Everdure NEO GRANDE, NEO GROSSO Instruction Manual

wwww

here barbecuing meets art

here barbecuing meets arthere barbecuing meets art

here barbecuing meets art

ASSEMBLY, OPERATION

& MAINTENANCE INSTRUCTIONS

NEO

NEO GRANDE

NEO NEO

GRANDE &

GRANDEGRANDE

& GROSSO

& &

F O R O U T D O O R U S E O N L Y

F O R O U T D O O R U S E O N L YF O R O U T D O O R U S E O N L Y

GROSSO

GROSSOGROSSO

ASSEMBLY, OPERATION AND MAINTENANCE INSTRUCTIONS

ASSEMBLY, OPERATION AND MAINTENANCE INSTRUCTIONSASSEMBLY, OPERATION AND MAINTENANCE INSTRUCTIONS

FOR

FOR EVERDURE

FOR FOR

EVERDURE 6666 BURNER GAS BARBECUE RANGE

EVERDURE EVERDURE

BURNER GAS BARBECUE RANGE

BURNER GAS BARBECUE RANGE BURNER GAS BARBECUE RANGE

GRANDE

GRANDE AND

GRANDEGRANDE

CONTENTS

CONTENTSCONTENTS

SECTION PAGE NO.

General Safety Instructions 3 Appliance Details 4 Gas Connections 4 Outdoor Installation Guide 5 Operating Instructions for Barbecue 6 Lighting Procedure 6 Cooking 7 Cleaning and Storage 7 Operating Instructions for Wok Burner 8 Troubleshooting 9 Maintenance 9 Assembly Instructions 10-17

It is important that you retain these instructions for future reference.

It is important that you retain these instructions for future reference.It is important that you retain these instructions for future reference.

Grande Grosso

AND GROSSO

AND AND

GROSSO OUTDOOR BARBECUES

GROSSOGROSSO

OUTDOOR BARBECUES

OUTDOOR BARBECUESOUTDOOR BARBECUES

IMPORTANT SAFETY INSTRUCTIONS

IMPORTANT SAFETY INSTRUCTIONSIMPORTANT SAFETY INSTRUCTIONS

IMPORTANT

IMPORTANT: Read the assembly instruction section and safety precautions

IMPORTANTIMPORTANT

Read the assembly instruction section and safety precautions of this

Read the assembly instruction section and safety precautionsRead the assembly instruction section and safety precautions booklet carefully before removing the contents of this carton.

booklet carefully before removing the contents of this carton.

booklet carefully before removing the contents of this carton.booklet carefully before removing the contents of this carton.

of this

of this of this

1. This barbecue and wok burner is for OUTDOOR USE ONLY indoors.

2. Unsupervised children or pets should not be near a barbecue while cooking or during warm up or cool down. Ensure children or pets are kept a distance well away from the barbecue whilst it is in use. Ensure that young children do not play with the appliance.

3. Particular care must be taken when removing the fat tray. Hot fats can cause serious injury.

4. Turn all gas valves off including cylinder after use. Do not allow build up of unburned gas.

5. Do not use this appliance for any purpose other than what it is intended for.

6. Do not move this barbecue while in use as accessible parts may be very hot.

7. People with flammable clothing such as nylon etc. should keep well away from the barbecue when it is operating.

8. Never leave burners on high for more than 10 minutes unless actually cooking.

9. Always check for leaks when a gas cylinder is replaced or reconnected. Never store more than one gas

cylinder in the trolley at any one time.

10. Sand, kitty litter and fat absorbers should not be used in the fat tray.

11. In case of fat fire turn cylinder off. Fat drip trays should be cleaned and checked before using the barbecue. Regular cleaning should reduce the build up of fat and food residues which is combustible and can result in a fat fire. Fat fires can be prevented with diligence in cleaning your fat tray. Damage as a result of fat fire is not covered by your warranty and voids it.

Fat fires can be prevented with diligence in cleaning your fat tray.

Fat fires can be prevented with diligence in cleaning your fat tray. Fat fires can be prevented with diligence in cleaning your fat tray.

OUTDOOR USE ONLY. This appliance must NOT

OUTDOOR USE ONLYOUTDOOR USE ONLY

NOT be used

NOT NOT

12. For your safety and enjoyment, read all operating instructions before lighting.

13. Ensure that the product has adequate clearance from combustible materials. The appliance is designed so that heat will not affect the trolley. All combustible materials must be kept more than 250mm from the sides of the trolley and more than 1500mm above the cooking surface of the barbecue.

