GE Professional Outdoor Grills and Cooktop User Manual

Installation Instructions

31-10702

11-08 JR

Professional Outdoor Grills and Cooktop

Tables de cuisson et barbecues de plein air professionnels

Instructions d’installation

La section française commence à la page 23

Parrillas y estufa profesionales para el aire libre

Instrucciones de instalación

La sección en español empieza en la página 45

Installation Instructions

BEFORE YOU BEGIN

Read these instructions completely and carefully.

•

IMPORTANT— Save these instructions for

local inspector’s use.

•

IMPORTANT— Observe all governing

codes and ordinances.

• Note to Installer — Be sure to leave these

instructions with the Consumer.

• Note to Consumer — Keep these instructions

with your Owner’s Manual for future reference.

If you have questions concerning the installation of this product, call the GE Answer Center

Consumer Information Service at 800.626.2000, 8 a.m. to 10 p.m. EST, Monday through Friday, and 8 a.m. to 7 p.m. EST, Saturday.

If you received a damaged grill or cooktop, you should contact your dealer.

Installation of this outdoor grill or cooktop requires basic mechanical skills. Proper installation is the responsibility of the installer.

For Monogram local service in your area, call 1.800.444.1845.

For Monogram service in Canada, call 1.800.561.3344.

For Monogram Parts and Accessories, call 1.800.626.2002.

FOR YOUR SAFETY:

Do not use the grill or cooktop in a space where gasoline or other liquids having flammable vapors are stored or used.

The installation must conform to local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, National Gas and propane Installation Code.

WARNING:

• For outdoor use only. Use this outdoor grill or

cooktop only in the manner intended by the manufacturer.

• This outdoor cooking gas appliance is not intended to be installed in or on recreational vehicles and/or boats.

• Do not use the grill in an explosive atmosphere. Keep the grill away from areas where gasoline or other flammable liquids and vapors are stored or being used.

• Observe proper clearances to combustible materials at all times.

• Do not use a rusty or damaged LP tank.

• Never substitute gases (natural for LP or LP for natural). These grills are factory-set for LP or natural gas. Order the model for the installation situation.

• When storing the grill indoors, disconnect the LP tank. Store the tank outdoors in a well ventilated area.

• Do not store additional LP tanks in or near the gas grill.

• Follow the guidelines on the LP tank for proper storage, transport and handling.

IF YOU SMELL GAS:

•

Shut off gas to appliance.

•

Extinguish any open flame.

•

Open lid.

•

If odor continues, keep away from the appliance and immediately call your gas supplier or fire department.

BEFORE LIGHTING:

1. Read instructions before lighting.

2. Open lid during lighting.

3. If ignition does not occur in 5 seconds, turn the

burner control(s) to OFF, wait 5 minutes and repeat the lighting.

Installation Instructions

FOR OUTDOOR USE ONLY

IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. READ THIS MANUAL THOROUGHLY BEFORE INSTALLATION, USE OR SERVICING THIS EQUIPMENT.

CALIFORNIA PROPOSITION 65

WARNING:

The burning of gas cooking fuel generates some by-products, which are on the list of substances, which are known by the State of California to cause cancer or reproductive harm. California law requires businesses to warn customers of potential exposure to such substances. To minimize exposure to the substances, always operate this unit according to the Use and Care instructions provided with this unit. Be certain to provide adequate ventilation when cooking. California Proposition 65 lists “Silica, crystalline” which is used in one of the components of the IR burner, as an agent known to the state of California to cause cancer.

In Massachusetts: All gas products must be

installed using a “Massachusetts” licensed plumber or gasfitter. A “T” handle type manual gas valve must be installed in the gas supply line to this appliance. This applies to permanently installed natural gas and propane installations. This does not apply to propane portable installations using a 20-pound tank (not included) plus regulator and hose assembly, which is supplied with propane gas grills.

INSECT WARNING!

Spiders and insects can nest in the burners of this and any other grill and cause the gas to flow from the front of the burner. This is a very dangerous condition which can cause fire to occur behind the valve panel, thereby damaging the grill and making it unsafe to operate. Inspect the grill twice a year or immediately if any symptoms appear.

CAUTION: All outdoor grills are

extremely heavy. Two people are required to lift and place a built-in grill into an enclosure. At least two people are also required to remove a grill on cart from the skid.

