Factory Direct Hardware 10458 User Manual

Installation Instructions / Warranty

Starck

10458XX1

Axor Starck Free-Standing Tub Filler
10458XX1

Technical Specification

Maximum water pressure 145 psi
Recommended water pressure 14.5 - 72 psi
Maximum hot water temp. 176
Recommended hot water temp 120o - 140o*
Max. flow rate @ 45 psi 5.8 gpm

Rough-in 10452181 must be installed and the floor finished and made watertight before the tub
filler can be installed.

This tub filler is not anti-scald. If anti-scald capability is desired, or is required by local plumbing
codes, install remote pressure balancing valve 13418181 to the hot and cold supplies before they
go into the 10452181 rough-in.

The handshower is protected against back siphonage with a check valve, located in the hand­shower outlet on the tub filler. The check valve should be inspected and cleaned yearly.

Tub filler 10458XX1 is listed by Underwriters Laboratories.

*Please know and follow all applicable local plumbing codes when setting the temperature on the water heater

2

o

*

Installation

Turn off the water at the main.
Cut the plaster shield so that it extends 3/8" above the

surface of the finished floor.

Use an 8 mm Allen wrench (not included) to remove
the three screws from the flush housing. Remove the
flush housing. Do not disgard the screws.

plaster shield

Place the tub filler on the rough-in (1). Pivot the tub
filler so that the spout faces the correct direction (2).
Use a level to make sure that the unit is straight (3).
Install the tub filler using the three reserved screws
from the flush housing as well as the three screws
included with the tub filler -- six screws total. Tighten
them with the 8 mm Allen wrench (4)

flush housing

3

Seal the floor around the plaster shield with waterproof
sealant (1). Gently guide the escutcheon to the floor (2).

Insert the black rubber washer in one end of the hose,
and screw it to the hose outlet on the tub filler. Insert the
screen washer in the other end of the hose and screw
it to the handshower. Place the handshower in the
handshower holder.

User Instructions

Turn the left handle to obtain hot water, the right handle
to obtain cold water.

Pull the diverter to divert the water to the handshower.
When the water is turned off, the diverter will reset to the

tub filler position.

The Starck handshower uses the RubitTM self-cleaning
system. If limescale deposits are noticed in the spray
channels, they can be easily dislodged. Turn the water
on lightly, and rub across the spray channels with a finger
or a sponge.

If the flow of water from the handshower decreases over
time, remove and clean the screen washer.

A check valve is located in the handshower outlet on the
tub filler to protect against back siphonage. It should be
removed and cleaned yearly.

4

Replacement Parts

7

10

8

12

2

3

4

14

9

11

1 handle 96928XXX
2 color ring 96299000
3 handle fixing set 94184000
4 cartridge 94149000

1

5 diverter assembly 96294XXX
6 aerator 96296XXX
7 handshower 28531XXX
8 handshower holder 96295000
9 check valve 94074000
10 screen washer 94246000
11 diverter 96297000
12 handshower hose 28282XXX

5

13 diverter extension, 2 3/8” 10981XXX
14 handshower outlet 97527XXX
15 hex socket screw (set) 97670000

15

6

XXX = color
001 = chrome
811 = Satinox
821 = brushed nickel

13

5

Cleaning Recommendation for Hansgrohe Products

Modern faucetry and shower products utilize a combination of materials to comply with the needs of the
market with regard to design and functionality.

To avoid damage, it is necessary to use some caution when cleaning. Damage caused by improper treatment
is not covered under the Hansgrohe warranty.

Cleaning Materials for Faucets and Showers

• To remove lime scale, use only products made specifically for that purpose. Always follow the
manufacturer’s instructions when using.

• Do not use cleaners that contain hydrochloric, formic, acetic, or phosphoric acids, as these will cause
considerable damage to finishes and to plastic components.

• Never mix cleaning materials.

• Never use cleaners containing abrasives. Do not use abrasive cleaning cloths, pads, or sponges.

Cleaning Procedures

• Clean your faucets and shower products as and when required. Regular cleaning will prevent scale
buildup and water spotting.

• Follow the label instructions. Do not allow any cleaner to remain on the product for longer than
necessary.

• When using spray cleaners, spray first onto a sponge or cloth – do not spray directly onto the product.

• After cleaning, rinse thoroughly with clear water to remove any cleaner residue.

Important

• Soap and shampoo residue can also cause damage to the product. Rinse well with clean water after use.

• If the surface is already damaged, harsh cleaning materials will cause further damage.

