GE ZDP30L4H1SS, ZDP30L4H2SS, ZDP30L4H3SS, ZDP30L4H4SS, ZDP30L4H5SS Installation Guide

...
Page 1
Installation Instructions
ProfessionalRanges
48"Natural Gas Models ZDP48N4G ZDP48N6R ZDP48N6D
48"LPGasModels ZDP48L4G
36"Natural Gas Models ZDP36N6
ZDP36N4R ZDP36N4D
36"LPGas Models ZDP36L6 ZDP36L4R
ZDP30N4 30"LPGasModel
ZDP30L4
Monogram._
Page 2
Installation Instructions
BEFORE YOU BEGIN
Read these instructions completely and carefully.
IMPORTANT- savethese instructions for
local inspector's use,
IMPORTANT - Observe all governing codes and ordinances.
Note to Installer- Be sure to leave these instructions with the Consumer.
Note to Consumer - Keep these instructions for
future reference.
Skill Level- Installation of this range requires basic mechanical and electrical skills.
Completion time - 1to 3 hours,
Proper installation is the responsibility of the installer,
Product failure due to improper installation is not covered under the Warranty,
WARNING:
This appliance must be properly grounded. See "Electric Supply", page 7.
AVERTISSEMENT :
Cet appareil doit _tre mis _ la terre ad_quatement. Voir la section, Alimentation _lectrique _ _ la page 7.
For Monogram local service in your area,
1.800.444.1845.
For Monogram Service in Canada, call
1.888.880.3030.
For Monogram Parts and Accessories, call
1.800.626.2002. If you received a damaged range, you should contact
your dealer.
In the Commonwealth of Massachusetts:
This product must be installed by a licensed plumber
or gas fitter.
When using ball type gas shut off valves, they shall
be T-handle type.
A flexible gas connector, when used, must not
exceed 3feet.
CAUTION:
THESE RANGES SHOULD BE INSTALLED
IN CONJUNCTION WITH A SUITABLE
OVERHEADVENT HOOD. Due to the high heat capacity of this unit, particular attention should be paid to the
hood and duct work installation to assure it meets local building codes.
MISE EN GARDE :
CES CUISINII_RES DOIVENT ETRE MONTI_ES CONJOINTEMENT AVEC UNE
HOTTE_, I_VACUATION DE PLAFOND APPROPRICE
I_tant donn_ la grande capacit_ thermique de cet appareil, une attention particuli_re doit _tre port_e
au montage de la hotte et du syst_me de gaines pour s'assurer qu'il est conforme aux codes du b_timent
Iocaux. Standard countertop and island installations:
A 1200 CFM hood is recommended for 48" ranges. A 600 CFM hood is recommended for 30" and 36" Ranges.
Hoods should be 24" min. deep and the same width as
the cooktop.
Check local building codes for the proper method of gas range installation. Local codes vary. Installation,
electrical connections and grounding must comply with applicable codes. In the absence of local codes, the gas range should be installed in accordance with
the National Fuel Gas Code ANSI 223.1,latest
edition and National Electrical Code ANSl/NFPA 70,
latest edition.
CAUTION:
These ranges weigh up to 600pounds.
Some disassembly will reduce the weight considerably. Due to the weight and size of the range and to reduce the risk of personal injury or damage
to the product, TWO PEOPLEARE REQUIREDFOR
PROPERINSTALLATION.
MISE EN GARDE :
Ces cuisini_res p_sent jusqu'_
272 kg (600 Ib).Tout d_montage r_duira
consid_rablement leur poids. En raison du poids et de la taille de la cuisini_re, dont la manipulation risque
d'entrainer des I_sions corporelles ou des dommages au produit, DEUX PERSONNES SONT NEOESSAIRES
POUR PROCEDERA UN MONTAGE ADI_QUAT.