CODE COMPLIANCE

Test in accordance with ANSI Z21.58 latest edition standard for outdoor cooking gas appliances. This grill is for outdoor use only. Check local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code No. Z223 latest edition and the National Electrical Code ANSI/NFPA no. 70, latest edition.

CONTENTS

Design Information

Models Available......................................................................4

Product Dimensions and Clearances ......................5–7

Accessories ................................................................................8

Accessory Product Dimensions........................................8

Installation Preparation

Advance Planning ................................................................9

Choosing the Location ........................................................9

Electrical Supply Requirements ....................................10

Gas Supply Requirements ..............................................10

Outdoor Grill, Cooktop and

Accessory Cutout Dimensions ......................................11

Tools Required ......................................................................12

Materials Required ..............................................................12

Parts Provided ......................................................................12

Remove Packaging from Cart Models ..............13, 14

Remove Packaging from Built-In Models..................15

Installation Instructions

LP Tank Tie-Down ................................................................16

Tank Drawer with LP Tank Retainer Loop ................16

LP Gas Grill Connections

to a Grill or Cooktop ..................................................16, 17

Natural Gas Grill Connections ......................................17

Leak Testing ..........................................................................18

Make Electrical Connections ..........................................19

MODELS AVAILABLE (select the model according to the type of gas)

Design Information

ZGG540NC, 54" Natural Gas Grill with Cart

ZGG540LC, 54" LP Gas Grill with Cart

ZGG542NC, 54" Natural Gas Grill with Cart and 2 Side Burners

ZGG542LC, 54" LP Gas Grill with Cart and 2 Side Burners

ZGG420NC, 42" Natural Gas Grill with Cart

ZGG420LC, 42" LP Gas Grill with Cart

ZGG300NC, 30" Natural Gas Grill with Cart

ZGG300LC, 30" LP Gas Grill with Cart

ZGG540NB, 54" Built-In Natural Gas

ZGG540LB, 54" Built-In LP Gas

ZGG420NB, 42" Built-In Natural Gas

ZGG420LB, 42" Built-In LP Gas

ZGG300NB, 30" Built-In

Natural Gas

ZGG300LB, 30" Built-In

LP Gas

12" Outdoor Cooktop

with 2 Burners

ZGU122N, Natural Gas

ZGU122L, LP Gas

Design Information

PRODUCT DIMENSIONS AND CLEARANCES

54" Built-In

42" Built-In

30" Built-In

53-7/8"

27"

12" Min. to Combustibles 4" Min. Clearance for Lid

to Non-Combustibles

41-7/8"

29-7/8"

12" Min. to Combustibles 4" Min. Clearance for Lid

to Non-Combustibles

12" Min. to Combustibles 4" Min. Clearance for Lid

to Non-Combustibles

27"

12" Outdoor Cooktop with 2 Burners

26-1/2"

26"

13"

10-1/2" to the Bottom of the Side

Support Flange

12" Min. to

Combustibles

on All Sides

11"

Side View, All Built-In Grill Models

*The weight of the grill is fully supported by

the side trims. The back of the grill overlaps the back edge of the cutout.

10-1/4" from

Bottom of

Support Flange

*25-1/2"

Countertop Depth

27" to Front

of Control Panel

28-1/2" to Front of Bullnose

Side View, Built-In Cooktop Model

*25" Countertop Depth

26-1/2" to Front of Control Panel

28" to Front of Bullnose

7/8" Overlap

at the Back

*The weight of the cooktop is fully supported

by the side trims. The back of the cooktop overlaps the back edge of the cutout.

Design Information

PRODUCT DIMENSIONS AND CLEARANCES

54" Cart with Side Burners

15-1/2" (both sides)

53-7/8"

27"

12" Min. to Combustibles 4" Min. Clearance for Lid

to Non-Combustibles

51"

54" Cart

27"

12" Min. to Combustibles

4" Min. Clearance for Lid

to Non-Combustibles

15-1/2" (both sides)

51"

53-7/8"

*12" Side Burner

*27-1/2"

Side Burner

and Shelf

PRODUCT DIMENSIONS AND CLEARANCES

Design Information

42" Cart

30" Cart

41-7/8"

27"

12" Min. to Combustibles

4" Min. Clearance for Lid

to Non-Combustibles

51"

29-7/8"

27"

12" Min. to Combustibles

4" Min. Clearance for Lid

to Non-Combustibles

51"

15-1/2" (both sides)

+ 15 hidden pages