Gastroback 40119 User Manual

®

GASTROBACK

INSTRUCTIONS FOR USE AND RECIPES

DESIGN JUICER BASIC

Art.-Nr. 40119 DESIGN JUICER BASIC

Read all provided instructions before first usage!

Model and attachments are subject to change

Carefully read all provided instructions before you start running the appliance and pay

regard to the warnings mentioned in these instructions.

!

Contents

Introduction ......................................................................................................3

Gastroback recommends safety first ..............................................................3 – 5

Know your Design Juicer Basic ....................................................................

Assembling your Design Juicer Basic ..........................................................8 – 10

Operating your Design Juicer Basic ..........................................................10 – 11

Disassembling your Design Juicer Basic ....................................................12 – 13

Care and cleaning..........................................................................................14

Trouble shooting guide....................................................................................15

The inside information on juicing ............................................................16 – 18

Recipes..................................................................................................19 – 27

Warranty ..................................................................................................................27

Disposal....................................................................................................................27

6 – 7

Introduction

The current Interest in fresh and unprocessed food is
the reason for fresh fruit and vegetable juices to
become a favorite component of our daily food
and wellbalanced diet.

The Gastroback juicer has a special designed large
feed chute, a large pulp container and a stainless
steel micro mesh filter. It operates with a high
performance 450 watt motor which makes the
juice production easy and efficient. The elaborate
design makes the cleaning an ease.

Gastroback recommends safety first

Carefully read all instructions before operating
and save the instructions for further reference.
Do not attempt to use this appliance for any
other than the intended use, described in these
instructions. Any other use, especially misuse,
can cause severe injury or damage by electric
shock, fire or moving mechanical parts. This
instruction is an essential part of the appliance.
When passing on the appliance to a third person,
ensure to include these instructions.

Any operation, repair and technical maintenance
of the appliance or any part of it other than
described in these instructions may only be
performed at an authorised service centre.
Please contact your vendor.

Safeguards for Daily Operation

• Do not use the appliance in moving vehicles
or boats. Only use the appliance indoors.

•Store and use the appliance in a clean, frost
free environment where it is protected from
dampness, moist and immoderate and extraordinary
burden (such as: downfall, beat, overheating,
moisture in the motor block) .

• Do not use or store the appliance outdoors.

• Only use units, spare parts and supplies
which are provided and recommended by
the manufacturer. Damaged or improper units
may break in use, damage the appliance
or cause injury. Do not use the appliance if the
rotating sieve is damaged.

The units have a smooth surface with no grooves and
rough edges and can be cleaned easily after use.

The provided pulp container finishes with the
juice run-out and therefore eliminates any splatter
during operation.

Please read all the advice and instructions with
care and keep the manual.

Only use the appliance to process fresh food.

• Store appliance and units out of reach of children.

• Never leave children unsupervised when the
appliance or units of the appliance are in reach.

• Never let children play with the appliance or
units of the appliance. Children and invalid
people have to be supervised using the appliance.

• This appliance is not intented for use by persons
(including children) with reduced physical, sensory
or mental capabilities, or lack of experience and
knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a
person responsible for their safety. Children
should be supervised to ensure that they do not
play with the appliance.

• The work space has to be easily accessible,
solid, even, dry and of sufficient size. Do not
use the appliance in moist and wet areas.

• Operate the appliance on a well accessible, stable,
level, dry, and suitable large surface. Do not place
the appliance or any part of it on or near hot surfaces
(heater, gas burner, grill, or oven). Do not place the
appliance near the edge of the table or counter or on
inclined or wet surfaces or where it can fall.

• Do not put any cloth or napkins underneath the
appliance to avoid endangering by fire and electric shocks.

• Never situate the appliance close to the edge
of the working area.

• Never let water or other liquids run into the
motor block.

• Never leave the appliance unattended,

when the plug is plugged into the

3

Gastroback recommends safety first

power point.

• Always turn the appliance off and pull the
plug when the appliance is not in use or when
disassembling, moving or cleaning the appliance.
Always grasp the plug to disconnect the
appliance from the power outlet.

• Do not leave food leftovers dehumidify on the
appliance or units of the appliance. If pulp
dehumidifies on the micro mesh filter it may clog
the fine pores of the micro mesh filter thereby
lessening the effectiveness of the juicer. Remove
such dirt immediately and operate according to the
instructions ´Care and cleaning` before you
continue to proceed.

• Never clean or operate the appliance or units
of the appliance with abrasive or hard sharp-edged
items. Use a nylon brush for cleaning the filter basket.

• Never clean the motor block in the dishwasher.

• Never use force operating the appliance to
avoid damage of the units of the appliance.

• Do not touch the small cutting blades in the
base of the stainless steel filter basket. Pay attention
not cutting yourself when handling the filter basket.

• Always make sure the appliance is properly and
completely assembled before connecting to power
outlet and operating. The unit will not turn ‘ON’
unless properly assembled.

• Do not push products into the feed chute with
your fingers or foreign objects. Always use the
food pusher provided.

• Do not operate the appliance continuously
more then 30 minutes. Allow the motor to rest
for 30 minutes between each use.

• Do not operate the appliance continuously on
heavy loads for more than 10 seconds. In this
case the appliance is overloaded or the fruit
chunks are too big. Cut the fruit in smaller pieces
and try smaller amounts at one time. To continue
juicing turn the appliance OFF and then ON
again. (None of the recipes in this book are
considered a heavy load.)

• While proceeding Do not push the food pusher
too hard down. Empty the pulp container and juice
jug in time to avoid run-over and splatter which
might causes damages to the appliance. When
proceeding hard or stringily food or if you press

the stamp down too hard the motor could stop
or slow down. In this case turn off the appliance
immediately and pull the plug to avoid overheating.
Operate according to the instructions ´Trouble
shooting guide`.

