Horizon PJ-100 Instruction Manual

Standard Horizon PJ-110

Air Assist Paper Jogger

Instruction Manual

PAPER JOGGER

PJ-100

Important Information

- This manual is designed to help you to install, operate and maintain the PJ-100 paper
jogger. Read, understand and keep this manual in a safe and convenient place.

- Do not operate the PJ-100 until you read and understand the instructions in this manual.

- Horizon International Inc. shall not be liable for incidental consequential damages
resulting from : improper or inadequate maintenance by customer; unauthorized modifica­tion or misuse; or operation outside of the environmental specifications for the product.

- Horizon International Inc. pursues a policy of continuing improvement in design and
performance of the product. Therefore, the product design and specifications are subject to
change without prior notice and without our legal obligation.

translated to another language without the prior written consent of Horizon International
Inc.

030221/PJ100/03E/DV

- All rights are reserved. No part of this manual may be photocopied, reproduced or

UM206006-03

1. Specifications

Model PJ-100

Voltage/ Frequency 115 V, 50 Hz / 60 Hz 5.7 A

230 V, 50 Hz / 60 Hz 2.8 A

Power Consumption 50 Hz : 580 W, 60 Hz : 580 W

Max. Sheet Size : 297 x 420 mm (11” x 17”)

Min. Sheet Size : 128 x 182 mm (5” x 7.2”)

Pile Height : 95 mm (3.7”)

Machine Weight 40 kg (88 lb)

Machine Dimensions : 489 (W) x 458 (D) x 1,135 (H) mm (19.3” x 18.0” x 44.7”)

Other : Air-assist, Vibration Timer

The machine design and specifications are subject to change without any notice.

2. Machine Descriptions

Sheet Holder

Tray Lock Lever

Foot Switch

Air Opening

Timer

Mode Select Switch

POWER

OFF

DELAY

6

84

2

10

0

12

sec

Circuit Protector (2A)

10A

2A

For vibration motor

Air Adjusting Dial

Circuit Protector (10A)
For blower

3. Selection of the Operation Mode

Select the PJ-100 operation mode with the
mode select switch.

[OFF]

PJ-100 machine power is OFF.

[Continuous Operating Mode]

While this mode is selected, jogger vi­brates continues. If the air adjusting dial is
turned ON, the air will come out with the
vibration.

[Foot Pedal Operating Mode]

When this mode is selected, jogger vibrates
only when stepping on the foot switch. If
the air adjusting dial is turned ON, the air
will come out with the vibration.

Continuous Operating Mode

OFF

Mode Select Switch

Foot switch Operating Mode

4. Air Adjusting Dial Set Up

The amount of the air can be adjusted by
the air adjusting dial.

[OFF]

Turn the dial counterclockwise until there
is a clicking sound. Air blower turns OFF
and air will not come out.

[With the air]

Turn the dial clockwise to increase the
amount of the air.

Air Adjusting Dial

5. Timer Set Up

NOTE

- Timer can be set from 0 to 12 sec.

When [Foot Switch Operating Mode] is
selected with the air on, the air comes out
and jogger vibrates during stepping the

foot switch.
The air will stop when foot switch is
released, but jogger will vibrate during
predetermined seconds.

NOTE

-Jogger vibrates during predetermined sec­onds. when [Continuous Operating Mode] is
switched to [Foot Switch Operating Mode]
during jogging.

POWER

OFF

DELAY

6

84

2

0

10

12

sec

6. Tray Angle Adjustment

Adjust tray angle according to the sheet

size and sheet thickness.

1. Loosen both tray lock levers (Left and

Right).

Caution

-Support the bottom part of the tray
with a hand when unlocking the lever,
in case tray moves by the weight of
itself.

Sheets

Tray Lock
Lever

Change the
tray angle

Foot
Switch

2. Pull up or push down the bottom part of

the tray to adjust the angle of the tray.

3. Fasten the tray lock levers.

7. Operation Procedure

1. Refer to section 5 and 7 and set up PJ-

100 in appropriate condition.

2. [When selecting the foot switch mode]

-1. Set the sheets on the tray.

-2. Step foot switch to start jogging.

[When selecting the continuous operating
mode]

-1.Select OFF operating mode with the
mode select switch.

-2. Set the sheets on the tray.

-3. Select continuous operating mode
with the mode select switch to start
jogging.

-4.Select OFF with the mode selecting
switch to stop jogging.

Sheets

8. Filter Cleaning

Clean the filter once every two weeks.

1. Pull out the filter.

CAUTION

Do not operate PJ-100 with filter re­moved.

2. Clean the filter using the vacuum cleaner.

- If the filter is dirty, wash it using the

neutral detergent. When washing the
filter, dry it completely before attaching it
back.

3. Attach the filter.

Filter

9. Consumable Parts

Air Blower

Air Blower is consumable. The lifetime of air blower is about 1500 to
2000 hours (Lifetime will differ according to the usage condition) .
Call your local dealer to change the air blower.

Page Intentionally Brank

510 Kuze Ooyabu-cho Minami-ku, Kyoto 601-8206, Japan
Phone:[phone], Fax:[phone], URL http://www.horizon.co.jp/