International 4200, 4300, 4400 Service Manual

4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

51

ELECTRICAL CIRCUIT DIAGRAMS

7. GAUGES WITH AND WITHOUT INTEGRAL WARNING LIGHT (C HAPTER

7)

7.1. IP/GAUGE LIST, P. 1

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

INSTRUMENT PANEL GAUGES

GAUGE

RPM (TACH) MPH/KPH (SPD) FUEL

VOLT AIR 1 (PRES)

AIR 2 (PRES) WATER (TEMP) ENG OIL (TEMP)

OIL (PRES) TRANS (TEMP)

AIR APPLICATION REAR AXLE TEMP

WARN LIGHT

NO NO YES YES YES YES YES YES YES YES NO YES

ENGINE CTRLR/DRIVE TRAIN J1939/CLU ST ER ENGINE CTRLR/DRIVE TRAIN J1939/CLU ST ER

SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER ENGINE CTRLR/DRIVE TRAIN J1939/CLU ST ER ENGINE CTRLR/DRIVE TRAIN J1939/CLU ST ER ENGINE CTRLR/DRIVE TRAIN J1939/CLU ST ER XMSN CTRLR/SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER

SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER

ELECTRICAL CIRCUIT DIAGRAM

IP/GAUGES

SIGNAL PATH

CHAPTER 7

SENSOR

LOCATION

ENGINE TRANSMISSION FUEL TANK

-----------------------

INSIDE CAB - DASH PNL

STEERING COL AREA ENGINE ENGINE ENGINE

TRANSMISSION

FWD CHASSIS

AXLE

Figure 51 IP/Gauge List

NOTES:

1) WARNING LIGHTS ARE PART OF THE GAUGES AND LOCATED IN THE GAUGE

DATE CHANGE

PRODUCTION RELEASE. A P54304UPEC 16JAN01

REV

REFERENCECHK

DRAWN

U00JXP9

RELEASE NO.

P52778H

09AUG0001AE08-52371

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

PART NO. SHEET

s08285

52 4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

7.2. WARNING LIGHT LIST, P. 2

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

IP WARNING LIGHTS

WARNING LIGHT

TITLE

RANGE INHIBITED FUEL FILTER ENGINE (YELLOW LED)

ENGINE (RED LED) BRAKE PRESSURE BRAKE FLUID

TRAC CTRL CHECK TRANS

TRAILER ABS WASHER FLUID

(LEFT TURN) AIR BAG WATER IN FUEL COOLANT LEVEL CHECK ELECT SYS PARK CRUISE ABS (RIGHT TURN) WAIT TO START FASTEN BELTS (HIGH BEAM IND) COLD AMB PROTEC SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER RETARD OVERHEAT CHECK AC AUTO NEUTRAL

ALTERNATOR PTO/THROTTLE

OPTIMIZED IDLE SNOW VALVE FR AXLE DIFF LOCK RR AXLE DIFF LOCK MESSAGE WAIT PTO CONVERTER TEMP TOUCHLOC RELEASE PARK FLUID

( )

( P )

TRANS CTRLR/DRIVE TRAIN J1939/CLUS TE R SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER ENGINE CTRLR/DRIVE TRAIN J1939/CLUSTER ENGINE CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER

SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER

TRUCK ABS CTRLR/DRIVE TRAIN J1939/CLUSTER TRANS CTRLR/DRIVE TRAIN J1939/CLUS TE R

TRLR ABS CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER

DISCRETE NOT ON DATA BUS SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER ENGINE CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER

SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER TRUCK CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER ENGINE CTRLR/DRIVE TRAIN J1939/C LU ST ER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER

