Hatco TPT-208D Installation Manual

Download

Page 1

hatcocorp.com

WARNING

ADVERTENCIA

AVERTISSEMENT

(see page 2)

Installation and Operating Manual

Pop-Up Toaster

TPTD Series

Replacement Parts List

P/N 07.04.668.00

Do not operate this equipment unless you have read and understood the contents of this manual! Failure to follow the instructions contained in this manual may result in serious injury or death. This manual contains important safety information concerning the maintenance, use, and operation of this product. If you’re unable to understand the contents of this manual, please bring it to the attention of your supervisor. Keep this manual in a safe location for future reference.

No opere este equipo al menos que haya leído y comprendido el contenido de este manual! Cualquier falla en el seguimiento de las instrucciones contenidas en este manual puede resultar en un serio lesión o muerte. Este manual contiene importante información sobre seguridad concerniente al mantenimiento, uso y operación de este producto. Si usted no puede entender el contenido de este manual por favor pregunte a su supervisor. Almacenar este manual en una localización segura para la referencia futura.

Ne pas utiliser cet équipement sans avoir lu et compris le contenu de ce manuel ! Le non-respect des instructions contenues dans ce manuel peut entraîner de graves blessures ou la mort. Ce manuel contient des informations importantes concernant l'entretien, l'utilisation et le fonctionnement de ce produit. Si vous ne comprenez pas le contenu de ce manuel, veuillez le signaler à votre supérieur. Conservez ce manuel dans un endroit sûr pour pouvoir vous y référer plus tard.

Page 2

CONTENTS

NOTICE

CAUTION

WARNING

24 Hour 7 Day Parts and Service Assistance available in the United States and Canada by calling 800-558-0607.

Important Owner Information ..............................................2

Introduction...........................................................................2

Important Safety Information...............................................3

Model Description.................................................................4

Model Designation................................................................4

Specifications........................................................................5

Plug Configurations ............................................................5

Electrical Rating Chart........................................................5

Dimensions.........................................................................5

Installation.............................................................................6

General...............................................................................6

Operation...............................................................................7

Maintenance ..........................................................................8

Troubleshooting Guide ........................................................9

Replacement Parts List ......................................................10

Hatco Limited Warranty......................................................12

Service Information ............................................................13

Authorized Parts Distributors............................Back Cover

IMPORTANT OWNER INFORMATION

Record the model number, serial number, voltage, and purchase date of the unit in the spaces below (specification label located on the bottom of the unit). Please have this information available when calling Hatco for service assistance.

Model No. ________________________________________

Serial No. ________________________________________

Voltage __________________________________________

Date of Purchase __________________________________

Completing online warranty registration will prevent delay in obtaining warranty coverage. Access the Hatco website at www.hatcocorp.com, select the Parts & Service pull-down menu, and click on “Warranty Registration”.

Business Hours: 8:00

Telephone: 800-558-0607; 414-671-6350

e-mail: partsandservice@hatcocorp.com

Fax: 800-690-2966 (Parts and Service)

Additional information can be found by visiting our web site at www.hatcocorp.com.

General...............................................................................7

General...............................................................................8

Daily Cleaning ....................................................................8

AM to 5:00 PM Central Standard Time (CST)

(Summer Hours: June to September— 8:00

AM to 5:00 PM CST Monday–Thursday

8:00

AM to 2:30 PM CST Friday)

414-671-3976 (International)

NOTE: Edward Don Pop-Up Toasters are manufactured by

the Hatco Corporation. Please contact Hatco for Service Assistance, Replacement Parts, or Warranty Information.

INTRODUCTION

The Edward Don Pop-Up Toaster is perfect for self-serve buffet areas, lighter volume restaurants, diners, and cafes. The unit evenly toasts a variety of bread products including bagels, texas toast, waffles, and english muffins. The Pop-Up Toaster makes a great addition to your conveyor toaster for those non-peak periods when an occasional order of toast is needed.

The Pop-Up Toaster features a durable stainless steel housing, four self-centering extra-wide slots, individual toasting controls, removable crumb trays for easy cleaning, and a 6′ (1829 mm) cord with plug.

