Page 1
MPA4-400
SERVICE MANUAL
CHANNEL 1 CHANNEL 3
5
CHANNEL 2
CLIP
SP
SP5CLIP
5
CLIP
SP
100 0 10 0 10 0
VOL
MAINS INPUT
GND
GND LINK
BRIDGE IN 1
STEREO
BRIDGE
IN 1+IN 2
BRIDGE IN 3
STEREO
OFFON
BRIDGE
IN 3+IN 4
XLR CONNECTIONS: PIN 1 - GROUND, PIN 2 - PHASE, PIN 3 - NON PHASE
LP FILTER
OFF
ON
HP FILTER
OFF
ON
CHANNEL 2
IN 2
CHANNEL 4
IN 4
IN 2
LINK CH 1
IN 4
LINK CH 2
CHANNEL 1
IN 1
CHANNEL 3
IN 3 LINK CH 1
IN 1+IN 2
IN 1
IN 3
OUTPUT
BRIDGED
CH 4 + CH 3 +
FOR BRIDGED OUTPUT USE RED POSTS ONLY.
MINIMUM LOAD: 4 OHM STEREO, 8 OHM BRIDGE
BRIDGED
CH 2 +
CH 1 +
CH 2 -
CH 3 -CH 4 -
CH 1 -
CHANNEL 4
5
10
VOLVOLVOL
SP
CLIP
LEC RE
MP
MULTICHANNEL
THERMAL
POWER AMPLIFIER
POWER
A4-
400
OFF
ON
Page 2
SERVICE MANUAL MPA4-400
INDEX
- BLOCK DIAGRAM
- FUNCTIONING DESCRIPTION
- SCHEMATICS
Power amplifier
Inputs
Power Supply + Outs
Leds + potentiometers
- COMPONENTS LOCATION SCHEMA
Power amplifier
Power Supply + Inputs + Outs
Leds + potentiometers
- TESTING AND QUALITY CONTROL
- TECHNICAL CHARACTERISTICS
- WIRING DIAGRAM
- CONFIGURATION DIAGRAM
- MECHANICAL DIAGRAM
- PACKING DIAGRAM
Page 3
Page 4
Queralt
author:
C
E
num:
The amplifying stage basic structure is actually the one commonly used until now, this is,
a push-pull mounted A-B class amplifier, using P-type (IRFP9240) and N-type (IRFP240)
mosfets.
The system's controlling core is a NE5534 OpAmp, which is internally compensated in
order to obtain an amplifying gain ratio equal or greater than 3. The amplifier's feedback
runs through a resistor and a capacitor associated to the OpAmp's non-inverting input.
Transistors BF871 and BF872 are common-base configured, becoming actually a current
source structure. They accomplish a dual function: on one hand, they polarise the mosfet's
gate-source junction, keeping them on their conduction knee. On the other hand, they
carry out the OpAmp's output voltage variations, referred to signal ground.
The polarisation current adjustment is fixed by a 2k5 trimming potentiometer connected to
the BF transistors base. This current is added to the current source's output, which passes
through the BF-transistors load resistors. The bias current stability against temperature is
fixed through the BD437 transistors. Their temperature- dependent base-emitter voltage
curve is used to alter adequately the current source's reference voltage. As a
consequence, if the temperature rises, the reference voltage decreases, thus the gatesource voltage also does, and finally the bias current also decreases.
The Zobel network, formed by a resistor-inductor-capacitor group, and which is located at
the amplifier's output, intends to keep the amplifier's load impedance as constant as
possible, no matter which load is connected to the stage's output, or which signal
frequency is to be amplified, in order to prevent an inverted-phase feedback signal.
In order to avoid a DC offset on the output signal, a diac-triac tandem system is used,
which shorts the output to signal ground when the DC level is enough to get the diac
triggered. To prevent this from happening while carrying audio signal (sine-wave, music),
the diac's reference voltage is taken from a filter formed by resistor R161 and capacitor
C123.
The protection circuitry supervises at any time the power consumed by the MOSFETS. The
circuitry basically consists on two sections: MOSFET's drain current (Id) monitoring and
drain-source voltage (Vds) monitoring.
When the drain current exceeds a certain limiting value, a transistor (called controltransistor) becomes conducting, together with an auxiliary circuitry (helper), formed by a
transistor (which is the same type as the control-transistor) and a 8'2V Zener diode. This
value determines the point where the auxillary circuitry starts to run. The helpertransistor's base-emitter junction curve is used to obtain a non-linear variation on the
MOSFETS gate-source voltage control, and thus on their drain current.
LE R
52..0017
version:
01.00
approved:
date:
title:
020927
project:
FUNCTIONING DESCRIPTION
EP14-02
product:
MPA4-400
52-0017-0100 EP14-02.doc 1 of 2
Page 5
Moreover, as the helper-transistor's base-emitter current is temperature-dependent, the
controlling circuitry (basically the control-transistor) compensates the safe operation area
(SOA) drift due to temperature.
If the MOSFET's drain-source voltage (Vds) drops too low, a second circuitry actuates to
alter the control-transistor's triggering level, obtaining a SOA-like curve section and a
current stage, which can be adjusted adequately in order to maintain the MOSFET's power
consumption as close as possible to its SOA.
Moreover, the amplifier also includes an ANTICLIP system.
When the amplifier reaches its clipping level, the OpAmp becomes unable to keep the
system under control, and as a consequence ±V peaks appear at its output (15V power
supply). This peaks are used to be rectified and sent to an optocupler (led-resistor) which
modifies its impedance as a function of those peaks' amplitude. The resulting impedance is
part of a voltage divider, together with the amplifier's input impedance. So, as the
optocoupler increases its impedance, the amplifier's input signal level decreases until the
system becomes stable.
Also a dual-function temperature control circuitry is provided:
- Temperature-depending control of the cooling fan speed, whose voltage supply is variable
between 7 and 14 Vac.
- Amplifier shutdown when temperature exceeds approximately 90ºC.
The circuitry is formed by LM35D-type IC, which acts like a thermal probe, an amplifier,
thermal probe level comparator and a 7805-type voltage regulator.
The amplifier is responsible for the cooling fan speed control. The comparator triggers a
relay, which cuts off the MOSFETs' bias current by shunting a 22Ω resistance to the BFtype transistors' load resistors. This way, the output signal of the amplifier is effectively
cutted off.
The STAND-BY circuit.
This circuit keeps the safety relay closed for about 10 seconds, thus the MOSFET's bias
current is cutted off during this period, until the whole system reaches again a voltagestable situation. Due to this, hearing annoying transients and noises during start up
through the loudspeakers is avoided. This delay is obtained by a RC-cell, where R=287K,
and C=47µF/50V. During start up, this RC-cell's voltage smoothly rises until the 40106type Trigger-Schmitt trigging level is reached, and the amplifier starts functioning. C=47µF
resets or discharges when the unit is turned off. During a short period of time, a BC817type transistor acts like a switch, connecting two 75Ω parallel resistors to C=47µ/50V.
52-0017-0100 EP14-02.doc 2 of 2
Page 6
Page 7
Page 8
Page 9
Page 10
Page 11
Page 12
Page 13
Page 14
Page 15
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCXCD12200
22p
C101
FCXCD41000
100n
C102
FCXCD41000
100n
C103
FCCE250100
10u/50
C104
FCCE250470
47u/50
C105
FCXCD16800
68p
C106
FCXCD16800
68p
C107
FCCE350470
47u/100
C108
FCCE350470
47u/100
C109
FCCE250100
10u/50
C110
FCXCD41000
100n
C111
FCXCD11500
15p
C112
FCXCD41000
100n
C113
FCCE250100
10u/50
C114
FCXCD44700
470n
C115
FCXCD44700
470n
C116
FCXCD11500
15p
C117
FCXCD11500
15p
C118
FCCDK52200
C220n/100V
C119
FCCDK52200
C220n/100V
C120
FCXCD26800
680p
C121
FCXCD26800
680p
C122
FCCDK20010
C1u/63V
C123
FCXCD40100
10n
C124
FCXCD40100
10n
C125
FCCDH71100
C100n/400V
C126
FCCDH71047
C47n/400V
C127
FCXCD41000
100n
C128
FCXCD41000
100n
C129
FCXCD41000
100n
C130
FCCE250100
10u/50
C131
FCXCD44700
470n
C132
FCCE250100
10u/50
C133
FCCE100000
47u/16
C134
FCXCD44700
470n
C135
FCCE250470
47u/50
C136
FCCE250470
47u/50
C137
FCCE250100
10u/50
C138
FCCE154700
470u/25
C139
FCXCD12200
22p
C140
FCXCD41000
100n
C141
FCXCD41000
100n
C142
FCCE250100
10u/50
C143
FCCE250470
47u/50
C144
FCXCD16800
68p
C145
FCXCD16800
68p
C146
FCCE350470
47u/100
C147
FCCE350470
47u/100
C148
FCCE250100
10u/50
C149
FCXCD41000
100n
C150
FCXCD11500
15p
C151
FCXCD41000
100n
C152
FCCE250100
10u/50
C153
FCXCD44700
470n
C154
FCXCD44700
470n
C155
FCXCD11500
15p
C156
40-0113-0105 EP14-02 MPA4-400.xls 1 of 10
Page 16
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCXCD11500
15p
C157
FCCDK52200
C220n/100V
C158
FCCDK52200
C220n/100V
C159
FCXCD26800
680p
C160
FCXCD26800
680p
C161
FCCDK20010
C1u/63V
C162
FCXCD40100
10n
C163
FCXCD40100
10n
C164
FCCDH71100
C100n/400V
C165
FCCDH71047
C47n/400V
C166
FCCE100000
47u/16
C167
FCCE250470
47u/50
C168
FCXCD41000
100n
C169
FCPERL2550
Cer. Bead
CB101
FCPERL2550
Cer. Bead
CB102
FCPERL2550
Cer. Bead
CB103
FCPERL2550
Cer. Bead
CB104
FCCI009560
Printed Board 11.0956
CI101
FCXDDBAS28
BAS28
D101
FCXZ000075
Z7.5V
D102
FCXDDBAS28
BAS28
D103
FCXZ000039
Z3.9V
D104
FCXZ000039
Z3.9V
D105
FCLEDSMD20
TLMH3101
D106
FCLEDSMD20
TLMH3101
D107
FCDD041200
Z12
D108
FCDD041200
Z12
D109
FCDD041200
Z12
D110
FCDD041200
Z12
D111
FCDD041200
Z12
D112
FCDD041200
Z12
D113
FCXZ000180
Z18V
D114
FCXZ000180
Z18V
D115
FCDD102700
Z27V/1
D116
FCDD102700
Z27V/1
D117
FCDIDB3000
DB3
D118
FCXZ000082
Z8.2V
D119
FCXZ000082
Z8.2V
D120
FCXZ000056
Z5.6V
D121
FCXDDBAS16
BAS16
D122
FCXDD40070
1N4007
D123
FCXZ000120
Z12V
D124
FCXDDBAS28
BAS28
D125
FCXDDBAS16
BAS16
D126
FCXDDBAS16
BAS16
D127
FCXDD40070
1N4007
D128
FCXZ000100
Z10V
D129
FCXDDBAS16
BAS16
D130
FCXDDBAS16
