Page 1
FLAV-R-SAVOR
®
Tall Holding Cabinets
PFST Series
Installation &
Operating Manual
I&W #07.05.092.00
This manual contains important safety information
concerning the maintenance, use and operation of
this product. Failure to follow the instructions
contained in this manual may result in serious injury.
If you are unable to understand the contents of this
manual, please bring it to the attention of your
supervisor. Do not operate this equipment unless
you have read and understood the contents of
this manual.
Este manual contiene importante información sobre
seguridad concerniente al mantenimiento, uso
y operación de este producto. Cualquier falla en
el seguimiento de las instrucciones contenidas en
este manual puede resultar en un serio daño. Si usted
no puede entender el contenido de este manual por
favor pregunte a su supervisor. No opere este equipo
al menos que haya leído y comprendido el contenido
de este manual.
Page 2
m
anual be read prior to installation or operation of your
H
atco T
all H
olding C
abinet. Safety instructions that
appear in this m
anual after a w
arning sym
bol
and
the w
ords
W
A
R
N
IN
G
or C
A
U
T
IO
N
printed in bold
face are very im
portant.
W
A
R
N
IN
G
m
eans there
is the possibility of serious injury or death to yourself
or others. C
A
U
T
IO
N
m
eans there is the possibility
of m
inor or m
oderate injury.
C
A
U
T
IO
N
w
ithout the
sym
bol
signifies the possibility of equipm
ent or property
dam
age only.
H
atco Flav-R
-Savor T
all H
olding C
abinet is a product
of extensive research and field testing. T
he m
aterials
used w
ere selected for m
axim
um
durability, attractive
appearance and optim
um
perform
ance. E
very unit
is thoroughly inspected and tested prior to shipm
ent.
i
INTRODUCTION
The Hatco Flav-R-Savor®Tall Portable Holding Cabinet
is designed to hold prepared foods for prolonged periods
of time while maintaining that “just-made” quality.
Hatco Holding Cabinets provide the best environment
for food products by regulating the air temperature.
The Flav-R-Savor air flow pattern is designed
to maintain consistent cabinet temperature without
drying out foods. The precise heat control creates
a “blanket” effect around the food. The air flow rate
enables the cabinet to rapidly recover temperature after
opening and closing the door.
This manual provides the installation, safety
and operating instructions for the Flav-R-Savor Tall
Holding Cabinet. We recommend all installation,
operating and safety instructions appearing in this
CONTENTS
Important Owner Information.....................................i
Introduction ...................................................................i
Important Safety Instructions .....................................1
Model Description.........................................................2
All Models ..............................................................2
PFST-1X..................................................................2
PFST-2X..................................................................2
Specifications.................................................................3
Plug Configurations ................................................3
Electrical Rating Chart............................................3
Dimensions..............................................................3
Installation.....................................................................4
All Models ..............................................................4
Location ..................................................................4
Operation.......................................................................5
All Models ..............................................................6
Maintenance ..................................................................7
General ....................................................................7
Cleaning ..................................................................7
Display Light Bulb Replacement............................7
Hatco Limited Warranty..............................................8
Authorized Parts Distributors....................Back Cover
IMPORTANT OWNER INFORMATION
Record the model number, serial number (identification
decal located on the lower side of the unit), voltage
and purchase date of your Flav-R-Savor
®
Heated Tall
Holding Cabinet in the spaces below. Please have this
information available when calling Hatco for service
assistance.
Model No. ____________________________________
Serial No. ____________________________________
Voltage ______________________________________
Date of Purchase ______________________________
Business 8:00 a.m. to 5:00 p.m.
Hours: Central Standard Time
(Summer Hours: June to September –
8:00 a.m. to 5:00 p.m. C.D.T.
Monday through Thursday
8:00 a.m. to 2:30 p.m. C.D.T. Friday)
Telephone: (800) 558-0607; (414) 671-6350
Fax: (800) 690-2966 (Parts & Service)
(414) 671-3976 (International)
Additional information can be found by visiting our
web site at www.hatcocorp.com
Form No. PFSTM-0602
Page 3
WARNINGS
Genuine Hatco Replacement Parts are specified
to operate safely in the environments in which
they are used. Some aftermarket or generic
replacement parts do not have the characteristics
that will allow them to operate safely in Hatco
equipment. It is essential to use Hatco
Replacement Parts when repairing Hatco
equipment. Failure to use Hatco Replacement
Parts may subject operators of the equipment
to hazardous electrical voltage, resulting in
electrical shock or burn.
