E-Z-GO RXV GOLF CAR, RXV FREEDOM, RXV SHUTTLE 2 plus 2, RXV FLEET, FREEDOM Owner's Manual

REVISED

JUNE 2012

ISSUED

FEBRUARY 2009

SAFETY

NOTICE

DANGER

For any questions on material contained in this manual, contact an authorized representative for clarification.

Read and understand all labels located on the vehicle. Always replace any damaged or missing labels.

On steep hills it is possible for vehicles to coast at greater than normal speeds encountered on a flat surface. To prevent
loss of vehicle control and possible serious injury, speeds should be limited to no more than the maximum speed on level
ground. See GENERAL SPECIFICATIONS. Limit speed by applying the service brake.

Catastrophic damage to the drivetrain components due to excessive speed may result from driving the vehicle above
specified speed. Damage caused by excessive speed may cause a loss of vehicle control, is costly, is considered abuse
and will not be covered under warranty.

Use extra caution when towing the vehicle(s). Do not tow a single vehicle at speeds in excess of 12 mph (19 kph). Do not
tow more than three vehicles at a time. Do not exceed 5 mph (8 kph) while towing multiple vehicles. Towing the vehicle at
above the recommended speed may result in personal injury and/or damage to the vehicle and other property. Vehicles
equipped with the AC Drive motor must be towed with the Run-Tow switch, located under the passenger seat, in the ‘Tow’
position.

If the vehicle is to be used in a commercial environment, signs similar to the ones illustrated should be used to warn of sit­uations that could result in an unsafe condition

BATTERY WARNING

Battery posts,

terminals and related

accessories contain

lead and lead compounds,

chemicals known

to cause cancer and

reproductive harm.

WASH HANDS

AFTER HANDLING!

BATTERIES

AND RELATED PARTS

CONTAIN LEAD

WASH HANDS

AFTER HANDLING!

WARNING: Battery posts, terminals and related
accessories contain lead and lead compounds,

chemicals known to cause cancer and reproductive harm.

!

<

14

˚

25

%

DO NOT

DRIVE ACROSS

SLOPES IN

EXCESS OF 14˚

Observe these NOTICES, CAUTIONS, WARNINGS and DANGERS; be aware that servicing a vehicle requires mechan­ical skill and a regard for conditions that could be hazardous. Improper service or repair may damage the vehicle or ren­der it unsafe.

NOTES, CAUTIONS, WARNINGS AND DANGERS

Address practices not related to personal injury.

Indicates a hazardous situation which, if not avoided,
could result in minor or moderate injury.

Indicates a hazardous situation which, if not
avoided, could result in death or serious injury.

Indicates a hazardous situation which, if
not avoided, will result in death or serious
injury.

Please observe these NOTES, CAUTIONS and WARN­INGS; be aware that servicing a vehicle requires mechan-

ical skill and a regard for conditions that could be
hazardous. Improper service or repair may damage the
vehicle or render it unsafe.

Battery posts, terminals and related accesso­ries contain lead and lead compounds. Wash
hands after handling.

(NOTES, CAUTIONS, WARNINGS AND DANGERS CONTINUED ON INSIDE OF BACK COVER)

OWNER’S GUIDE

ELECTRIC POWERED

FLEET & PERSONAL GOLF CARS

RXV GOLF CAR

RXV FREEDOM™

RXV SHUTTLE 2 + 2

STARTING MID-MODEL YEAR 2009

(MANUFACTURED BEGINNING FEBRUARY 23, 2009)

E-Z-GO Division of TEXTRON Inc. reserves the right to incorporate engineering and design changes to products in this Manual, without obligation to include
these changes on units leased/sold previously.

The information contained in this Manual may be revised pe ri odically by the E-Z-GO Division, and therefore is subject to change without notice.
The E-Z-GO Division DISCLAIMS LIABILITY FOR ERRORS IN THIS MANUAL, and the E-Z-GO Division SPECIFICALLY DISCLAIMS LIABILITY FOR INCI-

DENTAL AND CONSEQUENTIAL DAMAGES resulting from the use of the information and materi als in this Manual.
These are the original instructions as defined by 2006/42/EC.

