Hatco TK-135B, TK-72, TK-155B, TRH-50, TRH-60 Installation And Operating Manual

...
Page 1
www.hatcocorp.com
WARNING
ADVERTENCIA
AVERTISSEMENT
(see page 2)
®
Toast-Rite
and Toast King
Electric Conveyor Toasters
TRH and TK Series
Installation and Operating Manual
P/N 07.04.290.00
®
Do not operate this equipment unless you have read and understood the contents of this manual! Failure to follow the instructions contained in this manual may result in serious injury or death. This manual contains important safety information concerning the maintenance, use, and operation of this product. If you’re unable to understand the contents of this manual, please bring it to the attention of your supervisor. Keep this manual in a safe location for future reference.
No opere este equipo al menos que haya leído y comprendido el contenido de este manual! Cualquier falla en el seguimiento de las instrucciones contenidas en este manual puede resultar en un serio lesión o muerte. Este manual contiene importante información sobre seguridad concerniente al mantenimiento, uso y operación de este producto. Si usted no puede entender el contenido de este manual por favor pregunte a su supervisor. Almacenar este manual en una localización segura para la referencia futura.
Ne pas utiliser cet équipement sans avoir lu et compris le contenu de ce manuel ! Le non-respect des instructions contenues dans ce manuel peut entraîner de graves blessures ou la mort. Ce manuel contient des informations importantes concernant l'entretien, l'utilisation et le fonctionnement de ce produit. Si vous ne comprenez pas le contenu de ce manuel, veuillez le signaler à votre supérieur. Conservez ce manuel dans un endroit sûr pour pouvoir vous y référer plus tard.
© 2012 Hatco Corporation
Page 2
WARNING
CAUTION
NOTICE
CONTENTS
Important Owner Information ..............................................2
Introduction...........................................................................2
Important Safety Instructions..............................................3
Model Description.................................................................4
All Models ...........................................................................4
Toast-Rite Toast King
Model Designation................................................................4
Specifications........................................................................5
Plug Configurations ............................................................5
Electrical Rating Chart—TRH Models ................................6
Electrical Rating Chart—TK Models ...................................7
Dimensions—TRH Models .................................................8
Dimensions—TK Models ....................................................9
®
(TRH) Models...................................................4
®
(TK) Models.....................................................4
IMPORTANT OWNER INFORMATION
Record the model number, serial number (specification label located on the back of the unit), voltage, and purchase date of the unit in the spaces below. Please have this information available when calling Hatco for service assistance.
Model No. ____________________________________
Serial No. ____________________________________
Voltage ______________________________________
Date of Purchase ______________________________
Register your unit!
Completing online warranty registration will prevent delay in obtaining warranty coverage. Access the Hatco website at
www.hatcocorp.com, select the Parts & Service pull-down
menu, and click on “Warranty Registration”.
Installation...........................................................................10
General.............................................................................10
Operation .............................................................................11
General .............................................................................11
Thermostat Adjustment.....................................................11
Maintenance ........................................................................12
General.............................................................................12
Daily Cleaning ..................................................................12
Cleaning the Toasting Baskets .........................................12
Troubleshooting Guide ......................................................13
Options and Accessories...................................................14
Limited Warranty.................................................................15
Authorized Parts Distributors............................Back Cover
Business 8:00 AM to 5:00 PM Hours: Central Standard Time (C.S.T.)
(Summer Hours: June to September – 8:00
AM to 5:00 PM C.S.T. Monday – Thursday
8:00
AM to 2:30 PM C.S.T. Friday)
Telephone: (800) 558-0607; (414) 671-6350
E-mail: partsandservice@hatcocorp.com
Fax: (800) 690-2966 (Parts and Service)
(414) 671-3976 (International)
24 Hour 7 Day Parts and Service Assistance available in the United States and Canada by calling (800) 558-0607.
Additional information can be found by visiting our web site at
www.hatcocorp.com.
INTRODUCTION
The Hatco Toast-Rite and Toast King Electric Conveyor Toasters are specially designed to speed the toasting operation. Products pass through a heating chamber for rapid and thorough toasting. Dryness, moisture, sugar content, and thickness of bread product affect the ability to achieve the perfect toasted product. Conveyor speed, not temperature, determines the toasting color.
Hatco toasters are quality built to meet the demands of foodservice operations and provide years of trouble-free performance. The metal-sheathed tubular heating elements are guaranteed against breakage and burnout for two years. (If failure of one element should occur, your Hatco toaster will continue to operate – the production may be slightly lower.)
Hatco Electric Conveyor Toasters are products of extensive research and field testing. The materials used were selected for maximum durability, attractive appearance, and optimum performance. Every unit is inspected and tested thoroughly prior to shipment.
This manual provides the installation, safety, and operating instructions for Hatco Electric Conveyor Toasters. Hatco recommends all installation, operating, and safety instructions appearing in this manual be read prior to installation or operation of a unit.
Safety information that appears in this manual is identified by the following signal word panels:
WARNING indicates a hazardous situation which, if not avoided, could result in death or serious injury.
CAUTION indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
NOTICE is used to address practices not related to personal injury.
