Page 1
http://www.inter-m.com
MADE IN KOREA
NO: 9007978900
SERVICE
MANUAL
COMPACT DISC
RECEIVER
ACR-60/120
Page 2
1
AMP SECTION
1. OFF SET VOLTAGE
A. Setting
Set the master volume controls minimum.
B. Connection
C. Adjustment
Control OFFSET until voltmeter is the “0” position.
2. IDLE CURRENT
A. Setting
Set the master volume controls minimum.
B. Connection
C. Adjustment
Adjust IDLE so that the current through the R56, R57, R58, R59 become 10 milliampere. When that
voltage across the IDLE2 TO IDLE3 becomes 10 millivolt, the current becomes 10 milliampere.
ELECTRICAL ADJUSTMENT PROCEDURE
Electrical Adjustment Procedure 1, 2, 3
Micom Data (CD) 4, 5, 6, 7
Specifications
8
Electrical Parts List
9, 10, 11, 12
Top and Bottom View of P.C. Board
13, 14, 15
Wiring Diagram 16
Block Diagram 17
Schematic Diagram
18, 19, 20, 21, 22, 23
Exploded View of Cabinet & Chassis / Mechanical Parts List
24, 25
Ass’y Drawing 26, 27
CONTENTS
Page 3
FM SECTION
1. IF ALIGNMENT
A. Set up the test equipment as Fig. 2-1.
B. Adjust the cross T604 and T605 so that the S curve developed on the oscilloscope become point
symmetry to the centry frequency poine of 10.7MHz with a maximum amplitude.
C. If the genescope is not available, set the unit detuned and adjust the cross of T604, T605 so that noise
output is maximized.
32
AM SECTION
1. IF ALIGNMENT
A. Set up the test equipment as Fig. 1-1 and set the genescope output level to 110dB (300mV).
B. Adjust T603 so that the figure developed or the oscilloscope become laterally symmetrical with the axis
of symmetry at 450kHz and it has a maximum amplitude as well.
2. RF TUNING ALIGNMENT
A. Set up the test equipment as Fig. 1-2.
B. Set AM SG to 30% modulation at 400Hz and 30-40dB output.
C. Set the up and down switch of the frequency display to 603 (or 600) kHz.
Adjust AM SG to 603 (or 600) kHz, adjust T602 (RF) to maximize audio frequency output level.
D. Set the up and down switch of the frequency display to 1404 (or 1400) kHz, adjust AM SG to 1404 (or
1400) kHz, and adjust AM trimmer capacitor C605 to maximize audio frequency output level.
E. Repeat steps and so that output is maximized at the given frequencies.
Fig. 1-1
Fig. 1-2
Page 4
FEATURES
Memory
• ROM: 32-Kbyte (KS88C2432/P2432)
• ROM: 16-Kbyte (KS88C2416/P2416)
• RAM: 1056-Byte (KS88C2432/P2432,
KS88C2424/P2424)
• RAM: 544-Byte (KS88C2416/P2416,
KS88C2408/P2408)
• Data memory mapped I/O
Oscillation Sources
• Crystal, ceramic, RC (main)
• Crystal for subsystem clock
• Main system clock frequency 1-10 MHz
(3 MHz at 1.8 V, 10 MHz at 2.7 V)
• Subsystem clock frequency: 32.768 kHz
• CPU clock divider (1/1, 1/2, 1/8, 1/16)
Two Power-Down Modes
• Idle (only CPU clock stops)
• Stop (System clock stops)
Interrupts
• 6 level 8 vector 8 internal interrupt
• 1 level 8 vector 8 external interrupt
45 I/O Pins
• 45 configurable I/O pins
Basic Timer
• Overflow signal makes a system reset
• Watchdog function
8-Bit Timer/Counter A
• Programmable 8-bit timer
• Interval, capture, PWM MODE
• Match/capture, overflow interrupt
8-Bit Timer/Counter B
• Programmable 8-bit timer
• Carrier frequency generator
16-Bit Timer/Counter 0
• Programmable 16-bit timer
• Match interrupt generates
16-Bit Timer/Counter 1
• Programmable 16-bit timer
• Interval, capture, PWM mode
• Match/capture, overflow interrupt
Watch Timer
• Real-time and interval time measurement
• Clock generation for LCD
• Four frequency outputs for buzzer sound
LCD Controller/Driver
• Maximum 16-digit LCD direct drive capability
• Display modes: static, 1/2 duty (1/2 bias)
• 1/3 duty (1/2 or 1/3 bias), 1/4 duty (1/3 bias)
A/D Converter
• Eight analog input channels
• 50µs conversion speed at 1 MHz f
ADC
clock
• 10-bit conversion resolution
8-Bit Serial I/O Interface
• 8-bit transmit/receive mode
• 8-bit receive mode
• LSB-first/MSB-first transmission selectable
• Internal/external clock source
Voltage Booster
• LCD display voltage supply
• S/W control en/disable
• 3.0 V drive
Voltage Detector
• Programmable detection voltage
(2.2V, 2.4V, 3.0V, 4.0V)
• En/Disable S/W selectable
Instruction Execution Times
• 400 ns at 10 MHz (main)
• 122 us at 32.768 kHz (subsystem)
Operating Temperature Range
• –40°C to 85°C
Operating Voltage Range
• 1.8V to 5.5V
Package Type
• 80-pin QFP
• 80-pin TQFP
KS88C2432’s ROM version device
• KS88C2424 (ROM 24 Kbyte)
KS88C2432’s ROM version device
• KS88C2408 (ROM 8 Kbyte)
5
KS88-SERIES MICROCONTROLLERS
Samsung’s KS88 series of 8-bit single-chip CMOS microcontrollers offers a fast and efficient CPU, a wide
range of integrated peripherals, and various mask-programmable ROM sizes. Among the major CPU
features are:
– Efficient register-oriented architecture
– Selectable CPU clock sources
– Idle and Stop power-down mode release by interrupt
– Built-in basic timer with watchdog function
A sophisticated interrupt structure recognizes up to eight interrupt levels. Each level can have one or more
interrupt sources and vectors. Fast interrupt processing (within a minimum of four CPU clocks) can be
assigned to specific interrupt levels.
KS88C2416/P2416/C2432/P2432 MICROCONTROLLER
The KS88C2416/P2416/C2432/P2432 single-chip CMOS microcontroller are fabricated using the highly
advanced CMOS process, based on Samsung’s newest CPU architecture.
The KS88C2416 is a microcontroller with a 16-Kbyte mask-programmable ROM embedded.
The KS88C2432 is a microcontroller with a 32-Kbyte mask-programmable ROM embedded.
The KS88P2416 is a microcontroller with a 16-Kbyte one-time-programmable ROM embedded.
The KS88P2432 is a microcontroller with a 32-Kbyte one-time-programmable ROM embedded.
Using a proven modular design approach, Samsung engineers have successfully developed the KS88
C2416/P2416/C2432/P2432 by integrating the following peripheral modules with the powerful SAM8 core:
– Six programmable I/O ports, including five 8-bit ports and one 5-bit port, for a total of 45 pins.
– Eight bit-programmable pins for external interrupts.
