Gravely 890015 User Manual
Promaster 310 Grass Catcher
Owner/Operator & Parts Manual
Model
890015*
*NOTE: Installation requires a separate mower boot kit,
p/n 04916000 for 60" decks, p/n 04916100 for 50" decks.
Supercedes 08493200
08493200A 12/03
Printed in USA
TABLE OF CONTENTS
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
INTRODUCTION
THE MANUAL
Before operation of unit, carefully and completely read
your manuals. The contents will provide you with an
understanding of safety instructions and controls
during normal operation and maintenance.
All reference to left, right, front, or rear are given from
operator sitting in operation position and facing the
direction of forward travel.
MODEL AND SERIAL NUMBERS
When ordering replacement parts
Transfer
model & serial
number label
from product
registration
here.
• Record Unit Model and Serial numbers here.
or making service inquiries, know
the Model and Serial numbers of
your unit.
Numbers are located on the product
registration form in the unit literature
package. They are printed on a
serial number label, located on the
frame of your unit.
Storage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
DISCLAIMER
Ariens reserves the right to discontinue, make changes
to, and add improvements upon its products at any time
without public notice or obligation. The descriptions
and specifications contained in this manual were in
effect at printing. Equipment described within this
manual may be optional. Some illustrations may not be
applicable to your unit.
DELIVERY
Customer Note: If you have purchased this product
without complete assembly and instruction by your
retailer, it is your responsibility to:
1. Read and understand all assembly instructions in
this manual. If you do not understand or have
difficulty following the instructions, contact your
nearest Gravely Dealer for assistance.
all assembly has been properly completed and
safety interlock system works properly.
NOTE: To locate your nearest Gravely Dealer, call
800-472-8359 or go to www.gravely.com on the
internet.
Make sure
UNAUTHORIZED REPLACEMENT PARTS
Use only Gravely replacement parts. The replacement
of any part on this vehicle with anything other than an
Gravely authorized replacement part may adversely
affect the performance, durability, or safety of this unit
and may void the warranty. Gravely disclaims liability
for any claims or damages, whether warranty, property
damage, personal injury or death arising out of the use
of unauthorized replacement parts.
PRODUCT REGISTRATION
The Gravely dealer must register the product at the
time of purchase. Registering the product will help the
company process warranty claims or contact you with
the latest service information. All claims meeting
requirements during the limited warranty period will be
honored, whether or not the product registration card is
returned. Keep a proof of purchase if you do not
register your unit.
Customer Note: If Dealer does not register your
product, please fill out, sign and return the product
registration card to Gravely.
WARNING: Improper assembly or
adjustments can cause serious injury.
2. Understand all Safety Precautions provided in the
manuals.
3. Review control functions and operation of the
unit. Do not operate unit unless all controls
function as described in this manual.
4. Review recommended lubrication, maintenance
and adjustments.
5. Fill out Original Purchaser Registration Card and
return the card to Gravely Company.
GB - 2
© Copyright 2001, 2003 Ariens Company
SAFETY
SAFETY ALERTS
Look for these symbols to point out
important safety precautions. They mean:
Attention!
Personal Safety Is Involved!
Become Alert!
Obey The Message!
The safety alert symbols above and signal words below
are used on decals and in this manual.
Read and understand all safety messages.
DANGER: IMMINENTLY HAZARDOUS
SITUATION! If not avoided, WILL RESULT in
death or serious injury.
WARNING: POTENTIALLY HAZARDOUS
SITUATION! If not avoided, COULD RESULT
in death or serious injury.
CAUTION: POTENTIALLY HAZARDOUS
SITUATION! If not avoided, MAY RESULT in
minor or moderate injury. It may also be used
to alert against unsafe practices.
NOTATIONS
NOTE: General reference information for proper
operation and maintenance practices.
IMPORTANT: Specific procedures or information
required to prevent damage to unit or attachment.
PRACTICES AND LAWS
Practice usual and customary safe working
precautions, for the benefit of yourself and others.
Understand and follow all safety messages. Be alert to
unsafe conditions and the possibility of minor,
moderate, or serious injury or death. Learn applicable
rules and laws in your area. Always follow the practices
set forth in this manual.
REQUIRED OPERATOR TRAINING
Original purchaser of this unit was instructed by the
seller on safe and proper operation by the seller. If unit
is to be used by someone other than original
purchaser; loaned, rented or sold, ALWAYS provide
this manual and any needed safety training before
operation.
