HAYWARD AQ-TROL-RJ, AQ-TROL-RJ-TL, AQ-TROL-HP, AQ-TROL-HP-TL installation Guide

ELECTROL YTIC CHLORINE GENERA TOR

A

BASIC POOL MAINTENANCE REQUIREMENTS

TEST IDEAL RANGE ADJUSTMENT REQUIRED

®

Aqua Trol

Free Chlorine 1.0 - 3.0 ppm

pH 7.2 - 7.8

WEEKLY

Alkalinity 80 - 120 ppm

MONTHL Y

Salt 2700 - 3400 ppm Add salt as required to increase.

Stabilizer 60 - 80 ppm Add cyanuric acid to increase.

Calcium 200 - 400 ppm Add calcium to increase.

QUARTERL Y

Electrolytic Cell inspect & clean Refer to section in manual.

Raise desired output % to
increase, lower desired output %
to decrease -OR- increase or
decrease pump filtration time.

Too high - add muriatic acid
Too low - add soda ash.

Add baking soda to increase.

dd acid as required to decrease.

Drain and add water to decrease.

Questions?

Refer to www.goldlinecontrols.com for latest manual

revisions, additional information and helpful service.

Above Ground

Pool Chlorine Generator

Operation and Installation

Manual

AQ-TROL-RJ

AQ-TROL-RJ-TL

AQ-TROL-HP

AQ-TROL-HP-TL

620 Division St.
Elizabeth, NJ 07207

Copyright © 2010 Hayward Inc.

092016K RevL

www.haywardnet.com

IMPORTANT SAFETY INSTRUCTIONS

When using this electrical equipment, basic safety pre­cautions should always be followed, including the follow­ing:

•

READ AND FOLLOW ALL
INSTRUCTIONS

• Disconnect all AC power during installation.

• Warning - To reduce the risk of injury, do not permit
children to use this product unless they are closely
supervised at all times.

• A green colored terminal marked "Earth Ground" is
located inside the wiring compartment. To reduce
the risk of electric shock, this terminal must be con­nected to the grounding means provided in the elec­tric supply service panel with a continuous copper
wire equivalent in size to the circuit conductors sup­plying the equipment.

• One bonding lug for US models (two for Canadian
models) is provided on the external surface. To
reduce the risk of electric shock, connect the local
common bonding grid in the area of the swimming
pool, spa, or hot tub to these terminals with an in­sulated or bare copper conductor not smaller than
8 AWG US / 6 AWG Canada.

• All field installed metal components such as rails,
ladders, drains, or other similar hardware within 3
meters of the pool, spa or hot tub shall be bonded
to the equipment grounding bus with copper con­ductors not smaller than 8 AWG US / 6 AWG
Canada.

•

SAVE THESE INSTRUCTIONS

16

LIMITED W ARRANTY (effective 04/01/09) Hayward/Goldline warrants its Pro Logic and
E-Command pool automation products as well as its Aqua Rite, Aqua Rite Pro, Aqua Plus and
SwimPure chlorination products to be free of defects in materials and workmanship, under
normal use and service, for a period of three (3) years. Hayward/Goldline also warrants its
Aqua Trol chlorination products to be free of defects in materials and workmanship, under
normal use and service for a period of one (1) year. These warranties are applicable from the
initial date of installation on private residential swimming pools in the US and Canada.

Hayward/Goldline warrants all the above-identified pool automation and chlorination prod­ucts installed on commercial swimming pools and on swimming pools outside of the US and
Canada for a period of one (1) year. Likewise, Hayward/Goldline warrants all accessories
and replacement parts for the above-identified pool automation and chlorination products for
a period of one (1) year. Each of these warranties is not transferable and applies only to the
original owner.

Proof of purchase is required for warranty service. If written proof of purchase is not
provided, the manufacturing date code will be the sole determinant of the date of installation
of the product. To obtain warranty service or repair, please contact the place of purchase or
the nearest Hayward/Goldline authorized warranty service center. For more information on
authorized service centers please contact the Hayward/Goldline Technical Service Support
Center (61 Whitecap Road, North Kingstown RI, 02852) or visit the Goldline web site at
www.goldlinecontrols.com or the Hayward website at www.haywardnet.com.

W ARRANTY EXCLUSIONS:

1. Material supplied or workmanship performed by others in process of installation.

2. Damage resulting from improper installation including installation on pools larger than the

product rating.

3. Problems resulting from failure to install, operate or maintain the product(s) in accordance

with the recommendations contained in the owners manual(s).

Table of Contents

OPERATION

The Aqua Trol®...........................................................................1

Water Chemistry........................................................................1

Controls........................................................................................6

Maintenance.................................................................................8

.

4. Problems resulting from failure to maintain pool water chemistry in accordance with the

recommendations in the owners manual(s).

5. Problems resulting from tampering, accident, abuse, negligence, unauthorized repairs or

alternations, fire, flood, lightning, freezing, external water, degradation of natural stone used in
or immediately adjacent to a pool or spa, war or acts of God.

DISCLAIMER. THE EXPRESS LIMITED W ARRANTIES ABOVE CONSTITUTE THE
ENTIRE W ARRANTIES WITH RESPECT TO THE ABOVE-IDENTIFIED HA YW ARD/
GOLDLINE POOL AUTOMA TION AND CHLORINATION PRODUCTS AND IS IN
LIEU OF ALL OTHER W ARRANTIES, EXPRESS OR IMPLIED, INCLUDING W AR­RANTIES OF MERCHANT ABILITY OR FITNESS FOR A P ARTICULAR PURPOSE.
THESE W ARRANTIES GIVE YOU SPECIFIC LEGAL RIGHTS, AND YOU MA Y ALSO
HA VE OTHER RIGHTS OF EQUIPMENT , LOST PROFITS OR REVENUE, COSTS
OF RENTING REPLACEMENTS, AND OTHER ADDITIONAL EXPENSES, EVEN IF
THE SELLER HAD BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES.
SOME STATES DO NOT ALLOW THE EXCLUSION OF LIMITATION OF INCI­DENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATION OR
EXCLUSION MA Y NOT APPLY TO YOU.

NO WHOLESALER, AGENT, DEALER, CONTRACTOR OR OTHER PERSON IS
AUTHORIZED TO PROVIDE, SUPPLEMENT OR MODIFY ANY WARRANTY ON
BEHALF OF HAYW ARD/GOLDLINE.

THESE W ARRANTIES ARE VOID IF THE PRODUCT HAS BEEN AL TERED IN ANY
W AY AFTER LEA VING THE F ACTORY . FOR THE ABOVE-IDENTIFIED CHLORI­NATION PRODUCTS, THESE WARRANTIES ALSO ARE VOID IF , DURING THE
W ARRANTY PERIOD, YOU USE A REPLACEMENT CHLORINA TOR CELL OTHER
THAN AN UNMODIFIED, NEW HA YWARD/GOLDLINE CHLORINAT OR CELL PUR­CHASED FROM HA YW ARD/GOLDLINE. IF A WARRANTY BECOMES VOID, YOU
STILL MAY PURCHASE SERVICE AND/OR TELEPHONE TECHNICAL SUPPOR T
AT THE THEN CURRENT TIME AND MATERIAL RATES.

15

INSTALLATION

Mounting........................................................................................9

Plumbing.......................................................................................10

Wiring..........................................................................................11

TROUBLESHOOTING

Troubleshooting........................................................................13

WARRANTY

Warranty.....................................................................................15