAB0AAAA
RGS060KDBB0AAAA
LOW HEAT
AZ SUPPORT HEAT EXCHANGER BRACKET 1175258 1 1 1 1 1 1 1 1
BA BOLT HEX HEAD 1171056 4 4 4 4 4 4 4 4
BB SEAL DRAIN LINE ROUND 1171447 1 1 1 1 1 1 1 1
BC BRACKET MTR MTG 1175842 1 1 * * 1 1 * *
BC SUPPORT BRACKET MTR MTG 1175483 * * 1 1 * * 1 1
BD BRACKET ASY 1175423 2 2 2 2 2 2 2 2
BE BLOWER ASY STD STATIC 1175283 1 1 * * 1 1 * *
BF BASE PAN ASY INDOOR 1175231 1 1 1 1 1 1 1 1
BG BASE PAN ASY OUTDOOR 1175232 1 1 1 1 1 1 1 1
BH COVER ASY GAS HEAT 1178165 1 1 1 1 1 1 1 1
BJ DECK FAN 1175259 1 1 1 1 1 1 1 1
BL PANEL ACCESS 1178166 1 1 1 1 1 1 1 1
BM HANDLE SNAP-IN PLASTIC 1178036 3 3 3 3 3 3 3 3
BN SEAL DRAIN LINE SQUARE 1171202 1 1 1 1 1 1 1 1
BP GROMMET WIRE PARTITION 1176613 2 2 2 2 2 2 2 2
BQ PLATE ASY COMP MOUNTING 1175843 1 1 1 1 1 1 1 1
BR PLATE BLOCKOFF 1175294 1 1 1 1 1 1 1 1
BS FRAME ASY 1175238 1 1 1 1 1 1 1 1
BT RETAINER FILTER 1175273 1 1 1 1 1 1 1 1
BV RETAINER FILTER 1175274 1 1 1 1 1 1 1 1
BW RETAINER FILTER 1175275 2 2 2 2 2 2 2 2
BX BRACKET INDOOR 1175262 1 1 1 1 1 1 1 1
BZ SHIELD 1171453 1 1 1 1 1 1 1 1
CA SUPPORT 1175271 1 1 1 1 1 1 1 1
CB INSULATION 1175272 1 1 1 1 1 1 1 1
CC ANGLE BLOCKOFF 1175267 1 1 1 1 1 1 1 1
CH PANEL LOWER 1176276 * * * * 1 1 1 1
CJ PANEL UPPER 1176277 * * * * 1 1 1 1
CK HOOD LF SIDE 0640045A * * * * 1 1 1 1
CL FILTER (AL) (15.31 X 29.44 X 1) 1176284 * * * * 1 1 1 1
CM HOOD RT SIDE 0640040A * * * * 1 1 1 1
CN HOOD DIVIDER 0640014A * * * * 1 1 1 1
PARTS NOT SHOWN
)( PAINT (16-OZ CAN) (STERLING GRAY) 1171357 1 1 1 1 1 1 1 1
)( HARNESS ASY IFM 1178022 1 1 * * 1 1 * *
)( HARNESS ASY IFM 1178125 * * 1 1 * * 1 1
)( PLUG ASY SHORTING 1171405 1 1 1 1 1 1 1 1
)( PLUG ASY COMP 1178032 1 1 1 1 1 1 1 1
)( HARNESS ASY (J2) (YAC CONTROL) 1178161 1 1 1 1 1 1 1 1
)( HARNESS ASY(CLO1/COMP1) TERM BD 1178160 1 1 1 1 1 1 1 1
)( HARNESS ASY (PL6) (ECONOMIZER) 1178162 1 1 1 1 1 1 1 1
)( KIT WIRING 1175246 1 1 1 1 1 1 1 1
)( IGNITION CABLE 1175498 1 1 1 1 1 1 1 1
RGS060KLBB0AAAA
20
509 04 3502 00
RGS 5 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
DESCRIPTION FAST PARTS NO.
RGS060KEAA0AAAA
RGS060KEBA0AAAA
RGS060KMAA0AAAA
RGS060KMBA0AAAA
RGS060KEAB0AAAA
RGS060KEBB0AAAA
RGS060KMAB0AAAA
MED HEAT
01 COMP ZP54K5E-PFV-830 ZP54K5EPFV130 1 1 1 1 1 1 1 1
02 HEATER CRANKCASE 40W 240V 1178075 1 1 1 1 1 1 1 1
03 COIL ASY COND 4-5 TON AL/CU 1178039 1 1 1 1 1 1 1 1
04 COIL ASY EVAP 5 TON AL/CU 1178025 1 1 1 1 1 1 1 1
05 MTR BLW 208/230/1 1 1620 1176336 1 1 * * 1 1 * *
05 MTR BLW 1.5,1725,208/230/1 1176388 * * 1 1 * * 1 1
06 MTR CND 1/230 1/4 1100 1178026 1 1 1 1 1 1 1 1
07 FAN C 22" 3B 1/2" 24 INT 1178035 1 1 1 1 1 1 1 1
08 CAP RN RD 370V 5+80 1172113 1 1 1 1 1 1 1 1
10 CONTACTOR 2P 40A 24V 1176763 1 1 1 1 1 1 1 1
11 CAP RN OV 370V 15 1172505 1 1 * * 1 1 * *
12 MODULE IGN UT 1068-11 1171166 1 1 1 1 1 1 1 1
13 TRANS 208/230>24 75VA 1178027 1 1 1 1 1 1 1 1
14 WHEEL BLOWER 10" X 5/8 BORE 1175318 1 1 * * 1 1 * *
14 WHEEL BLOWER 11" X 5/8 BORE 1178085 * * 1 1 * * 1 1
15 WHEEL SI5.75x.938x5/16 CCW 1171049 1 1 1 1 1 1 1 1
16 FAN C 3.25" 12B 5/16" 1171222 1 1 1 1 1 1 1 1
17 TERMINAL BOARD 1178030 1 1 1 1 1 1 1 1