CAUTIONS
Locate the unit at the proper counter height,
in an area that is convenient for use. The location
should be level to prevent the unit or its contents
from accidentally falling, and strong enough
to support the weight of the unit.
Some exterior surfaces on the unit will get
hot. Use caution when touching these areas
to avoid injury.
Unit is not weatherproof. For safe and proper
operation locate the unit indoors
where
the ambient air temperature is a minimum
of 70°F (21°C).
CAUTIONS
Use only non-abrasive cleaners. Abrasive
cleaners could scratch the finish of your unit
marring its appearance and making it susceptible
to soil accumulation.
IMPORTANT SAFETY INSTRUCTIONS
1
WARNINGS
Plug cabinet into a properly grounded electrical
outlet of the correct voltage, size, and plug
configuration. If the plug and receptacle do not
match, contact a qualified electrician to determine
the proper voltage and size, and install the proper
electrical outlet.
To avoid any injury, turn the power switch
off, unplug the unit from the power source
and allow to cool completely before performing
any maintenance or cleaning.
For safe and proper operation, the unit must be
located at a reasonable distance from combustible
walls and materials. If safe distances are not
maintained, discoloration or combustion could
occur.
Only light bulbs which meet or exceed N.S.F.
standards, specifically designed for food holding
areas must be used. Breakage of light bulbs not
specially coated could result in personal injury
and/or food contamination.
To avoid electrical shock or personal injury,
do not steam clean or use excessive water
on the unit.
To prevent any injury or damage do not pull unit
by power cord.
To prevent any injury, discontinue use if power
cord is frayed or worn.
If service is required on this unit, contact your
Authorized Hatco Service Agent, or contact
the Hatco Service Department at 800-558-0607
or 414-671-6350; fax 800-690-2966
or International fax 414-671-3976.
This product has no “user” serviceable parts.
To avoid damage to the unit or injury
to personnel, use only Authorized Hatco Service
Agents and Genuine Hatco Parts when service
is required.
Form No. PFSTM-0602
IMPORTANT! Read the following important safety instructions to avoid personal injury or death,
and to avoid damage to the equipment or property.
Page 4
MODEL DESCRIPTION
2
ALL MODELS
Flav-R-Savor®Tall Holding Cabinets are made
of sturdy extruded aluminum and stainless steel
and come with a full view tempered glass door.
The cabinets also feature tempered glass sides,
incandescent lights to illuminate the cabinet interior,
a temperature control to regulate the heat,
and a temperature monitor to indicate cabinet
temperature. Units have heavy-duty locking casters
for easy portability.
MODEL PFST-1X
The PFST-1X is a single door model.
MODEL PFST-2X
The PFST-2X is equipped with front and rear
access doors.
Figure 1. PFST-2X Model Shown
Form No.
PFSTM-0602
Page 5
PLUG CONFIGURATIONS
Units are supplied from the factory with an electrical
cord and plug installed. Plugs are supplied according
to the applications as shown in Figure 2.
WARNING
Plug cabinet into a properly grounded electrical
outlet of the correct voltage, size and plug
configuration. If the plug and receptacle do not
match, contact a qualified electrician to determine
the proper voltage and size and install the proper
electrical outlet.
WARNING
To prevent any injury or damage do not pull unit
by power cord.
WARNING
To prevent any injury, discontinue use if power cord
is frayed or worn.
SPECIFICATIONS
3
Form No. PFSTM-0602
NEMA 5-15P
CEE 7/7 Schuko
NEMA 5-20P
Figure 2. Plug Configurations
Width Depth Height*
Model (A) (B) (C)
PFST-1X 22-3/4" 25" 56-3/4"
(58 cm) (64 cm) (144 cm)
PFST-2X 22-3/4" 27-1/8" 56-3/4"
(58 cm) (69 cm) (144 cm)
DIMENSIONS
ELECTRICAL RATING CHART
* NEMA 5-20P for Canada
The electrical information in the shaded areas pertains to Export models only.
