Installation
&
Operation Guide
DEHUMIDIFIER
MODELS
115 Volts • D30 • D40 • D50
EPA DOE
(D40 / D50 Only)
Register Your Dehumidifier
Model information can be found on the name plate on the rear of
the unit behind the condensate bucket.
To register your dehumidifier, complete and mail the enclosed
registration card. or register on-line at www.friedrich. com (USA
only). For your future convenience, record the model information
here.
MODEL NUMBER SERIAL NUMBER PURCHASE DATE
920-137-00 (01/02)
2
Inside you will find many helpful hints on how to use and
maintain your dehumidifier properly. Just a little preventive
care on your part can save you a great deal of time and
money over the life of your dehumidifier.
You'll find many answers to common problems in the chart of
Troubleshooting Tips. If you review our chart of
Troubleshooting Tips first, you may not need to call for
service at all.
READ THIS MANUAL
PRECAUTION
Safety Precautions.....3
Operating
Instructions.................5
Installation
Instructions.................8
Care and
Maintenance ..............9
Troubleshooting
Tips............................10
Warranty.....Back cover
Customer Assistance
Numbers ....Back cover
• Contact an Authorized Service Center for repair or
maintenance of this unit.
• The dehumidifier is not intended for use by young children
or invalids without supervision.
• Young children should be supervised to ensure that they do
not play with the dehumidifier.
3
WARNING
WARNING
B
e
n
z
e
n
e
S
C
O
U
R
I
N
G
C
L
B
A
R
G
E
R
S
I
N
N
E
R
Safety Precautions
Read all instruction before using.
■ To prevent property damage or injury to the user or others, the following instructions myst be followed.
■ Incorrect operation due to ignoring instructions will cause harm or damage; the seriousness is classified by the
following indications.
■ Meanings of symbols used in this manual are as shown below.
WARNING This symbol indicates the possibility of death or serious injury.
CAUTION This symbol indicates the possibility of injury or damage to properties only.
Never do this.
Always do this.
Complete all grounding and
installation requirements as
described on page 5.
• It could cause electrical shock
or fire.
Disconnect power cord from
receptacle before servicing or
cleaning.
• It could cause electrical shock
or fire.
Do not use flammable fluids, solvents,
abrasive cleaners, or strong detergents
to clean the dehumidifier.
• It could cause fire or product
damage hazard.
Do not plug the dehumidifier
in until the outside of unit is
completely dry.
• It could cause electrical shock
and personal injury hazard.
Do not use the water collected
in the bucket for drinking
purposes.
• It is not sanitary and could
cause illness or personal injury
hazard.
Do not clean the dehumidifier
while it is plugged in.
• It may cause electrical shock.
4
CAUTION
CAUTION
Be sure to block the wheels to
prevent unit from falling when
installed on a table or shelf.
• It may damage the dehumidifier
or cause other damage or
injury.
Be sure to replace bucket
properly after emptying to
prevent water from collecting
on the floor.
Make sure the dehumidifier is
the correct size for the area
you want to dehumidify.
Do not operate switches with
wet hands.
• It may cause electrical shock.
Install the dehumidifier
properly on a floor, table, or
shelf that is level and strong
enough to support it with a full
bucket of water.
• It should withstand around
90 lbs (40kg) of weight.
Do not install dehumidifier in
an area where temperatures
will fall below 65°F (18°C.)
• Low temperatures could cause
coils to frost and unit may not
start.
Close all doors, windows and other outside
openings to the room.
• The dehumidifier must be operated in an enclosed
area to be most effective.
Do not put a pet or house plant where it will be
exposed to direct air flow.
• This may injure the pet or plant.
5
Air Filter
Fan Speed
Humidistat
Cabinet
Bucket
Auto
Shut-Off
Light
Front
Grille
3-prong
grounding
plug
Ground
prong
Power
supply
cord
3-prong
grounding
type wall
receptacle
Operating Instructions
Features
This section contains captioned illustrations of your dehumidifier. Use the drawings to become familiar
with all parts and features and what they look like.
Electrical requirements
OBSERVE ALL LOCAL CODES AND ORDINANCES.
DO NOT, UNDER ANY CIRCUMSTANCES, REMOVE
THE POWER SUPPLY CORD GROUND PRONG.
