Datasheet RS2640B Datasheet

ALIGNMENT

SPECIFICATION FOR

RS2640

Copyrighted Thomson Inc.

Page: 1 of 10

Rev Date Revision Text Changed By

0 Jan-02-2002 First issue.

1 Oct-07-2003

Change adjust MW Osc coil (TF003) to obtain 1.51

1.

Ye Lun

±0.01V at TP 002 to adjust LW OSC coil( TF004)

to ……..

2. Add EA version

PAGE: 2 of 10

TABLE OF CONTENTS

TUNER BOARD ALIGNMENT

1 FM IF ALIGNMENT 4

2 FM OSCILLATOR AND RF ALIGNMENT 5

3 FM STEREO ALIGNMENT 6

4 AM OSC ALIGNMENT 7

5 AM IF AND AFC ALIGNMENT 8

6 AM RF ALIGNMENT 9

MAIN BOARD TAPE ALIGNMENT (SEMI- ENCASING)

1 Azimuth Alignment 10
2 Tape Speed Adjustment 10

PAGE: 3 of 10

TUNER BOARD ALIGNMENT

1 FM IF ALIGNMENT

1. Testing conditions (remove the probe of counter during “S” curve align.)

INPUT TP 001 TP001G (RFGND)

OUTPUT TP 003 TP 009G (AGND)

1. Send a FM IF signal through a 1nF capacitor series with a 10K resistor to TP004 (Pin 39 of U1).

2. Detect the IF signal output at TP009 (Pin 10 of U1) through a 4.7 uF capacitor.

3. Align TF006 to obtain a clear display on the oscilloscope without any interference.

4. Ensure that the curve is not saturated.

5. Tune the set to 98.10 MHz

6. Apply an un-modulated mono RF signal at 98.10 MHz with RF input level of 1 mV.

7. Connect a frequency counter to TP003 (Pin 33 of IC001) thru a capacitor 0.1 uF

8. Check TP003 and align TF006 to get US model (10.7 MHz ± 10 KHz). EU/EA model (10.7MHz

±5kHz)

9 Feed a signal 38 dBf, 98.10 MHz (through matching balanced pad) from the signal generator to the

antenna input of the set under test.

PAGE: 4 of 10

TUNER

G

K

10.80

TP-004

TP-004G

TP-009

TP-009

1 nF 10

4.7uF

IN

FIGURE 1

2 FM OSCILLATOR AND RF ALIGNMENT

1. Testing Conditions:

INPUT TP 001 TP001G (RFGND)
OUTPUT TP 007/ TP008 TP009G (AGND)
TUNING VOLTAGE VT TP 002 TP009G (AGND)

1. Set frequency to 87.5 MHz.
Adjust FM Osc coil (L004) to obtain 1.0 ~ 1.05 V at TP 002

10.70

10.60

OUT

FIGURE 2

2. Set frequency to 108.10 MHz.
Adjust Vari-Cap (CV002) to obtain 7.0 ±0.5 at TP002.

3. Repeat the above procedure until the band coverage is fall within the specified VT voltage.

4. Feed a FM RF signal to a matching balanced pad of (50 ohm - 75 ohm) at TP 001 and RFGND.

5. Detect signal from TP 007/008 through the following circuit (Fig 3).

6. Set frequency to 90.10 MHz and adjust L003 until maximum amplitude is reached.

7. Set frequency to 106.10 MHz to see whether approximate amplitude is acquired.

8. Check the amplitude of 98.10 MHz for equal sensitivity.

PAGE: 5 of 10

E

G

1.00V

G

z

DC Voltmeter

3 FM STEREO ALIGNMENT

FM Signal Generator

TUNER

TP-009

TP-002

TUNER SECTION

TP-001G

TP-007/008

TP-009

TP-001

GENESCOP

4.7uF

FIGURE 3

IN OUT

TP-010

RV-001

TP-001

TP-001G

TP-006

TP-005

FIGURE 5

Frequency Counter

152.000kHz

98.10MH

1. Testing Conditions: (Remove the VT probe during search)

INPUT TP 001 TP001G (RFGND)
OUTPUT TP 005 TP010G (DGND)

2. Apply an un-modulated mono RF signal at 98.10 MHz with RF input level of 1 mV.

3. Search to 98.10 MHz

PAGE: 6 of 10

4. Connect a frequency counter to TP005 (Pin 24 of IC001), short TP010 (Pin 27 of IC001) to ground
TP010G (Pin 26 of IC001) and across a resistor 10K from TP005 to GND

5. Check TP005 and align RV001 to get 152 KHz ± 1 KHz.

6. After the FM stereo alignment, sent a stereo 98.10 MHz signal to the set. Ensure the Stereo
indicator lights up. The signal strength must not be more than 32 dB.

4 AM OSCILLATOR ALIGNMENT

1. Testing Conditions:

INPUT Ant Loop TP001G (RFGND)
OUTPUT TP 007/ TP008 TP009G (AGND)
TUNING VOLTAGE VT TP 002 TP009G (AGND)

MW

2. Set frequency to 530 KHz (US version) & 522 KHz (EU/EA version)
Adjust MW Osc coil (TF003) to obtain 1.4 ± 0.05V at TP 002 for US version
Adjust MW Osc coil (TF003) to obtain 1.35 ± 0.05V at TP 002 for EU/EA version

LW

3. Set frequency to 1710 KHz (US version) & 1611KHz (EU/EA version)
Ensure the MW-VT at TP002 is 8.0 ± 1 V

4. Set frequency to 150 KHz.
Adjust LW Osc coil (TF004) to obtain 1.51 ±0.01V at TP 002

5 Set frequency to 283 KHz

Ensure the LW-VT at TP002 is 4.6 ± 1V

PAGE: 7 of 10

5 AM IF AND AFC ALIGNMENT

1. Testing Conditions: (remove the VT probe during search)

INPUT Ant Loop TP006
OUTPUT TP011 TP004G (IFGND)

2. Send a AM IF signal to TP012 (pin6 of IC001)

3. Detect the signal out at TP009 as below figure 6

4. Adjust TF005 & TF008 until maximal amplitude reached

5. Send an un-modulated RF signal at 1000 KHz (EU version: 999KHz) with RF level of 100mV.

6. Search up/down the receiver. It will stop after acquiring this signal.

7. Connect a frequency counter to TP011 (Pin 36 of IC001) thru a capacitor 1uF

8. Check TP011 and align TF007 to get 450 KHz ± 1 KHz.

PAGE: 8 of 10

TUNER

445

TP-012

TP-004G

TP-009

TP-009G

1uF

4.7uF

FIGURE 6

6 AM RF ALIGNMENT

1. Testing Conditions:

INPUT Ant Loop
OUTPUT TP 007/ TP008 TP009G (AGND)

IN

450

OUT

MW

1. Send a modulated (400 Hz) MW RF signal at 630 KHz with low RF level of 300 uV.

2. Detect signal from TP 007/008 and adjust TF001 until maximum amplitude is reached.

LW

7. Send a modulated (400 Hz) MW RF signal at 170 KHz with low RF level of 300 uV.

3. Detect signal from TP 007/008 and adjust TF002 until maximum amplitude is reached.

PAGE: 9 of 10

MAIN BOARD TAPE ALIGNMENT (SEMI-ENCASING)

Alignment for the cassette portion should be done at the semi - encased stage.

