Hatco TPT-120 Installation Manual

hatcocorp.com

ADVERTENCIA

(see page 2)

S’inscrire en ligne!

(voir page 11)

Grille-pain à éjection

Installation and Operating Manual

Manuel d’installation et d’utilisation

Pop-Up Toasters

automatique

TPT Series/Série

Do not operate this equipment unless you have read and understood the contents of this manual! Failure to follow the instructions contained in this manual may result in serious injury or death. This manual contains important safety information concerning the maintenance, use, and operation of this product. If you’re unable to understand the contents of this manual, please bring it to the attention of your supervisor. Keep this manual in a safe location for future reference.

WARNING

English = p 2

No opere este equipo al menos que haya leído y comprendido el contenido de este manual! Cualquier falla en el seguimiento de las instrucciones contenidas en este manual puede resultar en un serio lesión o muerte. Este manual contiene importante información sobre seguridad concerniente al mantenimiento, uso y operación de este producto. Si usted no puede entender el contenido de este manual por favor pregunte a su supervisor. Almacenar este manual en una localización segura para la referencia futura.

AVERTISSEMENT

Ne pas utiliser cet équipement sans avoir lu et compris le contenu de ce manuel ! Le non-respect des instructions contenues dans ce manuel peut entraîner de graves blessures ou la mort. Ce manuel contient des informations importantes concernant l’entretien, l’utilisation et le fonctionnement de ce produit. Si vous ne comprenez pas le contenu de ce manuel, veuillez le signaler à votre supérieur. Conservez ce manuel dans un endroit sûr pour pouvoir vous y référer plus tard.

Français = p 11

CONTENTS

CAUTION

English

Important Owner Information .............................................. 2

Introduction ...........................................................................2

Important Safety Information .............................................. 3

Model Description ................................................................4

Specifications ....................................................................... 5

Plug Configurations ............................................................. 5

Electrical Rating Chart ......................................................... 5

Dimensions .......................................................................... 5

Installation .............................................................................6

General ................................................................................ 6

IMPORTANT OWNER INFORMATION

Record the model number, serial number, voltage, and

purchase date of the unit in the spaces below (specification label located on the bottom of the unit). Please have this

information available when calling Hatco for service assistance.

Model No. ________________________________________

Serial No. _________________________________________

Voltage ___________________________________________

Date of Purchase ___________________________________

Completing online warranty registration will prevent delay in obtaining warranty coverage. Access the Hatco website at www.hatcocorp.com, select the Parts & Service pull-down menu, and click on “Warranty Registration”.

Operation ...............................................................................7

General ................................................................................ 7

Maintenance .......................................................................... 8

General ................................................................................ 8

Daily Cleaning .....................................................................8

Troubleshooting Guide ........................................................9

Limited Warranty ................................................................10

Service Information ............................................................ 10

Authorized Parts Distributors ........................... Back Cover

Business Hours: 7:00 am to 5:00 pm Central Standard Time (CST)

(Summer Hours: June to September— 7:00 am to 5:00 pm CST Monday–Thursday 7:00 am to 4:00 pm CST Friday)

Telephone: 800-558-0607; 414-671-6350

E-mail: partsandservice@hatcocorp.com

24 Hour 7 Day Parts and Service Assistance available in the United States and Canada by calling 800-558-0607.

Additional information can be found by visiting our web site at

www.hatcocorp.com.

INTRODUCTION

The Hatco Pop-Up Toaster is perfect for self-serve buffet areas, lighter volume restaurants, diners, and cafes. The unit evenly toasts a variety of bread products including bagels, texas toast, waffles, and english muffins. The Pop-Up Toaster makes a great addition to your conveyor toaster for those non-peak periods when an occasional order of toast is needed.

The Pop-Up Toaster features a durable stainless steel housing, four self-centering extra-wide slots, individual toasting controls,

removable crumb trays for easy cleaning, and a 6′ (1829 mm)

cord with plug. The Hatco Pop-Up Toaster is a product of extensive research

and field testing. The materials used were selected for maximum durability, attractive appearance, and optimum performance. Every unit is inspected and tested thoroughly prior to shipment.

This manual provides the installation, safety, and operating instructions for the Hatco Pop-Up Toaster. Hatco recommends all installation, operating, and safety instructions appearing in this manual be read prior to installation or operation of the unit.

Safety information that appears in this manual is identified by the following signal word panels:

WARNING

WARNING indicates a hazardous situation which, if not avoided, could result in death or serious injury.

CAUTION indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

NOTICE

NOTICE is used to address practices not related to personal injury.

Form No. TPTM-0817

English

WARNING

CAUTION

WARNING

IMPORTANT SAFETY INFORMATION

Read the following important safety information before using this equipment to avoid serious injury or death and to avoid damage to equipment or property.

ELECTRIC SHOCK HAZARD:

• Plug unit into a properly grounded electrical receptacle of correct voltage, size, and plug configuration. If plug and receptacle do not match, contact a qualified electrician to determine and install proper voltage and size electrical receptacle.

• Unplug power cord and allow unit to cool before performing maintenance, cleaning, or attempting to clear a jam.

• DO NOT submerge or saturate with water. Unit is not waterproof. Do not operate if unit has been submerged or saturated with water.

• Unit is not weatherproof. Locate unit indoors where the ambient air temperature is a minimum of 70°F (21°C).

• Do not pull unit by power cord.

• Discontinue use if power cord is frayed or worn.

• Do not attempt to repair or replace a damaged power cord. Cord must be replaced by Hatco, an Authorized Hatco Service Agent, or a person with similar qualifications.

• Do not steam clean or use excessive water on unit.

• This unit is not “jet-proof” construction. Do not use jet-clean spray to clean unit.

