Harbor Freight Tools 05770 Product manual

IMPORTANT SAFETY INFORMATION

Service Cart Safety Warnings

1. Do not ride or climb on cart. Keep away from children.

2. Do not exceed 450 lb. capacity, evenly distributed.
Be aware of dynamic loading!
Sudden load movement may briefly create
excess load causing product failure.

3. Use only on a flat, level surface able
to support Cart and load.

4. Wear ANSI-approved safety
goggles during assembly.

5. Inspect before every use; do not use
if parts are loose or damaged.

6. Maintain product labels and nameplates.
These carry important safety information. If
unreadable or missing, contact Harbor
Freight Tools for a replacement.

SAVE THESE INSTRUCTIONS.

Assembly Instructions

Read the ENTIRE IMPORTANT SAFETY INFORMATION section at the beginning of this

manual including all text under subheadings therein before set up or use of this product.

Note: For additional information regarding the parts listed in the following pages, refer to the Assembly Diagram

near the end of this manual. 10mm, 14mm and 17mm sockets and/or wrenches are required for assembly.

Unwrap and separate all parts on a clear work area.

Attaching Posts to Bottom Tray

Lay the Bottom Tray (2) (the tray with four sets
of four holes on the bottom) on the floor and
attach the Posts (7) to the outside corners
of the tray using sixteen Bolts (8), Washers
(9), Lock Washers (10), and Nuts (11).

Bolt (8)

Bottom Tray

(2)

Figure 1

Post (7)

Washer (9)

Nut (11)

Lock Washer

(10)

Page 2 For technical questions, please call 1-800-444-3353. Item 05770

Attaching Top Tray

Attach Top Tray (1) to the other end of the
legs using twelve Bolts (12), Washers (9),
Lock Washers (10), and Nuts (11). (Four holes
on one end of the top tray are reserved for
attaching the Handle in the next step.)

Top Tray (1)

Figure 2

Bolt (12)

Washer (9)

Post (7)

Lock Washer (10)

Nut (11)

Attaching Handle

Assemble the Handle Brackets (6) onto ends
of Handle (4) and attach Handle to end of
Posts (7) using the Bolts (12), Washers (9),
Lock Washers (10), and Nuts (11).

Figure 3

Note: For ease of assembly,

set the Cart on its side and
work on two legs at a time.

Bolt (12)Washer (9)

Post (7)

Lock Washer (10)

Nut (11)

Handle Bracket (6)

Page 3For technical questions, please call 1-800-444-3353.Item 05770