2
Form No. TRTKM-0812
Page 3
IMPORTANT SAFETY INSTRUCTIONS
WARNING
CAUTION
NOTICE
WARNING
Read the following important safety information before using this equipment to avoid serious injury or death and to avoid damage to equipment or property.
ELECTRIC SHOCK HAZARD:
• Plug unit into a properly grounded electrical receptacle of correct voltage, size, and plug configuration. If plug and receptacle do not match, contact a qualified electrician to determine and install proper voltage and size electrical receptacle.
• Turn OFF power switch, unplug power cord, and allow unit to cool before performing cleaning, adjustments, maintenance, or attempting to clear a jam.
• DO NOT submerge or saturate with water. Unit is not waterproof. Do not operate if unit has been submerged or saturated with water.
• Unit is not weatherproof. Locate unit indoors where the ambient air temperature is a minimum of 70°F (21°C).
• Do not pull unit by power cord.
• Discontinue use if power cord is frayed or worn.
• Do not attempt to repair or replace a damaged power cord. Cord must be replaced by Hatco, an Authorized Hatco Service Agent, or a person with similar qualifications.
• Do not steam clean or use excessive water on unit.
• This unit is not “jet-proof” construction. Do not use jet­clean spray to clean unit.
• Do not clean unit when it is energized or hot.
• Do not allow liquids to spill into unit.
• This unit must be serviced by qualified personnel only. Service by unqualified personnel may lead to electric shock or burn.
This unit has no “user-serviceable” parts. If service is required on this unit, contact an Authorized Hatco Service Agent or contact the Hatco Service Department at 800-558-0607 or 414-671-6350; fax 800-690-2966; or International fax 414-671-3976.
BURN HAZARD:
• Some exterior surfaces on unit will get hot. Use caution when touching these areas.
• Do not remove toast collector pan or baskets for cleaning until toaster is cool.
Locate unit at proper counter height in an area that is convenient for use. Location should be level to prevent unit or its contents from falling accidentally and strong enough to support weight of unit and contents.
Products thicker than 1-1/4" (32 mm) will cause conveyor system to jam, which could ignite product inside toaster.
Misalignment of toasting baskets will cause conveyor to jam. Hold down bars should be facing out and lying flat on baskets. Incorrectly positioned bars will cause conveyor to stop.
Always operate toaster with toast collector pan installed. Toasting of coated or buttered products such as garlic
bread, cheese sandwiches, and sweet rolls is NOT recommended. Residue will reduce toaster performance and could ignite inside toaster. Using toaster with food products listed above will void unit warranty.
FIRE HAZARD:
• Locate unit a minimum of 1″ (25 mm) from combustible walls and materials. If safe distances are not maintained, combustion or discoloration could occur.
• Do not locate toaster under shelving or closer than 12" (305 mm) from the ceiling.
• Do not place anything on top of toaster. Do not place toaster near or underneath curtains or other combustible materials. Items near or on top of toaster could catch fire causing injury and/or damage to toaster.
EXPLOSION HAZARD: Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance.
In case of fire, disconnect toaster from power source immediately. This allows unit to cool, making it easier and safer to put out the fire.
Make sure all operators have been instructed on the safe and proper use of the unit.
This unit is not intended for use by children or persons with reduced physical, sensory, or mental capabilities. Ensure proper supervision of children and keep them away from unit.
Form No. TRTKM-0812
Do not locate unit in an area subject to excessive temperatures or grease from grills, fryers, etc. Excessive temperatures could cause damage to the unit.
Do not locate toaster in an area that restricts air flow around front or rear of unit. Do not locate toaster in direct discharge path of air conditioning vent or makeup air vent.
Do not lay unit on the side with control panel or manual advance knob. Damage to unit could occur.
Use non-abrasive cleaners and cloths only. Abrasive cleaners and cloths could scratch finish of unit, marring its appearance and making it susceptible to soil accumulation.
This unit is intended for commercial use only—NOT for household use.
3
Page 4
MODEL DESCRIPTION
Toasting
Basket
Toast
Collector
Pan
Manual Advance Knob
Speed Control
Selector Switch
Manual Advance Knob
Toasting
Basket
Toast
Collector
Pan
Speed Control
Selector Switch
T R H - X X X B
TRH = Toast-Rite
TK = Toast King
Model Number
B = Buns model (Toasts one side)
All Models
All Toast-Rite®and Toast King®Electric Conveyor Toasters are fast, dependable, and versatile. Multiple heating elements assure continuous toasting, and are guaranteed against burnout and breakage for two years.
Every unit includes a toast collector pan, heated toast storage area, power saving thermostat, speed control, manual advance, and factory attached 4' (1219 mm) cord and plug.
Toast-Rite Models
Toast-Rite models are used for constant, medium-to-high volume applications. They are capable of toasting up to 600 slices of bread per hour. The toasting baskets are two-slices wide.
TRH-50 Model
The TRH-50 model toasts up to 8 bread or bun slices per minute (600 per hour).
TRH-60 Model
The TRH-60 model toasts up to 10 bread or bun slices per minute (600 per hour).
Toast King Models
Toast King models are for constant, high volume applications. They use fast heat-up, three-basket access for fast loading, and a vented top to toast up to 700–1500 slices of bread per hour.
