EdgeStar ESB1NG, ESB1LP, ESB2NG, ESB2LP Owner's Manual

V2.1-01242018

Built-In Side Burners

Owner’s Manual

For more information on other great EdgeStar products on the web, go to https://www.edgestar.com

Side Burner Models:

ESB1NG / ESB1LP
ESB2NG / ESB2LP

i

DANGER
If you smell gas:

 Shut off gas to the appliance.
 Extinguish any open flame.
 Open lid.
 If odor continues, keep away from the appliance and immediately call your gas

supplier or your fire department.

WARNING

 Do not store or use gasoline or other flammable liquids or vapors in the vicinity

of this or any other appliance.

 An LP cylinder not connected for use shall not be stored in the vicinity of this or

any other appliance.

Important: Your gas side burner is to be used outdoors only.

Important Safety Information

Improper handling can cause serious damage to the EdgeStar side burner and/or injury to the
user. This side burner is designed for domestic use only. Do not use the unit for industrial or
commercial use. Do not use in any enclosed areas, including buildings and garages. Any other
use may invalidate the warranty. Please review the ratings label for technical data related to this
unit.

Please read and follow the safety information listed below to reduce the risk of fire,
electric shock, or injury.

PROTECT CHILDREN:

Keep children away from the side burner during use and until the side burner has cooled after
you are finished using it. Do not allow children to operate the side burner.

ii

Gas and Electrical Safety

 This gas side burner must be installed in accordance with all local codes. In addition, the gas side

burner(s) must be installed in accord with the following codes, as applicable:

 National Fuel Gas Code, ANSI Z223.1 / NFPA 54
 Natural Gas and Propane Installation Code, CSA B149.1
 Propane Storage and Handling Code, CSA B149.2

 Where applicable, a standard electrical supply (115V, 60Hz) must be used for lights, rotisserie

motor(s), and all other apparatus that need to be plugged in. Electrical supplies must be properly
grounded in accordance with the National Electrical Code, ANSI / NFPA 70. Compliance with local
codes and ordinances is required.

 Never use dented, rusty, or damaged propane tanks.
 Always have an ABC fire extinguisher nearby. Never attempt to use water to extinguish a grease

fire.

 Check the tubes that lead into the burner for any blockage from insects, spiders, or food grease.
 Liquid petroleum (LP) or propane is highly flammable. Treat with care.
 Do not repair gas tanks yourself; seek repair from an authorized repair person.
 Do not repair damaged gas connectors, tank valves, or supply hoses.
 Store gas tanks in an upright, contained, and secure area. Do not leave filled tanks in a hot car or

car or car trunk.

 Check for gas leaks. If you detect a leak, immediately turn off the gas and do not attempt to ignite

the side burner until the leak is fixed.

 Never light cigarettes or matches, or expose open flames in the presence of a gas leak.
 Do not exceed the power outlet ratings.
 Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
 To protect against electric shock, do not immerse power cords or plugs in water or other liquids.
 Use outlets that cannot be turned off by a switch or pull chain.
 Do not operate any apparatus or accessories with power plugs missing the ground plug, a damaged

cord, or a loose socket. Do not bypass, cut, or remove the grounding plug.

 Unplug the unit if it is not going to be used for an extended period of time.
 Never plug or unplug the unit with wet hands.
 Do not use extension cords or power strips with this unit. You may need to contact your electrician if

it is necessary to use a longer cord or if you do not have a grounded outlet. Do not modify the
power cord’s length or share the outlet with other appliances.

 Do not start or stop the unit by switching the circuit’s power on and off.
 If the power cord is damaged, it must be replaced by the manufacturer or a qualified technician.
 Never repair the unit while it is plugged in.
 Immediately unplug the unit if it makes strange sounds, emits smells or smoke comes out of it, and

contact customer service.

 You should never attempt to repair the unit yourself. Contact customer service for service options if

the unit needs service.

 Never use charcoal or any other non-approved or solid fuel sources. This manual covers side

burners fueled by gas (LP and NG) only.

iii

Note: This owner’s manual is provided for reference use only. Specifications may

change without prior notice. Refer to the product label on your side burner for the latest
technical information.

