Extron Electronics RGB 580xi AAP Setup Guide

Setup Guide — RGB 580xi AAP

Pin 1

and RGB 580xi CC AAP Series

This guide provides basic instructions for an experienced
installer to set up and operate the Extron RGB 580xi AAP
and RGB 580xi CC AAP.

Installation

The AAP device should be cabled before attaching the AAP
device to a faceplate or wall plate.

C

Step 1 — Power down

Turn off or disconnect all equipment from power sources.

Step 2 — Connect the rear panel cables

Connect the cables to the AAP device’s rear connectors.

N

Installation and service must be performed by authorized personnel only.

Although the control cable, LED, and audio assemblies come prewired to the captive screw

connectors, any subsequent cable assembly replacement requires the following instructions.

3

Black
White

Red

Yellow

Pink

Orange

Green
Gray
Brown

Lt. Blue
Purple

1

2

Example of AAP device rear connectors

J4 J2

1 2

Example of Cable Cubby AAP device rear connectors

To cable the captive screw connectors, refer to the following diagrams and orient the wires
according to the view angle of the captive screws. Use the Extron VGA and control cable
assembly and refer to the color of each wire for signal identification.

Control connector (J4) — This connector is used for contact closure and horizontal shift

a

signals. Wire the appropriate connector as shown below.

Horizontal shift + (green)

Horizontal shift ground (gray)

Horizontal shift

Contact closure

Contact closure

– (brown)

+ (light blue)

– (purple)

Horizontal shift + (green)

Horizontal shift ground (gray)

Horizontal shift

Contact closure

+ (light blue)

Contact closure

– (brown)

– (purple)

Pin 1

(Continued on reverse side.)

Setup Guide — RGB 580xi AAP and CC AAP Series

A

LED connector (J2) — This connector is used for powering the green/amber LED. Wire

b

the appropriate connector as shown below.

Green LED (pink)

LED ground (yellow)

Amber LED (orange)

Audio output connector — This connector is used for unbalanced stereo

c

audio output. Wire the connector as shown below.

Audio right (red)

udio ground (black)

Audio right (white)

Pin 1

Pin 1

Green LED (pink)

LED ground (yellow)

Amber LED (orange)

Step 3 — Audio connect

Wire a 3.5 mm stereo plug for unbalanced audio input
as shown at right.

Step 4 — Mount the AAP

Insert the AAP device’s screws through the holes in the AAP double-space faceplate, the AAP
wall plate, or the Cable Cubby AAP shelf bracket. Secure the AAP device to the faceplate/wall
plate/shelf bracket with the provided captive washers and #4-40 nuts. See the examples below.

Pin 1

Tip (L)

Ring (R)

Sleeve ( )

RGB 580xi CCSI AAP

Operation

Extron USA - We st

Headqua rters

+800.6 33.9876

Inside USA / Canada Only

+1.714.491.1500
+1.714.491.1517 FAX

Cable
Clamp

#4-40 Nut w/ Captive
Washer

AAP 102

AAP 102

Wall Plate

Cable

AUDIO

COMPUTER

INPUT
SELECT

RGB 580xi SI AAP

H SHIFT

RGB 580xi SI AAP

H. SHIFT

INPUT
SELECT

Cable Cubby

The RGB 580xi AAP models S, SI, CCS, and CCSI have a front panel horizontal shift control
knob. The SI and CCSI models also have an input select button.

Horizontal shift control knob — While viewing the displayed image, rotate this control to
move the image to the right or left on the screen. The power/signal LED will flash green
whenever the minimum and maximum limits of this control are reached.

Input select button — Pressing this button results in contact closure between pins A and B of
the contact closure connector on the front panel of the RGB 580xi remote interface. This button
can also be used for direct control of any Extron contact closure-controlled switcher, or as a
direct connection to an external control system.

Extron USA - E ast

+800.6 33.9876

Inside USA / Canada Only

+1.919.863.1794
+1.919.863.1797 FA X

Extron Euro pe

+800.3 987.6673

Inside Europe Only

+31.33.4 53.4040
+31.33.4 53.4050 F AX

Extron Asia

+800.7 339.8766

Inside Asia Only

+65.63 83.440 0
+65.63 83.466 4 FAX

Extron Japa n

+81.3.35 11.7655
+81.3.35 11.7656 FAX

© 2009 Extron Electronics. All rights reserved.

Extron Chi na

+400. 883.1568

Inside China Only

+86.21. 3760.1568
+86.21. 3760.1566 FA X

Extron Mid dle East

+971.4.2 991800
+971.4.2 991880 FA X

68-537-50

Rev. A

11 09