TRANS CTRLR/DRIVE TRAIN J1939/CLUS TE R SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER DISCRETE NOT ON DATA BUS DISCRETE NOT ON DATA BUS SYSTEM CTRLR/DRIVE TRAIN J1939/CLUSTER DISCRETE NOT ON DATA BUS DISCRETE NOT ON DATA BUS DISCRETE NOT ON DATA BUS DISCRETE NOT ON DATA BUS DISCRETE NOT ON DATA BUS DISCRETE NOT ON DATA BUS DISCRETE NOT ON DATA BUS DISCRETE NOT ON DATA BUS

SYSTEM CTRLR/DRIVE TRAIN

SIGNAL PATH

ELECTRICAL CIRCUIT DIAGRAM

WARNING LIGHTS LIST

CHAPTER 7

SENSOR

LOCATION

FUEL FILTER

SWITCH

BRK RESEVOIR

WASHER BOTTLE TURN SIG SW

FUEL FILTER

SURGE TANK

SWITCH

TRANSMISSION

SWITCH

SNOW VALVE

FWD RR AXLE

RR RR AXLE

DATE CHANGE

PEC 16JAN01

Figure 52 Warning Light List

REFERENCECHK

REV

PRODUCTION RELEASE. A P54304U

DRAWN

U00JXP9

RELEASE NO.

P52778H

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

09AUG0002AE08-52371

s08

PART NO. SHEET

285

4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

7.3. WARNING LIGHTS CONTROLLED BY ENGINE, TRANSMISSION, ABS CONTROLLER, P. 3

53

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

THE FOLLOWING WARNING LIGHTS ARE C ON TROLLED BY THE ENGINE, TRANSMISSION, OR ABS CONTROLLER OVER THE DATA BU S AN D DO NO T HAVE IND EPENDENT CIRCUITRY THAT CAN BE OR NEEDS TO BE SHOWN:

RANGE INHIBIT

ENGINE (YELLOW LED)

ENGINE (RED LED)

TRAC CTRL

CHECK TRA N S

TRAILER ABS

CHECK ELE C TR SYS

ABS

WAIT TO START

RETARD OVERHEAT

AUTO NEUTRAL

OPTIMIZED IDLE

(NOT ON DATA BUS TO CLUSTER)

ELECTRICAL CIRCUIT DIAGRAM

WARNING LIGHTS CONTROLLED BY ENGINE, TRANSMISSION, ABS CONT ROLLER

CHAPTER 7

PEC 16JAN01

Figure 53 Warning Lights Controlled by Engine, Transmission, ABS Controller

DATE CHANGE

PRODUCTION RELEASE. A P54304U

REV

REFERENCECHK

DRAWN

U00JXP9

RELEASE NO.

P52778H

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

20JUN00

s08

PART NO. SHEET

285

03AE08-52371

54 4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

7.4. ENGINE OIL PRESSURE AND TEMP, SPEEDOMETER, TACH, VOLTMETER AND WATER TEMP GAUGE CIRCUITS, P. 4

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

REFER TO CONSOLIDATED ENGINE/VEHICL E CONT ROLLE R DIAGNOSTICS MANUAL EGES-175 (DT466), EGES-190 (V8-AVNT), FOR CIRCUIT DIAGRAMS SHOWING INPUT CIRCUITRY FOR THE FOLLOW I NG DATA L INK DRIV E N SYST EM:

ENGINE OIL PRESSURE GAUGE

ENGINE OIL TEMPERATURE GAUGE

SPEEDOMETER GAUGE

TACHOMETER GAUGE

WATER TEMPERATURE GAUGE

ELECTRICAL CIRCUIT DIAGRAM

ENG OIL PRESS & TEMP, SPEEDOMETER, TACH, VOLTMETER & WATER TEMP GAUGE CIRCUITS

CHAPTER 7

DATE CHANGE

Figure 54 Engine Oil Pressure and Temp, Speedometer, Tach, Voltmeter and Water Temp Gauge Circuits

REFERENCECHK

REV

PRODUCTION RELEASE. A P54304UPEC 16JAN01

DRAWN

U00JXP9

RELEASE NO.