1 AZIMUTH ALIGNMENT

1. In tape transport 1, playback a test tape (TCC-153) of freq. 10 KHz

2. Connect the output to an oscilloscope and a voltmeter.

3. Adjust the azimuth screw at tape head to obtain maximum amplitude on both channels. (Both
channels must be in phase).

4. Repeat the above procedure with tape transport 2.

2 TAPE SPEED ADJUSTMENT

1. Rewind test tape (MTT-111 DN 3khz) until both the left and right hubs are of equal spool.

2. Connect the output to the WOW -FLUTTER METER.

3.

Adjust the trimmer in motor to obtain playback freq. of 3KHz ± 60 Hz if necessary

PAGE: 10 of 10

4. Stop transport 1 and playback the same test tape on transport 2.

5. Check the output and result must be the same as transport 1, if not, repeat the item 3

3 RECORD BIAS OSCILLATOR ALIGNMENT

1. Place a tape inside the set. Ensure that the tape is not record protected.

2. Select Tape mode and engage the Record button.

3. Monitor TP60 and TP60G (as ground). Ensure that the scope/meter does not have an activated low
pass filter. Adjust L302 & L303 to obtain the voltage of 12Vrms±5% (9v ±1Vrms for A3080 and
frequency should be 58kHz ± 5%).

PAGE: 11 of 10

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

00002 255412 CD PLATTER, 5-DISC CD MECH RS2640B 55066450
00003 248366 CD BASE PLASTIC CD MECH RS2640B 20980000
0001 265140 PULLEY CD MECH RS2640B 20987470
0002 265139 PULLEY CD MECH RS2640B 20987480
0003 265137 WORM GEAR CD MECH RS2640B 20987490
00052 N/S/P AC ASSEMBLY CDM5B DRAWER CD MECH RS2640B 20987460
0020 248152 DRAWER CD PLASTIC CDM5B CD MECH RS2640B 20979990
0025 238383 ROLLER, RUBBER BLACK 4X10 MM CD MECH RS2640B 20712120
0030 262534 HUB, ROLLER CD MECH RS2640B 20712170
0035 255882 BRACKET, SPIN MOTOR CD MECH RS2640B 20979860
0040 267098 CABINET FRONT INSTRUMENT ASSEMBLY RS2640B 55274220
0040 238376 MOTOR CD CAROUSEL CD MECH RS2640B 20581820
0045 248153 PULLEY MOTOR CD MECH RS2640B 20979870
0050 N/S/P SCREW 2MM 3MM JIS B 1111 53 0 0 CD MECH RS2640B 20349510
0050 267143 AC MLD CABINET BOTTOM RS2640B INSTRUMENT ASSEMBLY RS2640B 55938640
0055 251504 PLASTIC BUSHING CD MECH RS2640B 20979960
0060 248154 PULLEY WORM CD MECH RS2640B 20979880
0060 261259 CABINET LEFT INSTRUMENT ASSEMBLY RS2640B 55668460
0065 248155 WORM PLASTIC CD MECH RS2640B 20979890
0068 253163 SHAFT, WORM CD MECH RS2640B 20979900
0070 261260 CABINET RIGHT INSTRUMENT ASSEMBLY RS2640B 55668470
0073 248156 GEAR DUAL WORM CD MECH RS2640B 20979780
0080 238377 BELT, PLATTER ID 23MM CD MECH RS2640B 20710160
0080 267142 AC MLD CABINET BACK RS2640B INSTRUMENT ASSEMBLY RS2640B 55938650
0090 261262 CABINET TOP INSTRUMENT ASSEMBLY RS2640B 55668480
0100 257334 HOLDER VFD DISPLAY MAIN CBA RS2640B 55221820
0100 267078 DOOR CASS RS2640 INSTRUMENT ASSEMBLY RS2640B 55378020
0120 261265 DOOR CD INSTRUMENT ASSEMBLY RS2640B 55600830
0130 267079 BUTTON CASS STOP/EJECT INSTRUMENT ASSEMBLY RS2640B 55555620
0135 257760 MOTOR DRAWER CD MECH RS2640B 20581800
0140 N/S/P SCREW 2.6MM 5MM JIS B 1111 53 0 0 CD MECH RS2640B 20349540
0150 267080 BUTTON CASS PLAY RS2640 INSTRUMENT ASSEMBLY RS2640B 55562840
0150 248157 GEAR PULLEY CD MECH RS2640B 20979840
0155 265333 GEAR DUAL CD MECH RS2640B 20979770
0160 248159 GEAR, PIVOT CD MECH RS2640B 20979830
0165 248160 ARM SWING PLASTIC CD MECH RS2640B 20979940
0170 248161 GEAR, IDLER CD MECH RS2640B 20979790
0170 267081 BUTTON CASS RECORD RS2640 INSTRUMENT ASSEMBLY RS2640B 55858220
0175 248162 GEAR, CLUTCH CD MECH RS2640B 20979750
0180 267082 BUTTON CASS REWIND RS2640 INSTRUMENT ASSEMBLY RS2640B 55858240
0180 248163 ROLLER, SLIDING CD MECH RS2640B 20979950
0185 248164 GEAR, DUAL IDLER CD MECH RS2640B 20979760
0190 267083 BUTTON CASS FFWD RS2640 INSTRUMENT ASSEMBLY RS2640B 55858260
0190 248165 GEAR, MAIN CD MECH RS2640B 20979800
0200 267084 BUTTON CASS PAUSE RS2640 INSTRUMENT ASSEMBLY RS2640B 55858280
0200 248166 CAM, SLIDER CD MECH RS2640B 20979740
0208 253164 SPRING, TORSION MAIN CD MECH RS2640B 20979810
0210 265158 BUTTON, VOLUME UP/DOWN INSTRUMENT ASSEMBLY RS2640B 55858310
0210 248371 BRACKET PICK-UP CD MECH RS2640B 20979970
0220 248108 BELT, DRIVE ID 36MM CD MECH RS2640B 55073350
0220 267085 BUTTON 13KEYS+RING FRONT P INSTRUMENT ASSEMBLY RS2640B 55858340
0222 251571 SPRING RETENTION CD MECH RS2640B 20979850
0225 261320 ABSORBER, RUBBER GRAY CD MECH RS2640B 20365070
0230 245154 CUSHION, CD BLUE CD MECH RS2640B 20446740
0230 261276 BUTTON POWER/ON INSTRUMENT ASSEMBLY RS2640B 55536800
0235 248373 ARM PLASTIC MAGNETIC ROTATION CD MECH RS2640B 20979980
0240 261277 BUTTON OPEN/CLOSE/BASE INSTRUMENT ASSEMBLY RS2640B 55536820
0240 257371 HOLDER MAGNET COVER CD MECH RS2640B 55257480
0241 257372 HOLDER MAGNET BASE CD MECH RS2640B 55381040
0250 267086 BUTTON PRESET/EQ RS2640 INSTRUMENT ASSEMBLY RS2640B 55858360
0252 245153 MAGNET CD MECH RS2640B 20495830
0300 267087 BUTTON VOLUME RING RS2640 INSTRUMENT ASSEMBLY RS2640B 55858370
0310 267088 DOOR RING CASS RS2640 INSTRUMENT ASSEMBLY RS2640B 55858380
0320 267089 DOOR CASS ROUND RS2640 INSTRUMENT ASSEMBLY RS2640B 55858860
0320 257285 GEAR BOSS SUPPORT METAL CD MECH RS2640B 55189250
0322 N/S/P WASHER 3.2MM 7MM 0.5MM 3 00 0 A4 CD MECH RS2640B 55218810
0330 267099 COVER CASS ROUND RS2640 INSTRUMENT ASSEMBLY RS2640B 55858410
0373 253167 BRACKET CD MECH RS2640B 20979820
0380 N/S/P SCREW-ST 3MM 10MM JIS B 1122 25 0 0 CD MECH RS2640B 20692310
0385 N/S/P SCREW-ST 3MM 8.0MM JIS B 1122 53 0 0 CD MECH RS2640B 20656110
0390 260304 WASHER METAL CD MECH RS2640B 21014110
0401 248367 PAD NON-METAL FRICTION CD MECH RS2640B 55028010
0410 265151 CRYSTAL WITH RCA LOGO INSTRUMENT ASSEMBLY RS2640B 55841590
0420 253169 RUBBER STOPPER CD MECH RS2640B 21014050
0420 267100 CRYSTAL DISPLAY RS2640 INSTRUMENT ASSEMBLY RS2640B 55858450
0430 265154 CD DOOR INSERT INSTRUMENT ASSEMBLY RS2640B 55858470
0440 267101 CRYSTAL CONTROL PANEL RS2640 INSTRUMENT ASSEMBLY RS2640B 55858490
0460 265141 HOLDER CASS DOOR INSTRUMENT ASSEMBLY RS2640B 55923540
0460 261321 BUFFER 8.0X4.8X2.5 CD MECH RS2640B 55020030
0470 265147 MLD CASSETTE BOARD STANDOFF INSTRUMENT ASSEMBLY RS2640B 55851210