Figure 3. Dimensions
* Includes 5" (13 cm) casters; 51-3/4" (131 cm) without
casters.
Interior
dimensions: 21-1/4"W x 21-1/4"D x 41"H
(54 cm x 54 cm x 144 cm)
Rack
dimensions: 18-1/2"W x 16"D x 38-1/4"H
(47 cm x 40 cm x 97 cm)
Model Voltage Hertz Watts Amps Plug Configuration Shipping Weight
PFST-1X 120 60 1767 14.7 NEMA 5-15P* 188 lbs. (85 kg)
220 50/60 1747 7.9 CEE 7/7 Schuko 188 lbs. (85 kg)
PFST-2X 120 60 1767 14.7 NEMA 5-15P* 198 lbs. (90 kg)
220 50/60 1747 7.9 CEE 7/7 Schuko 198 lbs. (90 kg)
Page 6
INSTALLATION
4
Form No.
PFSTM-0602
Figure 4. PFST Models
ALL MODELS
The Flav-R-Savor®Tall Holding Cabinets are
shipped with most components installed and ready
for operation. The following installation instructions
must be performed before plugging in and operating
the cabinet.
1. Remove unit from box.
2. Remove information packet. To prevent delay
in obtaining warranty coverage, fill out and mail
in the warranty card.
3. Remove tape and protective packaging from
all surfaces of unit.
4. Install the handle(s) to the access door(s).
See Figure 4.
5. Carefully lay the unit on its side. Attach the 5"
(13 cm) casters using the mounting hardware
provided. Return cabinet to the upright position.
NOTE: Place a piece of cardboard between the cabinet
and floor to prevent marring the cabinet finish.
LOCATION
WARNING
For safe and proper operation, the unit must
be located at a reasonable distance from
combustible walls and materials. If safe distances
are not maintained, discoloration or combustion
could occur.
CAUTION
Locate the unit at the proper counter height,
in an area that is convenient for use. The location
should be level to prevent the unit or its contents
from accidentally falling, and strong enough
to support the weight of the unit.
CAUTION
Unit is not weatherproof. For safe and proper
operation locate the unit indoors
where the ambient
air temperature is a minimum of 70°F (21°C).
Handle
5" (13 cm) Caster
5" (13 cm) Caster
PFST-2X equipped with
front and rear doors
Page 7
5
Form No. PFSTM-0602
OPERATION
NOTE: Temperature settings may vary depending upon
product make-up and consistency. The cabinet
temperature indicator displays the lowest temperature
point inside the cabinet, not the product temperature.
4. Allow 30 minutes to preheat the cabinet. The
Flav-R-Savor Tall Cabinet is then ready to hold
foods at the temperature selected.
®
Power Switch
Cabinet Temperature
Indicator
Cabinet Temperature
Control
Figure 5. Control Panel
ALL MODELS
CAUTION
Some exterior surfaces on the unit will get hot. Use
caution when touching these areas to avoid injury.
1. Plug unit into a properly electrical outlet
of the correct voltage, size and plug configuration.
See SPECIFICATIONS for details.
2. Turn the Power Switch to the control panel
to the ON position.
3. Set temperature Control to the desired level.
Page 8
MAINTENANCE
6
Form No.
PFSTM-0602
GENERAL
Hatco Flav-R-Savor®Tall Holding Cabinets
are designed for maximum durability and performance,
with minimum maintenance.
WARNING
To avoid any injury, turn the power switch
off, unplug the unit from the power source
and allow to cool completely before performing
any maintenance or cleaning.
CLEANING
WARNING
To avoid electrical shock or personal injury, do not
steam clean or use excessive water on the unit.
To preserve the bright finish of the Flav-R-Savor Tall
Holding Cabinet, it is recommended that the exterior
and interior surfaces be wiped daily with a damp cloth.
Food pans should be removed and washed. Stubborn
stains may be removed with a good stainless steel
cleaner or a non-abrasive cleaner. Hard to reach areas
should be cleaned with a small brush and mild soap.