– One 8-bit basic timer for oscillation stabilization and watchdog functions (system reset).
– Two 8-bit timer/counter and two 16-bit timer/counter with selectable operating modes.
– Watch timer for real time.
– 8-input A/D converter
– Serial I/O interface
The KS88C2416/P2416/C2432/P2432 is versatile microcontroller for camera, LCD and ADC application,
etc. They are currently available in 80-pin TQFP and 80-pin QFP package.
OTP
The KS88P2416/P2432 are OTP (One Time Programmable) version of the KS88C2416/C2432
microcontroller. The KS88P2416 microcontroller has an on-chip 16-Kbyte one-time-programmable EPROM
instead of a masked ROM. The KS88P2432 microcontroller has an on-chip 32-Kbyte one-timeprogrammable EPROM instead of a masked ROM. The KS88P2416 is comparable to the KS88C2416,
both in function and in pin configuration. The KS88P2432 is comparable to the KS88C2432, both in
function and in pin configuration.
MICOM DATA (CD)
4
Page 5
PIN ASSIGNMENT
7
BLOCK DIAGRAM
6
544/1056Byte
RegisterFile
OSC/
RESET
Basic
Timer
Watch
Timer
I/OPortandInterruptControl
16/32-Kbyte
ROM
SAM88RCCPU
8-Bit
Timer/
CounterB
16-Bit
Timer/
Counter0
16-Bit
Timer/
Counter1
I/OPort0
I/OPort1
A/D
Converter
I/OPort2
8-Bit
Timer/
CounterA
I/OPort3
TAOUT/TAPWM/P3.1
TACLK/P3.2
TACAP/P3.3
TBPWM/P3.0
T1CAP/P1.0
T1CLK/P1.1
T1OUT/T1PWM/P1.2
P0.0-P0.7/
INT0-INT7
P1.0-P1.7
AV
REF
AV
SS
P2.0-P2.7/
ADC0-ADC7
LCD
Driver
SerialI/O
Port
P3.0-P3.4
Voltage
Detector
V
VLDREF
I/OPort5
I/OPort4
Voltage
Booster
CB
CA
VLC0-VLC2
COM0-COM3
SEG0-SEG15
SEG16-SEG31
SI/P1.7
SO/P1.5
SCK/P1.6
P4.0-P4.7
P5.0-P5.7
RESET
BUZ/P1.4
X
OUT
XT
OUT
X
IN
XT
IN
SEG25/P5.1
SEG24/P5.0
SEG23/P4.7
SEG22/P4.6
SEG21/P4.5
SEG20/P4.4
SEG19/P4.3
SEG18/P4.2
SEG17/P4.1
SEG16/P4.0
SEG15
SEG14
SEG13
SEG12
SEG11
SEG10
SEG26/P5.2
SEG27/P5.3
SEG28/P5.4
SEG29/P5.5
SEG30/P5.6
SEG31/P5.7
P3.0/TBPWM
P3.1/TAOUT/TAPWM
P3.2/TACLK
P3.3/TACAP/SDAT
P3.4/SCLK
V
DD
V
SS
X
OUT
X
TEST
XT
XT
OUT
RESET
P0.0/INT0
P0.1/INT1
P0.2/INT2
P0.3/INT3
P0.4/INT4
807978777675747372717069686766
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
IN
KS88C2416/P2416/
C2432/P2432
(80-QFP-1420C)
16
17
IN
18
19
20
21
22
23
24
252627282930313233343536373839
65
40
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
SEG9
SEG8
SEG7
SEG6
SEG5
SEG4
SEG3
SEG2
SEG1
SEG0
COM3
COM2
COM1
COM0
VLC2
VLC1
VLC0
CA
CB
SS
AV
AV
REF
P2.7/ADC7/V
P2.6/ADC6
P2.5/ADC5
VLDREF
P0.5/INT5
P0.6/INT6
P0.7/INT7
P1.0/T1CAP
P1.3
P1.7/SI
P1.5/SO
P1.4/BUZ
P1.6/SCK
P1.1/T1CLK
P1.2/T1OUT/T1PWM
P2.0/ADC0
P2.1/ADC1
P2.2/ADC2
P2.3/ADC3
P2.4/ADC4
Page 6
8 9
ELECTRICAL PARTS LIST
R544 3009393973 RES CF 39K 15W J N 39K
R545 3009333973 RES CF 33K 1/5W J N 33K
R546 3009563973 RES CF 56K 1/5W J N 56K
R549 3009564973 RES CF 560K 1/5W J N 560K
R570-571 3009221973 RES CF 220 1/5W J N 220
VR501 3228074410 VR 09VSF30A103 10KA 10KA
XLR501-502,
4438193810 XLR JACK (F) 3P (E203A0040N) XLR JACK
XLR504
AN1 4355886621 CON ASS’Y 5P CON 5P
AN2-3, 4428595003 LW5267/LWB0640/2.5MM-03P CON 3P
CON608
CON601-602 3408222261 CAP RSA 2200UF 35V SNAP 18P 2200/35
C605-606 3409210141-T CAP AF RSG 100UF 25V 6P 100/25
C607-608, 3509104530-T CAP CE F 0.1UF 50V Z 0.1/50
C611, C613,
C615
C609 3419568265 CAP HE 6800UF 35V 20 PLUG 6800/35
C610, C614 3408247161 CAP RSA 470UF 35V SNAP 13P 470/35
C612, C616 3408233141 CAP RSA 330UF 25V SNAP 10P 330/35
CN601-602, 4428595003 LW5267/LWB0640/2.5MM-03P CON 3P
CN604
CN603, 605 4428595002 LW5267/LWB0640/2.5MM-02P CON 2P
CN606 4428595008 LW5267/LWB0640/2.5MM-08P CON 8P
CON607 4428595005 LW5267/LWB0640/2.5MM-05P CON 5P
D601-602 2058100976 DIODE BRIDGE KBP202G/KBP203G KBPC 202G
D605 2058100996 DIODE RECTIFIER LT1N4006(4007) 1N 4006
IC601 2118012005 IC KIA 7818 API KEC 7818
IC602 2118013005 IC KIA 7918 PI KEC 7918
IC603 2118011805 IC KIA 7812 API KEC 7812
IC604 2118011605 IC KIA 7809 API KEC 7809
IC605 2128611307 IC 7806 SAMSUNG 7806
PT 2828065700
TRANS POWER 120Version ACR-60(UL/CSA) P.T (120Version)
PT 2828065710
TRANS POWER 220Version ACR-60(DOM) P.T (220Version)
PT 2828065720
TRANS POWER 230Version ACR-60(EUROPE) P.T (230Version)
PT 2828065730
TRANS POWER 240Version ACR-60(EUROPE) P.T (240Version)
PT 2828065800
TRANS POWER 120Version ACR-120(UL/CSA) P.T (120Version)
PT 2828065810
TRANS POWER 120Version ACR-120(DOM) P.T (220Version)
PT 2828065820
TRANS POWER 120Version ACR-120(EUROPE) P.T (230Version)
PT 2828065830
TRANS POWER 120Version ACR-120(EUROPE) P.T (240Version)
R601-602, 3059100772 RES CE 10 5W JN 10 5W
R609-610
R608, R612 3039100572-F RES MO 10 2W J N 10 2W
R607 3059250783 RES CE 25 5W K T 25 5W
SW2 2423000999 SW POLY 50VX110 JX3K-T POLY SW
AC1-2 4355770517 CON ASS’Y 1P (TERMINAL) CON 1P
C617 3549472407 CAP SPARK KILLER 0.0047UF 400V 0.0047/400
CN501 4428595002 LW5267/LWB0640/2.5MM-02P CON 2P
