DeDietrich Elidens DTG130-45, Elidens DTG130-90, Elidens DTG130-115, Elidens DTG130-65 User Manual
DTG130 - 45/65/90/115 Eco.NOx Plus
Gas fired condensing boiler
ELIDENS
User Guide
300005222-02
EN
2
DTG130 - 45/65/90/115 Eco.NOx Plus 18/06/2015 - 300005222-02
Contents
1 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
1.1 General safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
1.1.1 Fire hazard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
1.1.2 Risk of intoxication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
1.1.3 Risk of being burnt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
1.1.4 Risk of damage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
1.2 Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
1.3 Ventilation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
1.3.1 Chimney versions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
1.3.2 Forced flue versions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
1.4 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
1.5 Adapting to another gas type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
1.6 Liabilities. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
1.6.1 Manufacturer's liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.6.2 Installer's liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
1.6.3 User's liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
2 About this manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
2.1 Symbols used in the manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
2.2 Abbreviations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
3 Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
3.1 Boilers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
3.2 Control panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
3.2.1 Electromechanical components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
3.2.2 Display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
3.2.3 Keys accessible when the flap is closed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
3.2.4 Keys accessible when the flap is open . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
4 Energy savings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
5 Commissioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
6 Switching off the boiler. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
7 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
8 Alarm messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
9 Appendix - Information on the Ecodesign and Energy Labelling Directives. . . . . . . . . . . . . . . . . . . . . . . .12
German instructions reference 300003110 available on request.
3
18/06/2015 - 300005222-02 DTG130 - 45/65/90/115 Eco.NOx Plus
1 Safety instructions
Danger
This appliance can be used by children aged
from 8 years and above and persons with
reduced physical, sensory or mental capabilities
or lack of experience and knowledge if they have
been given supervision or instruction
concerning use of the appliance in a safe way
and understand the hazards involved. Children
shall not play with the appliance. Cleaning and
user maintenance shall not be made by children
without supervision.
Any operation on the installation must be
performed by a qualified technician respecting
professional regulations and in accordance with
this document.
Before any work, switch off the mains supply to
the appliance. Protect the installation against
any unwanted restarts.
1.1 General safety instructions
1.1.1 Fire hazard
Do not stock products of an inflammable nature
close to the appliance.
If you smell gas, do not use a naked flame, do not
smoke, do not operate electrical contacts or
switches (doorbell, lights, motor, lift, etc.).
1.Shut off the gas supply
2.Open the windows
3.Extinguish all flames
4.Evacuate the premises
5.Contact a qualified professional
6.Inform the gas supplier
1.1.2 Risk of intoxication
Do not obstruct the air inlets in the room (even
partially).
If you smell flue gases
1. Switch the appliance off
2. Open the windows
3. Evacuate the premises
4. Contact a qualified professional
1.1.3 Risk of being burnt
Avoid direct contact with the flame viewport.
Depending on the settings of the appliance:
- The temperature of the flue gas conduits may exceed
60°C
- The temperature of the radiators may reach 95°C
- The temperature of the domestic hot water may reach
65°C
1.1.4 Risk of damage
Do not stock chloride or fluoride compounds
close to the appliance.
Install the appliance in frost-free premises.
Do not neglect to service the appliance: Contact a
qualified professional or take out a maintenance contract
for the annual servicing of the appliance.
4
DTG130 - 45/65/90/115 Eco.NOx Plus 18/06/2015 - 300005222-02
1.2 Recommendations
For a proper operating of the boiler, follow
carefully the instructions.
Any intervention on the appliance and heating
equipment must be carried out by a qualified
engineer.
The manufacturer is not liable for any improper
use of the appliance or failure to maintain or
install the unit correctly (the user shall take care
to ensure that the system is installed by a
qualified engineer).
Check the seal on the gas and water pipe
connections.
Check that the appliance is properly set for the
type of gas used.
Keep to the polarity shown on the terminals:
phase (L), neutral (N) and earth 4.
Check regularly that the installation contains
water and is pressurised.
Burn hazard in direct contact with the flame
inspection window.