Electrical ground is required on this appliance.
A 115-volt 60 Hz, AC only, 15A fused and properly
grounded electrical supply is required. A time delay
fuse or time delay circuit breaker is required.
Use a dedicated circuit, serving only this appliance.
Do not use an extension cord.
Recommended grounding method
For your personal safety, this appliance must be grounded. This appliance has a power supply cord
with a 3-prong grounding plug. To minimize possible shock hazard, the cord must be plugged into a
mating grounding type wall receptacle, grounded in accordance with the latest edition of the National
Electrical Code (ANSI/NFPA 70) and all local codes and ordinances. If a mating wall receptacle is not
available, it is the personal responsibility and obligation of the customer to have a properly grounded
3-prong wall receptacle installed by a qualified electrician.
6
Operating your dehumidifier
Control
Your dehumidifier has a control panel containing an indicator and two controls —
Auto Shut-Off, Fan Speed, and Humidistat.
Auto Shut-Off ---This lamp glows when the bucket is full or is missing.
Fan Speed --- This controls the speed of the airflow.
Humidistat --- This controls the moisture in the room.
Unit operation
1.Turn the Humidistat to Off. Plug the power supply cord into an electrical outlet.
2.The Humidistat can be set anywhere between Off and Max for normal operation.
If you need more dehumidification, turn the Humidistat toward Max. If you need less dehumidification,
turn the Humidistat toward Off.
3.Turn the Humidistat to Off to stop the unit.
4.If you want to control the speed of air flow, turn the Fan Speed toward Low or High.
NOTE: The Fan and compressor will not operate for about two minutes to protect the compressor
when you turn the unit off and immediately back on.
De-icer control (invisible)
The Defrost Control senses frost build-up on the evaporator coil and automatically shuts off the
compressor. The fan continues to run, drawing air across the coil, and melting the frost. When the coil is
defrosted, the compressor automatically restarts, and dehumidifying resumes.
NOTE: Do not operate the dehumidifier at temperature below 65°F (18°C.) If your dehumidifier runs when
the temperature and humidity conditions of room are low, frost can form on its evaporator coil. This
interferes with proper operation. Therefore, dehumidifying performance may be reduced.
7
Drill
Water level
control switch
Automatic shut off
The dehumidifier will turn off automatically when the bucket is
full, removed or not replaced in the proper position.
The bucket must be replaced in the proper position for the
dehumidifier to work. The light will be on and the dehumidifier
will not run if the bucket is not in the proper position.
Disposing of collected water (3 methods)
1.Empty the bucket manually.
When the bucket is full, pull out and
empty it into a large sink or tub and
then replace it properly.
NOTE: The bucket must be
positioned properly making sure
slots on the back of bucket are
positioned correctly.
NOTE: Do not overtighten the hose
when connecting it to the bucket.
Use a rubber washer and tighten
by hand firmly without stripping
the plastic threads.
2. Place the dehumidifier directly
over drain.
The bucket has a threaded hose
connection which can be left open.
Drill a 1/4" (6.4 mm) hole in the
center of the hose connection.
Once opened, the hose connection
will continually drain water from the
bucket.
NOTE: The nozzle cannot be fixed
after puncture. Use an ordinary
garden hose cap to reclose if
necessary.
3. Attach a length of garden hose
to the threaded bucket drain
hose connection to carry water
to the drain.
When being attached to the bucket
drain hose connection, be sure the
hose doesn’t kink or bend. It should
lie flat from the dehumidifier to the
drain.
NOTE: The hose attachment will
accept a standard garden hose
filling. You can attach a screw-on
cap to use the bucket without a
hose.
8
12"
12"
Installation Instructions
Installing the dehumidifier properly
1.Allow at least 12 inches of space on all sides of the unit for good air circulation.
2.Install your dehumidifier on a floor, table, or shelf. When installing the dehumidifier on a table
or shelf, make sure the table or shelf is strong enough to support the weight of the dehumidifier
with a full bucket. Do not sit or stand on the dehumidifier.
NOTE: The height of a table or shelf might provide a better position from which to handle the
bucket and help prevent icing of the coils due to colder air near the floor (such as in a
basement.)