CON502 4428599003 WAFER YW025-03 CON 3P
SW1 4628988610 SW POWER SDDF3PATL011 (SP278) POWER SW
SW600 4628984310 SW PUSH JPP-22-32H-01 JAEIL SW
SW700 4648098410 SW PS-5-W7AV SW
ACIN1 4308997310 AC CORD DOME 3-CORES AC CORD
F601 5508412734
FUSE TS 20MM 2A/250V (UL/CSA) ACR-60 2A/250V (UL/CSA)
F601 5508112237
FUSE 51S 20MM 1A/250V (DOM) ACR-60 1A/250V (DOM)
F601 5508412234
FUSE TS 20MM 1A/250V (Europe) ACR-60 1A/250V (Europe)
F601 5508112937
FUSE 51S 20MM 3A/250V (UL/CSA) ACR-120 3A/250V (UL/CSA)
F601 5508222530
FUSE NB 31.8MM 1.5A/250V (DOM) ACR-120 1.5A/250V (DOM)
F601 5508412434
FUSE TS 20MM 1.25A/250V (Europe) ACR-120
1.25A/250V (Europe)
T1-4 4465998210 TERMINAL (250) PCB TAB 250T
AN405, 4355886621 CON ASS’Y 5P CON 5P
CON405
C400, C402 3509473530-T CAP CE F 0.047UF 50V Z 0.047/50
C401, C403, 3509223530-T CAP CE F 0.022UF 50V Z 0.022/50
C405,
C417-418,
C428
C404, C406, 3409210971-T CAP AF RSG 1UF 50V 5P 1/50
C416, C430
Ref No. Part No. ValueDescription
SPECIFICATIONS
ELECTRICAL
• Rated Output Power (RMS)....................................................................................................ACR-60: 60W
..............................................................................................................................................ACR-120: 120W
• Speaker Output Impedance
ACR-60.........................................................................60W: 15.5V/4Ω, 25V/10.5Ω, 70V/82Ω, 100V/166Ω
ACR-120........................................................................... 120W: 22V/4Ω, 25V/5.2Ω, 70V/41Ω, 100V/83Ω
• Input Sensitivity/Impedance
MIC 1-3....................................................................................................................................... 1mV/600Ω
Aux.......................................................................................................................................... 350mV/10kΩ
Amp In ............................................................................................................................................1V/10kΩ
• Frequency Response (+1/–3dB)
MIC 1-3................................................................................................................................. 100Hz–12kHz
Aux.......................................................................................................................................... 60Hz–15kHz
Amp In......................................................................................................................................60Hz–18kHz
• T.H.D.......................................................................................................................................Less than 1%
• S/N
MIC 1-3..............................................................................................................................Better than 60dB
Aux.....................................................................................................................................Better than 75dB
• Tone Control
Bass (100Hz) .....................................................................................................................................±12dB
Treble (10kHz)....................................................................................................................................±12dB
TUNER SECTION
• Tuning Range..................................................................................................................FM: 87.5–108MHz
..........................................................................................................................................AM: 522–1620kHz
• Usable Sensitivity..........................................................................................................FM: 2µV, AM: 12µV
COMPACT DISC SECTION
• Type..........................................................................................................3 CD Changer of Magazine Type
• Frequency Response (+1/–3dB)..............................................................................................20Hz–20kHz
• THD........................................................................................................................................Less than 1%
GENERAL
• Power Source .......................................................................................................AC 110V–240V, 50/60Hz
• Power Consumption ...............................................................................................................ACR-60: 85W
..............................................................................................................................................ACR-120: 120W