14. If the burner makes a hissing sound when lit, it may be burning inside. Turn the burner off, allow to cool and try ignition again. Keep your barbecue protected against strong wind – if this cannot be avoided, always check that the burners remain alight if operating the barbecue in windy conditions.

15. This appliance is not intended for use by young children or infirm persons.

16. When the wok burner is in use or is still hot, the lid must not be placed in the closed position.

17. Do not carry out any servicing on the gas manifold of the barbecue yourself – this must only be done by authorised technicians.

18. We recommend that you regularly maintain your barbecue and keep it in good condition. This can be achieved by following the cleaning and maintenance suggestions in this booklet.

DO NOT DO NOT

DO NOT

DDDDO NOT

DO NOT OPERATE THIS APPLIANCE BEFORE READING THE

DO NOT DO NOT

DO NOT PLACE ARTICLES ON OR AGAINST THIS APPLIANCE

DO NOT DO NOT DO NOT STORE CHEMICALS OR FLAMMABLE MATERIALS OR

DO NOTDO NOT

DO NOT OPERATE THIS APPLIANCE INDOORS

DO NOTDO NOT DO NOT ENCLOSE THIS APPLIANCE

DO NOTDO NOT

O NOT LIGHT OR OPERATE WITH COVER ON

O NOTO NOT

INSTRUCTION BOOKLET

SPRAY AEROSOLS NEAR THIS APPLIANCE

APPLIANCE DETAILS

APPLIANCE DETAILSAPPLIANCE DETAILS

Gas Type:

Gas Type:Gas Type:

Burner

Burner Pressure:

BurnerBurner

Injector Diameter:

Injector Diameter: Ø0.95 mm Ø1.65 mm

Injector Diameter:Injector Diameter:

Heat Input:

Heat Input: 70 MJ/ hr 75 MJ/ hr

Heat Input:Heat Input:

Wok Injector Diameter:

Wok Injector Diameter: Ø0.90 mm Ø1.65 mm

Wok Injector Diameter:Wok Injector Diameter:

Wok Heat Input:

Wok Heat Input: 10.5MJ/hr 12.5MJ/hr

Wok Heat Input:Wok Heat Input:

Note: The size of the injector diameter is stamped on one of the hexagon faces (e.g. ‘104’ for Ø1.04mm injector).

Pressure: 2.75 kPa 0.95 kPa

Pressure: Pressure:

(Propane and/or Butane gas)

Universal LPG

Natural Gas

Barbecue only

Barbecue only 1004 545 220

Barbecue onlyBarbecue only

Barbecue and

Barbecue and Barbecue and

Trol

Trolley

ley

TrolTrol

leyley

Grande 1710 640 1220

Grosso 1680 640 1220

LENGTH (mm)

LENGTH (mm) WIDTH (mm)

LENGTH (mm)LENGTH (mm)

WIDTH (mm) HEIGHT (mm)

WIDTH (mm)WIDTH (mm)

HEIGHT (mm)

HEIGHT (mm)HEIGHT (mm)

GAS CONNECTIONS

GAS CONNECTIONSGAS CONNECTIONS

LOCAL AUTHORITY REQUIREMENTS

LOCAL AUTHORITY REQUIREMENTSLOCAL AUTHORITY REQUIREMENTS

Check Gas Type and specifications plate on the left-hand side of the barbecue. All gas fitting work, service and repairs can only be performed by an authorised person in accordance with AS5601 / AG601 and local gas regulations.

NATURAL GAS

NATURAL GASNATURAL GAS

Neo 6 burner barbecues can be converted to use natural gas ONLY with a Neo NG 6 burner conversion kit. Fit the NG manifolds, regulator and NG hose. This conversion can ONLY with AS5601 / AG601 and local gas regulations. Note: The burner pressure (as noted on the appliance details) MUST be checked after installation by turning on and measuring at the regulator output test point. All connections must be checked for leaks.

FOR

FOR GAS

GAS CYLINDER CONNECTION

FOR FOR

1. To achieve the optimum performance from your Barbecue, an approved gas cylinder (POL fitting) of 9kg capacity

must be used.

2. Do not connect gas to a barbecue that is not secured in a trolley.

3. Connect the cylinder to the barbecue, via the hose and regulator. Firmly tighten joints, but do not over-tighten. Take

LEAK TESTING

LEAK TESTINGLEAK TESTING

1. Make sure gas controls are Off

2. Check for leaking joints by brushing with solution of half-liquid detergent and half water. If a leak is present, bubbles

will appear (or you will hear a hissing sound). Retightening connections can generally repair a leaking joint. You must also check the gas hose and connection at the gas cylinder, and at the wok burner. If a leak cannot be resolved, do not proceed.