TK-72 Model
The TK-72 model toasts up to 12 bread or bun slices per minute (720 per hour) and features toasting baskets two-slices wide.
TK-100 Model
The TK-100 model toasts up to 16 bread or bun slices per minute (1000 per hour) and features toasting baskets three­slices wide.
TK-135B Model
The TK-135B model is a buns only toaster that toasts up to 22 bun slices per minute (1350 per hour) and features toasting baskets three-slices wide.
TK-155B Model
The TK-155B model is a 3-part hamburger bun toaster that toasts up to 25 3-part bun slices per minute (1550 per hour) and features toasting baskets three-slices wide. The outside buns are toasted on one side, the middle bun is toasted on both sides.
TRH Series
MODEL DESIGNATION
TK-100 Model
4
Form No. TRTKM-0812
Page 5
SPECIFICATIONS
WARNING
NEMA 6-20P
CEE 7/7 Schuko
NEMA 5-30P
BS 1363
NEMA 6-30P
Plug Configurations
Units are supplied from the factory with an electrical cord and plug installed. Plugs are supplied according to the applications.
ELECTRIC SHOCK HAZARD: Plug unit into a properly grounded electrical receptacle of correct voltage, size, and plug configuration. If plug and receptacle do not match, contact a qualified electrician to determine and install proper voltage and size electrical receptacle.
NOTE: Specification label located on the back of the unit. See
label for serial number and verification of unit electrical information.
Connecting Supply Wires
If local codes require Greenfield or conduit hook-up, consult a licensed electrical contractor to perform supply wire connection. Access to the unit wiring is through the rear lower access panel.
To connect supply wires to the toaster:
1. Remove the screws securing the side panels, and remove the side panels.
2. Remove the screws securing the rear lower access panel, and remove the panel.
3. Insert the Greenfield or conduit through the opening in the rear access panel and attach to the power supply bracket. Connect the wires.
4. Attach the ground wire to the power supply bracket at the threaded hole marked “G”.
5. Reinstall access panel and side panels.
Plug Configurations
NOTE: Receptacles are not supplied by Hatco, but are
available as accessories.
Form No. TRTKM-0812
5
Page 6
SPECIFICATIONS
Electrical Rating Chart—TRH Models
Model Voltage Hertz Watts Amps Plug Configuration Shipping Weight
TRH-50 120 60 2738 22.8 NEMA 5-30P 60 lbs. (27 kg)
208 60 2738 13.2 NEMA 6-20P 60 lbs. (27 kg)
240 60 2738 11.4 NEMA 6-20P 60 lbs. (27 kg)
220 60 2738 12.5 CEE 7/7 Schuko 60 lbs. (27 kg)
220 50 2738 12.5 CEE 7/7 Schuko 60 lbs. (27 kg)
220–230 CE 50 2738–2993 12.5–13.0 CEE 7/7 Schuko 60 lbs. (27 kg)
230–240 CE 50 2514–2738 10.9–11.4 BS 1363 60 lbs. (27 kg)
240 50 2738 11.4 BS 1363 60 lbs. (27 kg)
TRH-60 208 60 3838 18.5 NEMA 6-20P* 60 lbs. (27 kg)
240 60 3838 16.0 NEMA 6-20P 60 lbs. (27 kg)
200 50 3548 17.7 NEMA 6-20P 60 lbs. (27 kg)
220 60 3838 17.5 No Cap 60 lbs. (27 kg)
220 50 3838 17.5 CEE 7/7 Schuko 60 lbs. (27 kg)
220–230 CE 50 3838–4195 17.5–18.2 No Cap 60 lbs. (27 kg)
230–240 CE 50 3524–3838 15.3–16.0 No Cap 60 lbs. (27 kg)
240 50 3838 16.0 BS 1363 60 lbs. (27 kg)
TRH-65 (CE)
220–230 CE 50 4338–4741 19.7–20.6 No Cap 60 lbs. (27 kg)
230–240 CE 50 3984–4338 17.3–18.1 No Cap 60 lbs. (27 kg)
The shaded areas contain electrical information for International models only.
* NEMA 6-30P for Canada.
NOTE: Units with “No Cap” plug configuration come with a power cord only (no plug).