• Weight....................................................................................................................................ACR-60: 13kg
............................................................................................................................................ACR-120: 14.5kg
• Dimensions....................................................................................................420(W)
132(H) 320(D)mm
*Specifications and design subject to change without notice for improvements.
PRE POWER B’D (4005410200)
POWER SW B’D & SPK SEL B’D (4005410320)
INLET B’D (4005410220)
TUNER B’D (4005412700)
Ref No. Part No. ValueDescription
AN501 4428594903 LA5268/LAB0640/2.5MM-03P CN 3P
C501-502, 3509102530-T CAP CE B 0.001UF 50V J 0.001/50
C505-506,
C509-510
C503, C507, 3509150130-T CAP CE SL 15PF 50V J 15P
C511
C504, C570 3529680-311-T CAP CE SL 68PF 50V J AXIAL 68P
C508, C512 3509330130-T CAP CE SL 33PF 50V J 33P
C514 3509509030-T CAP CE SL 5PF 50V J 5P
C515-516 3609153120-T CAP MA 0.015UF 100V J 0.015/100(M)
C517 3509223530-T CAP CE F 0.022UF 50V Z 0.022/50
C518, C572 3509470130-T CAP CE SL 47PF 50V J 47P
C519, C521 3609104120-T CAP MA 0.1UF 100V J 0.1/100(M)
C520 3609103120-T CAP MA 0.01UF 100V 0.01/100(M)
C522-523, 3409247971-T CAP AF RSG 4.7UF 50V 5P 4.7/50
C525-526,
C528-529,
C533-534
C524, C527, 3409210971-T CAP AF RSG 1UF 50V 5P 1/50
C530-532,
C536-537
C535 3409222071-T CAP AF RSG 22UF 50V 5P 22/50
C538-541, 3409247071-T CAP AF RSG 47UF 50V 6P 47/50
C543-544
C542 3409247041-T CAP AF RSG 47UF 25V 5P 47/25
C571 3529330311-A CAP CE SL 33PF 50V J AXIAL 33P
C573-577 3509103530-T CAP CE F 0.01UF 50V Z 0.01/50
CN501, 4428595002 LW5267/LWB0640/2.5MM-02P CN 2P
CN503-505,
CN507
CN502 4428595509 WAFER 9P CA-6210 CN 9P
CN506 4428594903 LA5268/LAB0640/2.5MM-03P CN 3P
D501-503 2058304100 DIODE IN4148 1N 4148
D504 2058502056 DIODE ZENER UZ-5.6BW (5.4,5.8) UZ 5.6BM
FB501-506 3908609990 EMI FILTER 1000PF EMI 1000P
IC2-3, 2118010432 IC NJM2068DD JRC NJM 2068DD
IC502-503
IC501 2128740208 IC BXA 4240 BXA4240K
JK1 4438097320 BOARD PHONE JACK(ST) MPA-95 PHONE JACK
JK501-502 4438194510 RCA JACK BOARD 2P (24MM) JACK 2P
JMP 1508400501 JUMP WIRE (0.5/52M/M) JUMP
Q501 2008606105-T TR PNP KTA 1266Y KTA 1266Y
Q502-505 2008606998-T TR NPN KTD 1302 KEC ONLY KTD 1302
R501-502, 3009103973 RES CF 10K 1/5W J N 10K
R508-509,
R515-516,
R522, R530,
R548
R503-504 3009821973 RES CF 820 1/5W J N 820
R505 3009683973 RES CF 68K 1/5W J N 68K
R506, R513, 3009104973 RES CF 100K 1/5W J N 100K
R520,
R534-535
R507, R514, 3009101973 RES CF 100 1/5W J N 100
R521, R524,
R539
R510-511, 3009102973 RES CF 1K 1/5W J N 1K
R517-518,
R527, R536
R512, R519 3009154973 RES CF 150K 1/5W J N 150K
R523 3009123973 RES CF 12K 1/5 J N (ACR-60) 12K (ACR-60)
R523 3009123973 RES CF 15K 1/5 J N (ACR-120) 15K (ACR-120)
R525 3009472973 RES CF 4.7K 1/5W J N 4.7K
R526 3009273973 RES CF 27K 1/5W J N 27K
R528 3009105973 RES CF 1M 1/5W J N 1M
R529 3009274973 RES CF 270K 1/5W J N 270K
R531, R541 3009123973 RES CF 12K 1/5W J N 12K
R532 3009822973 RES CF 8.2K 1/5W J N 8.2K
R533 3009153973 RES CF 15K 1/5W J N 15K
R537 3009202973 RES CF 2K 1/5W J N 2K
R538 3039561572-F RES MO 560 2W J N 560 2W
R540 3009224973 RES CF 220K 1/5W J N 220K
R542, R547 3009473973 RES CF 47K 1/5W J N 47K
R543 3009225973 RES CF 2.2M 1/5W J N 2.2M
INPUT B’D (4005410210)
Page 7
R90 3009302973 RES CF 3K 1/5W J N 3K
R92 3009153973 RES CF 15K 1/5W J N 15K
R93 3009104973 RES CF 100K 1/5W J N 100K
R94 3009563973 RES CF 56K 1/5W J N 56K
R97 3009224973 RES CF 220K 1/5W J N 220K
R99 3009333973 RES CF 33K 1/5W J N 33K
R125 3009471973 RES CF 470 1/5W J N 470
RLY1 5528009980 RELAY HR-311 HR-311
T6 4355877007 CONNECTOR ASS’Y 1P MA630 1P
TH1-2 2438209011 THERMISTOR YSG-503J L=100MM 330
VR10-11 3248347120 RES SEMI CS 470B 10/5 470B
C82 3609102120-T CAP MA 0.001UF 100V 0.001/100(M)
C83-84 3609103120-T CAP MA 0.01UF 100V 0.01/100(M)
C85 3609152120-T CAP MA 0.0015UF 100V J 0.0015/100(M)
C86 3509100130-T CAP CE SL 10PF 50V D 10P
C87, C91, 3409247071-T CAP AF RSG 47UF 50V 6P 47/50
C99-100
C88, C92 3409233071-T CAP AF RSG 33UF 50V 6P 33/50
C89 3509151130-T CAP CE SL 150PF 50V J 150P
C90, C97 3409210071-T CAP AF RSG 10UF 50V 5P 10/50
C93-94 3509509030-T CAP CE SL 5PF 50V J 5P
C95 3409222071-T CAP AF RSG 22UF 50V 5P 22/50
C96, C98 3409215971-T CAP AF RSG 1.5UF 50V 5P 1.5/50
CON13 4355785400 CON ASS’Y 3P (VR PCB) CON 3P
CON14-15, 4355771017 CON ASS’Y (BLUE) CON 2P
CON21,
CON24
CON20 4355771222 CON ASS’Y 9P CON 9P
CON22 4355770719 CON ASS’Y 4P CON 4P
D18 2058304100 DIODE IN4148 1N 4148
IC9-10 2118010590 IC NJM4558D JRC NJM 4558D
R101-102 3009392973 RES CF 3.9K 1/5W J N 3.9K
R103-104 3009133973 RES CF 13K 1/5W J N 13K
R105 3009183973 RES CF 18K 1/5W J N 18K