SAFETY DECALS AND LOCATIONS
ALWAYS replace missing or damaged Safety Decals.
Refer to Parts List for Safety Decal locations.
Danger! -
Caution - Grass Catcher
Boot Danger - Rotating Blades
Boot Caution - Rotating Blades
To Avoid Serious Injury
ROTATING FAN! Stop grass pump and
power unit engines before removing any
part of bagger. Wait for all moving parts to
stop.
OL0900
DO NOT operate mower unless guards
are in place or grass pump and entire
bagger are attached.
OL0910
Stop engines and wait for all moving parts
to stop before opening cover.
Keep children and others away from unit
while operating.
OL4140
ALWAYS wear adequate hearing
protection.
OL4690
Avoid tip over and loss of control:
DO NOT overload bagger.
Use extreme caution on slopes.
DO NOT make abrupt turns or speed
changes.
Be aware of new turning radius.
Stop engine or motor before attaching or
removing grass catcher. Under normal
use the catcher bag material is subject to
wear and deterioration and should be
checked to insure compliance with
original manufacturer specifications.
Keep feet and hands clear.
OL5000
GB - 3
Stop engine before removing or cleaning
this chute. Keep hands and feet clear!
Rotating blades!
Warning - Engine
DO NOT operate in poorly ventilated area.
DO NOT refuel while engine is running.
Make sure no flame/spark around during
refuel.
DO NOT touch exhaust system and
engine while hot.
DO NOT touch spark plug cap or high
tension cord during engine running.
*SEE YOUR OPERATOR’S MANUAL.
ASSEMBLY SAFETY RULES
Read, understand, and follow all safety practices in
Owner/Operator Manual before beginning assembly.
Failure to follow instructions could result in personal
injury and/or damage to unit.
ALWAYS remove key and wire from spark plugs on unit
before assembly. Unintentional engine start up can
cause death or serious injury.
Sharp edges can cut. Movement of parts can cut off
fingers or a hand. Wrap blade(s), wear sturdy gloves
and use extreme caution when working near blades.
Installing the grass catcher on your mower
requires the removal of the discharge chute
deflector. Retain discharge chute and
hardware in a safe location and reinstall
whenever operating unit without the grass
pump. DO NOT operate mower unless guards
are in place or grass pump and entire bagger
are attached.
OPERATIONAL SAFETY RULES
Walk Around Inspection
Complete a walk around inspection of unit and work
area to understand:
• Work area • Your unit • All safety decals
Work Area
ALWAYS check overhead and side clearances carefully
before operation. ALWAYS be aware of traffic when
operating along streets or curbs.
Keep children and people away. Keep children out of
work area and under watchful care of a responsible
adult.
NEVER allow children to operate or play on or near
unit. Be alert and shut off unit if children enter area.
Keep area of operation clear of all toys, pets, and
debris. Thrown objects can cause injury.
Check for weak spots on docks, ramps or floors. Avoid
uneven work areas and rough terrain. Stay alert for
hidden hazards.
Avoid uneven and rough terrain. DO NOT operate near
drop offs, ditches, or embankments. Unit can suddenly
turn over if a wheel is over the edge of a cliff or ditch, or
if an edge caves in.
Dust, fog, etc. can reduce vision and cause an
accident. Operate unit only when there is good visibility
and light.
Personal Safety
Only trained adults may operate unit.
Training includes actual operation.
NEVER operate unit after or during the use of
medication, drugs or alcohol. Safe operation requires
your complete and unimpaired attention at all times.
NEVER allow anyone to operate this unit when their
alertness or coordination is impaired.
Wear adequate safety gear and protective gloves.
Wear proper footwear to improve footing on slippery
surfaces.
DO NOT wear loose clothing or jewelry and tie back
hair that may get caught in rotating parts.
Protect eyes, face and head from objects that may be
thrown from unit. Wear appropriate hearing protection.
Avoid sharp edges. Sharp edges can cut. Moving parts
can cut off fingers or a hand.
ALWAYS keep hands and feet away from all rotating
parts during operation. Rotating parts can cut off body
parts.
NEVER place your hands or any part of your body or
clothing inside or near any moving part while unit is
running.