Page 1 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

0480 249224 FOOT RUBBER SQUARE 4.8X11 MM CD MECH RS2640B 55074620
0485 261436 BRACKET PRESS CASS INSTRUMENT ASSEMBLY RS2640B 55535880
0500 253170 SPRING,PRESSURE 4TURNS 10 MM H CD MECH RS2640B 55105210
0510 261293 SPRING CASS INSTRUMENT ASSEMBLY RS2640B 55122110
0530 252829 FOOT RUBBER INSTRUMENT ASSEMBLY RS2640B 55111450
0560 267102 COVER FAN RS2640 INSTRUMENT ASSEMBLY RS2640B 55858970
0600 267103 GEAR DAMPER INSTRUMENT ASSEMBLY RS2640B 5591059A
AMANT 255415 ANTENNA AND HOLDER AM INSTRUMENT ASSEMBLY RS2640B 55115970
C001 157199 CAPCD 22PF J NP0 50V DRIVER BOARD ASY RS2640B 80434590
C001 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560
C002 260952 CAP CC 100NF 10% 25V Y5R DRIVER BOARD ASY RS2640B 20246950
C003 157199 CAPCD 22PF J NP0 50V DRIVER BOARD ASY RS2640B 80434590
C003 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560
C004 260952 CAP CC 100NF 10% 25V Y5R DRIVER BOARD ASY RS2640B 20246950
C004 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560
C005 260634 CAP LYTC 470UF +20% 16.0V 85C DRIVER BOARD ASY RS2640B 20718370
C006 240934 CAPCD .01UF K Y5P 50V DRIVER BOARD ASY RS2640B 70428520
C007 249349 CE 4.7UF 20% 50V 85C MAIN CBA RS2640B 20268870
C008 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940
C010 256817 CAP CC 47PF 50V NPO MAIN CBA RS2640B 20506570
C011 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380
C012 200538 CAPCC 15PF J NPO 50V MAIN CBA RS2640B 20468940
C013 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040
C014 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740
C015 260668 CAP POLY 100NF +10% 50V MAIN CBA RS2640B 20266460
C016 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740
C019 260615 CAPCC 1UF +80% -20% 10V MAIN CBA RS2640B 20811460
C020 253714 CAPCC 470PF 5% 50V MAIN CBA RS2640B 20506680
C021 256814 CAPCC 22PF +5% -5% 50V NPO MAIN CBA RS2640B 20506520
C022 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740
C023 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740
C024 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840
C025 256775 CAP CC .01UF K X7R 50V MAIN CBA RS2640B 10138960
C026 256775 CAP CC .01UF K X7R 50V MAIN CBA RS2640B 10138960
C027 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C028 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380
C029 243464 CAPCC 15PF 5% 50V MAIN CBA RS2640B 20678050
C030 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740
C031 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C032 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840
C033 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840
C034 260924 CAP LYTC 33UF +20% 25V 85C MAIN CBA RS2640B 20247150
C035 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C036 260933 CAPCC 12PF 20% 50V MAIN CBA RS2640B 10137170
C041 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C043 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040
C045 256817 CAP CC 47PF 50V NPO MAIN CBA RS2640B 20506570
C046 253714 CAPCC 470PF 5% 50V MAIN CBA RS2640B 20506680
C047 256817 CAP CC 47PF 50V NPO MAIN CBA RS2640B 20506570
C050 260636 CAP POLY 100NF +10% 50.0V MAIN CBA RS2640B 20936070
C060 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560
C061 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C062 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C099 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C300 249340 CAPCE 100U0F 20% 10V 85C CASSETTE CIRCUIT RS2640B 20268940
C301 260929 CAP POLY 33NF +5% 50V CASSETTE CIRCUIT RS2640B 20266410
C301L 265127 CAP POLY 1800PF +5% 50.0V CASSETTE CIRCUIT RS2640B 20351650
C301R 265127 CAP POLY 1800PF +5% 50.0V CASSETTE CIRCUIT RS2640B 20351650
C302 260927 CAP POLY 6.8NF +10% 50V CASSETTE CIRCUIT RS2640B 20266280
C302L 260668 CAP POLY 100NF +10% 50V CASSETTE CIRCUIT RS2640B 20266460
C302R 260668 CAP POLY 100NF +10% 50V CASSETTE CIRCUIT RS2640B 20266460
C303 260928 CAP POLY 68NF +10% 50V CASSETTE CIRCUIT RS2640B 20266570
C303L 249340 CAPCE 100U0F 20% 10V 85C CASSETTE CIRCUIT RS2640B 20268940
C303R 249340 CAPCE 100U0F 20% 10V 85C CASSETTE CIRCUIT RS2640B 20268940
C304 189981 CAP LYTC 10UF M 50V CASSETTE CIRCUIT RS2640B 20268880
C304L 189981 CAP LYTC 10UF M 50V CASSETTE CIRCUIT RS2640B 20268880
C304R 189981 CAP LYTC 10UF M 50V CASSETTE CIRCUIT RS2640B 20268880
C305 260926 CAP LYTC 22UF +20% 25V 85C CASSETTE CIRCUIT RS2640B 20268890
C305L 262520 CAPCD 220PF K Z5P 50V CASSETTE CIRCUIT RS2640B 70428370
C305R 262520 CAPCD 220PF K Z5P 50V CASSETTE CIRCUIT RS2640B 70428370
C306 249340 CAPCE 100U0F 20% 10V 85C CASSETTE CIRCUIT RS2640B 20268940
C306L 265126 CAP POLY .047UF +5% 50.0V CASSETTE CIRCUIT RS2640B 20266440
C306R 265126 CAP POLY .047UF +5% 50.0V CASSETTE CIRCUIT RS2640B 20266440
C308L 194673 CAP LYTC 1UF M 50V CASSETTE CIRCUIT RS2640B 20268840
C308R 194673 CAP LYTC 1UF M 50V CASSETTE CIRCUIT RS2640B 20268840
C309L 143881 CAPCD 2200PF K Z5P 50V CASSETTE CIRCUIT RS2640B 11055540
C309R 143881 CAPCD 2200PF K Z5P 50V CASSETTE CIRCUIT RS2640B 11055540
C400 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940
C400L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C400R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850