2
Page 3
Design Information
CONTENTS
Design Information
Models Available ..............................................................3
Accessory Requirements ................................................3
Product Dimensions and Clearances ........................4, 5
Advance Planning ............................................................6
Tools and Materials Required ......................................6
Installation Preparation
Power Supply Locations ..................................................7
MODELS AVAILABLE
These ranges are factory set for either natural gas or liquid propane gas. Order the model for your
installation situation. 48" Natural Gas Models:
ZDP48N4G -4 gas burners, grill and griddle ZDP48N6R-6 gas burners and grill ZDP48N6D -6 gas burners and griddle
48" Liquid Propane Gas Models:
ZDP48L4G - 4 gas burners, grill and griddle ZDP48L6R- 6 gas burners and grill ZDP48L6D - 6 gas burners and griddle
Installation Instructions
Step 1, Remove Packaging ..............................................8
Step 2, Level the Range ....................................................9
Step 3, Install Anti-Tip Device ..................................9, 10
Step 4, Connect Range to Gas ......................................11
Step 5, Connect Electrical ..............................................12
Step 6, Slide Range into Position ................................12
Step 7, Replace Oven Doors ..........................................12
Step 8, Assemble and Adjust Burners ........................13
Finalize Installation ..........................................................13
Installation Checklist ......................................................14
Install Backsplash Accessory ......................................15
36" Natural Gas Models:
ZDP36N6 - 6 gas burners ZDP36N4R - 4 gas burners and grill ZDP36N4D - 4 gas burners and griddle
36" Liquid Propane Gas Models:
ZDP36L6 - 6 gas burners ZDP36L4R- 4 gas burners and grill ZDP36L4D - 4 gas burners and griddle
30" Natural Gas Model:
ZDP30N4
30" Liquid Propane Gas Model:
ZDP30L4
BACKSPLASH ACCESSORIES
All models require 12" rain. clearance to a vertical combustible surface atthe rear. A backsplash accessory is available for installations with less
than 12" clearance to the back wall. Order a 12"high
backsplash or 22"high backsplash with warming shelf. Backsplash for 48" Models:
ZX12B48HSS - 12" high backsplash ZX22B48HSS - 22" high backsplash with warming shelf
(2 piece)
Backsplash for 36" Models: ZX12B36HSS - 12" high backsplash
ZX22B36HSS - 22" high backsplash with warming shelf
(2 piece)
INSTALLATION NOTE: A custom backspash may be constructed of non-combustible back wall materials such as ceramic tile, brick, marble
or other stone.
Backsplash for 30" Models:
ZX9B30HSS - 9" high backsplash ZX22B30HSS - 22" high backsplash with warming shelf
(2 piece)
HighBacksplashWith
helf
12"HighBacksplash
(9" Highfor30" Models)
3
Page 4
Design Information
PRODUCT DIMENSIONS AND CLEARANCES
48"Wide RangeModels 36"Wide RangeModels
_:::::::::::::±_:::::::::::::::::_:_:_:::_:_ 22 _
35-1/4"-36-3/4"
<
N
48"and 36"RangeModels
9 1/2"_ 29-1/16''_
-3/4"_ ",_
22" Backsplash
_12" HighBacksplash
J
[_ 31-1/2"_
22"High
with Shelf
45-5/8"
36" Min.
to Combustibles
28-1/4'_ _35-7/8"
12"Min. to Combustiblesor l/'
0" Min. to Combustibles with 12"or22" Backsplash
._Backguard
0" Clearance
' r'7 r" "3
NOTE: 12"Min. to Combustibles or 0"Min to Combustibles with any
backsplash accessory or custom non-combustible back wall.
/
36" Min.
to
Combustibles
4
Page 5
Design Information
PRODUCT DIMENSIONS AND CLEARANCES
30"Wide RangeModels
NOTE: Refer
to Vent Hood
Installation Instructions
for hood height
above the range.
22"
9-1/2"
3/4"_
27-3/8"_
_--22" High
Backsplash with Shelf
Backsplash
[_29-1/4"_ I_ 43-7/8"
36" Min.
to Combustibles
-?I
o
t
1-1/2" ElectricalSupply
GasSupply
[ ..................
"_ 35-3/8"Max.for CounterLevel
36-3/4"Max.with RangeLevelingLegsFullyExtended
5
o
O
Page 6
Design Information
ADVANCE PLANNING
Refer to "Dimensions and Clearances" for appropriate placement and necessary clearances when planning
the installation.