6
Form No. TRTKM-0812
Page 7
SPECIFICATIONS
Electrical Rating Chart—TK Models
Model Voltage Hertz Watts Amps Plug Configuration Shipping Weight
TK-72 208 60 4038 19.4 NEMA 6-20P* 73 lbs. (33 kg)
240 60 4038 16.8 NEMA 6-20P* 73 lbs. (33 kg)
200 50 3733 18.7 NEMA 6-20P 73 lbs. (33 kg)
220 50 4038 18.4 No Cap 73 lbs. (33 kg)
220 60 4038 18.4 No Cap 73 lbs. (33 kg)
220–230 CE 50 4038–4414 18.4–19.2 No Cap 73 lbs. (33 kg)
230–240 CE 50 3708–4038 16.1–16.8 No Cap 73 lbs. (33 kg)
240 50 4038 16.8 No Cap 73 lbs. (33 kg)
TK-75
TK-100 208 60 5038 24.0 NEMA 6-30P 88 lbs. (40 kg)
TK-105
TK-135B 208 60 4338 20.9 NEMA 6-30P 88 lbs. (40 kg)
TK-155B 208 60 5018 24.1 NEMA 6-30P 88 lbs. (40 kg)
220–230 CE 50 5238–5725 23.8–24.9 No Cap 73 lbs. (33 kg)
230–240 CE 50 4811–5238 21.0–21.8 No Cap 73 lbs. (33 kg)
240 60 5038 21.0 NEMA 6-30P 88 lbs. (40 kg)
200 50 4657 23.3 NEMA 6-30P 88 lbs. (40 kg)
220 60 5038 22.9 No Cap 88 lbs. (40 kg)
220 50 5038 22.9 No Cap 88 lbs. (40 kg)
220–230 CE 50 5038–5507 22.9–23.9 No Cap 88 lbs. (40 kg)
230–240 CE 50 4626–5038 20.1–21.0 No Cap 88 lbs. (40 kg)
240 50 5038 21.0 No Cap 88 lbs. (40 kg)
220 50 7438 33.8 No Cord 88 lbs. (40 kg)
240 50 5678 23.7 No Cap 88 lbs. (40 kg)
220–230 CE 50 7438–8129 33.8–35.3 No Cord 88 lbs. (40 kg)
230–240 CE 50 6830–7438 30.0–31.0 No Cord 88 lbs. (40 kg)
240 60 4338 18.1 NEMA 6-20P* 88 lbs. (40 kg)
220 60 4338 19.7 No Cap 88 lbs. (40 kg)
220 50 4338 19.7 No Cap 88 lbs. (40 kg)
220–230 CE 50 4338–4741 19.7–20.6 No Cap 88 lbs. (40 kg)
230–240 CE 50 3984–4338 17.3–18.1 No Cap 88 lbs. (40 kg)
240 50 4338 18.1 No Cap 88 lbs. (40 kg)
240 60 5018 20.9 NEMA 6-30P 88 lbs. (40 kg)
220 60 5018 22.8 No Cap 88 lbs. (40 kg)
220 50 5018 22.8 No Cap 88 lbs. (40 kg)
240 50 5018 20.9 No Cap 88 lbs. (40 kg)
The shaded areas contain electrical information for International models only.
* NEMA 6-30P for Canada.
NOTE: Units with “No Cap” plug configuration come with a power cord only (no plug).
Form No. TRTKM-0812
7
Page 8
SPECIFICATIONS
B
A
E
Front View
Side View
D
C
Dimensions—TRH Models
Width
Model
TRH-50 18-1/4″
TRH-60 18-1/4″
TRH-65E 18-1/4″
(A)
(464 mm)
(464 mm)
(464 mm)
Depth
(B)
27-1/2″
(699 mm)
27-1/2″
(699 mm)
27-1/2″
(699 mm)
Height
(C)
16-1/2″
(418 mm)
16-1/2″
(418 mm)
16-1/2″
(418 mm)
Footprint Width (D)
9-7/8″
(252 mm)
9-7/8″
(252 mm)
9-7/8″
(252 mm)
Footprint Depth (E)
20-1/4″
(516 mm)
20-1/4″
(516 mm)
20-1/4″
(516 mm)
8
Form No. TRTKM-0812
Page 9
Dimensions—TK Models
A
C
B
E
Front View
Side View
D
SPECIFICATIONS
Width
Model
TK-72 18-1/4″
TK-75 18-1/4″
TK-100 22-3/4″
TK-105 22-3/4″
TK-135B 22-3/4″
TK-155B 22-3/4″
(A)
(464 mm)
(464 mm)
(578 mm)
(578 mm)
(578 mm)
(578 mm)
Depth
(B)
17-5/8″
(448 mm)
17-5/8″
(448 mm)
17-5/8″
(448 mm)
17-5/8″
(448 mm)
17-5/8″
(448 mm)
17-5/8″
(448 mm)
Height
(C)
33″
(838 mm)
33″
(838 mm)
33″
(838 mm)
33″
(838 mm)
33″
(838 mm)
33″
(838 mm)
Footprint Width (D)
13-3/4″
(349 mm)
13-3/4″
(349 mm)
18-1/4″
(464 mm)
18-1/4″
(464 mm)
18-1/4″
(464 mm)
18-1/4″
(464 mm)
Footprint Depth (E)
11-1/4″
(287 mm)
11-1/4″
(287 mm)
11-1/4″
(287 mm)
11-1/4″
(287 mm)
11-1/4″
(287 mm)
11-1/4″
(287 mm)
Form No. TRTKM-0812
9
Page 10
INSTALLATION
Toast Collector Pan
Speed Control
Selector Switch
Manual Advance Knob
WARNING
NOTICE
General
Hatco Toast-Rite®and Toast King®Electric Conveyor Toasters are shipped with all components pre-assembled. Care should be taken when unpacking the shipping carton to avoid damage to the unit and the components enclosed.
ELECTRIC SHOCK HAZARD: Unit is not weatherproof. Locate unit indoors where ambient air temperature is a minimum of 70°F (21°C).
