1/8
888-97-194-G-00 rev.D • 08/17
User's Guide - English
Guía del usuario - Español
Manuel de l’utilisateur - Français
Gebruikersgids - Nederlands
Benutzerhandbuch - Deutsch
Guida per l’utente - Italiano
Användarhandbok - svenska
ユ ー ザ ー ガ イド : 日本語
用户指南 : 汉语
www.ergotron.com
Replace Battery
for StyleView® SV32 & SV42 Carts
with LiFe Power System
SV32SV42
53
10mm (3/8")
or
8mm (5/16")
EN
User Guide
Depends on battery
For local customer care phone numbers visit: http://contact.ergotron.com
For the latest User Installation Guide and StyleLink Software Download please visit: www.ergotron.com
For Service visit: www.ergotron.com
For Warranty visit: www.ergotron.com/warranty
2/8
888-97-194-G-00 rev.D • 08/17
EN
WARNING: RISK OF ELECTRICAL DISCHARGE
• Do NOT swap battery cables, doing so will cause arcing and trip the circuit breaker.
• Do not remove or replace the batteries while cart is located in an oxygen rich or
hazardous environment, arcing may occur and cause combustion.
CAUTION: To avoid risk of electrical shock when replacing battery:
• Remove Black (-) cable from post before removing Red (+) cable from post.
• Connect Red (+) cable to post before connecting Black (-) cable to post.
NOTE
• Only Ergotron-specied batteries may be used in the StyleView Power System.
Contact Ergotron customer care for more details.
• Do not dispose of the Lithium battery in the trash.
Recycle the battery according to local regulations.
Please note, the EPA classies spent lithium batteries as “Universal Waste”.
The shipping requirements for “Universal Waste” are available at the EPA website at www.epa.gov.
Maintenance & Safety
Color Symbol
Signal
Word
Level of Hazard
Red
DANGER
Indicates an imminently hazardous situation which, if not
avoided, will result in death or serious injury.
Orange
WARNING
Indicates a potentially hazardous situation which, if not
avoided, could result in death or serious injury.
Yellow
CAUTION
Indicates a potentially hazardous situation which, if not
avoided, may result in minor or moderate injury.
None
CAUTION
Used without the safety alert symbol indicates a potentially hazardous situation which, if not avoided, may
result in property damage.
Red,
Orange
or
Yellow
Electrical
Indicates an impending electrical hazard which, if not
avoided, may result in personal injury, re and/or death.
Hazard Symbols Review
The Meaning of Symbols appearing in this Guide, on the Cart or on the Power System
These symbols alert you to a safety condition that demands your attention. You should be able to recognize and
understand the signicance of the following Safety Hazards if you encounter them on the Cart or within Cart
documentation such as this Set-up Guide.
BATTERY REPLACEMENT
Only the following 40 -Ah lithium batteries are compatible with this system:
Valence Model Number: U1-12RT REV2
Ergotron Part Number: 910-434
Valence Model Number: U1-12RJ
Ergotron Part Number: 915-766
Installing batteries other than the Valence battery listed above will void the product warranty and
result in power system malfunction. Failure to heed this warning may result in severe damage to
batteries, power module and possible re hazard.
REMPLACEMENT DE LA BATTERIE
Seule la batterie suivante est compatible avec ce système:
Batterie au lithium de 40Ah.
Batterie Valence modèle numéro: U1-12RT REV2
Numéro de pièce Ergotron: 910-434
Batterie Valence modèle numéro: U1-12RJ
Numéro de pièce Ergotron: 915-766
L’installation de toute batterie autre que la batterie Valence indiquée ci- dessus rendra nulle la
garantie du produit et entraînera le dysfonctionnement du système d’alimentation. Si vous ne vous
conformez pas à cette précaution d’utilisation, les batteries et le module d’alimentation risquent
d’être sérieusement endommagés, ce qui pourrait provoquer un incendie.
WARNING/AVERTISSEMENT
826-505
3/8
888-97-194-G-00 rev.D • 08/17
1 a b c
2
3
a c
4
a
a
b
b
c
SV42
b
EN
Turn o all mounted equipment.
Disconnect Power System from power source.
Turn power system o by holding down
the AC Outlet Power button for 1 - 3
seconds. Power light will shut o.
Caution: Remove Black (-) before removing Red (+).
Recycle the battery
according to local
regulations.