P52778H

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

20JUN0004AE08-52371

s08

PART NO. SHEET

285

4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

7.5. IP/GAUGES AND WARNING LIGHTS — G AUGE CLUSTER, P. 5

55

Figure 55 IP/Gauges and Warning Lights — Gauge Cluster

s08

285

56 4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

7.6. AIR PRESSUR E INPUT CIRCUIT, P. 6

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

PRIMARY, SECONDARY AIR BRAKE APPLICATION GAUGE WIRING

SYSTEM CONTROLLER

(1600)

ZERO VOLT REFERENCE

PRIMARY AIR SENSE

SECONDARY AIR SENSE

SWITCHED SENSE CMD

SYSTEM CONTROLLER (4004)

AIR BRAKE APP

SYSTEM CONTROLLER (4004)

LOGIC GND

(5V)

5V OUT

A9H 20GY

3

A40 20GY

15

A40A 20GY

16

A6H 20GY

27

PASS THRU (4014)

J40F 18GY

13

AIR SYSTEM PRESSURE GAUGE WIRING

26 27

17

W / HYD BRAKES

ELECTRONIC REF GROUND SPLICE PACK (4830)

J9A 18GY

J6A 18GY

(4820) 5V REF SPLICE PACK

A9V 18GY

A40F 18GY

ELECTRICAL CIRCUIT DIAGRAM

AIR PRESSURE INPUT CIRCUIT

B9V

CAB/DCM (1800)

A4

C12

B2

B3

C2

J9EA 18GY

J6BA 18GY

18GY

B40 18GY

B40A 18GY

B6H 18GY

B40F 18GY

FWD CHASSIS/DASH (4301)

1 2 3

M9A 18GY

M6A 18GY

M40 18GY

B9VC 18GY

B6HB 18GY

B9VE 18GY

B6HA 18GY

B9VF 18GY

B6HC 18GY

CHAPTER 7

A

B

C

A B C

A B

C

A B C

PRIMARY AIR TRANSDUCER

(1811)

SECONDARY AIR TRANSDUCER

(1812)

AIR APPLICATION TRANSDUCER

(1822)

AUX AIR TRANSDUCER

(8505)

SYSTEM CONTROLLER (1600)

DATE CHANGE

Figure 56 Air Pressure Input Circuit

AUX AIR SENSE

PRODUCTION RELEASE. A P54304UPEC 16JAN01

PASS THRU (4014)

J40FA 18GY

A40 20GY

15

REV

REFERENCECHK

DRAWN

U00TRH2

RELEASE NO.

P52778H

3

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

21JUN0006AE08-52371

285

s08

DCM (1800) & (1805)

A99W 18VT

PART NO. SHEET

C12

B40G 18GY

B6

4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

57

ELECTRICAL CIRCUIT DIAGRAMS

7.7. AXLE TEMPERATURE, FWD REAR AND REAR AXLES, GAUGE INPUT CIRCUIT, P. 7

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

SYSTEM CONTROLLER (4004)

FR AXLE OIL TEMP RR AXLE OIL TEMP ZERO VOLT REF

2 1 26

ZERO VOLT REF SPLICE (4830)

ZERO VOLT REF SPLICE (8802)

ELECTRICAL CIRCUIT DIAGRAM

AXLE TEMPERATURE, FWD REAR & REAR REAR AXLES, GAUGE INPUT CIR C UI T

J32 18TN

J32A 18TN

J9A 18GY

J9G

18GY

DASH/CENTER CHASSIS

A2

A1

N9H** 18GY

N9F*

18GY

D8

N9

18GYN918GY

11

R9B**

18GY

N32

18TN

R9C* 18GY

(9700)

N32A

18TN

CENTER/REAR

5

6

R32A 18TN

R9A** 18GY

R32 18TN

R9** 18GY

CHASSIS (9800)

CHAPTER 7

F REAR AXLE

TEMP SENDER

(9811)

1

2

RR AXLE

TEMP SENDER

(9812)

1

2

16JAN01

Figure 57 Axle Temperature, FWD Rear and Rear Axles, Gauge Input Circuit

DATE CHANGE

PRODUCTION RELEASE. A P54304UPEC

REV

* GAUGE REAR ** GAUGE REAR & RR

REFERENCECHK

DRAWN

U00JXP9

RELEASE NO.