TO CONTACT US
NORTH AMERICA:

TECHNICAL ASSISTANCE & WARRANTY PHONE: [phone], FAX: [phone]
SERVICE PARTS PHONE: 1-888-GET-EZGO (1-888-438-3946), FAX: [phone]

INTERNATIONAL:
SALES PHONE: [phone], FAX: [phone]

E-Z-GO DIVISION OF TEXTRON INC., 1451 MARVIN GRIFFIN ROAD, AUGUSTA, GEORGIA USA 30906-3852

Owner’s Guide

Page i

GENERAL INFORMATION

This vehicle has been designed and manufactured in the Unit ed States of Ameri ca (USA ) as

a ‘World Vehicle’. The Standards and Specifications listed in the following text originate in

the USA unless otherwise indicated.

The use of non Original Equipment Manufacturer (OEM) approved parts may void the

warranty.

Overfilling batteries may void the warranty.

BATTERY PROLONGED STORAGE

All batteries will self discharge over time. The rate of se lf discharge v aries depending on the

ambient temperature and the age and condition of the batteries.

A fully charged battery will not freeze in winter temperatures unless the temperature falls

below -75° F (-60° C).

For winter storage, the batteries must be clean, fully charged and disconnected from any

source of electrical drain.

On all electric vehicles, set the key switch to ‘OFF’. Make sure that the ‘RUN/TOW’ switch,

located under the passenger seat, is set to the ‘RUN/STORAGE’ position; if the switch is left

in the ‘TOW’ position, it will drain the batteries.

As with all electric vehi cles, the ba tteries must be checked a nd recharged as requir ed or at a

minimum of 30 day intervals.

Page ii

Owner’s Guide

TABLE OF CONTENTS

SECTION TITLE PAGE NO.

SAFETY .................................................................................................... Inside Covers

GENERAL INFORMATION ............................................................................................ ii

SAFETY INFORMATION ................................................................................................ v

LABELS AND PICTOGRAMS ...................................................................................... ix

SERIAL NUMBER LOCATION ...................................................................................... 1

BEFORE INITIAL USE....................................................................................................1

PORTABLE CHARGER..................................................................................................2

PORTABLE CHARGER INSTALLATION ...............................................................2

USING THE CHARGER......................................................................................... 3

UNDERSTANDING THE CHARGER .....................................................................3

LED OPERATION CODES.....................................................................................4

LED FAULT CODES ..............................................................................................4

MAINTENANCE INSTRUCTIONS..........................................................................4

CONTROLS AND INDICATORS.................................................................................... 5

KEY SWITCH/DIRECTION SELECTOR ................................................................5

SPEEDOMETER/STATE OF CHARGE METER .................................................... 5

HEADLIGHT SWITCH............................................................................................ 6

TURN SIGNAL SWITCH ........................................................................................6

HORN ....................................................................................................................6

ACCELERATOR & BRAKE PEDALS ..................................................................... 6

PARKING BRAKE.................................................................................................. 6

RUN/TOW SWITCH ............................................................................................... 6

OPERATING THE VEHICLE.......................................................................................... 7

REGENERATIVE BRAKING ..................................................................................7

PEDAL-UP BRAKING ............................................................................................8

HIGH PEDAL DISABLE FEATURE ........................................................................8

STARTING AND DRIVING.....................................................................................8

STARTING VEHICLE ON A HILL........................................................................... 8

COASTING ............................................................................................................ 8

LABELS AND PICTOGRAMS ................................................................................8

SUN TOP AND WINDSHIELD ............................................................................... 8

VEHICLE CLEANING & CARE.......................................................................................8

VEHICLE CLEANING............................................................................................. 8

REPAIR...........................................................................................................................9

LIFTING THE VEHICLE ......................................................................................... 9

WHEELS AND TIRES ................................................................................................... 10

TIRE REPAIR....................................................................................................... 10

WHEEL INSTALLATION ......................................................................................11

LIGHT BULB REPLACEMENT.....................................................................................11

HEAD LIGHT BULB REPLACEMENT ..................................................................11

TURN SIGNAL BULB REPLACEMENT ............................................................... 12

TAILLIGHT/BRAKE LIGHT BULB REPLACEMENT............................................. 12

Owner’s Guide

Page iii

TABLE OF CONTENTS

SECTION TITLE PAGE NO.

