Page 1
Safety Data Sheet (SDS)
Date Prepared/Revised: 11/15/17 Version no.: 01 Supersedes: (-)
1.) Identification of the Mixture and of the Company
Product identifier: 831 Redo It
Product name:
Relevant identified uses of the substance: Aervoe Asphalt Redo It can be used to cover marks on asphalt
surfaces or prepare surfaces for new layers of striping.
Uses advised against: Do not use in non ventilated area.
CAS No: Not Applicable (mixture)
EC No: Not Applicable (mixture)
Index No: Not Applicable (mixture)
Manufacturer/Supplier: Aervoe Industries Incorporated
Street address/P.O. Box: 1100 Mark Circle
Country ID/Postcode/Place Gardnerville, Nevada 89410
Telephone number: 001 (0) 1-775-782-0100
e-mail: mailbox@aervoe.com
National contact: Aervoe Industries Incorporated
For Product Information: 001 (0) 1-800-227-0196
Emergency telephone number: 001 (0) 1-800-424-9300 (CHEMTREC – 24 hrs)
English Language Service
2. Hazards identification
Classifications
Physical Hazards: Aerosol - Category 1
Flam. Gas. 1
Press. Gas
Health Hazards:
Muta 1B
Asp Tox. 1
Environmental Hazards: N/AV
Labeling
Signal Word: Danger
Hazard Statements: H220 – Extremely flammable gas
H222 – Extremely flammable aerosol
H229 - Pressurized container: may burst if heated
Asphalt Sealer Primer
Car 1B
H304 - May be fatal if swallowed and enters airways
Page 2
Composition / Information on Ingredients
Safety Data Sheet (SDS)
Date Prepared/Revised: 11/15/17 Version no.: 01 Supersedes: (-)
H340 – May cause genetic defects
H350 – May cause cancer
Precautionary Statements: P101 - If medical advice is needed, have product container or label at hand
P102 - Keep out of reach of children
P103 - Read label before use
P210 - Keep away from heat/sparks/open flames/hot surfaces - no
smoking
P211 - Do not spray on an open flame or other ignition source
P251 - Pressurized container: Do not pierce or burn, even after use
P261 - Avoid breathing dust/fume/gas/mist/vapours/spray
P262 - Do not get in eyes, on skin, or on clothing
P264 - Wash … thoroughly after handling
P280 - Wear protective gloves/eye protection/face protection
P303+P361+P353 - If on skin or hair, remove/takeoff immediately all
contaminated clothing. Rinse skin with water/shower.
P410+P412 - Protect from sunlight. Do not expose to temperatures
exceeding 50ºC/122ºF
P501 - Dispose of contents/container in accordance with
local/regional/national/international regulation
Symbols/Pictograms:
3.
Composition
Page 3
Safety Data Sheet (SDS)
Date Prepared/Revised: 11/15/17 Version no.: 01 Supersedes: (-)
Chemical Synonyms CAS
Number
Aliphatic
Petroleum
Distillates
Hydrocarbon
Solvent
Naphtha
64742-89-8
LPG
Propellant
68476-86-8
Petroleum
Asphalt
Aliphatic
Hydrocarbon
Asphalt
8052-42-4
Petroleu
m
Distillat
e
8052-41-3
EINECS
Number
265-192-2
270-705-8
232-490-9
232-489-3
Weight
Percent
30-60%
10-30%
10-30%
3-7%
Hazard Category H-Code
Carc. 1B
Muta. 1B
Asp. Tox. 1
Press. Gas
Flam. Gas 1
Carc. 1B
H350
H340
H304
H220
H350
H340
Muta. 1B
N/AV N/AV
Carc. 1B
Muta. 1B
Asp. Tox. 1
H350
H340
H304
Other Product Information
Chemical Identity: Mixture
4.) First Aid Measures
General Advice: If symptoms persist, always call a doctor.
Inhalation First Aid: Remove victim to fresh air and provide oxygen if breathing is
difficult. If not breathing, give artificial respiration, preferably
mouth to mouth. Get medical attention immediately.
Skin Contact First Aid: Wash with soap and water. Remove contaminated clothing and
shoes. Get medical attention immediately. Wash clothing before
reuse.
Eye Contact First Aid: If contact with eyes, immediately flush eyes with plenty of water
for at least 15 minutes, while holding eyelids open. Get medical
attention immediately.
Ingestion First Aid: If swallowed, wash out mouth with water provided the person is
conscious. Do not induce vomiting. Never give anything by mouth
to an unconscious person. Get medical attention immediately.
Most Important
Symptoms/Effects: Exposure may cause slight irritation to the skin, eyes, and respiratory tract.
