Inter-m V-3000, V-4000 Service Manual

Download

SERVICE

MANUAL

V -3000/4000

moc.m

-retni.ww

EROK NI EDAM

PROFESSIONAL POWER

AMPLIFIER

ELECTRICAL ADJUSTMENT PROCEDURE

 REQUIRED TEST EQUIPMENT

1. Oscilloscope

2. 1kHz audio sine wave generator

3. Digital multimeter

4. 8ohm resistive load (rated for at least 750W)

 IDLE CURRENT (V-3000/4000)

1. Setting Set the master volume controls minimum.

2. Connection

3. Adjustment a. Measure the DC voltage across the resistor R155 and R272. adjust VR101 and VR201. b. Adjust VR101 until the DC voltage is within the range as below table. c. Repeat the adjustment(a,b) for the other channel.

;ΠΕΖΝ ͵ʹΧΠΝΥΒΘΖΣΒΟΘΖ ͲΕΛΦΤΥ

· Ξ·ρΞ·

·  Ξ·ρΞ·

ʹΙΒΟΟΖΝ͵ʹΧΠΝΥΒΘΖΒΔΣΠΤΤ΃ԽΒΕΛΦΤΥ·΃ ʹΙΒΟΟΖΝ͵ʹΧΠΝΥΒΘΖΒΔΣΠΤΤ΃ԽΒΕΛΦΤΥ·΃

Electrical Adjustment Procedure Specifications Electrical Parts List Top and Bottom View of P.C.Board Wiring Diagram Block Diagram Schematic Diagram

1 2 3~8 9~14 15 16 17~26

· · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · ·

· · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · ·

CONTENTS

2 3

SPECIFICATIONSSPECIFICATIONS

ELECTRICAL PARTS LIST (V-3000)ELECTRICAL PARTS LIST (V-3000)

Rated Output Power STEREO

BRIDGED

Input Sensitivity Rated Power @4Ω Rated Power @8Ω Voltage Gain @4Ω

Damping Factor 1KHz @8Ω T.H.D (20Hz~20KHz, 1/10 Power STEREO 4Ω, 8Ω & BRIDGED 8Ω) Channel Seperation 1KHz, Half Power @8Ω Residual Noise Signal to Noise Ratio Output Circuitry Input Impedance High Pass Filter (30Hz/50Hz) Indicators

Cooling

Operating Temperature. Power Source Power Consumption 1/8 Power @4Ω. Weight Dimensions

Frequency Response 1W@8Ω

Protection Circuitry

Connectors

8Ω (1kHz, THD 0.1%) 4Ω (1kHz, THD 0.1%) 2Ω (1kHz, THD 0.5%) 8Ω (1kHz, THD 0.1%) 4Ω (1kHz, THD 0.5%)

230 VAC

550W 1000W 1650W 2000W 3300W

120 VAC

550 W 1000 W 1600 W 2000 W 3200 W

120 VAC

750W 1300W 2000W 2600W 4000W

230 VAC

750W 1300W 2100W 2600W 4200W

0.95 V 1 V

1.05 V

1.15 V

36.8 dB

20 Hz~20 kHz : +0,-0.2 dB

10 Hz~100 kHz : +0,-3 dB

> 400

< 0.05%

more than 70 dB

more than 73dB

105 dB 106 dB

2 Step Class H

12 kΩ Balanced

12dB/OCT

Active, Signal, Prot/Clip

Full Short Circuit, Thermal Protection

Power ON/OFF Muting, DC Output Protection

2 Variable Speed Fans, Front to Rear Air Flow

Input : XLR(Female), 1/4” TRS

Output : 4 Pole Speaker Socket

-10°C +40°C

120VAC/60Hz 230VAC/50Hz 120VAC/60Hz 230VAC/50Hz

12A 6A 14A 7A

11.7 kg/25.8lb 11.8 kg/26lb

482(W) x 88(H) x 407(D)mm/19(W) x 4.6(H) x 16.2(D)in

V-3000 V-4000

AN11,AN12 4355428921 CON ASS'Y,DS,2P,P2.6,P2.6,510MM ASS'Y

AN1 4355429300 CON ASS'Y,DS,1P,P2.6,P2.6,40MM ASS'Y E4-5 1508400501 JUMP WIRE(0.5/52M/M) JUMPER AN5 4355429303 CON ASS'Y,DS,1P,P2.6,P2.6,100MM ASS'Y(120VAC) Q305 2028106960 TR,PW,PNP,3A,100V,TIP32C TIP32C AN9,AN10 4355716121 CON ASS'Y,DS,2P,P2.6,P2.6,510MM ASS'Y Q115-118 2028107118 TR,PW,PNP,15A,230V,2SA1943,TO-3P(L) 2SA1943 AN2 4355791712 CON ASS'Y,DS,1P,P2.6,P2.6,250MM ASS'Y Q219-222 J19 4355795704 CON ASS'Y,DS,1P,250T08,P2.6,110MM ASS'Y Q114 Q218 2028107995 TR,PW,PNP,8A,250V,MJE15033,TO-220 MJE15033 J20 4355833 204 CON ASS'Y,DS,1P,250T08,P2.6,110MM ASS'Y Q125 Q229 2028110941 TR,PW,PNP,1A,230V,2SA1837 2SA1837 CN1 4428592513 CON WAFER,BOX(M),14P,2/ST PC1635-14P Q130-133 2028407122 TR,PW,NPN,15A,230V,2SC5200,TO-3P(L) 2SC5200 CN2 4428592516 CON WAFER,BOX(M),16P,2/ST PC1635-16P Q234-237 CN301-302 4428595003 CON WAFER,BOX(M),3P,ST LW5267-03P Q129 Q233 2028407995 TR,PW,NPN,8A,250V,MJE15032,TO-220 MJE15032 CN3-4 4465998210 TERMINAL(250)PCB TAB 250T Q120 Q224 2028410884 TR,PW,NPN,1A,230V,2SC4793,TO-220IS 2SC4793 RL1 552800985 1 RELAY AZ2151-1C-24DE ZETTLER DC 24V Q1-2 2028900101 TR,IGBT,JF N,27A,600V,IRG4PC50 IRG4PC50W HS301 750529931 0 HEAT SINK(30MM) REG TR Heat sink