3.Lift the bucket and place it in the dehumidifier, making sure the slots on both sides of the
bucket are positioned correctly.
4.Rollers let you move the dehumidifier easily.
Choosing the proper location for your dehumidifier
• Use the dehumidifier in a
basement to help prevent
moisture damage.
• Use the dehumidifier in
laundry drying, bathing, and
dishwashing areas which have
excessive moisture.
• Use the dehumidifier to
prevent moisture damage
anywhere books are stored.
9
1
2
Care and Maintenance
Your dehumidifier is designed to serve you yearround. It needs practically no attention. However,
you should check your dehumidifier and inspect the
coils annually.
You may want an Authorized Service Center to
perform this annual checkup. (Cost of the inspection
is the owner’s responsibility.)
OR
If you are familiar with electrical appliances and their
functions, listed below are instructions which would
allow you to perform the inspection and
maintenance for yourself.
Cleaning the front grille and case
Clean the front grille and the cabinet with a soft
cloth, warm water, and a mild detergent.
Do not use bleach or abrasives.
Cleaning the air filter
1-1.First, flex the filter at the lower right corner.
Second, slide the upper right side to the left.
Then, release all of the tabs and remove
the filter.
1-2.Wash air filter with warm water and a mild
detergent. Rinse and dry it.
Replace dry air filter.
Cleaning the coil
2-1.Remove air filter from the cabinet (see step
1 above).
2-2.Brush the coil gently like arrow in the figure,
if necessary, with warm water and a mild
detergent. Rinse and dry them thoroughly.
Be careful not to spray the coil with a
water hose.
Be careful! Sharp edges!
Electrical Shock Hazard
• Disconnect power supply cord from receptacle before
performing any maintenance.
• Be careful when cleaning the coils.
Fins are sharp.
Failure to follow the above precautions could result in
electrical shock or personal injury.
10
Troubleshooting Tips
Before you call for service, review this list. It may save time and money.
The list includes common occurrences that are not the result of defective workmanship or materials in this
appliance.
FIND YOUR PROBLEM HERE
DEHUMIDIFIER DOES NOT
OPERATE
DEHUMIDIFIER RUNS TOO
MUCH
FROST APPEARS ON
COILS
FAN NOISE
Plug is disconnected from outlet.
The fuse is blown/circuit breaker is
tripped.
The dryness level you selected has
been reached.
The Auto Shut-Off light is on.
Dehumidifier is not turned on.
Humidistat is set too high.
Windows or doors near dehumidifier
are open to outdoors.
Area to be dehumidified is too large.
Air movement through dehumidifier
is blocked.
Humidistat is set at Max.
Room temperature is too low.
Room temperature is below 65°F
(18°C.)
Air is moving through the
dehumidifier.
Push plug firmly into wall outlet.
Check the house fuse/circuit breaker box
and replace fuse or reset the breaker.
Dehumidifier automatically shuts off
when the selected amount of moisture
has been removed from the air. If you
want to remove more moisture, turn the
Humidistat to Max. After the dehumidifier
starts, reset the control to the desired
setting.
Dehumidifier automatically shuts off
when the bucket is full. Empty the bucket
and replace.
Turn on the Humidistat.
Turn the Humidistat to a lower setting.
Close all windows or doors to outside.
Check with your dealer to see if capacity
is adequate.
Front grille may be dirty.
Use a soft cloth, warm water, and a mild
detergent to clean the grille.
Dehumidifier's coils on the back of unit
may be dirty. Clean the soil on the coils
on the back of the unit.
Dehumidifier must be placed in a space
that does not restrict air flowing into the
rear coil or out of the front grille.
Dehumidifier will not turn off if Humidistat
is at Max.
Frost will usually disappear within 60
minutes.
This is a normal sound.
POSSIBLE CAUSES
WHAT TO DO
11
DEHUMIDIFIER DOES NOT
DRY THE AIR AS IT SHOULD
Dehumidifier has been installed or
restarted recently.
Airflow is restricted.
The control may not be set high
enough.
Doors and windows may not be
closed tightly.
Clothes dryer may be blowing
moisture-laden air into the room.
Room temperature is too low.
• The more moisture in the room air,
the longer it takes for the room air to
become dry.
• Make sure there are no curtains,
blinds, or furniture blocking the front
or back of the dehumidifier.