R106, R109, 3009101973 RES CF 100 1/5W J N 100
R111, R115
R107 3009122973 RES CF 1.2K 1/5W J N 1.2K
R108 3009102973 RES CF 1K 1/5W J N 1K
R110 3009103973 RES CF 10K 1/5W J N 10K
R112 3009121973 RES CF 120 1/5W J N 120
R113, R117 3009473973 RES CF 47K 1/5W J N 47K
R114, R118 3009471973 RES CF 470 1/5W J N 470
R116 3009272973 RES CF 2.7K 1/5W J N 2.7K
R119-124, 3009123973 RES CF 12K 1/5W J N 12K
R126
SW1 4618006510 SW VOL SELE SDJL4SBKP011 (SP087) SW
VR1-8 3228074410 VR 09VSF30A103 10KA 10KA
IC14 2118031207 IC KA2281 S.S KA2281
C131 3409210971-T CAP AF RSG 1UF 50V 5P 1/50
C163 3409233971-T CAP AF RSG 3.3UF 50V 5P 3.3/50
CON30 4355770421 CON ASS’Y 4P CON 4P
CON31-32 4428594010 WAFER 5532-10A J.MOLEX CON 5P
R207, R212 3009104973 RES CF 100K 1/5W J N 100K
R208-209, 3009473973 RES CF 47K 1/5W J N 47K
R213
R210 3009103973 RES CF 10K 1/5W J N (ACR-60) 10K (ACR-60)
R210 3009133973 RES CF 13K 1/5W J N (ACR-120) 13K (ACR-120)
R211 3009202973 RES CF 2K 1/5W J N (ACR-60) 2K (ACR-60)
R211 3009182973 RES CF 1.8K 1/5W J N (ACR-120) 1.8K (ACR-120)
Q48 2008606104-T TR NPN KTC 3198Y KTC 3198Y
CN402 4355887317 CON ASS’Y 4P CON 4P
CN403 4355887114 CON ASS’Y 3P CON 3P
CON 404 4355898203 CON ASS’Y 26P CON 26P
D430-433 2058304100 DIODE IN4148 1N 4148
LCD400 2338170397 LCD SLC-5056RS-1/C3 LCD
LED400 2300030006 LED LTL 16KEE-021A LED
LMP3-4 2528000900 LAMP 14V40MA PI-TYPE PA-1000AR LAMP
SW400-409 4628985710 TACT (5MM) SKHV10906A (KBW89) SKHV10906A
R423, R431, 3009222973 RES CF 2.2K 1/5W J N 2.2K
R458
R424 3009105973 RES CF 1M 1/5W J N 1M
R425 3009153973 RES CF 15K 1/5W J N 15K
R426 3009100973 RES CF 10 1/5W J N 10
R427, R461 3009682973 RES CF 6.8K 1/5W J N 6.8K
R433, R445, 3009472973 RES CF 4.7K 1/5W J N 4.7K
R453
R435 3009272973 RES CF 2.7K 1/5W J N 2.7K
R439. R447, 3009102973 RES CF 1K 1/5W J N 1K
R449
R448 3009151973 RES CF 150 1/5W J N 150
R451 3009152973 RES CF 1.5K 1/5W J N 1.5K
R460 3009683973 RES CF 68K 1/5W J N 68K
SW2 4628988610 SW POWER SDDF3PATL011 (SP278) POWER SW
SVR400 3248347320 RES SEMI CS 47KB 10/5 47KB
VR400 3228081010 VR RK11K114030713A (RO992) 10KA
X1 3908101050 CRYSTAL 4.5MHZ 4.5MHZ
C61-62 3419533280 CAP AF 3300UF 63V 25 PLUG (ACR-60)
3300/63(ACR-60)
C61-62 3419547280
CAP AF HM 4700UF 63V 30 PLUG (ACR-120)
4700/63(ACR-120)
C65 3609102120-T CAP MA 0.001UF 100V 0.001/100(M)
C66 3509470130-T CAP CE SL 47PF 50V J 47P
C67, C69-70 3509101130-T CAP CE SL 100PF 50V J 100P
C68 3509103530-T CAP CE F 0.01UF 50V Z 0.01/50
C71 3409210971-T CAP AF RSG 1UF 50V 5P 1/50
C72-74, C81 3409247071-T CAP AF RSG 47UF 50V 6P 47/50
C75-76, 3409210071-T CAP AF RSG 10UF 50V 5P 10/50
C79-80
C77 3409233071-T CAP AF RSG 33UF 50V 6P 33/50
C78 3409247871-T CAP AF RSG 0.47UF 50V 5P 0.47/50
CON9, 4428596602 WAFER LW-1143-02P CON 2P
CON11-12
CON10 4428596603 LOCK WAFER LW-1143-03P CON 3P
D9 2058100988 DIODE BRIDGE PBU 804 PBU 804
D10-13 2058304100 DIODE IN4148 1N 4148
D14-15 2058100996 DIODE RECTIFIER LT1N4006 (4007) 1N 4006
D16-17 2058010101 DIODE IN 60 1N 60
IC8 2118050410 IC TA7317P TOSHIBA TA 7317P
IDLE1-3 4678699411 CNT PLUG 1P IDLE
Q6-7 2028407109 TR NPN 2SD718-O (BS) 2SC5197 2SD 718
Q8-9 2028107106 TR PNP 2SB688 (O)/2SA1940 2SB 688
Q10 2028407118 TR NPN 2SC 2238Y 2SC 2238Y
Q11 2028107115 TR PNP 2SA968Y 2SA 968Y
Q12-15, Q20 2008606108-T TR NPN KTC2240BL (KTC 3200BL) KTC 2240BL
Q16-17 2008206998-T TR PNP 2SA 965Y (KTA 1023Y) 2SA 965Y
Q18-19 2008407970-T TR NPN KTC 2SC 2235Y (KTC1027Y) 2SC 2235Y
Q21 2008606104-T TR NPN KTC 3198Y KTC 3198Y
Q22 2008606105-T TR PNP KTA 1266Y KTA 1266Y
R56-59 3059478783 RES CE 0.47 5W J T (ACR-60)
0.47/5W (ACR-60)
R56-59 3059278783 RES CE 0.27 5W J T (ACR-120)
0.27/5W (ACR-120)
R60-61 3039203473-F RES MO 20K 1W JN 20K 1W
R62 3039103572-F RES MO 10K 2W J N 10K 2W
R63 3039152572-F RES MO 1.5K 2W J N 1.5K 2W
R64 3039271572-F RES MO 270 2W J N 270 2W
R65 3009182973 RES CF 1.8K 1/5W J N 1.8K
R66 3009203973 RES CF 20K 1/5W J N 20K
R67 3009122973 RES CF 1.2K 1/5W J N 1.2K
R68, R86-87 3009152973 RES CF 1.5K 1/5W J N 1.5K
R69, R74-76 3009103973 RES CF 10K 1/5W J N 10K
R70, R95 3009473973 RES CF 47K 1/5W J N 47K
R71-72, R81 3009102973 RES CF 1K 1/5W J N 1K
R73 3009471973 RES CF 470 1/5W J N 470
R77 3009101973 RES CF 100 1/5W J N 100
R78-79 3009221973 RES CF 220 1/5W J N 220
R80 3009562973 RES CF 5.6K 1/5W J N 5.6K
R82 3009103973 RES CF 10K 1/5W J N (ACR-60) 10K (ACR-60)
R82 3009183973 RES CF 18K 1/5W J N (ACR-120) 18K (ACR-120)
R83 3009222973 RES CF 2.2K 1/5W J N 2.2K
R84-85 3009273973 RES CF 27K 1/5W J N (ACR-60) 27K (ACR-60)
R84-85 3009203973 RES CF 20K 1/5W J N (ACR-120) 20K (ACR-120)
R88, R96, 3009153973 RES CF 15K 1/5W J N 15K
R98
R89, R91, 3009563973 RES CF 56K 1/5W J N 56K
R100
Ref No. Part No. ValueDescription
PRE POWER B’D (4005410200)