Page 2 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

C401L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C401R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C402 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380
C402L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C402R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C403 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380
C404L 260935 CAPCC 5.6NF 10% 50V XR MAIN CBA RS2640B 10138730
C404R 260935 CAPCC 5.6NF 10% 50V XR MAIN CBA RS2640B 10138730
C407L 262523 CAP CC 150NF 10% 16V MAIN CBA RS2640B 20797500
C407R 262523 CAP CC 150NF 10% 16V MAIN CBA RS2640B 20797500
C408L 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C408R 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C409L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C409R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C410 260930 CAP LYTC 47UF +20% 25V 85C MAIN CBA RS2640B 20268910
C410L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C410R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C411 249352 CAPLYTC 220UF 20% 16V 85C MAIN CBA RS2640B 20252650
C412 237535 CE 22U0F +20% 100V 85C MAIN CBA RS2640B 13074800
C414L 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C414R 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C420 249339 CAPCE 7UF +20% 10V 85C MAIN CBA RS2640B 20268930
C430 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C453L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C453R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
C501L 260938 CAPCC 5PF 10% 50V MAIN CBA RS2640B 20719320
C501R 260938 CAPCC 5PF 10% 50V MAIN CBA RS2640B 20719320
C502 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380
C502L 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840
C502R 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840
C503 260930 CAP LYTC 47UF +20% 25V 85C MAIN CBA RS2640B 20268910
C505L 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C505R 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C507L 253714 CAPCC 470PF 5% 50V MAIN CBA RS2640B 20506680
C507R 253714 CAPCC 470PF 5% 50V MAIN CBA RS2640B 20506680
C509L 260930 CAP LYTC 47UF +20% 25V 85C MAIN CBA RS2640B 20268910
C509R 260930 CAP LYTC 47UF +20% 25V 85C MAIN CBA RS2640B 20268910
C512 267091 CAP 4.7MF +20% 50.0V 85C MAIN CBA RS2640B S 55854010
C513 267091 CAP 4.7MF +20% 50.0V 85C MAIN CBA RS2640B S 55854010
C514 260637 CAP LYTC 2200UF 25.0V 85C MAIN CBA RS2640B 13048060
C515 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890
C516 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890
C518 202011 CAP POLY .1UF J 63V MAIN CBA RS2640B 20780350
C518L 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C518R 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C520 202011 CAP POLY .1UF J 63V MAIN CBA RS2640B 20780350
C521L 267075 CPM 330N0F +5% 50.0V MAIN CBA RS2640B 13087290
C521R 267075 CPM 330N0F +5% 50.0V MAIN CBA RS2640B 13087290
C522L 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C522R 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C523 260952 CAP CC 100NF 10% 25V Y5R MAIN CBA RS2640B 20246950
C524 202011 CAP POLY .1UF J 63V MAIN CBA RS2640B 20780350
C533 202011 CAP POLY .1UF J 63V MAIN CBA RS2640B 20780350
C534 189981 CAP LYTC 10UF M 50V MAIN CBA RS2640B 20268880
C535 189981 CAP LYTC 10UF M 50V MAIN CBA RS2640B 20268880
C537 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890
C538 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890
C539 249823 CAPLYTC 100UF 20% 50V 85C MAIN CBA RS2640B 13074540
C540 249823 CAPLYTC 100UF 20% 50V 85C MAIN CBA RS2640B 13074540
C541 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C542 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380
C600 260670 CAP LYTC 470UF +20% 10V 85C MAIN CBA RS2640B 20252670
C604L 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890
C604R 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890
C605L 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940
C605R 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940
C611L 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840
C611R 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840
C701 249339 CAPCE 7UF +20% 10V 85C MAIN CBA RS2640B 20268930
C702 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940
C704 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040
C705 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040
C705A 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040
C706 260670 CAP LYTC 470UF +20% 10V 85C MAIN CBA RS2640B 20252670
C707 256811 CAPCC .047UF 50V Y5V MAIN CBA RS2640B 20288010
C708 256811 CAPCC .047UF 50V Y5V MAIN CBA RS2640B 20288010
C711 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560
C712 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560
C713 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840
C714 256814 CAPCC 22PF +5% -5% 50V NPO MAIN CBA RS2640B 20506520