ALWAYS disengage attachment, stop unit and engine,
remove key and allow moving parts to stop before
leaving operator’s position.
Operation
Understand:
• How to operate all controls
• The functions of all controls
• How to STOP in an Emergency
• Braking and steering characteristics
• Turning radius and clearances
NEVER operate bagger if the tractor’s safety interlock
system is not working properly.
Always be aware of maximum sweep of catcher when
turning. Always allow adequate clearance between
catcher, personnel and other objects when turning.
As grass catcher fills, be alert to changing unit stability
and control.
Disengage PTO when attachment is not in use.
ALWAYS disengage PTO, stop unit and engine,
remove key, engage parking brake and allow moving
parts to stop before leaving operator’s position.
DO NOT operate at too fast a rate. DO NOT change
engine governor settings or over-speed engine. Slow
down before turning.
DO NOT mow near dropoffs, ditches or embankments.
The mower could suddenly turn over if a wheel is over
the edge of a cliff or ditch, or if an edge caves in.
DO NOT mow on wet grass. Reduced traction could
cause sliding.
GB - 4
DO NOT try to stabilize the machine by putting your
foot on the ground.
Know the weight of loads. Limit loads to those you can
safely control and the unit can safely handle.
ALWAYS keep protective structures, guards and panels
in good repair, in place and securely fastened.
DO NOT operate in reverse unless absolutely
necessary. ALWAYS look down and behind before and
while backing.
Watch for holes, ruts, or bumps. Uneven terrain could
overturn the machine.
ALWAYS allow adequate clearance for unit,
attachments, operator and objects in work area when
turning. Slow down before turning.
NEVER carry passengers.
Hazardous Slopes
If you cannot back up a slope or you feel uneasy on it,
do not mow it.
Mow up and down slopes, not across them.
Keep all movements on the slope slow and gradual.
DO NOT make sudden changes in speed or direction.
Avoid starting or stopping on a slope. If tires lose
traction, disengage the blades and proceed slowly
straight down the slope.
DO NOT operate on slopes over 10˚.
DO NOT park on slopes unless absolutely necessary. If
you must park on a slope, always chock or block
wheels. Always set parking brake.
Transport
Use extra care when loading or unloading unit onto
trailer or truck.
Secure unit chassis to transport vehicle. NEVER
secure from rods or linkages that could be damaged.
DO NOT transport machine while engine is running.
ALWAYS turn off power to attachment when
transporting.
Keep all hardware properly tightened.
Cleaning
Keep unit free of debris. Clean up oil or fuel spills.
STORAGE SAFETY RULES
DO NOT store grass can with grass in them.
For extended storage, clean unit thoroughly. See
Engine Manual for proper storage.
ALWAYS lower cutting deck when unit is parked or
stored.
FUEL SAFETY RULES
Fuel is highly flammable and its vapors are explosive.
Handle with care. Use an approved fuel container.
NO smoking, NO sparks, NO flames. ALWAYS allow
engine to cool before servicing.
NEVER fill fuel tank when engine is running or hot from
operation.
NEVER fill or drain fuel tank indoors.
Replace fuel cap securely and clean up spilled fuel.
ACCESSORY AND ATTACHMENT SAFETY
RULES
Use only attachments or accessories designed for your
unit and properly installed.
Check attachment components frequently. If worn or
damaged, replace with manufacturer’s recommended
parts.
Grass catcher components are subject to wear,
damage, and deterioration, which could expose moving
parts or allow objects to be thrown. Frequently check
components and replace with manufacturer’s
recommended parts, when necessary.
MAINTENANCE AND SERVICE SAFETY
RULES
Disengage PTO, stop engine, remove key and wait for
all moving parts to stop before servicing, making
repairs, adjusting or when clearing debris.
ALWAYS block wheels. Know all jack stands are
strong, secure and will hold weight of unit during
maintenance.
ALWAYS keep protective structures, guards, and
panels in good repair, in place and securely fastened.
NEVER modify or remove safety devices.
Fumes from engine exhaust can cause injury or death.
DO NOT run engine in an enclosed area. Always
provide good ventilation.
Keep unit free of grass, leaves, or other debris. Clean
up oil or fuel spills.
Check grass can and catcher parts prior to each use
for any holes, abrasions, mildew, or structural damage.
Replace parts when necessary.
GB - 5
Loading...