BAS16
D131
FCXDDBAS28
BAS28
D132
FCXZ000075
Z7.5V
D133
FCXDDBAS28
BAS28
D134
FCXZ000039
Z3.9V
D135
FCXZ000039
Z3.9V
D136
FCLEDSMD20
TLMH3101
D137
FCLEDSMD20
TLMH3101
D138
40-0113-0105 EP14-02 MPA4-400.xls 2 of 10
Page 17
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCDD041200
Z12
D139
FCDD041200
Z12
D140
FCDD041200
Z12
D141
FCDD041200
Z12
D142
FCDD041200
Z12
D143
FCDD041200
Z12
D144
FCXZ000180
Z18V
D145
FCXZ000180
Z18V
D146
FCDD102700
Z27V/1
D147
FCDD102700
Z27V/1
D148
FCDIDB3000
DB3
D149
FCXZ000082
Z8.2V
D150
FCXZ000082
Z8.2V
D151
FCXZ000056
Z5.6V
D152
FCXDD40070
1N4007
D153
FCXZ000120
Z12V
D154
FCXDDBAS28
BAS28
D155
FCXDDBAS16
BAS16
D156
FCXDDBAS16
BAS16
D157
FCFUS50350
F8A
F101
FCFUS50350
F8A
F102
FCFUS50350
F8A
F103
FCFUS50350
F8A
F104
FCFER43220
Ferrite
FB101
FCFER43220
Ferrite
FB102
FCFER43220
Ferrite
FB103
FCFER43220
Ferrite
FB104
FCFER43220
Ferrite
FB105
FCFER43220
Ferrite
FB106
FCFER43220
Ferrite
FB107
FCFER43220
Ferrite
FB108
FCFER43220
Ferrite
FB109
FCFER43220
Ferrite
FB110
FCFER43220
Ferrite
FB111
FCFER43220
Ferrite
FB112
FCMECT0220
Heatsink f/ TO220
HS101
FCMECT0220
Heatsink f/ TO220
HS102
FCMECT0220
Heatsink f/ TO220
HS103
FCMECT0220
Heatsink f/ TO220
HS104
FCMECT0220
Heatsink f/ TO220
HS105
FCMECT0220
Heatsink f/ TO220
HS106
FCMECT0220
Heatsink f/ TO220
HS107
FCRAD13850
Heatsink f/ Power Module
HS108
FCOPTVTL50
VTL 5C8
IC101
FCIC071010
TL071
IC102
FCIC553410
NE5534A
IC103
FCIC431010
LM431AC
IC104
FCIC350000
LM35DZ
IC105
FCIC072010
TL072
IC106
FCREG78050
7805
IC107
FCIC409301
HEF4093B
IC108
FCOPTVTL50
VTL 5C8
IC109
FCIC071010
TL071
IC110
FCIC553410
NE5534A
IC111
FCIC409301
HEF4093B
IC112
FCMICTO126
Insulant TO126
IN101
40-0113-0105 EP14-02 MPA4-400.xls 3 of 10
Page 18
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCMICTO126
Insulant TO126
IN102
FCMICTO126
Insulant TO126
IN103
FCMICTO126
Insulant TO126
IN104
FCMICTO126
Insulant TO126
IN105
FCMICTO126
Insulant TO126
IN106
FCMICTO126
Insulant TO126
IN107
FCTIRKON00
Insulating polymer
IN108
FCTIRKON00
Insulating polymer
IN109
FCMICTO126
Insulant TO126
IN112
FCCTM00040
B4B-EH-A
J101
FCCTM00030
B3B-EH-A
J102
FCTERM0100
Jumper Pin
J103
FCTERM0100
Jumper Pin
J104
FCTERM0100
Jumper Pin
J105
FCTERM0100
Jumper Pin
J106
FCTERM0100
Jumper Pin
J107
FCTERM0100
Jumper Pin
J108
FCCTM00030
B3B-EH-A
J109
FCCTM00020
B2B-EH-A
J110
FCCTM00040
B4B-EH-A
J111
FCTERM0100
Jumper Pin
J112
FCTERM0100
Jumper Pin
J113
FCTERM0100
Jumper Pin
J114
FCTERM0100
Jumper Pin
J115
FCTERM0100
Jumper Pin
J116
FCTERM0100
Jumper Pin
J117
FCREL00300
TQ2-12V
K101
FCREL00300
TQ2-12V
K102
FCIND00100
1uH
L101
FCIND00100
1uH
L102
FCMJ000100
Jumper
MJ101
FCMJ000100
Jumper
MJ102
FCMJ000100
Jumper
MJ103
FCMJ000100
Jumper
MJ104
FCMJ000100
Jumper
MJ105
FCMJ000100
Jumper
MJ106
FCPINZAM00
Clamp WD. 00.2636
MP101
FCPINZAM00
Clamp WD. 00.2636
MP102
FCTUE00300
Nut M3
NV101
FCTUE00300
Nut M3
NV102
FCTUE00300
Nut M3
NV103
FCTUE00300
Nut M3
NV104
FCTUE00300
Nut M3
NV105
FCTUE00300
Nut M3
NV106
FCPORF3150
3/15P
PF101
FCPORF3150
3/15P
PF102
FCPORF3150
3/15P
PF103
FCPORF3150
3/15P
PF104
FCTR437000
BD437
Q101
FCTR437000
BD437
Q102
FCTR471000
BF471
Q103
FCTR472000
BF472
Q104
FCTR340000
MJE340
Q105
FCTR350000
MJE350
Q106
FCTR340000
MJE340
Q107
FCTR350000
MJE350
Q108
40-0113-0105 EP14-02 MPA4-400.xls 4 of 10
Page 19
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCTR243000
IRFP9240
Q109
FCTR240000
IRFP240
Q110
FCTR243000
IRFP9240
Q111
FCTR240000
IRFP240
Q112
FCXTT08570
BC857B
Q113
FCXTT08470
BC847B
Q114
FCXTT08570
BC857B
Q115
FCXTT08470
BC847B
Q116
FCTR240000
IRFP240
Q117
FCTR243000
IRFP9240
Q118
FCXTT08570
BC857B
Q119
FCXTT08470
BC847B
Q120
FCTI246000
BTB24600B
Q121
FCXTT08570
BC857B
Q122
FCXTT08470
BC847B
Q123
FCTR254010
2N5401
Q124
FCXTT08470
BC847B
Q125
FCXTT08170
BC817/25
Q126
FCTR437000
BD437
Q127
FCTR437000
BD437
Q128
FCTR471000
BF471
Q129
FCTR472000
BF472
Q130
FCTR340000
MJE340
Q131
FCTR350000
MJE350
Q132
FCTR340000
MJE340
Q133
FCTR350000
MJE350
Q134
FCTR243000
IRFP9240
Q135
FCTR240000
IRFP240
Q136
FCTR243000
IRFP9240
Q137
FCTR240000
IRFP240
Q138
FCXTT08570
BC857B
Q139
FCXTT08470
BC847B
Q140
FCXTT08570
BC857B
Q141
FCXTT08470
BC847B
Q142
FCTR240000
IRFP240
Q143
FCTR243000
IRFP9240
Q144
FCXTT08570
BC857B
Q145
FCXTT08470
BC847B
Q146
FCTI246000
BTB24600B
Q147
FCXTT08570
BC857B
Q148
FCXTT08470
BC847B
Q149
FCTR254010
2N5401
Q150
FCXTT08470
BC847B
Q151
FCXTT08170
BC817/25
Q152
FCXR561000
1M
R101
FCXR542150
21k5
R102
FCXR542150
21k5
R103
FCXR542150
21k5
R104
FCXR551000
100k0
R105
FCXR531000
1k0
R106
FCXR531000
1k0
R107
FCXR543480
34k8
R108
FCXR543480
34k8
R109
FCXR531960
1k96
R110
FCXR535620
5k62
R111
FCXR571000
10M
R112
40-0113-0105 EP14-02 MPA4-400.xls 5 of 10
Page 20
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCXR531210
1k21
R113
FCXR531210
1k21
R114
FCXR525110
511
R115
FCXR521780
178
R116
FCXR525110
511
R117
FCXR521780
178
R118
FCXR515620
56.2
R119
FCXR531470
1k47
R120
FCXR531470
1k47
R121
FCXR515620
56.2
R122
FCXR526810
681
R123
FCXR531470
1k47
R124
FCRJG44700
4k7
R125
FCXR526810
681
R126
FCXR511000
10.0
R127
FCXR515620
56.2
R128
FCXR523160
316
R129
FCXR515620
56.2
R130
FCXR511000
10.0
R131
FCXR523160
316
R132
FCRF426800
NF68/1
R133
FCRF426800
NF68/1
R134
FCRF232200
NF220/ 1/2
R135
FCRF232200
NF220/ 1/2
R136
FCRF232200
NF220/ 1/2
R137
FCRF232200
NF220/ 1/2
R138
FCRY000100
W0.22/5
R139
FCRY000100
W0.22/5
R140
FCRY000100
W0.22/5
R141
FCRY000100
W0.22/5
R142
FCXR542610
26k1
R143
FCXR542370
23k7
R144
FCRF232200
NF220/ 1/2
R145
FCRF232200
NF220/ 1/2
R146
FCXR525620
562
R147
FCXR525620
562
R148
FCXR524640
464
R149
FCXR524640
464
R150
FCXR543480
34k8
R151
FCXR543480
34k8
R152
FCRY000100
W0.22/5
R153
FCRY000100
W0.22/5
R154
FCXR536810
6k81
R155
FCXR543480
34k8
R156
FCXR543480
34k8
R157
FCXR536810
6k81
R158
FCXR543480
34k8
R159
FCXR543480
34k8
R160
FCXR544640
46k4
R161
FCXR521000
100.0
R162
FCXR521000
100.0
R163
FCXR541330
13k3
R164
FCXR541330
13k3
R165
FCXR521000
100.0
R166
FCXR531000
1k0
R167
FCRY000250
6.8/5W
R168
40-0113-0105 EP14-02 MPA4-400.xls 6 of 10
Page 21
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCXR531000
1k0
R169
FCXR521000
100.0
R170
FCRC521000
10/2
R171
FCRC512200
2.2/2
R172
FCXR534220
4k22
R173
FCXR534220
4k22
R174
FCXR534220
4k22
R175
FCXR534220
4k22
R176
FCXR544640
46k4
R177
FCXR544640
46k4
R178
FCXR544640
46k4
R179
FCXR532150
2k15
R180
FCXR541000
10k0
R181
FCXR531620
1k62
R182
FCXR524640
464
R183
FCXR544640
46k4
R184
FCXR541000
10k0
R185
FCXR551000
100k0
R186
FCXR542150
21k5
R187
FCXR551000
100k0
R188
FCXR531000
1k0
R189
FCXR544640
46k4
R190
FCXR535620
5k62
R191
FCXR562200
2M2
R192
FCXR551000
100k0
R193
FCXR542150
21k5
R194
FCXR552870
287k
R195
FCXR541000
10k0
R196
FCXR551000
100k0
R197
FCXR528250
825
R198
FCXR531470
1k47
R199
FCXR515620
56.2
R200
FCXR528250
825
R201
FCXR515620
56.2
R202
FCXR521780
178
R203
FCXR531000
1k0
R204
FCXR561000
1M
R205
FCXR542150
21k5
R206
FCXR542150
21k5
R207
FCXR542150
21k5
R208
FCXR551000
100k0
R209
FCXR531000
1k0
R210
FCXR531000
1k0
R211
FCXR543480
34k8
R212
FCXR543480
34k8
R213
FCXR571000
10M
R214
FCXR531960
1k96
R215
FCXR535620
5k62
R216
FCXR531210
1k21
R217
FCXR531210
1k21
R218
FCXR525110
511
R219
FCXR521780
178
R220
FCXR525110
511
R221
FCXR521780
178
R222
FCXR515620
56.2
R223
FCXR531470
1k47
R224
40-0113-0105 EP14-02 MPA4-400.xls 7 of 10
Page 22
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCXR531470
1k47
R225
FCXR515620
56.2
R226
FCXR526810
681
R227
FCXR531470
1k47
R228
FCRJG44700
4k7
R229
FCXR526810
681
R230
FCXR511000
10.0
R231
FCXR515620
56.2
R232
FCXR523160
316
R233
FCXR523160
316
R234
FCXR515620
56.2
R235
FCXR511000
10.0
R236
FCRF426800
NF68/1
R237
FCRF426800
NF68/1
R238
FCRF232200
NF220/ 1/2
R239
FCRF232200
NF220/ 1/2
R240
FCRF232200
NF220/ 1/2
R241
FCRF232200
NF220/ 1/2
R242
FCRY000100
W0.22/5
R243
FCRY000100
W0.22/5
R244
FCRY000100
W0.22/5
R245
FCRY000100
W0.22/5
R246
FCXR542610
26k1
R247
FCXR542370
23k7
R248
FCRF232200
NF220/ 1/2
R249
FCRF232200
NF220/ 1/2
R250
FCXR525620
562
R251
FCXR525620
562
R252
FCXR524640
464
R253
FCXR524640
464
R254
FCXR543480
34k8
R255
FCXR543480
34k8
R256
FCRY000100
W0.22/5
R257
FCRY000100
W0.22/5
R258
FCXR536810
6k81
R259
FCXR543480
34k8
R260
FCXR543480
34k8
R261
FCXR536810
6k81
R262
FCXR543480
34k8
R263
FCXR543480
34k8
R264
FCXR544640
46k4
R265
FCXR521000
100.0
R266
FCXR521000
100.0
R267
FCXR541330
13k3
R268
FCXR541330
13k3
R269
FCXR521000
100.0
R270
FCXR531000
1k0
R271
FCRY000250
6.8/5W
R272
FCXR531000
1k0
R273
FCXR521000
100.0
R274
FCRC521000
10/2
R275
FCRC512200
2.2/2
R276
FCXR534220
4k22
R277
FCXR534220
4k22
R278
FCXR534220
4k22
R279
FCXR534220
4k22
R280
40-0113-0105 EP14-02 MPA4-400.xls 8 of 10
Page 23
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCXR544640
46k4
R281
FCXR544640
46k4
R282
FCXR544640
46k4
R283
FCXR544640
46k4
R284
FCXR542150
21k5
R285
FCXR544640
46k4
R286
FCXR542150
21k5
R287
FCXR541000
10k0
R288
FCXR552870
287k
R289
FCXR551000
100k0
R290
FCXR515620
56.2
R291
FCXR515620
56.2
R292
FCXR521780
178
R293
FCXR531000
1k0
R294
FCT8040060
Screw M4x6 SPAN
SC101
FCT7503008
Screw M3x8
SC102
FCT7503008
Screw M3x8
SC103
FCT7503008
Screw M3x8
SC104
FCT7503008
Screw M3x8
SC105
FCT7503008
Screw M3x8
SC106
FCT7503008
Screw M3x8
SC107
FCSEPPM000
Plastic Spacer f/board ct.
SC108
FCSEPPM000
Plastic Spacer f/board ct.
