™ |
OWNER’S MANUAL |
|
Outdoor LP Gas Barbecue Grill
Model No. XG18-103-002-05 / GBT1814W
WARNING
FOR YOUR SAFETY:
1. Do NOT store or use gasoline or
other flammable liquids or vapors in
the vicinity of this or any other
appliance.
2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
Table of Contents |
|
|
|
DANGER |
|
|
|
|
|
|
Never operate this appliance |
Important Safeguards . . . . . . . . . . . . . . . . . . . . Page 2 |
|
|
unattended. Failure to follow the |
||
|
|
|
|
|
dangers, warnings and cautions in |
Limited Warranty . . . . . . |
. . . . . . . . . . . . . |
. 5. . . |
. . . . |
||
Expanded View & Hardware |
. . . . . . . . . . . . . .6.&. 7 |
|
|
this manual may result in serious |
|
|
|
|
|||
Assembly Instructions . . . . . |
. . . . . . . . . . . . . . . . . . . |
8 |
|
|
bodily injury or death, or in a fire |
Operating Instructions . . . . . |
. . . . . . . . . . . . . . . . . . |
11 |
|
|
|
Cleaning and Care . . . . . |
. . . . . . . . . . . . . . 13. . . . |
. |
. or an explosion causing damage to |
||
Troubleshooting . . . . . . . |
. . . . . . . . . . . . . . . |
15. . . . . |
|
|
property. |
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT |
|
|
|
. |
|
|
|
|
WARNING |
||
SAFETY INFORMATION.. PLEASE READ AND KEEP FOR |
|
|
|
||
FUTURE REFERENCE.. |
|
|
|
|
FOR YOUR SAFETY: |
|
|
|
|
|
|
If you are assembling this unit for someone else, give |
|
|
For Outdoor Use Only! (outside any enclosure) |
||
|
|
|
|||
this manual to him or her to read and save for future |
|
|
|
|
|
|
|
|
|
||
reference.. |
|
|
|
|
DANGER |
California Proposition 65: Combustion by-products |
|
|
|
||
produced when using this product contain chemicals |
|
|
|
If you smell gas - |
|
known to the State of California to cause cancer, birth |
|
|
1.Shut off gas to appliance. |
||
defects, and other reproductive harm.. |
|
|
|
||
California Proposition 65: Wash your hands after |
|
|
|
2.Extinguish any open flame. |
|
handling this product.. |
|
|
|
|
3.Open lid. |
|
|
|
|
|
4.If odor continues, keep away from |
|
|
|
|
||
|
|
|
|
|
the appliance and immediately |
|
|
|
|
|
call your fire department. Failure |
|
|
|
|
|
to follow these instructions could |
|
|
|
|
|
result in fire or explosion which |
Manufactured in China for: RevoAce Inc.. Limited |
|
|
|
could cause property damage, |
|
|
|
|
|
||
Hong Kong, China |
|
|
|
|
personal injury or death. |
1..800..694..0013 • service@revoace..com |
|
|
|
||
8:00 am to 5:00 pm central time, Monday to Friday.. |
|
|
|
|
|
GBT1814W-OM-E-F104
2 |
|
|
FOR YOUR SAFETY |
WW |
DANGER |
1.Never operate this appliance unattended.
2.Never operate this appliance within 10 ft (3.05 m) of any structure, combustible material or other gas cylinder.
3.Never operate this appliance within 25 ft (7.62 m) of any flammable liquid.
4.Do not fill cooking vessel beyond maximum fill-line.
5.Never allow oil or grease to get hotter than 400°F or 200°C. If the temperature exceeds 400°F (200°C) or if oil begins to smoke, immediately turn the burner or gas supply OFF.
6.Heated liquids remain at scalding temperatures long after the cooking process. Never touch cooking appliance until liquids have cooled to 115°F (45°C) or less.
7.If a fire should occur, keep away from the appliance and immediately call your fire department. Do not attempt to extinguish oil or grease fire with water.
Failure to follow these istructions could result in fire or explosion which could cause property damage, personal injury or death:
IMPORTANT SAFEGUARDS
WW DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.
WW WARNINGS:
WW This grill is for outdoor use only, and should not be used in a building, garage or any other enclosed area. WW Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.
WW Read the installation, operation, and maintenance instructions thoroughly before installing or servicing this equipment.
WW This instruction manual contains Important information necessary for the proper assembly and safe use of the appliance.
WW Read and follow all warnings and instructions before assembling and using the appliance. WW Follow all warnings and instructions when using the appliance.
WW Keep this manual for future reference.
WW For residential use only. This grill is NOT for commercial use.
WW This grill is not intended for and should never be used as a heater. TOXIC fumes can accumulate and cause asphyxiation.
