Holder C 9700, C 9700 H, C 9800 H, C 9.72, C 9.72 H Operating Instructions Manual
...
Date of Issue: 17.11.2006
Order No.: 145 052
Operating Instructions
C-Trac
C 9700
C 9700 H
C 9800 H
C 9.72
C 9.72 H
C 9.83 H
C 9.78 H
C 9.88 H
145 052 1
C 9700 ... C 9.88 H
Operating Instructions
Foreword
We congratulate you for having chosen a product from
HOLDER. W e would lik e you to be ab le to work safely with
your tractor and without malfunctions, and therefore we
recommend you follow the instructions in this operating
manual. You also ensure getting full value from your tractor ,
save yourself trouble and maintain your warranty. The
operating manual provides you with the required information.
Development
Due to the continuous improvements made in the design
and equipment of our tractors, deviations between this
operating manual and your tractor may be possible.
Despite taking all care possible in the creation of this manual,
we cannot fully exclude mistakes. Please note that the
technical data, illustrations and descriptions contained in
this manual are not binding and no legal claims can be made
on the basis hereof.
This operating and maintenance manual is supplied with
each tractor. Keep this in a safe place where it is av ailab le
for the driver and owner at any time. If they should get lost,
the owner must get a replacement from the manufacturer .
The personnel concerned with the operation and maintenance
of the tractors must be made acquainted with the operating
and maintenance manual. The owner must ensure that e very
operator has received, read and understood this manual.
We thank you for reading and observing this manual. In
case you still have any questions, suggestions for
improvements or discovered mistakes, please contact our
customer service.
General Notes on Service
Detach the warranty card, have it filled in by your dealer
and send the signed card to us.
Have the scheduled services carried out at the proper
intervals and have it confirmed with the dealer's stamp and
signature in this manual. Please note that warranty can only
be claimed if the regular services have been carried out as
scheduled.
Descriptions and illustrations can be related to special
equipment not installed in your tractor .
C 9700 ... C 9.88 H
Operating Instructions
2 145 052
Foreword
In case of questions regarding your tractor , please state the
following data:
T ractor Model ................................................ eg C 9800 H
Engine Serial Number .................................. eg 00542087
Chassis Serial Number................................. eg 52410101
Date of Sale, or Date of Complaint............. eg 02.01.2003
Operating Hours ............................... eg 500 service hours
Date of Issue and Manual V ersion
November 2006
We wish you safe driving and troublefree working with your
HOLDER C-T rac.
Gebrüder Holder GmbH
Max-Holder-Straße 1
72555 Metzingen
Phone (Germany) 07123 966 - 0
Fax 07123 966 - 228
E-mail: info@holder-gmbh.com
www.holder-gmbh.com
Explanations of T erminology:
DANGER
Indicates procedures which must be observed
exactly to prevent danger to the life and limbs
of persons.
CAUTION
Indicates procedures which must be observed
exactly to prevent personal injuries.
ATTENTION
Indicates procedures which must be observed
exactly to prevent damage to and/or
destruction of objects and equipment.
NOTE
Indicates technical requirements requiring
special attention.
Operating Instructions
145 052 3
C 9700 ... C 9.88 H
Foreword
Chapter PageChapter Page
Table of Contents
Maintenance Schedule................................................161
Maintenance Schedule................................................161
Maintenance during the First Period of Operation .......16 5
Maintenance as Required ...........................................167
Maintenance According to Intervals............................173
Maintenance Every 125 Service Hours.......................173
Maintenance Every 500 Service Hours.......................181
Maintenance Every 1000 Service Hours .....................187
Maintenance Every 1500 Service Hours .....................191
Maintenance Every 3000 Service Hours .....................201
Annual Maintenance ...................................................203
Maintenance Every 2 Years .......................................203
Laying Up ...................................................................205
Recommended Fuels and Lubricants..........................207
Alphabetical Index ......................................................217
Foreword ........................................................................ 1
Instructions for the Tractor ............................................ 5
Instructions for Operation .............................................. 7
Technical Data..............................................................15
Description ...................................................................28
Taking into Service.......................................................49
Operation ......................................................................65
Operating the Implements.............................................87
Other Activities...........................................................123
Taking out of Operation ..............................................137
Trailers, Towing ..........................................................139
Transport, Loading, Towing.........................................14 3
Indicators, Adjustments..............................................145
Problems, Cause, Remedy .........................................147
General Remarks on Maintenance..............................153
145 052 5
C 9700 ... C 9.88 H
Operating Instructions
Instructions for the Tractor
After the safety test, this tractor has received the operating
permit acc. to 74/150/EEC. The tractor conforms to the EMC
(Electromagnetic Compatibility) requirements of directive 89/
336/EEC. The regulations f or exhaust gas identification and
the noise emissions are observed. The tractor must be
registered and the license plate must be attached at the
front and/or rear if applicable.