Q110 Q137 Q214

2048247900 TR,PW,MF N,60A,60V,NTP60N06G,TO-220 NTP60N06 LIM101 LIM201 8545993380 LED LIMITER LED LIMITER Q241 Q124 Q228 2008005998-T TR,SG,PNP,200MA,40V,2N3906 2N3906 D114 D119 D215 2058100106 DIODE,RE,3A,400V,1N54 04,DO-201A 1N5404 Q121 Q225 2008405998-T TR,SW,NPN,200MA,40V,2N3904 2N3904 D219 R113 R216 3022165455-T RES,MF,16.5K,1W,1%,RA A,TA 16.5K 1W 1% BD1 2058199100 DIODE,BR,50A,600V,RBV5006 ,RBV25 RBV5006 R3-4 3029303575-T RES,MF,30K,2W,5%,RA A,TA 30K 2W D20-23 2058300995 DIODE,RE,15A,400V,MUR1540,TO-2 MUR 1540 R158 R160-162 3039150575-T RES,MF,15,2W,5%,RA R,TA 15 2W D113 D120 D214 2058300996 DIODE,RE,15A,200V,MUR1520 ,TO-220AC MUR 1520 R274 R276-278 D220 R353 3039151575-T RES,MF,150,2W,5%,RA R,TA 150 2W D18-19 D24-25 2058499700

DIODE,SW,30A,400V,DSEP30-04A,TO-247AD

DSEP30-04A R348 3039159575-T RES,MF,1.5,2W,5%,RA R,TA 1.5 2W

D2-3 20584998 00

DIODE,SW,4A,400V,MUR440,DO-201AD

MUR440 R6-8 R157 R159 3039569575-T RES,MF,5.6,2W,5%,RA R,TA 5.6 2W D105 D206 2058502039 DIODE,ZN,500MW,BM,3.9V,DO-35,T 3.9BM R200 R275 D313 205850 2240 DIODE,ZN,500MW,BM,24V,DO-35,TA 24BM VR101 VR201 3248550120-T RES SEMI FT-63 TP(500) 500 D307-310 2058510150 DIODE,ZN,1W,BM,15V,DO-41,TA 15BM C24 3409210039-T CAP,EC,SM,WB,10UF,16V,M,5X11,T 100/16 D311 205851 2150 DIODE,ZN,1W,BM,12V,DO-41,TA 12V 1W C30 C43 C111 3409210062-T CAP,E,SM,SS,85C,10UF,35V,M 10/35 D106 D207 2058512190 DIODE,ZN,1W,BM,10V,DO-41,TA 10V 1W C212 C312 U101 U201 2118013377 IC,OP AMP,NE5532P,DIP8 5532N C40-42 C69 C71 3409210140-T CAP,EC,SM,WB,100UF,25V,M 100/25 U2 2118031800 IC,PWM CONT,SG3525AN,DIP16 SG3525AN C73 U1 2128220089 IC,DRIVER,IR2110,DIP14P,IR IR2110

C108 C113 C208

3409210141-T CAP,E,SM,SG,85C,100UF,25V,M 100/25 U5 2128660000 IC,PWM SW,TOP210,DIP08P TOP210 C213 C316-318 PC1-2 2408000980 PHOTO COUPLER,1U,CNY17F-1,ON S CNY17F-1 C321 TH1 2438200960 THERMIST,NTC,20A,10OHM,85C,HJ NTC-10

C103 C206 C310

3409210971-T CAP,E,SM,SG,85C,1UF,50V,M 1/50 TH101 TH201 2438200970 KCL103F414F L,NTC,10K KCL103F

C114 C123 C214

3409222033-T CAP,E,SM,SE,85C,22UF,16V,M 22/16 L101 L201 2648099800 COIL,AIR,2.2UH 2.2 uH C223 L3-8 2648609800 COIL,FER,RADIAL,6UH 6uH C46 3409233147-T CAP,E,SM,SD,85C,330uF,25V,M 330/25 L9 2648699510 COIL,FER,TOROID,1.9UH,20A 1.9UH C314 3409247071-T CAP,E,SM,SG,85C,47UF,50V,M 47/50 L1-2 2648699520 COIL,FER,TOROID,2.2MH,20A 2mH C301 -306 3409247147-T CAP,E,SM,SD,85C,470UF,25V,M 470/25 T2 2828053800 TRANS,PW,SMPS,Q-3300 TRANS C32 3409710070-T CAP,E,NP,NP,85C,10UF,50V,M 10/50 NP T1 2828053900 TRANS,PW,SMPS,EE,Q-3300/4300 TRANS

C102 C202 C308

3409847041-T CAP,E,NP,NP,85C,47UF,25V,M 47/25 NP R1-2 3027503660 RES,MF,750K,1/2W,5%,AX M 750K 1/2W C106 C204 35291502 10-T CAP,CE,TEMP,NPO,15PF,50V,J,RA 15 P R50 R142 R171 3029150572 RES,MF,15,2W,5%,AX M 15 2W C120 C220 3609 223120-T CAP,FILM,POLYESTR,0.022UF,100V 0.0 22/100(M) R258 R288 C15 3609332120-T CAP,FILM,POLYESTR,0.0033UF,100V 0.0033/100(M) R153 R182 R269 3029159572 RES,MF,1.5,2W,5%,AX M 1.5 2W TP101 TP201 4225000810-T TERMINAL,PIN,TEST,1P,TA TP R299 Q123 Q227 S20110402001 TR,SG,PNP,500MA,300V,KST92,SOT KST92 R143-150 3029478572 RES,MF,0.47,2W,5%,AX M 0.47 2W Q122 Q226 S20 160402009 TR,SG,NPN,500MA,30 0V,KST42MTF, KST42MTF R172-179 Q3-4 Q7 Q101 S205 10405004

TR,SG,PNP,200MA,40V,2N3906S,SOT-23,TA

2N3906S

R259-266

Q104 Q106 Q109 R289-296 Q111-112 Q128 R341-342 3032701960 RES,MO,2.7K,3W,5%,AX P 2.7K 3W Q136 Q202-205 R340 3039331673 RES,MO,330,3W,5%,AX N 330 3W