18 SWITCH LMT 195-80 1171325 1 1 1 1 1 1 1 1
19 REGULATOR FLAME 1175869 1 1 1 1 1 1 1 1
20 SWITCH TEMP ACT 1175306 1 1 1 1 1 1 1 1
21 SENSOR FLAME 1171449 1 1 1 1 1 1 1 1
22 IGNITER ASY 1171306 1 1 1 1 1 1 1 1
23 MANIFOLD ASY 1175234 1 1 1 1 1 1 1 1
24 BURNER ASY 1171095 2 2 2 2 2 2 2 2
25 BURNER ASY 1171087 1 1 1 1 1 1 1 1
26 RING INSERT 1171439 3 3 3 3 3 3 3 3
27 VALVE GAS 1 STAGE 1178163 1 1 1 1 1 1 1 1
28 SPUD ORIFICE 1172226 3 * 3 * 3 * 3 *
28 SPUD ORIFICE 1172235 * 3 * 3 * 3 * 3
29 MOTOR ASY (INDUCED DRAFT) 1171314 1 1 1 1 1 1 1 1
30 SENSOR HALL EFFECT (HS) 1171450 1 1 1 1 1 1 1 1
31 MOTOR (IDM) 1171348 1 1 1 1 1 1 1 1
32 BAFFLE FLUE LWNX 1176044 * 1 * 1 * 1 * 1
33 HT EX TUBLR 3-2 SS 1176230 1 * 1 * 1 * 1 *
33 HT EX TUBLR 3-2 SS LWNX 1176232 * 1 * 1 * 1 * 1
34 BAFFLE LWNX 1175987 * 3 * 3 * 3 * 3
38 FILTER DRIER 1178033 1 1 1 1 1 1 1 1
39 GROUND LUG 1172300 1 1 1 1 1 1 1 1
40 CAP RN OV 370V 4 1175500 1 1 1 1 1 1 1 1
42 BEARING 1175424 2 2 2 2 2 2 2 2
43 KEY BLOWER 1175493 1 1 1 1 1 1 1 1
44 PULLEY BLOWER 1175830 1 1 1 1 1 1 1 1
45 PULLEY MOTOR 1175849 1 1 * * 1 1 * *
45 PULLEY MOTOR 1175832 * * 1 1 * * 1 1
46 BELT V 1178179 1 1 * * 1 1 * *
46 BELT V 1178200 * * 1 1 * * 1 1
47 SHAFT FAN 1175422 1 1 1 1 1 1 1 1
48 SWITCH PRESSURE (LPS) 1178029 1 1 1 1 1 1 1 1
50 SWITCH PRESSURE (HPS) 1178028 1 1 1 1 1 1 1 1
RGS060KMBB0AAAA
509 04 3502 00
21
RGS 5 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS060KEAA0AAAA
RGS060KEBA0AAAA
RGS060KMAA0AAAA
RGS060KMBA0AAAA
RGS060KEAB0AAAA
RGS060KEBB0AAAA
RGS060KMAB0AAAA
MED HEAT
51 KEY MOTOR 1175300 1 1 * * 1 1 * *
52 ACTUATOR DAMPER MOTOR 1176280 * * * * 1 1 1 1
53 CONTROLLER 1176282 * * * * 1 1 1 1
54 SHAFT ACTUATOR 1178103 * * * * 1 1 1 1
55 SENSOR (DISCHARGE)SUPPLY AIR(MIXED) 1176279 * * * * 1 1 1 1
56 SENSOR LOW AMBIENT 1176283 * * * * 1 1 1 1
57 SENSOR OUTDOOR-AIR TEMPERATURE 1176281 * * * * 1 1 1 1
A FILTER AIR 1175312 2 2 2 2 2 2 2 2
B BOOT PROTECTIVE 1171842 1 1 1 1 1 1 1 1
C BRACKET BASERAIL CORNER 1171071 2 2 2 2 2 2 2 2
D BRACKET COIL 1171070 1 1 1 1 1 1 1 1
E CHANNEL INDUCED DRAFT MOTOR 1171112 1 1 1 1 1 1 1 1
F STRAP CAPACITOR 1171552 2 2 2 2 2 2 2 2
G COVER ASY TOP 1178042 1 1 1 1 1 1 1 1
H BRACKET SUPPORT GAS VALVE 1176209 1 1 1 1 1 1 1 1
J COVER ASY RETURN AIR 1175227 1 1 1 1 1 1 1 1
K COVER ASY SUPPLY 1175228 1 1 1 1 1 1 1 1
L GASKET REGULATOR 1175268 1 1 1 1 1 1 1 1
M GRILLE OUTLET 1171267 1 1 1 1 1 1 1 1
N GROMMET 1171270 4 4 4 4 4 4 4 4
P GUARD BASERAIL INDOOR END 1175263 1 1 1 1 1 1 1 1
R GUARD LIMIT SWITCH 1171271 1 1 1 1 1 1 1 1
S WIND CAP ASY 1173617 1 1 1 1 1 1 1 1
T HOUSING FAN 1171301 1 1 1 1 1 1 1 1
V INSULATION 1171317 1 1 1 1 1 1 1 1
W PAN ASY CONDENSATE 1175243 1 1 1 1 1 1 1 1
X PANEL ACCESS CONTROL BOX 1178168 1 1 1 1 1 1 1 1
Y PANEL ACCESS COMPRESSOR 1178046 1 1 1 1 1 1 1 1
Z PANEL ASY FILTER LOWER 1175242 1 1 1 1 * * * *
AA PANEL ASY DOOR FILTER UPPER 1175241 1 1 1 1 * * * *
AB PANEL ASY INDOOR END 1175226 1 1 1 1 1 1 1 1
AC PANEL ASY INDOOR BLOWER ACCESS 1178040 1 1 1 1 1 1 1 1
AD PANEL OUTDOOR END 1178047 1 1 1 1 1 1 1 1
AE PLATE FAN 1175484 1 1 1 1 1 1 1 1