P52778H

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

10AUG0007AE08-52371

s08

PART NO. SHEET

285

58 4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

7.8. FUEL GAUGE INPUT CIRCUIT (SINGLE TANK) DIFFERENTIAL LOCK WARNING LAMPS, P. 8

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

FUEL GAUGE INPUT CIRCUIT (SINGLE TA NK )

A49D 18GY

F9

A1

RIGHT FUEL SENDER

LEFT FUEL S ENDER

ZERO VOLT REF

19 A49F 18GY

20

PASS THRU

A49C

18GY

(4014)

A49E

18GY

D1

CAB FUSE

BLOCK

5A

(1011)

E1

C1

A13CY

10PK

ZERO VOLT REF SPLICE (8802)

DIFFERNTIAL LOCK WARNING LAMPS

J11-GJ 10WH

GND (4006)

IGNITION FEED FROM CAB FUSE BLOCK (1011) A2 SEE CH02_12

SYSTEM CONTROLLER (4004)

G

B

E

D

WARNING LIGHTS (1555)

5

J36A 18TN

4

J36B 18TN

26

J9A 18GY

ZERO VOLT REF SPLICE (4830)

A C B

J49A 18GY

J11-GA 14WH

J49B 18GY

DASH/CENTER CHASSIS (9700)

ELECTRICAL CIRCUIT DIAGRAM

FUEL GAUGE INPUT CIRCUIT (SINGLE TANK) DIFFERENTIAL LOCK WARNING LAMPS

SENSOR RESISTANCE FULL - 29 TO 37 OHMS EMPTY - 234 TO 246 OHMS

J9G

18GY

B11

N49A 18GY

N49B 18GY

DASH/CENTER CHASSIS (9700)

N36A 18TN

N9B 18GY

N36 18TN

N9A 18GY

8

9 N49-G 18WH

7

CENTER/REAR CHASSIS (9800)

A B

R10-GB 18WH

N9 18GY

C12

C6

D1

C10

D8

N10-G 14WH

CHASSIS GND SPLICE PAC K (8803)

CHAPTER 7

RIGHT FUEL SENDER (9101)

LEFT FUEL SENDER (9100)

R49-G 18WH

R49 18GY

R49A 18GY

R49-GA 18WH

RR AXLE DIFF LOCK (9815)

A

B

A

F REAR AXLE DIFF LOCK (9814)

DATE CHANGE

Figure 58 Fuel Gauge Input Circuit (Si ngle Tank) Differential Lock Warning Lamps

REFERENCECHK

REV

PRODUCTION RELEASE. A P54304UPEC 16JAN01

DRAWN

U00JXP9

RELEASE NO.

P52778H

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

10AUG00

s08

PART NO. SHEET

285

08AE08-52371

4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

59

ELECTRICAL CIRCUIT DIAGRAMS

7.9. GAUGES AND WARNING LIGHTS — FUEL FILTER RESTRICTION AND WATER IN FUEL LIGHTS, P. 9

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

MAXIFUSE BLOCK (4000)

J14F

8RD

J14M 10RD

MINI FUSE

F2-E3 F2-G3

BLOCK

(4001)

20A

F2-H3

IGNITION SPLICE (4840)

J13AS 18PK

J19 16GY

FUEL HEATER RELAY (4002)

M1-J4

M1-J3

M1-H3

SYSTEM CONTROLLER (1600)