The Edward Don Pop-Up Toaster is a product of extensive research and field testing. The materials used were selected for maximum durability, attractive appearance, and optimum performance. Every unit is inspected and tested thoroughly prior to shipment.

ruc

a instructions appearing in this manual be read pri or operation of the unit.

Safety information that appears in this manual is identified by the following signal word panels:

WARNING indicates a hazardous situation which, if not avoided, could result in death or serious injury.

CAUTION indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

ons tco

or the E

mme

dward Don P

op-Up T

lla

sta

tio

oas

er. E

tin

dward Don

tal

ati

tin

ty, a

, sa

tio

lla

sta

s th

vid

l p

is ma

NOTICE is used to address practices not related to personal injury.

Form No. TPTDM-1213

Page 3

IMPORTANT SAFETY INFORMATION

NOTICE

CAUTION

WARNING

Read the following important safety information before using this equipment to avoid serious injury or death and to avoid damage to equipment or property.

ELECTRIC SHOCK HAZARD:

• Plug unit into a properly grounded electrical receptacle of correct voltage, size, and plug configuration. If plug and receptacle do not match, contact a qualified electrician to determine and install proper voltage and size electrical receptacle.

• Unplug power cord and allow unit to cool before performing maintenance, cleaning, or attempting to clear a jam.

• DO NOT submerge or saturate with water. Unit is not waterproof. Do not operate if unit has been submerged or saturated with water.

• Unit is not weatherproof. Locate unit indoors where the ambient air temperature is a minimum of 70°F (21°C).

• Do not pull unit by power cord.

• Discontinue use if power cord is frayed or worn.

• Do not attempt to repair or replace a damaged power cord. Cord must be replaced by Hatco, an Authorized Hatco Service Agent, or a person with similar qualifications.

• Do not steam clean or use excessive water on unit.

• This unit is not “jet-proof” construction. Do not use jetclean spray to clean unit.

• NEVER insert a knife, fork, or similar object into toasting chamber.

• Do not pick up toaster by inserting fingers into toaster slots and grasping heating elements.

• Do not clean unit when it is energized or hot.

• Do not allow liquids to spill into unit.

• Unit must be serviced by qualified personnel only. Service by unqualified personnel may lead to electric shock or burn.

FIRE HAZARD:

• Locate unit a minimum of 1″ (25 mm) from combustible walls and materials. If safe distances are not maintained, combustion or discoloration could occur.

• Do not place anything on top of toaster. Do not place toaster near or underneath curtains or other combustible materials. Items near or on top of toaster could catch fire causing injury and/or damage to toaster.

In case of fire, disconnect toaster from power source immediately. This allows unit to cool, making it easier and safer to put out the fire.

Make sure all operators have been instructed on the safe and proper use of the unit.

This unit is not intended for use by children or persons with reduced physical, sensory, or mental capabilities. Ensure proper supervision of children and keep them away from unit.

This unit has no “user-serviceable” parts. If service is required on this unit, contact an Authorized Hatco Service Agent or contact the Hatco Service Department at 800-558-0607 or 414-671-6350; fax 800-690-2966; or International fax 414-671-3976.

BURN HAZARD:

• Some exterior surfaces on unit will get hot. Use caution when touching these areas.

• Do not remove crumb trays for cleaning until toaster is cool.

Locate unit at proper counter height in an area that is convenient for use. Location should be level to prevent unit or its contents from falling accidentally and strong enough to support weight of unit and contents.

Always operate toaster with crumb trays installed. Toasting of coated or buttered products such as garlic

bread, cheese sandwiches, and sweet rolls is NOT recommended. Residue will reduce toaster performance and could ignite inside toaster. Using toaster with food products listed above will void unit warranty.

Do not lay unit on the side with the control panel or damage to the unit could occur.

Use non-abrasive cleaners and cloths only. Abrasive cleaners and cloths could scratch finish of unit, marring its appearance and making it susceptible to soil accumulation.

This unit is intended for commercial use only — NOT for household use.

EXPLOSION HAZARD: Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance.