WW This is NOT a tabletop grill. Therefore, do NOT operate this grill on any type of tabletop surface.
WW This grill is safety certified for use in the United States and/or Canada only. Do NOT modify for use in any other location. Modification will result in a safety hazard and will void your warranty.
WW This grill is for use with liquid propane (LP) gas only. The conversion to or attempted use of natural gas in this LP gas grill is dangerous, may cause bodily harm and will void your warranty.
WW LP gas characteristics:
3 |
IMPORTANT SAFEGUARDS |
a.LP gas is flammable and hazardous if handled improperly. Become aware of the characteristics before using any LP gas product.
b.LP gas is explosive under pressure, heavier than air, and settles and pools in low areas.
c.LP gas in its natural state has no odor. For your safety, an odorant is added that smells like rotten cabbage.
d.Contact with LP gas can cause freeze burns to skin.
WW Apartment dwellers: Check with management to learn the requirements and fire codes for using a LP gas grill in your apartment complex. If allowed, use outside on the ground floor with a ten foot (3.05 m) clearance from any structure. Do NOT use on or under balconies.
WW LP gas cylinder needed to operate. Only cylinders marked “propane” may be used.
WW The LP gas cylinder must be constructed and marked in accordance with the Specifications for LPgas Cylinders of the U.S. Department of Transportation (D.O.T.), Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods; or the National Standard of Canada, CAN/CSA-B339.
WW LP gas cylinder must be arranged for vapor withdrawal.
WW Dented or rusted LP gas cylinders may be hazardous and should be checked by your LP gas supplier prior to use.
WW The LP gas cylinder should not be dropped or handled roughly.
WW LP gas cylinders must be stored outdoors out of the reach of children and must not be stored in a building, garage or any other enclosed area. Your cylinder must never be stored where temperatures can reach over 125°F.
WW Do NOT insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve and cause a leak. Leaking propane may result in an explosion, fire, severe personal injury or death.
WW Do NOT block holes in sides, bottom or back of grill.
WW Never keep an LP gas cylinder in a hot car or trunk. Heat will cause the gas pressure to increase, which may open the relief valve and allow gas to escape.
WW Never attempt to attach this grill to the self-contained LP gas system of a camper trailer, motor home or house.
WW The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.
WW Strong odors, colds, sinus congestion, etc. may prevent the detection of propane. Use caution and common sense when testing for leaks.
WW Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene or alcohol with this product.
WW Your grill has been checked at all factory connections for leaks. Recheck all connections as described in the “Operating Instructions” section of the manual, as shipping can loosen connections.
WW Check for leaks even if your unit was assembled for you by someone else.
WW Do NOT operate if a gas leak is present. Gas leaks may cause a fire or explosion.
WW You must follow all instructions in the “Checking for Leaks” section before operating. To prevent a fire or explosion hazard when testing for a leak:
a.Always perform a leak test before lighting the grill and each time the cylinder is connected for use.
b.No smoking. Do NOT use or permit sources of ignition in the area while conducting a leak test.
c.Conduct the leak test outdoors in a well-ventilated area.
d.Do NOT use matches, lighters, or a flame to check for leaks.
e.The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.
4 |
IMPORTANT SAFEGUARDS |
f.Strong odors, colds, sinus congestion, etc. may prevent the detection of propane. Use caution and common sense when testing for leaks.
g.Do NOT use grill until any and all leaks are corrected. If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your local LP gas supplier.
WW Do NOT use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids.
WW Do NOT use this appliance under any type of overhang or roof.
WW It is essential to keep the grill’s regulator and valve assembly, burners and circulating air passages clean. WW Inspect grill before each use.
WW Do NOT alter grill in any manner. Any alteration will void your warranty.
WW Do NOT use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened. WW This grill should be thoroughly cleaned and inspected on a regular basis.
WW Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts or leaks, the hose must be replaced prior to operation.
WW Use only the pressure regulator provided. Use only the replacement pressure regulator specified by RevoAce Inc. Limited.
WW Do NOT attempt to repair or alter the pressure regulator for any assumed defect. Any modification to this assembly will void your warranty and create the risk of a gas leak and fire. Use only authorized replacement parts supplied by manufacturer.
WW Use only RevoAce Inc. Limited factory-authorized parts. The use of any part that is not factory-authorized can be dangerous and will void your warranty.
WW Do NOT operate this appliance without reading “Operating Instructions” in this manual.
WW Do NOT touch metal parts of grill until they have completely cooled to avoid burns, unless you are wearing protective gear (pot holders, gloves, BBQ mitts, etc.).
WW Do NOT install or use in or on boats or recreational vehicles (RV).
WW Do NOT use grill in a vehicle trunk, station wagon, mini-van or sport utility vehicle (SUV).