CAUTION
Use only non-abrasive cleaners. Abrasive
cleaners could scratch the finish of your unit
marring its appearance and making it susceptible
to soil accumulation.
Clean the glass doors and side panels using a common
glass cleaner and soft cloth.
DISPLAY LIGHT BULB REPLACEMENT
The display light is an incandescent light bulb which
illuminates the warming area. The bulb has a special
coating to guard against injury and food contamination
in the event of breakage.
1. To replace a light bulb, disconnect the power supply
and wait until the unit has cooled.
2. Bulbs have a threaded base. Unscrew the light bulb
from the unit and replace it with a new specially
coated incandescent bulb.
NOTE: Hatco shatter-resistant light bulbs meet N.S.F.
standards for food holding and display areas. For 120
volt applications, use Hatco part #02.30.043.00. For
220 volt applications, use Hatco part #02.30.058.00.
WARNING
Only light bulbs which meet or exceed N.S.F.
standards, specifically designed for food holding
areas must be used. Breakage of light bulbs not
specially coated could result in personal injury
and/or food contamination.
WARNING
If service is required on this unit, contact your
Authorized Hatco Service Agent, or contact
the Hatco Service Department at 800-558-0607
or 414-671-6350; fax 800-690-2966 or International
fax 414-671-3976.
WARNING
This product has no “user” serviceable parts.
To avoid damage to the unit or injury to personnel,
use only Authorized Hatco Service Agents
and Genuine Hatco Parts when service is required.
WARNING
Genuine Hatco Replacement Parts are specified
to operate safely in the environments in which
they are used. Some aftermarket or generic
replacement parts do not have the characteristics
that will allow them to operate safely in Hatco
equipment. It is essential to use Hatco Replacement
Parts when repairing Hatco equipment. Failure
to use Hatco Replacement Parts may subject
operators of the equipment to hazardous electrical
voltage, resulting in electrical shock or burn.
Page 9
7
Form No.
PFSTM-0602
HATCO LIMITED WARRANTY
1. PRODUCT WARRANTY
Hatco warrants the products that it manufactures
(the “Products”) to be free from defects in materials
and workmanship, under normal use and service,
for a period of one (1) year from the date of purchase
when installed and maintained in accordance with
Hatco’s written instructions or 18 months from
the date of shipment from Hatco. Buyer must
establish the product’s purchase date by returning
Hatco’s Warranty Registration Card or by other
means satisfactory to Hatco in its sole discretion.
Hatco warrants the following Product components
to be free from defects in materials and workmanship
from the date of purchase (subject to the foregoing
conditions) for the period(s) of time and on the
conditions listed below:
a) One (1) Year Parts and Labor PLUS One (1)
Additional Year Parts-Only Warranty:
Toaster Elements (metal sheathed)
Drawer Warmer Elements (metal sheathed)
Drawer Warmer Drawer Rollers and Slides
Food Warmer Elements (metal sheathed)
Infra-Black®Elements (metal sheathed)
Display Warmer Elements (metal sheathed air heating)
Holding Cabinet Elements (metal sheathed air heating)
Cook and Hold Oven Elements (metal sheathed)
b) One (1) Year Parts and Labor PLUS Four (4)
Additional Years Parts-Only Warranty on
pro-rated terms that Hatco will explain at
Buyer’s Request:
Powermite
®
Gas Booster Heater Tanks
Mini Compact Tanks (stainless steel)
3CS and FR Tanks
c) One (1) Year Parts and Labor PLUS Four (4)
Additional Years Parts-Only Warranty PLUS
Five (5) Year Parts-Only Warranty on
pro-rated terms that Hatco will explain at
Buyer’s Request:
Booster Heater Tanks (Castone
®
)
d) One (1) Year Parts-Only Warranty for
components not installed by Hatco:
Accessory Components (including but not
limited to valves, gauges and remote switches)
THE FOREGOING WARRANTIES ARE
EXCLUSIVE AND IN LIEU OF ANY OTHER
WARRANTY, EXPRESSED OR IMPLIED,
INCLUDING BUT NOT LIMITED TO ANY
IMPLIED WARRANTY OF MERCHANTABILITY
OR FITNESS FOR A PARTICULAR PURPOSE
OR PATENT OR OTHER INTELLECTUAL
PROPERTY RIGHT INFRINGEMENT. Without
limiting the generality of the foregoing, SUCH
WARRANTIES DO NOT COVER: Coated
incandescent light bulbs, fluorescent lamps, lamp
warmer heat bulbs, glass components or Product
failure in booster tank and fin tube heat exchanger
caused by liming, sediment buildup, chemical attack
or freezing in tanks, Product misuse, tampering or
misapplication, improper installation, application
of improper voltage, or recalibration of thermostats
or high limit switches.