Form No. TPTDM-1213

Page 4

MODEL DESCRIPTION

Model TPT-120D

Models TPT-208D/TPT-240D

T P T - X X X D

Pop-Up Toaster

Unit Voltage

Edward Don

All Models

Edward Don Pop-Up Toasters are perfect for buffet areas and lighter volume restaurants. The TPTD series toasters have four self-centering, extra wide slots with individual progressive toasting controls. Models TPT-208D and TPT-240D are equipped with bagel/bun buttons for one-sided toasting. The durable stainless steel housing contains removable crumb trays for easy cleaning.

MODEL DESIGNATION

TPTD Series Pop-Up Toasters

Form No. TPTDM-1213

Page 5

SPECIFICATIONS

12-3/8"

(313 mm)

13-5/8"

(346 mm)

8-1/16"

(204 mm)

12"

(304 mm)

8-1/16"

(204 mm)

TPTD Series Slot Openings = 1-1/4" W x 5-1/2" D x 4-1/2" H (32 x 140 x114 mm)

Front View Side View

WARNING

NEMA 5-15P NEMA 6-15P

Plug Configurations

Units are supplied from the factory with an electrical cord and plug installed. Plugs are supplied according to the application.

ELECTRIC SHOCK HAZARD: Plug unit into a properly grounded electrical receptacle of correct voltage, size, and plug configuration. If plug and receptacle do not match, contact a qualified electrician to determine and install proper voltage and size electrical receptacle.

NOTE: Specification label located on the bottom of the unit.

See label for serial number and verification of unit electrical information.

NOTE: Receptacle not supplied by Hatco.

Electrical Rating Chart

Model Voltage Watts Amps Plug Configuration Shipping Weight

TPT-120D 120 1800 15.0 NEMA 5-15P 14 lbs. (6 kg)

TPT-208D 208 2600 12.5 NEMA 6-15P 16 lbs. (7 kg)

TPT-240D 240 2600 10.9 NEMA 6-15P 16 lbs. (7 kg)

Plug Configurations

Dimensions

Form No. TPTDM-1213

Page 6

INSTALLATION

WARNING

TOAST/BAGEL

Button

(TPT-208D and

TPT-240D only)

Operating Lever

TPT-208D/TPT-240D

Crumb

Tray

Toasting Slot

TPT-120D

COLOR

CONTROL

Knob

General

The Pop-Up Toaster is shipped with all components preassembled. Care should be taken when unpacking the shipping carton to avoid damage to the unit and the components enclosed.

ELECTRIC SHOCK HAZARD: Unit is not weatherproof. Locate unit indoors where ambient air temperature is a minimum of 70°F (21°C).

EXPLOSION HAZARD: Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance.

FIRE HAZARD:

• Locate unit a minimum of 1″ (25 mm) from combustible walls and materials. If safe distances are not maintained, combustion or discoloration could occur.

NOTE: TPTD Series toasters require a dedicated circuit.

1. Remove the unit from the carton.

NOTE: To prevent delay in obtaining warranty coverage,

complete online warranty registration. See the IMPORTANT OWNER INFORMATION section for details.

2. Remove tape and protective packaging from all surfaces of the unit.

3. Place the unit in the desired location.

• Locate the unit in an area where the ambient air temperature is constant and a minimum of 70°F (21°C). Avoid areas that may be subject to active air movements or currents (i.e., near exhaust fans/hoods and air conditioning ducts, exterior doors).

• Make sure the unit is at the proper counter height in an area convenient for use.

• Make sure the countertop is level and strong enough to support the weight of the unit and food product.

• Make sure all the feet on the bottom of the unit are positioned securely on the countertop.

Components

Form No. TPTDM-1213

Page 7

OPERATION

WARNING

CAUTION

COLOR CONTROL Knob

COLOR CONTROL

Knob

TOAST/BAGEL Button TOAST/BAGEL Button

General

The Pop-Up Toaster is designed for ease of operation. Perform the following procedure to operate the toaster.

Read all safety messages in the IMPORTANT SAFETY INFORMATION section before operating this equipment.