TRANSPORTING THE VEHICLE ................................................................................. 12

TOWING.............................................................................................................. 12

HAULING............................................................................................................. 13

SERVICE AND MAINTENANCE .................................................................................. 13

ROUTINE MAINTENANCE.................................................................................. 14

TIRE INSPECTION.............................................................................................. 14

REAR AXLE ........................................................................................................ 14

HARDWARE........................................................................................................ 14

CAPACITIES AND REPLACEMENT PARTS....................................................... 15

PERIODIC SERVICE SCHEDULE....................................................................... 16

BATTERIES AND CHARGING..................................................................................... 17

SAFETY............................................................................................................... 17

BATTERY ............................................................................................................ 17

BATTERY MAINTENANCE .......................................................................................... 18

AT EACH CHARGING CYCLE ............................................................................ 18

MONTHLY ........................................................................................................... 18

ELECTROLYTE LEVEL AND WATER................................................................. 19

CLEANING BATTERIES

BATTERY REMOVAL & INSTALLATION .................................................................... 20

PROLONGED STORAGE ............................................................................................ 22

BATTERY CHARGING................................................................................................. 23

TROUBLESHOOTING.................................................................................................. 23

HYDROMETER ................................................................................................... 23

USING A HYDROMETER.................................................................................... 24

GENERAL SPECIFICATIONS...................................................................................... 27

RXV ELECTRIC - FLEET VEHICLE SPECIFICATIONS ...................................... 28

RXV ELECTRIC - FREEDOM VEHICLE SPECIFICATIONS ............................... 29

RXV ELECTRIC - SHUTTLE 2 + 2 VEHICLE SPECIFICATIONS........................ 30

DECLARATION OF CONFORMITY (EUROPE ONLY) ................................................ 35

Page iv

Owner’s Guide

SAFETY INFORMATION

Read all of manual to become familiar with vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

This manual has been designed to assist in maintaining the vehicle in accordance with procedures developed by the
manufacturer. Adherence to these procedures and troubleshooting tips will ensure the best possible service from the
product. To reduce the chance of personal injury or property damage, the following must be carefully observed:

Certain replacement parts can be used independently and/or in combination with other accessories to modify an
E-Z-GO-manufactured vehicle to permit the vehicle to operate at or in excess of 20 mph. When an E-Z-GO-manu­factured vehicle is modified an any way by the Distributor, Dealer or customer to operate at or in excess of 20mph,
UNDER FEDERAL LAW the modified product will be a Low Speed Vehicle (LSV) subject to the strictures and
requirements of Federal Motor Vehicle Safety Standard 571.500. In these instances, pursuant to Federal law the
Distributor or Dealer MUST equip the product with headlights, rear lights, turn signals, seat belts, top, horn and all
other modifications for LSV’s mandated in FMVSS 571.500, and affix a Vehicle Identification Number to the product
in accordance with the requirements of FMVSS 571.565. Pursuant to FMVSS 571.500, and in accordance with the
State laws applicable in the places of sale and use of the product, the Distributor, Dealer or customer modifying the
vehicle also will be the Final Vehicle Manufacturer for the LSV, and required to title or register the vehicle as man­dated by State law.

E-Z-GO will NOT approve Distributor, Dealer or customer modifications converting E-Z-GO products into LSV’s.
The Company recommends that all E-Z-GO products sold as personal transportation vehicles BE OPERATED ONLY

BY PERSONS WITH VALID DRIVERS LICENSES, AND IN ACCORDANCE WITH APPLICABLE STATE REQUIRE­MENTS. This restriction is important to the SAFE USE AND OPERATION of the product.

All customers should adhere to this SAFETY RESTRICTION, in connection with the use of all E-Z-GO products, new
and used, the Distributor or Dealer has reason to believe may be operated in personal transportation applications.