Approved Applications
The tractor can be used for towing trailers and for mounting
various attachments. The maximum tr ailer load, which must
not be exceeded, is stated on the identification plate. The
transport of persons is only allowed on the passenger seat.
The tractor is designed solely for the customary type of
operation in farming and forestry, the upkeep of municipal
facilities, including operation in winter . The tractor ma y only
be used as intended and described in this operating manual.
The intended use also includes the use following the specified
maintenance and repair recommendations. The tractor,
together with its attachments, may only be used, serviced
and repaired by persons familiar with this equipment and have
been warned of possible risks. The applicable safety
regulations must be strictly observed, along with all other
recognized rules regarding industrial health, safety at work
and the highway traffic code.
Site of Operation
The tractor must be used in the open. Its operation on public
roads is allowed. When using the public highway, respect
the high way code in y our country .
Unintended Applications
Any use not intended as described as above is not
authorized. The Supplier HOLDER will not be responsible
for any hazard resulting from unintended applications. The
Supplier will also not be responsible for any resulting
damages, they shall be solely borne by the user . The tractor
may not be used for any other purposes than those described
in this manual. Do not carry persons on the loading area or
on attachments.
C 9700 ... C 9.88 H
Operating Instructions
6 145 052
Instructions for the Tractor
Residual Hazards and Risks
Despite all care being taken and in conformance with standards
and regulations, it is not possible to exclude all risks in the
handling of the tractor.
The tractor and all other system components conform to
currently applicable safety regulations . Nev ertheless, a residual risk cannot be excluded even by authorized use of
the tractor and observation of all the safety notices given.
For this reason, persons standing in the area of the tractor
and attachments must ex ercise particular caution in order
to be able to be able to react directly in case of a malfunction,
an incident, a failure, etc.
CAUTION
All persons standing in the area of the tractor
and implements must be advised of the risks
which can result from their operation.
Furthermore, read and observe the other
safety rules and regulations contained in this
operating manual.
The risks can include:
- Unexpected movements of the implements and
tractor.
- Escape of fuel and lubricants due to leaks, broken
lines and reservoirs, etc.
- Risk of accidents when driving, steering and braking
due to unfavourable ground conditions such as
slopes, icy roads, unevenness or poor visibility, etc.
- Falling, stumbling, etc. when moving on the tractor,
particularly when it is wet.
- Fire and explosion hazards due to the battery and
electric currents.
- Danger of poisoning through Diesel exhaust gases
- Danger of fire through Diesel fuel and oils
- Human errors due to non-observance of the safety
rules.
Note on Disposal of T ractor
Your tractor is made of different materials. Each mater ial
should be disposed of/treated/recycled according to different regional/national regulations. We recommend contacting
a salvage company.
145 052 7
C 9700 ... C 9.88 H
Operating Instructions
Instructions for Operation
Driver's license
For the operation of this vehicle you need a driver's license
dependent of the maximum speed and the permissible total
weight of the vehicle or the combination. See the tables
below . Please observe y our national laws.
Driver's license classes (Germany only)
T ractors for farming and f orestry (also with implements)
Maximum Speed
(dependent on type)
Maximum Total Weight
Driver's License Class
(Minimum Requirements)
Former Driver's License
Class
up to 32 km/h
no limitation B, L, T 1, 1a, 1b, 2, 3, 4, 5
over 32 km/h
up to 3.5 tons B
T: 60 km/h, under 18 years
only 40 km/h
2, 3
over 3.5 tons
to 7.5 tons
C1
T: 60 km/h, under 18 years
only 40 km/h
2, 3
C 9700 ... C 9.88 H
Operating Instructions
8 145 052
Instructions for Operation
Single-axle Trailers or Tw o-axle T railers with an Axle Base of up to max. 1 m
25
25
25
25
Maximum Total Weight
Driver's License Class
(Minimum Requirements)
Former Driver's License
Class
up to 750 kg trailer weight B, C1, C, T
L: only with additional
sign and maximum tractor
speed of 25 km/h
(depending on type)
1, 1a, 1b, 2, 3, 4, 5
over 750 kg trailer weight BE, C1E, CE, T
B, C1, C: only up to
3.5 tons adm. total weight of
the combination and adm.