1. Plug the unit into a properly grounded electrical receptacle of the correct voltage, size, and plug configuration. See the SPECIFICATIONS section for details.

2. Set the COLOR CONTROL knob(s) to the desired toast darkness setting. The “1” setting on the COLOR CONTROL knobs represents the lightest toast setting and the “7” setting represents the darkest.

3. For TPT-208D and TPT-240D toasters, make sure the TOAST/BAGEL button(s) is in the correct position. Push the TOAST/BAGEL button(s) to change its setting, if necessary.

• When the TOAST/BAGEL button(s) is in the TOAST position (depressed), both heating elements in each toasting slot will energize to toast both sides of the product.

• When the TOAST/BAGEL button(s) is in the BAGEL position (released), only the inner heating elements in each pair of toasting slots will energize to toast the inner side of the product.

4. Place bread product in toasting slot(s). If toasting only one side of the product, make sure to place the toasting side toward the center of each pair of toasting slots.

5. Push down on the operating lever(s) to lower product into the toaster.

• As soon as the operating lever is pushed down, the heating elements inside the toaster energize and begin heating.

BURN HAZARD: Some exterior surfaces on unit will get hot. Use caution when touching these areas.

• When the toasting cycle is complete, the heating elements shut off and the operating lever(s) rises automatically.

NOTE: The operating lever(s) can be lifted manually during

toasting for product removal. This will end the toasting cycle.

ELECTRIC SHOCK HAZARD:

• Unplug power cord and allow unit to cool before performing maintenance, cleaning, or attempting to clear a jam.

• NEVER insert a knife, fork, or similar object into toasting chamber.

6. Remove and empty the crumb trays periodically in between toasting cycles.

Always operate toaster with crumb trays installed. Toasting of coated or buttered products such as garlic bread,

cheese sandwiches, and sweet rolls is NOT recommended. Residue will reduce toaster performance and could ignite inside toaster. Using toaster with food products listed above will void unit warranty.

Form No. TPTDM-1213

TPT-208D and TPT-240D Control Panel

Page 8

MAINTENANCE

WARNING

General

The Pop-Up Toaster is designed for maximum durability and performance with minimum maintenance.

ELECTRIC SHOCK HAZARD:

• Unplug power cord and allow unit to cool before performing cleaning, adjustments, maintenance, or attempting to clear a jam.

• DO NOT submerge or saturate with water. Unit is not waterproof. Do not operate if unit has been submerged or saturated with water.

• This unit is not “jet-proof” construction. Do not use jetclean spray to clean this unit.

• Do not steam clean or use excessive water on unit.

• Do not allow liquids to spill into unit.

• Unit must be serviced by qualified personnel only. Service by unqualified personnel may lead to electric shock or burn.

NOTE: Submerging or saturating the unit with water will

damage the unit and void the unit warranty.

Daily Cleaning

To preserve the finish of the toaster, it is recommended that the metal surfaces be wiped daily with a non-abrasive, damp cloth.

ELECTRICSHOCKHAZARD: Do not clean unit when it is energized or hot.

1. Unplug the power cord and allow the unit to cool.

2. Remove and empty the crumb trays. CAUTION! BURN

HAZARD—Do not remove crumb trays for cleaning until toaster is cool.

3. Wash the crumb trays with warm water and a mild detergent. Rinse with water.

4. Allow the crumb trays to air dry or hand dry with a soft cloth before placing back into the toaster.

5. Wipe the exterior surface of the toaster with a damp cloth.

NOTICE: Use non-abrasive cleaners and cloths only.

6. Wipe dry with a clean, dry, non-abrasive cloth.

Form No. TPTDM-1213

Page 9

TROUBLESHOOTING GUIDE

WARNING

Unit must be serviced by qualified personnel only. Service by unqualified personnel may lead to electric shock or burn.

ELECTRIC SHOCK HAZARD: Unplug power cord and allow unit to cool before performing cleaning, adjustments, maintenance, or attempting to clear a jam.

Symptom Probable Cause Corrective Action

Toast too light. COLOR CONTROL knob set on a light

setting.

