DuPont 07865 User Manual

MATERIAL SAFETY DATA SHEET

FILE NO.: 039
Tower Sealants -DuPont™ Concrete & Masonry Sealant with Kevlar® MSDS DATE: 2/24/12
SUPERCEDES: 2/11/22

PAGE 1 OF 5

SECTION 1: PRODUCT AND COMPANY IDENTIFICATION

PRODUCT NAME: DuPont™ Concrete & Masonry Sealant with Kevlar®
SYNONYMS: Sealant, Caulk
PRODUCT CODES: DP-07865

MANUFACTURER: Tower Sealants
ADDRESS: 2095 Memorial Park Road Gainesville Georgia 30504

EMERGENCY CONTACT: Chemtrec
CHEMTREC PHONE: [phone]
OTHER CALLS: Not Applicable

CHEMICAL NAME: Acrylic Sealant
CHEMICAL FAMILY/Use: Sealant
CHEMICAL FORMULA: Mixture

PREPARED BY: Robert S Stannard V. P. Chemical Technology Tower Sealants

SECTION 2: COMPOSITION / INFORMATION ON INGREDIENTS

INGREDIENT CAS NO. % WT TLV PEL - TWA

Limestone 1317-65-3 25-40 2 mg/m

3

15 mg/m3
Mineral Spirits 8052-41-3 < 1.5 100 ppm 100 ppm
Ethylene Glycol 107-21-1 0.05-2 Not Established Not Established
Acrylic Polymer Proprietary 45-60 Not Established Not Established
Oxydiethylene dibenzoate 120-55-8 1-5 Not Established Not Established
Water 13463-67-7 >5 Not Established Not Established
Titanium Dioxide 13463-67-7 0.1-10 15 mg/m

3

15 mg/m

3

Quartz (SiO2) 14808-60-7 <0.1 - 1

0.1 mg/m

3

0.1 mg/m

3

SECTION 3: HAZARDS IDENTIFICATION

EFFECTS OF OVEREXPOSURE -
ACUTE EFFECTS:

EYES: Direct contact may cause slight to moderate irritation.
SKIN: May cause allergic skin reactions and / or central nervous system depression.
INHALATION: May cause slight irritation to respiratory passages – headache – dizziness.
INGESTION: Low ingestion hazard in normal use.

PROLONGED / REPEATED EXPOSURE EFFECTS:

SKIN: May cause allergic skin reactions, defatting, drying, and dermatitis.
INHALATION: No applicable information available.
INGESTION: May cause adverse kidney effects.

Print Date: 7 - 6 - 2012

MATERIAL SAFETY DATA SHEET

FILE NO.: 039
Tower Sealants -DuPont™ Concrete & Masonry Sealant with Kevlar® MSDS DATE: 2/24/12
SUPERCEDES: 2/11/22

PAGE 2 OF 5

OTHER: Some adverse reproduction effects have been reported in animals.

This product contains crystalline silica which can cause lung cancer or silicosis. The risk of cancer
depends on the duration and level of exposure to dust from sanding surfaces or mist from spray

applications. Since this product is not designed to be sanded, the risk of exposure is considered

to be low

This formulation contains material which in their raw form are considered dust hazards. When in this formulation, the dust hazards
are essentially eliminated.

SECTION 4: FIRST AID MEASURES

EMERGENCY FIRST AID PROCEDURES –

EYES: Flush with large volumes of water for 15 to 30 minutes. Remove contacts after the first 2 minutes of

flushing. Get medical attention.

SKIN: Wash with soap and water or waterless cleanser. Get medical attention if irritation develops or persists.
INHALATION: Move to fresh air. Get medical attention.
INGESTION: Do not induce vomiting. Seek medical attention from a physician. Never give anything by mouth to an

unconscious person.

OTHER: No ingredient in this product is an IARC, NTP or OSHA listed carcinogen.

SECTION 5: FIRE-FIGHTING MEASURES

Flash Point: Waterbased product flash point not applicable
Explosion Hazard: Waterbased product, not an explosion hazard
LEL: Not Applicable
Extinguishing Media: Carbon dioxide, dry chemical, foam, or water spray
Unusual Fire and Explosion Hazards: Material can splatter above 200°F

Special Fire Fighting Procedures: Water can be used to cool fire-exposed containers. Self-contained

breathing apparatus and protective clothing should always be worn
when fighting large fires involving chemicals.

SECTION 6: ACCIDENTAL RELEASE MEASURES

In the case of accidental release or spill: Follow all recommendations regarding Personal Protective

Equipment. Preferred method would be to scrape up spilled material and place in secondary container for
disposal. Smaller spills can also be wiped up. Residual material can be removed with the assistance of hot water
and soap. White water should be captured and contained for disposal.

Disposal Method: All material must be disposed in accordance with Federal, State, and Local Regulations. This
includes any white water created in the cleaning of the spill.

SECTION 7: HANDLING AND STORAGE

HANDLING AND STORAGE:

Protect from freezing

.

Rotate all stock.

.

Store in a cool, dry place.
Keep away from food, feed, or drinking water.
Keep container closed when not in use.

Print Date: 7 - 6 - 2012