2. LIMITATION OF REMEDIES
AND DAMAGES
Hatco’s liability and Buyer’s exclusive remedy
hereunder will be limited solely, at Hatco’s option,
to repair or replacement by a Hatco-authorized
service agency (other than where Buyer is located
outside of the United States or Canada, in which case
Hatco’s liability and Buyer’s exclusive remedy
hereunder will be limited solely to replacement
of part under warranty) with respect to any claim
made within the applicable warranty period referred
to above. Without limiting the generality
of the foregoing, all portable Products (as defined
in N.S.F. 4-4.28.4) shall be delivered by Buyer,
at its sole expense, to the nearest Hatco-authorized
service agency for replacement or repair. Hatco
reserves the right to accept or reject any such claim
in whole or in part. Hatco will not accept the return
of any Product without prior written approval from
Hatco, and all such approved returns shall be made
at Buyer’s sole expense. HATCO WILL NOT BE
LIABLE, UNDER ANY CIRCUMSTANCES,
FOR CONSEQUENTIAL OR INCIDENTAL
DAMAGES, INCLUDING BUT NOT LIMITED
TO LABOR COSTS OR LOST PROFITS
RESULTING FROM THE USE OF OR INABILITY
TO USE THE PRODUCTS OR FROM
THE PRODUCTS BEING INCORPORATED
IN OR BECOMING A COMPONENT OF ANY
OTHER PRODUCT OR GOODS.
Page 10
8
Form No. PFSTM-0602
NOTES
Page 11
9
Form No.
PFSTM-0602
NOTES
Page 12
HATCO CORPORATION
P.O. Box 340500, Milwaukee, WI 53234-0500 U.S.A.
(800) 558-0607 (414) 671-6350
Parts & Service Fax (800) 690-2966 Int’l. Fax (414) 671-3976
www.hatcocorp.com
HATCO AUTHORIZED PARTS DISTRIBUTORS
Part No. 07.04.303.00 Form No. PFSTM-0602
ALABAMA
Jones McLeod Appl. Svc.
Birmingham 205-251-0159
ARIZONA
Auth. Comm. Food Equip.
Phoenix 602-234-2443
Byassee Equipment Co.
Phoenix 602-252-0402
CALIFORNIA
Industrial Electric
Huntington Beach 714-379-7100
Chapman Appl. Service
San Diego 619-298-7106
P & D Appliance
S. San Francisco 650-635-1900
COLORADO
Hawkins Commercial Appliance
Englewood 303-781-5548
DELA
WARE
Food Equipment Service
Wilmington 302-996-9363
FLORIDA
Whaley Foodservice Repair
Jacksonville 904-725-7800
Nass Service Co., Inc.
Orlando 407-425-2681
B.G.S.I.
Pompano Beach 954-971-0456
Comm. Appliance Service
Tampa 813-663-0313
GEORGIA
Southeastern Rest. Svc.
Norcross 770-446-6177
HA
WAII
Burney’s Comm. Service, Inc.
Honolulu 808-848-1466
Food Equip Parts & Service
Honolulu 808-847-4871
ILLINOIS
Parts Town
Lombard 708-865-7278
Eichenauer Elec. Service
Decatur 217-429-4229
Midwest Elec. Appl. Service
Elmhurst 630-279-8000
Cone’s Repair Service
Moline 309-797-5323
INDIANA
GCS Service
Indianapolis 317-545-9655
IOW
A
Electric Motor Service Co.