General Safety

 To prevent back and other types of injuries, use at least two people to move and install the side

burner(s) and grilling equipment.

 This appliance is not intended for use by persons, including children, with reduced physical, sensory

or mental capabilities, unless they have been given supervision or instruction concerning the use of
the appliance by the person(s) responsible for their safety.

 Install the gas side burner(s) in a well-ventilated area.
 Do not place hot or warm items into the cooler before they cool down to room temperature.
 This side burner should not be installed indoors or in a garage, RV, under a carport, etc. Keep away

from surfaces that can catch fire.

 This side burner should be installed in a well-ventilated area. It is recommended that it is protected

from direct rain, sleet, snow, and / or moisture.

 This side burner is not intended to be used by children.
 Children should be supervised to ensure that they do not play with this product.
 Never allow children to crawl inside the side burner.
 Do not use this appliance near combustibles such as gasoline, benzene, thinner, etc.
 Take care when working with the gas side burner as there will be extremely hot surfaces.
 Only use in an upright position on a flat, level surface and provide proper ventilation.
 Do not pinch or kink the power supply line between the unit and cabinet.
 Do not leave any cleaning solutions in the unit.
 Do not use solvent-based cleaning agents or abrasive solutions to clean the unit as they may

damage the interior and exterior.

 Do not place any other appliances on top of the unit.
 Do not turn the unit upside down, on its side or at an angle off level.
 The Consumer Product Safety Commission recommends keeping the side burner at least 10 feet

away from your house or any building.

 Maintain all clearance requirements detailed in this user’s manual.
 Follow all food safety and handling requirements required by local codes. Do not let food sit

[unrefrigerated] for more than one hour before or after cooking.

 Never leave the side burner unattended while cooking.
 Never cook without the drip tray in place.

iv

PROPANE GAS SAFETY

 Your propane gas side burner (models ESB1LP and ESB2LP) is designed to operate on

propane gas only at a pressure regulated at 11 inches water column (WC) when equipped
with the correct propane orifices on the valves and a propane regulator on the supply line.

 EdgeStar LP side burners are designed to be used with a standard 20 lb. (9.1kg)

Department of Transportation (DOT) approved LP cylinder. No tanks larger than 20
lbs. are to be used. The tank must be marked in accordance with the latest DOT
specification for LP gas tanks: Specifications for LP gas Cylinders (DOT CFR49).

 Burners must be inspected and cleaned before each use.

Beware of Spiders

Spiders and small insects occasionally spin webs or make nests in the burners during

warehousing, transit, and/or after long period of not using the side burner. These webs can lead
to a gas flow obstruction, which could result in a fire in and around the burner tubes. This type
of fire is known as “flashback” and can cause serious damage to your side burner and create
an unsafe operating condition for the side burner user. Although an obstructed burner tube is
not the only cause of “flashback,” it is the most common cause. Frequent inspection of the

burners is necessary.

v

NATURAL GAS SAFETY

 Your natural gas side burner (models ESB1NG and ESB2NG) is designed to operate on

natural gas only at a pressure regulated at 4 inches water column (WC) when equipped with
the correct natural gas orifices on the valves and a natural gas regulator on the supply line.

 Burners must be inspected and cleaned before each use.

Beware of Spiders

Spiders and small insects occasionally spin webs or make nests in the burners during

warehousing, transit, and/or after long period of not using the side burner. These webs can lead
to a gas flow obstruction, which could result in a fire in and around the burner tubes. This type
of fire is known as “flashback” and can cause serious damage to your side burner and create
an unsafe operating condition for the side burner user. Although an obstructed burner tube is
not the only cause of “flashback,” it is the most common cause. Frequent inspection of the

burners is necessary.