Q208 Q210 Q213 R354-355 3039471674 RES,MO,470,3W,5%,AX P 470 3W Q215-21 6 Q232 R5 3039560673 RES,MO,56,3W,5%,AX N 56 3W Q240 Q301-302 R349-350 3039681674 RES,MO,680,3W,5%,AX P 680 3W Q5-6 Q8 S20560448002

TR,SG,NPN,200MA,40V,MMBT3904,SOT-23,TA

2N3904 R351-352 3039821674 RES,MO,820,3W,5%,AX N 820 3W Q102-103 Q105 R132-133 3039822674 RES,MO,8.2K,3W,5%,AX N 8.2K 3W Q107-108 Q113 R248-249 Q126-127 Q135 R347 Q201 Q206-207 C49-53 C64-68 34092 47189 CAP,E,SM,WB,470UF,63V,M,16X20 470/63 Q209 Q211-212 C54-63 3409247199 CAP,EC,SM,WB,470UF,100V,M,18X40 470/100 Q217 Q230-231 C7-12 3419033205 CAP,EC,LA,LS,3300UF,200V,M,35X70 3300/200 Q239 Q303-304 C2-3 C13 C39 3549222091 CAP,CE,AC,Y2/X1,2200PF,250VAC 2200P250 U4 S21101142601 IC,OP AMP,LM339,SOP14 LM339MX C74 U102 S211011 67701 IC,OP AMP,NJM13600M,DMP 16 NJM13600M C70 C72 C116 3630104500 CAP,FILM,M-POLYESTR,0.1UF,250V 0.1/250(M) U301 S21102084801 IC,COMP,LM393,SOP08 L M393D C121 C125 C216 U103-104 S21102087701 IC,COMP,LM311,DMP8 LM311D C221 C225 C315 U202-203 C320 U3 S21283142601 IC,TIMER,LM556CM,SOP14 LM556CM C16 C31 C319 3639104600 CAP,FILM,M-POLYESTR,0.1UF,400V,K 0.1/400(M) D1 D4-5 D7 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 C6 3649104251 CAP,FILM,AC,X2,0.1UF,250VAC,K 0.1/250 D10-13 D15-17 C47 3659101179 CAP,FILM,MICA,100PF,500V,J 100P500 D1 01-104 C17-18 3659331179 CAP,FILM,MICA,330PF,63V,J 330P500 D107-112 C1 C4 3669105208 CAP,FILM,M-POLYPRPN,1UF,275V 1/275(M) D115-118 D121 C5 3669474208 CAP,FILM,M-POLYPRPN,0.47UF,275V 0.47/275(M) D201-205 C14 3670474600 CAP,FILM,M-POLYPRPN,0.47UF,400V,J 0.47/4 00(M) D208-213

AMP B'D (40 000 066 00 )

Ref. Part N o. Description Va lue Ref. Part N o. Description Value

4 5

Ref. Pa rt No. D escription Value Ref. Part N o. Description Value

D216-218 R124 R126 R134 D221-222 R166 R188-189 D301-305 D312 R203 R240 R242 D6 D8 D30 S2250104800 1 DIODE MURS160T3 MOTOROLA MUR160T3 R251 R282 R303 D9 D26-29 S22501448001

DIODE,SW,1A,600V,MURS120TS,DO-214AA,TA

MURS120T3 R305 D306 S22620620010 DIODE,ZN,350MW,BM,6.2V,BZX84C6 6.2V R115 R128 R190 S30135905230 RES,TF,5.9K,1/10W,1%,2012 5.9K 1% D14 S226 21100010 DIODE,ZN,350MW,BM,10V,BZX84C10 10V R215 R244 R308 R97-98 R163 S30101017 231 RES,TF,100,1/10W,5%,2012 100 R343 S30139095331 RES,TF,9.09K,1/8W,1%,2012 9.09K 1% R193 R220-221 R11 R18 S30 141005230 RES,TF,100,1/10W,1%,2012 100 1% R270 R279 R109 R230 R313 S30143835331 RES,TF,383,1/8W,1%,2012 383 1% R108 R204-205 S30101027340 RES,TF,1K,1/8W,5%,3216 1K R316 R229 R320 R324 R101 R117 R219 S30144755230 RES,TF,475,1/10W,1%,2012 475 1% R326 R236 R106 R206 R228 S30101047231 RES,TF,100K,1/10W,5%,2012 100K R17 R33 R114 S30145365331 RES,TF,536,1/8W,1%,2012 536 1% R335 S30101237231 RES,TF,12K,1/10W,5%,2012 12K R214 R102-105 R112 S30101527231 RES,TF,1.5K,1/10W,5%,2012 1.5K R325 S30146345440 RES TF 634F 1/4W 3216 634 1% R118-119 R213 R38 S30151005230 RES,TF,10,1/10W,1%,2012 10 1% R224-227 R34 R51 S30153925441 RES,TF,39.2,1/4W,1%,3216 39.2 1% R232-233 R311-312 R338-339 R314-315 R120 R235 S30101537231 RES,TF,15K,1/10W,5%,2012 15K R131 R192 R247 S30154755230 RES,TF,47.5,1/10W,1%,2012 47.5 1% R19-20 R43 R45 S30101547340 RES,TF,150K,1/8W,5%,3216 150K R310 R47 R123 R125 R9-10 R35 S30301005440 RES,MF,10,1/4W,1%,3216,TA 10 1% R184-185 R239 R16 S30337875330 RES MF 7.87K F 2012 7.87K R241 R302 R304 R137 R167 R253 S30342745330 RES,MF,274,1/8W,1%,2012,TA 274 1% R141 R170 R257 S30102017231 RES,TF,200,1/10W,5%,2012 200 R283 R287 C107 C203 S351010043 30 CAP,CE,MONO,COG,10PF ,50V,J,2012 10P R122 R238 R333 S30102027231 RES,TF,2K,1/10W,5%,2012 2K C1 01 C109 C201 S35101014331 CAP,CE,MONO,COG,100PF,50V,J,2012 100P R99 R222 R318 S30102037231 RES,TF,20K,1/10W,5%,2012 20K C209 R321 R327-328 C29 C45 C309 S35101024344 CAP,CE,MONO,X7R,1000PF,50V,5% 1000pF R332 C311 C313 R52 S30102737231 RES,TF,27K,1/10W,5%,2012 27K C19-23 C26 C38 S35101044344 CAP,CE,MONO,X7R,0.1UF,50V,K,3216 0.1U R155-156 S30107507231 RES,TF,75,1/10W,5%,2012 75 C44 C104 C117 R272-273