SC109
FCT8040060
Screw M4x6 SPAN
SC110
FCT8040060
Screw M4x6 SPAN
SC111
FCT8030100
Screw M3x10 SPA
SC112
FCT8030100
Screw M3x10 SPA
SC113
FCT8030100
Screw M3x10 SPA
SC114
FCT8030100
Screw M3x10 SPA
SC115
FCT8030100
Screw M3x10 SPA
SC116
FCT8030100
Screw M3x10 SPA
SC117
FCT8030100
Screw M3x10 SPA
SC118
FCT8030100
Screw M3x10 SPA
SC119
FCT8030100
Screw M3x10 SPA
SC120
FCT8030100
Screw M3x10 SPA
SC121
FCSEPPM000
Plastic Spacer f/board ct.
SC122
FCSEPPM000
Plastic Spacer f/board ct.
SC123
FCT8030100
Screw M3x10 SPA
SC124
FCT8030100
Screw M3x10 SPA
SC125
FCT8040060
Screw M4x6 SPAN
SC126
FCTERMF280
Faston 2.8mm
TS101
FCTERMF280
Faston 2.8mm
TS102
FCTERMF280
Faston 2.8mm
TS103
FCTERMF280
Faston 2.8mm
TS104
FCMECPON19
19mm
W100
FCMECPON19
19mm
W101
FCMECPON19
19mm
W102
FCMECPON19
19mm
W103
FCMECPON19
19mm
W104
FCMECPON19
19mm
W105
FCMECPON19
19mm
W106
FCMECPON19
19mm
W107
FCMECPON19
19mm
W108
FCMECPON19
19mm
W109
FCMECPON19
19mm
W110
FCMECPON19
19mm
W111
40-0113-0105 EP14-02 MPA4-400.xls 9 of 10
Page 24
PARTS LIST: PRINTED CIRCUIT 11.0956.03.01
Code
Description
Reference
FCMECPON19
19mm
W112
FCMECPON19
19mm
W113
FCMECPON19
19mm
W114
FCMECPON19
19mm
W115
FCMECPON19
19mm
W116
FCMECPON19
19mm
W117
FCARM32010
Metal Washer 3.2x6x1
WA101
FCARM32010
Metal Washer 3.2x6x1
WA102
FCARDE0300
Toothed Washer M3
WA103
FCARM32010
Metal Washer 3.2x6x1
WA104
FCARM32010
Metal Washer 3.2x6x1
WA105
FCARM32010
Metal Washer 3.2x6x1
WA106
FCARM32010
Metal Washer 3.2x6x1
WA107
FCARM32010
Metal Washer 3.2x6x1
WA108
FCARM32010
Metal Washer 3.2x6x1
WA109
FCARDE0300
Toothed Washer M3
WA114
FCARDE0300
Toothed Washer M3
WA115
FCARDE0300
Toothed Washer M3
WA116
FCARDE0300
Toothed Washer M3
WA117
FCARDE0300
Toothed Washer M3
WA118
FC0H111500
1111.05.00
WI107
FC0H110500
1110.05.00
WI108
40-0113-0105 EP14-02 MPA4-400.xls 10 of 10
Page 25
Page 26
Page 27
Page 28
Page 29
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXCD12200
22p
C101
FCXCD41000
100n
C102
FCXCD41000
100n
C103
FCCE250100
10u/50
C104
FCCE250470
47u/50
C105
FCXCD16800
68p
C106
FCXCD16800
68p
C107
FCCE350470
47u/100
C108
FCCE350470
47u/100
C109
FCCE250100
10u/50
C110
FCXCD41000
100n
C111
FCXCD11500
15p
C112
FCXCD41000
100n
C113
FCCE250100
10u/50
C114
FCXCD44700
470n
C115
FCXCD44700
470n
C116
FCXCD11500
15p
C117
FCXCD11500
15p
C118
FCCDK52200
C220n/100V
C119
FCCDK52200
C220n/100V
C120
FCXCD26800
680p
C121
FCXCD26800
680p
C122
FCCDK20010
C1u/63V
C123
FCXCD40100
10n
C124
FCXCD40100
10n
C125
FCCDH71100
C100n/400V
C126
FCCDH71047
C47n/400V
C127
FCXCD41000
100n
C128
FCXCD41000
100n
C129
FCXCD41000
100n
C130
FCCE250100
10u/50
C131
FCXCD44700
470n
C132
FCCE250100
10u/50
C133
FCCE100000
47u/16
C134
FCXCD44700
470n
C135
FCCE250470
47u/50
C136
FCCE250470
47u/50
C137
FCCE250100
10u/50
C138
FCCE154700
470u/25
C139
FCXCD12200
22p
C140
FCXCD41000
100n
C141
FCXCD41000
100n
C142
FCCE250100
10u/50
C143
FCCE250470
47u/50
C144
FCXCD16800
68p
C145
FCXCD16800
68p
C146
FCCE350470
47u/100
C147
FCCE350470
47u/100
C148
FCCE250100
10u/50
C149
FCXCD41000
100n
C150
FCXCD11500
15p
C151
FCXCD41000
100n
C152
FCCE250100
10u/50
C153
FCXCD44700
470n
C154
FCXCD44700
470n
C155
FCXCD11500
15p
C156
40-0113-0102 EP14-02.xls 1 of 10
Page 30
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXCD11500
15p
C157
FCCDK52200
C220n/100V
C158
FCCDK52200
C220n/100V
C159
FCXCD26800
680p
C160
FCXCD26800
680p
C161
FCCDK20010
C1u/63V
C162
FCXCD40100
10n
C163
FCXCD40100
10n
C164
FCCDH71100
C100n/400V
C165
FCCDH71047
C47n/400V
C166
FCCE100000
47u/16
C167
FCCE250470
47u/50
C168
FCXCD41000
100n
C169
FCPERL2550
Cer. Bead
CB101
FCPERL2550
Cer. Bead
CB102
FCPERL2550
Cer. Bead
CB103
FCPERL2550
Cer. Bead
CB104
FCCI009560
Printed Board 11.0956
CI101
FCXDDBAS28
BAS28
D101
FCXZ000075
Z7.5V
D102
FCXDDBAS28
BAS28
D103
FCXZ000039
Z3.9V
D104
FCXZ000039
Z3.9V
D105
FCLEDSMD20
TLMH3101
D106
FCLEDSMD20
TLMH3101
D107
FCDD041200
Z12
D108
FCDD041200
Z12
D109
FCDD041200
Z12
D110
FCDD041200
Z12
D111
FCDD041200
Z12
D112
FCDD041200
Z12
D113
FCXZ000180
Z18V
D114
FCXZ000180
Z18V
D115
FCDD102700
Z27V/1
D116
FCDD102700
Z27V/1
D117
FCDIDB3000
DB3
D118
FCXZ000082
Z8.2V
D119
FCXZ000082
Z8.2V
D120
FCXZ000056
Z5.6V
D121
FCXDDBAS16
BAS16
D122
FCXDD40070
1N4007
D123
FCXZ000120
Z12V
D124
FCXDDBAS28
BAS28
D125
FCXDDBAS16
BAS16
D126
FCXDDBAS16
BAS16
D127
FCXDD40070
1N4007
D128
FCXZ000100
Z10V
D129
FCXDDBAS16
BAS16
D130
FCXDDBAS16
BAS16
D131
FCXDDBAS28
BAS28
D132
FCXZ000075
Z7.5V
D133
FCXDDBAS28
BAS28
D134
FCXZ000039
Z3.9V
D135
FCXZ000039
Z3.9V
D136
FCLEDSMD20
TLMH3101
D137
FCLEDSMD20
TLMH3101
D138
40-0113-0102 EP14-02.xls 2 of 10
Page 31
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCDD041200
Z12
D139
FCDD041200
Z12
D140
FCDD041200
Z12
D141
FCDD041200
Z12
D142
FCDD041200
Z12
D143
FCDD041200
Z12
D144
FCXZ000180
Z18V
D145
FCXZ000180
Z18V
D146
FCDD102700
Z27V/1
D147
FCDD102700
Z27V/1
D148
FCDIDB3000
DB3
D149
FCXZ000082
Z8.2V
D150
FCXZ000082
Z8.2V
D151
FCXZ000056
Z5.6V
D152
FCXDD40070
1N4007
D153
FCXZ000120
Z12V
D154
FCXDDBAS28
BAS28
D155
FCXDDBAS16
BAS16
D156
FCXDDBAS16
BAS16
D157
FCFUS50350
F8A
F101
FCFUS50350
F8A
F102
FCFUS50350
F8A
F103
FCFUS50350
F8A
F104
FCFER43220
Ferrite
FB101
FCFER43220
Ferrite
FB102
FCFER43220
Ferrite
FB103
FCFER43220
Ferrite
FB104
FCFER43220
Ferrite
FB105
FCFER43220
Ferrite
FB106
FCFER43220
Ferrite
FB107
FCFER43220
Ferrite
FB108
FCFER43220
Ferrite
FB109
FCFER43220
Ferrite
FB110
FCFER43220
Ferrite
FB111
FCFER43220
Ferrite
FB112
FCMECT0220
Heatsink f/ TO220
HS101
FCMECT0220
Heatsink f/ TO220
HS102
FCMECT0220
Heatsink f/ TO220
HS103
FCMECT0220
Heatsink f/ TO220
HS104
FCMECT0220
Heatsink f/ TO220
HS105
FCMECT0220
Heatsink f/ TO220
HS106
FCMECT0220
Heatsink f/ TO220
HS107
FCRAD13850
Heatsink f/ Power Module
HS108
FCOPTVTL50
VTL 5C8
IC101
FCIC071010
TL071
IC102
FCIC553410
NE5534A
IC103
FCIC431010
LM431AC
IC104
FCIC350000
LM35DZ
IC105
FCIC072010
TL072
IC106
FCREG78050
7805
IC107
FCIC409301
HEF4093B
IC108
FCOPTVTL50
VTL 5C8
IC109
FCIC071010
TL071
IC110
FCIC553410
NE5534A
IC111
FCIC409301
HEF4093B
IC112
FCMICTO126
Insulant TO126
IN101
40-0113-0102 EP14-02.xls 3 of 10
Page 32
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCMICTO126
Insulant TO126
IN102
FCMICTO126
Insulant TO126
IN103
FCMICTO126
Insulant TO126
IN104
FCMICTO126
Insulant TO126
IN105
FCMICTO126
Insulant TO126
IN106
FCMICTO126
Insulant TO126
IN107
FCTIRKON00
Insulating polymer
IN108
FCTIRKON00
Insulating polymer
IN109
FCMICTO126
Insulant TO126
IN112
FCCTM00040
B4B-EH-A
J101
FCCTM00030
B3B-EH-A
J102
FCTERM0100
Jumper Pin
J103
FCTERM0100
Jumper Pin
J104
FCTERM0100
Jumper Pin
J105
FCTERM0100
Jumper Pin
J106
FCTERM0100
Jumper Pin
J107
FCTERM0100
Jumper Pin
J108
FCCTM00030
B3B-EH-A
J109
FCCTM00020
B2B-EH-A
J110
FCCTM00040
B4B-EH-A
J111
FCTERM0100
Jumper Pin
J112
FCTERM0100
Jumper Pin
J113
FCTERM0100
Jumper Pin
J114
FCTERM0100
Jumper Pin
J115
FCTERM0100
Jumper Pin
J116
FCTERM0100
Jumper Pin
J117
FCREL00300
TQ2-12V
K101
FCREL00300
TQ2-12V
K102
FCIND00100
1uH
L101
FCIND00100
1uH
L102
FCMJ000100
Jumper
MJ101
FCMJ000100
Jumper
MJ102
FCMJ000100
Jumper