AF PLATE FAN 1175299 1 1 1 1 1 1 1 1
AG STRAP CAPACITOR 1172735 1 1 1 1 1 1 1 1
AH POST CENTER FILTER ACCESS SIDE 1178023 1 1 1 1 1 1 1 1
AJ POST CENTER CONTROL BOX SIDE 1178167 1 1 1 1 1 1 1 1
AK POST CORNER COIL 1175256 1 1 1 1 1 1 1 1
AL POST CORNER CONTROL BOX 1178043 1 1 1 1 1 1 1 1
AM POST CORNER INDOOR END 1175230 2 2 2 2 2 2 2 2
AN CONDUIT 1171428 1 1 1 1 1 1 1 1
AP RAIL BASE FILTER ACCESS 1175266 1 1 1 1 1 1 1 1
AQ RAIL BASE INDOOR FAN ACCESS 1175265 1 1 1 1 1 1 1 1
AR RAIL BASE OUTDOOR END 1175334 1 1 1 1 1 1 1 1
AS RETAINER FLAME 1175287 1 1 1 1 1 1 1 1
AT PANEL COIL 1178104 1 1 1 1 1 1 1 1
AV PLATE MOTOR 1175844 1 1 * * 1 1 * *
AV PLATE ASY MOTOR 1175664 * * 1 1 * * 1 1
AW SCROLL FAN 1175260 1 1 1 1 1 1 1 1
RGS060KMBB0AAAA
22
509 04 3502 00
RGS 5 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS060KEAA0AAAA
RGS060KEBA0AAAA
RGS060KMAA0AAAA
RGS060KMBA0AAAA
RGS060KEAB0AAAA
RGS060KEBB0AAAA
RGS060KMAB0AAAA
MED HEAT
AX SUPPORT ASY INDUCER & HEAT EXCH 1175237 1 1 1 1 1 1 1 1
AY SUPPORT BURNER 1175296 1 1 1 1 1 1 1 1
AZ SUPPORT HEAT EXCHANGER BRACKET 1175258 1 1 1 1 1 1 1 1
BA BOLT HEX HEAD 1171056 4 4 4 4 4 4 4 4
BB SEAL DRAIN LINE ROUND 1171447 1 1 1 1 1 1 1 1
BC BRACKET MTR MTG 1175842 1 1 * * 1 1 * *
BC SUPPORT BRACKET MTR MTG 1175483 * * 1 1 * * 1 1
BD BRACKET ASY 1175423 2 2 2 2 2 2 2 2
BE BLOWER ASY STD STATIC 1175283 1 1 * * 1 1 * *
BF BASE PAN ASY INDOOR 1175231 1 1 1 1 1 1 1 1
BG BASE PAN ASY OUTDOOR 1175232 1 1 1 1 1 1 1 1
BH COVER ASY GAS HEAT 1178165 1 1 1 1 1 1 1 1
BJ DECK FAN 1175259 1 1 1 1 1 1 1 1
BL PANEL ACCESS 1178166 1 1 1 1 1 1 1 1
BM HANDLE SNAP-IN PLASTIC 1178036 3 3 3 3 3 3 3 3
BN SEAL DRAIN LINE SQUARE 1171202 1 1 1 1 1 1 1 1
BP GROMMET WIRE PARTITION 1176613 2 2 2 2 2 2 2 2
BQ PLATE ASY COMP MOUNTING 1175843 1 1 1 1 1 1 1 1
BR PLATE BLOCKOFF 1175294 1 1 1 1 1 1 1 1
BS FRAME ASY 1175238 1 1 1 1 1 1 1 1
BT RETAINER FILTER 1175273 1 1 1 1 1 1 1 1
BV RETAINER FILTER 1175274 1 1 1 1 1 1 1 1
BW RETAINER FILTER 1175275 2 2 2 2 2 2 2 2
BX BRACKET INDOOR 1175262 1 1 1 1 1 1 1 1
BZ SHIELD 1171453 1 1 1 1 1 1 1 1
CA SUPPORT 1175271 1 1 1 1 1 1 1 1
CB INSULATION 1175272 1 1 1 1 1 1 1 1
CC ANGLE BLOCKOFF 1175267 1 1 1 1 1 1 1 1
CH PANEL LOWER 1176276 * * * * 1 1 1 1
CJ PANEL UPPER 1176277 * * * * 1 1 1 1
CK HOOD LF SIDE 0640045A * * * * 1 1 1 1
CL FILTER (AL) (15.31 X 29.44 X 1) 1176284 * * * * 1 1 1 1
CM HOOD RT SIDE 0640040A * * * * 1 1 1 1
CN HOOD DIVIDER 0640014A * * * * 1 1 1 1
PARTS NOT SHOWN
)( PAINT (16-OZ CAN) (STERLING GRAY) 1171357 1 1 1 1 1 1 1 1
)( HARNESS ASY IFM 1178022 1 1 * * 1 1 * *
)( HARNESS ASY IFM 1178125 * * 1 1 * * 1 1
)( PLUG ASY SHORTING 1171405 1 1 1 1 1 1 1 1
)( PLUG ASY COMP 1178032 1 1 1 1 1 1 1 1
)( HARNESS ASY (J2) (YAC CONTROL) 1178161 1 1 1 1 1 1 1 1
)( HARNESS ASY(CLO1/COMP1) TERM BD 1178160 1 1 1 1 1 1 1 1
)( HARNESS ASY (PL6) (ECONOMIZER) 1178162 1 1 1 1 1 1 1 1
)( KIT WIRING 1175246 1 1 1 1 1 1 1 1
)( IGNITION CABLE 1175498 1 1 1 1 1 1 1 1
RGS060KMBB0AAAA
509 04 3502 00
23
RGS 5 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
DESCRIPTION FAST PARTS NO.