C122 C127 C207

R111 R207-209 S30107527230 RES TF 7.5K J 1/10W 2012 7.5K

C217 C222 C227 R217 C307 R36-37 R136 S30111045 440 RES,TF,100K,1/4W,1%,3216 100K C33-35 C110 S3510272 5434 CAP,CE,MONO,X7R,2700PF ,100V 2700P R139 R164 R195

C115 C124 C210 R250 R255 R280 C215 C224 R285 R337

C112 C126 C128

S35104704331 CAP,CE,MONO,COG,47PF,50V,J,2012 47P

R30 R100 R127 S30113925331 RES,TF,392K,1/8W,1%,2012 392K 1%

C211 C226 C228 R187 R223 R243 C25 C27-28 S35104714344 C AP,CE,MONO,COG,470PF,50V,J,3216 470P R307 R336 R345

C36-37 C48 C105 R23-24 R27-28 S30 114875441 RES,TF,487K,1/4W,1%,3216 487K 1%

C119 C205 C219 R14-15 R31-32 S30 121005230 RES,TF,10K,1/10W,1%,2012 10K 1% C118 C218 S35106815331 CAP,CE,MONO,COG,680PF,50V,J,2012 680P R42 R46 R22 R44 R92-93 S30121275230 RES,TF,12.7K,1/10W,1%,2012 12.7K 1% R95 R107 R116 ZD401-402 205850 2024 DIODE,ZN,500MW,BM,2.4V,DO-35,T 2.4BM R121 R130 R154 LD401 LD407 230003010 0 LED,RND 3.1MM,RED,DIF,1U,ST2.5 LTL-1CHE R201-202

LD402-406 LD408

2300032100 LED,RND 3.1MM,GRN,DIF,1U,ST2.5 LTL-1CHG

R211-212 VR401-402 32 28066600

VR,ROT,VER,1U,L15,10K,B,RV16ADO-41-15F

10KB

R234 R237 R246 AN402 4355429120

CON ASS'Y,RB,16P,IDC2.54,DIP2.54,480MM

ASS'Y-16P R271 R322-323 LIM1-8 8545993340 LED LIMITER LED LIMITER R344 C402 C404 34092100 23-T CAP,E,SM,SE,85C,10UF,50V,M 10/50 R12 S30121505230 RES TF 15K F 1/10W 2012 15K 1% Q401-402 S2051040 5004

TR,SG,PNP,200MA,40V,2N3906S,SOT-23,TA

2N3906S R41 S30122005230 RES,TF,20K,1/10W,1%,2012 20K 1% Q404-405 R26 S30122495331 RES,TF,24.9K,1/8W,1%,2012 24.9K 1% Q407-408 R183 R194 S30123325441 RES,TF,33.2K,1/4W,1%,3216 33.2K 1% Q403 Q406 S20560448002

TR,SG,NPN,200MA,40V,MMBT3904,SOT-23,TA

2N3904 R300-301 D401-404 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 R25 R29 R96 S30123925331 RES,TF,39.2K,1/8W,1%,2012 39 .2K 1% R402 R405 S30101027340 RES,TF,1K,1/8W,5%,3216 1K R135 R140 R165 R401 R403-404 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% R169 R218 R252 R406 R256 R281 R286 C401 C403 S35104714344 CAP,CE,MONO,COG,470PF,50V,J,3216 470P R319 R346 R186 R306 S30124755331 RES,TF,47.5K,1/8W,1%,2012 47.5K 1% R39 S30131005230 RES,TF,1K,1/10W,1%,2012 1K 1% C601-602 3630104500 CAP,FILM,M-POLYESTR,0.1UF,250V 0.1/250(M) R334 S30131745331 RES,TF,1.74K,1/8W,1%,2012 1.74K 1% JK603-60 4 4430001200 JACK,SPEAKON,1U,4P,ST,FC60112 4P R48-49 R110 S30132215 331 RES,TF,2.21K,1/8W,1%,2012 2.21K 1% R138 R168 R191 R210 R231 R254 AN501 4355429008 CON ASS'Y,RB,14P,IDC2.54,DIP2.54,170MM ASS'Y-14P R284 R309 R317 JK402 JK404 4438192910 JACK,PHONE,1U,5P,ST PHONE R329-331 JK401 JK 403 4438193810 JACK,XLR(F),1U,3P,ST XLR(F) R94 R129 R245 S30133015230 RES,TF,3.01K,1/10W,1%,2012 3.01K 1% SW501 SW503 4618499310 SW SLIDE SS84017-0403-5.3T-FN SS84017 R864 SW506 R13 R21 R40 R91 S3013475 5331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% SW504-505 4628991710 SW,PUSH,VER,DPDT,NS,1U,L12.5 SPEC122SC011

VR B'D (40 000 066 10)

O UTPUT B'D (4 000 006 62 0)

INPU T B'D (400 000 690 0)