CYLINDER CONNECTION

GASGAS

CYLINDER CONNECTION CYLINDER CONNECTION

care not to damage the regulator fitting.

Off and turn the cylinder valve On

OffOff

LEAK TEST ALL CONNECTIONS, INCL

LEAK TEST ALL CONNECTIONS, INCLUDING THE CONNECTION

LEAK TEST ALL CONNECTIONS, INCLLEAK TEST ALL CONNECTIONS, INCL TO THE GAS CYLINDER

TO THE GAS CYLINDER.

TO THE GAS CYLINDERTO THE GAS CYLINDER DO NOT USE NAKED FLAME FOR LOCATING GAS LEAKS.

DO NOT USE NAKED FLAME FOR LOCATING GAS LEAKS.

DO NOT USE NAKED FLAME FOR LOCATING GAS LEAKS.DO NOT USE NAKED FLAME FOR LOCATING GAS LEAKS. IF A LEAK PERSISTS CALL AN AUTHORISED GAS FITTER.

IF A LEAK PERSISTS CALL AN AUTHORISED GAS FITTER.

IF A LEAK PERSISTS CALL AN AUTHORISED GAS FITTER.IF A LEAK PERSISTS CALL AN AUTHORISED GAS FITTER.

ONLY be performed by an authorised person in accordance

ONLYONLY

On.

OnOn

UDING THE CONNECTION

UDING THE CONNECTION UDING THE CONNECTION

OUTDOOR INSTALLATION GUIDE

OUTDOOR INSTALLATION GUIDEOUTDOOR INSTALLATION GUIDE

This Appliance shall only be used in an above ground open-air situation with natural ventilation, without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by wind and natural convection.

This appliance

This appliance must not

This appliance This appliance other enclo

other enclosed areas. The barbecue is not intended to be installed in or used on recreational vehicles

other encloother enclo (e.g. boats, camping vans) and should not be placed close to or under any surfaces that will burn or

(e.g. boats, camping vans) and should not be placed close to or under any surfaces that will burn or

(e.g. boats, camping vans) and should not be placed close to or under any surfaces that will burn or (e.g. boats, camping vans) and should not be placed close to or under any surfaces that will burn or are sensitive to heat. Do not block/obstruct the flow of air

are sensitive to heat. Do not block/obstruct the flow of air and combustion around the barbecue

are sensitive to heat. Do not block/obstruct the flow of air are sensitive to heat. Do not block/obstruct the flow of air housing while in use.

housing while in use.

housing while in use.housing while in use.

Any enclosure in which the appliance is used shall comply with one of the following:

Any enclosure in which the appliance is used shall comply with one of the following:Any enclosure in which the appliance is used shall comply with one of the following:

• An enclosure with walls on all sides, but at least one permanent opening at ground level and no overhead cover.

• Within a partial enclosure that includes an overhead cover and no more than two walls

• Within a partial enclosure that includes an overhead cover and more than two walls, the following shall

apply-

In the case of balconies, at least 20% of the total of the side, back and front wall areas shall be and remain open and unrestricted.

must not be used indoors. Do not use your barbecue in garages, porches, sheds or

must notmust not

sed areas. The barbecue is not intended to be installed in or used on recreational vehicles

sed areas. The barbecue is not intended to be installed in or used on recreational vehicles sed areas. The barbecue is not intended to be installed in or used on recreational vehicles

(i) at least 25% of the total wall area is completely open: and (ii) at least 30% of the remaining wall area is open and unrestricted.

be used indoors. Do not use your barbecue in garages, porches, sheds or

be used indoors. Do not use your barbecue in garages, porches, sheds or be used indoors. Do not use your barbecue in garages, porches, sheds or

and combustion around the barbecue

and combustion around the barbecue and combustion around the barbecue

OPERATING IN

OPERATING INSTRUCTIONS

OPERATING INOPERATING IN

GAS TYPE AND CONSUMPTION

GAS TYPE AND CONSUMPTIONGAS TYPE AND CONSUMPTION

The barbecue is designed to operate on Universal LP Gas only (Propane and/or Butane gas) and Natural Gas (using a conversion kit). Gas consumption, Pressure and Injector Orifice size are shown on the Data Plate found on the left-hand side of the barbecue.

