Electrolux EW28BS71IS, EW23BC71IS Wiring Diagram

PERFORMANCE DATA NO LOAD & NO DOOR OPENINGS AT 37°/0° CONTROL SETTING

T

U

R

N

Mounting
Plate
Screws

Mounting
Plate
Screw

Motor
Gear

Timing

Gear

Water Fill
Adjustment

Type A with Run/Start Capacitor 65°F (18°C) Ambient 90°F (32°C) Ambient

Operating Time 90 to 100% 100%

Freezer Temperature -5° to 2° F (-20° to -17° C) -1° to 3° F (-18° to -16° C)

Refrigerator Temperature 34° to 39° F (1° to 4° C) 34° to 39° F (1° to 4° C)

Low Side Pressure -2 to 6 psig ( -14 to 41 kPa) -2 to 6 psig (-14 to 41 kPa)

High Side Pressure (last 1/3 cycle) 85 to 105 psig (586 to 724 kPa) 120 to 135 psig (827 to 931 kPa)

Wattage (last 1/3 cycle) 30 to 50 50 to 70

Amps (running) .4 to .8 .7 to .9

Base Voltage 115 vac (127 vac max)

DEFROST SPECIFICATIONS

Cabinet Size

26’ & 28’ SD, 23’ CD 25° F (-4° C) 47° F (8° C) 500 26.5

Electronic Timer - (ADC) Defrost 24 minutes every 6-96 hours of compressor run time.

Watts RPM Amps

3.1 1100 CW Opposite Shaft 0.03 Running

ICE MAKER SPECIFICATIONS

Electrical 115 vac (127 vac max)

Thermostat Opens at 48° F ( 9° C), Closes at 15° F ( -9° C)

Heater Voltage 85 vac

ICE MAKER CONNECTOR PLUG CONNECTIONS

Wire Number Wire Color Connects to:

1 Green/Yellow Ground

2 Yellow Water Valve

3 Black Line

4 Light Blue Neutral

Thermostat Heater

Cut-in Cut-out Watts Ohms

CONDENSER FAN MOTOR

IMPORTANT SAFETY NOTE

The information provided herein is designed to assist qualified repair personnel only.
Untrained persons should not attempt to make repairs due to the possibility of electrical
shock. Disconnect power cord before servicing this appliance.

IMPORTANT

If any green grounding wires are removed during servicing, they must be returned to
their original position and properly secured.

NOTE

This product comes equipped with an Adaptive Defrost Control (ADC). To activate manual
defrost, simultaneously press and hold the Fresh Food up (+) and Fresh Food down (-)
keys for 5 seconds. A “d” in the freezer temperature window and “F” in the refrigerator
temperature window will display when the heater is activated. To deactivate manual
defrost, simultaneously press and hold the Fresh Food up (+) and Fresh Food down (-)
keys for 5 seconds. A “d” and “F” will be displayed until the defrost cycle is complete.

CAUTION

All electrical parts and wiring must be shielded from torch flame. DO NOT allow
torch to touch insulation; it will char at 200°F and flash ignite (burn) at 500°F.
Excessive heat will distort the plastic liner.

SERVICE DATA SHEET

242047002

IMPORTANT

PLEASE RETURN THIS SHEET TO IT’S ORIGINAL LOCATION.

ICE & WATER - AUTOMATIC DEFROST

BOTTOM FREEZER - R134a

Ice Maker Errors Displayed on “UI” Diagnostic Mode Note: See Service Manual for

complete description.
ERROR Test
None 52C

55C
57C
58C
63C

System Error Codes Displayed on “UI” Diagnostic Mode Note: See Service Manual for

ERROR Test Activate: FZ (+) and FZ (-) for 5

OP or 2
SH or 3
OP or 2
SH or 3
SY EF
SY CE
SY CF

Freezer Sensor OPEN
Freezer Sensor SHORTED
FF Sensor OPEN
FF Sensor SHORTED
Evaporator Fan Circuit
Communication error
Communication error

1
2
3
8
9
10
11
41
12

To initiate manual defrost press and hold, for 5 sec. FF(+) and FF(-), (d) and (f) will

38

be displayed.

dF

In Manual Defrost (See Note)

15

FREEZER ICE MAKER INFORMATION

(Where Applicable)

Test Cycling: Remove cover by inserting screwdriver

in notch at bottom and prying cover from housing. Use
screwdriver to rotate motor gear counterclockwise until
holding switch circuit is completed. All components of ice

maker should function to complete the cycle.

Water Fill Volume: The water ll adjustment screw

will change the ll time. One full turn is equal to 20cc
(.68 oz.). The correct ll is 102 to 130cc (3.4 to 4.3 oz.).
When a water valve is replaced, the ll volume must be

checked.

Activate: Hold FF (+) and FZ (+) for 5 sec.
Ice tray thermistor temperature displayed - OK, OP open, SH short
Water valve test
Fan test, on or off
Ice level sensor switch test
Harvest motor system test

De-activate: Hold FF (+) for 5 sec.

complete description.

sec.

Standard compressor
Defrost heater
FF lighting
Water valve,water disp.
FZ lighting
Auger motor
Cube/crush solenoid
Perfect Temp Drawer
VCC Condensor fan
VCC Compressor

22
23
24
26
28
36
29
30
33
0-

Damper

Fresh food door

Freezer door

Defrost limit switch

Dispenser paddle

Ice door

FF Thermistor

FZ Thermistor

Ambient Thermistor

Software version

Evaporator fan

De-activate: Hold FF (+) for 5 sec.

LINE

BLK

P-3

GRN / YEL

P-1

BLK

CE MAKER

I

GRN/YEL

MOLD

BRN

THERMAL

CUT-OUT

MOTOR

BLK

MOUNTING

PLATE

POWER

ICE MAKER

RED

MOLD HEATER

165 WATTS

ICE MAKER

HOLD

SWITCH

C

BLK

NO

NC

RED

YEL

THERMOSTAT

NO

NC

C

WATER FILL

SWITCH

BLU

NO

NC

C

SHUT-OFF

SWITCH

LT. BLU

NEUTRAL

YEL

RED

ICE MAKER

YEL

P-4

LT. BLU

P-2

WATER VALVE

242155401 Wiring Diagram
ELUX FDBF 2500++ V5 with dispenser/GEN2 IM w/PTD