Herkules SCB-06 User Manual

Herkules Equipment Corporation

2760 Ridgeway Court

Walled Lake, MI 48390-1662

Phone: [phone]

Fax: [phone]

www.herkules.us

SAFETY DATA SHEET

SCB01 & SCB06 Sparkle Clean Blast

SECTION 1 – CHEMICAL PRODUCT and COMPANY IDENTIFICATION

Product Family Name: SCB01 1qty Sparkle Clean Blast

SCB06 6qty Sparkle Clean Blast
Application: paint clean up
Manufacturer/Supplier: Herkules Equipment Corporation
Emergency Phone Number: 734-721-5930

SECTION 2 – HAZARDS IDENTIFICATION

Hazard Classification:
Skin corrosion/irritation Category 2
Serious eye damage/eye irritation: Category 2A
Reproductive Toxicity: Category 2
Specific target organ toxicity
(single exposure): Category 3
Specific target organ toxicity
(repeated exposure): Category 2
Aspiration toxicity: Category 1
Flammable aerosols: Category 1
Gases under press: Compressed Gas

Hazard Statements:
Causes skin irritation
Causes serious eye irritation
Suspected of damaging fertility or the unborn child.
May cause damage to organs (Blood, Central Nervous System, Eyes, Hematopoietic System, Kidney, Liver,
Respiratory System, Skin, and reproductive System) through prolonged or repeated exposure.
May be fatal if swallowed and enters the airways
Extremely Flammable Aerosol
Contains gas under pressure; may explode if heated.

Hazard Symbols:

Precautionary Statements
Prevention: Obtain special instructions before use; Do not handle until all safety precautions have been read and
understood; Wear protective gloves/protective clothing/eye protection/face protection; Wash face, hand and any
exposed skin thoroughly after handling;
Do not breathe dust/fume/gas/mist/vapors/spray; Use only outdoors or in well-ventilated area; Keep away from
heat/sparks/open flames/hot surfaces- No smoking; Do not spray on an open flame or other ignition source;
Pressurized container; do not pierce or burn, even after use.

l156_01_herkules_sparkle_clean_blast_safety_data_sheet pg. 1

Herkules Equipment Corporation

2760 Ridgeway Court

Walled Lake, MI 48390-1662

Phone: [phone]

Fax: [phone]

www.herkules.us

Response: If exposed or concerned; Get medical advice/attention; Specific treatment (see first aid on the label); IF IN
EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do. Continue
rinsing. If eye irritation persists: Get medical advice. IF ON SKIN: Wash with plenty of soap and water. Take off
contaminated clothing and wash it before reuse. If skin irritation occurs: Get medical advice/attention. If Inhaled:
Remove person to fresh air and keep comfortable for breathing. Call a POISON CENTER or doctor/physician if you
feel unwell. If SWALLOWED: Immediately call a poison center/doctor. Do NOT Induce vomiting.

Storage: Store locked up. Sore in a well-ventilated place. Keep container tightly closed. Protect from sunlight, Do not
expose to temperatures exceeding 50 C/122 F.

Disposal: Dispose of contents/container to an approved waste disposal plant.
Hazards Not Otherwise Classified (HNOC): None.

SECTION 3 – COMPOSITION/INFORMATION ON INGREDIENTS

Substances CAS Number Weight (Percent) *
Acetone 67-64-1 50-60
Toluene 108-88-3 20-30
Petroleum Distillates 64742-89-8 1-10
Methyl Acetate 79-20-9 1-10
2-Butoxyethanol 111-76-2 1-10
Isopropyl Alcohol 67-63-0 1-10
Nitrogen Gas 7727-37-9 0.1-1.0
Ethylene Glycol 107-21-1 <0.1
Ethyl Benzene 100-41-4 <0.1
Benzene 71-43-2 <0.1
Methanol 67-56-1 <0.1
Acetaldehyde 75-07-0 <0.1

SECTION 4 – FIRST AID MEASURES

General: Causes skin and eye irritation. May cause respiratory irritation. May cause drowsiness. Harmful if swallowed
and enters airways. Avoid contact with eyes, skin, and clothing. Avoid breathing vapors, mist, or gas.

Eyes: Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Keep eye wide open while
rinsing. If symptoms persist, call a physician.

Ingestion: Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Call a physician or
Poison Control Center immediately.

Inhalation: Move to fresh air. If not breathing, give artificial respiration. If breathing has stopped, contact emergency
medical services immediately.

Skin: Wash off immediately with soap and plenty of water for at least 15 minutes. Get medical attention immediately if
symptoms occure. If symptoms persist, call a physician.

Notes to Physician: Provide general supportive measures and treat symptomatically.

l156_01_herkules_sparkle_clean_blast_safety_data_sheet pg. 2

*The specific identity and/or percentage of composition has been withheld as a trade secret.

Herkules Equipment Corporation

2760 Ridgeway Court

Walled Lake, MI 48390-1662

Phone: [phone]

Fax: [phone]

www.herkules.us

SECTION 5 – FIRE FIGHTING MEASURES

Suitable Extinguishing Media: Water fog. Carbon Dioxide (CO2), Foam, Dry Chemical. Cool Tanks/containers with
water spray.