EXPLOSION HAZARD: Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance.
FIRE HAZARD:
• Locate unit a minimum of 1″ (25 mm) from combustible walls and materials. If safe distances are not maintained, combustion or discoloration could occur.
• Do not place anything on top of toaster. Do not place toaster near or underneath curtains or other combustible materials. Items near or on top of toaster could catch fire causing injury and/or damage to toaster.
1. Remove the unit from the carton.
NOTE: To prevent delay in obtaining warranty coverage,
complete online warranty registration. See the IMPORTANT OWNER INFORMATION section for details.
2. Remove tape and protective packaging from all surfaces of the unit.
3. Place the unit in the desired location.
4. Install the toast collector pan.
5. If the unit does not have a plug installed on the power cord, contact a qualified electrician to determine and install the proper voltage and size electrical plug. See the SPECIFICATIONS section for details.
NOTE: Hatco tests each toaster with bread product prior to
shipping.
TK-100 Model
Do not locate unit in an area subject to excessive temperatures or grease from grills, fryers, etc. Excessive temperatures could cause damage to the unit.
Do not locate toaster in an area that restricts air flow around front or rear of unit. Do not locate toaster in direct discharge path of air conditioning vent or makeup air vent.
• Locate the unit in an area where the ambient air temperature is constant and a minimum of 70°F (21°C). Avoid areas that may be subject to active air movements or currents (i.e., near exhaust fans/hoods and air conditioning ducts).
• Make sure the unit is at the proper counter height in an area convenient for use.
• Make sure the countertop is level and strong enough to support the weight of the unit and food product.
• Make sure all the feet on the bottom of the unit are positioned securely on the countertop.
10
Form No. TRTKM-0812
Page 11
General
WARNING
CAUTION
CAUTION
Selector Switch
Speed Control
Manual Advance Knob
Thermostat Adjustment Screw
Hatco Toasters are designed for ease of operation. Perform the following procedure to operate the toaster.
Read all safety messages in the IMPORTANT SAFETY INFORMATION section before operating this equipment.
1. Plug the unit into a properly grounded electrical receptacle of the correct voltage, size, and plug configuration. See the SPECIFICATIONS section for details.
2. Turn the Selector Switch from the OFF (O) position to the TOAST or BUNS position.
NOTE: When toasting buns or bagels, place cut side facing out
and set the Selector Switch to the BUNS position.
3. Turn the Speed Control counter-clockwise to the lightest/fastest position while the unit heats up.
NOTE: Allow approximately 15 minutes for a warm-up period.
Always operate toaster with toast collector pan installed. BURN HAZARD: Some exterior surfaces on unit will get hot.
Use caution when touching these areas.
4. After warm-up period, set the Speed Control to the desired toast darkness setting. The “1” setting on the Speed Control knobs represents the lightest toast setting and the “7” setting represents the darkest.
NOTE: To toast moist products such as English muffins, rye
bread, or whole wheat, slow the conveyor by turning the Speed Control knob to a DARKER setting (clockwise).
Toasting of coated or buttered products such as garlic bread, cheese sandwiches, and sweet rolls is NOT recommended. Residue will reduce toaster performance and could ignite inside toaster. Using toaster with food products listed above will void unit warranty.
Products thicker than 1-1/4" (32 mm) will cause conveyor system to jam, which could ignite product inside toaster.
OPERATION
Control Panel (TK-100 shown)
Manual Advance
The manual advance knob is located on the right side panel of the toaster. This knob permits manual advancement of the toasting baskets and allows rapid discharge of toast.
Thermostat Adjustment
The thermostat adjustment screw is located on the control panel. The thermostat controls the toasting chamber temperature and is preset at the factory.
If adjustment is needed, use the following procedure.
1. Turn the Selector Switch to the TOAST or BUNS position and allow approximately 15 minutes for a warm-up period.
• The thermostat should be adjusted when the toaster is at the operation temperature.
2. Turn the adjustment screw using a small screwdriver.
• Turn the screw clockwise to increase temperature or counterclockwise to decrease the temperature.
NOTE: Do not turn the screw more than 1/8 turn at a time. Allow
at least five minutes for temperature to stabilize.
Form No. TRTKM-0812
11
Page 12
MAINTENANCE
WARNING
WARNING
CAUTION
CAUTION
Spring-Loaded
Chain
Toasting Basket
Hold Down
Bar
General
Hatco Electric Conveyor Toasters are designed for maximum durability and performance, with minimum maintenance.
NOTE: The conveyor chain gear motor is permanently
lubricated and requires no maintenance.
ELECTRIC SHOCK HAZARD:
• Turn OFF power switch, unplug power cord, and allow unit to cool before performing cleaning, adjustments, maintenance, or attempting to clear a jam.
• DO NOT submerge or saturate with water. Unit is not waterproof. Do not operate if unit has been submerged or saturated with water.
• Do not steam clean or use excessive water on unit.
• This unit is not “jet-proof” construction. Do not use jet­clean spray to clean this unit.
• Do not clean unit when it is energized or hot.