Limited Lifetime Consumer Warranty

This product has been manufactured and tested to the highest quality standards by Hansgrohe, Inc. (“Hansgrohe”). This warranty is limited to
Hansgrohe products which are purchased by a consumer in the United States after March 1, 1996, and installed in either the United States or
Canada.

WHO IS COVERED BY THE WARRANTY
This warranty extends to the original consumer purchaser only.
WHAT IS COVERED BY THE WARRANTY
This warranty covers only your Hansgrohe manufactured product. Hansgrohe warrants this product against defects in material or workmanship

as follows: Hansgrohe will repair at no charge for parts only or, at its option, replace any product or part of the product which proves defective
because of improper workmanship and/or material, under normal installation, use, service and maintenance. If Hansgrohe is unable to provide a
replacement and repair is not practical or cannot be timely made, Hansgrohe may elect to refund the purchase price in exchange for the return of
the product.

LENGTH OF WARRANTY
Replacement or repaired parts of products will be covered for the term of this warranty as stated in the following two sentences. If you are a

consumer who purchased the product for use primarily for personal, family, or household purposes, this warranty extends for as long as you own
the product and the home in which the product is installed. If you purchased the product for use primarily for any other purpose, including, without
limitation, a commercial purpose, this warranty extends only (i) for 1 year, with respect to Interaktiv and Retroaktiv products, and (ii) for 5 years,
with respect to AXOR, ShowerPower and Pharo products.

6

THIS WARRANTY DOES NOT COVER, AND HANSGROHE WILL NOT PAY FOR:
A. Conditions, malfunctions or damage not resulting from defects in material or workmanship.
B. Conditions, malfunctions or damage resulting from (1) improper installation, improper maintenance, misuse, abuse, negligence, accident

or alteration, or (2) the use of abrasive or caustic cleaning agents or “no rinse” cleaning products, or the use of the product in any manner
contrary to the product instructions.

C. Labor or other expenses for the disconnection or return of the product for warranty service, or for installation or reinstallation of the product.
D. Accessories or related products not manufactured by Hansgrohe.

TO OBTAIN WARRANTY SERVICE
Contact your Hansgrohe retailer, or write to Technical Service at:
Hansgrohe Inc.

1492 Bluegrass Lakes Parkway
Alpharetta GA 30004

Or, call Hansgrohe toll-free at [phone].
In requesting warranty service, you will need to provide

1. The sales receipt or other evidence of the date and place of purchase.

2. A description of the problem.

3. Delivery of the product or the defective part, postage prepaid and carefully packed and insured, to Hansgrohe Inc. 1492 Bluegrass Lakes
Parkway, Alpharetta, Georgia 30004, Attention: Technical Service, if required by Hansgrohe.

When warranty service is completed, any repaired or replacement product or part will be returned to you postage prepaid.
EXCLUSIONS AND LIMITATIONS
REPAIR OR REPLACEMENT (OR, IN LIMITED CIRCUMSTANCES, REFUND OF THE PURCHASE PRICE) AS PROVIDED UNDER THIS WARRANTY IS

THE EXCLUSIVE REMEDY OF THE PURCHASER. HANSGROHE NEITHER ASSUMES NOR AUTHORIZES ANY PERSON TO CREATE FOR IT ANY
OBLIGATION OR LIABILITY IN CONNECTION WITH THIS PRODUCT.

HANSGROHE SHALL NOT BE LIABLE TO PURCHASER OR ANY PERSON FOR ANY INCIDENTAL, SPECIAL, OR CONSEQUENTIAL DAMAGES,
ARISING OUT OF BREACH OF THIS WARRANTY OR ANY IMPLIED WARRANTY (INCLUDING MERCHANTABILITY).

Some States do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to
you.

This warranty gives you specific legal rights, and you may have other rights which vary from State to State.
You may be required by law to give us a reasonable opportunity to correct or cure any failure to comply before you can bring any action in court

against us under the Magnuson-Moss Warranty Act.
PRODUCT INSTRUCTIONS AND QUESTIONS
Upon purchase or prior to installation, please carefully inspect your Hansgrohe product for any damage or visible defect. Prior to installing, always

carefully study the enclosed instructions on the proper installation and the care and maintenance of the product. If you have questions at any time
about the use, installation, or performance of your Hansgrohe product, or this warranty, please call or write to us at the toll-free number and address
printed above.

7

Hansgrohe, Inc. • 1490 Bluegrass Lakes Parkway • Alpharetta, GA 30004

Tel. [phone] • Fax [phone]

www.hansgrohe-USA.com

US - Installation Instructions • Part No. • Revised 07/2006