RGS060KFAA0AAAA
RGS060KFBA0AAAA
RGS060KNAA0AAAA
RGS060KFAB0AAAA
RGS060KNBA0AAAA
RGS060KFBB0AAAA
RGS060KNAB0AAAA
HIGH HEAT
01 COMP ZP54K5E-PFV-830 ZP54K5EPFV130 1 1 1 1 1 1 1 1
02 HEATER CRANKCASE 40W 240V 1178075 1 1 1 1 1 1 1 1
03 COIL ASY COND 4-5 TON AL/CU 1178039 1 1 1 1 1 1 1 1
04 COIL ASY EVAP 5 TON AL/CU 1178025 1 1 1 1 1 1 1 1
05 MTR BLW 208/230/1 1 1620 1176336 1 1 * * 1 1 * *
05 MTR BLW 1.5,1725,208/230/1 1176388 * * 1 1 * * 1 1
06 MTR CND 1/230 1/4 1100 1178026 1 1 1 1 1 1 1 1
07 FAN C 22" 3B 1/2" 24 INT 1178035 1 1 1 1 1 1 1 1
08 CAP RN RD 370V 5+80 1172113 1 1 1 1 1 1 1 1
10 CONTACTOR 2P 40A 24V 1176763 1 1 1 1 1 1 1 1
11 CAP RN OV 370V 15 1172505 1 1 * * 1 1 * *
12 MODULE IGN UT 1068-11 1171166 1 1 1 1 1 1 1 1
13 TRANS 208/230>24 75VA 1178027 1 1 1 1 1 1 1 1
14 WHEEL BLOWER 10" X 5/8 BORE 1175318 1 1 * * 1 1 * *
14 WHEEL BLOWER 11" X 5/8 BORE 1178085 * * 1 1 * * 1 1
15 WHEEL SI5.75x.938x5/16 CCW 1171049 1 1 1 1 1 1 1 1
16 FAN C 3.25" 12B 5/16" 1171222 1 1 1 1 1 1 1 1
17 TERMINAL BOARD 1178030 1 1 1 1 1 1 1 1
18 SWITCH LMT 195-80 1171325 1 1 1 1 1 1 1 1
19 REGULATOR FLAME 1175288 1 1 1 1 1 1 1 1
20 SWITCH TEMP ACT 1175306 1 1 1 1 1 1 1 1
21 SENSOR FLAME 1171449 1 1 1 1 1 1 1 1
22 IGNITER ASY 1171306 1 1 1 1 1 1 1 1
23 MANIFOLD ASY 1175234 1 1 1 1 1 1 1 1
24 BURNER ASY 1171095 2 2 2 2 2 2 2 2
25 BURNER ASY 1171087 1 1 1 1 1 1 1 1
26 RING INSERT 1171439 3 3 3 3 3 3 3 3
27 VALVE GAS 1 STAGE 1178163 1 1 1 1 1 1 1 1
28 SPUD ORIFICE 1171461 3 * 3 * 3 * 3 *
28 SPUD ORIFICE 1171782 * 3 * 3 * 3 * 3
29 MOTOR ASY (INDUCED DRAFT) 1171314 1 1 1 1 1 1 1 1
30 SENSOR HALL EFFECT (HS) 1171450 1 1 1 1 1 1 1 1
31 MOTOR (IDM) 1171348 1 1 1 1 1 1 1 1
32 BAFFLE FLUE LWNX 1176044 * 1 * 1 * 1 * 1
33 HT EX TUBLR 3-3 SS 1175734 1 * 1 * 1 * 1 *
33 HT EX TUBLR 3-3 SS LWNX 1176258 * 1 * 1 * 1 * 1
34 BAFFLE LWNX 1175987 * 3 * 3 * 3 * 3
35 BAFFLE HEAT 1175290 1 1 1 1 1 1 1 1
38 FILTER DRIER 1178033 1 1 1 1 1 1 1 1
39 GROUND LUG 1172300 1 1 1 1 1 1 1 1
40 CAP RN OV 370V 4 1175500 1 1 1 1 1 1 1 1
42 BEARING 1175424 2 2 2 2 2 2 2 2
43 KEY BLOWER 1175493 1 1 1 1 1 1 1 1
44 PULLEY BLOWER 1175830 1 1 1 1 1 1 1 1
45 PULLEY MOTOR 1175849 1 1 * * 1 1 * *
45 PULLEY MOTOR 1175832 * * 1 1 * * 1 1
46 BELT V 1178179 1 1 * * 1 1 * *
46 BELT V 1178200 * * 1 1 * * 1 1
47 SHAFT FAN 1175422 1 1 1 1 1 1 1 1
48 SWITCH PRESSURE (LPS) 1178029 1 1 1 1 1 1 1 1
RGS060KNBB0AAAA
24
509 04 3502 00
RGS 5 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS060KFAA0AAAA
RGS060KFBA0AAAA
RGS060KNAA0AAAA
RGS060KFAB0AAAA
RGS060KNBA0AAAA
RGS060KFBB0AAAA
RGS060KNAB0AAAA
HIGH HEAT
50 SWITCH PRESSURE (HPS) 1178028 1 1 1 1 1 1 1 1
51 KEY MOTOR 1175300 1 1 * * 1 1 * *
52 ACTUATOR DAMPER MOTOR 1176280 * * * * 1 1 1 1
53 CONTROLLER 1176282 * * * * 1 1 1 1
54 SHAFT ACTUATOR 1178103 * * * * 1 1 1 1
55 SENSOR (DISCHARGE)SUPPLY AIR(MIXED) 1176279 * * * * 1 1 1 1
56 SENSOR LOW AMBIENT 1176283 * * * * 1 1 1 1
57 SENSOR OUTDOOR-AIR TEMPERATURE 1176281 * * * * 1 1 1 1
A FILTER AIR 1175312 2 2 2 2 2 2 2 2
B BOOT PROTECTIVE 1171842 1 1 1 1 1 1 1 1
C BRACKET BASERAIL CORNER 1171071 2 2 2 2 2 2 2 2
D BRACKET COIL 1171070 1 1 1 1 1 1 1 1
E CHANNEL INDUCED DRAFT MOTOR 1171112 1 1 1 1 1 1 1 1
F STRAP CAPACITOR 1171552 2 2 2 2 2 2 2 2
G COVER ASY TOP 1178042 1 1 1 1 1 1 1 1
H BRACKET SUPPORT GAS VALVE 1176209 1 1 1 1 1 1 1 1
J COVER ASY RETURN AIR 1175227 1 1 1 1 1 1 1 1
K COVER ASY SUPPLY 1175228 1 1 1 1 1 1 1 1
L GASKET REGULATOR 1175268 1 1 1 1 1 1 1 1
M GRILLE OUTLET 1171267 1 1 1 1 1 1 1 1
N GROMMET 1171270 4 4 4 4 4 4 4 4
P GUARD BASERAIL INDOOR END 1175263 1 1 1 1 1 1 1 1
R GUARD LIMIT SWITCH 1171271 1 1 1 1 1 1 1 1
S WIND CAP ASY 1173617 1 1 1 1 1 1 1 1
T HOUSING FAN 1171301 1 1 1 1 1 1 1 1
V INSULATION 1171317 1 1 1 1 1 1 1 1
W PAN ASY CONDENSATE 1175243 1 1 1 1 1 1 1 1
X PANEL ACCESS CONTROL BOX 1178168 1 1 1 1 1 1 1 1
Y PANEL ACCESS COMPRESSOR 1178046 1 1 1 1 1 1 1 1
Z PANEL ASY FILTER LOWER 1175242 1 1 1 1 * * * *
AA PANEL ASY DOOR FILTER UPPER 1175241 1 1 1 1 * * * *
AB PANEL ASY INDOOR END 1175226 1 1 1 1 1 1 1 1