total weight of trailers
dead weight of tractor;
otherwise:
C1E: only up to 12 tons adm.
total weight of combination
and adm. total weight of
trailer dead weight of
tractor; otherwise:
L:
1, 1a, 1b, 2, 3, 4, 5
145 052 9
C 9700 ... C 9.88 H
Instructions for Operation
Operating Instructions
Multiple-axle Trailers and Two-axle Trailers with an Axle Base over 1 m
25
25
25
25
25
Maximum Total Weight
Driver's License Class
(Minimum Requirements)
Former Driver's License
Class
up to 750 kg trailer weight B, C1, C, T
L: only with additional
sign and maximum tractor
speed of 25 km/h
(depending on type)
2, 3
over 750 kg trailer weight
up to 3.5 tons Maximum Total
Weight
up to 12 tons Maximum Total
Weight
BE, C1E, CE, T
B, C1, C: only up to
3.5 tons adm. total weight of
the combination and adm.
total weight of trailers
dead weight of tractor;
otherwise:
C1E: only up to 12 tons adm.
total weight of combination
and adm. total weight of
trailer dead weight of
tractor; otherwise:
L:
2, 3
1, 1a, 1b, 4, 5:
in each case
C 9700 ... C 9.88 H
Operating Instructions
10 145 052
Instructions for Operation
Two T railers behind Tractors for Farming and Forestry
25
25
25
25
Maximum Total Weight
Driver's License Class
(Minimum Requirements)
Former Driver's License
Class
up to 3.5 Maximum Total
Weight
up to 12 Maximum Total
Weight
BE, C1E, CE, T
B, C1, C
in each case only up to
3.5 tons adm. total weight of
the combination and adm.
total weight of trailers
dead weight of tractor;
otherwise:
C1E:
only up to 12 tons adm. total
weight of combination and
adm. total weight of trailer
dead weight of tractor;
otherwise:
L:
2, 3
1, 1a, 1b, 4, 5,
145 052 11
C 9700 ... C 9.88 H
Instructions for Operation
Operating Instructions
Safety
General Notes on Safety
• Observe the VSG 3.1 (German regulations for safety
and health protection).
• Do not allow children under 16 to use the tractor.
• When using the public highway, respect the highway
code.
• Do not allow anyone to stand around where they might
get hurt.
• Do not run the engine in enclosed spaces.
• Exercise extreme caution when handling fuels - there
is a high risk of fire.
• Exercise extreme caution when handling fuels and
oils; these can be poisonous and caustic.
• To prevent the danger of fire, keep the tractor and
implements clean.
• Observe the warning notices and symbols on your
tractor.
Working Clothes
• Only wear snugly fitting clothing when working with
the tractor.
• If necessary, wear suitable headwear to keep loose
hairs and pigtails from being caught in rotating parts.
• Do not wear any jewellery and similar objects, eg
rings, when working with the tractor.
Safety Notes for Later Installations
The tractor has electronic components whose proper
functioning can be influenced by the electromagnetic
emissions of other equipment. These influences can
endanger persons if the following notes on safety are not
observed.
• Have your equipment installed only by an authorized
workshop.
• Before the installation of electric or electronic equipment connected to the tractor's electrical system,
check if these installations can interfere with the
tractor's electronic system or other system components.
C 9700 ... C 9.88 H
Operating Instructions
12 145 052
Instructions for Operation
• The installed equipment must conform to the applicable EMC directive 89/336/EU and carry the CE
symbol.
• If you must install a mobile communications system
(or have it installed) (eg radio, mobile telephone), the
following requirements must be met:
- Only approved equipment (eg BTZ approval in Germany) may be installed.
- The equipment must be installed permanently.
- The operation of portable or mobile equipment inside
the vehicle is only allowed if connected to a permanently installed external antenna.
- The transmitting section must be installed away from
the tractor's electronic system.
- When installing the antenna, install it properly and
with a good connection vehicle ground.