MJ103
FCMJ000100
Jumper
MJ104
FCMJ000100
Jumper
MJ105
FCMJ000100
Jumper
MJ106
FCPINZAM00
Clamp WD. 00.2636
MP101
FCPINZAM00
Clamp WD. 00.2636
MP102
FCTUE00300
Nut M3
NV101
FCTUE00300
Nut M3
NV102
FCTUE00300
Nut M3
NV103
FCTUE00300
Nut M3
NV104
FCTUE00300
Nut M3
NV105
FCTUE00300
Nut M3
NV106
FCPORF3150
3/15P
PF101
FCPORF3150
3/15P
PF102
FCPORF3150
3/15P
PF103
FCPORF3150
3/15P
PF104
FCTR437000
BD437
Q101
FCTR437000
BD437
Q102
FCTR471000
BF471
Q103
FCTR472000
BF472
Q104
FCTR340000
MJE340
Q105
FCTR350000
MJE350
Q106
FCTR340000
MJE340
Q107
FCTR350000
MJE350
Q108
40-0113-0102 EP14-02.xls 4 of 10
Page 33
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCTR243000
IRFP9240
Q109
FCTR240000
IRFP240
Q110
FCTR243000
IRFP9240
Q111
FCTR240000
IRFP240
Q112
FCXTT08570
BC857B
Q113
FCXTT08470
BC847B
Q114
FCXTT08570
BC857B
Q115
FCXTT08470
BC847B
Q116
FCTR240000
IRFP240
Q117
FCTR243000
IRFP9240
Q118
FCXTT08570
BC857B
Q119
FCXTT08470
BC847B
Q120
FCTI246000
BTB24600B
Q121
FCXTT08570
BC857B
Q122
FCXTT08470
BC847B
Q123
FCTR254010
2N5401
Q124
FCXTT08470
BC847B
Q125
FCXTT08170
BC817/25
Q126
FCTR437000
BD437
Q127
FCTR437000
BD437
Q128
FCTR471000
BF471
Q129
FCTR472000
BF472
Q130
FCTR340000
MJE340
Q131
FCTR350000
MJE350
Q132
FCTR340000
MJE340
Q133
FCTR350000
MJE350
Q134
FCTR243000
IRFP9240
Q135
FCTR240000
IRFP240
Q136
FCTR243000
IRFP9240
Q137
FCTR240000
IRFP240
Q138
FCXTT08570
BC857B
Q139
FCXTT08470
BC847B
Q140
FCXTT08570
BC857B
Q141
FCXTT08470
BC847B
Q142
FCTR240000
IRFP240
Q143
FCTR243000
IRFP9240
Q144
FCXTT08570
BC857B
Q145
FCXTT08470
BC847B
Q146
FCTI246000
BTB24600B
Q147
FCXTT08570
BC857B
Q148
FCXTT08470
BC847B
Q149
FCTR254010
2N5401
Q150
FCXTT08470
BC847B
Q151
FCXTT08170
BC817/25
Q152
FCXR561000
1M
R101
FCXR542150
21k5
R102
FCXR542150
21k5
R103
FCXR542150
21k5
R104
FCXR551000
100k0
R105
FCXR531000
1k0
R106
FCXR531000
1k0
R107
FCXR543480
34k8
R108
FCXR543480
34k8
R109
FCXR531960
1k96
R110
FCXR535620
5k62
R111
FCXR571000
10M
R112
40-0113-0102 EP14-02.xls 5 of 10
Page 34
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXR531210
1k21
R113
FCXR531210
1k21
R114
FCXR525110
511
R115
FCXR521780
178
R116
FCXR525110
511
R117
FCXR521780
178
R118
FCXR515620
56.2
R119
FCXR531470
1k47
R120
FCXR531470
1k47
R121
FCXR515620
56.2
R122
FCXR526810
681
R123
FCXR531470
1k47
R124
FCRJG44700
4k7
R125
FCXR526810
681
R126
FCXR511000
10.0
R127
FCXR515620
56.2
R128
FCXR523160
316
R129
FCXR515620
56.2
R130
FCXR511000
10.0
R131
FCXR523160
316
R132
FCRF426800
NF68/1
R133
FCRF426800
NF68/1
R134
FCRF232200
NF220/ 1/2
R135
FCRF232200
NF220/ 1/2
R136
FCRF232200
NF220/ 1/2
R137
FCRF232200
NF220/ 1/2
R138
FCRY000100
W0.22/5
R139
FCRY000100
W0.22/5
R140
FCRY000100
W0.22/5
R141
FCRY000100
W0.22/5
R142
FCXR542610
26k1
R143
FCXR542370
23k7
R144
FCRF232200
NF220/ 1/2
R145
FCRF232200
NF220/ 1/2
R146
FCXR525620
562
R147
FCXR525620
562
R148
FCXR524640
464
R149
FCXR524640
464
R150
FCXR543480
34k8
R151
FCXR543480
34k8
R152
FCRY000100
W0.22/5
R153
FCRY000100
W0.22/5
R154
FCXR536810
6k81
R155
FCXR543480
34k8
R156
FCXR543480
34k8
R157
FCXR536810
6k81
R158
FCXR543480
34k8
R159
FCXR543480
34k8
R160
FCXR544640
46k4
R161
FCXR521000
100.0
R162
FCXR521000
100.0
R163
FCXR541330
13k3
R164
FCXR541330
13k3
R165
FCXR521000
100.0
R166
FCXR531000
1k0
R167
FCRY000250
6.8/5W
R168
40-0113-0102 EP14-02.xls 6 of 10
Page 35
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXR531000
1k0
R169
FCXR521000
100.0
R170
FCRC521000
10/2
R171
FCRC512200
2.2/2
R172
FCXR534220
4k22
R173
FCXR534220
4k22
R174
FCXR534220
4k22
R175
FCXR534220
4k22
R176
FCXR544640
46k4
R177
FCXR544640
46k4
R178
FCXR544640
46k4
R179
FCXR532150
2k15
R180
FCXR541000
10k0
R181
FCXR531620
1k62
R182
FCXR524640
464
R183
FCXR544640
46k4
R184
FCXR541000
10k0
R185
FCXR551000
100k0
R186
FCXR542150
21k5
R187
FCXR551000
100k0
R188
FCXR531000
1k0
R189
FCXR544640
46k4
R190
FCXR535620
5k62
R191
FCXR562200
2M2
R192
FCXR551000
100k0
R193
FCXR542150
21k5
R194
FCXR552870
287k
R195
FCXR541000
10k0
R196
FCXR551000
100k0
R197
FCXR528250
825
R198
FCXR531470
1k47
R199
FCXR515620
56.2
R200
FCXR528250
825
R201
FCXR515620
56.2
R202
FCXR521780
178
R203
FCXR531000
1k0
R204
FCXR561000
1M
R205
FCXR542150
21k5
R206
FCXR542150
21k5
R207
FCXR542150
21k5
R208
FCXR551000
100k0
R209
FCXR531000
1k0
R210
FCXR531000
1k0
R211
FCXR543480
34k8
R212
FCXR543480
34k8
R213
FCXR571000
10M
R214
FCXR531960
1k96
R215
FCXR535620
5k62
R216
FCXR531210
1k21
R217
FCXR531210
1k21
R218
FCXR525110
511
R219
FCXR521780
178
R220
FCXR525110
511
R221
FCXR521780
178
R222
FCXR515620
56.2
R223
FCXR531470
1k47
R224
40-0113-0102 EP14-02.xls 7 of 10
Page 36
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXR531470
1k47
R225
FCXR515620
56.2
R226
FCXR526810
681
R227
FCXR531470
1k47
R228
FCRJG44700
4k7
R229
FCXR526810
681
R230
FCXR511000
10.0
R231
FCXR515620
56.2
R232
FCXR523160
316
R233
FCXR523160
316
R234
FCXR515620
56.2
R235
FCXR511000
10.0
R236
FCRF426800
NF68/1
R237
FCRF426800
NF68/1
R238
FCRF232200
NF220/ 1/2
R239
FCRF232200
NF220/ 1/2
R240
FCRF232200
NF220/ 1/2
R241
FCRF232200
NF220/ 1/2
R242
FCRY000100
W0.22/5
R243
FCRY000100
W0.22/5
R244
FCRY000100
W0.22/5
R245
FCRY000100
W0.22/5
R246
FCXR542610
26k1
R247
FCXR542370
23k7
R248
FCRF232200
NF220/ 1/2
R249
FCRF232200
NF220/ 1/2
R250
FCXR525620
562
R251
FCXR525620
562
R252
FCXR524640
464
R253
FCXR524640
464
R254
FCXR543480
34k8
R255
FCXR543480
34k8
R256
FCRY000100
W0.22/5
R257
FCRY000100
W0.22/5
R258
FCXR536810
6k81
R259
FCXR543480
34k8
R260
FCXR543480
34k8
R261
FCXR536810
6k81
R262
FCXR543480
34k8
R263
FCXR543480
34k8
R264
FCXR544640
46k4
R265
FCXR521000
100.0
R266
FCXR521000
100.0
R267
FCXR541330
13k3
R268
FCXR541330
13k3
R269
FCXR521000
100.0
R270
FCXR531000
1k0
R271
FCRY000250
6.8/5W
R272
FCXR531000
1k0
R273
FCXR521000
100.0
R274
FCRC521000
10/2
R275
FCRC512200
2.2/2
R276
FCXR534220
4k22
R277
FCXR534220
4k22
R278
FCXR534220
4k22
R279
FCXR534220
4k22
R280
40-0113-0102 EP14-02.xls 8 of 10
Page 37
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXR544640
46k4
R281
FCXR544640
46k4
R282
FCXR544640
46k4
R283
FCXR544640
46k4
R284
FCXR542150
21k5
R285
FCXR544640
46k4
R286
FCXR542150
21k5
R287
FCXR541000
10k0
R288
FCXR552870
287k
R289
FCXR551000
100k0
R290
FCXR515620
56.2
R291
FCXR515620
56.2
R292
FCXR521780
178
R293
FCXR531000
1k0
R294
FCT8040060
Screw M4x6 SPAN
SC101
FCT7503008
Screw M3x8
SC102
FCT7503008
Screw M3x8
SC103
FCT7503008
Screw M3x8
SC104
FCT7503008
Screw M3x8
SC105
FCT7503008
Screw M3x8
SC106
FCT7503008
Screw M3x8
SC107
FCSEPPM000
Plastic Spacer f/board ct.
SC108
FCSEPPM000
Plastic Spacer f/board ct.
SC109
FCT8040060
Screw M4x6 SPAN
SC110
FCT8040060
Screw M4x6 SPAN
SC111
FCT8030100
Screw M3x10 SPA
SC112
FCT8030100
Screw M3x10 SPA
SC113
FCT8030100
Screw M3x10 SPA
SC114
FCT8030100
Screw M3x10 SPA
SC115
FCT8030100
Screw M3x10 SPA
SC116
FCT8030100
Screw M3x10 SPA
SC117
FCT8030100
Screw M3x10 SPA
SC118
FCT8030100
Screw M3x10 SPA
SC119
FCT8030100
Screw M3x10 SPA
SC120
FCT8030100
Screw M3x10 SPA
SC121
FCSEPPM000
Plastic Spacer f/board ct.
SC122
FCSEPPM000
Plastic Spacer f/board ct.