Ref. Pa rt No. D escription Value

BK501 6505955520 PCB BKT MX-400 BRACKET C521-522 34092 10071-T CAP,E,SM,SG,85C,10UF,50V,M 10/50 C503 C508 C511 3409847041-T CAP,E,NP,NP,85C,47UF,25V,M 47/25 NP C516 C505 C513 36096831 20-T CAP,FILM,POLYESTR,0.068UF,100V 0.068/100 C507 C515 36392241 88-T CAP,FILM,M-POLYESTR,0.22UF,63V 0.22/63(M) C506 C514 36394731 88-T CAP,FILM,M-POLYESTR,0.047UF,63V 0.047/63(M) U501-504 S21101087701 IC,OP AMP,NE5532A,SOP8 NE5532A D501-504 S22 400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 R531-532 S30100007230 RES,TF,0,1/10W,5%(J),2012 0 R505 R518 S30101037231 RES,TF,10K,1/10W,5%,2012 10K R506 R519 S30101047231 RES,TF,100K,1/10W,5%,2012 100K R512 R525 S30102037231 RES,TF,20K,1/10W,5%,2012 20K R527-530 S30107507231 RES,TF,75,1/10W,5%,2012 75 R507 R513 R520 S30107527230 RES TF 7.5K J 1/10W 2012 7.5K R526 R508 R521 S30121375230 RES,TF,13.7K,1/10W,1%,2012 13.7K 1% R511 R524 S30124755331 RES,TF,47.5K,1/8W,1%,2012 47.5K 1% R509 R522 S30133655230 RES,TF,3.65K,1/10W,1%,2012 3.65K 1% R510 R523 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% R501-504 S30135605230 RES,TF,5.6K,1/10W,1%,2012 5.6K 1% R514-517 C501-502 S351010 14331 CAP,CE,MONO,COG,10 0PF,50V,J,2012 100P C509-510 C523-524 S351010 45331 CAP,CE,MONO,X7R,0.1UF,50V,Z,20 12 0.1U C504 C512 S351022043 39 CAP,CE,MONO,COG,22PF ,50V,J,2012 22P C517-520 S351047 14330 CAP,CE,MONO,COG,47 0PF,50V,J,2012 470P

AC CORD 4308997410 AC POWER CORD (16A/250V) 230VAC AC CORD 4308997610 AC POWER CORD (15A/125V) 120VAC AC INLET 4448597210 AC INLET 3P 2.0T 16A/20 A 4793 CONNECTOR 4355429504 CON ASS'Y,DS,1P,R5.3,250T08,110MM CONNECTOR 4355429510 CON ASS'Y,DS,1P,R5.3,250T08,210MM CONNECTOR 4355810803 CON ASS'Y,DS,1P,250T08,ST4.2,100MM FAN 1,2 7308997510 DC FAN(3110KL-05W-B70-F04) SW 4648099810

SW,POWER,18A,250V,AJ1-B0-44-618-5C2-D

230VAC

SW 4648099920 SW POWER AJ1-B0-44-635-5C2-C 120VAC

ASS'Y

6 7

ELECTRICAL PARTS LIST (V-4000)ELECTRICAL PARTS LIST (V-4000)

Ref. Pa rt No. D escription Value Ref. Pa rt No. D escription Value

AN11,AN12 4355428921 CON ASS'Y,DS,2P,P2.6,P2.6,510MM ASS'Y

AN1 4355429300 CON ASS'Y,DS,1P,P2.6,P2.6,40MM ASS'Y E4-5 1508400501 JUMP WIRE(0.5/52M/M) JUMPER AN5 4355429303 CON ASS'Y,DS,1P,P2.6,P2.6,100MM ASS'Y(120VAC) Q305 2028106960 TR,PW,PNP,3A,100V,TIP32C TIP32C AN9,AN10 435571612 1 CON ASS'Y,DS,2P,P2.6,P2.6,510MM ASS'Y Q115-119 2028107118 TR,PW,PNP,15A,230V,2SA1943,TO-3P(L) 2SA1943 AN2 43557917 12 CON ASS'Y,DS,1P,P2.6,P2.6,250MM ASS'Y Q219-223 J19 4355795704 CON ASS'Y,DS,1P,250T08,P2.6,110MM ASS'Y Q114 Q218 2028107995 TR,PW,PNP,8A,250V,MJE15033,TO-220 MJE15033 J20 4355 833204 CON ASS'Y,DS,1P,250T08,P2.6,110MM ASS'Y Q125 229 2028110941 TR,PW,PNP,1A,230V,2SA183 7 2SA1837 CN1 4428592513 CON WAFER,BOX(M),14P,2/ST PC1635-14P Q130-134 2028407122 TR,PW,NPN,15A,230V,2SC5200,TO-3P(L) 2SC5200 CN2 4428592516 CON WAFER,BOX(M),16P,2/ST PC1635-16P Q234-238 CN301-302 4428595003 CO N WAFER,BOX(M),3P,ST LW5267-03P Q129 Q233 2028407995 TR,PW,NPN,8A,250V,MJE15032,TO-220 MJE15032 CN3-4 4465998210 TERMINAL(250)PCB TAB 250T Q120 Q224 2028410884 TR,PW,NPN,1A,230V,2SC4793,TO-220IS 2SC4793 RL1 55280098 51 RELAY AZ2151-1C-24DE ZETTLER DC 24V Q1-2 2028900101 TR,IGBT,JF N,27A,600V,IRG4PC50 IRG4PC50 W HS301 7505299310 HEAT SINK(30MM) REG TR Heat sink

Q110 Q137 Q214

2048247900 TR,PW,MF N,60A,60V,NTP60N06G,TO-220 NTP60N06 LIM101 LIM201 8545993380 LED LIMITER LED LIMITER Q241 Q124 Q228 2008005998-T TR,SG,PNP,200MA,40V,2N3906 2N3906 D114 D119 D215

2058100106 DIODE,RE,3A,400V,1N5404,DO-201A 1N5404 Q121 Q2 25 2008405998-T TR,SW,NPN,200MA,40V,2N3904 2N3904 D219 R113 R216 3022165455-T RES,MF,16.5K,1W,1%,RA A,TA 16.5K 1W 1% BD1 2 058199100 DIODE,BR,50A,600V,RBV5006,RBV25 RBV5006 R3-4 3029303575-T RES,MF,30K,2W,5%,RA A,TA 30K 2W D20-23 2058300995 DIODE,RE,15A,400V,MUR1540,TO-2 MUR 1540 R158 R160-162 3039150575-T RES,MF,15,2W,5%,RA R,TA 15 2W D113 D120 D214 2058300996 D IODE,RE,15A,200V,MUR1520,TO-220AC MUR 1520 R274 R276-278 D220 R353 3039151575-T RES,MF,150,2W,5%,RA R,TA 150 2W D18-19 D24-25 2058499700