- Do not exceed the maximum permissible current
rating of the wiring according to the installation instructions of the equipment manufacturer.
Safety Instructions for Handling Fuels and
Oils
Gear Oil, Engine Oil, Diesel Fuel
Do not eat, drink or smoke when working with
the product. Prolonged intensive contact may
cause degreasing and irritation of the skin.
Wash skin with soap and water , use skin care
products. If required, wear protective gear.
Change soaked clothes and shoes immediately. If vapour or mist was inhaled, breathe
fresh air. Consult a doctor if the complaint
persists. After contact with the eyes, rinse
the eyes thoroughly with water (at least 10
minutes), then consult an eye doctor . If sw allowed, do not force to vomit, but consult a
doctor. Danger of slipping on the spilled product, especially in connection with water.
Oils can contaminate water. Always keep
them in approved containers. Avoid spilling
oils. Remove spilled fluids at once with an oil
binding agent and dispose of in accordance
with laws and regulations. Discard drained
fluids as specified. Observe all applicable laws
and regulations. Oils are inflammable. Do not
145 052 13
C 9700 ... C 9.88 H
Instructions for Operation
Operating Instructions
let them come in contact with hot engine parts
as fire can result.
Hydraulic Oil, Brake Fluid
During tractor operation, these fluids are under
pressure and a health hazard. Do not spill these
fluids! Remove any spilled fluid at once with an
oil binding agent and discard as specified. Dispose of old fluids as specified and follow the
applicable laws and regulations. Do not allow
them to come in contact with hot engine parts
as fire can result. Danger of fire!
Av oid contact with the skin. A void the inhalation
of spray f og. The penetration of the fluids into
the skin is especially dangerous if the fluids
are under high pressure and escape from the
hydraulic system through leaks. Seek medical
aid at once in case of such injuries.
If injuries cannot be excluded, use suitable
protectors (for example, protective gloves,
glasses and skin protection and care creams).
Battery Acid
Battery acid contains dissolved sulphuric
acid. This acid is poisonous and caustic. When
working with battery acid, always wear
protective clothing and eye protectors. Do not
allow acid to contact clothing, skin or eyes.
In case of contact, wash directly with ample
clean water. If personal injuries exist, seek
medical aid at once. Neutralize spilled battery
acid immediately .
Discard the old battery fluid as specified.
Observe laws and regulations.
Emissions
Exhaust Gases
During operation, the engine emits exhaust
gases into the environment. The e xhaust gas
mainly consists of water vapour, carbon
dioxide (CO
2
), carbon monoxide (CO),
hydrocarbon (CH), nitrogen o xide (NOX) and
soot. The components CO , CH and NOX are
poisonous or hazardous to health and should
not be inhaled in high concentrations. Soot is
a carcinogenic material; particularly the
C 9700 ... C 9.88 H
Operating Instructions
14 145 052
Instructions for Operation
particles in the exhaust gases can cause
cancer. For this reason the engine may not
be operated in enclosed spaces.
Heat
The exhaust gases are very hot and can ignite
inflammable material. The e xhaust gas pipe
should therefore be kept away from ignitable
material.
Battery
During charging, the battery produces a mixture of oxygen and hydrocarbon (detonating
gas). This mixture of gases is explosive and
may not be ignited. The risk of explosion can
be avoided with proper ventilation and keeping naked flames away. Observe the safety
rules when handling the battery.