Caution: Do NOT swap battery cables, doing so will cause sparking and trip the circuit breaker.
Red
Black
Battery Harness
Battery "Yellow" Comm 3
4/8
888-97-194-G-00 rev.D • 08/17
SV42
8
7
5
6
a b
b c d
Torque to
110 in-lbs
Torque to
110 in-lbs
a
a
b
1 2
EN
Red
Caution: Connect Red (+) before connecting Black (-).
Follow Battery Charge/Discharge Initial Power on steps a, b, c.
Black
PLUG BATTERY HARNESS IN FIRST!
Battery Harness
Battery "Yellow" Comm 3
5/8
888-97-194-G-00 rev.D • 08/17
SV32
1
2
3
4
b
b
c
c
a
a
a
b
b ca
EN
Turn o all mounted equipment.
Disconnect
Power System
from power
source.
Turn power system o by holding down
the AC Outlet Power button for 1 - 3
seconds. Power light will shut o.
Battery Harness
Battery "Yellow" Comm 3
Red
Black
Caution: Remove Black (-) before removing Red (+).
Recycle the battery according to
local regulations.
6/8
888-97-194-G-00 rev.D • 08/17
7
8
5
6
b
b c
a
a
SV32
Torque to
110 in-lbs
Torque to
110 in-lbs
a
b
1 2
c
EN
Red
Caution: Connect Red (+) before connecting Black (-).
Black
Follow Battery Charge/Discharge Initial Power on steps.
PLUG BATTERY HARNESS IN FIRST!
Battery Harness
Battery "Yellow" Comm 3
7/8
888-97-194-G-00 rev.D • 08/17
a b c
2.5hrs
EN
Battery Charge/Discharge
Initial Power on/Charge Battery (takes aproximately 2.5 hours to charge)
Turn on power system by holding power button down for
1 - 3 seconds.
With cart's power cord
plugged into the wall
outlet, wait until cart is
at 100% charge. (takes
aproximately up to 2.5
hours to charge)
Plug Cart's Power Cord into wall outlet.
Do Not stretch coiled cord further than 8 feet
(2.5 meters), damage to the cord may occur.
CAUTION: There is no on/o switch on
this equipment; the AC power cord is the only
power disconnect. The socket outlet should be
easily accessible and should be installed near the
equipment.
If other lights are ashing red/green it could indicate a power system fault. If this occurs contact Ergotron Customer Care.
NOTE: Frequent operation of the cart while battery charge levels are below 10% will signicantly reduce the life of your battery.
Battery has 100% charge.
Light ashes when charging (power cord plugged into wall outlet)
Allow battery to continue
charging until light stops ashing. After light stops ashing, it is OK to unplug the
power cord from the wall.
You can use cart while charging.
Battery has less than 90% charge.
Battery has less than 60% charge.
Battery has less than 10% charge and alarm beeps. Light is orange and then turns red when
battery has less than 5% charge. Plug-in power cord and charge to 100%! You can use cart while
charging.
Alarm Mute button. Pressing this will temporarily mute alarm. When battery has less than 5%
charge, the alarm mute is only eective for 1 min.
Power button for internal power system outlets. Pressing this will provide or remove power to/
from components plugged into the internal outlets.
When lit, alarm is enabled and
will beep when battery charge
gets below 10%. For details on
enabling and disabling alarm
contact Ergotron Customer Care.
When lit, the power system is on.
When dark, power system is o.
This power system interface will alert you to the percentage of charge remaining in the cart battery with a series of steady or ashing
red, yellow or green lights, and an alarm that will beep when charge gets below 10%. Remember, the battery needs to be charged to
100% every day, and you can use the cart while charging, so plug-in cord as often as possible to avoid running out of power!
NOTE: Put monitor in power save mode to optimize battery run time.
If the battery is stored too long
without recharging, the electronics
in the battery may cause the
battery voltage to drop below 10.8V.
If this happens, the power system
will enter a low charge recovery
mode when plugged into power
source.
During the low charge recovery
process this light will be green.
This light will be blinking red.
Once the process has nished the
power system will resume charging
as normal. if the low charge
recovery process takes longer than
45 min please contact Ergotron
Customer Care.
8/8
888-97-194-G-00 rev.D • 08/17
© 2015 Ergotron, Inc. All rights reserved.
EN
Loading...