DIODE,SW,30A,400V,DSEP30-04A,TO-247AD

DSEP30-04A R348 3039159575-T RES,MF,1.5,2W,5%,RA R,TA 1.5 2W

D2-3 2058499800

DIODE,SW,4A,400V,MUR440,DO-201AD

MUR440 R6-8 R157 R159 3039569575-T RES,MF,5.6,2W,5%,RA R,TA 5.6 2W D105 D206 20585 02039 DIODE,ZN,500MW,BM,3.9V,DO-35,T 3.9BM R200 R275 D313 2058502240 DIODE,ZN,500MW,BM,24V,DO-35,TA 2 4BM VR101 VR201 3248550120-T RES SEMI FT-63 TP(500) 500 D307-310 20585 10150 DIODE,ZN,1W,BM,15V,DO-41,TA 15BM C24 3409210039-T CAP,EC,SM,WB,10UF,16V,M,5X11,T 100/16 D311 2058512150 DIODE,ZN,1W,BM,12V,DO-41,TA 12V 1W C30 C43 C111 3409210062-T CAP,E,SM,SS,85C,10UF,35V,M 10/35 D106 D207 20585 12190 DIODE,ZN,1W,BM,10V,DO-41,TA 10V 1W C212 C312 U101 U201 211 8013377 IC,OP AMP,NE5532P,DIP8 5532N C40-42 C69 C71 3409210140-T CAP,EC,SM,WB,100UF,25V,M 100/25 U2 2118031800 IC,PWM CONT,SG3525AN,DIP16 SG3525AN C73 U1 2128220089 IC,DRIVER,IR2110,DIP14P,IR IR2110

C108 C113 C208

C103 C206 C310

3409210971-T CAP,E,SM,SG,85C,1UF,50V,M 1/50 TH101 TH201 2438200970 KCL103F414FL,NTC,10K KCL103F

C114 C123 C214

3409222033-T CAP,E,SM,SE,85C,22UF,16V,M 22/16 L101 L201 2648099800 COIL,AIR,2.2UH 2.2 uH C223 L3-8 2648609800 COIL,FER,RADIAL,6UH 6uH C314 3409247071-T CAP,E,SM,SG,85C,47UF,50V,M 47/50 L9 2648699510 COIL,FER,TOROID,1.9UH,20A 1.9UH C46 C301-306 3409247147-T CAP,E,SM,SD,85C,470UF,25V,M 470/25 L1-2 2648699520 COIL,FER,TOROID,2.2MH,20A 2mH C32 3409710070-T CAP,E,NP,NP,85C,10UF,50V,M 10/50 NP T2 2828053700 TRANS,PW,SMPS,Q-4300 TRANS

C102 C202 C308

3409847041-T CAP,E,NP,NP,85C,47UF,25V,M 47/25 NP T1 2828053900 TRANS,PW,SMPS,EE,Q-3300/4300 TRANS C106 C204 35 29150210-T CAP,CE,TEMP,NPO,15PF,50V,J,RA 15P R1-2 3027503660 RES,MF,750K,1/2W,5%,AX M 750K 1/2W C120 C220 3609223120-T CAP,FILM,POLYESTR,0.022UF,100V 0.022/100(M) R50 R142 R171 3029150572 RES,MF,15,2W,5%,AX M 15 2W C15 3609332120-T CAP,FILM,POLYESTR,0.0033UF,100V 0.0033/1 00(M) R258 R288 TP101 TP201 4225000810-T TERMINAL,PIN,TEST,1P,TA TP R153 R182 R269 3029159572 RES,MF,1.5,2W,5%,AX M 1.5 2W Q123 Q227 S20110402001 TR,SG,PNP,500MA,300V,KST92,SOT KST92 R299 Q122 Q226 S20160402009 TR,SG,NPN,500MA,300V,KST42MTF, KST42MTF R143-152 3029478572 RES,MF,0.47,2W,5%,AX M 0.47 2W Q3-4 Q7 Q10 1 S20510405004

TR,SG,PNP,200MA,40V,2N3906S,SOT-23,TA

2N3906S

R172-181

Q104 Q106 Q109 R259-268 Q111-112 Q128 R289-298 Q136 Q202-205 R341-342 3032701960 RES,MO,2.7K,3W,5%,AX P 2.7K 3W

Q208 Q210 Q213 R340 3039331673 RES,MO,330,3W,5%,AX N 330 3W Q215-216 Q232 R354-355 3039471674 RES,MO,470,3W,5%,AX P 470 3W Q240 Q301-302 R5 3039560673 RES,MO,56,3W,5%,AX N 56 3W Q5-6 Q8 S20560448002

TR,SG,NPN,200MA,40V,MMBT3904,SOT-23,TA

2N3904 R349-350 3039681674 RES,MO,680,3W,5%,AX P 680 3W Q102-103 Q105 R351-352 3039821674 RES,MO,820,3W,5%,AX N 820 3W Q107 -108 Q113 R132-133 3039822674 RES,MO,8.2K,3W,5%,AX N 8.2K 3W Q126-127 Q135 R248-249 Q201 Q206-207 R347 Q209 Q211 -212 C49-53 C64-68 340 9247189 CAP,E,SM,WB,470UF,63V,M,16X20 470/6 3 Q217 Q230-231 C54-63 3409247199 CAP,EC,SM,WB,470UF,100V,M,18X40 470/100 Q239 Q303-304 C7-10 3419027205 CAP,EC,LA,LS,2700UF,200V,M,35X70 2700/200 U4 S21101142601 IC,OP AMP,LM339,SOP14 LM339MX C2-3 C13 C39 3549222091 CAP,CE,AC,Y2/X1,2200PF,250VAC 2200P250 U102 S21101167701 IC,OP AMP,NJM13600M,DMP16 NJM13600M C74 U301 S21102084801 IC,COMP,LM393,SOP08 LM393D C70 C72 C116 3630104500 CAP,FILM,M-PO LYESTR,0.1UF,250V 0.1/250(M) U103-104 S21102087 701 IC,COMP,LM311,DMP8 LM311D C121 C125 C216

U202-203

C221 C225 C315

U3 S21283142601 IC,TIMER,LM556CM,SOP14 LM556CM C320 D1 D4-5 D7 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 C16 C31 C319 3639104600 CAP,FILM,M-PO LYESTR,0.1UF,400V,K 0.1/400(M) D10-13 D15-17 C6 3649104251 CAP,FILM,AC,X2,0.1UF,250VAC,K 0.1/250 D101-104 C47 365910117 9 CAP,FILM,MICA,100PF,500V,J 100P500 D107-112 C17-18 3659331179 CAP,FILM,MICA,330PF,63V,J 330P500 D115-118 D121 C1 C4 3669105208 CAP,FILM,M-POLYPRPN,1UF,275V 1 /275(M) D201-205 C5 3669474208 CAP,FILM,M-POLYPRPN,0.47UF,275 V 0.47/275(M) D208-213 C14 367047460 0 CAP,FILM,M-POLYPRPN,0.47UF,400V,J 0.47/400(M) D216-218