145 052 15
C 9700 ... C 9.88 H
Operating Instructions
Technical Data
Model Variants
Model Transmission Type of Drive Type of Engine Engine Performance
C 9700
Mechanical Reversing
Gearbox
Mechanical BF4M1011 53.5 kW 72 HP (DIN)
C 9700 H Hydrostatic transmission Hydrostatic BF4M1011 53.5 kW 72 HP (DIN)
C 9800 H Hydrostatic transmission DUAL DRIVE* BF4M1011F 61 kW 83 HP (DIN)
C 9.72
Mechanical Reversing
Gearbox
Mechanical BF4M1011 53.5 kW 72 HP (DIN)
C 9.72 H Hydrostatic transmission Hydrostatic BF4M1011 53.5 kW 72 HP (DIN)
C 9.83 H Hydrostatic transmission DUAL DRIVE* BF4M1011F 61 kW 83 HP (DIN)
C 9.78 H Hydrostatic transmission Hydrostatic BF4M2011 57 kW 78 HP (DIN)
C 9.88 H Hydrostatic transmission DUAL DRIVE* BF4M2011F 65 kW 88 HP (DIN)
* mechanical + hydrostatic
^
=
^
=
^
=
^
=
^
=
^
=
^
=
^
=
C 9700 ... C 9.88 H
Operating Instructions
16 145 052
Technical data
T ractor Dimensions
Sketch
g
b
d
c
100
(3,9")
200
(7,8")
3980-4100
(156,5-161,4")
3900-4020
(153,5-158,3")
1110
1030
970
(43,1")
(40,5")
(38,2")
1827
(72")
1040-1160
(40,9-45,6")
1090
(Cab for 1 person)
1250
(42,9")
(49,3")
(Cab for 2 persons)
f
a
e
Bild_194
Data in brackets are American dimensions
Operating Instructions
145 052 17
C 9700 ... C 9.88 H
Technical data
Trailer Coupling
Tires Type Overall Height Avg. Height of
Seat
Ground
Clearance
Lowest Position Highest Position Height of Body
a
mm (Inches)
b
mm (Inches)
c
mm (Inches)
d
mm (Inches)
d
mm (Inches)
g
mm (Inches)
10
.
5-18 MPT S
524-31-6 2130 (83.8) 1050 (41.3) 230 (9) 575 (22.4) 975 (38.2) 1130 (44.5)
10
.
5-18 MPT
524-31-1 2130 (83.8) 1050 (41.3) 230 (9) 575 (22.4) 975 (38.2) 1130 (44.5)
36x13
.
50-15
524-31-8 2100 (82.5) 1020 (40.1) 200 (7.9) 545 (21.3) 945 (37.1) 1095 (43.1)
400/60-15
.
5
524-31-5 2095 (82.3) 1030 (40.5) 195 (7.5) 540 (21.2) 940 (37) 1095 (43.1)
33x12,50-R15 524-31-7 2090 (82.2) 1020 (40.1) 190 (7.3) 535 (21.0) 935 (36.6) 1090 (42.9)
33/18LL-16.1 524-31-9 2090 (82.2) 1020 (40.1) 190 (7.3) 535 (21.0) 935 (36.6) 1090 (42.9)
33x12
.
50-15
524-31-4 2075 (81.4) 1010 (39.7) 180 (7) 525 (20.6) 925 (36.3) 1075 (42.3)
33x15
.
50-15
524-31-3 2075 (81.4) 1010 (39.7) 180 (7) 525 (20.6) 925 (36.3) 1075 (42.3)
31x15
.
50-15
524-31-2 2065 (81.1) 980 (38.6) 165 (6.4) 510 (20) 910 (35.8) 1060 (41.7)
T able of Dimensions
C 9700 ... C 9.88 H
Operating Instructions
18 145 052
Technical data
Tires
Min. Turning
Radius to DIN
7020
(measured at
outermost
point of
vehicle)
Normal Track Width
(
Flange size
1034
)
With Hub Spacers
Type 5234-80= 45 mm Type 526-34-70= 80 mm
Track Width e Overall Width f Track Width e Overall Width f Track Width e Overall Width f
m
min.-mmmax.-
mm
min.
-
mm
max.-mmmin.-mmmax.-
mm
min.
-
mm
max.-mmmin.-mmmax.-
mm
min.