• NEVER insert a knife, fork, or similar object into toasting chamber.

• Do not pick up toaster by inserting fingers into toaster slots and grasping heating elements.

• Do not clean unit when it is energized or hot.

• Do not allow liquids to spill into unit.

• Unit must be serviced by qualified personnel only. Service by unqualified personnel may lead to electric shock or burn.

FIRE HAZARD:

 • Locateunitaminimumof1″(25mm)fromcombustible

walls and materials. If safe distances are not maintained, combustion or discoloration could occur.

• Do not place anything on top of toaster. Do not place toaster near or underneath curtains or other combustible materials. Items near or on top of toaster could catch fire causing injury and/or damage to the toaster.

EXPLOSION HAZARD: Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance.

In case of fire, disconnect toaster from power source immediately. This allows unit to cool, making it easier and safer to put out the fire.

Make sure all operators have been instructed on the safe and proper use of the unit.

This unit is not intended for use by children or persons with reduced physical, sensory, or mental capabilities. Ensure proper supervision of children and keep them away from unit.

This unit has no “user-serviceable” parts. If service is required on this unit, contact an Authorized Hatco Service Agent or contact the Hatco Service Department at 800-558-0607 or 414-671-6350.

BURN HAZARD:

• Some exterior surfaces on unit will get hot. Use caution when touching these areas.

• Do not remove crumb trays for cleaning until toaster is cool.

Locate unit at proper counter height in an area that is convenient for use. Location should be level to prevent unit or its contents from falling accidentally and strong enough to support weight of unit and contents.

Always operate toaster with crumb trays installed. Toasting of coated or buttered products such as garlic

bread, cheese sandwiches, and sweet rolls is NOT recommended. Residue will reduce toaster performance and could ignite inside toaster. Using toaster with food products listed above will void unit warranty.

NOTICE

Do not lay unit on the side with the control panel or damage to the unit could occur.

Use non-abrasive cleaners and cloths only. Abrasive cleaners and cloths could scratch finish of unit, marring its appearance and making it susceptible to soil accumulation.

This unit is intended for commercial use only — NOT for household use.

Clean unit daily to avoid malfunctions and maintain sanitary operation.

Form No. TPTM-0817

MODEL DESCRIPTION

Model TPT-120

Models TPT-208/TPT-240

All Models

Hatco Pop-Up Toasters are perfect for buffet areas and lighter volume restaurants. The TPT series toasters have four selfcentering, extra wide slots with individual progressive toasting controls. Models TPT-208 and TPT-240 are equipped with bagel/bun buttons for one-sided toasting. The durable stainless steel housing contains removable crumb trays for easy cleaning.

English

TPT Series Pop-Up Toasters

Form No. TPTM-0817

English

12-3/8"

(313 mm)

13-5/8"

(346 mm)

8-1/16"

(204 mm)

12"

(304 mm)

8-1/16"

(204 mm)

TPT Series Slot Openings = 1-1/4" W x 5-1/2" D x 4-1/2" H (32 x 140 x114 mm)

Front View Side View

WARNING

NEMA 5-15PNEMA 6-15P

NEMA 6-20P

SPECIFICATIONS

Plug Configurations

Units are supplied from the factory with an electrical cord and plug installed. Plugs are supplied according to the application.

ELECTRIC SHOCK HAZARD: Plug unit into a properly grounded electrical receptacle of correct voltage, size, and plug configuration. If plug and receptacle do not match, contact a qualified electrician to determine and install proper voltage and size electrical receptacle.

NOTE: Specification label located on the bottom of the unit.

See label for serial number and verification of unit electrical information.

NOTE: Receptacle not supplied by Hatco.

Plug Configurations

Electrical Rating Chart

Model Voltage Watts Amps Plug Configuration Shipping Weight

TPT-120 (US)

120

TPT-120 (CAN) 1440 12.0

TPT-208 208

TPT-240 240 10.8 NEMA 6-15P

1800 15.0

NEMA 5-15P

15 lbs. (7 kg)

12.5 NEMA 6-15P*

2600

* NEMA 6-20P for Canada.

Dimensions

Form No. TPTM-0817

INSTALLATION

TOAST/BAGEL

Button

Operating Lever

TPT-208/TPT-240

Crumb

Tray

Toasting Slot

TPT-120

COLOR

CONTROL

Knob

English

General

The Pop-Up Toaster is shipped with all components preassembled. Care should be taken when unpacking the shipping carton to avoid damage to the unit and the components enclosed.

WARNING

ELECTRIC SHOCK HAZARD: Unit is not weatherproof. Locate unit indoors where ambient air temperature is a minimum of 70°F (21°C).

EXPLOSION HAZARD: Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance.

FIRE HAZARD:

 • Locateunitaminimumof1″(25mm)fromcombustible

walls and materials. If safe distances are not maintained, combustion or discoloration could occur.

NOTE: TPT Series toasters require a dedicated circuit.

1. Remove the unit from the carton.

NOTE: To prevent delay in obtaining warranty coverage,

complete online warranty registration. See the IMPORTANT OWNER INFORMATION section for details.

2. Remove tape and protective packaging from all surfaces of the unit.

3. Place the unit in the desired location.

• Locate the unit in an area where the ambient air

temperature is constant and a minimum of 70°F

(21°C). Avoid areas that may be subject to active air movements or currents (i.e., near exhaust fans/hoods, air conditioning ducts, and exterior doors).

• Make sure the unit is at the proper counter height in an

area convenient for use.

• Make sure the countertop is level and strong enough to

support the weight of the unit and food product.

• Make sure all the feet on the bottom of the unit are

positioned securely on the countertop.

Components

Form No. TPTM-0817

+ 14 hidden pages