Cabinetry can not be installed directly above the range.
We recommend the installation of a vent hood above
the surface.
- The vent hood must be at least 24" deep.
- The vent hood must be at least the same width as the range.
- For 48"models, we recommend the vent hood blower be 1200 CFM.
- For 30"and 36" models, we recommend the vent hood blower be 600 CFM.
Working areas adjacentto the range should have 18"minimum clearance between countertop and
cabinet bottom.
Clearance between range and side wall or
combustible material must be at least 12"on each side.
Allow 12"min. clearance atthe backto combustible
materials.
TOOLS REQUIRED
Saw
Measuring tape
Carpenter's square
Pipe wrench
Large flat-blade screwdriver
Safety glasses
Drill and appropriate bits
MATERIALS REQUIRED
(not supplied)
Pipe and fittings as required
Manual gas line shut-off valve
Gas pressure regulator (supplied)
Gas-resistant pipe joint sealant
5 foot, 5/8"AGA-certified flexible metal gas supply line
- If required by local codes, use solid pipe fittings.
NOTE: Purchase new flexible line. DO NOT USE OLD,
PREVl0USLY USED FLEXIBLE LINE.
Allow 36" min. above the cooking surface to
combustible materials.
Installation must conform with local codes. In the
absence of local codes, the range must comply with
the National Fuel Gas Code, ANSI Z223.1/NFPA.54,
latest edition. In Canada, installation must conform
with the current Natural Gas Installation Code,
CAN/CGA-B149.1 or the current Propane Installation Code, CAN/CGA-B149.2, and with local codes where applicable. This range has been design-certified by CSA International according to ANSI Z21.1, latest edition and Canadian Gas Association according
to CAN/CGA-I.1 latest edition.
6
Page 7
Installation Preparation
POWER SUPPLY LOCATIONS
Gas Supply:
The natural gas models are designed to operate at 5"
water column pressure. A regulator is required at the
natural gas source to provide a maximum of 7" water pressure to the cooktop regulator,
The liquid propane models are designed to operate at 10"water column pressure. A regulator is required at
the LP source to provide a maximum of 14" water
pressure to the cooktop regulator,
These gas ranges are supplied with 1/2" NPT female
gas connection located atthe left rear corner.
A minimum 5/8" din, metal flexible line is required,
Locate pipe stub on the back wall as illustrated.
- Use 5-foot, 5/8" long flexible gas supply line.
Install a manual shut-off valve in the gas line, in an
easily accessible location.
4" for 30"/36" Models
8" Models
2" FlexLine
2" Maximum Protrusion From
Wall ForGas Supply
iGas Supply
toRange
8" for 30" Models 4" for 30"/36"
12" for 36" Models Models 16" for 48" Models 8" for 48"
"_ Models
i'"-Electrica, | /I
i Supply /
If the electrical service provided does not meet the above specifications, it is recommended that a licensed electrician install an approved outlet,
Locate the electric supply as illustrated.
WARNING: The range isequipped for use with an electrical supply
which uses a separate grounding conductor (4 wire system).
If this range must be connected to an electrical system which utilizes a single conductor for ground and neutral (3 wire system), the grounding jumper at
the terminal block must be connected. The grounding
jumper is located behind the front kick panel.
AVERTISSEMENT :
I_tant donn_ sa conception, la cuisini@e
exige que I'alimentation _lectrique soit dot_e d'un conducteur de terre distinct (syst_me 4 fils).
Si cette cuisini_re dolt _tre connect_e _ un syst_me _lectrique qui utilise un conducteur simple pour la mise _ la terre et le conducteur neutre (syst_me 3 fils), ilfaut alors connecter le cavalier de terre sur la plaque _ bornes. Le cavalier de terre est situ_ derri@e le panneau de protection frontal.
Receptacle
Electric Supply:
These ranges must be supplied with 208/240 volt, 60 Hz., and connected to an individual, properly grounded branch circuit protected by a circuit breaker or time delay fuse (50 amp for 48" ranges, 30 amp for 36" ranges and 25 amps for 30" ranges). The receptacle must be a NEMA 14-50R device to accept the 4-prong plug supplied with the range,
jWhite /Black
Co
TerminalBlock
To connect grounding jumper:
Disconnect restraining clip holding jumper.
