Page 1
p
L3D/L3S Series
User’s Guide
Thermal Dis
ensers
Revised vacuum dispenser user guide
L3D-10
1 gallon
L3D-15
1.5 gallon
L3D-20
2 gallon
© 2012 Food Equipment Technologies Company
FETCO®, LUXUS®, Driven To Innovation™,
Freshness Time™, and Volume Indicator™ are trademarks
or trade names of Food Equipment Technologies Company. Part # P015 REV. 004
®
May 2012
Page 2
IMPORTANT SAFEGUARDS
f To prevent overflows, make sure the dispenser is completely
empty before brewing
.
f Always remove the funnel for manual filling of the dispenser.
f Do not use bleach or cleaners containing chlorides.
f Do not use solvent based cleaner or polish on this equipment.
f Use only non-metallic brushes and cleaning pads.
f Use only the handle to lift or carry the dispenser.
f Do not use the faucet guard to pull or lift the dispenser.
f Do not submerge the brew funnel.
CLEANING AND MAINTENANCE
Detailed instructions are available on our web site, www.fetco.com.
Daily:
Important Notice: To maintain proper operation of the funnel
display, clean the funnel stem daily under running water with
detergent and a sponge or towel.
Do not submerge. Do not use abrasives of any kind
f Use any commercial beverage urn cleaner to clean the inside of
the dispenser. Follow the cleaner manufacturer’s instructions.
Make sure to thoroughly rinse the dispenser after cleaning.
f Wash the drip tray and other plastic parts with dish detergent.
Avoid abrasives.
f To sanitize the dispenser before filling, brew a batch of water only
(no coffee) into the dispenser and allow it to rest for 10 minutes.
Weekly, or as needed:
f Remove the faucet upper assembly and inspect the seat cup for
wear. Clean or replace if necessary.
Page 3
BREW FUNNEL DISPLAY
= Each segment = 15 minutes.
= 1 hour.
= Maximum time has
elapsed. (4 hrs.)
Time is reset when dispenser is
completely emptied, when funnel is
removed, or when enough liquid is
added to increase the volume by at
least one level.
Example - for L3D-15:
NEW CONFIGURATION 5-2011
Each bar equals:
20% of the L3D dispenser
st
- “Vee” section is the 1
bar &
does indicate 20% level.
New display for all funnels is:
L3D-10 “Vee”-plus- 4 bars.
L3D-15 “Vee”-plus- 4 bars.
L3D-20 “Vee”-plus- 4 bars.
“VEE”
counts as
a level
Example - for L3D-10:
15 minutes
Full
1 hour, 30 minutes
Half full – (
¾ gallon)
1 hour, 30 minutes
Half full – (
½ gallon)
3 hours, 15 minutes
(
¼ gallon)
3 hours, 15 minutes
(
¼ gallon)
Page 4
OPENING THE
DISPENSER LID
OPENING AND CLOSING
THE COVER PLUG
1) Squeeze the two
tabs together
2) Lift lid upwards
Closed
position
for serving
REMOVING THE BREW FUNNEL
Open
position
for brewing
Important Notice: To maintain proper
operation of the funnel display, clean the
funnel stem daily under running water
with detergent and a sponge or towel.
Do not use abrasives or submerge.
• Brew funnel must be removed for manual
filling of dispenser.
• Removing the funnel resets timer.
• To extend battery life, remove the funnel
when not in use.
(Battery cannot be replaced.)
Page 5
REMOVING THE DRIP TRAY
1) Press and hold down latch release
2) Slide out drip tray.
3) Separate tray from cover to clean
REMOVING THE FAUCET GUARD
1) Unscrew knob 4 turns
2) Slide faucet guard out
.
1)
2)
3)
REMOVING THE FAUCET
2)
1) (knob)
1) Press faucet
release latch up.
Page 6
REMOVING THE FAUCET-Continued
2) Rotate faucet 180°
3) Pull out.
(Replace gasket if removed)
4) Unscrew faucet upper
assembly to clean or replace
seat cup.
TO REINSTALL:
5) Press release latch down to
lock faucet in place.
Page 7
Replacement Parts
Page 8
Dispenser Model Number
ITEM Description
L3D-10 &
L3S-10
L3D-15 &
L3S-15
L3D-20 &
L3S-20
1a LOCK (inside cover) 1023.00036.00 1023.00030.00 1023.00030.00
1b PLUG ASSY. 1023.00119.00 1023.00125.00 1023.00125.00
2 COVER ASSY. 1102.00125.00 1102.00144.00 1102.00144.00
3 HANDLE ASSY. 1000.00006.00 1000.00007.00 1000.00007.00
4 FUNNEL GASKET 1029.00014.00 1029.00016.00 1029.00016.00
5 FUNNEL ASSY. 1102.00143.00 1102.00150.00 1102.00176.00
6 TOP ASSY. 1000.00008.00 1000.00009.00 1000.00009.00
7 NECK GASKET 1024.00035.00 1024.00035.00 1024.00035.00
FAUCET UPPER ASSY.
8
1071.00020.00 1071.00020.00 1071.00020.00
(BLACK HANDLE)
FAUCET HANDLE, BLACK 1071.00022.00 1071.00022.00 1071.00022.00
9
FAUCET HANDLE, ORANGE 1071.00030.00 1071.00030.00 1071.00030.00
9
FAUCET HANDLE,GREEN 1071.00021.00 1071.00021.00 1071.00021.00
9
FAUCET HANDLE, RED ”Hot Water” 1071.00040.00 1071.00040.00 1071.00040.00
9
10 FAUCET SEAT CUP 1071.00013.00 1071.00013.00 1071.00013.00
11 FAUCET BODY ASSY. 1000.00012.00 1000.00012.00 1000.00012.00
12 FAUCET ASSY.,COMPLETE 1102.00055.00 1102.00055.00 1102.00055.00
13 FAUCET GUARD 1023.00076.00 1023.00055.00 1023.00055.00
14 FAUCET GUARD KNOB & WASHER 1000.00010.00 1000.00010.00 1000.00010.00
15 DRIP TRAY ASSY. 1000.00013.00 1000.00014.00 1000.00014.00
16 FAUCET LOCK 1023.00069.00 1023.00069.00 1023.00069.00
17 INSERT, BOTTOM 1023.00083.00 1023.00067.00 1023.00067.00
18 BOTTOM 1023.00084.00 1023.00068.00 1023.00068.00
19 STAND ASSY. 1000.00015.00 1000.00016.00 1000.00016.00
20 ANTI-SLIP FOOT 1025.00016.00 1025.00015.00 1025.00015.00
600 Rose Rd. Lake Zurich, IL 60047-0429 USA
Phone: (800) 338-2699 or (847) 719-3000
e-mail: sales@fetco.com
®
To order parts:
Fax to Customer Service - 847-719-3001
Email - parts@fetco.com.
Check prices at www.fetco.com.
May, 2012
Loading...