This unit has no “user-serviceable” parts. If service is required on this unit, contact an Authorized Hatco Service Agent or contact the Hatco Service Department at 800-558-0607 or 414-671-6350; fax 800-690-2966; or International fax 414-671-3976.
Daily Cleaning
To preserve the finish of the toaster, it is recommended that the metal surfaces be wiped daily with a non-abrasive, damp cloth.
Submerging or saturating unit with water will damage the unit and void unit warranty.
Do not remove toast collector pan or baskets for cleaning until toaster is cool.
1. Turn the Selector Switch to the OFF (O) position, unplug power cord, and allow the unit to cool.
2. Remove and empty the toast collector pan.
3. Wash the toast collector pan with warm water and a mild detergent. Rinse with water.
4. Allow the toast collector pan to air dry before placing back into the toaster.
5. Wipe the exterior surface of the toaster with a damp cloth.
NOTICE: Use non-abrasive cleaners and cloths only.
6. Wipe dry the entire unit using a dry, non-abrasive cloth.
Cleaning the Toasting Baskets
The toasting baskets need to be removed from the toaster periodically in order to be cleaned properly.
1. Use the manual advance knob on the right side of the unit to advance the baskets without energizing the unit.
2. Remove the baskets by pushing the spring-loaded chain away from the basket while pulling the basket away from the chain and outward.
• The chain link pins must be pulled out of the toasting basket holes on the top of each side of the baskets.
Removing Toasting Baskets
NOTE: Do not detach the hold down bars when cleaning
toasting baskets.
3. Wipe clean with a soft, damp cloth or soak the baskets in a mild solution of soap and water.
4. Re-install a basket by aligning a pin on each chain with the holes in each side of the toasting basket. The pin on the right-hand chain must be exactly opposite the pin on the left­hand chain.
5. To attach the remaining baskets, advance the conveyor and repeat the previous step. Each basket must be hung immediately below the preceding basket for all baskets to fit properly.
Misalignment of toasting baskets will cause conveyor to jam. Hold down bars should be facing out and lying flat on baskets. Incorrectly positioned bars will cause conveyor to stop.
12
Form No. TRTKM-0812
Page 13
TROUBLESHOOTING GUIDE
WARNING
WARNING
This unit must be serviced by qualified personnel only. Service by unqualified personnel may lead to electric shock or burn.
ELECTRIC SHOCK HAZARD: Turn OFF power switch, unplug power cord, and allow unit to cool before performing cleaning, adjustments, maintenance, or attempting to clear a jam.
Symptom Probable Cause Corrective Action
Toast too light. Speed Control set on a light setting. Turn Speed Control to a darker setting.
Thermostat is set to low. Refer to “Thermostat Adjustment” in the
Supply voltage to unit is low. Verify the supply voltage to the toaster matches
Heating element defective. Visually check the heating element inside the
Toast too dark. Speed Control set on a dark setting. Turn Speed Control to a lighter setting.
Thermostat is set to high. Refer to “Thermostat Adjustment” in the
Supply voltage to unit is high. Verify the supply voltage to the toaster matches
Unit takes too long to toast. The first few batches can take longer because
the toaster needs time to heat up when initially turned on.
OPERATION section for information.
the unit specifications.
toaster with the unit turned on. The heating elements should glow red. If the element does not glow, Contact Authorized Service Agent or Hatco for assistance.
OPERATION section for information.
the unit specifications.
Wait until the toaster is at full operation temperature before inserting bread.
Unit toasts on one side only.
(TK-135B and TK-155B models are designed to toast one side of buns/bagels only.)
Toaster trips the circuit breaker or GFCI.
Supply voltage to unit is low. Verify the supply voltage to the toaster matches
The selector switch is in the BUNS position. Move the selector switch to the BREAD position.
Heating element defective. Visually check the heating element inside the
Circuit breaker is not sized properly for the toaster.
Wiring fault inside toaster. Contact Authorized Service Agent or Hatco for
the unit specifications.
toaster with the unit turned on. The heating elements should glow red. If the element does not glow, Contact Authorized Service Agent or Hatco for assistance.
Check circuit breaker for proper sizing.
assistance.
Form No. TRTKM-0812
13
Page 14
OPTIONS AND ACCESSORIES
Lengthen
Shorten
Adjustable Tip
NOTICE
4" (102 mm) Adjustable Legs
4” (102 mm) adjustable legs are available as accessories for all models. Use the following procedure to install the legs.
Do not lay unit on the side with control panel or manual advance knob. Damage to unit could occur.
1. Carefully place unit on its side.
2. Thread the 4" (102 mm) adjustable legs into the existing leg holes on the bottom of the unit.
3. After all legs are secure, return the unit to the upright position.
4. Level the unit by turning the adjustable tip on each leg. Use a 5/8″ (16mm) open-end wrench to make leveling adjustments.
Baskets for Jumbo Buns
Baskets for Jumbo Buns are available as accessories for TK­100, TK-135B, and TK-155B Models only. These baskets accommodate large buns up to 5-1/2" (140 mm) in diameter.
Security Control Cover
An optional security control cover is available for all models (not for field retrofit). A security control cover includes the control cover, bracket, and mounting hardware. TK models come with a fuse cover.