Supply voltage to unit is low. Verify the supply voltage to the toaster

Toast too dark. COLOR CONTROL knob set on a dark

setting.

Supply voltage to unit is high. Verify the supply voltage to the toaster

Unit takes too long to toast. The first few batches can take longer

because the toaster needs time to heat up.

Supply voltage to unit is low. Verify the supply voltage to the toaster

Unit toasts on one side only. TOAST/BAGEL button is in the BAGEL

position (one-sided toasting).

Heating element defective. Visually check the heating element inside the

Heating element does not come on at all when the operating lever is pushed down.

The operating lever does not latch.

Toaster trips the circuit breaker or GFCI.

The switch may be broken. Contact Hatco for assistance.

Latch mechanism is broken. Contact Hatco for assistance.

Circuit breaker is not sized properly for the toaster.

Turn COLOR CONTROL knob to a darker setting.

matches the unit specifications.

Turn COLOR CONTROL knob to a lighter setting.

matches the unit specifications.

Push down the operation lever(s) for a toasting cycle before inserting bread product to allow the toaster to heat up.

matches the unit specifications.

Push the TOAST/BAGEL button to set it to the TOAST position (two-sided toasting).

toaster with the operation lever engaged. With the lever pushed down, the heating element should glow red. If the element does not glow, Contact Authorized Service Agent or Hatco for assistance.

Check circuit breaker for proper sizing.

Troubleshooting Questions?

If you continue to have problems resolving an issue, please contact the nearest Authorized Hatco Service Agency or Hatco for assistance. To locate the nearest Service Agency, log onto the Hatco website at www.hatcocorp.com and click on

Find Service Agent, or contact the Hatco Parts and Service Team at:

Telephone: 800-558-0607 or 414-671-6350 e-mail: partsandservice@hatcocorp.com Fax: 800-690-2966 or 414-671-3976

Form No. TPTDM-1213

NOTE: TPTD Series toasters require a

dedicated circuit.

Wiring fault inside toaster. Contact Hatco for assistance.

Page 10

Specification label

on bottom of unit.

SIDE

CENTER

SIDE

CENTER

T P T - X X X D

Pop-Up Toaster

Unit Voltage

Edward Don

CAUTION

24 Hour 7 Day Parts and Service Assistance available in the United States and Canada by calling 800-558-0607.

REPLACEMENT PARTS LIST

HATCO POP-UP TOASTER

TPT-120D, TPT-208D, and TPT-240D Models

Model Designation

Use of replacement parts other than those supplied by Hatco Corporation may result in damage to unit or injury to personnel and will void all warranties.