Unsuitable Extinguishing Media: Do not use a cold water stream as it may scatter and spread fire.
Special Exposure Hazards: Extremely flammable/Flammable. Keep product and empty container away from hear and

sources of ignition.
Explosion Data

Sensitivity to Mechanical Impact: None.
Sensitivity to Static Discharge: Yes.

Special Protective Equipment and Precautions for Firefighters: As in any fire, wear self-contained breathing apparatus
pressure-demand, MHSA/NIOSH (approved or equivalent) and full protective gear.

SECTION 6 – ACCIDENTAL RELEASE MEASURES

Personal Precautionary Measures: Use with adequate ventilation to keep exposure levels below the OELS.
Environmental Precautionary Measures: Vapors can accumulate in low areas. Prevent further leakage or spillage if

safe to do so. Do not allow material to contaminate ground water system. Prevent product from entering drains.

Procedure for Cleaning/Absorption
Methods for containment: Absorb or cover with dry earth, sand or other non-combustible material and transfer to
containers. Prevent further leakage or spillage if safe to do so.
Methods for cleaning up: Use personal protective equipment. Dam up. Cover liquid spill with sand, earth or other
noncombustible absorbent material. Take up mechanically or collect in suitable container for disposal. Clean
contaminated surface thoroughly.

SECTION 7 – HANDLING AND STORAGE

Handling Precautions: Avoid contact with eyes. Avoid breathing vapors or mists. Contents under pressure. Do not
puncture or incinerate cans. Do not stick pin or any other sharp object into opening on top of can. Avoid skin contact.
Use with adequate ventilation. Keep container away from heat, flames, and all other sources of ignition. Keep can
away from all sources of electricity such as electric motors and batteries. Do no spray on hot surfaces.

Storage Information: Keep container tightly closed in a dry and well-ventilated place. Keep away from open flames,
hot surfaces, and sources of ignition. Keep in properly labeled containers. Keep out of the reach of children. Store
locked up.

Incompatible products: Strong acids, alkalis, oxidizing agents.
Aerosol Level: 3

l156_01_herkules_sparkle_clean_blast_safety_data_sheet pg. 3

Herkules Equipment Corporation

2760 Ridgeway Court

Walled Lake, MI 48390-1662

Phone: [phone]

Fax: [phone]

www.herkules.us

SECTION 8 – EXPOSURE CONTROLS/PERSONAL PROTECTION

Control parameters
Exposure guidelines
Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH
Acetone STEL: 500 ppm TWA: 1000 ppm IDLH: 2500 ppm
67-64-1 TWA: 250 ppm TWA: 2400 mg/m
(vacated) TWA: 750 ppm TWA: 590 mg/m3
(vacated) TWA: 1800 mg/m

the cellulose acetone fiber industry
It is in effect for all other sectors.
(vacated) STEL: 1000 ppm

Toluene TWA: 20 ppm TWA: 200 ppm IDLH: 500 ppm
108-88-3 (vacated) TWA: 100 ppm TWA: 100 ppm
(vacated) TWA: 375 mg/m

Methyl Acetate STEL: 250 ppm TWA: 200 ppm IDLH: 3100 ppm
79-20-9 TWA: 200 ppm TWA: 610 mg/m3 TWA: 200 ppm
(vacated) TWA: 200 ppm TWA: 610 mg/m3
(vacated) TWA: 610 mg/m3 STEL: 250 ppm
(vacated) STEL: 250 ppm STEL: 760 mg/m3
(vacated) STEL: 760 mg/m3

2-Butoxyethanol TWA: 20 ppm TWA: 50 ppm IDLH: 700 ppm
111-76-2 TWA: 240 mg/m3 TWA: 5 ppm
(vacated) TWA: 25 ppm TWA: 24 mg/m3
(vacated) TWA: 120 mg/m3
(vacated) S*
S*

Isopropyl Alcohol STEL: 400 ppm TWA: 400 ppm IDLH: 2000 ppm
67-63-0 TWA: 200 ppm TWA: 980 mg/m3 TWA: 400 ppm
(vacated) TWA: 400 ppm TWA: 980 mg/m3
(vacated) TWA: 980 mg/m3 STEL: 500 ppm
(vacated) STEL: 500 ppm STEL: 1225 mg/m3
(vacated) STEL: 1225 mg/m3

Nitrogen Gas Minimal Oxygen Content - ­7727-37-9

Ethylene Glycol Ceiling: 100 mg/m3 (vacated) Ceiling: 50 ppm
107-21-1 aerosol only (vacated) Ceiling: 125 mg/m3

Ethyl Benzene TWA: 20 ppm TWA: 100 ppm IDLH: 800 ppm
100-41-4 TWA: 435 mg/m3 TWA: 100 ppm
(vacated) TWA: 100 ppm TWA:435 mg/m3
(vacated) TWA: 435 mg/m3 STEL: 125 ppm
(vacated) STEL: 125 ppm STEL: 545 mg/m3
(vacated) STEL: 545 mg/m3

l156_01_herkules_sparkle_clean_blast_safety_data_sheet pg. 4

3

(vacated) STEL: 2400 mg/m

3

3

TWA: 250 ppm

The acetone STEL does not apply to

3

TWA: 375 mg/m

(vacated) STEL: 150 ppm STEL: 150 ppm

3

(vacated) STEL: 560mg/m3 STEL: 560 mg/m3
Ceiling: 300 ppm