Connect green jumper to open terminal on neutral (white) portion of the terminal block,
Page 8
Installation
STEP 1 REMOVE PACKAGING
Before moving the range indoors:
Remove outer carton and packing material from the shipping base,
KickPanel
Remove the kick panel by removing 2 screws atthe top and pulling forward.
LeftRearShipping
Screws
Slot
PulIthe hinge locks
down to unlock.
Remove oven doors:
Fully open the door.
Each hinge has a hinge lock, Close the hinge latch down against the door frame.
Firmly grasp the door at the top sides.
Close the door to the near-vertical position.
Lift the door up and pull straight out.
RangeMust beUniformly Supported
onBraces
The range is secured to the skid with 2 bolts in the front and 2 "L" brackets on the bottom flange of the range
back. Remove bolts and "L" brackets.
To simplify handling and to reduce the weight of the range:
Remove the grates and the drawers belowthe knobs (on grille and griddle models),
Remove grill and griddle covers. DO NOT ATTEMPT TO REMOVE A GRILL OR GRIDDLE ASSEMBLY.
Remove the broiler pans/literature package from inside oven(s).
LevelingLeg
Due to the weight of these ranges, use a dolly with soft wheels to move this range.
Lift the range onto the dolly and move indoors.
Remove the panel from the rear of the shipping pack. Lay the panel on the floor directly in front of the installation location. The range should be placed on this panel to prevent damage to the floor.
Remove the two strips from the oven interior. Place the strips on the floor at the left and right sides of the installation location, These strips provide a surface for sliding the range into the final position and will prevent damage to the floor. The leveling legs must rest permanently on these runner strips,
Range
Opening 1 _
_rs _C_\ I o
ToSupport _,_\\ II I
LevelingLe
8
Page 9
STEP 2 LEVEL THE RANGE
Installation
NOTE: Rear range leveling legs are not accessible after installation.
Check to be sure the adjoining cabinets/countertops are level, front to back and left to right across the opening of the range.
Measure the distance from the floor to the top of the countertop in the left and right rear corners.
STEP 3 INSTALL ANTI-TIP DEVICE
All Ranges Can Tip
WARNING:
Injury Could Result
Install Anti-Tip Bracket
Provided
See Instructions
Adjust the height of the range to countertop height or higher.
IMPORTANT: The range should always be installed at countertop height or higher. DO NOT INSTALL THE
RANGE LOWER THAN ADJACENT COUNTERTOP
HEIGHT.
The anti-tip bracket is designed to be installed on
top of the slide (runners) provided with the range.
Any other type of construction may require special installation techniques to insure adequate fastening of the anti-tip bracket to the floor or wall.
The bracket must be properly installed to prevent tipping of the range.
Read the AHAM Anti-Tip Safety brochure packed with the product.
All Ranges must have an anti-tip device correctly installed according to these instructions.
Ifthe range is pulled out from the wall for any reason, make sure that the device is properly engaged when pushed back against the wall or installation position.
Toutes les cuisinieres peuvent
basculer
Des blessures peuvent en
resulter
antibasculement fourni
Consultez les instructions
Montez le support
AVERTISSEMENT:
Ifthe anti-tip device is not engaged, there is a possible risk that the range can tip over and cause injury if you or a child stand, sit or lean on an open door.
[4]#10 x2" wood
screws
Anti-Tip Bracket
AHAMAnti-Tip
SafetyBrochure
9
Page 10
Installation
STEP 3 INSTALL ANTI-TIP DEVICE
(CONTINUED)
SmallHoleForWood Installations(2Total)
(2)LargeHolesFor ConcreteInstallations
SmallHolesForWood Installations(2
Wood Slide Strip
Wood Construction:
Place the bracket against the back wall, into the right rear corner of the installation location.
(2)WoodScrewsinto
BackWall
(All Installations)
Back Wall
Dimension A
1/4"
5/8"
ZDP36
ZDP30
Concrete or Cement Construction:
Hardware Required (not supplied): [2] sleeve anchors, lag bolts and washers.