Receptacles
Receptacles are available as accessories for units using NEMA 5-20P, NEMA 5-30P, or NEMA 6-30P plugs.
Mounting Brackets
Mounting brackets are available as accessories to securely and permanently mount a toaster. The brackets are installed in the leg mounting holes. Fasteners not supplied.
14
Form No. TRTKM-0812
Page 15
LIMITED WARRANTY
1. PRODUCT WARRANTY
Hatco warrants the products that it manufactures (the “Products”) to be free from defects in materials and workmanship, under normal use and service, for a period of one (1) year from the date of purchase when installed and maintained in accordance with Hatco’s written instructions or 18 months from the date of shipment from Hatco. Buyer must establish the Product’s purchase date by registering the Product with Hatco or by other means satisfactory to Hatco in its sole discretion.
Hatco warrants the following Product components to be free from defects in materials and workmanship from the date of purchase (subject to the foregoing conditions) for the period(s) of time and on the conditions listed below:
a) One (1) Year Parts and Labor PLUS One (1) Additional
Year Parts-Only Warranty:
Conveyor Toaster Elements (metal sheathed) Drawer Warmer Elements (metal sheathed) Drawer Warmer Drawer Rollers and Slides Strip Heater Elements (metal sheathed) Display Warmer Elements (metal sheathed air heating) Holding Cabinet Elements (metal sheathed air heating) Heated Well Elements — HWB Series (metal sheathed)
b) One (1) Year Parts and Labor PLUS Four (4) Years
Parts-Only Warranty:
3CS and FR Tanks
c) One (1) Year Parts and Labor PLUS Nine (9) Years
Parts-Only Warranty on:
Electric Booster Heater Tanks Gas Booster Heater Tanks
d) Ninety (90) Day Parts-Only Warranty:
Replacement Parts
THE FOREGOING WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTY, EXPRESSED OR IMPLIED, INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR PATENT OR OTHER INTELLECTUAL PROPERTY RIGHT INFRINGEMENT. Without limiting the generality of the foregoing, SUCH WARRANTIES DO NOT COVER: Coated incandescent light bulbs, fluorescent lights, heat lamp bulbs, coated halogen light bulbs, halogen heat lamp bulbs, xenon light bulbs, LED light tubes, glass components, and fuses; Product failure in booster tank, fin tube heat exchanger, or other water heating equipment caused by liming, sediment buildup, chemical attack, or freezing; or Product misuse, tampering or misapplication, improper installation, or application of improper voltage.
2. LIMITATION OF REMEDIES AND DAMAGES
Hatco’s liability and Buyer’s exclusive remedy hereunder will be limited solely, at Hatco’s option, to repair or replacement using new or refurbished parts or Product by Hatco or a Hatco­authorized service agency (other than where Buyer is located outside of the United States, Canada, United Kingdom, or Australia, in which case Hatco’s liability and Buyer’s exclusive remedy hereunder will be limited solely to replacement of part under warranty) with respect to any claim made within the applicable warranty period referred to above. Hatco reserves the right to accept or reject any such claim in whole or in part. In the context of this Limited Warranty, “refurbished” means a part or Product that has been returned to its original specifications by Hatco or a Hatco-authorized service agency. Hatco will not accept the return of any Product without prior written approval from Hatco, and all such approved returns shall be made at Buyer’s sole expense. HATCO WILL NOT BE LIABLE, UNDER ANY CIRCUMSTANCES, FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES, INCLUDING BUT NOT LIMITED TO LABOR COSTS OR LOST PROFITS RESULTING FROM THE USE OF OR INABILITY TO USE THE PRODUCTS OR FROM THE PRODUCTS BEING INCORPORATED IN OR BECOMING A COMPONENT OF ANY OTHER PRODUCT OR GOODS.
Form No. TRTKM-0812
15
Page 16
HATCO AUTHORIZED PARTS DISTRIBUTORS
HATCO CORPORATION
P.O. Box 340500
Milwaukee, WI 53234-0500 U.S.A.