SC123
FCT8030100
Screw M3x10 SPA
SC124
FCT8030100
Screw M3x10 SPA
SC125
FCT8040060
Screw M4x6 SPAN
SC126
FCTERMF280
Faston 2.8mm
TS101
FCTERMF280
Faston 2.8mm
TS102
FCTERMF280
Faston 2.8mm
TS103
FCTERMF280
Faston 2.8mm
TS104
FCMECPON19
19mm
W100
FCMECPON19
19mm
W101
FCMECPON19
19mm
W102
FCMECPON19
19mm
W103
FCMECPON19
19mm
W104
FCMECPON19
19mm
W105
FCMECPON19
19mm
W106
FCMECPON19
19mm
W107
FCMECPON19
19mm
W108
FCMECPON19
19mm
W109
FCMECPON19
19mm
W110
FCMECPON19
19mm
W111
40-0113-0102 EP14-02.xls 9 of 10
Page 38
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCMECPON19
19mm
W112
FCMECPON19
19mm
W113
FCMECPON19
19mm
W114
FCMECPON19
19mm
W115
FCMECPON19
19mm
W116
FCMECPON19
19mm
W117
FCARM32010
Metal Washer 3.2x6x1
WA101
FCARM32010
Metal Washer 3.2x6x1
WA102
FCARDE0300
Toothed Washer M3
WA103
FCARM32010
Metal Washer 3.2x6x1
WA104
FCARM32010
Metal Washer 3.2x6x1
WA105
FCARM32010
Metal Washer 3.2x6x1
WA106
FCARM32010
Metal Washer 3.2x6x1
WA107
FCARM32010
Metal Washer 3.2x6x1
WA108
FCARM32010
Metal Washer 3.2x6x1
WA109
FCARDE0300
Toothed Washer M3
WA114
FCARDE0300
Toothed Washer M3
WA115
FCARDE0300
Toothed Washer M3
WA116
FCARDE0300
Toothed Washer M3
WA117
FCARDE0300
Toothed Washer M3
WA118
FC0H111500
1111.05.00
WI107
FC0H110350
1110.03.50
WI108
40-0113-0102 EP14-02.xls 10 of 10
Page 39
Page 40
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXCD12200
22p
C101
FCXCD41000
100n
C102
FCXCD41000
100n
C103
FCCE250100
10u/50
C104
FCCE250470
47u/50
C105
FCXCD16800
68p
C106
FCXCD16800
68p
C107
FCCE350470
47u/100
C108
FCCE350470
47u/100
C109
FCCE250100
10u/50
C110
FCXCD41000
100n
C111
FCXCD11500
15p
C112
FCXCD41000
100n
C113
FCCE250100
10u/50
C114
FCXCD44700
470n
C115
FCXCD44700
470n
C116
FCXCD11500
15p
C117
FCXCD11500
15p
C118
FCCDK52200
C220n/100V
C119
FCCDK52200
C220n/100V
C120
FCXCD26800
680p
C121
FCXCD26800
680p
C122
FCCDK20010
C1u/63V
C123
FCXCD40100
10n
C124
FCXCD40100
10n
C125
FCCDH71100
C100n/400V
C126
FCCDH71047
C47n/400V
C127
FCXCD41000
100n
C128
FCXCD41000
100n
C129
FCXCD41000
100n
C130
FCCE250100
10u/50
C131
FCXCD44700
470n
C132
FCCE250100
10u/50
C133
FCCE100000
47u/16
C134
FCXCD44700
470n
C135
FCCE250470
47u/50
C136
FCCE250470
47u/50
C137
FCCE250100
10u/50
C138
FCCE154700
470u/25
C139
FCXCD12200
22p
C140
FCXCD41000
100n
C141
FCXCD41000
100n
C142
FCCE250100
10u/50
C143
FCCE250470
47u/50
C144
FCXCD16800
68p
C145
FCXCD16800
68p
C146
FCCE350470
47u/100
C147
FCCE350470
47u/100
C148
FCCE250100
10u/50
C149
FCXCD41000
100n
C150
FCXCD11500
15p
C151
FCXCD41000
100n
C152
FCCE250100
10u/50
C153
FCXCD44700
470n
C154
FCXCD44700
470n
C155
FCXCD11500
15p
C156
40-0113-0101 EP14-02.xls 1 of 10
Page 41
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXCD11500
15p
C157
FCCDK52200
C220n/100V
C158
FCCDK52200
C220n/100V
C159
FCXCD26800
680p
C160
FCXCD26800
680p
C161
FCCDK20010
C1u/63V
C162
FCXCD40100
10n
C163
FCXCD40100
10n
C164
FCCDH71100
C100n/400V
C165
FCCDH71047
C47n/400V
C166
FCCE100000
47u/16
C167
FCCE250470
47u/50
C168
FCXCD41000
100n
C169
FCPERL2550
Cer. Bead
CB101
FCPERL2550
Cer. Bead
CB102
FCPERL2550
Cer. Bead
CB103
FCPERL2550
Cer. Bead
CB104
FCCI009560
Printed Board 11.0956
CI101
FCXDDBAS28
BAS28
D101
FCXZ000075
Z7.5V
D102
FCXDDBAS28
BAS28
D103
FCXZ000039
Z3.9V
D104
FCXZ000039
Z3.9V
D105
FCLEDSMD20
TLMH3101
D106
FCLEDSMD20
TLMH3101
D107
FCDD041200
Z12
D108
FCDD041200
Z12
D109
FCDD041200
Z12
D110
FCDD041200
Z12
D111
FCDD041200
Z12
D112
FCDD041200
Z12
D113
FCXZ000180
Z18V
D114
FCXZ000180
Z18V
D115
FCDD102700
Z27V/1
D116
FCDD102700
Z27V/1
D117
FCDIDB3000
DB3
D118
FCXZ000082
Z8.2V
D119
FCXZ000082
Z8.2V
D120
FCXZ000056
Z5.6V
D121
FCXDDBAS16
BAS16
D122
FCXDD40070
1N4007
D123
FCXZ000120
Z12V
D124
FCXDDBAS28
BAS28
D125
FCXDDBAS16
BAS16
D126
FCXDDBAS16
BAS16
D127
FCXDD40070
1N4007
D128
FCXZ000100
Z10V
D129
FCXDDBAS16
BAS16
D130
FCXDDBAS16
BAS16
D131
FCXDDBAS28
BAS28
D132
FCXZ000075
Z7.5V
D133
FCXDDBAS28
BAS28
D134
FCXZ000039
Z3.9V
D135
FCXZ000039
Z3.9V
D136
FCLEDSMD20
TLMH3101
D137
FCLEDSMD20
TLMH3101
D138
40-0113-0101 EP14-02.xls 2 of 10
Page 42
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCDD041200
Z12
D139
FCDD041200
Z12
D140
FCDD041200
Z12
D141
FCDD041200
Z12
D142
FCDD041200
Z12
D143
FCDD041200
Z12
D144
FCXZ000180
Z18V
D145
FCXZ000180
Z18V
D146
FCDD102700
Z27V/1
D147
FCDD102700
Z27V/1
D148
FCDIDB3000
DB3
D149
FCXZ000082
Z8.2V
D150
FCXZ000082
Z8.2V
D151
FCXZ000056
Z5.6V
D152
FCXDD40070
1N4007
D153
FCXZ000120
Z12V
D154
FCXDDBAS28
BAS28
D155
FCXDDBAS16
BAS16
D156
FCXDDBAS16
BAS16
D157
FCFUS50350
F8A
F101
FCFUS50350
F8A
F102
FCFUS50350
F8A
F103
FCFUS50350
F8A
F104
FCFER43220
Ferrite
FB101
FCFER43220
Ferrite
FB102
FCFER43220
Ferrite
FB103
FCFER43220
Ferrite
FB104
FCFER43220
Ferrite
FB105
FCFER43220
Ferrite
FB106
FCFER43220
Ferrite
FB107
FCFER43220
Ferrite
FB108
FCFER43220
Ferrite
FB109
FCFER43220
Ferrite
FB110
FCFER43220
Ferrite
FB111
FCFER43220
Ferrite
FB112
FCMECT0220
Heatsink f/ TO220
HS101
FCMECT0220
Heatsink f/ TO220
HS102
FCMECT0220
Heatsink f/ TO220
HS103
FCMECT0220
Heatsink f/ TO220
HS104
FCMECT0220
Heatsink f/ TO220
HS105
FCMECT0220
Heatsink f/ TO220
HS106
FCMECT0220
Heatsink f/ TO220
HS107
FCRAD13850
Heatsink f/ Power Module
HS108
FCOPTVTL50
VTL 5C8
IC101
FCIC071010
TL071
IC102
FCIC553410
NE5534A
IC103
FCIC431010
LM431AC
IC104
FCIC350000
LM35DZ
IC105
FCIC072010
TL072
IC106
FCREG78050
7805
IC107
FCIC409301
HEF4093B
IC108
FCOPTVTL50
VTL 5C8
IC109
FCIC071010
TL071
IC110
FCIC553410
NE5534A
IC111
FCIC409301
HEF4093B
IC112
FCMICTO126
Insulant TO126
IN101
40-0113-0101 EP14-02.xls 3 of 10
Page 43
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCMICTO126
Insulant TO126
IN102
FCMICTO126
Insulant TO126
IN103
FCMICTO126
Insulant TO126
IN104
FCMICTO126
Insulant TO126
IN105
FCMICTO126
Insulant TO126
IN106
FCMICTO126
Insulant TO126
IN107
FCTIRKON00
Insulating polymer
IN108
FCTIRKON00
Insulating polymer
IN109
FCMICTO126
Insulant TO126
IN112
FCCTM00040
B4B-EH-A
J101
FCCTM00030
B3B-EH-A
J102
FCTERM0100
Jumper Pin
J103
FCTERM0100
Jumper Pin
J104
FCTERM0100
Jumper Pin
J105
FCTERM0100
Jumper Pin
J106
FCTERM0100
Jumper Pin
J107
FCTERM0100
Jumper Pin
J108
FCCTM00030
B3B-EH-A
J109
FCCTM00020
B2B-EH-A
J110
FCCTM00040
B4B-EH-A
J111
FCTERM0100
Jumper Pin
J112
FCTERM0100
Jumper Pin
J113
FCTERM0100
Jumper Pin
J114
FCTERM0100
Jumper Pin
J115
FCTERM0100
Jumper Pin
J116
FCTERM0100
Jumper Pin
J117
FCREL00300
TQ2-12V
K101
FCREL00300
TQ2-12V
K102
FCIND00100
1uH
L101
FCIND00100
1uH
L102
FCMJ000100
Jumper
MJ101
FCMJ000100
Jumper
MJ102
FCMJ000100
Jumper
MJ103
FCMJ000100
Jumper
MJ104
FCMJ000100
Jumper
MJ105
FCMJ000100
Jumper
MJ106
FCPINZAM00
Clamp WD. 00.2636
MP101
FCPINZAM00
Clamp WD. 00.2636
MP102
FCTUE00300
Nut M3
NV101
FCTUE00300
Nut M3
NV102
FCTUE00300
Nut M3
NV103
FCTUE00300
Nut M3
NV104
FCTUE00300
Nut M3
NV105
FCTUE00300
Nut M3
NV106
FCPORF3150
3/15P
PF101
FCPORF3150
3/15P
PF102
FCPORF3150
3/15P
PF103
FCPORF3150
3/15P
PF104
FCTR437000
BD437
Q101
FCTR437000
BD437
Q102
FCTR471000
BF471
Q103
FCTR472000
BF472
Q104
FCTR340000
MJE340
Q105
FCTR350000
MJE350
Q106
FCTR340000
MJE340
Q107
FCTR350000
MJE350
Q108
40-0113-0101 EP14-02.xls 4 of 10
Page 44
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCTR243000
IRFP9240
Q109
FCTR240000
IRFP240
Q110
FCTR243000
IRFP9240
Q111
FCTR240000
IRFP240
Q112
FCXTT08570
BC857B
Q113
FCXTT08470
BC847B
Q114
FCXTT08570
BC857B
Q115
FCXTT08470
BC847B
Q116
FCTR240000
IRFP240
Q117
FCTR243000
IRFP9240
Q118
FCXTT08570
BC857B
Q119
FCXTT08470
BC847B
Q120
FCTI246000
BTB24600B
Q121
FCXTT08570
BC857B
Q122
FCXTT08470
BC847B
Q123
FCTR254010
2N5401
Q124
FCXTT08470
BC847B
Q125
FCXTT08170
BC817/25
Q126
FCTR437000
BD437
Q127
FCTR437000
BD437
Q128
FCTR471000
BF471
Q129
FCTR472000
BF472
Q130
FCTR340000
MJE340
Q131
FCTR350000
MJE350
Q132
FCTR340000
MJE340
Q133
FCTR350000
MJE350
Q134
FCTR243000
IRFP9240
Q135
FCTR240000
IRFP240
Q136
FCTR243000
IRFP9240
Q137
FCTR240000
IRFP240
Q138
FCXTT08570
BC857B
Q139
FCXTT08470
BC847B
Q140
FCXTT08570
BC857B
Q141
FCXTT08470
BC847B
Q142
FCTR240000
IRFP240
Q143
FCTR243000
IRFP9240
Q144
FCXTT08570
BC857B
Q145
FCXTT08470
BC847B
Q146
FCTI246000
BTB24600B
Q147
FCXTT08570
BC857B
Q148
FCXTT08470
BC847B
Q149
FCTR254010
2N5401
Q150
FCXTT08470
BC847B
Q151
FCXTT08170
BC817/25
Q152
FCXR561000
1M
R101
FCXR542150
21k5
R102
FCXR542150
21k5
R103
FCXR542150
21k5
R104
FCXR551000
100k0
R105
FCXR531000
1k0
R106
FCXR531000
1k0
R107
FCXR543480
34k8
R108
FCXR543480
34k8
R109
FCXR531960
1k96
R110
FCXR535620
5k62
R111
FCXR571000
10M
R112
40-0113-0101 EP14-02.xls 5 of 10
Page 45
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXR531210
1k21
R113
FCXR531210
1k21
