GE PGB900SET, JGB870DET, JGB870SET, PGB910DET, PGB910SET Series Manual
...
Dual Cavity Gas, Free Standing Ranges
Café, Profile & GE
JGB870DET
JGB870SET
PGB900DET
PGB900SET
PGB910DET
PGB910SET
PGB915SET
PGB930DET
PGB930SET
PGB935SET
P2B930DET
P2B930SET
PGB980SET
PGB995DET
PGB995SET
CGS990SET
CGS985SET
Café Profile & GE
C2S985SET
Copyright General Electric 2011
IMPORTANT SAFETY NOTICE
The information in this presentation is intended for use by individuals
possessing adequate backgrounds of electrical, electronic, &
mechanical experience. Any attempt to repair a major appliance may
result in personal injury & property damage. The manufacturer or seller
cannot be responsible for the interpretation of this information, nor can it
assume any liability in connection with its use.
WARNING
To avoid personal injury, disconnect power before servicing this product.
If electrical power is required for diagnosis or test purposes, disconnect
the power immediately after performing the necessary checks.
RECONNECT ALL GROUNDING DEVICES
If grounding wires, screws, straps, clips, nuts, or washers used to
complete a path to ground are removed for service, they must be
returned to their original position & properly fastened.
GE Factory Service Employees are required to use safety glasses with
side shields, safety gloves & steel toe shoes for all repairs.
Plano Type Safety Glasses
Electrically Rated Glove
Dyneema® Cut
Resistant Glove
Steel Toe Work
Boot
and Dyneema® Cut
Resistant Glove Keeper
Prescription Safety Glasses
Safety Glasses must be
ANSI Z87.1-2003 compliant
Brazing Glasses
Copyright General Electric 2011
11/28/2011
4 /
The Mini Manual is located in the control panel area on GE & Profile units. Back top left
rear corner on Café models.
The Nomenclature Tag is on the bottom left side front frame of the main oven.
Mini Manual Profile & GE
Mini Manual Cafe
Model Tag
Copyright General Electric 2011
5 /
11/28/2011
Overview-Product Info
Café, Profile, and GE Brands
Cooktop
•Tri-Ring Burner
•Tri-Bridge Burner
•Tri-Bridge Griddle
Double Oven
• Upper Oven 2.5 cuft
• Lower Oven 4.0 cuft
• Both Self Clean
2x Lighting
Full Visibility Door (Glass
Liner)
Black Enameled Cavity
New Doors & SS trims
Copyright General Electric 2011
11/28/2011
6 /
Overview-Feature Detail
Cooktop Burners
3 Ring = 19/20K BTUs
• Tri Ring 20K BTUs- Café / 19K Profile
• Tri Bridge 23K BTUs
• New cooktop configurations
• New Griddles / Double-Bridge Griddle
9.1K
5.0K
9.5K
9.1K
5.0K
20/19K
17000 btu/h Max.
3000 btu/h Max.
400 btu/h Min.
3 Bridge = 24K BTUs
5000 btu/h Max.
1000 btu/h Min.
9100 btu/h Max.
850 btu/h Min.
Copyright General Electric 2011
11/28/2011
7 /
Cooktop Grates & Griddle Designs
Copyright General Electric 2011
11/28/2011
8 /
Note: The center griddle is used without the center grate installed, the Chef griddle is
installed on top of the left grate.
Copyright General Electric 2011
11/28/2011
9 /
Copyright General Electric 2011
11/28/2011
10 /
Control Overview, ERC & Thermostat
The lower oven is controlled by an (ERC) electronic control, the upper oven is controlled by
an hydraulic thermostat. Both upper and lower ovens have self clean capability.
Café Models
Profile & GE Models
Copyright General Electric 2011
11 /
11/28/2011
Anti-Tip Bracket
• Range must be secured by the Anti-Tip Bracket supplied.
Copyright General Electric 2011
12 /
11/28/2011
Control Panel Removal – GE & Profile
Copyright General Electric 2011
11/28/2011
13 /
Lower Oven Door Removal
Copyright General Electric 2011
11/28/2011
14 /
Upper Oven Door Removal – Hinge Release
Copyright General Electric 2011
11/28/2011
15 /
Upper Oven Door Removal
Open the oven door to a 45 degree angle from the oven frame, press in on both release
buttons and lift the door off of the door hinges.
Release Button
Copyright General Electric 2011
16 /
11/28/2011
Component View, Back – Profile & GE
ERC
Spark Module
Thermostat
Capillary
Oven Sensor
Igniters UO
Gas Valve UO
Gas Lockout
Valve
Convection
Fan Motor
Gas Valve LO
Igniter LO
Regulator
17 /
Copyright General Electric 2011
11/28/2011
Component View, Back – Café
Thermostat
Cooling Fan
Capillary
Oven Sensor
Gas Valve UO
Gas Valve LO
Igniters UO
Gas Lockout
Valve
Spark Module
Broil Element LO
Convection
Fan Motor
Igniter LO
Regulator
18 /
Copyright General Electric 2011
11/28/2011
Component View, LH Side – All Models
TCO UO
Gas Lockout
Valve
Self Clean
Latch Assy
Lock Out
Relay UO
TCO LO
19 /
Copyright General Electric 2011
11/28/2011
Component View, Oven Cavities
Broil Burner
Thermostat Capillary
Bake Burner
Broil Element, Café Only
Convection Fan
Sensor
Bake Burner
20 /
Copyright General Electric 2011
11/28/2011
Oven Gaskets
The oven gaskets are installed with push in spring clips.
The bottom corners of the gasket
are installed in two oval slots at
the bottom without a crossover.
Copyright General Electric 2011
11/28/2011
21 /
Loading...