Hoshizaki CR3BHS, CF3BFS, CF2BFS, CR2BHS, CF1BHS Instructions

Hoshizaki America, Inc.

Hoshizaki

Commercial Series
Refrigerated Kitchen Equipment

“A Superior Degree

of Reliability”

www.hoshizaki.com

Models
Reach-In B-Series

INSTRUCTION MANUAL

Issued: 1-18-2011
Revised: 3-19-2012

WARNING

Only qualied service technicians should install and service the appliance. To
obtain the name and phone number of your local Hoshizaki Certied Service
Representative, visit www.hoshizaki.com. No installation or service should be
undertaken until the technician has thoroughly read this Instruction Manual.
Likewise, the owner/manager should not proceed to operate the appliance until the
installer has instructed them on its proper operation. Failure to install, operate, and
maintain the appliance in accordance with this manual may adversely affect safety,
performance, component life, and warranty coverage. Proper installation is the
responsibility of the installer. Product failure or property damage due to improper
installation is not covered under warranty.

Hoshizaki provides this manual primarily to assist qualied service technicians in the
installation, maintenance, and service of the appliance.

Should the reader have any questions or concerns which have not been satisfactorily
addressed, please call, send an e-mail message, or write to the Hoshizaki Technical
Support Department for assistance.

Phone: [phone]
Fax: [phone]

E-mail: [e-mail]

HOSHIZAKI AMERICA, INC.
618 Highway 74 South
Peachtree City, GA 30269
Attn: Hoshizaki Technical Support Department

Web Site: www.hoshizaki.com

NOTE: To expedite assistance, all correspondence/communication MUST include the

following information:

• Model Number

• Serial Number

• Complete and detailed explanation of the problem.

2

IMPORTANT

This manual should be read carefully before the appliance is installed and
operated. Read the warnings and guidelines contained in this booklet carefully as
they provide essential information for the continued safe use and maintenance of
the appliance. Retain this booklet for any further reference that may be necessary.

CONTENTS

Important Safety Information ................................................................................................. 4

I. Installation Instructions ....................................................................................................... 7

A. Location ........................................................................................................................ 7

B. Checks Before Installation ............................................................................................. 7

C. Setup ............................................................................................................................. 8

D. Door Reversal................................................................................................................ 9

E. Electrical Connection .................................................................................................. 10

F. Final Checklist ...............................................................................................................11

II. Operating Instructions ...................................................................................................... 12

A. Important Notes About Usage .................................................................................... 12

B. Startup ........................................................................................................................ 13

C. Controls and Adjustments ........................................................................................... 14

1. Temperature Display ............................................................................................... 14

2. Adjusting the Temperature Setpoint ....................................................................... 14

3. Changing the Temperature Display Scale (°F or °C) ............................................. 15

4. Light Switch for Glass Door Models ....................................................................... 15

D. Control Module Icons .................................................................................................. 15

E. Defrost ......................................................................................................................... 16

F. Food Storage ............................................................................................................... 16

G. Alarm Safeties ............................................................................................................. 17

H. Safety Devices ............................................................................................................ 18

I. Cooling Performance .................................................................................................... 18

J. Cabinet Condensation ................................................................................................. 18

III. Cleaning and Maintenance Instructions .......................................................................... 19

A. Cleaning ...................................................................................................................... 19

1. Exterior ................................................................................................................... 19

2. Cabinet Interior ...................................................................................................... 19

3. Door Gaskets ......................................................................................................... 19

4. Shelves .................................................................................................................. 19

5. Glass Door ............................................................................................................. 19

B. Maintenance ................................................................................................................ 20

1. Condenser .............................................................................................................. 20

2. Power Supply Connection ...................................................................................... 20

IV. Preparing the Appliance for Periods of Non-Use ............................................................ 21

V. Disposal ........................................................................................................................... 22

3

Important Safety Information

Throughout this manual, notices appear to bring your attention to situations which could
result in death, serious injury, damage to the appliance, or damage to property.

,

WARNING Indicates a hazardous situation which could result in death or

serious injury.

NOTICE Indicates a situation which could result in damage to the

appliance or property.

IMPORTANT Indicates important information about the use and care of the

appliance.

WARNING

This appliance should be destined only to the use for which it has been expressly
conceived. Any other use should be considered improper and therefore dangerous.
The manufacturer cannot be held responsible for injury or damage resulting
from improper, incorrect, and unreasonable use. Failure to install, operate, and
maintain the appliance in accordance with this manual will adversely affect safety,
performance, component life, and warranty coverage.

To reduce the risk of death, electric shock, serious injury, or re, follow basic
precautions including the following:

• Only qualied service technicians should install and service this appliance.

• This appliance must be installed in accordance with applicable national, state, and

local codes and regulations.

• To reduce the risk of electric shock, do not touch the power switch or plug with

damp hands.

• Make sure the power switch is in the "OFF" position before plugging in or

unplugging the appliance to reduce the risk of electric shock.

• Before servicing, move the power switch to the "OFF" position. Unplug the

appliance from the electrical outlet.

• This appliance requires an independent power supply of proper capacity. See

the nameplate for electrical specications. Failure to use an independent power
supply of proper capacity can result in a tripped breaker, blown fuse, damage to
existing wiring, or component failure. This could lead to heat generation or re.

• 115VAC Models: THIS APPLIANCE MUST BE GROUNDED: This appliance

is equipped with a NEMA5-15 three-prong grounding plug to reduce the
risk of potential shock hazards. It must be plugged into a properly grounded,
independent 3-prong wall outlet. If the outlet is a 2-prong outlet, it is your personal
responsibility to have a qualied electrician replace it with a properly grounded,
independent 3-prong wall outlet. Do not remove the ground prong from the plug
and do not use an adapter plug. Failure to follow these instructions may result in
death, electric shock, or re.