86

87

87A

J19A 16GY

11

85

30

ELECTRICAL CIRCUIT DIAGRAM

GAUGES & WARNING LIGHTS FUEL FILTER RESTRICTION-WATER IN FUE L LIGH TS

GND

M1-G3

M1-G4

J19-G 18WH

J19E 16GY

J19D 18GY

(4006)

WIF MODULE (4040)

A

B

C

D

WIF MODULE

CHAPTER 7

J19C

18GY

FRAME MOUNTED

J19C

WITH FILTER ON V8-AVNT ENGINE

DATE CHANGE

PEC 16JAN01

ENGINE/DASH (4103)

FUEL FILTER (6708)

REFERENCECHK

REV

PRODUCTION RELEASE. A P54304U

16

K19B

16GY

DRAWN

U00DAG9

RELEASE NO.

P52778H

24

K19C

16GY

21

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

22JUN0009AE08-52371

NAME

DATE

AUX FWD CHASSIS CONN (4305)

FUEL HEATER (4042)

J19A

E D

M19A

16GY

A

PART NO. SHEET

16GY

18GY

M19C

18GY

WATER

A

PROBE (4043)

Figure 59 Gauges and Warning Lights — Fuel Filter Restriction and Water in Fuel Lights

s08

285

60 4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

7.10. GAUGES AND WARNING LIGHTS — PAR K BRAKE LIGHT AND TRANSM ISSION OIL TEMP. GAUGE, P. 10

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

W/AIR BRAKES W/HYDRAULIC BRAKES

AIR PARK BRAKE (1813)

DCM CONN (1800)

SYSTEM CONTROLLER (1600)

B7

32

B44BB

18GY

A44BB

20GY

DC

B9VD

18GY

B9V

18GY

A9V

18GY

A9H

20GY

3 A4

ELECTRICAL CIRCUIT DIAGRAM

GAUGES & WARNING LIGHTS PARK BRAKE LIGHT-XMSN OIL TEMP GAUGE

DCM CONN (1800)

SYSTEM CONTROLLER (1600)

B7

32

A

18WH

B44BB

18GY

A44BB

20GY

CHAPTER 7

B

A4

3

MANUAL PARK BRAKE (1815)

18BK

B9V

18GY

A9V

18GY

A9H

20GY

W/MANUAL TRANSMISSION

TRANS OIL TEMP (7700M)

3

26

SYSTEM CONTROLLER (4004)

DATE CHANGE

PRODUCTION RELEASE. A P54304UPEC 16JAN01

J9A 18GY

ZERO VOLT REF GROUND SPLICE (4830)

REV

J31 18TN

J9X 18GY

REFERENCECHK

DRAWN

U00JXP9

RELEASE NO.

P52778H

E

G

XMSN/DASH CONN (4705)

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

10AUG0010AE08-52371

L31B 18TN

L31GB 18WH

PART NO. SHEET

A

B

Figure 60 Gauges and Warning Lights — Park Brake Light and Transmission Oil Temp. Gauge

285

s08

4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

7.11. GAUGES AND WARNING L IGHTS — AMMETER, P. 11

61

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

(4087)

7

J5R(+) 20YL

8

J5R(-) 20GN

PAM MODULE

9

20SHLD

1

6

J26D 18TN

12

J11-GPP 18WH

10

J26B 18TN

11

J26A 18TN

F2-D3

ENGINE/ DASH (4103)

MINI-FUSE BLOCK (4001)

5A

23 22

SEE CH02_07 SEE CH02_07 SEE CH02_07

F2-C3

J14M 10RD

F2-E3

GND (4005)

K26B 18TN

K26A 18TN

ELECTRICAL CIRCUIT DIAGRAM

GAUGES & WARNING LIGHTS-AMMETER

DRIVETRAIN J1939 DATALINK

J14F 8RD

AMMETER (6332)

AMMETER (6333)

AMMETER

N26B 14TN

K26A 10TN

(9262)

A

N26B 10TN

STARTER GROUND STUD

A

CHAPTER 7

MAXIFUSE BLOCK (4000)

BATTERY NEGATIVE POST

SEE CH02_03

Figure 61 Gauges and Warning L ights — Ammeter

DATE CHANGE

PRODUCTION RELEASE. A P54304UPEC 16JAN01

REV

REFERENCECHK

DRAWN

U00JXP9

RELEASE NO.