Table of Contents

IMPORTANT SAFETY INFORMATION ................................................................................................................ I

INTRODUCTION ............................................................................................................................................. 1

PARTS IDENTIFICATION .................................................................................................................................. 2

SIDE BURNER DIMENSIONS ............................................................................................................................ 4

ISLAND / CABINET CUTOUT DIMENSIONS ....................................................................................................... 6

MAINTAINING ADEQUATE VENTILATION ........................................................................................................ 7

INSTALLING THE GAS SIDE BURNER ................................................................................................................ 8

TYPES OF INSTALLATION ............................................................................................................................................ 9

LIQUID PROPANE (LP) INSTALLATION AND REQUIREMENTS: .......................................................................................... 10

NATURAL GAS (NG) INSTALLATION AND REQUIREMENTS: ............................................................................................ 13

CHECKING FOR GAS LEAKS ........................................................................................................................... 15

ELECTRICAL REQUIREMENTS ..................................................................................................................................... 16

PLUGGING IN THE LIGHTS ........................................................................................................................................ 17

INCLUDED COOKING COMPONENTS ............................................................................................................. 18

CHECKING THE IGNITER ........................................................................................................................................... 18

LIGHTING THE BURNER(S) ........................................................................................................................................ 19

CLEANING AND MAINTENANCE .................................................................................................................... 21

CLEANING THE BURNER(S) ....................................................................................................................................... 21

REINSTALLING THE BURNER(S) ................................................................................................................................. 22

CLEANING THE COOKING GRIDDLE ............................................................................................................................ 23

CLEANING THE DRIP TRAY........................................................................................................................................ 23

EXTERIOR CLEANING ............................................................................................................................................... 23

CARING FOR STAINLESS STEEL .................................................................................................................................. 24

SPECIFICATIONS ........................................................................................................................................... 25

EDGESTAR LIMITED WARRANTY ................................................................................................................... 26

First Time Operating Instructions

Before use, make sure all packaging labels and materials are all removed from the unit. Be sure
to keep track of all included parts and pieces before discarding packaging materials. It is advised
that you keep the original box and packaging materials in case you are ever to move or ship the
appliance in the future.
The instruction manual should be read in full before use.

Introduction

Thank you for purchasing this EdgeStar gas side burner. We hope that this purchase will be
the beginning of a lasting and rewarding relationship between you and EdgeStar. We will
provide the customer support and exemplary products necessary to nurture that relationship.

This manual contains important information regarding the proper installation, use and
maintenance of your gas side burner. Following this manual will ensure that your product will
work at its peak performance and efficiency.

Please save the original product packaging in case you need to safely transport your gas side
burner.

For Your Records:

Please write down the model number and serial number below for future reference. Both
numbers are located on the ratings label on the back of your unit and are needed to obtain
warranty service. You may also want to staple your receipt to this manual as it is the proof
of your purchase, and is also needed for service under your warranty.

Model Number:
Serial Number:

Date of Purchase:
For a more efficient experience, please do the following before contacting customer service:
 If you received a damaged product, immediately contact the retailer or dealer that sold you

the product.
 Read and follow this instruction manual carefully to help you install, use and maintain your

gas side burner.
 Read the troubleshooting section of this manual as it will help you diagnose and solve

common issues.
 Visit us on the web at https:/www.edgestar.com to register your product, download

product guides, additional troubleshooting resources and up-to-date information. You can

also find an interactive self-diagnostic tool at https://support.edgestar.com
 If you need warranty service, our friendly customer service representatives are available

via email at [e-mail] or by telephone at 1 [phone].

2

Parts Identification

ESB1NG / ESB1LP

(Single Gas Side Burner)

Part Description

Included Quantity

Burner

1

Igniting Line

1

Stainless Steel Flexline

1

Igniting Valve

1

Igniting Pin

1

LED Light

1

Control Panel (Face Plate)

1

Gas Control (Burner) Knob

1

Knob Bezel

1

Light Switch

1

Firebox

1

Drip Tray

1

Cooking Griddle

1

Lid

1

Lid Handle

1

Gas Manifold

1

Electrode Wire

1

Transformer

1

3

ESB2NG / ESB2LP

(Double Side Burner)

Part Description

Included Quantity

Burner

2

Igniting Line

2

Stainless Steel Flexline

2

Igniting Valve

1

Igniting Pin

2

LED Light

2

Control Panel (Face Plate)

1

Gas Control (Burner) Knob

2

Knob Bezel

2

Light Switch

1

Firebox

1

Drip Tray

1

Cooking Griddle

1

Lid

1

Lid Handle

1

Gas Manifold

1

Electrode Wire

1

Transformer

1

4

Side Burner Dimensions

ESB1NG / ESB1LP