AC PANEL ASY INDOOR BLOWER ACCESS 1178040 1 1 1 1 1 1 1 1
AD PANEL OUTDOOR END 1178047 1 1 1 1 1 1 1 1
AE PLATE FAN 1175484 1 1 1 1 1 1 1 1
AF PLATE FAN 1175299 1 1 1 1 1 1 1 1
AG STRAP CAPACITOR 1172735 1 1 1 1 1 1 1 1
AH POST CENTER FILTER ACCESS SIDE 1178023 1 1 1 1 1 1 1 1
AJ POST CENTER CONTROL BOX SIDE 1178167 1 1 1 1 1 1 1 1
AK POST CORNER COIL 1175256 1 1 1 1 1 1 1 1
AL POST CORNER CONTROL BOX 1178043 1 1 1 1 1 1 1 1
AM POST CORNER INDOOR END 1175230 2 2 2 2 2 2 2 2
AN CONDUIT 1171428 1 1 1 1 1 1 1 1
AP RAIL BASE FILTER ACCESS 1175266 1 1 1 1 1 1 1 1
AQ RAIL BASE INDOOR FAN ACCESS 1175265 1 1 1 1 1 1 1 1
AR RAIL BASE OUTDOOR END 1175334 1 1 1 1 1 1 1 1
AS RETAINER FLAME 1175854 * * * * * * * *
AS RETAINER FLAME 1175287 1 1 1 1 1 1 1 1
AT PANEL COIL 1178104 1 1 1 1 1 1 1 1
AV PLATE MOTOR 1175844 1 1 * * 1 1 * *
RGS060KNBB0AAAA
509 04 3502 00
25
RGS 5 Ton 208/230v 1Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS060KFAA0AAAA
RGS060KFBA0AAAA
RGS060KNAA0AAAA
RGS060KFAB0AAAA
RGS060KNBA0AAAA
RGS060KFBB0AAAA
RGS060KNAB0AAAA
HIGH HEAT
AV PLATE ASY MOTOR 1175664 * * 1 1 * * 1 1
AW SCROLL FAN 1175260 1 1 1 1 1 1 1 1
AX SUPPORT ASY INDUCER & HEAT EXCH 1175237 1 1 1 1 1 1 1 1
AY SUPPORT BURNER 1175296 1 1 1 1 1 1 1 1
AZ SUPPORT HEAT EXCHANGER BRACKET 1175258 1 1 1 1 1 1 1 1
BA BOLT HEX HEAD 1171056 4 4 4 4 4 4 4 4
BB SEAL DRAIN LINE ROUND 1171447 1 1 1 1 1 1 1 1
BC BRACKET MTR MTG 1175842 1 1 * * 1 1 * *
BC SUPPORT BRACKET MTR MTG 1175483 * * 1 1 * * 1 1
BD BRACKET ASY 1175423 2 2 2 2 2 2 2 2
BE BLOWER ASY STD STATIC 1175283 1 1 * * 1 1 * *
BF BASE PAN ASY INDOOR 1175231 1 1 1 1 1 1 1 1
BG BASE PAN ASY OUTDOOR 1175232 1 1 1 1 1 1 1 1
BH COVER ASY GAS HEAT 1178165 1 1 1 1 1 1 1 1
BJ DECK FAN 1175259 1 1 1 1 1 1 1 1
BL PANEL ACCESS 1178166 1 1 1 1 1 1 1 1
BM HANDLE SNAP-IN PLASTIC 1178036 3 3 3 3 3 3 3 3
BN SEAL DRAIN LINE SQUARE 1171202 1 1 1 1 1 1 1 1
BP GROMMET WIRE PARTITION 1176613 2 2 2 2 2 2 2 2
BQ PLATE ASY COMP MOUNTING 1175843 1 1 1 1 1 1 1 1
BR PLATE BLOCKOFF 1175294 1 1 1 1 1 1 1 1
BS FRAME ASY 1175238 1 1 1 1 1 1 1 1
BT RETAINER FILTER 1175273 1 1 1 1 1 1 1 1
BV RETAINER FILTER 1175274 1 1 1 1 1 1 1 1
BW RETAINER FILTER 1175275 2 2 2 2 2 2 2 2
BX BRACKET INDOOR 1175262 1 1 1 1 1 1 1 1
BZ SHIELD 1171453 1 1 1 1 1 1 1 1
CA SUPPORT 1175271 1 1 1 1 1 1 1 1
CB INSULATION 1175272 1 1 1 1 1 1 1 1
CC ANGLE BLOCKOFF 1175267 1 1 1 1 1 1 1 1
CH PANEL LOWER 1176276 * * * * 1 1 1 1
CJ PANEL UPPER 1176277 * * * * 1 1 1 1
CK HOOD LF SIDE 0640045A * * * * 1 1 1 1
CL FILTER (AL) (15.31 X 29.44 X 1) 1176284 * * * * 1 1 1 1
CM HOOD RT SIDE 0640040A * * * * 1 1 1 1
CN HOOD DIVIDER 0640014A * * * * 1 1 1 1
PARTS NOT SHOWN
)( PAINT (16-OZ CAN) (STERLING GRAY) 1171357 1 1 1 1 1 1 1 1
)( HARNESS ASY IFM 1178022 1 1 * * 1 1 * *
)( HARNESS ASY IFM 1178125 * * 1 1 * * 1 1
)( PLUG ASY SHORTING 1171405 1 1 1 1 1 1 1 1
)( PLUG ASY COMP 1178032 1 1 1 1 1 1 1 1
)( HARNESS ASY (J2) (YAC CONTROL) 1178161 1 1 1 1 1 1 1 1
)( HARNESS ASY(CLO1/COMP1) TERM BD 1178160 1 1 1 1 1 1 1 1
)( HARNESS ASY (PL6) (ECONOMIZER) 1178162 1 1 1 1 1 1 1 1
)( KIT WIRING 1175246 1 1 1 1 1 1 1 1
)( IGNITION CABLE 1175498 1 1 1 1 1 1 1 1
RGS060KNBB0AAAA
26
509 04 3502 00
RGS 3 TON 208/230V 3Phase PARTS LIST
KEY
NO.
DESCRIPTION FAST PARTS NO.
RGS036HLAA0AAAA
RGS036HLBA0AAAA
RGS036HLAB0AAAA
RGS036HLBB0AAAA
RGS036HDAA0AAAA
RGS036HDBA0AAAA
RGS036HDAB0AAAA
LOW HEAT MED HEAT
RGS036HEAA0AAAA
RGS036HDBB0AAAA
RGS036HMAA0AAAA
RGS036HEBA0AAAA
RGS036HEAB0AAAA
RGS036HMBA0AAAA
RGS036HMAB0AAAA
01 COMP ZP31K5E-TF5-830 ZP31K5ETF5130 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
03 COIL ASY COND 3 TON AL/CU 1178038 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
04 COIL ASY EVAP 3 TON AL/CU 1178037 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
05 MTR BLW 208/230/1 1 1620 1176336 1 1 * * 1 1 * * 1 1 * * 1 1 * *
05 MTR BLW 230/460/3 3 1725 1175478 * * 1 1 * * 1 1 * * 1 1 * * 1 1
06 MTR CND 1/230 1/4 1100 1178026 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