Information on FMVSS 571.500 can be obtained at Title 49 of the Code of Federal Regulations, section 571.500, or
through the Internet at the website for the U.S. Department of Transportation - at Dockets and Regulation, then to Title
49 of the Code of Federal Regulations (Transportation)

B

B

GENERAL

All vehicles can be used for a variety of tasks beyond the original intended use of the vehicle; therefore, it is impossi­ble to anticipate and warn against every possible combination of circumstances that may occur. No warning can take
replace good common sense and prudent driving practices.

Good common sense and prudent driving practices do more to prevent accidents and injury than all of the warnings
and instructions combined. E-Z-GO strongly suggests that all users and maintenance personnel read this entire man­ual paying particular attention to the CAUTIONS, WARNINGS and DANGERS contained therein.

If you have any questions regarding this vehicle, contact your E-Z-GO dealer or write to the address on the back cover
of this publication, Attention: Customer Care Department.

E-Z-GO reserves the right to make design changes without obligation to make these changes on units previously sold.
The information contained in this manual is subject to change without notice.

E-Z-GO IS NOT LIABLE FOR ERRORS IN THIS MANUAL . E-Z-G O IS NOT LIABLE FO R INCIDENTAL OR CONSE­QUENTIAL DAMAGES THAT RESULT FROM THE USE OF THE MATERIAL IN THIS MANUAL.

This vehicle conforms to the current applicable standard(s) for safety and performance requirements.
These vehicles are designed and manufactured for off-road use. They DO NOT conform to Federal Motor Vehicle

Safety Standards of the United States of America (USA) and are not equipped for operation on public streets. Some
communities may permit these vehicles to be operated on their streets on a limited basis and in accordance with local
ordinances.

With electric powered vehicles, be sure that all electrical accessories are grounded directly to the battery (-) post.

Never use the chassis or body as a ground connection.

Refer to GENERAL SPECIFICATIONS for vehicle seating capacity.

Owner’s Guide

Page v

SAFETY INFORMATION

Read all of manual to become familiar with vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

Never modify the vehicle in any way that will alter the weight distribution of the vehicle, decrease its stability
or increase the speed or extend the stopping distance beyond the factory specifi cation. Such modificat ions
can result in serious personal injury or death.

B

Do not make any such modifications or changes. E-Z-GO prohibits and disclaims responsibility for all such modifica­tions or and alterations which would adversely affect the safety of the vehicle.

Vehicles that are capable of higher speeds must limit their speed to no more than the speed of other vehicles when
used in a golf course environment. Additionally, speed should be further moderated by the environmental conditions,
terrain and common sense.

Operation of the vehicle is limited to persons above the height of 59 inches (150 cm).

GENERAL OPERATION

ALWAYS:

• use the vehicle in a responsible manner and maintain the vehicle in safe operating condition

• read and observe all warnings and operation instruction labels affixed to the vehicle

• follow all safety rules established in the area where the vehicle is being operated

• leave the vehicle when there is a risk of lightning

• reduce speed to compensate for poor terrain or conditions

• apply service brake to control speed on steep grades

• maintain adequate distance between vehicles

• maintain adequate distance between vehicles

• reduce speed in wet areas

• use extreme caution when approaching sharp or blind turns

• use extreme caution when driving over loose terrain

• use extreme caution in areas where pedestrians are present

MAINTENANCE

ALWAYS:

• replace damaged or missing warning, caution or information labels

• maintain the vehicle in accordance with the manufacturer’s periodic service schedule

• ensure that repairs are performed by trained and qualified personnel

• follow the manufacturer’s maintenance procedures

• insulate any tools used within the battery area in order to prevent sparks or battery explosion

• check the polarity of each battery terminal and be sure to rewire the batteries correctly

• use specified replacement parts, NEVER use replacement parts of lesser quality

• use recommended tools

• determine that tools and procedures not specifically recommended by the manufacturer will not compromise the
safety of personnel nor jeopardize the safe operation of the vehicle

• support the vehicle using wheel chocks and jack stands, NEVER get under a vehicle that is supported by a jack, lift
the vehicle in accordance with the manufacturer’s instructions

• maintain the vehicle in an area away from exposed flame or persons who are smoking