P52778H

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

10AUG0011AE08-52371

s08

PART NO. SHEET

285

62 4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

8. LIGHTS (CHA PTER 8)

8.1. BACK UP LIGHTS, P. 1

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRI C TED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION .

FROM PRIMARY IGNITION RELAY

SEE CH02_14

J13S

14PK

TRANS/ DASH (4705)

F1-A1 10A F1-B1

J71

18OR

L71B

16OR

AB

BACKUP LIGHT SWITCH (7500)

AB

L71C

16OR

F1-E1

MINI - FUSE BLOCK (4001)

F1-F1

J71AA 18OR

DASH/ CHASSIS (9700)

ELECTRICAL CIRCUIT DIAGRAM

BACKUP LIGHTS W/MANUAL XMSN

BACKUP T/S SPLICE (4810)

J71A

18OR

J11-GA 14WH

C6A4

N10-G

14WH

N71

14OR

A B

CHAPTER 8

J11-GJ 10WH

CHASSIS GND SPLICE PACK (8803)

CAB GND (4006)

DATE CHANGE

PEC 16JAN01

PRODUCTION RELEASE. A P54304U

Figure 62 Back Up Lights

REV

CENTER/REAR CHASSIS (9800)

STOP TAIL & TURN (9303)

REFERENCECHK

1

R71

A

DRAWN

U00JXP9

RELEASE NO.

P52778H

N10-GA

12WH

12

R10-G

12WH

14OR

LEFT TAIL LIGHT (71)

E

A

S71C 14LTBL

E E

S10-GC 14WH

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

10AUG0001AE08-52372

285

s08

RIGHT TAIL LIGHT (72)

A

PART NO. SHEET

4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

8.2. LIGHT SYSTEMS — CLEARANCE, MARKER, PARK, TAIL, TURN AND STOP LAMPS, P. 2

63

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRICTED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION.

HEADLIGHT SWITCH IS PART OF GAUGE CLUSTER SEE CHAPTER 7 FOR CLUSTER WIRING.

LEFT FENDER MARKER & TURN LIGHT

SYSTEM CONTROLLER (4007)

SYSTEM CONTROLLER BLUE (4008)

TURN

PARK

LEFT GUIDE POST LIGHT (8150)

A B

POST LIGHT

BACKUP LIGHT T/S SPLICE (4810 ) (LEFT TURN)

C H B

B C

COMBINATION STOP/TURN (4830) (LEFT)

M58H 16BN

M58-GA 16WH

J56AA 16OR

J58A 14BN

J57AA 16OR

J57J 16OR

J56J 16OR

E

M58C

14BN

M56B

16OR

M58B

14BN

J56A

16OR

J58AA

14BN

J56B

16OR

J68B

14BN

N68

14BN

N56

14OR

BD

M11-GB

14WH

GROUND ADAPTER #1

M11-G

12WH

(8800)

1312119

J11-G

12WH

J11-GJ 10WH

J71A

J11-GA

14WH C6B7A5

N10-G

14WH

N71

ELECTRICAL CIRCUIT DIAGRAM

LIGHT SYSTEMS - CLEARANCE, MARKER, PARK, TAIL, TURN, & STOP LAMPS

LEFT FRONT MARKER & TURN LIGHT

LEFT HEADLIGHT T/S HARNESS (8001)

GND (4006)

COMBINATION STOP/TURN (4830) (RIGHT)

J57B

16OR

18OR

A4

B6

CHASSIS GND SPLICE PACK

N57

14OR

(8803)

M11-GD 12WH

CENTER CHASSIS (9700)