07 FAN C 22" 3B 1/2" 24 INT 1178035 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
08 CAP RN OV 370V 5 1172149 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
10 CONTACTOR 2P 40A 24V 1178074 1 1 2 2 1 1 2 2 1 1 2 2 1 1 2 2
11 CAP RN OV 370V 15 1172505 1 1 * * 1 1 * * 1 1 * * 1 1 * *
12 MODULE IGN UT 1068-11 1171166 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
13 TRANS 208/230>24 75VA 1178027 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
14 WHEEL BLOWER 10" X 5/8 BORE 1175318 1 1 * * 1 1 * * 1 1 * * 1 1 * *
14 WHEEL BLOWER 11" X 5/8 BORE 1178085 * * 1 1 * * 1 1 * * 1 1 * * 1 1
15 WHEEL SI5.75x.938x5/16 CCW 1171049 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
16 FAN C 3.25" 12B 5/16" 1171222 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
17 TERMINAL BOARD 1178030 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
18 SWITCH LMT 195-80 1171325 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
19 REGULATOR FLAME 1175855 1 1 1 1 1 1 1 1 * * * * * * * *
19 REGULATOR FLAME 1175869 * * * * * * * * 1 1 1 1 1 1 1 1
20 SWITCH TEMP ACT 1175306 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
21 SENSOR FLAME 1171449 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
22 IGNITER ASY 1171306 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
23 MANIFOLD ASY 1175852 1 1 1 1 1 1 1 1 * * * * * * * *
23 MANIFOLD ASY 1175234 * * * * * * * * 1 1 1 1 1 1 1 1
24 BURNER ASY 1171095 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
25 BURNER ASY 1171087 * * * * * * * * 1 1 1 1 1 1 1 1
26 RING INSERT 1171439 2 2 2 2 2 2 2 2 3 3 3 3 3 3 3 3
27 VALVE GAS 1 STAGE 1178163 1 1 1 1 1 1 1 1 * 1 * 1 * 1 * 1
27 VALVE GAS 2 STAGE 1175853 * * * * * * * * 1 * 1 * 1 * 1 *
28 SPUD ORIFICE 1172226 2 * 2 * 2 * 2 * 3 * 3 * 3 * 3 *
28 SPUD ORIFICE 1172235 * 2 * 2 * 2 * 2 * 3 * 3 * 3 * 3
29 MOTOR ASY (INDUCED DRAFT) 1171314 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
30 SENSOR HALL EFFECT (HS) 1171450 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
31 MOTOR (IDM) 1171348 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
32 BAFFLE FLUE LWNX 1176211 * 1 * 1 * 1 * 1 * * * * * * * *
32 BAFFLE FLUE LWNX 1176044 * * * * * * * * * 1 * 1 * 1 * 1
33 HT EX TUBLR 2-1 SS 1176229 1 * 1 * 1 * 1 * * * * * * * * *
33 HT EX TUBLR 2-1 SS LWNX 1176231 * 1 * 1 * 1 * 1 * * * * * * * *
33 HT EX TUBLR 3-2 SS 1176230 * * * * * * * * 1 * 1 * 1 * 1 *
33 HT EX TUBLR 3-2 SS LWNX 1176232 * * * * * * * * * 1 * 1 * 1 * 1
34 BAFFLE LWNX 1175987 * 2 * 2 * 2 * 2 * 3 * 3 * 3 * 3
38 FILTER DRIER 1178033 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
39 GROUND LUG 1172300 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
40 CAP RN OV 370V 4 1175500 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
42 BEARING 1175424 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
43 KEY BLOWER 1175493 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
RGS036HEBB0AAAA
RGS036HMBB0AAAA
509 04 3502 00
27
RGS 3 TON 208/230V 3Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS036HLBB0AAAA
RGS036HLAB0AAAA
RGS036HLBA0AAAA
RGS036HLAA0AAAA
RGS036HDAA0AAAA
LOW HEAT MED HEAT
RGS036HDAB0AAAA
RGS036HDBA0AAAA
RGS036HEAA0AAAA
RGS036HDBB0AAAA
RGS036HMAA0AAAA
RGS036HEBA0AAAA
RGS036HMBA0AAAA
RGS036HEBB0AAAA
RGS036HEAB0AAAA
RGS036HMAB0AAAA
44 PULLEY BLOWER 1178034 1 1 * * 1 1 * * 1 1 * * 1 1 * *
44 PULLEY BLOWER 1175830 * * 1 1 * * 1 1 * * 1 1 * * 1 1
45 PULLEY MOTOR 1175849 1 1 * * 1 1 * * 1 1 * * 1 1 * *
45 PULLEY MOTOR 1175832 * * 1 1 * * 1 1 * * 1 1 * * 1 1
46 BELT V 1178127 1 1 * * 1 1 * * 1 1 * * 1 1 * *
46 BELT V 1178200 * * 1 1 * * 1 1 * * 1 1 * * 1 1
47 SHAFT FAN 1175422 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
48 SWITCH PRESSURE (LPS) 1178029 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
50 SWITCH PRESSURE (HPS) 1178028 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
51 KEY MOTOR 1175300 1 1 * * 1 1 * * 1 1 * * 1 1 * *
52 TERMINAL BOARD 1178164 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
52 ACTUATOR DAMPER MOTOR 1176280 * * * * 1 1 1 1 * * * * 1 1 1 1