C407, C412, 3409247041-T CAP AF RSG 47UF 25V 5P 47/25
C426
C408 3639274111-T CAP ECQ-V 1H274JL2 0.27UF 50V 0.27/50
C409 3509221130-T CAP CE SL 220PF 50V J 220P
C410 3409247971-T CAP AF RSG 4.7UF 50V 5P 4.7/50
C411 3509104530-T CAP CE F 0.1UF 50V Z 0.1/50
C413 3409247871-T CAP AF RSG 0.47UF 50V 5P 0.47/50
C414 3419510401 CAP AF 0.1UF 5.5V (EFFCF5R5U104) 0.1/5.5
C415 3609473120-T CAP MA 0.047UF 100V 0.047/100(M)
C419 3509102530-T CAP CE B 0.001UF 50V J 0.001/50
C420 3409222871-T CAP AF RSG 0.22UF 50V 5P 0.22/50
C421, C423 3509103530-T CAP CE F 0.01UF 50V Z 0.01/50
C422 3409247071-T CAP AF RSG 47UF 50V 6P 47/50
C424 3509330130-T CAP CE SL 33PF 50V J 33P
C425 3509100130-T CAP CE SL 10PF 50V D 10P
C427 3609333120-T CAP MA 0.033UF 100V J 0.033/100(M)
C429 3609683120-T CAP MA 0.068UF 100V J 0.068/100(M)
C431 3609223120-T CAP MA 0.022UF 100V J 0.022/100(M)
CF400-401 3908011001 FILTER SK107M3-AO-20 10.7M
CON401 4428599004 WAFER YW025-04 CON 4P
CON402 4428598304 WAFER LW-0640-4P CON 4P
CON403 4428598303 CONNECTOR WAFER LW-0640-3P CON 3P
CON404 4678699300 70221-0253 26P CON 26P
DD1 3938000900 AM TUNER PACK FA2-A98 AM TUNER
D400, D412 2058502082 DIODE ZENER UZ-8.2BM (7.9,8.5) UZ 8.2BM
D401-405, 2058304100 DIODE IN4148 1N 4148
D407-409,
D411,
D413-425
D406 2058500051 DIODE ZENER UZ-5.1B (4.8,5.4) UZ 5.1B
D410, D426 2058502056 DIODE ZENER UZ-5.6BW (5.4,5.8) UZ 5.6BM
FE2 3928110930 FRONT END FTC2-361V FRONT END
IC400 2138013995 IC UPD1719G-014 12 D1719G-014
IC401 2168417994 IC LA 1145 (FM IF) SANYO LA1145
JK1 4678699430 CNT PLUG 3P 3P
L2-3 2648399930 COIL PEAKING 0.33uH (PA-600RB) 0.33uH
L7-8 2648699980 COIL CHOCK COMMON MODE PA-608R CHOCK
L9 2628099940 COIL FM DET COIL
Q400 2008406103-T TR NPN KTC 1923Y (KTC 3194) KTC 1923Y
Q401 2008606999-T TR KTC 3198BL KTC 3198BL
Q402-403 2008606998-T TR NPN KTD 1302 KEC ONLY KTD 1302
Q404, Q409, 2008606104-T TR NPN KTC 3198Y KTC 3198Y
Q414
Q405-408, 2008606105-T TR PNP KTA 1266Y KTA 1266Y
Q410, Q413
Q411 2018211100-T FET N-CH 2SK 168D SANKYOELE 2SK 168D
Q412 2008606108-T TR NPN KTC2240BL (KTC 3200BL) KTC 2240BL
R400, R430, 3009473973 RES CF 47K 1/5W J N 47K
R432, R434,
R444, R457
R401 3009680973 RES CF 68 1/5W J N 68
R402, R440, 3009104973 RES CF 100K 1/5W J N 100K
R443
R403 3009271973 RES CF 270 1/5W J N 270
R404, R446, 3009101973 RES CF 100 1/5W J N 100
R459
R405, R442 3009332973 RES CF 3.3K 1/5W J N 3.3K
R406, R439, 3009561973 RES CF 560 1/5W J N 560
R463
R407 3009471973 RES CF 470 1/5W J N 470
R408-409 3009331973 RES CF 330 1/5W J N 330
R410, R415, 3009103973 RES CF 10K 1/5W J N 10K
R417
R411, R414 3009273973 RES CF 27K 1/5W J N 27K
R412, R462 3009563973 RES CF 56K 1/5W J N 56K
R413 3009183973 RES CF 18K 1/5W J N 18K
R416 3009302973 RES CF 3K 1/5W J N 3K
R418 3009752973 RES CF 7.5K 1/5W J N 7.5K
R419-420, 3009103973 RES CF 10K 1/5W J N 10K
R428-439,
R436-437,
R441, R450,
R452,
R454-455
R421 3039101572-F RES MO 100 2W J N 100 2W
Ref No. Part No. ValueDescription
CON33-34 4428593910 WAFER 5533-10APB J.MOLEX CON 5P
LD1-9 2300552110 LED LTL-9233A LITEON LED
R1-9 3009681973 RES CF 680 1/5W J N 680
C134-136 3509103450-T CAP CE 0.01UF 500V Z 0.01/500V
CON18 4428596604 LOCK WAFER LW-1143-04P CON 4P
CON19 4428598304 WAFER LW-0640-4P CON 4P
CON501 4355886221 CON ASS’Y 2P CON 2P
CN502 4355886806 CON ASS’Y 3P CON 3P
CON503 4428598304 WAFER LW-0640-4P CON 4P
PT2 2818098300 TRANS OUTPUT ACR-60
TRANS OUTPUT
PT2 2818098400 TRANS OUTPUT ACR-120
TRANS OUTPUT
SW500 4618006510 SW VOL SELE SDJL4SBKP011 (SP087) SW
T16 4465997706 SCREW TERMINAL 6P 6P
AN308 4355887517 CON ASS’Y 8P CON 8P
AN505 4353982105 CON ASS’Y 2P 120MM CN 2P
AN702 4353982913 CON ASS’Y 3P 270MM CN 3P
C301 3609473120-T CAP MA 0.047UF 100V 0.047(M)
C302 3509309030-T CAP CE SL 3PF 50V C 3P
C303 OPEN OPEN OPEN
C304 3409247041-T CAP AF RSG 47UF 25V 5P 47/25
C305, C320, 3409210971-T CAP AF RSG 1UF 50V 5P 1/50
C374, C377
C306 3509680130-T CAP CE SL 68PF 50V J 68P
C307, C314 3609273120-T CAP MA 0.027UF 100V J 0.027(M)
C308-309, 3609222120-T CAP MA 0.0022UF 100V J 0.0022(M)
C319
C310-311 3609104120-T CAP MA 0.1UF 100V J 0.1(M)
C312, C344 3509222530-T CAP CE B 0.0022UF 50V K 0.0022
C313 3509821130-T CAP CE B 820PF 50V K 820P
C315-316, 3409210141-T CAP AF RSG 100UF 25V 6P 100/25
C328, C332,
C334, C339,
C341, C343,
C349, C355,
C370, C372
C317, 3509223530-T CAP CE F 0.022UF 50V Z 0.022/50
C326-327,
C329, C333,
C337-338,
C340, C346,
C348, C369,
C371
C318 3609153120-T CAP MA 0.015UF 100V J 0.015(M)
C321 3609224122-T CAP MA 0.22UF 100V J MINI 0.22(M)
C322 3539103521-A CAP CE YF 10000PF 25V Z AXIAL 10000P
C323, C373 3609102120-T CAP MA 0.001UF 100V 0.001(M)
C324 3539223521-A CAP CE YF 22000PF 25V Z AXIAL 22000P
C325 3639334111-T CAP ECQ-V 1H334JL2 0.33UF 50V 0.33(M)
C330, C345 3409210221-T CAP AF RSG 1000UF 6.3V 10P 1000/6.3