See Dimension A, position the bracket the correct distance from the right side. Mark the 2 small screw holes for fastening the bracket to the floor and remove
the bracket.
Drill two, 1/8"diameter pilot holes.
Fasten the bracket securely to the floor and wall using all 4 screws provided.
Place the bracket against the back wall, into the right rear corner of the installation location.
See Dimension A, position the bracket the correct distance from the right side. Mark the 2 large holes for fastening the bracket to the floor and remove
the bracket.
Drill recommended size holes for the hardware.
Install the sleeve anchors into the holes and then install the lag bolts through the bracket. The bolts
must be properly tightened as recommended for the hardware.
Fasten the bracket securely to the floor.
Drive wood screws into the back wall.
10
Page 11
Installation
STEP 4 CONNECT RANGE TO GAS
Assure that gas supply is turned off at the shut-off valve:
Connect flexible metal connector to incoming gas line pipe stub located on the left side on the bottom back of the range.
Turn on gas and check for leaks:
- Use a liquid leak detector at all joints and connections in the system.
_k_ CAUTION:
Do not use aflame to check for gas leaks.
MISE EN GARDE :
II ne faut pas utiliser de flamme pour
v_rifier s'il y a des fruites.
NOTE: This range is equipped with a gas shut-off valve located behind the kick plate, This valve is to be used in the event that service is required in the future.
o o
o o
I
D
u
11
Page 12
Installation
STEP 5 CONNECT ELECTRICAL
Plug power cord into properly grounded receptacle,
STEP 6 SLIDE RANGE INTO
POSITION
Carefully, slide the range into position,
- Be careful notto entangle power cord and gas flexible tubing,
Be sure the right rear leg is engaged in the slot of the installed anti-tip bracket,
Check for proper installation by grasping the range at the top front edge and carefully attempt to tilt the range forward,
Check to be sure the front of the range is level. Adjust front leveling legs accordingly.
Replace the front kick panel by reversing the procedure described in Step 1,
STEP 7 REPLACE OVEN DOOR(S)
IMPORTANT: Do not lift the door by the handle. To replace the oven doors:
Firmly grasp the door at the top sides. This is critical.
Approach the range with the door angled in a vertical position.
Guide the hinges into the slots.
Push the door infirmly while opening,
Once in position, open the door completely. Push the hinge locks back in and towards the front frame.
CAUTION:
Take care when replacing the oven doors.
If the hinge latch is not securely locked,
the hinge may snap back and separate. If the hinge
separates, you must apply pressure (possibly with your foot) to press it back together and then engage the hinge latch.
MISE EN GARDE :
Soyez prudent Iorsque vous remettez en
place les portes du four. Si le Ioquet de charni_re n'est pas verrouill_ correctement, la charni_re peut se d_gager brusquement et se s_parer. Si c'est le cas, vous devez exercer une pression (par exemple avec le pied) pour la remettre en place, puis enclencher le Ioquet.
12
Page 13
Installation
STEP 8 ASSEMBLE AND ADJUST BURNERS
Assemble burners as shown. Checkto be sure that burner heads and caps are securely seated. Pin(s) must
completely engage holes to ensure proper assembly.
Check for proper ignition:
- Push in one control knob and turn 90° to LITE position.
- The igniter will spark and the burner will light; the igniter will cease sparking when the burner is lit.
- First test may require some time, while air is flushed out of the gas line.
- Turn knob to OFE
- Repeat the procedure for each burner.
IMPORTANT: If the ignitor electrodes continue to spark after the burners are lit, check that each burner
component is assembled and seated properly by observing constant gaps between each layer.
Disassemble and reassemble as required.
Burner flames should be blue and stable with no yellow or yellow tips, excessive noise or lifting of the
flame from the burner. If any of these conditions exist,
check thatthe burner ports are not blocked. If one of
these conditions continues, call for service.
(__ _- Burner Cap
BurnerHead._
(Brass) _
LocatorPins_
Toaid reassembly,eachbrassburner headismarkedwith a clockface.
