GRASS VALLEY TRITON TTN-BAV-0808 Installation Manual

MANUAL PART NO. 071

-

8242

-

00 R

ev. 0

MARCH 18, 2003

INSTALLATION MANUAL

TRITON routing switcher

Multimedia Router 8x8

Product model no. TTN-BAV-0808

the most watched worldwide

ii

Headquarters

Thomson Broadcast Systems
17 rue du Petit Albi - BP 8244
95801 Cergy Pontoise Cedex
FRANCE

Thomson Broadcast and
Media Solutions, Inc.
P.O. Box 599000
Nevada City, CA 95959-7900
USA

Copyr

ight 2003 Thomson Broadcast and Media Solutions, Inc. All rights reserved. Grass Valley, Jupiter, and

Triton are trademarks of Thomson. Specifications subject to change without notice.
For customer service, please call [phone]. For comments or questions concerning this manual, please

contact: Technical Publications Department, P.O. Box 30816, Salt Lake City, Utah 84130 USA. Phone: (801)
972-8000. Fax: [phone]. Email: [e-mail]

iii

Contents

Electromagnetic Radiation Notice v
Hardware Warranty and Software License vi
Parts and Service vi
Revision history vii
1 General 1

1.1 Specifications 1

1.1.1 Video Specifications 1

1.1.2 (Optional) Audio Specifications 2

1.1.3 Panel Specifications 2

1.1.4 General Specifications 2

1.2 Connection drawing 2

2 Power connection 3
3 Connecting the BAV-0808 to your PC 3

3.1 Selection of router level 3

3.2 Pin-out of RS-232 connector 3

3.3 Maximum cable length 3

4 NCB connection 4

4.1 Several routers in one system 4

4.2 Connecting control panels 4

4.3 Pin-out and cable type 5

4.3.1 RJ45 connectors 5

4.3.2 5-pin DIN connectors 5

4.3.3 RJ45 to 5-pin DIN converter 6

4.4 Control bus structure 6

4.5 Maximum distance between NCB devices 6

4.6 Control Bus configuration notes 6

5 Router configuration 8

5.1 Router level 8

5.2 Video Switch-timing mode 8

5.3 Disconnect Allowed 9

5.4 Power up mode 9

5.5 Programming of restrictions 10

6 Connecting signal cables to the BAV-0808 11

6.1 Connecting Video Signals 11

6.2 Connecting Audio Signals 11

6.2.1 Unbalanced audio signals on BAV-0808 outputs 11

iv

7 Control panel operation 12

7.1 Front panel drawing 12

7.2 PANEL ENABLE button 12

7.3 V/A TOGGLE button 12

7.4 Operating crosspoints 12

7.5 TAKE function 13

8 Programming of SALVOS (Pre-sets) 13
9 Control and connection of Triton systems, interface protocol 16

9.1 Important notes regarding the Triton Control Protocol 16

9.1.1 Binary Code 16

9.1.2 Echo 16

9.1.3 RS-422 Matrixes 16

9.1.4 Timeout 16

9.2 Basic principles 16

9.2.1 Example: A single unit with no NCB connected 16

9.2.2 Example: Several units connected by NCB 17

9.3 RS232 17

9.4 NCB 17

9.5 Commands 18

9.5.1 Audio crosspoint set 18

9.5.2 Audio crosspoint set acknowledge 18

9.5.3 Video crosspoint set 18

9.5.4 Video crosspoint set acknowledge 19

9.5.5 Crosspoint status request 19

v

Electromagnetic Radiation Notice

The following information is given to note compliance with the United States Government Federal Communications
Commission (FCC) Rules (47 CFR Part 15) designed to limit interference to radio and TV reception. The ruling establishes
measurement procedures and frequency criteria for Class A computing devices (commercial and industrial applications) with
the following conduction and radiation limits:

CLASS A COMPUTING DEVICE: CONDUCTION LIMIT (Part 15.812)

Frequency (MHz) Maximum RF Line Voltage (uV)

0.45 - 1.6 1000

1.6 - 30 3000

CLASS A COMPUTING DEVICE: RADIATION LIMIT (Section 15.810)

Frequency (MHz) Distance (meters) Field Strength (uV/m)

30 - 88 30 30
88 - 216 30 50
216 - 1000 30 70

The policy of Thomson is one of continual development and improvement. For that reason Thomson uses components and
manufacturing techniques that provide the current state-of-the-art suppression of electromagnetic radiation. This equipment, in
production before October 1, 1981, has not been tested to the above listed measurements. However, equipment such as this
delivered after October 1, 1983 will have the measurements on record at the factory. Therefore, in compliance with the stated
FCC Regulation, the following information is provided for the user:

NOTE

Interference to Radio Communications

This equipment generates, uses, and can radiate radio frequency energy and if not installed and used
in accordance with the instruction manual, may cause interference to radio communications. As
temporarily permitted by regulation it has not been tested for compliance with the limits for Class A
computing devices pursuant to Subpart J of of Part 15 of FCC Rules, which are designed to provide
reasonable protection against such interference. Operation of this equipment in a residential area
is likely to cause interference in which case the user at his own expense will be required to take
whatever measures may be required to correct the interference.

vi

Hardware Warranty and Software License

Please contact your local Thomson representative for

hardware warranty and software license information.

Parts and Service

Thomson maintains a full stock of replacement parts available for immediate shipment.

NORTH AMERICA PARTS AND SERVICE

Please call toll-free 1-800-547-8949.

You will be switched automatically to the parts and service representative nearest you.

For email correspondence: [e-mail]

Internet: http://www.thomsongrassvalley.com

INTERNATIONAL PARTS AND SERVICE

Contact your Thomson representative.

vii

Revision history

Current revision of this document is the uppermost in the table below.

Revision Replaces Date Change Description

0 - 18/03/03 Initial Revision

BAV-0808 Rev. 0

1

1 General

The Media-8 is an RGBHV Analogue Video + Stereo Analogue Audio (optional) 8x8 Router for
Multimedia applications. The Video Router has seamless tri-step switching, or vertical interval switching,
and a large signal bandwidth, which provides high performance up to 1600x1200 resolution. The Audio
Router has balanced inputs and outputs, and audio breakaway allows selecting audio independent from
video. A preset editor allows the user multi-crosspoint settings in one operation, and multi panel interface
allows control of the router from up to 20 different sites.
This top of the line Router provides high performance circuits in SMD technology, with no discernible
signal degradation. The built-in RS-232 interface allows the user to control the router via the Triton
Router Control System PC software with many operational features. The control bus allows linking of the
unit to other Triton Routers and Control Panels, all designed to suit the needs of the user.
The following formats may be configured (stereo audio is optional):

8x8 RGBHV + AA

1.1 Specifications

1.1.1 Video Specifications

Frequency response: 0-250MHz / -3dB; 0-400MHz / -6dB
Differential gain: typical 0.1% (3.58/4.43MHz)
Differential phase: typical 0.2° (3.58/4.43MHz)
Crosstalk: < -55dB (3.58/4.43MHz)
Video S/N Ratio: typical 70dB
Bar tilt: < 0.1%
Lum. Non-linearity: < 0.1%
Number of inputs: 8
Number of outputs: 8
Impedance: 75 ohms
Return loss: typical 38dB
Max signal: 2 Vp-p
Coupling: DC
DC offset: typ. 5mV
Propagation delay: 5ns ± 1ns
Connector: BNC
Switching: Seamless w/ variable delay 2-5s, or VIT,
Selectable via DIP-switches
PAL/NTSC selection on DIP-switches
VIT loop