AMP B'D (40 000 066 00 )

Ref. Pa rt No. D escription Value Ref. Part N o. Description Value

D221-222 R282 D301-305 D312 R13 R21 R40 R91 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% D6 D8 D30 S22501048001 DIODE MURS160T3 MOTOROLA MUR160T3 R124 R126 D9 D26-29 S22 501448001

DIODE,SW,1A,600V,MURS120TS,DO-214AA,TA

MURS120T3 R188-189 R203 D306 S22620620010 DIODE,ZN,350MW,BM,6.2V,BZX84C6 6.2V R240 R242 R30 3 D14 S226211 00010 DIODE,ZN,350MW,BM,10V,BZX84C1 0 10 V R305 R97-98 R163 S30101017231 RES,TF,100,1/10W,5%,2012 100 R115 R128 R190 S30135905230 RES,TF,5.9K,1/10W,1%,2012 5 .9K 1% R193 R220-221 R215 R244 R308 R270 R279 R343 S30139095331 RES,TF,9.09K,1/8W,1%,2012 9.09K 1% R108 R204-205 S30101027340 RES,TF,1K,1/8W,5%,3216 1K R11 R18 S30141005230 RES,TF,100,1/10W,1%,2012 100 1% R229 R320 R324 R109 R230 R313 S30143835331 RES,TF,383,1/8W,1%,2012 383 1% R326 R316 R106 R206 R228 S30101047231 RES,TF,100K,1/10W,5%,2012 100K R101 R117 R219 S30144755230 RES,TF,475,1/10W,1%,2012 475 1% R335 S30101237231 RES,TF,12K,1/10W,5%,2012 12K R236 R102-105 R112 S30101527231 RES,TF,1.5K,1/10W,5%,2012 1.5K R17 R33 R114 S30145365331 RES,TF,536,1/8W,1%,2012 536 1% R118-119 R213 R214 R224-227 R325 S30146345440 RES TF 634F 1/4W 3216 634 1% R232-233 R38 S30151005230 RES,TF,10,1/10W,1%,2012 10 1% R338-339 R34 R51 S30153925441 RES,TF,39.2,1/4W,1%,3216 39.2 1% R120 R235 S30101537231 RES,TF,15K,1/10W,5%,2012 15K R311-312 R19-20 R43 R45 S30101547340 RES,TF,150K,1/8W,5%,3216 150K R314-315 R47 R123 R125 R131 R192 R247 S30154755230 RES,TF,47.5,1/10W,1%,2012 47.5 1% R136 R164 R310 R184-185 R239 R9-10 R35 S30301005440 RES,MF,10,1/4W,1%,3216,TA 10 1% R241 R250 R280 R16 S30337875330 RES MF 7.87K F 2012 7.87K R302 R304 R137 R167 R253 S30342745330 RES,MF,274,1/8W,1%,2012,TA 274 1% R141 R170 R257 S30102017231 RES,TF,200,1/10W,5%,2012 200 R283 R287 C107 C203 S35101004330 CAP,CE,MONO,COG,10PF,50V,J,2012 10P R122 R238 R333 S30102027231 RES,TF,2K,1/10W,5%,2012 2K

C101 C109 C201

S35101014331 CAP,CE,MONO,COG,100PF,50V,J,2012 100P R99 R222 R318 S30102037231 RES,TF,20K,1/10W,5%,2012 20K C209 R321 R327-328 C29 C45 C309 S35101024344 CAP,CE,MONO,X7R,1000PF,50V,5% 1000pF R332 C311 C313 R155-156 S30107507231 RES,TF,75,1/10W,5%,2012 75 C19-23 C26 C38 S35101044344 CAP,CE,MONO,X7R,0.1UF,50V,K,3216 0.1U R272-273 C44 C104 C117 R111 R207-209 S30107527230 RES TF 7.5K J 1/10W 2012 7.5K

C122 C127 C207

R217

C217 C222 C227 R36-37 R139 S30111045440 RES,TF,100K,1/4W,1%,3216 100K 1% C307 R195 R255 R285 C33-35 C110 S35102725434 CAP,CE,MONO,X7R,2700PF,100V 2 700P R337

C115 C124 C210 R30 R100 R127 S30113925331 RES,TF,392K,1/8W,1%,2012 392K 1% C21 5 C224 R187 R223 R243

C112 C126 C128

S35104704331 CAP,CE,MONO,COG,47PF,50V,J,2012 47P

R307 R336 R345

C211 C226 C228 R23-24 R27-28 S30114 875441 RES,TF,487K,1/4W,1%,3216 487K 1% C25 C27-28 S35104714344 CAP ,CE,MONO,COG,470PF,50V,J,3216 470P R14-15 R31-32 S30121 005230 RES,TF,10K,1/10W,1%,2012 10K 1%

C36-37 C48 C105 R42 R46

C119 C205 C219 R22 R44 R92-93 S30121275230 RES,TF,12.7K,1/10W,1%,2012 12.7K 1% C118 C218 S35106815331 CAP,CE,MONO,COG,680PF,50V,J,2012 680P R95 R107 R116 R121 R130 R140 R154 R169 ZD401-402 20585020 24 DIODE,ZN,500MW,BM,2.4V,DO-35,T 2.4BM R201-202 LD401 LD407 2300030100 LED,RND 3.1MM,RED,DIF,1U,ST2.5 LTL-1CHE R211-212

LD402-406 LD408

2300032100 LED,RND 3.1MM,GRN,DIF,1U,ST2.5 LTL-1CHG

R234 R237 R246 VR401-402 3228066600

VR,ROT,VER,1U,L15,10K,B,RV16ADO-41-15F

10KB

R256 R271 R286 AN402 4355429120

CON ASS'Y,RB,16P,IDC2.54,DIP2.54,480MM

ASS'Y-16P R322-323 R344 LIM1-8 8545993340 LED LIMITER LED LIMITER R12 S30121505230 RES TF 15K F 1/10W 2012 15K 1% C402 C404 3 409210023-T CAP,E,SM,SE,85C,10UF,50V,M 10/50 R41 R52 S30122 005230 RES,TF,20K,1/10W,1%,2012 20K 1% Q401-402 S20510405004