-
mm
max.-
mm
36x13.50-15
7.28 m
f. track w. 1084
- 1084 - 1439 1090 1174 1445 1529 1160 1244 1515 1599
10.5-18 MPT S
7.10 m
f. track w. 960
960 1124 1230 1394 1124 1140 1320 1484 1120 1284 1390 1554
10.5-18 MPT
7.14 m
f. track w. 1034
1034 1050 1304 1320 1050 1214 1394 1410 1194 1210 1464
1480
400/60-15.5
7.30 m
f. track w. 1070
- 1070 - 1470 1106 1160 1506 1560 1176 1230 1576 1630
33x12.50 R15
7.15 m
f. track w. 1000
1000 1084 1320 1404 1090 1174 1410 1494 1160 1244 1480 1564
33x12.50-15
7.15 m
f. track w. 1000
1000 1084 1320 1404 1090 1174 1410 1494 1160 1244 1480 1564
33x15.50-15
7.24 m
f. track w. 1124
* 992 1124 * 1382 1514 1052 1214 1442 1604 1122 1284 1512 1674
33/18LL-16.1
7.45 m
f. track w. 1164
- 1164 - 1636 - 1254 - 1726 - - - -
31x15.50-15
7.30 m
f. track w. 1124
* 962 1124 * 1332 1494 1052 1214 1422 1584 1122 1284 1492 1654
*Snow chains not possible
* With track spacer type 526-34-75 (15 mm per wheel)
Track Widths
Operating Instructions
145 052 19
C 9700 ... C 9.88 H
Technical data
All Tractors Weight in kg
Permissible total weight
4500 kg (9920.6 LBS)
Permissible load on front axle
*
2660 kg - 2700 kg
(5864 LBS - 5952 LBS)
Permissible load on rear axle
*
2660 kg - 2700 kg
(5864 LBS - 5952 LBS)
Permissible supporting load on
trailer hitch
800 kg (1764 LBS)
* With 33x12.50 R15 tires
Accessories Total Front Rear
Creep speed gear
13 kg
(28.6 LBS)
10 kg
(22 LBS)
3 kg
(6.6 LBS)
Rear lift
77 kg
(169.7 LBS)
-25 kg
(-55 LBS)
102 kg
(224.8 LBS)
Loading platform
75 kg
(165.3 LBS)
0 k g
(0 LBS)
75 kg
(165.3 LBS)
Weights w/o loading platform and rear lift
Tires 36x13.5-15
10.5-18 MPT
400/60-15.5
33x12.50 R15 33x12.50-15
31x15.50-15
33x15.50-15
33/18LL-16.1
Empty weight (incl.
driver 75 kg)
C9700
C9.72
C9700H
C9800H
C9.72H
C9.78H
C9.83H
C9.88H
C9700
C9.72
C9700H
C9800H
C9.72H
C9.78H
C9.83H
C9.88H
C9700
C9.72
C9700H
C9800H
C9.72H
C9.78H
C9.83H
C9.88H
C9700
C9.72
C9700H
C9800H
C9.72H
C9.78H
C9.83H
C9.88H
C9700
C9.72
C9700H
C9800H
C9.72H
C9.78H
C9.83H
C9.88H
C9700
C9.72
C9700H
C9800H
C9.72H
C9.78H
C9.83H
C9.88H
Total: k g
2430
(5351)
2620
5776)
2440
(5319)
2630
(5198)
2390
(5269)
2580
(5687.8)
2380
(5246.9)
2570
(5665.8)
2410
(5313.1)
2600
(5732)
2470
(5445.4)
2660
(5864.2)
Front: kg
1275
(2810.8)
1390
(3064.4)
1280
(2821.8)
1395
3015)
1255
(2766.7)
1370
(3020.3)
1250
(2755.7)
1365
(3009.3)
1265
(2788.8)
1380
(3042.3)
1295
(2855)
1410
(3108.5)
Rear: kg
1155
(2546.3)
1230
(2711.6)
1160
(2551.3)
1235
(2122.6)
1135
(2502)
1210
(2667.5)
1130
(2491.2)
1205
(2656.5)
1145
(2524.3)
1220
(2689.6)
1175
(2590.4)
1250
(2755.7)
Weights
C 9700 ... C 9.88 H
Operating Instructions
20 145 052
Technical data
Tires
The pressure can deviate, depending on the make and use of the tyres – observe the instructions of the tyre manufacturers.