• be aware that a vehicle that is not performing as designed is a potential hazard and must not be operated

• test drive the vehicle after any repairs or maintenance in a safe area that is free of both vehicular and pedestrian
traffic

• keep complete records of the maintenance history of the vehicle

Page vi

Owner’s Guide

SAFETY INFORMATION

Read all of manual to become familiar with vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

The manufacturer cannot anticipate all situations, therefore people attempting to maintain or repair the vehicle must
have the skill and experience to recognize and protect themselves from potential situations that could result in severe
personal injury or death and damage to the vehicle. Use extreme caution and, if unsure as to the potential for injury,
refer the repair or maintenance to a qualified mechanic.

VENTILATION

Hydrogen gas is generated in the charging cycle of batteries and is explosive in concentrations as low as 4%.
Because hydrogen gas is lighter than air, it will collect in the ceiling of buildings necessitating proper ventilation. Five
air exchanges per hour is considered the minimum requirement.

NEVER charge a vehicle in an area that is subject to flame or spark. Pay particular attention to natural gas or propane
water heaters and furnaces.

Always use a dedicated circuit for each battery charger. Do not permit other appliances to be plugged into the recepta­cle when the charger is in operation.

Chargers must be installed and operated in accordance with charger manufacturers recommendations or applicable
electrical code (whichever is higher).

B

B

Owner’s Guide

Page vii

SAFETY INFORMATION

Read all of manual to become familiar with vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

Notes:

Page viii

Owner’s Guide

LABELS & PICTOGRAMS

Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

LABELS & PICTOGRAMS

B

B

Owner’s Guide

Page ix

LABELS & PICTOGRAMS

608522 FLEET VEHICLES

608528

608529

608522

Except where PERMITTED BY LAW:

To be operated by persons with valid drivers license, in accordance with state requirements. Operate from Driver’s side only.

Reduce the RISK OF ACCIDENTS:

For non-road use, and in designated areas only. Do not operate under the influence of drugs or alcohol.

AVOID FALLS from the vehicle:

All occupants must be fully seated, keep entire body inside vehicle and hold on while vehicle is in motion.

STARTING the vehicle:

Apply service brake , move direction selector to desired position and accelerate smoothly. On Gas Vehicle, direction selector is
the F-N-R. On Electric vehicle, direction selector is the key switch.

DO NOT OVERLOAD this vehicle:

Maximum vehicle payload is 800 lbs. (363 kg) including a maximum of 2 persons, options, and accessories.

Drive with CAUTION:

Drive slowly straight up and down slopes and in turns. Use care in reverse, congested areas, and wet or loose terrain.

STOPPING the vehicle:

To stop, release accelerator pedal and apply service brake.

PARKING the vehicle:

Before leaving vehicle , turn key ‘OFF’. On Gas vehicle, move the direction selector to “FORWARD” and engage park brake.

Failure to follow these instructions can result in SERIOUS INJURY or DEATH

608528

Failure to follow these instructions can result in SERIOUS INJURY or DEATH

Except where PERMITTED BY LAW:

NEVER drive on public roads. Drivers must possess a valid drivers license in accordance with local state law.

AVOID FALLS from the vehicle:

Do not start moving until all occupants are PROPERLY SEATED and HOLDING ON. KEEP entire body INSIDE VEHICLE while moving.

Reduce the RISK OF ACCIDENTS:

Always DRIVE SLOWLY in congested areas, on wet or loose terrain, and when backing up. DRIVE SLOWLY when turning and

AVOID sudden stops.
ALWAYS drive straight up and down slopes. Do not coast, use BRAKE when going down a slope. NEVER drive this vehicle under the influence
of drugs or alcohol.

This vehicle is NOT A TOY:

Drive responsibly. NEVER leave children unattended or allow children to play on the vehicle. NEVER leave the key in the vehicle when parked.

DO NOT OVERLOAD this vehicle:

NEVER carry more than 2 occupants on each bench seat. Do not exceed vehicle WEIGHT CAPACIT Y (see Owner’s Manual).