Excessive exposure may cause central nervous system effects.
5. Fire Fighting Measures
Flammable Properties: Flammable
Auto Ignition Temperature: Not Available
Page 4
Safety Data Sheet (SDS)
Date Prepared/Revised: 11/15/17 Version no.: 01 Supersedes: (-)
Suitable extinguishing media: Carbon dioxide, dry chemical, water spray.
Unsuitable extinguishing media: None known
Special hazards arising from the
substance or mixture: None known
Hazardous combustion products: Carbon dioxide, Carbon monoxide
Fire & Explosion Hazards: Closed Containers may rupture due to the buildup of pressure
from extreme temperatures.
Precautions for fire-fighters: Use water spray to cool containers exposed to heat or fire to prevent
pressure build up. In the event of a fire, wear full protective clothing and
NIOSH- approved self-contained breathing apparatus with full face piece
operated in the pressure demand or other positive pressure mode.
6. Accidental Release Measures
PERSONAL PRECAUTIONARY MEASURES:
1) Follow personal protective equipment recommendations found in section 8.
2) Maintain adequate ventilation.
SPILL CLEAN-UP PROCEDURES:
1.) Evacuate unprotected personnel from the area.
2.) Remove sources of ignition if safe to do so.
3.) Pickup spilled materials using non-sparking tools and place in an appropriate container for disposal.
4.) Contain spill to prevent material from entering sewage or ground water systems.
5.) Always dispose of waste materials in accordance with all EU, National and Local Regulations.
7. Handling and Storage
Handling:
Flammable Aerosol, use in a well ventilated area.
Do not use near sources of ignition.
Do not to eat, drink and smoke while working with this material.
Wash hands after use.
Conditions for safe storage, including any incompatibilities:
Store out of direct sunlight.
Storage Temperature: 32° to 120°F (0° to 49°C).
No known incompatibilities.
8. Exposure Controls / Personal Protection
Appropriate engineering controls:
Ensure adequate ventilation. A system of local and/or general exhaust is recommended to keep
employee exposures below the Airborne Exposure Limits.
Keep away from sources of ignition.
Take precautionary measures against static discharge.
Page 5
Safety Data Sheet (SDS)
Date Prepared/Revised: 11/15/17 Version no.: 01 Supersedes: (-)
Personal Protection:
Eye & face protection devices such as safety glasses, safety goggles or face shield are recommended.
Skin protection
Wear the appropriate protective clothing, including boots, gloves, lab coat, apron or coveralls, as
appropriate, to prevent skin contact.
Respiratory protection:
Use only in an adequately ventilated area. For unknown vapor concentrations use a positive-pressure,
pressure-demand, self-contained breathing apparatus (SCBA).
Hazardous Ingredient CAS
Number
Aliphatic Petroleum
Distillates
Petroleum Asphalt
Aliphatic Hydrocarbon
*Values are based on the 2014 Guide to Occupational Exposure Values by ACGIH
9. Information on Basic Physical and Chemical Properties
Appearance: Black Liquid Odor: Hydrocarbon
Odor Threshold: N/AV pH: Not Applicable (solvent Base)
Melting Point: N/AV Freezing Point: N/AV
Initial Boiling Point: N/AV Boiling Point Range: N/AV
Flash Point: 34ºC Evaporation Rate: Slower Than n-Butyl
Flammability Solid/Gas: flammable liquid LEL: 0.7% UEL: 9.5%
Vapor Pressure: N/AV Vapor Density: Heavier Than Air
Relative Density: N/AV Solubility: Negligible
Partition Coefficient:
n-octanol/ water: N/AV
Decomposition Temperature: N/AV Viscosity: N/AV
Explosive Properties: N/AV Oxidizing Properties: N/AV
10. Stability & Reactivity
Possibility of hazardous reactions: Hazardous polymerization will not occur under normal conditions
Chemical stability: Stable under normal conditions
Conditions to avoid: Heat and ignition sources
Incompatible materials: Strong Oxidizing Agents
Hazardous decomposition products: Will not occur
11. Toxicological Information
64742-89-8
8052-42-4
8052-41-3
ACGIH TLV
(TWA)
N/AV N/AV N/AV N/AV
N/AV N/AV N/AV N/AV
100ppm N/AV 500ppm N/AV
Acetate
Auto-ignition Temperature: N/AV
ACGIH TLV
(STEL)
OSHA
PEL
(TWA)
OSHA PEL
(STEL)
Page 6
Safety Data Sheet (SDS)
Date Prepared/Revised: 11/15/17 Version no.: 01 Supersedes: (-)
Reports have associated repeated and prolonged overexposure to solvents with permanent brain and
nervous system damage. Repeated overexposure can also damage kidneys, lungs, liver, heart and blood
Routes of exposure: Eyes, skin, ingestion, and/or inhalation
Acute toxicological data: N/AV
Eye irritation data: N/AV
Skin irritation/sensitization/absorption data: N/AV
Reproductive toxicity data: N/AV
Mutagenicity data: Muta 1B
Symptoms associated with physical contact: N/AV
Acute/chronic effects from short/long
term exposure: Irritating to skin. Prolonged/repeated contact may
cause defatting of the skin which can lead to
dermatitis. Not expected to be a skin sensitizer.