Page 3 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

C715 256814 CAPCC 22PF +5% -5% 50V NPO MAIN CBA RS2640B 20506520
C721 256811 CAPCC .047UF 50V Y5V MAIN CBA RS2640B 20288010
C725 256818 CAP CC 100PF 50V NPO MAIN CBA RS2640B 20506590
C726 256818 CAP CC 100PF 50V NPO MAIN CBA RS2640B 20506590
C730 249339 CAPCE 7UF +20% 10V 85C MAIN CBA RS2640B 20268930
C750 256811 CAPCC .047UF 50V Y5V MAIN CBA RS2640B 20288010
C751 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040
C753 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040
C755 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390
C790 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C791 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C792 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C793 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550
C805 249823 CAPLYTC 100UF 20% 50V 85C MAIN CBA RS2640B 13074540
C806 249823 CAPLYTC 100UF 20% 50V 85C MAIN CBA RS2640B 13074540
C807 267090 CAP 100NF +80% -20% 50V Y5V MAIN CBA RS2640B 20267290
C901 194673 CAP LYTC 1UF M 50V CASSETTE CIRCUIT RS2640B 20268840
CD MEC 267112 CD MECHANISM CD MECH RS2640B 55843210
CD MOD 267145 CDM5B CD MECH TCM-135 INSTRUMENT ASSEMBLY RS2640B 55947050
CIR 267144 AC SINGLE TAPE-DECK MODULE INSTRUMENT ASSEMBLY RS2640B 55831110
CV001 260944 CAP TRIM 3PF 11.0F 100 N450 MAIN CBA RS2640B 20969010
CV002 260944 CAP TRIM 3PF 11.0F 100 N450 MAIN CBA RS2640B 20969010
CY03 195922 CAPCC 330PF 10% 50V MAIN CBA RS2640B 10138480
D001 246124 DIODE SVC201SPA MAIN CBA RS2640B 20677870
D001 246515 DIODE ZENER 0.5W Z5V6 DRIVER BOARD ASY RS2640B 20414280
D002 246124 DIODE SVC201SPA MAIN CBA RS2640B 20677870
D002 246343 DIODE ZENER 6.8V 1/2W IN5235B DRIVER BOARD ASY RS2640B 20526990
D003 260293 DIODE SLPVC KV1270NT 16.0V MAIN CBA RS2640B 55235610
D003 257370 DIODE 1N4002 100.0V 1A DRIVER BOARD ASY RS2640B 20415050
D004 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D004 257370 DIODE 1N4002 100.0V 1A DRIVER BOARD ASY RS2640B 20415050
D005 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D401 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D402 248145 DIODE ZENER 7.5V 1/2W BZX55C7V MAIN CBA RS2640B 80444150
D501 248140 DIODE ZENER 5.1V 1/2W 1N5231B MAIN CBA RS2640B 20526960
D502L 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D502R 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D503 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D504 261441 D-ZENER 1N5221B 2.4V 1/2W MAIN CBA RS2640B 20845050
D505 249217 DIODE 1N5402 200.0V 3.0A MAIN CBA RS2640B 55041640
D506 249217 DIODE 1N5402 200.0V 3.0A MAIN CBA RS2640B 55041640
D507 249217 DIODE 1N5402 200.0V 3.0A MAIN CBA RS2640B 55041640
D508 249217 DIODE 1N5402 200.0V 3.0A MAIN CBA RS2640B 55041640
D509 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670
D510 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670
D511 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670
D512 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670
D513 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D515 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D516 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D701 223783 DIODE ZENER 6.2V .5W MAIN CBA RS2640B 20475410
D702 223783 DIODE ZENER 6.2V .5W MAIN CBA RS2640B 20475410
D703 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D704 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D712 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D715 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D716 246244 DIODE LED MAIN CBA RS2640B 20971500
D718 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D721 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D730 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540
D819 248145 DIODE ZENER 7.5V 1/2W BZX55C7V MAIN CBA RS2640B 80444150
D820 257133 DIODE ZENER BZX85C27 27V 1.3W MAIN CBA RS2640B S 20741600
D821 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670
D822 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670
DECK 267111 CASSETTE DECK ASSEMBLY INSTRUMENT ASSEMBLY RS2640B 5584148A
F503 246839 FUSE SB 5A/125V POWER AMP PCB RS2640B S 20828880
F504 246839 FUSE SB 5A/125V POWER AMP PCB RS2640B S 20828880
FAN 262981 FAN POWER AMP PCB RS2640B S 55634450
FH503 252836 HOLDER FUSE MAIN CBA RS2640B 55017140
FH504 252836 HOLDER FUSE MAIN CBA RS2640B 55017140
FMANT NONSTK WIRE JUMPER INSTRUMENT ASSEMBLY RS2640B 55380950
IC001 251852 IC FAN8082 DRIVER BOARD ASY RS2640B S 55116380
IC001 217386 IC LB1641 DRIVER BOARD ASY RS2640B S 20656300
IC001 252771 IC TEA5757H AM/FM REC MAIN CBA RS2640B 20955120
IC002 217386 IC LB1641 DRIVER BOARD ASY RS2640B S 20656300
IC002 251852 IC FAN8082 DRIVER BOARD ASY RS2640B S 55116380
IC300 265124 IC, POWER AMP UTC7312 CASSETTE CIRCUIT RS2640B 55827080
IC401 252772 IC TDA7440D AUDIO MAIN CBA RS2640B 55097860
IC501 261309 IC-POWAMP TDA7293 POWER AMP PCB RS2640B 55512880
IC502 261309 IC-POWAMP TDA7293 POWER AMP PCB RS2640B 55512880

Page 4 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

IC503 251567 IC KIA7812API POWER AMP PCB RS2640B 55094390
IC701 261444 IC - UPD780205AGF-018-38A MAIN CBA RS2640B 55547820
IR701 265123 IC, REMOTE RECEIVER MAIN CBA RS2640B 55488350
J101 NONSTK WIRE JUMPER CASSETTE CIRCUIT RS2640B 55210010
J101 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J102 NONSTK WIRE JUMPER CASSETTE CIRCUIT RS2640B 55210010
J102 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J103 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J104 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J105 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J106 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J107 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J108 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J109 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J110 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J111 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J112 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J113 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J114 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J115 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J116 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J117 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J118 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J119 NONSTK WIRE JUMPER CASSETTE CIRCUIT RS2640B 55210010
J119 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J120 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J121 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J122 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J123 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J124 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J125 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J126 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J127 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J128 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J129 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J130 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
J201 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J202 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J203 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J204 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J205 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J206 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J207 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J208 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J209 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J210 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J211 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J212 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J213 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J214 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J215 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J216 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J217 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J218 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J219 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J220 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J221 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J222 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J224 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J225 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J226 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J227 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J228 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J229 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J230 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J231 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200
J301 NONSTK WIRE JUMPER CASSETTE CIRCUIT RS2640B 20181860
J301 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J302 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J303 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J304 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J305 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J306 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J307 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J308 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J309 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J310 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J311 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J312 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J313 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860