DO NOT MODIFY this vehicle:

NEVER alter this vehicle to increase travel speeds above factory specifications. ONLY authorized E-Z-GO dealers should alter the vehicle using
approved parts. Alterations not approved or tested by E-Z-GO can create unsafe conditions and increase your chance of having an accident.

BEFORE OPERATING

READ all warning labels and the owner’s manual. Contact an authorized E-Z-GO dealer or visit
www.ezgo.com for a replacement manual.

This vehicle is equipped for personal use in most communities. However, state law or local rules may
require additional equipment in your community.

SAFE OPERATION

Turn key to “ON” - select “forward” or “reverse” - release the parking brake (Gas vehicle only) - then slowly
depress accelerator pedal.

Always bring the vehicle to a complete stop BEFORE shifting the direction selector.

Operate from the driver’s seat ONLY.

PARKING

ALWAYS fully engage the parking brake and remove the key BEFORE leaving the vehicle. In an electric
vehicle set the direction selector to “neutral” and in a gasoline vehicle set the selector to “forward”.

MAINTENANCE

This vehicle requires regularly scheduled maintenance (see owner’s manual). ONLY qualified
personnel should service this vehicle.

OPERATING INSTRUCTIONS

608529

74443G01

!

1. To Prevent Roll-Back

On a Hill From a
Stopped Position

3. Fully

Release
Park Brake

2. Apply Service

Brake With
Left Foot

4. Depress Accelerator While

Releasing Service Brake As
Vehicle Starts

74443G01

Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

B

Page x

Owner’s Guide

LABELS & PICTOGRAMS

WARNING

Windshields do not
provide protection
from golf balls or
other flying objects.

EGWHL14

609987

609694

Failure to follow these instructions can result in SERIOUS INJURY or DEATH

THIS PROCEDURE SHOULD ONLY BE TO CLEAR VEHICLE FROM AN UNSAFE AREA AND BE PERFORMED
ONLY BY QUALIFIED TRAINED PERSONNEL
In Case Of Total Power Loss And The ‘Run-tow’ Switch DOES NOT Release The Brake To Move The Vehicle:

Turn the ignition key to the ‘OFF’ position and ‘chock’ tires to prevent inadvertent movement.

Connect ‘Auxiliary Power’ line (3) to ‘Primary Power’ line (1) which will release the brake. THIS WILL
CAUSE THE VEHICLE TO MOVE IMMEDIATELY IF NOT ON LEVEL GROUND.
Move vehicle to desired location and park it properly on level ground, chock tires, IMMEDIATELY
DISCONNECT ‘AUXILIARY POWER’ AND RECONNECT ‘PRIMARY POWER’ (1, 2) FOR SAFETY
AND TO AVOID BATTERY DRAIN.
Reconnect the Weather Pack Seal (4) to the Auxiliary Power line (3) and perform required service
procedures following all Safety guidelines as outlined in your repair manual.

Identify the ‘Auxiliary Power’ line (3) and remove the Weather Pack Seal (4) from the connector.
Identify the ‘Primary Power’ line (1) connector and disconnect the line (2).

609694

612594

This device is ONLY to be used for towing E-Z-GO vehicles. NEVER tow other vehicles or equipment.
READ Owner’s Manual before towing. NO RIDERS in towed cars.

NEVER tow more than 3 vehicles at one time. Max speed towing 2 or 3 vehicles is 5 mph. Max speed
towing 1 vehicle is 12 mph.

MONTHLY INSPECTION: tow bar pins, attaching hardware, and front frame attachment of towed cars.
Replace worn or damaged parts. CHECK alignment of wheels on towed cars.

FULLY ENGAGE coupling. Rubber latch-stop must be under latch release lever.

611716

DRIVE SLOWLY, it is not recommended to tow vehicle over rough or unsafe terrain or on grades
greater than 10%.

611716

DO NOT alter or tamper with this unit. Unauthorized modifications can result in
SERIOUS INJURY or damage to the vehicle and will void the warranty.

WAIT 30 seconds after reconnecting batteries BEFORE turning key switch to
‘REVERSE’, ‘FORWARD’ or ‘NEUTRAL’ positions.

TOWING - Always select ‘TOW’
position before towing

612594

To disable electrical system, turn key switch to ‘OFF’ and remove battery wires.