C331, C364 3409222071-T CAP AF RSG 22UF 50V 5P 22/50
C335-336 3509100130-T CAP CE SL 10PF 50V D 10P
C342, C363 3509331231-A CAP CE B 330PF 50V K AXIAL 330P
C347, 3539222311-A CAP CE YR 2200PF 50V MZ 2200P
C361-362,
C366
C350, C359 3409247071-T CAP AF RSG 47UF 50V 6P 47/50
C351-352 3609154122-T CAP MA 0.15UF 100V MINI 0.15(M)
C353 3409222113-T CAP E SK 220UF 6.3V 6.3*7 220/6.3
C354 3409222124-T CAP E SG 220UF 10V 220/10
C356, C360, 3509101231-A CAP CE B 100PF 50V K AXIAL 100P
C365, C367
C357 3409233971-T CAP AF RSG 3.3UF 50V 5P 3.3/50
C358, C368 3409210071-T CAP AF RSG 10UF 50V 5P 10/50
C375-376 3509330130-T CAP CE SL 33PF 50V J 33P
CF301-304 3908609990 EMI FILTER 1000PF 1000PF
CN301 4428536316 WAFER FMN-BTRK-16P/1MM.JST CON 16P
CN302 4428531206 WAFER S06B-PH-K/2MM.JST CON 6P
CN303 4428532209 WAFER S09B-EH/2.5MM/ANGLE.JST CON 9P
CN304, 4428595004 LW5267/LWB0640/2.5MM-04P CON 4P
CN307
Ref No. Part No. ValueDescriptionRef No. Part No. ValueDescription
VR B’D (4005410310)
LCD B’D (4005412600)
OUTPUT LED B’D (4005410350)
LED B’D (4005410340)
CD B’D (4003484100)
SP TERMINAL B’D & IMP SEL B’D (4005410330)
10 11
Page 8
TOP AND BOTTOM VIEW OF P.C. BOARD
CN305 4428536329 WAFER FMN-BTRK-29P/IMM.JST CON 29P
CN306 4428595011 LW5267/LWB0640/2.5MM-11P CON 11P
CN310 4428532204 WAFER S04B-EH/2.5MM/ANGLE:JST CON 4P
D301-304 2058304100 DIODE IN4148 1N4148
IC301 2128000835 IC AN8806SB MATSUSHITA AN8806SB
IC302 2128220435 IC AN8389SR MATSUSHITA AN8389SB
IC303 2128514055 IC MN662720RB MATSUSHITA MN662720RB
IC304 2128820535 IC SM5878AM NPC SM5878AM
IC305 2128121007 IC CPU KS88P2432QW SAMSUNG KS88P2432
IC306-307 2118010432 IC NJM2068DD JRC NJM 2068DD
IC308-309 2118020710 IC TA7291S TOSHIBA TA7291S
IC310 2138010979 IC M51953B MITSUBISHI M51953BL
L301-302 2648099990 COIL INDUCTOR 10UH CDC-9300 100K
Q301, Q304, 2008606113-T TR PNP KTA 1271(A1515) KEC KTA 1271Y
Q307
Q302, 2008606998-T TR NPN KTD 1302 KEC ONLY 2SD 1302R
Q305-306
Q303 2008613954-T TR DTC 124ES DTC 124ES
R301-302, 3009124973 RES CF 120K 1/5W J N 120K
R331
R303-306 3009183973 RES CF 18K 1/5W J N 18K
R308 3009824973 RES CF 820K 1/5W J N 820K
R307, R344, 3009470973 RES CF 47 1/5W J N 47
R373, R375
R309 3009823973 RES CF 82K 1/5W J N 82K
R310-311 3009272973 RES CF 2.7K 1/5W J N 2.7K
R312 OPEN OPEN OPEN
R313 3009123973 RES CF 12K 1/5W J N 12K
R314, R317 3009393973 RES CF 39K 1/5W J N 39K
R315, R323, 3009103973 RES CF 10K 1/5W J N 10K
R332, R337,
R339, R342,
R366-367,
R379-386
R316, 3009471973 RES CF 470 1/5W J N 470
R333-335,
R340, R346,
R371-372
R318, R376 3009472973 RES CF 4.7K 1/5W J N 4.7K
R319, R322 3009224973 RES CF 220K 1/5W J N 220K
R320-321, 3009223973 RES CF 22K 1/5W J N 22K
R341, R353,
R355, R364
R324, R348, 3009562973 RES CF 5.6K 1/5W J N 5.6K
R356, R360,
R369
R328 3009155973 RES CF 1.5M 1/5W J N 1.5M
R329, 3009681973 RES CF 680 1/5W J N 680
R351-352
R330 3039100572-F RES MO 10 2W J N 10 2W
R336, R338, 3009102973 RES CF 1K 1/5W J N 1K
R343, R368,
R370, R374,
R377-378
R345, R357 3009682973 RES CF 6.8K 1/5W J N 6.8K
R347, R365 3009000973 RES CF 0 1/5W J N 0
R350, R362 3009101973 RES CF 100 1/5W J N 100
R354, R363 3009203973 RES CF 20K 1/5W J N 20K
R358-359 3009753973 RES CF 75K 1/5W J N 75K
R387 OPEN OPEN OPEN
R388 1508400501 JUMP WIRE (0.5/25M/M) short
X301 3908101060 CRYSTAL 16.9344MHz KD6586FFB
X302 3908101080 CRYSTAL 4.19MHz 4.19MHz
AN306 4353983802 CON ASS’Y 11P 90MM CON 11P
AN305 4428536329 CON ASS’Y 4P 100MM CON 4P
LD301-318 2308232222-T SLR 34URF 25 LED
LCD301 2338170394 LCD KXN29150DAN CD KEC KXN2915DAN
S301 4628985710 TACT (5MM) SKHV10906A (KBW89) REPEAT
S302 4628985710 TACT (5MM) SKHV10906A (KBW89) CLEAR
S303 4628985710 TACT (5MM) SKHV10906A (KBW89) MEMORY
S304 4628985710 TACT (5MM) SKHV10906A (KBW89) DISPLAY
S305 4628985710 TACT (5MM) SKHV10906A (KBW89) RESET
S306 4628985710 TACT (5MM) SKHV10906A (KBW89) STOP
S307 4628985710 TACT (5MM) SKHV10906A (KBW89) PLAY
S308 4628985710 TACT (5MM) SKHV10906A (KBW89) S-FF
S309 4628985710 TACT (5MM) SKHV10906A (KBW89) S-REW
S310 4628985710 TACT (5MM) SKHV10906A (KBW89) FF
S311 4628985710 TACT (5MM) SKHV10906A (KBW89) REW
S312 4628985710 TACT (5MM) SKHV10906A (KBW89) DISC
S313 4628985710 TACT (5MM) SKHV10906A (KBW89) MODE
S314 4628985710 TACT (5MM) SKHV10906A (KBW89) RANDOM
AN307 4353981003 CON ASS’Y 4P 100MM CON 4P
S315 4628985710 TACT (5MM) SKHV10906A (KBW89) DISC1
S316 4628985710 TACT (5MM) SKHV10906A (KBW89) DISC2
S317 4628985710 TACT (5MM) SKHV10906A (KBW89) DISC3
Ref No. Part No. ValueDescriptionRef No. Part No. ValueDescription
CD DISPLAY B’D (4003484120)
CD EJECT B’D (4003484110)
VR B’D (4005410310)
12 13
Page 9
1514
Page 10
1716
WIRING DIAGRAM BLOCK DIAGRAM
Page 11
1918
SCHEHATIC DIAGRAM
Page 12
2120
Page 13
2322