Page 5 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

J314 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J315 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J316 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J317 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J318 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J319 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J320 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J321 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J322 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J323 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J324 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J325 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J326 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J327 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J328 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J329 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J330 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J331 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J332 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
J401 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J402 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J403 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J404 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J405 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J406 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J407 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J408 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J409 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J410 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J411 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J412 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J413 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J414 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J415 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J416 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J417 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J418 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J419 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J420 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J421 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J422 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J423 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J424 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J425 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J426 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J427 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J428 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J429 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J430 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
J501 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J502 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J503 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J504 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J505 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J506 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J507 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J508 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J509 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J510 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J511 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J512 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J513 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J514 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J515 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J516 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J601 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J602 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J603 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J604 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J605 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J606 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J607 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J608 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J609 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870
J610 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J611 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J612 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J613 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J614 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J615 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320

Page 6 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

J616 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J617 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J618 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J619 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J620 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J621 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J622 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J623 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J624 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J625 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J626 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J627 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
J628 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
JA001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20535600
JA002 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20535600
JB001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200
JB002 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200
JB003 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200
JB004 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200
JB006 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200
JC002 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181860
JD001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329290
JE001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20637320
JE002 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870
JE003 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870
JE004 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870
JE005 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870
JE006 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870
JE007 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870
JE008 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870
JE009 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870
JP02 256783 RES CMF 0 OHM 0% 1/16W MAIN CBA RS2640B 10328750
L001 260945 COIL AIR 0.812MM 4.0MM 4.5 R MAIN CBA RS2640B 20289390
L001 261319 COIL LF 39UH 10% 1.5A DRIVER BOARD ASY RS2640B 55326960
L003 262528 COIL AIR MAIN CBA RS2640B 55156120
L004 260947 COIL AIR .85MM 4.5MM 2.5 LEFT MAIN CBA RS2640B 55109060
L007 190729 COIL 47UH MAIN CBA RS2640B 30944670
L301 175411 COIL 220UH CASSETTE CIRCUIT RS2640B 40438480
L302 261449 COIL LF 470UH +5% 7.7 OHM CASSETTE CIRCUIT RS2640B 13080530
L303 261449 COIL LF 470UH +5% 7.7 OHM CASSETTE CIRCUIT RS2640B 13080530
L501L 250600 COIL AIR 1MM 10MM 7 TURNS MAIN CBA RS2640B 21070690
L501R 250600 COIL AIR 1MM 10MM 7 TURNS MAIN CBA RS2640B 21070690
L602 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
L602L NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
L602R NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290
L701 160186 COIL 100UH MAIN CBA RS2640B 30944680
N002 249907 CONNECTOR 2.5MM 2 MA MAIN CBA RS2640B S 20366830
N005 248206 CONN 2.0MM 9 MA DRIVER BOARD ASY RS2640B 20368920
N006 255420 CABLE, 3P 220MM DRIVER BOARD ASY RS2640B 20365440
N300 253190 CONNECTOR 4P CASSETTE CIRCUIT RS2640B 55109170
N301 265134 CONNECTORS, 10 PIN CASSETTE CIRCUIT RS2640B 20368810
N302 253190 CONNECTOR 4P CASSETTE CIRCUIT RS2640B 55109170
N501 265218 CONNECTOR, 2-PIN MAIN CBA RS2640B 55078300
N516 248203 CONN 2.5MM 3P MAIN CBA RS2640B 20368290
N601 265131 CONNECTOR, 4 PIN MAIN CBA RS2640B 20368280
N701 267093 CONNECTOR 6PIN MAIN CBA RS2640B 20368740
N702 267094 CONNECTOR 2.5MM 9PIN MAIN CBA RS2640B 20368840
N801B 265130 CONNECTOR, 5 PIN MAIN CBA RS2640B 55123640
NJ501 248096 CONNECTOR SPEAKER 4X MAIN CBA RS2640B 20604680
NJ503 248103 3.5MM PHONE JACK MAIN CBA RS2640B 20369030
NJ504 262244 CON PHONO SCKT RCA 2 PINS MAIN CBA RS2640B 5554881A
P-CORD 267071 WIRE BARE 22 POWER AMP PCB RS2640B S 55920140
P001 267141 WCL UL1095 HOOK-UP MAIN CBA RS2640B 55879940
P002 265132 CONNECTOR, 3 PIN DRIVER BOARD ASY RS2640B 20368710
P003 265135 CONNECTOR, 6 PIN DRIVER BOARD ASY RS2640B 20683150
P004 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20818500
P005 250634 CABLE ASY 9P 220MM DRIVER BOARD ASY RS2640B S 55024510
P006 265132 CONNECTOR, 3 PIN DRIVER BOARD ASY RS2640B 20368710
P007 249907 CONNECTOR 2.5MM 2 MA DRIVER BOARD ASY RS2640B S 20366830
P008 265128 CONNECTOR, 8 PIN DRIVER BOARD ASY RS2640B 20368720
P009 265129 CONNECTOR, 7 PIN DRIVER BOARD ASY RS2640B 20366610
P026 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20818500
P027 252838 CABLE 6 PIN DRIVER BOARD ASY RS2640B 55089690
P101 257276 CABLE 2P 360MM MAIN CBA RS2640B 20364270
P300 267113 RIBBON CABLE CASSETTE CIRCUIT RS2640B 55843050
P301 267095 CABLE 10 PIN 250MM MAIN CBA RS2640B 20685000
P302 267114 RIBBON CABLE CASSETTE CIRCUIT RS2640B 55843040
P401 257347 CABLE 3P 350MM MAIN CBA RS2640B 55092650
P516 257204 CABLE 3P 280MM MAIN CBA RS2640B 20368990
P601 262529 CABLE 4P 100MM MAIN CBA RS2640B 20365490