WW When cooking, fire extinguishing materials should be readily accessible. In the event of an oil/grease fire, do NOT attempt to extinguish with water. Use type BC or ABC dry chemical fire extinguisher or smother with dirt, sand or baking soda.
WW Move gas hoses as far away as possible from hot surfaces and dripping hot grease. WW Do NOT use grill in high winds.
WW Never lean over the grill when lighting.
WW Do NOT leave a lit grill unattended. Keep children and pets away from grill at all times.
WW Do NOT leave grill unattended while preheating or burning off food residue on high. If grill has not been cleaned, a grease fire can occur that may damage the product.
WW Do NOT place empty cooking vessels on the appliance while in operation.
WW Use caution when placing anything on the grill while the appliance is in operation.
WW Do NOT attempt to move grill when in use. Allow the grill to cool before moving or storing. WW LP gas cylinder must be properly disconnected and removed prior to moving this grill.
WW Storage of grill indoors is permissible only if the cylinder is disconnected, removed from the grill and properly stored outdoors.
WW Always open grill lid carefully and slowly as heat and steam trapped within grill can cause severe burns. WW Do NOT attempt to disconnect the gas regulator from the cylinder or any gas fitting while the grill is in use.
5 |
IMPORTANT SAFEGUARDS |
WW Disconnect LP gas tank when not in use.
WW Always place your grill on a hard, non-combustible, level surface. An asphalt or blacktop surface may not be acceptable for this purpose.
WW Do NOT use directly on wooden decks.
WW Move gas hoses as far away as possible from hot surfaces and dripping hot grease. WW Keep all electrical cords away from a hot grill.
WW After a period of storage and/or non-use, check for leaks, burner obstructions and inspect for any abrasion, wear or cuts to the hose.
WW Failure to open lid while igniting the grill’s burner(s), or not waiting
five minutes to allow the gas to clear if the grill does not light, may result in an explosive flame-up. WW Never operate grill without its heat plates installed.
WW Always use a meat thermometer to ensure food is cooked to a safe temperature. WW Use protective gloves when assembling this product.
WW Do NOT force parts together as this can result in personal injury or damage to the product. WW Never cover entire cooking area with aluminum foil.
WW Deaths, serious injury or damage to property may occur if the above is not followed exactly.
Limited Warranty
RevoAce Inc.. Limited (“RA”) warrants to the original retail purchaser of this product, and to no other person, that if this product is assembled, maintained, and operated in accordance with the printed instructions accompanying it, then for a period of one (1) year for all remaining parts from the date of purchase, all parts in such product shall be free from defects in material and workmanship.. RA may require reasonable proof of your date of purchase.. Therefore, you should retain your sales slip or invoice.. This Limited Warranty shall be limited to the repair or replacement of parts, which prove defective under normal use and service and which RA shall determine in its reasonable discretion upon examination to be defective.. Before returning any parts, you should contact RA’s Customer Care Department using the contact information listed below.. If RA conforms, after examination, a defect covered by this Limited Warranty in any returned part, and if RA approves the claim, RA will replace such defective part without charge.. If you return defective parts, transportation charges must be prepaid by you.. RA will return replacement parts to the original retail purchaser, freight or postage prepaid.. This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse, misuse, alteration, misapplication, improper installation or improper maintenance or service by you or any third party, or failure to perform normal and routine maintenance on the product as set out in this owner’s manual.. In addition, the Limited Warranty does not cover damage to the finish, such as scratches, dents, discoloration, rust or other weather damage, after purchase..
This Limited Warranty is in lieu of all other express warranties.. RA disclaims all warranties for products that are purchased from sellers other than authorized retailers or distributors, including the warranty of merchantability or the warranty of fitness for a particular purpose.. RA ALSO DISCLAIMS ANY AND ALL IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.. RA SHALL HAVE NO LIABILITY TO PURCHASER OR ANY THIRD PARTY FOR ANY SPECIAL, INDIRECT, PUNITIVE, INCIDENTAL, OR CONSEQUENTIAL DAMAGES.. RA further disclaims any implied or express warranty of, and assumes no responsibility for, defects in workmanship caused by third parties.. This Limited Warranty gives the purchaser specific legal rights; a purchaser may have other rights depending upon where he or she lives.. Some jurisdictions do not allow the exclusion or limitation of special, incidental or consequential damages, or limitations on how long a
warranty lasts, so the above exclusion and limitations may not apply to everyone.. RA does not authorize any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return,
or replacement of its equipment, and no such representations are binding on RA..
Manufactured in China for: RevoAce Inc.. Limited Hong Kong, China
1..800..694..0013 • service@revoace..com
8:00 am to 5:00 pm central time, Monday to Friday..
Loading...