R114
FCXR525110
511
R115
FCXR521780
178
R116
FCXR525110
511
R117
FCXR521780
178
R118
FCXR515620
56.2
R119
FCXR531470
1k47
R120
FCXR531470
1k47
R121
FCXR515620
56.2
R122
FCXR526810
681
R123
FCXR531470
1k47
R124
FCRJG44700
4k7
R125
FCXR526810
681
R126
FCXR511000
10.0
R127
FCXR515620
56.2
R128
FCXR523160
316
R129
FCXR515620
56.2
R130
FCXR511000
10.0
R131
FCXR523160
316
R132
FCRF426800
NF68/1
R133
FCRF426800
NF68/1
R134
FCRF232200
NF220/ 1/2
R135
FCRF232200
NF220/ 1/2
R136
FCRF232200
NF220/ 1/2
R137
FCRF232200
NF220/ 1/2
R138
FCRY000100
W0.22/5
R139
FCRY000100
W0.22/5
R140
FCRY000100
W0.22/5
R141
FCRY000100
W0.22/5
R142
FCXR542610
26k1
R143
FCXR542370
23k7
R144
FCRF232200
NF220/ 1/2
R145
FCRF232200
NF220/ 1/2
R146
FCXR525620
562
R147
FCXR525620
562
R148
FCXR524640
464
R149
FCXR524640
464
R150
FCXR543480
34k8
R151
FCXR543480
34k8
R152
FCRY000100
W0.22/5
R153
FCRY000100
W0.22/5
R154
FCXR536810
6k81
R155
FCXR543480
34k8
R156
FCXR543480
34k8
R157
FCXR536810
6k81
R158
FCXR543480
34k8
R159
FCXR543480
34k8
R160
FCXR544640
46k4
R161
FCXR521000
100.0
R162
FCXR521000
100.0
R163
FCXR541330
13k3
R164
FCXR541330
13k3
R165
FCXR521000
100.0
R166
FCXR531000
1k0
R167
FCRY000250
6.8/5W
R168
40-0113-0101 EP14-02.xls 6 of 10
Page 46
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXR531000
1k0
R169
FCXR521000
100.0
R170
FCRC521000
10/2
R171
FCRC512200
2.2/2
R172
FCXR534220
4k22
R173
FCXR534220
4k22
R174
FCXR534220
4k22
R175
FCXR534220
4k22
R176
FCXR544640
46k4
R177
FCXR544640
46k4
R178
FCXR544640
46k4
R179
FCXR532150
2k15
R180
FCXR541000
10k0
R181
FCXR531620
1k62
R182
FCXR524640
464
R183
FCXR544640
46k4
R184
FCXR541000
10k0
R185
FCXR551000
100k0
R186
FCXR542150
21k5
R187
FCXR551000
100k0
R188
FCXR531000
1k0
R189
FCXR544640
46k4
R190
FCXR535620
5k62
R191
FCXR562200
2M2
R192
FCXR551000
100k0
R193
FCXR542150
21k5
R194
FCXR552870
287k
R195
FCXR541000
10k0
R196
FCXR551000
100k0
R197
FCXR528250
825
R198
FCXR531470
1k47
R199
FCXR515620
56.2
R200
FCXR528250
825
R201
FCXR515620
56.2
R202
FCXR521780
178
R203
FCXR531000
1k0
R204
FCXR561000
1M
R205
FCXR542150
21k5
R206
FCXR542150
21k5
R207
FCXR542150
21k5
R208
FCXR551000
100k0
R209
FCXR531000
1k0
R210
FCXR531000
1k0
R211
FCXR543480
34k8
R212
FCXR543480
34k8
R213
FCXR571000
10M
R214
FCXR531960
1k96
R215
FCXR535620
5k62
R216
FCXR531210
1k21
R217
FCXR531210
1k21
R218
FCXR525110
511
R219
FCXR521780
178
R220
FCXR525110
511
R221
FCXR521780
178
R222
FCXR515620
56.2
R223
FCXR531470
1k47
R224
40-0113-0101 EP14-02.xls 7 of 10
Page 47
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXR531470
1k47
R225
FCXR515620
56.2
R226
FCXR526810
681
R227
FCXR531470
1k47
R228
FCRJG44700
4k7
R229
FCXR526810
681
R230
FCXR511000
10.0
R231
FCXR515620
56.2
R232
FCXR523160
316
R233
FCXR523160
316
R234
FCXR515620
56.2
R235
FCXR511000
10.0
R236
FCRF426800
NF68/1
R237
FCRF426800
NF68/1
R238
FCRF232200
NF220/ 1/2
R239
FCRF232200
NF220/ 1/2
R240
FCRF232200
NF220/ 1/2
R241
FCRF232200
NF220/ 1/2
R242
FCRY000100
W0.22/5
R243
FCRY000100
W0.22/5
R244
FCRY000100
W0.22/5
R245
FCRY000100
W0.22/5
R246
FCXR542610
26k1
R247
FCXR542370
23k7
R248
FCRF232200
NF220/ 1/2
R249
FCRF232200
NF220/ 1/2
R250
FCXR525620
562
R251
FCXR525620
562
R252
FCXR524640
464
R253
FCXR524640
464
R254
FCXR543480
34k8
R255
FCXR543480
34k8
R256
FCRY000100
W0.22/5
R257
FCRY000100
W0.22/5
R258
FCXR536810
6k81
R259
FCXR543480
34k8
R260
FCXR543480
34k8
R261
FCXR536810
6k81
R262
FCXR543480
34k8
R263
FCXR543480
34k8
R264
FCXR544640
46k4
R265
FCXR521000
100.0
R266
FCXR521000
100.0
R267
FCXR541330
13k3
R268
FCXR541330
13k3
R269
FCXR521000
100.0
R270
FCXR531000
1k0
R271
FCRY000250
6.8/5W
R272
FCXR531000
1k0
R273
FCXR521000
100.0
R274
FCRC521000
10/2
R275
FCRC512200
2.2/2
R276
FCXR534220
4k22
R277
FCXR534220
4k22
R278
FCXR534220
4k22
R279
FCXR534220
4k22
R280
40-0113-0101 EP14-02.xls 8 of 10
Page 48
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCXR544640
46k4
R281
FCXR544640
46k4
R282
FCXR544640
46k4
R283
FCXR544640
46k4
R284
FCXR542150
21k5
R285
FCXR544640
46k4
R286
FCXR542150
21k5
R287
FCXR541000
10k0
R288
FCXR552870
287k
R289
FCXR551000
100k0
R290
FCXR515620
56.2
R291
FCXR515620
56.2
R292
FCXR521780
178
R293
FCXR531000
1k0
R294
FCT8040060
Screw M4x6 SPAN
SC101
FCT7503008
Screw M3x8
SC102
FCT7503008
Screw M3x8
SC103
FCT7503008
Screw M3x8
SC104
FCT7503008
Screw M3x8
SC105
FCT7503008
Screw M3x8
SC106
FCT7503008
Screw M3x8
SC107
FCSEPPM000
Plastic Spacer f/board ct.
SC108
FCSEPPM000
Plastic Spacer f/board ct.
SC109
FCT8040060
Screw M4x6 SPAN
SC110
FCT8040060
Screw M4x6 SPAN
SC111
FCT8030100
Screw M3x10 SPA
SC112
FCT8030100
Screw M3x10 SPA
SC113
FCT8030100
Screw M3x10 SPA
SC114
FCT8030100
Screw M3x10 SPA
SC115
FCT8030100
Screw M3x10 SPA
SC116
FCT8030100
Screw M3x10 SPA
SC117
FCT8030100
Screw M3x10 SPA
SC118
FCT8030100
Screw M3x10 SPA
SC119
FCT8030100
Screw M3x10 SPA
SC120
FCT8030100
Screw M3x10 SPA
SC121
FCSEPPM000
Plastic Spacer f/board ct.
SC122
FCSEPPM000
Plastic Spacer f/board ct.
SC123
FCT8030100
Screw M3x10 SPA
SC124
FCT8030100
Screw M3x10 SPA
SC125
FCT8040060
Screw M4x6 SPAN
SC126
FCTERMF280
Faston 2.8mm
TS101
FCTERMF280
Faston 2.8mm
TS102
FCTERMF280
Faston 2.8mm
TS103
FCTERMF280
Faston 2.8mm
TS104
FCMECPON19
19mm
W100
FCMECPON19
19mm
W101
FCMECPON19
19mm
W102
FCMECPON19
19mm
W103
FCMECPON19
19mm
W104
FCMECPON19
19mm
W105
FCMECPON19
19mm
W106
FCMECPON19
19mm
W107
FCMECPON19
19mm
W108
FCMECPON19
19mm
W109
FCMECPON19
19mm
W110
FCMECPON19
19mm
W111
40-0113-0101 EP14-02.xls 9 of 10
Page 49
PARTS LIST: PRINTED CIRCUIT 11.0956.03.00
Code
Description
Reference
FCMECPON19
19mm
W112
FCMECPON19
19mm
W113
FCMECPON19
19mm
W114
FCMECPON19
19mm
W115
FCMECPON19
19mm
W116
FCMECPON19
19mm
W117
FCARM32010
Metal Washer 3.2x6x1
WA101
FCARM32010
Metal Washer 3.2x6x1
WA102
FCARDE0300
Toothed Washer M3
WA103
FCARM32010
Metal Washer 3.2x6x1
WA104
FCARM32010
Metal Washer 3.2x6x1
WA105
FCARM32010
Metal Washer 3.2x6x1
WA106
FCARM32010
Metal Washer 3.2x6x1
WA107
FCARM32010
Metal Washer 3.2x6x1
WA108
FCARM32010
Metal Washer 3.2x6x1
WA109
FCARM32010
Metal Washer 3.2x6x1
WA110
FCARM32010
Metal Washer 3.2x6x1
WA111
FCARM32010
Metal Washer 3.2x6x1
WA112
FCARM32010
Metal Washer 3.2x6x1
WA113
FCARDE0300
Toothed Washer M3
WA114
FCARDE0300
Toothed Washer M3
WA115
FCARDE0300
Toothed Washer M3
WA116
FCARDE0300
Toothed Washer M3
WA117
FCARDE0300
Toothed Washer M3
WA118
FC0H111500
1111.05.00
WI107
FC0H110350
1110.03.50
WI108
40-0113-0101 EP14-02.xls 10 of 10
Page 50
Page 51
Page 52
PARTS LIST: PRINTED CIRCUIT 11.0960.02.01
Code
Description
Reference
FCCE100000
47u/16
C101
FCCE100000
47u/16
C102
FCCE100000
47u/16
C103
FCCE100000
47u/16
C104
FCCE100000
47u/16
C105
FCCE100000
47u/16
C106
FCCE100000
47u/16
C107
FCCE100000
47u/16
C108
FCXCD21000
100p
C109
FCXCD21000
100p
C110
FCXCD21000
100p
C111
FCXCD21000
100p
C112
FCXCD21000
100p
C113
FCXCD21000
100p
C114
FCXCD21000
100p
C115
FCXCD21000
100p
C116
FCXCN12201
22p 2%
C117
FCXCN12201
22p 2%
C118
FCXCN12201
22p 2%
C119
FCXCN12201
22p 2%
C120
FCXCN12201
22p 2%
C121
FCXCN12201
22p 2%
C122
FCXCN12201
22p 2%
C123
FCXCN12201
22p 2%
C124
FCCE100000
47u/16
C125
FCCE100000
47u/16
C126
FCCE100000
47u/16
C127
FCCE100000
47u/16
C128
FCXCD41000
100n
C129
FCXCD41000
100n
C130
FCXCD41000
100n
C131
FCXCD41000
100n
C132
FCCE100000
47u/16
C133
FCCE100000
47u/16
C134
FCCE100000
47u/16
C135
FCCE100000
47u/16
C136
FCCE100000
47u/16
C137
FCCDK11000
C100n/63V
C138
FCCDK11000
C100n
C139
FCCDK11000
C100n
C140
FCCDK50180
C18n
C141
FCCDK50180
C18n
C142
FCCDK50180
C18n
C143
FCCDK50180
C18n
C144
FCCDK50180
C18n
C145
FCCDK10047
C4n7/63V
C146
FCCE100000
47u/16
C147
FCCE100000
47u/16
C148
FCCE100000
47u/16
C149
FCCE100000
47u/16
C150
FCCE100000
47u/16
C151
FCXCD41000
100n
C152
FCXCD41000
100n
C153
FCXCD41000
100n
C154
FCXCD41000
100n
C155
FCCDH71470
C470n/275V X2
C156
40-0113-0101 EP14-02.xls 1 of 4
Page 53
PARTS LIST: PRINTED CIRCUIT 11.0960.02.01
Code
Description
Reference
FCCDH71470
C470n/275V X2
C157
FCCCD22250
C2n2/250V Y1
C158
FCCCD22250
C2n2/250V Y1
C159
FCCDK11000
C100n/63V
C160
FCXCD41000
100n
C161
FCXCD41000
100n
C162
FCCE212200
2200u/35V
C163
FCCE212200
2200u/35V
C164
FCCE331525
4700u/100
C165
FCCE331525
4700u/100
C166
FCCE331525
4700u/100
C167
FCCE331525
4700u/100
C168
FCCE331525
4700u/100
C169
FCCE331525
4700u/100
C170
FCCE250470
47u/50
C171
FCCE250470
47u/50
C172
FCCE211000
1000u/35
C173
FCCI009600
Printed Circuit 11.0960
CI101
FCREC25100
B250C1000
D101
FCREC50060
FB5006
D102
FCXDD40070
1N4007
D103
FCXDD40070
1N4007
D104
FCXDD40070
1N4007
D105
FCXDD40070
1N4007
D106
FCFUS80400
16A Temp.
F101
FCRAD11515
Heatsink f/ Rect.