GAS

GAS CONTROL

CONTROL KNOBS

GAS GAS

CONTROLCONTROL

The gas control knob locks in both the Off clockwise, gas flow will gradually increase until the High and gas flow will decrease until a simmer level is reached at Low must be turned clockwise from Low

VAPOURISER

VAPOURISERVAPOURISER

Prior to using the barbecue, ensure the vapouriser is located in the correct position below the grill plate.

HOT PLATE, GRILL PLATE

HOT PLATE, GRILL PLATE, BAKING DISH

HOT PLATE, GRILL PLATEHOT PLATE, GRILL PLATE

Prior to using the barbecue, it’s advisable to cure the cooking surface. Wash the hot plate and grill plate, then cover with olive or vegetable oil, light all burners and leave on until oil is absorbed, then wipe with a dry cloth.

STRUCTIONS

STRUCTIONSSTRUCTIONS

KNOBS

KNOBS KNOBS

Low, depressed at High

LowLow

, BAKING DISH

, BAKING DISH, BAKING DISH

Off and High

OffOff

High positions. By depressing the knob and turning anti-

HighHigh

High position is reached. Continue turning in this direction

High High

Low. To turn gas flow off the gas control knob

LowLow

High and turned until the Off

HighHigh

Off position is reached.

OffOff

DRIP TRAY

DRIP TRAYDRIP TRAY

Prior to use check that the drip tray is clean and lined with aluminium foil.

UNDER NO CIRCUMSTANC

UNDER NO CIRCUMSTANCES MUST SAND, FAT AB

UNDER NO CIRCUMSTANCUNDER NO CIRCUMSTANC

OR KITTY LITTE

OR KITTY LITTER BE USED IN THE DRI

OR KITTY LITTEOR KITTY LITTE

LIGHTING PROCEDURE

LIGHTING PROCEDURELIGHTING PROCEDURE

ES MUST SAND, FAT ABSORBENTS

ES MUST SAND, FAT ABES MUST SAND, FAT AB

R BE USED IN THE DRIP TRAY

R BE USED IN THE DRIR BE USED IN THE DRI

SORBENTS

SORBENTSSORBENTS

P TRAY

P TRAYP TRAY

READ ALL OPERATING I

MAKE SURE ALL GAS

LIGHTING THE BARBECUE

LIGHTING THE BARBECUELIGHTING THE BARBECUE

The 6 burner barbecue has a rotary ignition system built into the second gas control in from either end, which ignites the corresponding burner. The remaining burners are ignited by a cross over channel. Pushing either of these control knobs in, and rotating the control knob in an anti-clockwise direction (starting at off a spark to ignite an extended pilot flame, which will in turn light the burner in front of the control knob. Once the knob is released, the pilot flame will extinguish. Visually check to see if the burner has ignited. If the burner does not light, turn gas control off (turn the control knob clockwise) and allow the unburned gas to dissipate before attempting ignition again. If ignition continues to fail refer, to the “Trouble shooting” section. To achieve ignition on the remaining burners, turn an adjacent burner control knob to high ignite from the first burner.

MANUAL IGNITION

MANUAL IGNITIONMANUAL IGNITION

To help light the barbecue manually, a match holder and chain has been provided, and should be attached to the right hand servery. The right hand burner can then be lit by lighting a match, fitting it into the holder and pushing the match through to the right hand burner. After the initial burner is lit, the others can be ignited as described above.

READ ALL OPERATING INSTRUCTIONS BEFORE L

READ ALL OPERATING IREAD ALL OPERATING I

MAKE SURE ALL GAS CONTROL

MAKE SURE ALL GAS MAKE SURE ALL GAS

POSITION AND OPEN CY

POSITION AND OPEN CYLINDER VALVE.

POSITION AND OPEN CYPOSITION AND OPEN CY

NSTRUCTIONS BEFORE LIGHTING.

NSTRUCTIONS BEFORE LNSTRUCTIONS BEFORE L

CONTROL KNOBS ARE IN THE ‘O

CONTROLCONTROL

KNOBS ARE IN THE ‘OFF’

KNOBS ARE IN THE ‘O KNOBS ARE IN THE ‘O

LINDER VALVE.

LINDER VALVE.LINDER VALVE.

IGHTING.

IGHTING.IGHTING.

FF’

FF’ FF’

off), will cause

offoff

high and the burner will

highhigh

+ 14 hidden pages