Type of Tire Ply Profile Tube Wheel Weights
Inflation Pressure
(in bar)
Empty weight max. loading
front rear Type Weight
10.5-18 MPT S 6 Cleat profile yes 1.5 (22 PSI) 1.75 (25 PSI) 1.9 (27 PSI) 524-34-1 approx. 45 kg (100 LBS)
10.5-18 MPT 6 Cleat profile yes 1.5 (22 PSI) 1.75 (25 PSI) 1.9 (27 PSI) 524-34-1 approx. 45 kg (100 LBS)
31x15.50-15* 8 Profile no 2.0 (29 PSI) 3.2 (46 PSI) 3.2 (46 PSI) 524-34-1 approx. 45 kg (100 LBS)
33x15.50-15 4 Profile no 1.0 (14 PSI) 1.6 (23 PSI) 1.6 (23 PSI) 524-34-1 approx. 45 kg (100 LBS)
33x12.50-15 6/8 (M+S)/Profile no 1.4 (20 PSI) 1.9 (27 PSI) 2.0 (29 PSI) 524-34-1 approx. 45 kg (100 LBS)
33x12.50-R15* 6 M + S no 1.6 (23 PSI) 2.5 (36 PSI) 2.5 (36 PSI) 524-34-1 approx. 45 kg (100 LBS)
36x13.50-15 4 Lawn no 1.0 (14 PSI) 1.2 (17 PSI) 1.4 (20 PSI) 524-34-1 approx. 45 kg (100 LBS)
400/60-15.5 6 Profile yes 1.8 (26 PSI) 1.8 (26 PSI) 2.0 (29 PSI) 524-34-1 approx. 45 kg (100 LBS)
33/18LL-16.1 10 Lawn no 1.2 (17 PSI) 1.8 (26 PSI) 2.0 (29 PSI) 524-34-1 approx. 45 kg (100 LBS)
NOTE: Observe prescribed inflation pressure with maximum axle load and when driving on roads.
* NOTE: Admissible maximum axle loading is 2660 kg.
Operating Instructions
145 052 21
C 9700 ... C 9.88 H
Technical data
Engine Specifications
C 9700/9.72
C 9700/9.72H
C 9800/9.73H C 9.78H C 9.88H
Manufacturer Deutz AG Deutz AG Deutz AG Deutz AG
Type BF4M1011 BF4M1011F BF4M2011 BF4M2011
Mode of operation Four-stroke Diesel Four-stroke Diesel Four-stroke Diesel Four-stroke Diesel
Number of cylinders 4 4 4 4
Cubic capacity 2914 2914 3108 3108
Fuel consumption
223g/KW-h at
1500-1750 rpm
222g/KW-h
at 1750-1850 rpm
216g/KW-h
at 1750-1850 rpm
216g/KW-h
at 1550-1650 rpm
Rated speed
2500
rpm
2600 rpm
2500 rpm 2800 rpm
Maximum idling speed 2600 rpm 2750 rpm
2750
rpm
3050 rpm
Minimum idling speed 900 rpm 900 rpm 900 rpm 900 rpm
Power at n=2800 rpm 53.5 KW (72 HP) 61 KW (83 HP) 57 KW (78 HP) 65 KW (88 HP)
C 9700 ... C 9.88 H
Operating Instructions
22 145 052
Technical data
Transmission Unit Gearbox
Hydrosta-
tic Drive
Hydrosta-
tic Drive
Hydrosta-
tic Drive
Dual
Drive
Dual
Drive
Dual
Drive
Engine Output
kW 53.5
53.5
57
61 65
53.5
57
61 65
Engine speed
rpm 2500 2500 2600 2800 2500 2600 2800
Tires Type
36x13.50-15
524-31-8 km/h 36.8 30.8 32.0 34.4 38.4 39.9 43.0
10.5-18 MPT
524-31-1/-6 km/h 35.9 30.1 31.3 33.7 37.6 39.1 42.1
400/60-15.5
524-31-5 km/h 34.1 28.6 29.7 32.0 35.7 37.1 40.0
33x12.50 R15
524-31-7 km/h 33.3 27.9 29.0 31.2 34.8 36.2 39.0
33x12.50-15
524-31-4 km/h 32.4 27.2 28.3 30.4 33.9 35.3 38.0
33x15.50-15
524-31-3 km/h 32.4 27.2 28.3 30.4 33.9 35.3 38.0
33/18LL-16.1
524-31-9 km/h 31.8 26.7 27.8 29.9 33.3 34.7 37.3
31x15.50-15
524-31-2 km/h 30.5 25.1 26.1 28.1 31.3 32.6 35.1
Theoretical Driving Speeds
Operating Instructions
145 052 23
C 9700 ... C 9.88 H
Technical data
Assembly Suppl. Information Description
Mechanical gearbox
16 forward gears/16 reverse gears with planetary axles
Hydrostatic drive
Infinitely variable driving speed, 2 mechanical speed ranges
Power take-offs
2 PTOs (front and rear) Rotating Direction: clockwise when looking at
end of shaft
- RPM, front 540 rpm at 2200 engine rpm, 1000 rpm at 2390 engine rpm
- RPM, rear 1000 rpm at 2360 engine rpm
- Wedge shaft profile 1 3/8 " (6) DIN 9611
PTO clutch Multiple disk wet clutch
Differential lock Acts simultaneously on front and rear axles
Fuel system
Fuel tank Diesel fuel 86 l (22.7 USGAL.)
