Drolet Savannah, Jurassien, Adirondack, ElDorado, Celtic User Manual

OWNER`S MANUAL

ELDORADO, ADIRONDACK, JURASSIEN,

CELTIC AND SAVANNAH

US ENVIRONMENTAL PROTECTION

AGENCY PHASE II CERTIFIED

WOODSTOVES

Verified and tested following

ULC S627 and UL 1482 Standards by:

Intertek Testing Services

Manufactured by : STOVE BUILDER INTERNATIONAL INC.

1700, Léon-Harmel, Québec (Québec) G1N 4R9

Tel : ( 418 ) 527-3060

Fax : ( 418 ) 527-4311

www.drolet.ca

READ AND KEEP THIS MANUAL FOR REFERENCE

45061.doc feb 03

INTRODUCTION............................................................................................................... 2

TECHNICAL SPECIFICATIONS.......................................................................................3

ASSEMBLY....................................................................................................................... 4

PEDESTAL AND PANELS ............................................................................................ 4

LEGS AND ASH PAN.................................................................................................... 5

DOOR ADJUSTMENT................................................................................................... 6

THE BENEFITS OF INSTALLING A BLOWER................................................................. 7

INSTALLATION................................................................................................................. 8

POSITIONING THE STOVE.......................................................................................... 8

FLOOR PROTECTOR................................................................................................... 9

CLEARANCES FROM COMBUSTIBLES.................................................................... 10

REDUCED CLEARANCES.......................................................................................... 11

CHIMNEY.................................................................................................................... 12

CHIMNEY CONNECTOR (STOVE PIPE).................................................................... 13

TYPICAL INSTALLATIONS......................................................................................... 14

OUTSIDE COMBUSTION AIR..................................................................................... 18

WOODSTOVE UTILISATION.......................................................................................... 19

AVERAGE ENERGY YIELD OF ONE AIR DRIED CORD OF CUT WOOD................ 19

TESTING YOUR WOOD ............................................................................................. 20

THE FIRST FIRES....................................................................................................... 20

IGNITION..................................................................................................................... 20

HEATING..................................................................................................................... 21

RELOADING................................................................................................................ 22

CREOSOTE FORMATION AND NEED FOR REMOVAL............................................ 22

ASH DISPOSAL .......................................................................................................... 23

MAINTENANCE..............................................................................................................24

GLASS......................................................................................................................... 24

GASKETING................................................................................................................ 24

PAINT.......................................................................................................................... 24

LIMITED LIFETIME WARRANTY.................................................................................... 25

INTRODUCTION

SBI INC., one of the most important wood stove and fireplace manufacturers in Canada, congratulates you on your purchase and wishes to help you get maximum satisfaction from your wood stove. In the pages that follow, we will give you advice on wood heating and controlled combustion as well as technical specifications regarding installation, operation and maintenance of the model you have chosen.

The instructions pertaining to the installation of your wood stove comply with ULC-S627 and UL-1482 standards.

Read this entire manual before you install and use your new stove. If this stove is not properly installed, a house fire may result. To reduce the risk of fire, follow the installation instructions. Failure to follow instructions may result in property damage, bodily injury, or even death.

Consult your municipal building department or fire officials about restrictions and installations requirements in your area and the need to obtain a permit.

Keep this instructions manual for future references.

CAUTIONS:

• HOT WHILE IN OPERATION. KEEP CHILDREN, CLOTHING AND FURNITURE AWAY. CONTACT MAY

CAUSE SKIN BURNS.

• DO NOT USE CHEMICALS OR FLUIDS TO IGNITE THE FIRE.

• DO NOT LEAVE THE STOVE UNATTENDED WHEN THE DOOR IS SLIGHTLY OPENED.

• DO NOT BURN WASTES, FLAMMABLE FLUIDS SUCH AS GASOLINE, NAPHTHA OR MOTOR OIL.

• DO NOT CONNECT TO ANY AIR DISTRIBUTION DUCT OR SYSTEM.

• ALWAYS CLOSE THE DOOR AFTER THE IGNITION.

TECHNICAL SPECIFICATIONS

Combustible: Recommended Surface

Wood

500 to 1 500 ft

(47 to 140 m2)

Heating Capacity : E.P.A :

44 000 BTU/h

(12.8kW)

Efficiency : Emissions: Colours :

Flue Pipe Diameter : Chimney type :

Minimum Chimney Height : Maximum Log Length :

Dimensions Overall:

Eldorado Celtic : Adirondack, Savannah : Jurassien :

Combustion Chamber : Width x Depth :

Volume : Door Opening :

All Models :

Pyroceram Glass Door :

Adirondack, Celtic, Savannah, Eldorado : Jurassien :

75.32 %

6.28 g/h

Metallic Black

6’’ (152 mm)

2 100°F (650 °C)

12’ (3,66 m)

18’’ (460 mm)

W x D x H

25 x 24 x 26’’

(635 x 533 x 660mm)

25 x 24 x 26’’

(635 x 533 x 660mm)

31 x 18 ¾ x 29 ¾’’

(788 x 476 x 756mm)

W x D

20 ¼ x 11 ¼ ’’

(514 x 286 mm)

1,47 pi

(0,04 m3)

W x H 7 5/8’’ x 18 1/4’’ (200 x 464 mm)

W x H

8 ¾ ’’ x 16 ½ ’’

(222 x 419 mm)

10’’ x 18 ¼ ’’

(254 x 464 mm)

Weight: Eldorado : Adirondack, Celtic, Savannah : Jurassien :

255 lbs ( 116 Kg) 280 lbs ( 127 Kg) 415 lbs ( 188 Kg)

OPTIONS PART NUMBER

Ultra-quiet blower with variable speed control All Models: AC02050 Thermodisc 90 -120oF (32-490C). All Models: AC05530

Outside air intake kit All Models: AC02080

ASSEMBLY

PEDESTAL AND PANELS

Pedestal Base Installation:

1. Slide the front part of the pedestal base around the pedestal and fix the rear part with the two supplied screws.

2. Slide the ash pan in position.

Side Panels and Ash Lip Installation:

1. Start by fixing the front part of the decorative side in the two clips welded on the sides of the fire box.

2. Then, fix the back of the decorative side with two screws and washers supplied. Line up the decorative side parallel to the side of the appliance.

3. Clip the ash lip into position, centred just below the door.

LEGS AND ASH PAN

Ash Lip Installation :

1. Just clip the ash lip into position, centred just below the door.

2. Slide the ash pan in position.

DOOR ADJUSTMENT

In order for your stove to operate properly, the door should be adjusted periodically to provide an air tight fit. To adjust:

• Remove the lock pin (spring pin) by pulling and turning it using pliers ("wise grip")

• Turn the handle counter clock wise one turn to increase pressure

• Re-install the lock pin (spring pin) with a small hammer

Figure 1: Door Adjustment

THE BENEFITS OF INSTALLING A BLOWER

A blower can be installed at the back of your DROLET stove. This option is necessary if you wish to redistribute into a room the heat trapped at the back of your stove. By forcing hot air toward the front, the blower enables you to extend the radiation power of your stove. You can purchase this option through your DROLET dealer. Make sure to specify this part number: #AC02050. You can also install a thermodisc to enable the blower to start or stop automatically when the stove is hot or too cold. The thermodisc part number is AC05530. Installation instructions are supplied with the blower and the thermodisc.

+ 18 hidden pages