Page 7 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

P701 267096 CABLE 6 PIN 220MM MAIN CBA RS2640B 20862510
P702 267092 CABLE RIBBON MAIN CBA RS2640B S 55009710
P705 257341 CABLE 7P 200MM MAIN CBA RS2640B 20939490
P706 257342 CABLE 8P 200MM MAIN CBA RS2640B 55075100
PI001 250652 DIODE-PHOTO RPI-576 DRIVER BOARD ASY RS2640B 55098050
PI002 250652 DIODE-PHOTO RPI-576 DRIVER BOARD ASY RS2640B 55098050
PI003 238359 DIODE PHOTO RPI-574 DRIVER BOARD ASY RS2640B 20586840
PI004 251851 DIODE TYPE ITR2002 DRIVER BOARD ASY RS2640B 5508631A
PI005 250652 DIODE-PHOTO RPI-576 DRIVER BOARD ASY RS2640B 55098050
PI006 250652 DIODE-PHOTO RPI-576 DRIVER BOARD ASY RS2640B 55098050
Q301 253887 TRANSISTOR KTC3203Y CASSETTE CIRCUIT RS2640B 20538220
Q302 250627 TRANSISTOR KTA1271Y CASSETTE CIRCUIT RS2640B 20685080
Q303 248202 TRANSISTOR 2SC1815Y CASSETTE CIRCUIT RS2640B 20508030
Q401 253887 TRANSISTOR KTC3203Y MAIN CBA RS2640B 20538220
Q410 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q410L 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q410R 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q501 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q502 250627 TRANSISTOR KTA1271Y MAIN CBA RS2640B 20685080
Q503 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q602L 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q602R 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q603L 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q603R 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q701 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q702 253887 TRANSISTOR KTC3203Y MAIN CBA RS2640B 20538220
Q703 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q704 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
Q705 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850
R001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20535600
R002 210245 RES CF 1/4W 5% 100R DRIVER BOARD ASY RS2640B 50882950
R003 248167 RES CFF 2.2R 5% 1/4W DRIVER BOARD ASY RS2640B S 20549430
R004 248167 RES CFF 2.2R 5% 1/4W DRIVER BOARD ASY RS2640B S 20549430
R005 260685 RES CMF 56R +5% 1/16W MAIN CBA RS2640B 10134680
R005 210245 RES CF 1/4W 5% 100R DRIVER BOARD ASY RS2640B 50882950
R006 253139 RES CF 150R 5% 1/4W DRIVER BOARD ASY RS2640B 50882960
R006 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220
R007 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220
R007 179297 RES CF 1/2W 5% 68R DRIVER BOARD ASY RS2640B 20469670
R008 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220
R009 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220
R010 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860
R011 256752 RES CMF 75K OHM 5% 1/16W MAIN CBA RS2640B 10135310
R013 256757 RES CMF 220K OHM 5% 1/16W MAIN CBA RS2640B 10135420
R014 256757 RES CMF 220K OHM 5% 1/16W MAIN CBA RS2640B 10135420
R015 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860
R017 256768 RES CMF 8.2K OHM 5% 1/16W MAIN CBA RS2640B 10136000
R021 256768 RES CMF 8.2K OHM 5% 1/16W MAIN CBA RS2640B 10136000
R030 256730 RES CMF 100 OHM 5% 1/16W MAIN CBA RS2640B 10134740
R031 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R034 256725 RES CMF 22 OHM +5% 1/16W MAIN CBA RS2640B 10134540
R035 256744 RES CMF 18K OHM 5% 1/16W MAIN CBA RS2640B 10135080
R036 256756 RES CMF 150K OHM 5% 1/16W MAIN CBA RS2640B 10135380
R045 256737 RES CMF 470 OHM 5% 1/16W MAIN CBA RS2640B 10134910
R046 256737 RES CMF 470 OHM 5% 1/16W MAIN CBA RS2640B 10134910
R047 256737 RES CMF 470 OHM 5% 1/16W MAIN CBA RS2640B 10134910
R097 256730 RES CMF 100 OHM 5% 1/16W MAIN CBA RS2640B 10134740
R300 175324 RES CF 1/4W 5% 220R CASSETTE CIRCUIT RS2640B 20469450
R301 176801 RES CF 1/4W 5% 56K CASSETTE CIRCUIT RS2640B 11059710
R301L 240936 RES CF 1/4W 5% 12K CASSETTE CIRCUIT RS2640B 90571120
R301R 240936 RES CF 1/4W 5% 12K CASSETTE CIRCUIT RS2640B 90571120
R302 175322 RES CF 1/4W 5% 47K CASSETTE CIRCUIT RS2640B 40435670
R302L 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480
R302R 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480
R303L 265122 RES CF 7.5 OHMS 1/4 WATT CASSETTE CIRCUIT RS2640B 55223890
R303R 265122 RES CF 7.5 OHMS 1/4 WATT CASSETTE CIRCUIT RS2640B 55223890
R304 175361 RES CF 1/4W 5% 120R CASSETTE CIRCUIT RS2640B 11059600
R304L 175308 RES CF 1/4W 5% 1.2K CASSETTE CIRCUIT RS2640B 80437000
R304R 175308 RES CF 1/4W 5% 1.2K CASSETTE CIRCUIT RS2640B 80437000
R305 175054 RES CF 1/4W 5% 22K CASSETTE CIRCUIT RS2640B 60441580
R305L 175314 RES CF 1/4W 5% 33K CASSETTE CIRCUIT RS2640B 30939490
R305R 175314 RES CF 1/4W 5% 33K CASSETTE CIRCUIT RS2640B 30939490
R306 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480
R306L 202069 RES CF 1/4W 5% 1K CASSETTE CIRCUIT RS2640B 11059640
R306R 202069 RES CF 1/4W 5% 1K CASSETTE CIRCUIT RS2640B 11059640
R307 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480
R307L 239019 RES CF 1/4W 5% 220K CASSETTE CIRCUIT RS2640B 30939530
R307R 239019 RES CF 1/4W 5% 220K CASSETTE CIRCUIT RS2640B 30939530
R308 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480
R309 175324 RES CF 1/4W 5% 220R CASSETTE CIRCUIT RS2640B 20469450