53 CONTROLLER 1176282 * * * * 1 1 1 1 * * * * 1 1 1 1
54 SHAFT ACTUATOR 1178103 * * * * 1 1 1 1 * * * * 1 1 1 1
SENSOR (DISCHARGE)SUPPLY AIR(MIXED)
55
1176279 * * * * 1 1 1 1 * * * * 1 1 1 1
56 SENSOR LOW AMBIENT 1176283 * * * * 1 1 1 1 * * * * 1 1 1 1
SENSOR OUTDOOR-AIR TEMPERATURE
57
1176281 * * * * 1 1 1 1 * * * * 1 1 1 1
A FILTER AIR 1175312 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
B BOOT PROTECTIVE 1171842 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
C BRACKET BASERAIL CORNER 1171071 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
D BRACKET COIL 1171070 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
E CHANNEL INDUCED DRAFT MOTOR 1171112 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
F STRAP CAPACITOR 1171552 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3
G COVER ASY TOP 1178042 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
H BRACKET SUPPORT GAS VALVE 1176209 1 1 1 1 1 1 1 1 * 1 * 1 * 1 * 1
H BRACKET SUPPORT GAS VALVE 1175291 * * * * * * * * 1 * 1 * 1 * 1 *
J COVER ASY RETURN AIR 1175227 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
K COVER ASY SUPPLY 1175228 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
L GASKET REGULATOR 1175268 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
M GRILLE OUTLET 1171267 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
N GROMMET 1171270 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
P GUARD BASERAIL INDOOR END 1175263 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
R GUARD LIMIT SWITCH 1171271 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
S WIND CAP ASY 1173617 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
T HOUSING FAN 1171301 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
V INSULATION 1171317 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
W PAN ASY CONDENSATE 1175243 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
X PANEL ACCESS CONTROL BOX 1178168 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
Y PANEL ACCESS COMPRESSOR 1178046 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
Z PANEL ASY FILTER LOWER 1175242 1 1 1 1 * * * * 1 1 1 1 * * * *
AA PANEL ASY DOOR FILTER UPPER 1175241 1 1 1 1 * * * * 1 1 1 1 * * * *
AB PANEL ASY INDOOR END 1175226 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AC PANEL ASY INDOOR BLOWER ACCESS 1178040 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AD PANEL OUTDOOR END 1178024 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AE PLATE FAN 1175484 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AF PLATE FAN 1175299 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AH POST CENTER FILTER ACCESS SIDE 1178023 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
RGS036HMBB0AAAA
28
509 04 3502 00
RGS 3 TON 208/230V 3Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS036HLBB0AAAA
RGS036HLAB0AAAA
RGS036HLBA0AAAA
RGS036HLAA0AAAA
RGS036HDAA0AAAA
LOW HEAT MED HEAT
RGS036HDAB0AAAA
RGS036HDBA0AAAA
RGS036HEAA0AAAA
RGS036HDBB0AAAA
RGS036HMAA0AAAA
RGS036HEBA0AAAA
RGS036HMBA0AAAA
RGS036HEBB0AAAA
RGS036HEAB0AAAA
RGS036HMAB0AAAA
AJ POST CENTER CONTROL BOX SIDE 1178167 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AK POST CORNER COIL 1175256 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AL POST CORNER CONTROL BOX 1178043 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AM POST CORNER INDOOR END 1175230 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
AN CONDUIT 1171428 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AP RAIL BASE FILTER ACCESS 1175266 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AQ RAIL BASE INDOOR FAN ACCESS 1175265 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AR RAIL BASE OUTDOOR END 1175334 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AS RETAINER FLAME 1175854 1 1 1 1 1 1 1 1 * * * * * * * *
AS RETAINER FLAME 1175287 * * * * * * * * 1 1 1 1 1 1 1 1
AT PANEL COIL 1178104 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AV PLATE MOTOR 1175844 1 1 * * 1 1 * * 1 1 * * 1 1 * *