Page 14
2524
EXPLODED VIEW OF CABINET & CHASSIS/MECHANICAL PARTS LIST
SCREW 2BTC #2.6X8Y
SCREW BM3X8B
SCREW 2PTC 2.6X5B
DOT SCREW (2BTC3X10B)
SCREW BM3X6NI
HEX MSPM 3X16Y
HEX MSPM 3X12Y
SCREW #2BTC3X12B
SCREW #2BTC3X8B
SCREW #2BTC3X6B
SCREW #3BTC4X8B
SCREW #3BTC3X6B
SCREW BM3X6B
SCREW #3WTC4X8B
50
S2
39
38
25
24
S7
S1
14
55
56
7
53
3
4
5
6
2
1
8
S3
16
12
11
9
10
54
64
13
S12
7
20
S1
S2
S3
S5
40
41
S6
S7
S8
S9
S10
S11
S12
S13
S4
S5
S14
31
34
66
33
32
S1
35
27
26
S11
S14
S11
63
CD MECH
S5
21
17
28
30
18
29
19
S12
23
62
45
22
S5
15
43
36
42
S12
S10
44
52
51
65
1
048522991611
CD PACK24
10
23
22
21
20
19
18
17
16
15
14
13
12
11
9
8
7
6
5
4
3
2
NO
15
4
12
8109230063
8109340083
8109330063
1
4
4
4
8
2
13
1
13
8
37
12
8009130083
8119226053
8095996520
8009130064
8099130161
8099130121
8109230123
8109230083
8009130063
8159340083
8109226081
1
048533998513TUNER INLAY
048543997210
048543997110
048521995111
PART NUMBER
FRONT PANEL
PART NAME
KNOB PUSH
CHIME KNOB
3
Q'TY
1
1
REMARK
4005412710
4005412600
6538995703
4005410350
4005410320
4465998010
7503093610
6535993510
048522995911
6735989010
6538997711
4005410310
6163196210
6735988920
6715997420
6505954610
048543997011
048543997311
048543998313
BUSHING CAP
INSULATION SHEET
POWER SW B'D
OUTPUT LED BD-2
INSULATION PLATE
RUBBER SPONGE
CONTROL KNOB
CONTROL KNOB
PCB BKT
LEVEL KNOB
SUB HEAT SINK
LAMP SPONGE
SIDE LOCKING SADDLE
SHORT BAR
TACK B'D
VR B'D
STUD
TUNER B'D
PACK TUNER
1
3
5
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
47
61
37
59
60
S3
46
57
58
S9
S6
S8
48
S4
49
1
4628988310
SPEAKER SELECTOR
4005410810
4005410820
4005410200
6503973810
048543986212
8543986310
5708999310
8575990810
048545989021
2338170394
8545988310
048575990911
4005410330
2828065820
2818098400
6735994110
6335999510
6122691110
046122095720
BRACKET CD MECH
CD DOOR(OUT)
CD MECHANISM
LCD SUPPORT
TACT KNOB(CD)
LCD KXN 29150 DAN
TACT B'D
FILTER
INLAY(CD)
CD DOOR(IN)
PRE POWER B'D
SP TERMINAL B'D
TRANS POWER
TRANS OUTPUT
MAIN CHASSIS
FOOT FELT
CD PCB
FOOT
TOP COVER
1
1
1
1
1
1
1
1
1
1
4
4
1
1
1
1
1
1
1
4005409900
4005410340
6505955520
4458999210(310)
4005410220
6505952110
6535995820
8575996530
4005410240
048545991011
6538998810
6505942010
7502090110
6535998020
4005410300
4308999410
4448599010
046102980112
4005410210
OUTPUT LED BD-1
HEAT SINK BKT
BACK CHASSIS
AC CORD
AC INLET
INPUT B'D
HEAT SINK
SUPPORTER
AMP B'D
CONNECTOR PCB
FUSE HOLDER(SOCKET)
BRACKET P/J B"
TERMINAL STUD
TERMINAL COVER
TACT SW B'D
TACT KNOB
RIVET NYLON
BKT GND
INLET B'D
2
1
1
1
1
1
1
1
1
2
2
3
2
1
1
1
1
1
1
66
65
64
6165168410
6505936610
8545992710
SHIELD FENCE
BRACKET COVER
LENS LED
1
1
1
Page 15
2726
ASS’Y DRAWING
15
16
420
132 280
PROT
+2dB
0dB
-2dB
-6dB
-12dB
-21dB
-24dB
POWER
BASS TREBLE
CHIME
MIN MAX
SPEAKER
ON
POWER
A
B
MIC 2 MIC 3
AM/FM
123
UP
TUNER
456
DOWN
MEMO
ON/OFF MAX
TUN
OFF
-12dB
+12dB
-12dB
+12dB
MIN
MAX
MIN
MAX
MIN
MAX
MIN
MAX
CD AUX
MIC 1
MIN
MAX
MIC 1
DISC1
DISC2
DISC2
MODE
MEMO
REPT
CLEAR
TIME
DISC
STOPPLAY
RAND
SEARCH
SCAN
3 DISC CHANGER
COMPACT DISC RECEIVER
-60
321
ACR
DIGITAL AUDIO
COMPACT
MASTER VOLUME
AM/FM DTS TUNER
S
N
COMPACT DISC RECEIVER
MODEL NO.ACR-60
MADE IN KOREA
CAUTION;
TO REDUCE THE RISK OF ELECTRIC SHOCK,
DO NOT REMOVE COVER. NO USER SERVICEABLE PARTS INSIDE.
REFER SERVICING TO QUALIFIED SERVICE PERSONNEL.
AVIS;
RISQUE DE CHOC ELECTRIOUE NE PAS OUVRIR.
CAUTION;
TO REDUCE THE RISK OF FIRE REPLACE ONLY
WITH SAME TYPE FUSE. UTILISER UN FUSIBLE DE RECHANGE
DE MEME TYPE
~AC INPUT
230V 50Hz, 85W
T1ALA / 250V
MIC 2 MIC 1MIC 3
MUTE LEVEL
MIN MAX
AUX
AMP IN
PRE AMP
OUTPUT
FUSE
ANT TERMINAL
FM(75 )
Ω
COM AM
IMPEDANCE SELECTOR
100V
(166Ω
Ω
)
70V
(82 )
4Ω
SPEAKER OUTPUT
B
A
COM
OPT
IN
1236 4710 911 8
141312
5
24
25
26
20 2117 22 2318 19
TOP COVER 046122095720
1
1
BACK CHASSIS
046102980112
046102980101
046102980114
046102980115
1
2
LEVEL KNOB
048543997313
1
CONTROL KNOB
048543998334
5
CONTROL KNOB
048543997013
3
3
4
5
6
9
1
XLR JACK(F) 3P
4438193810
3
AC INLET
4448599010
1
10
20
15
1
4465998410
ANT. TERMINAL
22
1
4465997706
SCREW TERMINAL 6P
23
1
4618001110
SELECTOR SWITCH
21
PUSH KNOB
048543997210
1
CHIME KNOB
048543997110
3
1
FRONT PANEL
048521995111
1 ACR-60
048521995112
1 ACR-120
ACR-60
RCA JACK 4438194510
19
4308999410
2
220V
230V
120V
240V
1
1
RemarkNo.
Description Part No
Q'ty
046102980116
046102980102
046102980118
046102980119
1
1
ACR-120
ACR-60
ACR-120
ACR-60
ACR-120
ACR-60
ACR-120
220V
230V
120V
240V
1
1
TACT KNOB 048545991011
3
TACT KNOB 048545989021
1
CD INLAY 048575990911
1
11
CD PACK 048522991611
1
12
CD DOOR 048543986214
1
13
TUNER PACK 048522995911
1
COVER B.K.T 046505936612
1
16
CONTROL KNOB 048543997011
1
17
18
14
TUNER INLAY 048533998513
1
8
PHONE JACK 4438097320
1
7
24
SOCKET TERMINAL
4355934707
1
AC CORD
25
26
Loading...