(800) 558-0607 (414) 671-6350
Parts and Service Fax (800) 690-2966
International Fax (414) 671-3976
partsandservice@hatcocorp.com
www.hatcocorp.com
ALABAMA
Jones McLeod Appl. Svc. Birmingham 205-251-0159
ARIZONA
Service Solutions Group Phoenix 602-234-2443
Byassee Equipment Co. Phoenix 602-252-0402
CALIFORNIA
Industrial Electric Commercial Parts & Service, Inc. Huntington Beach 714-379-7100
Chapman Appl. Service San Diego 619-298-7106
P & D Appliance Commercial Parts & Service, Inc. S. San Francisco 650-635-1900
COLORADO
Hawkins Commercial Appliance Englewood 303-781-5548
FLORIDA
Whaley Foodservice Repair Jacksonville 904-725-7800
3Wire Nass Service Co., Inc. Orlando 407-425-2681
B.G.S.I. Pompano Beach 954-971-0456
Comm. Appliance Service Tampa 813-663-0313
GEORGIA
TWC Services Mableton 770-438-9797
Heritage Service Group Norcross 866-388-9837
Southeastern Rest. Svc. Norcross 770-446-6177
HAWAII
Burney’s Comm. Service, Inc. Honolulu 808-848-1466
Food Equip Parts & Service Honolulu 808-847-4871
ILLINOIS
Parts Town Lombard 708-865-7278
Eichenauer Elec. Service Decatur 217-429-4229
Midwest Elec. Appl. Service Elmhurst 630-279-8000
Cone’s Repair Service Moline 309-797-5323
INDIANA
GCS Service Indianapolis 317-545-9655
IOWA
Electric Motor Service Co. Davenport 319-323-1823
Goodwin Tucker Group Des Moines 515-262-9308
KENTUCKY
Service Solutions Group Lexington 859-254-8854
Service Solutions Group Louisville 502-451-5411
LOUISIANA
Chandlers Parts & Service Baton Rouge 225-272-6620
MARYLAND
Electric Motor Service Baltimore 410-467-8080
GCS Service Silver Spring 301-585-7550
MASSACHUSETTS
Ace Service Co., Inc. Needham 781-449-4220
MICHIGAN
Bildons Appliance Service Detroit 248-478-3320
Commercial Kitchen Service Bay City 517-893-4561
Midwest Food Equip. Service Grandville 616-261-2000
MINNESOTA
GCS Service Plymouth 800-345-4221
MISSOURI
General Parts Kansas City 816-421-5400
Commercial Kitchen Services St. Louis 314-890-0700
Kaemmerlen Parts & Service St. Louis 314-535-2222
NEBRASKA
Anderson Electric Omaha 402-341-1414
NEVADA
Burney’s Commercial Las Vegas 702-736-0006
Hi. Tech Commercial Service N. Las Vegas 702-649-4616
NEW JERSEY
Jay Hill Repair Fairfield 973-575-9145
Service Plus Flanders 973-691-6300
NEW YORK
Acme American Repairs, Inc. Brooklyn 718-456-6544
Alpro Service Co. Brooklyn 718-386-2515
Appliance Installation Buffalo 716-884-7425
Duffy’s Equipment Services, Inc. Buffalo 800-836-1014
3Wire Northern Plattsburgh 800-634-5005
Duffy’s Equipment Services, Inc. Sauquoit 800-836-1014
J.B. Brady, Inc. Syracuse 315-422-9271
NORTH CAROLINA
Authorized Appliance Charlotte 704-377-4501
OHIO
Akron/Canton Comm. Svc. Inc. Akron 330-753-6635
Service Solutions Group Cincinnati 513-772-6600
Commercial Parts and Service Columbus 614-221-0057
Electrical Appl. Repair Service Brooklyn Heights 216-459-8700
E. A. Wichman Co. Toledo 419-385-9121
OKLAHOMA
Hagar Rest. Service, Inc. Oklahoma City 405-235-2184
Krueger, Inc. Oklahoma City 405-528-8883
OREGON
Ron’s Service, Inc. Portland 503-624-0890
PENNSYLVANIA
Elmer Schultz Services Philadelphia 215-627-5401
FAST Comm. Appl. Service Philadelphia 215-288-4800
Appliance Installation & Service Pittsburgh 412-809-0244
K & D Service Co. Harrisburg 717-236-9039
Electric Repair Co. Reading 610-376-5444
RHODE ISLAND
Marshall Electric Co. Providence 401-331-1163
SOUTH CAROLINA
Whaley Foodservice Repair W. Columbia 803-791-4420
TENNESSEE
Camp Electric Memphis 901-527-7543
TEXAS
GCS Service Fort Worth 800-433-1804
Armstrong Repair Service Houston 713-666-7100
Cooking Equipment Specialist Mesquite 888-866-9276
Refrigerated Specialist, Inc. Mesquite 888-866-9276
Commercial Kitchen Repair Co. San Antonio 210-735-2811
UTAH
La Monica’s Rest. Equip. Service Murray 801-263-3221
VIRGINIA
Daubers Norfolk 757-855-4097
Daubers Springfield 703-866-3600
WASHINGTON
3Wire Restaurant Appliance Seattle 800-207-3146
WISCONSIN
A.S.C., Inc. Madison 608-246-3160
A.S.C., Inc. Milwaukee 414-543-6460
CANADA
ALBERTA
Key Food Equipment Service Edmonton 780-438-1690
BRITISH COLUMBIA
Key Food Equipment Service Vancouver 604-433-4484
Key Food Equipment Service Victoria 250-920-4888
MANITOBA
Air Rite, Inc. Winnipeg 204-895-2300
NEW BRUNSWICK
EMR Services, Ltd. Moncton 506-855-4228
ONTARIO
R.G. Henderson Ltd. Toronto 416-422-5580
Choquette - CKS, Inc. Ottawa 613-739-8458
QUÉBEC
Choquette - CKS, Inc. Montreal 514-722-2000
Choquette - CKS, Inc. Québec City 418-681-3944
UNITED KINGDOM
Marren Group Northants +44(0)1933 665313
Printed in U.S.A. August 2012 P/N 07.04.290.00 Form No. TRTKM-0812
Register your unit online!
See IMPORTANT OWNER INFORMATION
section for details.
Loading...