• Do not use the appliance if it is damaged or
units of the appliance are damaged. Do not use
the appliance if it does not function properly or if
it was excessively loaded. The appliance is likely
damaged if the appliance or units of the
appliance show cracks, exorbitant wearing
down, alterations or leaks. It is also likely damaged
if the drive wheel of the motor block moves slowly.
Take the appliance for technical maintenance
and repair to an authorised specialised reparation
shop. Reparation and technical maintenance of
the appliance or line cord are just allowed to be
accomplished by an authorised specialist reparation
shop.

• The appliance is not suitable for mincing nuts,
chocolate or similar ingredients. The appliance
is not suitable to make minced meet or to blend food.

Important Safeguards for all Electrical
Appliances

• Always uncoil the line cord completely before
installing the appliance.

• Place the appliance close to a power point
and connect it directly without using any extension
cords to avoid additional risks of injury through
fire or voltage.

• Only install the appliance in proper form
secure grounding receptacle with adequate
electric power supply (alternating current;
220/230 V, 50/60 Hz) and ground fault circuit
interrupter. The maximum power consumption of the
appliance is 450 Watt. You should also install a fuse
with a release current of maximum 30mA. If
necessary ask your electrician for help.

• Never pull, rip, bend, clamp, squish or knot the
line cord. Pay attention to the line cord not
hanging of the table. Attend to nobody getting
caught in loops of the line cord or pulling the
appliance of the work space. When pulling the
plug always catch hold of the enclosure of the plug.

4

Important Safeguards for all Electrical Appliances

• Do not immerse the motor housing or power
cord in water or any other liquid. Do not pour
or drip any liquids on the motor housing or power
cord. When liquids are spilled on the motor
housing, immediately unplug the appliance and
dry the motor housing to avoid risk of electric
shock or fire. Do not attempt to operate the
appliance, when liquids are on or in the motor housing.

Movable and sharp-edged units – risk
of injury

• The feed chute is designed exceedingly large.
Never put fingers, wooden spoons or other
foreign substance (such as hair, clothing, brushes,
cloths) into the feed chute when the appliance is
plugged into the power point.

• Always turn the appliance off, wait for the
motor to stop moving and then pull the plug
before taking off the lid of the juicer.

• Only use the provided food pusher to push
food through the feed chute.

• Never hold your face or other body parts
over the feed chute when the motor is running
because little pieces of food could be thrown out
of the feed chute.

• The blades on the base of the stainless steel
micro mesh filter and inside the feed chute are
very sharp. Pay attention when handling the
units. Only touch the stainless steel micro mesh filter
on the edge and handle with care when cleaning with
the nylon bristle brush. Only store the appliance
completely assembled. This way the blades will be
out of reach.

• Never put foreign substance or hard objects
into the feed chute. Remove all inedible parts
(such as stem, hard peeling and seeds) of the
food before putting them into the feed chute.

• The motor pursues running for a little while
after turning the appliance off. Wait until the
motor stops running completely before you
open or move the appliance.

5

Get to know your Gastroback juicer

Food pusher with cannelure:

for pushing whole fruit and vegetables down

the feed chute

Patented extra wide feed chute: You can fill in
whole fruit such as apples, carrots, tomatoes
and peeled oranges. For quick and easy juicing
of fruit and vegetables.

Juicer cover (dishwasher safe) with interlocking
safety arm: stops the juicer operating without
the juicer cover locked in place.

Large pulp container with integrated handle
(dishwasher safe)

Motor block with 450 Watt motor

On-/Off-switch

6

Stainless steel micro mesh filter basket
(dishwasher safe)

Safety arm

Customer designed juice nozzle: perfect
for mess free juicing straight into a glass
(dishwasher safe)

Rubberfeet

7

Assembling your Design Juicer Basic

Step 1:

Place the filter bowl surround on the motor block
(picture 1).

Step 2:

WARNING: Handle the units with care and do

not use any force. Pay attention to the sharp

!

blades on the stainless steel micro mesh filter
and the feed chute to avoid injury. Always
completely assemble your juicer before you
plug the plug into the power point.

1

ATTENTION: Ensure the stainless steel filter
basket is clean before assembling. Any dehumidified

!

left over food on the basket will block the fine
mesh holes. If necessary remove excess fibre
build up (from fruit or vegetables) according to
the instructions ´Care and Cleaning`.

Align the arrows on the stainless steel filter basket
with the arrows on the motor drive coupling and
push down until it clicks into place. Ensure the
stainless steel filter basket is fitted securely
inside the integrated pulp container and onto
the motor base (picture 2).

Step 3:

Place the juicer cover over the stainless steel filter
on top of the filter bowl surround (picture 3). The
feed chute has to be positioned in the middle of
the filter basket and the pulp spouting of the cover
has to face away from the interlocking safety arm.

2

3

8

Assembling your Design Juicer Basic

Step 4:

Raise the safety locking arm straight up and lock
into the two grooves on either side of the juicer
cover. The safety locking arm should now be in a
vertical position and locked into place on top of the
juicer cover (picture 4).

IMPORTANT: If the safety locking arm is not in the

right position the motor will not start moving.

4

Secure the safety arm by lifting it into the two
grooves of the cover (picture 4a).

Step 5:

Slide the food pusher down the feed chute by
aligning the groove of the food pusher with the
small protrusion on the inside of the top of the
feed chute. Continue to slide the food pusher
down the feed chute (picture 5).

4a

Food
Pusher
Groove

5

9