Davenport 319-323-1823
KENTUCKY
GCS Service
Louisville 502-3671788
LOUISIANA
Chandlers Parts & Service
Baton Rouge 225-272-6620
Bana Comm. Parts, Inc.
Shreveport 318-631-6550
MAR
YLAND
Electric Motor Service
Baltimore 410-467-8080
GCS Service
Silver Spring 301-585-7550
MASSACHUSETTS
Ace Service Co., Inc.
Needham 781-449-4220
MICHIGAN
Commercial Kitchen Service
Bay City 517-893-4561
Bildons Appliance Service
Detroit 248-478-3320
Midwest Food Equip. Service
Grandville 616-261-2000
MINNESOT
A
GCS Service
Minneapolis 612-546-4221
MISSOURI
GCS Service
Kansas City 816-920-5999
Commercial Kitchen Services
St. Louis 314-890-0700
Kaemmerlen Parts & Service
St. Louis 314-535-2222
NEBRASKA
Anderson Electric
Omaha 402-341-1414
NEV
ADA
Burney’s Commercial
Las Vegas 702-736-0006
Hi. Tech Commercial Service
N. Las Vegas 702-649-4616
NEW JERSEY
Jay Hill Repair
Fairfield 973-575-9145
Service Plus
Flanders 973-691-6300
NEW
YORK
Acme American Repairs, Inc.
Brooklyn 718-456-6544
Alpro Service Co.
Brooklyn 718-386-2515
NEW
YORK (continued)
Appliance Installation
Buffalo 716-884-7425
Northern Parts Dist.
Plattsburgh 518-563-3200
J. B. Brady, Inc.
Syracuse 315-422-9271
NORTH CAROLINA
Authorized Appliance
Charlotte 704-377-4501
OHIO
Akron/Canton Comm. Svc. Inc.
Akron 330-753-6635
Certified Service Center
Cincinnati 513-772-6600
GCS Service
Columbus 614-476-3225
Electrical Appl. Repair Service
Independence 216-459-8700
E. A. Wichman Co.
Toledo 419-385-9121
OKLAHOMA
Hagar Rest. Service, Inc.
Oklahoma City 405-235-2184
Krueger, Inc.
Oklahoma City 405-528-8883
OREGON
Bressie Electric Co.
Portland 503-231-7171
Ron’s Service, Inc.
Portland 503-624-0890
PENNSYL
VANIA
Authorized Factory Service
Coraopolis 412-262-2330
FAST Comm. Appl. Service
Philadelphia 215-288-4800
GCS Service
Pittsburgh 412-787-1970
K & D Service Co.
Harrisburg 717-236-9039
Elmer Schultz Services
Philadelphia 215-627-5401
Electric Repair Co.
Reading 610-376-5444
RHODE ISLAND
Marshall Electric Co.
Providence 401-331-1163
SOUTH CAROLINA
Whaley Foodservice Repair
W. Columbia 803-791-4420
TENNESSEE
Camp Electric
Memphis 901-527-7543
TEXAS
Stove Parts Supply
Fort Worth 817-831-0381
Armstrong Repair Service
Houston 713-666-7100
Commercial Kitchen Repair Co.
San Antonio 210-735-2811
San Antonio Rest. Equip.
San Antonio 210-532-1660
UT
AH
GCS Service
Salt Lake City 801-487-3653
VIRGINIA
Daubers
Norfolk 757-855-4097
Daubers
Springfield 703-866-3600
W
ASHINGTON
Restaurant Appl. Service
Seattle 206-524-8200
WISCONSIN
A.S.C., Inc.
Madison 608-246-3160
A.S.C., Inc.
Milwaukee 414-543-6460
CANADA
BRITISH COLUMBIA
Key Food Equipment Service
Vancouver 604-433-4484
ONT
ARIO
R.G. Henderson Ltd.
Toronto 416-422-5580
Choquette CKS
Ottawa 613-739-8458
QUÉBEC
Choquette CKS
Montreal 514-722-2000
Choquette CKS
Québec City 418-681-3944
Printed in U.S.A. June 2002
Loading...