Replacethe burnerheadwith the arrow pointingto the rearofthe cooktop(12o'clockposition).
13
Page 14
FINALIZE INSTALLATION
Installation
Place the burner grates over the burners. Press corner
of the grate to the cooktop. The grates should be seated and should not rock.
The grill and griddle are secured with screws atthe
front. They are designed to be stationary and should not
be removed.
INSTALLATION CHECKLIST
[] Double checkto make sure everything in this manual
has been completed, Rechecking steps will ensure safe use of the range.
[] Make sure all controls are left in the OFFposition, [] Make sure the flow of combustion and ventilation air
to the range is unobstructed,
[] The serial plate is located beneath the ledge trim on
the left side, just above the left knob. In addition to the model and serial numbers, it tells you the ratings
of the burners and the type of fuel and pressure the range was adjusted for when it left the factory.
The griddle has two leveling screws beneath the rear flue cover that can be used to adjust to the desired slope. The center screw is for shipping purposes only and can
be removed.
[] When ordering parts, always include the serial
number, model number and a code letter to ensure proper replacement parts.
[] Recheck Steps:
Double check to make sure everything in this manual has been completed. Rechecking steps will ensure
safe use of the range.
14
Page 15
Installation
INSTALL 9" or 12" HIGH BACKSPLASH
Install and level the range or cooktop according to the installation instructions,
Remove the backsplash packaging, Select the back, wall mount panel with mounting screw slots.
Mark a horizontal line on the wall, 1/8" above the range/cooktop backguard,
Use wood screws or fasteners (not supplied) to secure
the back section to the wall. Slide the panel up or down to provide the 1/8" gap between the top of the
range/cooktop and the bottom of the backsplash. This 1/8"gap allows the appearance or front section
to overlap the mounted rear panel.
Secure the appearance panel to the mounted back section with the # 8 self-tapping screws provided. Install 3 screws on each side and 5 across the top.
INSTALL 22" HIGH BACKSPLASH
Install and level the range or cooktop according to the installation instructions,
Remove the backsplash packaging, Select the back, wall mount panel with mounting screw slots.
Mark a horizontal line on the wall, 1/8" above the range/cooktop backguard,
Use wood screws or fasteners (not supplied) to secure
the back section to the wall, Slide the panel up or down to provide the 1/8" gap between the top of the
range/cooktop and the bottom of the backsplash. This 1/8"gap allows the appearance or front section
to overlap the mounted rear panel,
Attach the shelf to the front section of the backsplash using screws and nuts supplied.
Secure the appearance panel to the mounted back section with the # 8 self-tapping screws provided, Install 3 screws on each side and 5 across the top.
Frontsection
Supplied Back
#BScrews " section\
Supplied\
#BScrews \
\
\
\
\
Backguard_
Slotsfor Vertical \
Adjustment \
/ Slots for
Vertical
Adjustment
Bach
Back
section "\
Backsection
l/B'L
Frontsection ,
Back-- section
II °"
WARNING:
The back section must be securely fastened to the wall. Failure to do so could cause damage or personal injury. Maximum shelf weight capability
is 10 Ibs.
Supplied_
#8Screws
AVERTISSEMENT
La section arri_re doit _tre fix_e solidement
sur lemur. Le d_faut de proc_der ainsi peut causer des dommages materiels ou des I_sions corporelles. La capacit_ de charge maximale
de I'_tag_re estde 4,5 kg (10 Ibs ).
15
Page 16
NOTE:While performing installations described in this book, safety glasses or goggles should be worn.
F<>rMonog'ra_? '_local s_r_Jice h_ )our arm, call
l._S00. 444. l,_4 _.
)
NOTE:] ro(hi(:l iml)l-o'_(m( ill i'_ a (:olHilitling (_ll(l(_a'_'()r _/t
sl)(_(if](:alions m-(_ sul;_j(:(t to (:hmig( Wil[lotlr noti(:(.
Pub.No.49-80222-1 PartNo.164D4290P374
17681Rev.B
12-04JR
Monogram:
GEConsumer & Industrial Louisville, KY4ll225
©2004 GE Company
Loading...