Tec hnical Data/Filling Quantities
C 9700 ... C 9.88 H
Operating Instructions
24 145 052
Technical data
Assembly Suppl. Information Description
Steering
- Type Hydrostatic with 2 double-acting steering rams
- Steering valve Orbitrol OSPC 125 LS
Brakes
- Service brake Multiple-disk brakes, wet, acting on all 4 wheels
- Activation Hydraulic
- Parking brake Multiple-disk brakes, wet, acting on all 4 wheels
- Activation Mechanical
Trai ler hi tch
- Make Cramer, height-adjustable
Front lift
- Make 3-point, upper link adjustable
- Mounting Category I and II
- Lifting power 27000 N (measured at installation points)
- Cylinders 2 double-acting cylinders
Operating Instructions
145 052 25
C 9700 ... C 9.88 H
Technical data
Assembly Suppl. Information Description
Rear lift
- Model HOLDER 3-point standard
- Mounting Category I and II
- Lifting power 15700 N (at installation points)
- Cylinders 2 double-acting cylinders
Flatbed body
- Dimensions L x B x H 1530 x 1140 x 215 mm
- Payload 1400 kg
Drive Hydraulics
Variable pump Hydromatik
- Model A11 VG 50 EP / A4 VG 40 EP
- Flow rate 160 l/min
- Operating pressure 300 bar (max. 350 bar) / 380 bar (max. 430 bar)
Variable motor Hydromatik
- Model A6 VM 55 EP
- Displacement 26.1 - 55 cm
3
/rev
Hydraulic oil tank 19 l
C 9700 ... C 9.88 H
Operating Instructions
26 145 052
Technical data
Assembly Suppl. Information Description
Hydraulics for implements
(with steering)
Pump Sundstrand
- Make -
- Flow rate 17 cm
3
/rev (42.5 l/min at 2500 engi ne r pm)
- Operating pressur e 180 -190 bar
Hydraulic oil tank 45 l (11.89 GAL.)
Electrical System
- Operating voltage 12 VDC
- Batter y 12 V / 88 Ah
- A/C alter nat or 14 V / 60 A
- Star ter 12 V / 2.4 kW
Whole Vehicle
- Ambient temperature range - 30° to + 50°C
Operating Instructions
145 052 27
C 9700 ... C 9.88 H
Technical data
Noise Level
The tractor emits the following noise level (measured at the
driver's ear) according to EU Standard 77/311/EEC;
measurement according to Appendix II.
T able of Noise Levels and Absorption Rating
Exhaust Gas Identification
The absorption rating is stated on the identification plate.
Model Engine Type Engine Output Noise Level dB(A) Absorption rating
Cabin
open*
Cabin
closed
C 9700 BF4M1011 53.5 kW (72 HP) 79 78 2.1
C 9700 H BF4M1011 53.5 kW (72 HP) 79 78 2.1
C 9800 H BF4M1011F 61 kW (83 HP) 79 78 2.1
C 9.72 BF4M1011 53.5 kW (72 HP) 79 78 2.1
C 9.72 H BF4M1011 53.5 kW (72 HP) 79 78 2.1
C 9.83 H BF4M1011F 61 kW (83 HP) 79 79 2.1
C 9.78 H BF4M2011 57 kW (78 HP) 79 79 1.8
C 9.88 H BF4M2011F 65 kW (88 HP) 79 79 2.0
*Roof vent and side window open
C 9700 ... C 9.88 H
Operating Instructions
28 145 052
1
2
3
4
5
6
7
8
9
10
11
12
13
15
14
Description
Views of T ractor
Front Left View
1 Turn signal, position
light
2 Headlight, top
3 Driver's cab
4 Dump body (dump)
5 Rear of vehicle
6 Engine oil dipstick
7 Battery isolating switch
8 Rear axle
9 Hydraulic oil tank and
filler neck (drive
hydraulics)
10 Front axle
11 Hydraulic couplings for
implements*
12 Front lift - lower link
support
13 Upper link support
14 Headlight
15 Windshieldwiper /
washer
* Option
Loading...