ALWAYS turn key to ‘OFF’ before disconnecting or reconnecting
battery wires. ELECTRICAL ARC or BATTERY EXPLOSION can
occur if key is not in the ‘OFF’ position.

STORAGE

Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

B

B

Owner’s Guide

Page xi

LABELS & PICTOGRAMS

FAILURE TO FOLLOW THESE INSTRUCTIONS
MAY RESULT IN SEVERE PERSONAL INJURY.

AVOID FALLS from the vehicle and other SERIOUS INJURIES:

Never attempt to enter or exit a moving vehicle.

KEEP feet, legs, hands, and arms inside the vehicle at all times.
NEVER leave children unattended. Children may need

assistance to remain properly seated and holding on.

AVOID standing in front of, or behind vehicle.

ONLY 2 occupants per seat.

Always remain PROPERLY SEATED and HOLDING ON.

608537

:

608537

Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

B

Page xii

Owner’s Guide

LABELS & PICTOGRAMS

Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

Notes:

Owner’s Guide

Page xiii

LABELS & PICTOGRAMS

614043 CE VEHICLES

608818

608818

< 14° 25%

< 14° 25%

cm

MIN 150

ON

N

F

R

OFF

O

R F

ON

OFF

I

O

R

F

ON

OFF

I

O

ON

N

F

R

OFF

O

614043

F

R

OFF

O

ON

N

ON

OFF

I

O

R F

MAXIMUM RAMP
OR HILL

MAXIMUM CROSS
RAMP OR HILL

OPERATE FROM
DRIVER SIDE ONLY

DO NOT STAND UP
AND KEEP ENTIRE
BODY INSIDE VEHICLE

MINIMUM HEIGHT TO
OPERATE VEHICLE IS
150 CM

DO NOT DRIVE
ON HIGHWAY

DO NOT OPERATE
IF USING DRUGS
OR ALCOHOL

DO NOT OPERATE
VEHICLE WHEN
LIGHTNING IS
IN THE AREA

READ THE MANUAL

OPERATE ACCORDING
TO LOCAL LAWS AND
REGULATIONS

USE CAUTION IN
BAD WEATHER

FORWARD OPERATION
* TURN KEY TO ‘ON’
* MOVE DIRECTION
SELECTOR TO ‘F’
* PRESS ACCELERATOR
PEDAL GENTLY

REVERSE OPERATION
* TURN KEY TO ‘ON’
* MOVE DIRECTION
SELECTOR TO ‘R’
* PRESS ACCELERATOR
PEDAL GENTLTY

PARK VEHICLE
* MOVE DIRECTION
SELECTOR TO ‘F’
* TURN KEY TO ‘OFF’
* APPLY PARKING
BRAKE

GASOLINE
VEHICLES

FORWARD OPERATION
* TURN KEY TO ‘F’
* PRESS ACCELERATOR
PEDAL GENTLY

REVERSE OPERATION
* TURN KEY TO ‘R’
* GENTLY PRESS
ACCELERATOR
PEDAL

PARK VEHICLE
* TURN KEY
TO ‘OFF’