HS101
FCMECT0220
Heatsink f/ TO220
HS102
FCMECT0220
Heatsink f/ TO220
HS103
FCIC074010
TL074
IC101
FCIC074010
TL074
IC102
FCIC074010
TL074
IC103
FCIC072010
TL072
IC104
FCREG78150
7815
IC105
FCREG79150
7915
IC106
FCBASX0900
YKF52-5005
J101
FCBASX0900
YKF52-5005
J102
FCBASX0900
YKF52-5005
J103
FCBASX0900
YKF52-5005
J104
FCCTM00060
B6B-EH-A
J105
FCCTM00080
B8B-EH-A
J106
FCCTM00060
B6B-EH-A
J107
FCCTM00030
B3B-EH-A
J108
FCCTAMP040
4P AMP MALE SOCKET
J109
FCCTAMP040
4P AMP MALE SOCKET
J110
FCCTAMP090
9P AMP MALE SOCKET
J111
FCCTAMP020
2P AMP MALE SOCKET
J112
FCCTAMP040
4P AMP MALE SOCKET
J113
FCCTAMP020
2P AMP MALE SOCKET
J114
FCCTAMP040
4P AMP MALE SOCKET
J115
FCCTAMP060
6P AMP MALE SOCKET
J116
FCCTAMP060
6P AMP MALE SOCKET
J117
FCCTJAL100
YKD31-0496
J118
FCCTJAL100
YKD31-0496
J119
FCBB2X3500
2x1.5mH
L101
FCTUE00300
Nut M3
NV101
FCTUE00300
Nut M3
NV102
40-0113-0101 EP14-02.xls 2 of 4
Page 54
PARTS LIST: PRINTED CIRCUIT 11.0960.02.01
Code
Description
Reference
FCPORF0200
Fuse clip
PF101
FCPORF0200
Fuse clip
PF102
FCXR551000
100k0
R101
FCXR551000
100k0
R102
FCXR551000
100k0
R103
FCXR551000
100k0
R104
FCXR551000
100k0
R105
FCXR551000
100k0
R106
FCXR551000
100k0
R107
FCXR551000
100k0
R108
FCXR521000
100.0
R109
FCXR521000
100.0
R110
FCXR521000
100.0
R111
FCXR521000
100.0
R112
FCXR521000
100.0
R113
FCXR521000
100.0
R114
FCXR521000
100.0
R115
FCXR521000
100.0
R116
FCXR642430
24k3 0.5%
R117
FCXR642430
24k3 0.5%
R118
FCXR642430
24k3 0.5%
R119
FCXR642430
24k3 0.5%
R120
FCXR642430
24k3 0.5%
R121
FCXR642430
24k3 0.5%
R122
FCXR642430
24k3 0.5%
R123
FCXR642430
24k3 0.5%
R124
FCXR642430
24k3 0.5%
R125
FCXR642430
24k3 0.5%
R126
FCXR642430
24k3 0.5%
R127
FCXR642430
24k3 0.5%
R128
FCXR642430
24k3 0.5%
R129
FCXR642430
24k3 0.5%
R130
FCXR642430
24k3 0.5%
R131
FCXR642430
24k3 0.5%
R132
FCXR541960
19k6
R133
FCXR541960
19k6
R134
FCXR551000
100k0
R135
FCXR551000
100k0
R136
FCXR551000
100k0
R137
FCXR551000
100k0
R138
FCXR541960
19k6
R139
FCXR541960
19k6
R140
FCXR541960
19k6
R141
FCXR541960
19k6
R142
FCXR541960
19k6
R143
FCXR541960
19k6
R144
FCXR541960
19k6
R145
FCXR551000
100k0
R146
FCXR551000
100k0
R147
FCXR541960
19k6
R148
FCXR541960
19k6
R149
FCXR541960
19k6
R150
FCXR551000
100k0
R151
FCXR551000
100k0
R152
FCXR551000
100k0
R153
FCXR551000
100k0
R154
40-0113-0101 EP14-02.xls 3 of 4
Page 55
PARTS LIST: PRINTED CIRCUIT 11.0960.02.01
Code
Description
Reference
FCXR551000
100k0
R155
FCXR551000
100k0
R156
FCXR539090
9k09
R157
FCXR541000
10k0
R158
FCXR541000
10k0
R159
FCXR541960
19k6
R160
FCXR541960
19k6
R161
FCXR551000
100k0
R162
FCXR551000
100k0
R163
FCXR541960
19k6
R164
FCXR541960
19k6
R165
FCXR543160
31k6
R166
FCXR543160
31k6
R167
FCXR551210
121k
R168
FCXR551210
121k
R169
FCXR551000
100k0
R170
FCXR551000
100k0
R171
FCXR551000
100k0
R172
FCXR551000
100k0
R173
FCXR551000
100k0
R174
FCINTAP130
8019L
S101
FCINTAP130
8019L
S102
FCINTAP130
8019L
S103
FCINTAP130
8019L
S104
FCINTAP090
NS43E11
S105
FCINTAP090
NS43E11
S106
FCINTAP130
8019L
S107
FCINTAP140
8021L
S108
FCINTD4000
17128
S109
FCT3804012
Screw M4x12 TR
SC100
FCT7503008
Screw M3x8
SC101
FCT7503008
Screw M3x8
SC102
FCTERMF280
Faston 2.8mm
TS101
FCMECPON19
19mm
W101
FCARDE0300
Toothed Washer f/M3
WA101
FCARDE0300
Toothed Washer f/M3
WA102
FC4N049150
1049.01.50
WI101
FC6J024500
1024.05.00
WI102
FC6J024500
1024.05.00
WI103
FC6J024500
1024.05.00
WI104
FC6J024500
1024.05.00
WI105
FC2F017400
1017.04.00
WI106
FC2F016400
1016.04.00
WI107
FC4I005550
1005.05.50
WI108
FC4I005550
1005.05.50
WI109
40-0113-0101 EP14-02.xls 4 of 4
Page 56
Page 57
Page 58
Page 59
Page 60
PARTS LIST: PRINTED CIRCUIT 11.0961.02.01
Code
Description
Reference
FCXCD41000
100n
C101
FCXCD41000
100n
C102
FCCE100000
47u/16
C103
FCCE100000
47u/16
C104
FCCE100000
47u/16
C105
FCCE100000
47u/16
C106
FCCE100000
47u/16
C107
FCCE100000
47u/16
C108
FCCE100000
47u/16
C109
FCCE100000
47u/16
C110
FCCI009610
Printed Circuit 11.0961
CI101
FCLED300RO
LED3R
D101
FCLED300RO
LED3R
D102
FCLED300RO
LED3R
D103
FCLED300AM
LED3Y
D104
FCLED300RO
LED3R
D105
FCXDDBAS16
BAS16
D106
FCXDDBAS16
BAS16
D107
FCXDDBAS16
BAS16
D108
FCXDDBAS16
BAS16
D109
FCLED300VE
LED3G
D110
FCLED300VE
LED3G
D111
FCLED300VE
LED3G
D112
FCLED300VE
LED3G
D113
FCIC074010
TL074
IC101
FCPR210040
10kAx2
R101
FCPR210040
10kAx2
R102
FCPR210040
10kAx2
R103
FCPR210040
10kAx2
R104
FCXR554640
464k
R105
FCXR554640
464k
R106
FCXR554640
464k
R107
FCXR554640
464k
R108
FCXR531000
1k0
R109
FCXR531000
1k0
R110
FCXR531000
1k0
R111
FCXR531000
1k0
R112
FCXR531000
1k0
R113
FCXR531000
1k0
R114
FCXR531000
1k0
R115
FCXR531000
1k0
R116
FCXR553480
348k
R117
FCXR553480
348k
R118
FCXR553480
348k
R119
FCXR553480
348k
R120
FCXR531470
1k47
R121
FCXR531470
1k47
R122
FCXR531470
1k47
R123
FCXR531470
1k47
R124
FC1L097500
1097.05.00
WI101
FC4I005400
1005.04.00
WI102
FC4I005400
1005.04.00
WI103
FC1L097500
1097.05.00
WI104
FC4I005550
1005.05.50
WI105
40-0113-0101 EP14-02.xls 1 of 1
Page 61
J. Colomines
author:
C
E
num:
PRELIMINARY:
- Check the Ground Link switch.
- Be sure that the correct cable types are used.
- Main POWER switch OFF.
- Select a 1KHz 0dB output signal on the generator, but keep it turned off.
- Place four 4Ω load impedances into outputs 1, 2, 3 and 4. If it’s not possible, just place
one 4Ω load into the tested channel output.
- Connect the millivoltmeter and the oscilloscope to channel one.
- Turn down all potentiometers to their minimum position.
- Connect the power amplifier’s mains plug to a 230Vac variac output.
VERIFICATION:
- Retire fuse F101 (or its matching fuse on any other tested channel), placed at channel
one’s +Vcc. In its place, insert a 10 A ranged DC ammeter.
- Connect the power amplifier mains plug to the variac output, turned down to deliver 0V.
Switch over the unit’s main POWER switch to ON. Slowly increase the variac’s output
until it reaches 230V output voltage, and verify that the current consumption adjustments
remain correct: 150mA. If this value has changed, rectify it. Once adjusted, seal the
potentiometer with fixing lacquer.
- Retire the ammeter and replace instead the F101 fuse. Caution! The unit’s power supply
will be charged! Previously the power supply should be properly discharged, or disconnect
the module’s power supply wires (yellow-, black- and brown-colored wires) to avoid
electrical shocks. Repeat this procedure on all other channels.
- Once the current consumption is checked, switch off and again on the unit with its main
power switch, verify that the green neon lights up, that the unit first remains for 10
seconds in STANDBY mode and that the cooling fans run up to maximum speed.
- Apply a 0dB 1KHz signal to XLR-type input 1, by turning on the signal generator.
- Connect a 4Ω load to this channel’s output.
- Verify the unit’s output power when working at nominal mains voltage (230Vac).
Vo=41Vrms (millivoltmeter)
- To verify the ANTICLIP function, increase the input signal level above 0dB and check that
the clipping output signal is smoothened. Place a mini-jumper into the test point terminal
near the VTL5C8 device, verify that the anticlip function now is triggered earlier and
rounds the clipping signal even more. Check the CLIP indicator LED’s are lit, and, when
reducing the output signal level in 0’5 or 1dB, the CLIP LEDs turn off. Leave the minijumper inserted.
- Verify the unit’s bandwidth curve, which, with a 2KHz 0’5V input signal, should be linear
between 20Hz and 20KHz without inducing any distortion to the output signal. Also check
that when applying an input signal up to 50KHz, the unit’s output level only decreases in 1
or 2 dB, and no visible distortion is observed.
LE R
51.0098
version:
01.00
approved:
date:
title:
021007
project:
VERIFICATION PROCESS
EP14-02
product:
MPA4-400
51-0098-0100 EP14-02 Anglès.doc 1 of 4
Page 62
- Connect a load impedance formed by a 4Ω resistor shunted to a 1µ5F capacitor, and
apply a 1KHz square waveform input signal. Using an oscilloscope, observe the output
signal, at the flat level areas of the squared waveform, only two or three ringings should
be detected both at positive and negative slope flanges. Increase the input signal level until
the displayed signal starts clipping. Check that, even when clipping, the ringings do not
grow, and no more ringings than before appear either.
- Verify the THERMAL protection circuitry. Short the unit’s thermal probe pins 1 and 2 (see
the component placement sheet), and verify that the relay releases, while the THERMAL
indicator light up, as the output signal is cutted off and the cooling fan increases its speed
until it reaches maximum airflow.
PROTECTIONS
- Signal generator OFF, 1V scale, select a 1KHz output signal and keep the level
potentiometer down to its minimum.
- Connect a 0'5Ω load impedance.
- Connect the oscilloscope to the module’s output.
- Switch on the generator and turn up slowly the output level potentiometer, while
checking that the output voltage keeps below these limits, as listed below:
FIRST EVALUATION POINT: 15Vpp (240V)
SECOND EVALUATION POINT: 18Vpp (210V)
Note: the signal clipping should appear without any distortion or ringing. Both evaluation
points are obtained by adjusting the variac’s output voltage.
- Repeat this process on all the other channels.
CHECKING INPUT SELECTION SWITCHES.
Initial positioning:
- IN1/IN1+IN2 → IN1
- IN2/LINK IN1 → LINK IN1
- LP FILTER ON/OFF → OFF
BRIDGE IN 1
STEREO
CHANNEL 2
LP FILTER
OFF
IN 2
CHANNEL 1
IN 1
- ST/B IN1/B IN1+IN2 → ST
- IN3/LINK1 → LINK IN1
BRIDGE
IN 1+IN 2
ON
IN 2
LINK CH 1
IN 1
IN 1+IN 2
- IN4/LINK2 → LINK IN2
IN 4
CHANNEL 3
IN 3
IN 3 LINK CH 1
- HP FILTER ON/OFF → OFF
0dBV 1KHz input signal to IN1
Millivoltmeter/oscilloscope
connected to channel 1 and 2.
ON
CHANNEL 4
IN 4
LINK CH 2
BRIDGE IN 3
STEREO
HP FILTER
OFF
BRIDGE
IN 3+IN 4
XLR CONNECTIONS: PIN 1 - GROUND, PIN 2 - PHASE, PIN 3 - NON PHASE
51-0098-0100 EP14-02 Anglès.doc 2 of 4
Page 63
- Channel 1’s Signal Present indicating LED lights up. Turn up channel one’s potentiometer.
Verify its sweep. Vo=41Vrms . Check that the output corresponds to the used channel.
- Channel 2’s Signal Present indicating LED lights up. Turn up channel two’s
potentiometer. Verify its sweep. Vo=41Vrms . Check that the output corresponds to the
used channel.
- Both outputs are in phase.
- On the channel’s ST/B IN1/B IN1+IN2 switch, select IN1+IN2. By now both outputs
should be push-pull configured. The S.P.2 indicating LED turns off. Verify that now only
channel one’s input potentiometer is active, and leave it up to its maximum position.
- Change the millivoltmeter/oscilloscope test probes from the actual outputs to outputs
3-4.
- Verify that channel 3’s Signal Present indicating LED is lit. Turn up channel 3’s input
potentiometer. Verify it’s sweep. Vo=41Vrms . Check that the output corresponds to the
used channel.
- Verify that channel 4’s signal present indicating LED is lit. Turn up channel 4’s input
potentiometer. Verify it’s sweep. Vo=41Vrms . Check that the output corresponds to the
used channel.
- Both outputs are in phase.
- On the unit’s ST/B IN1/B IN3+IN4 switch, select IN3+IN4. By now both outputs should
be push-pull configured. The S.P.4 indicating LED turns off. Verify that now only channel
three’s input potentiometer is active, and leave it up to its maximum position.
- Verify that all CLIP-indicating LED’s are lit. If necessary, add 1 or 2 dB’s to the input
signal level.
- On the IN1/IN1+IN2 switch, select IN1+IN2. Check that the output level has dropped
6dB.
- Leave the switch again to IN1.
BURNING TEST.
- Leave the unit loaded and connected to its nominal mains voltage, while applying input
signal, and keep it working at 3dB under its maximum output level during 24 hours.
SAFETY VERIFICATION TESTS.
Preliminary:
- Unplug the unit to be tested from the mains outlet.
- Short all ground terminals from signal inputs, outputs and other external connectors,
except the mains plug’s ground.
- Turn ON the unit’s main power switch.
Ground continuity test:
- Connect the tester’s probes between the mains ground contact and the unit’s backside
main ground test point. When applying a 10A current, verify that the ground impedance is
lower than 0’1Ω.
