Hestan GCD30, GCR30, GCD36, GCR36, GCR42 Use & Care Guide

OUTDOOR COOKING

Grill Cart

GCD / GCR

Use & Care Manual

Installation & Operation

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.

IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Do not try lighting this appliance without reading the LIGHTING INSTRUCTIONS section of this manual.

For outdoor use ONLY. This cooking appliance is not intended to be installed in or on recreational vehicles, and/or boats.

DANGER

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

Flammable Gas - disconnect all propane or natural gas supplies to this unit before servicing.

Electrical Parts & Components – disconnect all power supplies and batteries before servicing.

READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE USING YOUR GRILL TO REDUCE THE RISK OF FIRE, BURN HAZARD, OR OTHER INJURY. KEEP THIS MANUAL FOR FUTURE REFERENCE.

TABLE OF CONTENTS

4 MODEL NUMBERS

5 INTRODUCTION

5 PRECAUTIONS

6 REGULATORY / CODE REQUIREMENTS

7 PORTABLE LP CYLINDERS

8 CART & GRILL ASSEMBLY

16 GAS CONNECTIONS

17 PARTS LIST

17 SERVICE

17 WARRANTY

MODEL NUMBERS

Double Door Model Double Door & Drawer Model

CART MODELS

Model No. Description

GCD30 30” DOUBLE DOOR TOWER CART

GCR30 30” DOUBLE DRAWER AND DOOR TOWER CART

GCD36 36” DOUBLE DOOR TOWER CART

GCR36 36” DOUBLE DRAWER AND DOOR TOWER CART

GCR42 42” DOUBLE DRAWER AND DOOR TOWER CART

INTRODUCTION

Thank you for choosing the Hestan Outdoor Grill Cart. We have written this Installation Guide to help you properly install a Hestan Grill for years of safe and enjoyable use.

Keep this guide handy, as it will help answer questions that may arise as you use your new Cart.

Inspect the product to verify that there is no shipping damage. If any damage is detected, call the shipper and initiate a damage claim.

Hestan Commercial Corp. is not responsible for shipping damage. DO NOT discard any packing material (box, pallet, straps) until the unit has been inspected.

PRECAUTIONS - BEFORE YOU USE YOUR GRILL CART

When properly cared for, your Hestan grill cart will provide safe, reliable service for many years. However, extreme care must be used since the grill produces intense heat, which can cause serious injury or even death if the instructions are not followed carefully. When using this appliance, basic safety practices must be followed as outlined below.

1. NEVER LEAVE THE GRILL UNATTENDED WHILE COOKING.

2. Children should not be left alone or unattended in an area where the grill is being used. Never allow them to sit, stand, or play on or around the grill. Do not store items of interest to children around or below the grill or in the cart. Never allow children to crawl inside of the cart.

3. The grill and cart shall be used only outdoors and shall not be used in buildings, garages, sheds, breezeways, or any enclosed areas. Do not operate the grill under unprotected, combustible construction. Use only in well-ventilated areas. See the INSTALLATION section of the Hestan Grill manual for more information.

4. Do not use the grill unless a leak check has been performed on all gas connections. See the GAS CONNECTIONS section of the Hestan Grill manual.

5. Portable LP cylinders - Always shut off the main valve on the liquid propane (LP) cylinder after each use. Never use a dented or rusted LP cylinder. Never attach or disconnect an LP cylinder, or move or alter gas fittings when the grill is in operation or is hot.

6. Inspect LP gas supply hose prior to each use of the grill. The hose must be kept away from heated areas of the grill. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be replaced before using the grill. The hose and LP regulator are supplied as a complete assembly and must be replaced together. Do not attempt to repair or replace the hose itself. Contact your Hestan dealer for genuine replacement P/N 014309.

7. Keep any electrical supply cord away from the heated areas of the grill. The cord is provided with a 3-prong grounding plug which should not be removed or altered. Do not use this appliance with an ungrounded, 2-prong adapter. The cord must be plugged into a properly grounded GFCI-protected outlet. See INSTALLATION section of the Hestan Grill manual.

8. Keep the areas surrounding the grill free from combustible materials, trash, or combustible fluids and vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion gases (rear) and ventilation airways (front). Keep the rear area free and clear of debris, extra LP cylinders, etc. Do not block the ventilation louvers of the cart.

9. If your grill is stored indoors, ensure that it is cool before moving. If propane is used, the LP cylinder must be disconnected and stored OUTSIDE in a well-ventilated area, out of the reach of children. A grill cover is recommended, even when stored indoors.

10. Never move the grill when hot. When in use, portions of the grill are hot enough to cause severe burns.

PRECAUTIONS - BEFORE YOU USE YOUR GRILL CART

11. Do not repair or replace any part of the cart unless specifically recommended in this manual.

All other warranty and non-warranty service should be referred to and performed by a qualified technician.

12. Clean the grill and cart with caution. Avoid steam burns - do not use a wet sponge or cloth

to clean the grill or cart while it is hot. Some cleaners produce noxious fumes or can ignite when applied to a hot surface. Be sure all grill controls are turned off and the grill and cart are cool before using any type of aerosol cleaner on or around the grill and cart. The chemical that produces the spraying action could, in the presence of heat, ignite or cause metal parts to corrode. Clean and perform general maintenance on the grill and cart twice a year. Watch for corrosion, cracks, or insect activity. See the CLEANING AND MAINTENANCE section of the Hestan Grill manual for more information.

13. Do not push down on an extended drawer as this may result in damage to the drawer slides,

or in extreme cases, could cause the cart to tip forward causing injury. Do not overload the drawers as this may cause damage or personal injury. The maximum load rating of the drawer is 35 lbs. (15.8 kg).

14. Do not overload the side shelves of the cart as this may result in damage to the unit, or

personal injury. Do not sit, step, or push down on the side shelves. The maximum load rating of the side shelf is 25 lbs. (11.3 kg).

(continued)

REGULATORY / CODE REQUIREMENTS

Installation of this cooking appliance must be made in accordance with local codes. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code

ANSI Z223.1/NFPA 54

Storage and Handling Code

All Electrical Components must be electrically grounded in accordance with local codes or in the absence of local codes with the National Electrical Code code

CSA C22.1

STATE OF MASSACHUSETTS Massachusetts requires all gas be installed using a plumber or gas fitter carrying the appropriate Massachusetts license. All permanently installed natural gas or propane installations require a T handle type manual gas valve be installed in the gas supply line to this appliance. This does not apply to portable propane installations using a 20lb. cylinder.

CALIFORNIA PROPOSITION 65 - WARNING The burning of gas cooking fuel generates toxic by-products, which are on the list of substances which are known by the State of California to cause cancer or reproductive harm. California law requires businesses to warn customers of potential exposure to such substances. To minimize exposure to these substances, always operate this unit according to the use and care manual, ensuring you provide good ventilation when cooking with gas. This warning is issued pursuant to California Health & Safety Code Sec. 25249.6.

, Natural Gas and Propane Installation code

B149.2

ANSI/NFPA 70

CSA B149.1

, or Canadian Electrical

, or Propane

+ 14 hidden pages

Hestan GCD30, GCR30, GCD36, GCR36, GCR42 Use & Care Guide

Specifications and Main Features

Frequently Asked Questions

User Manual