4

WARNING, continued

• 208-230VAC Models: THIS APPLIANCE MUST BE GROUNDED: This appliance
is equipped with a NEMA L14-20 four-prong locking, grounding plug to reduce
the risk of potential shock hazards. It must be plugged into a properly grounded,
independent 4-prong wall outlet. If the outlet is a 3-prong outlet or a 4-prong
non-locking outlet, it is your personal responsibility to have a qualied electrician
replace it with a properly grounded, independent 4-prong locking wall outlet. Do
not remove the ground prong from the plug and do not use an adapter plug. After
plugging in, twist the plug clockwise to lock it into place. Failure to follow these
instructions may result in death, electric shock, or re.

• Do not use an extension cord.

• Do not use an appliance with a damaged power cord. The power cord should not

be altered, jerked, bundled, weighed down, pinched, or tangled. Such actions could
result in electric shock or re. To unplug the appliance, be sure to pull the plug, not
the cord, and do not jerk the cord. Before unplugging a 4-prong plug, rotate the plug
counter-clockwise to unlock it.

• The GREEN ground wire in the factory-installed power cord is connected to the

appliance. If it becomes necessary to remove or replace the power cord, be sure to
connect the power cord's ground wire.

• Do not splash, pour, or spray water directly onto or into the appliance. This might

cause short circuit, electric shock, corrosion, or failure.

• Do not make any alterations to the appliance. Alterations could result in electric

shock, injury, re, or damage to the appliance.

• This appliance is not intended for use by persons (including children) with reduced

physical, sensory, or mental capabilities, or lack of experience and knowledge,
unless they have been given supervision or instruction concerning use of the
appliance by a person responsible for their safety.

• Children should be properly supervised around this appliance.

• Do not climb, stand, or hang on the appliance or door or allow children or animals to

do so. Do not climb into the appliance or allow children or animals to do so. Death or
serious injury could occur or the appliance could be damaged.

• Be careful not to pinch ngers when opening and closing the doors. Be careful when

opening and closing the doors when children are in the area.

• Open and close the doors with care. Doors opened too quickly or forcefully may

cause injury or damage to the appliance or surrounding equipment.

• Do not use combustible spray or place volatile or ammable substances in or near

the appliance. They might catch re.

• Keep the area around the appliance clean. Dirt, dust, or insects in the appliance

could cause harm to individuals or damage to the equipment.

• Do not throw anything onto the shelves or load any single shelf with more than

120lb. (54.5 kg) of product. They might fall off and cause injury.

• Do not place anything on top of the appliance. Foreign objects or moisture could

enter the appliance and result in electric shock or re.

5

WARNING, continued

• This appliance is designed only for temporary storage of food. Employ sanitary

methods. Use for any other purposes (for example, storage of chemicals or medical
supplies such as vaccine and serum) could cause deterioration of stored items.

• Do not block the cabinet air inlet or outlet, otherwise cooling performance may be

reduced.

• Do not tightly pack the cabinet. Allow some space between items to ensure good air
ow. Also allow space between items and interior surfaces.

• Do not put warm or hot foods in the cabinet. Let them cool rst, or they will raise the

cabinet temperature and could deteriorate other foods in the cabinet or overload the
appliance.

• All foods should be wrapped in plastic lm or stored in sealed containers. Otherwise

foods may dry up, pass their smells onto other foods, cause frost to develop, result
in poor appliance performance, or increase the likelihood of cross-contamination.
Certain dressings and food ingredients, if not stored in sealed containers, may
accelerate corrosion of the evaporator, resulting in failure.

• Do not store items near the air outlet. They might freeze up and crack or break

causing a risk of injury or contamination of other food.

NOTICE

• Protect the oor when moving the appliance to prevent damage to the oor.

• Keep ventilation openings, in the appliance enclosure or in the built-in structure,

clear of obstruction. Do not place anything on top of the appliance. Blockage of

airow could negatively affect performance and damage the appliance.

• To prevent deformation or cracks, do not spray insecticide onto the plastic parts or

let them come into contact with oil.

• To avoid damage to the gasket, use only the door handle when opening and closing.

6

I. Installation Instructions

WARNING

• This appliance must be installed in accordance with all applicable national, state,

and local regulations.

• Appliance is heavy. Use care when lifting or positioning. Work in pairs when

needed to prevent injury or damage.

• Do not tilt the appliance more than 45°.

A. Location

WARNING

• This appliance is not intended for outdoor use.

• Normal operating ambient temperature:

– Refrigerators and Solid Door Freezers 45°F to 100°F (7°C to 38°C)

– Glass Door Freezers 45°F to 80°F (7°C to 27°C)

Operation of the appliance, for extended periods, outside of this normal
temperature range may affect appliance performance.

For best operating results:

• The appliance should not be located next to ovens, grills, or other high heat producing

equipment.

• The location should provide a rm and level foundation for the appliance.

• The appliance should not be located in a corrosive environment.

• Minimum Clearance:

Model Side Top Rear

Refrigerators and Solid Door Freezers
Glass Door Freezers 12" (31 cm)

4" (11 cm)

10" (25 cm)

0

B. Checks Before Installation

WARNING

Refer to the nameplate for electrical specications. The nameplate is located on
the right side wall of the cabinet interior. For more electrical connection details, see

"I.E. Electrical Connection." We reserve the right to make specication and design

changes without prior notice.

Nameplate

7