ELECTRIC
VEHICLES

WARNING:
SHORTING ACROSS
TERMINALS MAY CAUSE
BATTERY EXPLOSION

READ THE
MANUAL
REPLACEMENT
AVAILABLE AT
www.ezgo.com

WARNING:
NEGATIVE GROUND
ELECTRICAL SYSTEM

Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

B

Page xiv

Owner’s Guide

LABELS & PICTOGRAMS

614044

614044

NO

N

F

R

FFO

O

NO

F

R

FFO

O

N

NO

FFO

I

O

R F

R F

NO

FFO

I

O

NO

N

F

R

FFO

O

R

F

NO

FFO

I

O

P

www.ezgo.com

www.ezgo.com

cm

150

WARNING READ THE MANUAL

REPLACEMENT
IS AVAILABLE AT
www.ezgo.com

READ ALL
LABELS

OPERATE
FROM
DRIVER
SIDE
ONLY

OPERATE
ACCORDING
TO LOCAL
LAWS AND
REGULATIONS

MAINTAIN
ACCORDING
TO SERVICE &
REPAIR MANUAL
AVAILABLE AT
www.ezgo.com

FORWARD OPERATION
* TURN KEY TO ‘ON’
* MOVE DIRECTION
SELECTOR TO ‘F’
* PRESS ACCELERATOR
PEDAL GENTLY

REVERSE OPERATION
* TURN KEY TO ‘ON’
* MOVE DIRECTION
SELECTOR TO ‘R’
* PRESS ACCELERATOR
PEDAL GENTLTY

PARK VEHICLE
* MOVE DIRECTION
SELECTOR TO ‘F’
* TURN KEY TO ‘OFF’
* APPLY PARKING BRAKE

GASOLINE
VEHICLES

FORWARD OPERATION
* TURN KEY TO ‘F’
* PRESS ACCELERATOR
PEDAL GENTLY

REVERSE OPERATION
* TURN KEY TO ‘R’
* PRESS ACCELERATOR
PEDAL GENTLY

PARK VEHICLE
* TURN KEY TO ‘OFF’

ELECTRIC
VEHICLES

MINIMUM HEIGHT TO
OPERATE VEHICLE IS
150 CM

DO NOT OPERATE
VEHICLE WHEN
LIGHTNING IS
IN THE AREA

Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

B

B

Owner’s Guide

Page xv

LABELS & PICTOGRAMS

610991

612214

608769

610990

610991

DO NOT TOW MORE THAN 3 VEHICLES MAX 12 mph (19 kph) TOWING 1 VEHICLE
DO NOT DRIVE IN REVERSE WHEN TOWING VEHICLES MAX 5 mph (8 kph) TOWING 2 or 3 VEHICLES
NO PASSENGERS IN TOWED VEHICLES
DO NOT TOW VEHICLES OVER UNEVEN TERRAIN 10% MAX SLOPE FOR TOWING VEHICLES

READ THE
MANUAL
REPLACEMENT
AVAILABLE AT
www.ezgo.com

WARNING
ENGAGE
LOCKING
COLLAR

WARNING
READ THE
MANUAL

CHOCK
THE
WHEELS

UNPLUG
1 FROM 2
AND
3 FROM 4

PLUG
1 INTO 3

PLUG
1 INTO 2
AND
3 INTO 4

CHOCK
THE
WHEELS

MOVE THE
VEHICLE

IF THE
VEHICLE
WILL NOT
MOVE

WARNING
READ THE
MANUAL

WARNING
DO NOT
DRIVE
FAST

WARNING INSPECT TOW BAR
SYSTEM EVERY 30 DAYS

TOW BAR OPERATION
* PULL LOCKING COLLAR AWAY
FROM LATCH AND PRESS ON
LATCH TAB TO OPEN
* PLACE LATCH OVER FRONT
TOWING BRACKET
* CLOSE LATCH AND MOVE
LOCKING COLLAR UNDER
LATCH TAB
* DO NOT TOW MORE THAN
3 VEHICLES
* 12 mph (19 kph) MAX SPEED
TOWING 1 VEHICLE
* DO NOT DRIVE IN REVERSE
WHEN TOWING VEHICLES
* NO PASSENGERS IN TOWED
VEHICLES
* DO NOT TOW VEHICLES OVER
UNEVEN TERRAIN 10% MAXIMUM
SLOPE FOR TOWING VEHICLES

612214

MAX

5 mph

(8 kph)

+

MAX
12 mph
(19 kph)

MAX
10%

1

2

3

4

1

2

3

4

1

2

3

4

610990

608769

F

R

OFF

O

ON

N

WARNING: ATTACH TOW BAR BEFORE
TURNING KEY SWITCH TO ‘TOW’

KEEP
HANDS
OUT

READ THE
MANUAL
REPLACEMENT
AVAILABLE AT
www.ezgo.com

TO REDUCE POSSIBILITY OF
BATTERY EXPLOSION TURN
KEY TO ‘OFF’ BEFORE
DISCONNECTING OR CONNECTING
BATTERY WIRES

Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.

B

Page xvi

Owner’s Guide