Form No. TPTDM-1213

Page 11

Week Thirty-One

1331

Year 2013

REPLACEMENT PARTS LIST

TPT-120D

Item Description

1 Knob, Color Control 05.30.115.00 05.30.115.00 05.30.115.00 2

2 Decal, Control Panel 07.01.389.00 07.01.390.00 07.01.390.00 1

3 E-Ring 05.04.558.00 05.04.558.00 05.04.558.00 8

4 Damping Spring 05.08.017.00 05.08.017.00 05.08.017.00 4

5 Carriage Shaft 05.07.042.00 05.07.042.00 05.07.042.00 4

6 Spring, Extension 05.08.019.00 05.08.019.00 05.08.019.00 4

7 Return Spring, Solenoid 05.08.015.00 05.08.015.00 05.08.015.00 2

Plunger, Solenoid

9 Solenoid

10 Carriage Spring

11 Carriage Handle Assembly

12 Knob, Carriage Handle Assembly

13 Potentiometer, Color Control

14 Micro Switch, DPDT

15 Selector Switch

16 Crumb Tray Assembly

17 Wire Guide, Left

18 Wire Guide, Right

19 Heating Element Assembly, Side

20 Heating Element Assembly, Center

21 Rubber Foot

22 Cord Grip

23 Power Cord and Plug

Part Number

02.20.343.00 02.20.343.00 02.20.343.00 2

02.20.342.00 02.20.407.00 02.20.407.00 2

05.08.034.00 05.08.034.00 05.08.034.00 2

04.05.783.00 04.05.783.00 04.05.783.00 2

R05.30.133.00 R05.30.133.00 R05.30.133.00 2

02.18.484.00 02.18.484.00 02.18.484.00 2

02.19.193.00 02.19.193.00 02.19.193.00 2

--- 02.18.452.00 02.18.452.00 2

04.05.795.00 04.05.795.00 04.05.795.00 2

04.05.781.00 04.05.781.00 04.05.781.00 4

04.05.778.00 04.05.778.00 04.05.778.00 4

02.05.789.00 02.05.799.00 02.05.812.00 4

02.05.792.00 02.05.798.00 02.05.811.00 2

05.30.114.00 05.30.114.00 05.30.114.00 4

02.20.233.00 02.20.233.00 02.20.233.00 1

02.18.474.00 02.18.475.00 02.18.475.00 1

TPT-208D

Part Number

TPT-240D

Part Number

Qty.

Wiring Diagram

NOTE: The last four digits in a ten digit numerical serial number are the manufacturing date code. Example: Serial number 9625061331 has a date code of “1331” which indicates the following:

Form No. TPTDM-1213

10-01-1033 10-01-1034 10-01-1034

Page 12

LIMITED WARRANTY

1. PRODUCT WARRANTY

Hatco warrants the products that it manufactures (the “Products”) to be free from defects in materials and workmanship, under normal use and service, for a period of one (1) year from the date of purchase when installed and maintained in accordance with Hatco’s written instructions or 18 months from the date of shipment from Hatco. Buyer must establish the Product’s purchase date by registering the Product with Hatco or by other means satisfactory to Hatco in its sole discretion.

Hatco warrants the following Product components to be free from defects in materials and workmanship from the date of purchase (subject to the foregoing conditions) for the period(s) of time and on the conditions listed below:

a) One (1) Year Parts and Labor PLUS One (1) Additional

Year Parts-Only Warranty:

Conveyor Toaster Elements (metal sheathed) Drawer Warmer Elements (metal sheathed) Drawer Warmer Drawer Rollers and Slides Strip Heater Elements (metal sheathed) Display Warmer Elements (metal sheathed air heating) Holding Cabinet Elements (metal sheathed air heating) Heated Well Elements — HW and HWB Series

(metal sheathed)

b) One (1) Year Parts and Labor PLUS Four (4) Years

Parts-Only Warranty:

3CS and FR Tanks

c) One (1) Year Parts and Labor PLUS Nine (9) Years

Parts-Only Warranty on:

Electric Booster Heater Tanks Gas Booster Heater Tanks

d) Ninety (90) Day Parts-Only Warranty:

Replacement Parts

THE FOREGOING WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTY, EXPRESSED OR IMPLIED, INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR PATENT OR OTHER INTELLECTUAL PROPERTY RIGHT INFRINGEMENT. Without limiting the generality of the foregoing, SUCH WARRANTIES DO NOT COVER: Coated incandescent light bulbs, fluorescent lights, heat lamp bulbs, coated halogen light bulbs, halogen heat lamp bulbs, xenon light bulbs, LED light tubes, glass components, and fuses; Product failure in booster tank, fin tube heat exchanger, or other water heating equipment caused by liming, sediment buildup, chemical attack, or freezing; or Product misuse, tampering or misapplication, improper installation, or application of improper voltage.

2. LIMITATION OF REMEDIES AND DAMAGES

Hatco’s liability and Buyer’s exclusive remedy hereunder will be limited solely, at Hatco’s option, to repair or replacement using new or refurbished parts or Product by Hatco or a Hatcoauthorized service agency (other than where Buyer is located outside of the United States, Canada, United Kingdom, or Australia, in which case Hatco’s liability and Buyer’s exclusive remedy hereunder will be limited solely to replacement of part under warranty) with respect to any claim made within the applicable warranty period referred to above. Hatco reserves the right to accept or reject any such claim in whole or in part. In the context of this Limited Warranty, “refurbished” means a part or Product that has been returned to its original specifications by Hatco or a Hatco-authorized service agency. Hatco will not accept the return of any Product without prior written approval from Hatco, and all such approved returns shall be made at Buyer’s sole expense. HATCO WILL NOT BE LIABLE, UNDER ANY CIRCUMSTANCES, FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES, INCLUDING BUT NOT LIMITED TO LABOR COSTS OR LOST PROFITS RESULTING FROM THE USE OF OR INABILITY TO USE THE PRODUCTS OR FROM THE PRODUCTS BEING INCORPORATED IN OR BECOMING A COMPONENT OF ANY OTHER PRODUCT OR GOODS.