Known reportable carcinogens via the
following agencies:
NTP: N/AV
IARC: N/AV
OSHA: N/AV
*
Petroleum distillates may contain chemical carcinogens in limited quantities (< 0.01%). These quantities are determined by
the supplier/fraction/purity of the distillate during the manufacturing process. Chemicals that may be present within distillates
are listed on California’s prop 65 list such as ETHYLBENZENE, BENZENE, and TOLUENE.
12. Ecological Information
Ecotoxicity: No Data Available
Persistence and degradability: No Data Available
Bioaccumulative potential: No Data Available
Mobility in soil: No Data Available
Results of PBT and vPvB assessment: No Data Available
Other adverse effects: No Data Available
13. Disposal Considerations
Page 7
Safety Data Sheet (SDS)
Date Prepared/Revised: 11/15/17 Version no.: 01 Supersedes: (-)
Waste Disposal: Dispose of material in accordance with EU, national and local requirements.
For proper disposal of used material, an assessment must be completed to determine the proper
and permissible waste management options permitted under applicable rules, regulations and/or
laws governing your location.
Product / Packaging disposal: Dispose of packaging in accordance with federal, state and local
requirements, regulations and/or laws governing your location.
14. Transportation Information
US DOT
UN
Number
UN1993
Proper Shipping Name Hazard
Class
Flammable Liquid
3
n.o.s. (VM&P Naphtha,
Packing
Group
PGIII
Marine
Pollutant
Not
Applicable
Special
Provisions
Reference 49
CFR 172.101
Aliphatic Petroleum
Distillates)
IMDG
UN
Number
UN1993
Proper Shipping Name Hazard
Class
Flammable Liquid
3
n.o.s. (VM&P Naphtha,
Aliphatic Petroleum
Packing
Group
PGIII
Marine
Pollutant
Not
Applicable
Special
Provisions
Reference
IMDG code
part 3
Distillates)
IATA:
UN
Number
UN1993
Proper Shipping Name Hazard
Class
Flammable Liquid
3
n.o.s. (VM&P Naphtha,
Aliphatic Petroleum
Distillates)
Packing
Group
PGIII
Marine
Pollutant
Not
Applicable
Special
Provisions
Reference
IATA
Dangerous
Goods
Regulation
15. Regulatory Information
Workplace classification:
This product is considered hazardous under the OSHA Hazard Communication Standard (29 CFR
1910.1200). The Occupational Safety and Health Administration's interpretation of the product's hazard
to workers.
SARA Title 3:
Section 311/312 Categorizations (40 CFR 372): This product is a hazardous chemical under 29 CFR
1910.1200, and is categorized as an immediate and delayed health, and flammability physical hazard.
Superfund Amendment and Reauthorization Act (SARA) category. SARA requires reporting any spill of
any hazardous substance.
Page 8
Safety Data Sheet (SDS)
Date Prepared/Revised: 11/15/17 Version no.: 01 Supersedes: (-)
TSCA status: All chemicals in this product are listed, or are exempt from listing, on the TSCA
Inventory.
WHMIS: This product has been classified in accordance with the hazard criteria of the Controlled
Products Regulations (CPR) and the (M)SDS contains all of the information required by the CPR.
PROP 65 (CA): WARNING: This product can expose you to chemicals including carbon black, which
is known to the state of California to cause cancer. For more information go to www.P65Warnings.gov.
16. Other Information
This SDS has been completed in accordance with GHS Rev04 (2011): U.S OSHA, CMA, ANSI,
Canadian WHMIS standards, and European Directives.
Date of Preparation/Revision: 11/15/17
Supersedes: -
To the best of our knowledge, the information contained herein is believed to be accurate. However, the
above data does not imply any guarantee or warranty of any kind, expressed or implied. The final
determination of the suitability of any material is the sole responsibility of the user. All materials made
present un-known hazards and should be used with caution. Although certain hazards are described
herein, we cannot guarantee these are the only hazards existing.
Loading...