1.3 Ventilation
1.3.1 Chimney versions
Do not obstruct the air inlets in the room (even
partially).
France: the cross section of the aeration vent, which is
compulsory in the boiler room in which the boiler is
installed, must comply with the DTU 61.1 (P 45 204)
standard and, in particular, with the instruction on boiler
room layout (Book 1764 April 1982).
Belgium:the cross-section of the aeration vents, which
are compulsory in the room in which the boiler is installed,
must comply with the NBN D51-003 standard.
Germany: the cross section of the ventiliation vents,
which are compulsory in the room in which the boiler is
installed, must comply with the VDI 2050 form 1 standard
and with other prevailing regulations.
Other countries: the cross section of the aeration inlet,
which is compulsory in the premises in which the boiler is
installed, must comply with the standards in force in the
country.
1.3.2 Forced flue versions
It is not necessary to provide ventilation of the premises
in which the boiler is installed. Ventilation is required if a
mechanical connection to the gas exists.
1.4 Maintenance
- The servicing and cleaning of the boiler and the
sweeping of the flue gas pipe and the bleed pot must be
done at least once a year by a qualified professional.
- Regularly check the level of water in the system and top
up if required, taking care that cold water is not added
suddenly into the boiler when it is hot.
- We recommend taking out a maintenance contract.
Do not drain the installation, except in cases of
absolute necessity. For example: Several
months' absence with the risk of ice in the
building.
1.5 Adapting to another gas type
Belgium:
The operations required to switch from one gas to another
must be carried out by a SERV'elite technician.
Other countries:
The operations required to switch from one gas to another
must be carried out by your fitter.
5
18/06/2015 - 300005222-02 DTG130 - 45/65/90/115 Eco.NOx Plus
1.6 Liabilities
1.6.1 Manufacturer's liability
Our products are manufactured in compliance with the
requirements of the various applicable European
Directives. They are therefore delivered with CE marking
and all relevant documentation. In the interest of
customers, we are continuously endeavouring to make
improvements in product quality. All the specifications
stated in this document are therefore subject to change
without notice.
Our liability as the manufacturer may not be invoked in
the following cases:
- Failure to abide by the instructions on installing the
appliance
- Failure to abide by the instructions on using the
appliance
- Faulty or insufficient maintenance of the appliance
1.6.2 Installer's liability
The installer is responsible for the installation and
commissioning of the appliance. The installer is required
to observe the following instructions:
- Read and follow the instructions given in the manuals
provided with the appliance
- Install the appliance in acordance with the legislation
and standards currently in force
- Perform the initial start up and carry out any checks
necessary
- Explain the installation to the user
- If a maintenance is necessary, warn the user of the
obligation to check the appliance and maintain it in
good working order
- Give all the instruction manuals to the user
1.6.3 User's liability
To guarantee optimum operation of the appliance, the
user must respect the following instructions:
- Read and follow the instructions given in the manuals
provided with the appliance
- Call on qualified professionals to carry out installation
and initial start up
- Get your installer to explain your installation to you
- Ensure the Appliance is serviced in accordance with the
manufacturer's instructions by a suitable qualified
person
- Keep the instruction manuals in good condition close to
the appliance
2 About this manual
2.1 Symbols used in the manual
Caution danger
Risk of injury and damage to equipment. Attention must be
paid to the warnings on safety of persons and equipment.
Specific information
Information must be kept in mind to maintain comfort.
Z
Reference
Refer to another manual or other pages in this instruction
manual.
2.2 Abbreviations
` DHW: Domestic hot water.
` PPS: Polypropylene hardly inflammable.
` 3CE: Collective conduit for sealed boiler
6
DTG130 - 45/65/90/115 Eco.NOx Plus 18/06/2015 - 300005222-02
3 Description
3.1 Boilers
The models presented are marketed in the various countries according to the countries' specific sales programme.
Boiler self-standing 45 kW - 65 kW Boiler self-standing 90 kW - 115 kW
Boiler with accumulator BC or BP
150,200,300 l 45,65,90,115 kW
C001269
C001270
C001276
Loading...