Form No. TPTDM-1213

Page 13

SERVICE INFORMATION

United States and Canada

The warranty on Hatco TPTD Series toasters is for one year from date of purchase or eighteen months from date of shipping from Hatco, whichever occurs first.

Warranty Problems

If you experience a problem with a TPTD toaster during the warranty period, contact the Hatco Parts and Service Team at:

Telephone: 1-800-558-0607 or 414-671-6350 Fax: 1-800-690-2966 or414-671-3976

When contacting Hatco for warranty service, please supply the following information:

• Model of unit

• Serial number (located on the bottom of the unit)

• Specific problem with the toaster

• Date of purchase

• Name of business

• Shipping address

• Contact name and phone number

Non-Warranty Problems

If you experience a non-warranty problem that requires assistance, please contact the nearest Authorized Hatco Service Agency.

To locate the nearest Service Agency, log onto our website at www.hatcocorp.com and click on Service Agency Locator, or contact the Hatco Parts and Service Team by phone.

Form No. TPTDM-1213

Page 14

NOTES

Form No. TPTDM-1213

Page 15

NOTES

Form No. TPTDM-1213

Page 16

AUTHORIZED PARTS DISTRIBUTORS

HATCO CORPORATION

P.O. Box 340500

Milwaukee, WI 53234-0500 U.S.A.

800-558-0607 414-671-6350

Parts and Service Fax 800-690-2966

International Fax 414-671-3976

partsandservice@hatcocorp.com

www.hatcocorp.com

LABAMA

ones McLeod Appl. Svc.

irmingham 205-251-0159

ARIZONA

ervice Solutions Group

hoenix 602-234-2443

Byassee Equipment Co. Phoenix 602-252-0402

ALIFORNIA

Industrial Electric Commercial Parts & Service, Inc. Huntington Beach 714-379-7100

hapman Appl. Service

an Diego 619-298-7106

P & D Appliance Commercial Parts & Service, Inc. S. San Francisco 650-635-1900

COLORADO

Hawkins Commercial Appliance Englewood 303-781-5548

FLORIDA

Whaley Foodservice Repair Jacksonville 904-725-7800

3Wire Nass Service Co., Inc. Orlando 407-425-2681

B.G.S.I. Pompano Beach 954-971-0456

omm. Appliance Service

ampa 813-663-0313

GEORGIA

TWC Services Mableton 770-438-9797

Heritage Service Group Norcross 866-388-9837

Southeastern Rest. Svc. Norcross 770-446-6177

HAWAII

Burney’s Comm. Service, Inc. Honolulu 808-848-1466

Food Equip Parts & Service Honolulu 808-847-4871

ILLINOIS

Parts Town Lombard 708-865-7278

Eichenauer Elec. Service Decatur 217-429-4229

Midwest Elec. Appl. Service Elmhurst 630-279-8000

Cone’s Repair Service Moline 309-797-5323

INDIANA

GCS Service Indianapolis 317-545-9655

IOWA

lectric Motor Service Co.

