Fedders CH18ABD1VF, CH30ACD1VF, CH24ACD1VF, CH42ACD1VF, CH60ACZ1VF User Manual

...

Residential & Light Commercial HVAC

Split System Heat Pump

11⁄2 thru 5 Tons

208/230 Volt, 1-Phase, 60 Hz

Performance:

Efficiency rating of 13 SEER

Cooling capacities from 1

Refrigerant Circuit:

Factory installed biflow liquid line filter drier

Long life copper tubes, aluminum fins

State-of-the-art compressors

Large, wrap-around coil surface

⁄2 to 5 tons

Quality Built:

Galvanized steel exterior cabinet with 1,000-hour salt spray, powder-coated finish

Powder-coated fan guard

Full louvered panel to protect coil

Formed base with 2

Limited 5-y

ear warranty on par

⁄2" ground c

learance

Low pressure port

Integrated solid state control with adjustable

emp demand defrost

ime-t

Easy To Install:

Rated in Accordance with ARI Standard 210/240. Certification Applies Only When Used with Proper Components as Listed with ARI. Additional rating information can be found at www.aridirectory.org

Model

Number

CH18ABD1VF 11⁄2 R-22 18,000 13.5 20 32 1⁄2 X 21 1⁄2 X 21 1⁄2 24 x 24 132 / 127

CH24ACD1VF 2 R-22 24,000 16.0 25 32 1⁄2 X 29 1⁄2 X 29 1⁄2 32 x 32 195 / 186

CH30ACD1VF 21⁄2 R-22 30,000 18.8 30 32 1⁄2 X 29 1⁄2 X 29 1⁄2 32 x 32 195 / 186

CH36ACD1VF 3 R-22 36,000 20.5 35 32 1⁄2 X 29 1⁄2 X 29 1⁄2 32 x 32 197 / 188

CH42ACD1VF 31⁄2 R-22 42,000 24.8 40 32 1⁄2 X 29 1⁄2 X 29 1⁄2 32 x 32 208 / 201

CH48ACD1VF 4 R-22 48,000 27.3 45 32 1⁄2 X 29 1⁄2 X 29 1⁄2 32 x 32 212 / 203

CH60ACZ1VF 5 R-410A 60,000 38.4 60 39 X 29 1⁄2 X 29 1⁄2 32 x 32 258 / 249

Size

(tons)

Refrigerant

Nominal

BTUH

Min. Circuit

Ampacity

2Max. Fuse

eaker

or Br

tory-charged

ews to access electrical controls

e scr

y thr

Onl

Easy access to service valves

Operating Dimensions

H x W x D (inches)

Min. Mounting

Pad Size (inches)

Ship / Operating

Weight (lbs)

Product Specifications

PHYSICAL DATA

MODEL SIZE

PERFORMANCE DATA

NOMINAL CAPACITY (BTUH) 18,000 24,000 30,000 36,000 42,000 48,000 60,000

FAN DATA

FAN MOTOR TYPE PSC PSC PSC PSC PSC PSC PSC

HP 1/5 1/3 1/3 1/3 1/3 1/3 1/3

DIAMETER 18" 22" 22" 22" 22" 22" 24"

BLADE 3 3 3 3 3 3 3

RPM 1,050 1,050 1,050 1,050 1,050 1,050 950

CFM 1,800 3,400 3,400 3,400 3,400 3,400 4,000

OUTDOOR COIL

TYPE Enhanced Aluminum Plate Fin / Rifled Copper Tube

COIL FACE AREA (ft2) 12.2 18.2 18.2 18.2 18.2 18.2 22.2

O.D. 3/8" 7mm 7mm 7mm 7mm 7mm 7mm

FPI / ROWS 18 -1 18-2 18 -2 18 -2 18-3 18-3 18-3

ELECTRICAL DATA (208/230 – 1-60, VOLTAGE RANGE 197V - 253V)

MINIMUM CIRCUIT AMPACITY - MCA (amps)

MAXIMUM OVERCURRENT PROTECTIVE DEVICE - MOCP(amps)

COMPRESSOR RLA (Rated Load Amps) 10.0 11.4 13.6 15 18.4 20.9 29.4

COMPRESSOR LRA (Locked Rotor Amps) 41 56 67 73 95 109 134

FAN MOTOR FLA (Full Load Amps) 1.4 1.8 1.8 1.8 1.8 1.8 1.9

REFRIGERANT CONNECTIONS

LIQUID LINE CONNECTION SIZE (In. OD) 3/8 3/8 3/8 3/8 3/8 3/8 3/8

SUCTION LINE CONNECTION SIZE

RECOMMENDED LINE SET LIQUID TUBE DIAMETER (In. OD) 3/8 3/8 3/8 3/8 3/8 3/8 3/8

RECOMMENDED LINE SET SUCTION DIAMETER (In. OD) 3/4 3/4 7/8 7/8 7/8 1 1/8 1 1/8

FACTORY CHARGE - OZ. 103 164 154 164 207 233 233*

(In. OD)

18 24 30 36 42 48 60

13.5 16.0 18.8 20.5 24.8 27.3 38.5

20 25 30 35 40 45 50

3/4 3/4 7/8 7/8 7/8 7/8 7/8

NOTE: Control circuit is 24V on all units and requires external power source. Copper wire must be used from service disconnect to unit. ALL motors/compressors contain internal overload protection.

1. Wire size should be determined in accordance with National Electrical Codes. Extensive wire runs will require larger wire sizes.

2. Time delay fuses may be used in place of HACR circuit breaker.

* Unit uses R-410A refrigerant.

Specifications subject to change without notice.

+ 4 hidden pages