TR,SG,PNP,200MA,40V,2N3906S,SOT-23,TA

2N3906S R26 S30122495331 RES,TF,24.9K,1/8W,1%,2012 24.9K 1% Q404-405 R183 R194 S30123325441 RES,TF,33.2K,1/4W,1%,3216 33.2K 1% Q 407-408 R300-301 Q403 Q406 S20560448002

TR,SG,NPN,200MA,40V,MMBT3904,SOT-23,TA

2N3904 R25 R29 R96 S30123925331 RES,TF,39.2K,1/8W,1%,2012 39.2K 1% D401-404 S22400500001 DIODE,SW,0.2A,200V,BAS21,SOT-23 BAS21 R135 R165 R218 R402 R405 S30101027340 RES,TF,1K,1/8W,5%,3216 1K R252 R281 R319 R401 R403-404 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% R346 R406 R186 R306 S30124755331 RES,TF,47.5K,1/8W,1%,2012 47.5K 1% C4 01 C403 S35104714344 CAP,CE,MONO,COG,470PF,50V,J,3216 470P R39 S30131005230 RES,TF,1K,1/10W,1%,2012 1K 1% R138 R168 R254 S30131625331 RES,TF,1.62K,1/8W,1%,2012 1.62K 1% R284 C601-602 3630104500 CAP,FILM,M-POLY ESTR,0.1UF,250V 0.1/250(M) R334 S30131745331 RES,TF,1.74K,1/8W,1%,2012 1.74K 1% JK603-604 4430001200 JACK,SPEAKON,1U,4P,ST,FC60112 4P R48-49 R110 S30132215331 RES,TF,2.21K,1/8W,1%,2012 2.21K 1% R191 R210 R231 R309 R317 AN501 435542 9008

CON ASS'Y,RB,14P,IDC2.54,DIP2.54,170MM

ASS'Y-14P R329-331 JK402 JK404 4438192910 JACK,PHONE,1U,5P,ST PHONE R94 R129 R245 S30133015230 RES,TF,3.01K,1/10W,1%,2012 3 .01K 1% JK401 JK 403 4438193810 JACK,XLR(F),1U,3P,ST XLR(F) R864 SW501 SW503 4618499310 SW SLIDE SS84017-0403-5.3T-FN SS84017 R134 R166 R251 S30134325230 RES,TF,4.32K,1/10W,1%,2012 4.32K 1% SW506

VR B'D (40 000 066 10)

O UTPUT B'D (4 000 006 62 0)

INPU T B'D (400 000 690 0)

Ref. Pa rt No. D escription Value

SW504-505 4628991710 SW,PUSH,VER,DPDT,NS,1U,L12.5 SPEC122SC011 BK501 6505955520 PCB BKT MX-400 BRACKET C521-522 340921 0071-T CAP,E,SM,SG,85C,10UF,50V,M 10/50 C503 C508 C511 3409847041-T CAP,E,NP,NP,85C,47UF,25V,M 47/25 NP C516 C505 C513 360968312 0-T CAP,FILM,POLYESTR,0.068UF,100V 0.068/100 C507 C515 363922418 8-T CAP,FILM,M-POLYESTR,0.22UF,63V 0.22/63(M) C506 C514 363947318 8-T CAP,FILM,M-POLYESTR,0.047UF,63V 0.047/63(M) U501-504 S21 101087701 IC,OP AMP,NE5532A,SOP8 NE5532A D501-504 S224 00500001 DIOD E,SW,0.2A,200V,BAS21,SOT-23 BAS21 R531-532 S30100007230 RES,TF,0,1/10W,5%(J),2012 0 R505 R518 S30101037231 RES,TF,10K,1/10W,5%,2012 10K R506 R519 S30101047231 RES,TF,100K,1/10W,5%,2012 100K R512 R525 S30102037231 RES,TF,20K,1/10W,5%,2012 20K R527-530 S30107507231 RES,TF,75,1/10W,5%,2012 75 R507 R513 R520 S30107527230 RES TF 7.5K J 1/10W 2012 7.5K R526 R508 R521 S30121375230 RES,TF,13.7K,1/10W,1%,2012 13.7K 1% R511 R524 S30124755331 RES,TF,47.5K,1/8W,1%,2012 47.5K 1% R509 R522 S30133655230 RES,TF,3.65K,1/10W,1%,2012 3.65K 1% R510 R523 S30134755331 RES,TF,4.75K,1/8W,1%,2012 4.75K 1% R501-504 S30135605230 RES,TF,5.6K,1/10W,1%,2012 5.6K 1% R514-517 C501-502 S3510101 4331 CAP,CE,MONO,COG,100P F,50V,J,2012 100P C509-510 C523-524 S3510104 5331 CAP,CE,MONO,X7R,0.1UF,50V,Z,2012 0.1U C504 C512 S3510220433 9 CAP,CE,MONO,COG,22PF,50V,J,20 12 22P C517-520 S3510471 4330 CAP,CE,MONO,COG,470P F,50V,J,2012 470P

AC CORD 4308997410 AC POWER CORD (16A/250V) 230VAC AC CORD 4308997610 AC POWER CORD (15A/125V) 120VAC AC INLET 4448597210 AC INLET 3P 2.0T 16A/20A 479 3 CONNECTOR 4355429504 CON ASS'Y,DS,1P,R5.3,250T08,110MM CONNECTOR 4355429510 CON ASS'Y,DS,1P,R5.3,250T08,210MM CONNECTOR 4355810803 CON ASS'Y,DS,1P,250T08,ST4.2,100MM FAN 1,2 7308997510 DC FAN(3110KL-05W-B70-F04) SW 4648099810

SW,POWER,18A,250V,AJ1-B0-44-618-5C2-D

230VAC

SW 4648099920 SW POWER AJ1-B0-44-635-5C2-C 120VAC

ASS'Y