Hearth and Home Technologies SFE-35 User Manual 2

Model: SFE-35

INSTALLER/CONSUMER SAFETY

INFORMATION

PLEASE READ THIS MANUAL BEFORE

INSTALLING AND USING APPLIANCE.

WARNING!

IF THE INFORMATION IN THIS

MANUAL IS NOT FOLLOWED

EXACTLY, AN ELECTRICAL SHOCK

OR FIRE MAY RESULT, CAUSING

PROPERTY DAMAGE, PERSONAL

INJURY OR LOSS OF LIFE.

BUILDER BOX

FOR YOUR SAFETY

SERVICE MUST BE PERFORMED BY

A QUALIFIED SERVICE AGENCY.

DO NOT STORE OR USE GASOLINE

OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF

THIS OR ANY OTHER APPLIANCE.

ANSI / UL 2021. Fixed or location dedicated electric room heater.

Installer: do not discard this manual -- leave for home owner

TUV Listed as SFE-35

Homeowner’s Installation & Operating Manual

Note: The device complies with Part 15 of the FCC Rules.

Operation is subject to the following two conditions:

1. This device may not cause harmful interference, and

2. This device must accept any interference received, including interference that may cause undesired operation.

1 Hearth & Home Technologies Inc. • SFE-35 • 4050-313 Rev C • 01/08

Congratulations!

Congratulations on selecting a Simplifyre electric ﬁ replace. The unit you have selected is designed to provide the utmost in safety, reliability and efﬁ ciency.

As the owner of a new ﬁ replace, you’ll want to read and carefully follow all of the instructions contained in this owner’s manual. Pay special attention to all cautions and warnings.

This owner’s manual should be retained for future reference. We suggest you keep it with your other important documents and product manuals.

TABLE OF CONTENTS

Please read the installation & operation instructions before using this appliance.

1 Important Instructions 3

A Unpacking the Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

B. Locating Your Electric Fireplace . . . . . . . . . . . . . . . . . 4

C. Clearance to Combustibles . . . . . . . . . . . . . . . . . . . . . 4

D. Framing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

E. Electrical Speciﬁ cations . . . . . . . . . . . . . . . . . . . . . . . . 4

F. Hardwire Electrical Connections . . . . . . . . . . . . . . . . . 4

G. Wall Switch and Thermostat Connections . . . . . . . . . . 4

H. Finishing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

2 Fireplace Dimensions 5

3 Operating Instructions 6

A. Remote Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

B. Remote Control Initialization . . . . . . . . . . . . . . . . . . . . 6

C. Control Usage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

4 Electrical Wiring 7

5 Service Instructions 7

A. Replacing the Light Bulb . . . . . . . . . . . . . . . . . . . . . . . 7

B. Screen Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

C. Maintenance of Motors . . . . . . . . . . . . . . . . . . . . . . . . 7

D. Resetting the Temperature Cutout Switch . . . . . . . . . . 7

6 Replacement Parts List 8

7 Warranty 9

The information contained in this owner’s manual unless noted otherwise, applies to all models.

Your new Simplifyre electric ﬁ replace will give you years of durable use and trouble-free enjoyment.

Welcome to the Hearth & Home Technologies family of ﬁ replace products!

2 Hearth & Home Technologies Inc. • SFE-35 • 4050-313 Rev C • 01/08

Important Instructions

WARNING! Risk of Fire!

DO NOT:

• install or operate damaged heater

• modify heater

• operate the heater without fully assembling all components

The following actions are strictly prohited:

• Installation other than as instructed by Hearth & Home Technologies Inc.

• Installation and/or use of any component part not approved by Hearth & Home Technologies Inc.

Hearth & Home Technologies Inc. disclaims any responsibility for, and the warranty and agency listing will be voided by the above actions.

When using electrical heaters, basic precautions should always be followed to reduce the risk of ﬁ re, electric shock and injury to persons, including the following:

• Read all instructions before using this heater.

• This heater is hot when in use. To avoid burns do not let bare skin touch hot surfaces. If provided, use handles when moving this heater. Keep combustible materials, such as furniture, pillows, bedding, papers, clothes and curtains away from sides and rear of heater, and at least 36 in. (914 mm) from the front.

• Extreme caution is necessary when any heater is used by or near children or invalids and whenever the heater is left operating and unattended.

• Always unplug heater when not in use.

• Do not operate any heater with a damaged cord or plug or after the heater malfunctions, has been dropped or damaged in any manner. Return heater to authorized service facility for examination, electrical or mechanical adjustment, or repair.

• Do not use outdoors.

• This heater is intended for use in bathrooms, laundry areas and similar indoor locations. Never locate heater where it may fall into a bathtub or other water container.

• Do not run cord under carpeting. Do not cover cord with throw rugs, runners, or the like. Arrange cord away from trafﬁ c areas and where it will not be tripped over. Do not coil cord.

• To disconnect heater, turn controls to “OFF” then remove plug from outlet.

• Do not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an electric shock or ﬁ re, or damage the heater.

WARNING! Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the owner’s information manual

provided with this heater. For assistance or additional information consult a qualiﬁ ed installer, service agency or your dealer.

NOTICE! This ﬁ replace is not intended for use as a primary heat source and should not be factored as such in residential heating calculations.

WARNING! Risk of Electric Shock! This product should never be installed near water.

• To prevent a possible ﬁ re, do not block air intakes or exhaust in any manner.

• A heater has hot and arcing or sparking parts inside. Do not use it in areas where gasoline, paint, or ﬂ ammable liquids are used or stored.

• Use this heater only as described in this manual. Any other use not recommended by the manufacturer may cause ﬁ re, electric shock, or injury to persons.

• Always use properly grounded, fused and polarized outlets.

• Always use ground fault protection where required by electrical code.

• Always disconnect power before performing any cleaning, maintenance or relocation of the heater.

• To prevent a possible ﬁ re, do not burn wood or other materials in this heater.

• To prevent electric shock or ﬁ re, always use a certiﬁ ed electrician should new circuits or outlets be required.

• When transporting or storing the heater, keep in a dry place free from excessive vibration and store to avoid damage.

• Avoid the use of an extension cord because the extension cord may over heat and cause a risk of ﬁ re. However, if you have to use an extension cord, the cord shall be No. 16 AWG minimum size and rated not less than 1875 watts.

• SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.

3 Hearth & Home Technologies Inc. • SFE-35 • 4050-313 Rev C • 01/08

+ 7 hidden pages