• Turn the knob to a higher number.
• Check that all doors, windows, and
other openings are securely close.
• Install the dehumidifier away from
the dryer. Dryer should be vented to
the outside.
• The unit will not effectively operate
satisfactorily if the room
temperature is below 65°F (18°C.)
FRIEDRICH AIR CONDITIONING CO.INC.
Post Office Box 1540 ¥ San antonio, Texas 78295-1540
4200 N. Pan Am Expressway ¥ San Antonio, Texas 78218-5212
(210) 357-4400 ¥ FAX (210) 357-4480
Visit us on the Internet at www.friedrich.com
DEHUMIDIFIERS
LIMITED WARRANTY
FIRST YEAR
ANY PART: If any part supplied by FRIEDRICH fails because of a defect in workmanship or material within twelve months from date
of original purchase, FRIEDRICH will repair the product at no charge, provided the product is transported to a Friedrich Authorized
Service Center for repair. ALL transportation charges are the sole responsibility of the owner. This remedy is expressly agreed to be
the exclusive remedy within twelve months from the date of the original purchase.
SECOND THROUGH FIFTH YEAR
SEALED REFRIGERANT SYSTEM: If the Sealed Refrigeration System (defined for this purpose as the compressor, condenser
coil, dehumidifying coil, capillary, filter drier, and all interconnecting tubing) supplied by FRIEDRICH in your dehumidifier fails
because of a defect in workmanship or material within sixty months from date of purchase, FRIEDRICH will pay a labor allowance
and parts necessary to repair the Sealed Refrigeration System; PROVIDED FRIEDRICH will not pay the cost of diagnosis of the
problem, removal, freight charges, and transportation of the dehumidifier to and from the Service Agency, and the reinstallation
charges associated with repair of the Sealed Refrigeration System. All such cost will be the sole responsibility of the owner. This
remedy is expressly agreed to be the exclusive remedy within sixty months from the date of the original purchase.
APPLICABILITY AND LIMITATIONS: This warranty is applicable only to units retained within the Fifty States of the U.S.A., District
of Columbia, and Canada. This warranty is not applicable to:
1. Air filters or fuses.
2. Products on which the model and serial numbers have been removed.
3. Products which have defects or damage which results from improper installation, wiring, electrical current characteristics, or maintenance; or caused by accident, misuse or abuse, fire, flood, alterations and/or misapplication of the product and/or units installed in a corrosive atmosphere, default or delay in performance caused by war, government restrictions or restraints, strikes, material shortages beyond the control of FRIEDRICH, or acts of God.
OBTAINING WARRANTY PERFORMANCE: Service will be provided by the FRIEDRICH Authorized Dealer or Service Organization in your area. They are listed in the Yellow Pages. If assistance is required in obtaining warranty performance, write to: Room Air
Conditioner Service Manager, Friedrich Air Conditioning Co., P.O. Box 1540, San Antonio, TX 78295-1540.
LIMITATIONS: THIS WARRANTY IS GIVEN IN LIEU OF ALL OTHER WARRANTIES. Anything in the warranty notwithstanding, ANY IMPLIED WARRANTIES OF FITNESS FOR PARTICULAR PURPOSE AND/OR MERCHANTABILITY SHALL BE LIMITED TO THE DURATION OF THIS EXPRESS WARRANTY. MANUFACTURER EXPRESSLY DISCLAIMS AND EXCLUDES ANY
LIABILITY FOR CONSEQUENTIAL OR INCIDENTAL DAMAGE FOR BREACH OF ANY EXPRESSED OR IMPLIED WARRANTY.
NOTE: Some states do not allow limitations on how long an implied warranty lasts, or do not allow the limitation or exclusion of con-
sequential or incidental damages, so the foregoing exclusions and limitations may not apply to you.
OTHER: This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.
PROOF OF PURCHASE: Owner must provide proof of purchase in order to receive any warranty related services.
All service calls for explaining the operation of this product will be the sole responsibility of the consumer.
All warranty service must be provided by an Authorized FRIEDRICH Service Agency, unless authorized by FRIEDRICH prior to
repairs being made.
Revised (01/02)
P/NO. 3828A30059J 920-137-00 (01/02)
Loading...