51-0098-0100 EP14-02 Anglès.doc 3 of 4
Page 64
Electrical insulation test:
- Connect the electrical insulation tester probes between the mains outlet ground contact
and both shorted mains input poles.
- Adjust the tester’s current limit down to 10mA.
- Apply 1500Vac during 5 seconds.
- The unit’s insulation should be able to resist this voltage, without generating spurious
sparks or a sparkover effect, and the tester may not detect any misfunction.
CAUTION: Do not disconnect nor touch the test probes until the test has finished
completely!
VERIFICATION USING MUSIC
- This unit is a four channel power amplifier, with a flexible input channel selection system,
which actually increases its range of use and connection applications. All input selection
stages and input combinations have been fully verified in the “CHECKING INPUT
SELECTION SWITCHES” section.
- Verify all inputs and outputs. Release all the input selection switches.
- Verify the input potentiometers sweeps, which should completely cut off the signal when
turned down, and should not produce any noise or scratching.
- Verify the unit’s sound quality, free from distortion and noise.
- Verify background noise in each channel.
- Check the low pass filters on channel 1, and the high pass filters on channels 3 and 4.
- Hit the unit several times against your working desk to ensure that there are no failing
contacts and defective junctions.
- While applying input signal, short the unit’s output contacts. Verify that when the
shorting is retired, the unit recovers its normal functioning status.
QUALITY CONTROL
All mechanical parts should be visually revised, in order to detect scratches on the unit's
painting; all screws should be on their place, correctly tight and unmarked. Check out the
unit's general presentation.
51-0098-0100 EP14-02 Anglès.doc 4 of 4
Page 65
author: J. Colomines date: 020916 project:
Ω
y
C
E
num:
POWER 20-20kHz 1% THD
1 Channel @ 4Ω 410 WRMS
1 Channel @ 8Ω 230 WRMS
All Channels @ 4Ω
All Channels @ 8Ω
1 Bridged channel @ 8Ω (all channels driven)
Frequency response (-1dB)
Filter (Hi-Lo) 3rd order Butterworth
LER
53.0036 version: 01.00
approved:
A.S.
title:
TECHNICAL CHARACTERISTICS
EP14-02
305 WRMS
200 WRMS
610 WRMS
7Hz - 50kHz
160Hz
product:
MPA4-400
THD+Noise @ 1kHz Full Pwr.
Intermodulation distortion 50Hz & 7kHz, 4:1
TIM 100
S+N/N 20Hz -20kHz @ 1W/4Ω
Damping factor 1kHz @ 8
Slew Rate
Channel crosstalk @ 1kHz
Input Sensitivity / Impedance
Anticlip
Power consumption (max. Out)
Dimensions
Weight
Mains Depending on your countr
<0,05%
<0,08%
<0,03%
>85dB
>300
±50V/µs
>70dB
0dBV / >20kΩ
1 & 5% THD
2550 VA
Panel
Depth
See characteristics in the back of the unit.
482.6x88 mm
415 mm
19.4kg
Page 66
2 x 16.1110.05.00
16.1049.01.50
16.1086.01.00
16.1087.01.00
3x Heat Shrink code: FCMC00TR10
16.1021.02.50
16.1112.02.50
16.1021.02.50
2 x 16.1005.05.50
4 x 16.1024.05.00
2 x 16.1111.05.00
2 x 16.1017.04.00
2 x 16.1016.04.00
16.1005.04.00
16.1005.04.00
16.1097.05.0016.1005.05.5016.1097.05.00
Page 67
Page 68
Page 69
h
Nº Qty ECLER Code Description
1 1 FCARDE040000 TOOTHED WASHER M4
2 4 FCARDEPOTE00 ROTARY POT. WASHER M9
3 1 FCARM1050000 WASHER 10,5X30X2,5M
4 1 FCARS4000000 SEGMENTED WASHER M4
5 1 FCBASRE50000 MAINS SOCKET
6 1 FCBOR0030000 GROUND TERMINAL
7 1 FCETIZTT0000 EARTH TAG
8 8 FCINSPLA10/1100 BINDING POSTS SECURITY CAP
9 1 FCINTRED3000 MAINS SWITCH W/LIGHT
10 2 FCREJ0800000 FAN GRILLE 80x80
11 4 FCSEPWLS0600 PLASTIC SPACER 6MM
12 8 FCT060512000 SCREW 5,1x20
13 10 FCT400290900 SCREW 2,9x9,5 D7981F BLACK
14 27 FCT804006000 SCREW M4x6 SPANLO BLACK
15 4 FCT804012000 SCREW M4x12 D965 SPANLO
16 1 FCT850411000 SCREW M4x10 TRILOB. WHITE
17 1 FCTFTMPA8500 TOROIDAL TRANSFORMER
*
*
18 4 FCTUPOT00000 ROTARY POT. NUT M9
19 1 FP0274900000 BASE CHASSIS
20 1 FP0275000000 FRONT PANEL
21 1 FP0275100000 FRONTAL CIRCUIT MEC. SUPORT
22 1 FP0275200000 MECHANICAL REINFORCEMENT
23 2 FP0275300000 LEFT/RIGHT SIDE
24 1 FP0275400000 TOP COVER
25 2 FP0275600000 MODULE SUPPORT PLATE 305 mm
26 4 FRBOTRD24000 ROTARY KNOB D24
27 2 FRVEN080B000 FAN 80x80 12VDC CABLE=300
28 2 GENERIC HEATSINK POWER MODULE 305 mm
29 2 GENERIC FOUR POLE BINDING POST
30 1 GENERIC TOOTHED WASHER M8
31 1 GENERIC SCREW M8 TRANSFORMER
32 1 GENERIC TRANSFORMER RUBBER DISC
33 1 GENERIC TRANSFORMER NUT M8
*FOR 100V UNIT, TRANSFORMER CODE FCTFTMPA9000
*
*
24
1
THE DIRECTION OF THE ARROWS
PRINTED ON THE CIRCUIT BOARD
INDICATES THE ORIENTATION
OF AMPLIFIER POWER MODULES
25
2
28
2
21
1
2
4
33
1
30
1
3
1
17
1
22
1
32
1
12
8
E
number:
C
LE R
30.0186
version
NOTE ABOUT ASSEMBLING PROCESS OF FRONT PANEL
AND LEFT/RIGHT SIDES:
TO AVOID DEFORMATIONS IN THE FRONT PANEL,
YOU MUST ASSEMBLE FIRST THIS FRONT PANEL AND
AFTER BOTH LEFT & RIGHT SIDES.
drawn: date:
Jordi Folc
approved:
01.02
18
4
26
4
20
1
15
4
9
1
title:
041108
project:
EP14-02
product:
MPA 4-400
29
2
MECHANICAL DIAGRAM
W
O
L
F
R
I
A
7
1
1
1
16
8
8
31
1
27
2
19
1
11
4
14
27
23
2
1
NOTE:
1.-TO VIEW CABLES POSITION AND WIRING
CHARACTERISTICS, SEE WIRING DIAGRAM
NUMBER 31.0172
13
10
10
2
5
1
6
1
4
1
Page 70
h
Nº Qty ECLER Code Description
1 1 FCARDE0400 TOOTHED WASHER M4
2 1 FCARDE0800 TOOTHED WASHER M8
3 4 FCARDEPOTE ROTARY POT. WASHER M9
4 1 FCARM10500 WASHER 10,5X30X2,5M
5 1 FCARS40000 SEGMENTED WASHER M4
6 1 FCBASRE500 MAINS SOCKET
7 1 FCBOR00300 GROUND TERMINAL
8 4 FCBOTD2400 ROTARY KNOB D24
9 8 FCINSPLA10/11 BINDING POSTS SECURITY CAP
10 1 FCINTRED30 MAINS SWITCH W/LIGHT
11 1 FCMEC02749 BASE CHASSIS
12 1 FCMEC02750 FRONT PANEL
13 1 FCMEC02751 FRONTAL CIRCUIT MEC. SUPORT
14 1 FCMEC02752 MECHANICAL REINFORCEMENT
15 2 FCMEC02753 LEFT/RIGHT SIDE
16 1 FCMEC02754 TOP COVER
17 2 FCMEC02756 MODULE SUPPORT PLATE 305 mm
18 2 FCREJ08000 FAN GRILLE 80x80
19 4 FCSEPWLS06 PLASTIC SPACER 6MM
20 8 FCT0605120 SCREW 5,1x20
21 10 FCT4002909 SCREW 2,9x9,5 D7981F BLACK
22 27 FCT8040060 SCREW M4x 6 SPANLO BLACK
23 4 FCT8040120 SCREW M4x12 D965 SPANLO
24 1 FCT8504110 SCREW M4x10 TRILOB. WHITE
25 1 FCTFTMPA85 TOROIDAL TRANSFORMER
*
*
26 4 FCTUPOT000 ROTARY POT. NUT M9
27 2 FCVEN08000 FAN 80x80 12VDC
28 2 GENERIC HEATSINK POWER MODULE 305 mm
29 1 GENERIC SCREW M8 TRANSFORMER
30 1 GENERIC TRANSFORMER RUBBER DISC
31 1 GENERIC TRANSFORMER NUT M8
32 2 GENERIC FOUR POLE BINDING POST
*FOR 100V UNIT, TRANSFORMER CODE FCTFTMPA90
*
*
16
1
THE DIRECTION OF THE ARROWS
PRINTED ON THE CIRCUIT BOARD
INDICATES THE ORIENTATION
OF AMPLIFIER POWER MODULES
17
2
28
2
13
1
3
4
31
1
2
1
4
1
25
1
14
1
30
1
20
8
E
number:
C
LE R
30.0186
version
NOTE ABOUT ASSEMBLING PROCESS OF FRONT PANEL
AND LEFT/RIGHT SIDES:
TO AVOID DEFORMATIONS IN THE FRONT PANEL,
YOU MUST ASSEMBLE FIRST THIS FRONT PANEL AND
AFTER BOTH LEFT & RIGHT SIDES.
drawn: date:
Jordi Folc
approved:
01.01
26
4
8
4
12
1
23
4
10
1
title:
021217
project:
EP14-02
product:
MPA 4-400
32
2
MEC HAN ICAL DI AGRAM
W
O
L
F
R
I
A
1
1
24
9
8
29
1
27
2
11
1
19
4
22
27
15
2
1
NOTE:
1.-TO VIEW CABLES POSITION AND WIRING
CHARACTERISTICS, SEE WIRING DIAGRAM
NUMBER 31.0172
21
10
18
2
6
1
7
1
5
1
Page 71
h
11
1
13
1
15
1
5
1
4
1
9
1
3
2
8
4
14
4
2
4
1
4
12
1
6
4
Nº Qty ECLER Code Description
1 4 FCARAT300000 SCREW INSULATOR
2 4 FCARN5000000 WASHER 5X11,5X0,8
3 2 FCBOL0010000 BAG 60x80
4 1 FCBOL0020000 PLASTIC BAG 120x180
5 1 FCBOLS020000 STANDARD BAG 75x65
6 4 FCBOTD240100 ROT. KNOB PROTECTION COVER
7 1 FCCAJSTA1900 PACKING CARDBOARD BOX
8 4 FCCANT116000 INTERIOR REINFORCEMENT
9 1 FCCONX017500 MAINS CABLE 3x1
10 1 FCETI0951140 PRODUCT LABEL PACK (ONE FOR EACH UNIT)
11 1 FCFUNMAN0000 USER MANUAL BAG
12 1 FCFUS8040000 FUSE 16A 10x38
13 1 FCMANMPA1200 USER MANUAL
14 4 FCPIE1125500 RUBBER FOOT
15 1 FCTARJG00000 WARRANTY CARD
drawn: date:
C
E
number:
LE R
32.0097
version
01.01
approved:
Jordi Folc
title:
040213
10
1
project:
EP14-02
product:
MPA 4-400
PACKING DIAGRAM
7
1
Page 72
11
1
13
1
15
1
5
1
4
1
9
1
3
2
8
4
14
4
2
4
1
4
12
1
6
4
Nº Qty ECLER Code Description
1 4 FCARAT3000 SCREW INSULATOR
2 4 FCARN50000 WASHER 5X 11,5X0,8
3 2 FCBOL00100 BAG 60x80
4 1 FCBOL00200 PLASTIC BAG 120x180
5 1 FCBOLS0200 STANDARD BAG 75x65
6 4 FCBOTD2401 ROT. KNOB PROTECTION COVER
7 1 FCCAJSTA19 PACKING CARDBOARD BOX
8 4 FCCANT1160 INTERIOR REINFORCEMENT
9 1 FCCONX0175 MAINS CABLE 3x1
10 2 FCETICAJA0 UNIT INFORMATION LABEL
11 1 FCFUNMAN00 USER MANUAL BAG
12 1 FCFUS80400 FUSE 16A 10x38
13 1 FCMANMPA12 USER MANUAL
14 4 FCPIE11255 RUBBER FOOT
15 1 FCTARJG000 WARRANTY CARD
C
E
number:
LE R
32.0097
version
01.00
drawn: date:
Jordi Folch
approved:
title:
020925
10
2
project:
EP14-02
product:
MPA 4-400
PACKING DIAGRAM
7
1
Loading...