avenport 319-323-1823

Goodwin Tucker Group Des Moines 515-262-9308

ENTUCKY

Service Solutions Group Lexington 859-254-8854

ervice Solutions Group

ouisville 502-451-5411

LOUISIANA

Chandlers Parts & Service Baton Rouge 225-272-6620

ARYLAND

Electric Motor Service Baltimore 410-467-8080

GCS Service Silver Spring 301-585-7550

MASSACHUSETTS

Ace Service Co., Inc. Needham 781-449-4220

MICHIGAN

Bildons Appliance Service Detroit 248-478-3320

Commercial Kitchen Service Bay City 517-893-4561

idwest Food Equip. Service

randville 616-261-2000

MINNESOTA

GCS Service Plymouth 800-345-4221

MISSOURI

General Parts Kansas City 816-421-5400

Commercial Kitchen Services St. Louis 314-890-0700

Kaemmerlen Parts & Service St. Louis 314-535-2222

NEBRASKA

Anderson Electric Omaha 402-341-1414

NEVADA

Burney’s Commercial Las Vegas 702-736-0006

Hi. Tech Commercial Service N. Las Vegas 702-649-4616

NEW JERSEY

Jay Hill Repair Fairfield 973-575-9145

Service Plus Flanders 973-691-6300

EW YORK

cme American Repairs, Inc.

rooklyn 718-456-6544

lpro Service Co.

rooklyn 718-386-2515

Appliance Installation Buffalo 716-884-7425

Duffy’s Equipment Services, Inc. Buffalo 800-836-1014

Wire Northern

lattsburgh 800-634-5005

Duffy’s Equipment Services, Inc. Sauquoit 800-836-1014

J.B. Brady, Inc. Syracuse 315-422-9271

NORTH CAROLINA

Authorized Appliance Charlotte 704-377-4501

OHIO

Akron/Canton Comm. Svc. Inc. Akron 330-753-6635

Service Solutions Group Cincinnati 513-772-6600

ommercial Parts and Service

olumbus 614-221-0057

Electrical Appl. Repair Service Brooklyn Heights 216-459-8700

E. A. Wichman Co. Toledo 419-385-9121

OKLAHOMA

Hagar Rest. Service, Inc. Oklahoma City 405-235-2184

Krueger, Inc. Oklahoma City 405-528-8883

OREGON

Ron’s Service, Inc. Portland 503-624-0890

PENNSYLVANIA

Elmer Schultz Services Philadelphia 215-627-5401

FAST Comm. Appl. Service Philadelphia 215-288-4800

Appliance Installation & Service Pittsburgh 412-809-0244

K & D Service Co. Harrisburg 717-236-9039

Electric Repair Co. Reading 610-376-5444

RHODE ISLAND

Marshall Electric Co. Providence 401-331-1163

SOUTH CAROLINA

Whaley Foodservice Repair W. Columbia 803-791-4420

TENNESSEE

Camp Electric Memphis 901-527-7543

EXAS

CS Service

ort Worth 800-433-1804

rmstrong Repair Service

ouston 713-666-7100

Cooking Equipment Specialist Mesquite 888-866-9276

Refrigerated Specialist, Inc. Mesquite 888-866-9276

ommercial Kitchen Repair Co.

an Antonio 210-735-2811

UTAH

La Monica’s Rest. Equip. Service Murray 801-263-3221

IRGINIA

aubers

orfolk 757-855-4097

aubers

pringfield 703-866-3600

WASHINGTON

3Wire Restaurant Appliance Seattle 800-207-3146

WISCONSIN

A.S.C., Inc. Madison 608-246-3160

.S.C., Inc.

ilwaukee 414-543-6460

CANADA

ALBERTA

Key Food Equipment Service Edmonton 780-438-1690

BRITISH COLUMBIA

Key Food Equipment Service Vancouver 604-433-4484

Key Food Equipment Service Victoria 250-920-4888

MANITOBA

Air Rite, Inc. Winnipeg 204-895-2300

NEW BRUNSWICK

EMR Services, Ltd. Moncton 506-855-4228

ONTARIO

R.G. Henderson Ltd. Toronto 416-422-5580

Choquette - CKS, Inc. Ottawa 613-739-8458

QUÉBEC

Choquette - CKS, Inc. Montreal 514-722-2000

Choquette - CKS, Inc. Québec City 418-681-3944

UNITED KINGDOM

Marren Group Northants +44(0)1933 665313

See IMPORTANT OWNER INFORMATION

December 2013 P/N 07.04.668.00 Form No.TPTDM-1213

section for details.

Hatco TPT-208D Installation Manual

Specifications and Main Features

Frequently Asked Questions

User Manual