AV PLATE ASY MOTOR 1175664 * * 1 1 * * 1 1 * * 1 1 * * 1 1
AW SCROLL FAN 1175260 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AX SUPPORT ASY INDUCER & HEAT EXCH 1175237 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AY SUPPORT BURNER 1175296 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
AZ SUPPORT HEAT EXCHANGER BRACKET 1175258 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BA BOLT HEX HEAD 1171056 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
BB SEAL DRAIN LINE ROUND 1171447 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BC BRACKET MTR MTG 1175842 1 1 * * 1 1 * * 1 1 * * 1 1 * *
BC SUPPORT BRACKET MTR MTG 1175483 * * 1 1 * * 1 1 * * 1 1 * * 1 1
BD BRACKET ASY 1175423 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
BE BLOWER ASY STD STATIC 1175283 1 1 * * 1 1 * * 1 1 * * 1 1 * *
BF BASE PAN ASY INDOOR 1175231 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BG BASE PAN ASY OUTDOOR 1175232 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BH COVER ASY GAS HEAT 1178165 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BJ DECK FAN 1175259 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BL PANEL ACCESS 1178166 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BM HANDLE SNAP-IN PLASTIC 1178036 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3
BN SEAL DRAIN LINE SQUARE 1171202 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BP GROMMET WIRE PARTITION 1176613 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
BQ PLATE ASY COMP MOUNTING 1175843 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BR PLATE BLOCKOFF 1175294 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BS FRAME ASY 1175238 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BT RETAINER FILTER 1175273 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BV RETAINER FILTER 1175274 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BW RETAINER FILTER 1175275 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
BX BRACKET INDOOR 1175262 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BZ SHIELD 1171453 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
CA SUPPORT 1175271 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
CB INSULATION 1175272 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
CC ANGLE BLOCKOFF 1175267 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
CH PANEL LOWER 1176276 * * * * 1 1 1 1 * * * * 1 1 1 1
CJ PANEL UPPER 1176277 * * * * 1 1 1 1 * * * * 1 1 1 1
CK HOOD LF SIDE MIM0640045A * * * * 1 1 1 1 * * * * 1 1 1 1
CL FILTER (AL) (15.31 X 29.44 X 1) 1176284 * * * * 1 1 1 1 * * * * 1 1 1 1
CM HOOD RT SIDE MIM0640040A * * * * 1 1 1 1 * * * * 1 1 1 1
RGS036HMBB0AAAA
509 04 3502 00
29
RGS 3 TON 208/230V 3Phase PARTS LIST (continued)
KEY
NO.
FAST PARTS NO.DESCRIPTION
RGS036HLBB0AAAA
RGS036HLAB0AAAA
RGS036HLBA0AAAA
RGS036HLAA0AAAA
RGS036HDAA0AAAA
LOW HEAT MED HEAT
RGS036HDAB0AAAA
RGS036HDBA0AAAA
RGS036HEAA0AAAA
RGS036HDBB0AAAA
RGS036HMAA0AAAA
RGS036HEAB0AAAA
RGS036HEBA0AAAA
RGS036HMAB0AAAA
RGS036HMBA0AAAA
CN HOOD DIVIDER MIM0640014A * * * * 1 1 1 1 * * * * 1 1 1 1
PARTS NOT SHOWN
)( PAINT (16-OZ CAN) (STERLING GRAY) 1171357 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
)( HARNESS ASY IFM 1178022 1 1 * * 1 1 * * 1 1 * * 1 1 * *
)( HARNESS ASY IFM 1178084 * * 1 1 * * 1 1 * * 1 1 * * 1 1
)( PLUG ASY SHORTING 1171405 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
)( PLUG ASY COMP 1178076 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
)( HARNESS ASY (J2) (YAC CONTROL) 1178161 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
)( HARNESS ASY(CLO1/COMP1) TERM BD 1178160 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
)( HARNESS ASY (PL6) (ECONOMIZER) 1178162 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
)( KIT WIRING 1175246 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
)( IGNITION CABLE 1175498 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
RGS036HEBB0AAAA
RGS036HMBB0AAAA
30
509 04 3502 00
Loading...