J57A

B

GROUND ADAPTER #2 (8801)

FORWARD CHASSIS (4301)

16OR

BACKUP LIGHT T/S SPLICE (4810 ) (RIGHT TURN)

BACKUP LIGHT T/S SPLICE (4810) (BACKUP)

CHAPTER 8

RIGHT FRONT MARKER & TURN LIGHT

RIGHT FENDER MARKER & TURN LIGHT

D

E

RIGHT HEADLIGHT T/S HARNESS (8000)

M58D

14BN

M57B

16OR

M11-GA

14WH

A

M58J 16BN

M58-GB 16WH

RIGHT GUIDE POST LIGHT (8151)

B

POST LIGHT

CHK

Figure 63 Light Systems — Clearance, Marker, Park, Tail, Turn and Stop Lamps

LEFT TAIL LIGHT (71)

DATE CHANGE

PRODUCTION RELEASE. A P54304UPEC 16JAN01

REAR/CENTER CHASSIS (9800)

STOP TAIL AND TURN (9303)

TAIL

TURN/ STOP

REV

N10-GA

2

R68

14BN

R56

14OR

REFERENCE

12WH

112 34

R71

14OR

R10-G

12WH

ABCDE

DRAWN

U00JXP9

RELEASE NO.

52778H

R57

14OR

S57B 14LTGN

C B E A

BACK UP

C S68C 14BN

B S10-GC 14WH

E S71C 14LTBL

A

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

22AUG00

s08

PART NO.

AE08-52372

285

RIGHT TAIL LIGHT (72)

SHEET

02

64 4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

8.3. LIGHT SYSTEMS — CLEARANCE, MARKER, PARK, TAIL, TURN AND STOP LAMPS (CONT.), P. 3

Figure 64 Light Systems — Clearance, Marker, Park, Tail, Turn and Stop Lamps (Cont.)

s08

285

4200, 4300, 4400 SERIES Built October 16, 2000 to December 31, 2001 —

WADLCO. USO PERSONAL

ELECTRICAL CIRCUIT DIAGRAMS

8.4. LIGHT SYSTEMS — TUR N SIGNAL AND STOP SWITCHES, P. 4

65

INTERNATIONAL TRUCK AND ENGINE CORPORATION

THIS PRINT IS PROVIDED ON A RESTRICTED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF INTERNATIONAL TRUCK AND ENGINE CORPORATION.

LEFT

RIGHT

TURN

TURN SIGNAL

SWITCH (1810)

DCM CONN (1800)

HAZARD

1 7

2

B56A

18OR

A2A1

B57A

18OR

B9S

18GY

6.8V

150

STOP LIGHT (1814)

AB

W/HYD BRAKES

ELECTRICAL CIRCUIT DIAGRAM

LIGHT SYSTEMS - TURN SIGNAL & STOP SWITCHES

150

6.8V

B9VG

B9V

A

18GY

B70CA

18OR

18GY

B70C

18OR

B9A4

B9VF 18GY

B70C 18RD

B

STOP LIGHT LIGHT #1 (1823)

B9VH 18GY

B70CB 18OR

CHAPTER 8

B

A

STOP LIGHT #2 (1824)

W/AIR

BRAKES

6.8V 150

A9V

18GY

A70C

A9H

20GY

33

DRAWN

U00JXP9

RELEASE NO.

P52778H

20RD

SYSTEM CONTROLLER (1600)

NOTE: ONLY ONE STOP LIGHT SWITCH

USED W/AIR BRAKES, W/TRACTOR

NAME

42/43/44/85/8600 & 73/74/7500 CIRC DIAGRAMS

DATE

10AUG0004AE08-52372

PART NO. SHEET

DATE CHANGE

PEC 16JAN01

PRODUCTION RELEASE.

A57A

A56A

20OR

19

18

REFERENCECHK

REV

A P54304U

20OR

3

Figure 65 Light Systems — Turn Signal and Stop Switches

285

s08