Page 8 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

R310 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480
R315L 175047 RCF 5K6 OHM +5% 250MI0W CASSETTE CIRCUIT RS2640B 70430560
R315R 175047 RCF 5K6 OHM +5% 250MI0W CASSETTE CIRCUIT RS2640B 70430560
R316L 175047 RCF 5K6 OHM +5% 250MI0W CASSETTE CIRCUIT RS2640B 70430560
R316R 175047 RCF 5K6 OHM +5% 250MI0W CASSETTE CIRCUIT RS2640B 70430560
R401 175769 RES CF 1/2W 5% 390R MAIN CBA RS2640B 70430860
R401L 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R401R 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R402L 256765 RES CMF 5.6K OHM 5% 1/16W MAIN CBA RS2640B 10135960
R402R 256765 RES CMF 5.6K OHM 5% 1/16W MAIN CBA RS2640B 10135960
R403L 256765 RES CMF 5.6K OHM 5% 1/16W MAIN CBA RS2640B 10135960
R403R 256765 RES CMF 5.6K OHM 5% 1/16W MAIN CBA RS2640B 10135960
R407 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R408 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R410 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220
R410L 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940
R410R 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940
R411 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R412 175317 RES CF 1/4W 5% 10K MAIN CBA RS2640B 30939480
R413L 244090 RES CMF 7.5K 5% 1/10W MAIN CBA RS2640B 10135990
R413R 244090 RES CMF 7.5K 5% 1/10W MAIN CBA RS2640B 10135990
R414L 256764 RES CMF 3.3K OHM 5% 1/16W MAIN CBA RS2640B 10135900
R414R 256764 RES CMF 3.3K OHM 5% 1/16W MAIN CBA RS2640B 10135900
R420 260685 RES CMF 56R +5% 1/16W MAIN CBA RS2640B 10134680
R501L 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170
R501R 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170
R502 256737 RES CMF 470 OHM 5% 1/16W MAIN CBA RS2640B 10134910
R502L 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170
R502R 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170
R503 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R503L 243486 RES CMF 390 OHMS 5% 1/10W MAIN CBA RS2640B 10134890
R503R 243486 RES CMF 390 OHMS 5% 1/10W MAIN CBA RS2640B 10134890
R504 202069 RES CF 1/4W 5% 1K MAIN CBA RS2640B 11059640
R505 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R506L 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R506R 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R507L 256754 RES CMF 100K OHM 5% 1/16W MAIN CBA RS2640B 10135340
R507R 256754 RES CMF 100K OHM 5% 1/16W MAIN CBA RS2640B 10135340
R509 220568 RES CF 1/4W 5% 10R MAIN CBA RS2640B 30939360
R510 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R510L 220568 RES CF 1/4W 5% 10R MAIN CBA RS2640B 30939360
R510R 220568 RES CF 1/4W 5% 10R MAIN CBA RS2640B 30939360
R511 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R512 256767 RES CMF 6.8K OHM 5% 1/16W MAIN CBA RS2640B 10135980
R512L 261306 RES CMF 4.7 OHM +5% 1/16W MAIN CBA RS2640B 20538660
R512R 261306 RES CMF 4.7 OHM +5% 1/16W MAIN CBA RS2640B 20538660
R525 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170
R527 256783 RES CMF 0 OHM 0% 1/16W MAIN CBA RS2640B 10328750
R529 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R530 267073 RESISTOR MAIN CBA RS2640B 90571460
R531 267073 RESISTOR MAIN CBA RS2640B 90571460
R532 256759 RES CMF 1.5K 5% 1/10W MAIN CBA RS2640B 10135820
R600 175040 RES CF 1/4W 5% 47R MAIN CBA RS2640B 70430510
R610L 262525 RES CMF 680K 5% 1/6W MAIN CBA RS2640B 10135570
R610R 262525 RES CMF 680K 5% 1/6W MAIN CBA RS2640B 10135570
R611L 256760 RES CMF 2K OHM 5% 1/16W MAIN CBA RS2640B 10135850
R611R 256760 RES CMF 2K OHM 5% 1/16W MAIN CBA RS2640B 10135850
R612L 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R612R 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R613L 256942 RES CMF 220 OHM 5% 1/16W MAIN CBA RS2640B 10134830
R613R 256942 RES CMF 220 OHM 5% 1/16W MAIN CBA RS2640B 10134830
R615L 249039 RES CMF 1.8K 5% 1/10W MAIN CBA RS2640B 10135840
R615R 249039 RES CMF 1.8K 5% 1/10W MAIN CBA RS2640B 10135840
R616L 176646 RES CF 1/4W 5% 180R MAIN CBA RS2640B 60441540
R616R 176646 RES CF 1/4W 5% 180R MAIN CBA RS2640B 60441540
R617L 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860
R617R 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860
R700 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R701 175312 RES CF 1/4W 5% 680R MAIN CBA RS2640B 11059630
R702 256730 RES CMF 100 OHM 5% 1/16W MAIN CBA RS2640B 10134740
R703 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R704 256730 RES CMF 100 OHM 5% 1/16W MAIN CBA RS2640B 10134740
R705 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940
R706 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940
R707 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R708 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R709 256742 RES CMF 12K OHM 5% 1/16W MAIN CBA RS2640B 10135030
R710 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220
R712 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R714 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010

Page 9 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

R716 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R717 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R718 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R725 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940
R726 256760 RES CMF 2K OHM 5% 1/16W MAIN CBA RS2640B 10135850
R728 256762 RES CMF 2.7K OHM 5% 1/16W MAIN CBA RS2640B 10135880
R729 256759 RES CMF 1.5K 5% 1/10W MAIN CBA RS2640B 10135820
R734 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R735 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R736 256764 RES CMF 3.3K OHM 5% 1/16W MAIN CBA RS2640B 10135900
R737 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940
R739 256751 RES CMF 68K OHM 5% 1/16W MAIN CBA RS2640B 10135290
R740 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860
R741 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R742 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860
R743 256764 RES CMF 3.3K OHM 5% 1/16W MAIN CBA RS2640B 10135900
R744 244090 RES CMF 7.5K 5% 1/10W MAIN CBA RS2640B 10135990
R745 256753 RES CMF 82K OHM 5% 1/16W MAIN CBA RS2640B 10135320
R746 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R747 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R748 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R749 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R750 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R751 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R752 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R753 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R754 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R755 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R756 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R757 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R759 249041 RES CMF 1.2K 5% 1/10W MAIN CBA RS2640B 10135790
R760 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R761 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R762 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R763 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220
R764 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R765 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220
R766 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R767 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R768 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R769 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R770 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R771 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120
R780 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220
R783 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940
R784 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940
R786 256735 RES CMF 330 OHM 5% 1/16W MAIN CBA RS2640B 10134870
R788 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770
R790 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R791 256760 RES CMF 2K OHM 5% 1/16W MAIN CBA RS2640B 10135850
R792 256768 RES CMF 8.2K OHM 5% 1/16W MAIN CBA RS2640B 10136000
R793 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940
R794 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R795 249041 RES CMF 1.2K 5% 1/10W MAIN CBA RS2640B 10135790
R796 256759 RES CMF 1.5K 5% 1/10W MAIN CBA RS2640B 10135820
R797 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R798 249041 RES CMF 1.2K 5% 1/10W MAIN CBA RS2640B 10135790
R799 256759 RES CMF 1.5K 5% 1/10W MAIN CBA RS2640B 10135820
R805 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
R881 256435 RES CF 3.3M 10% 1/2W MAIN CBA RS2640B S 55180100
R885 175317 RES CF 1/4W 5% 10K MAIN CBA RS2640B 30939480
R886 176651 RES CF 1/2W 5% 220R MAIN CBA RS2640B 50883190
R888 186819 RESISTOR 1R 5% 1/4W MAIN CBA RS2640B 11067570
R889 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010
REMO 267108 REM301-RS2640 REMOTE INSTRUMENT ASSEMBLY RS2640B 55237400
RF505 262527 RES FUSE 1W MAIN CBA RS2640B S 55780020
RV001 257759 RES VAR 47K0 OHM +25% MAIN CBA RS2640B 55276190
SPK 267109 MAIN SPEAKER BOX ASSEMBLY INSTRUMENT ASSEMBLY RS2640B 55857990
SW1 265121 SWITCH, ON/OFF CASSETTE CIRCUIT RS2640B S 55830210
SW701 245481 SWITCH MAIN CBA RS2640B 20404730
SW702 245481 SWITCH MAIN CBA RS2640B 20404730
SW703 245481 SWITCH MAIN CBA RS2640B 20404730
SW704 245481 SWITCH MAIN CBA RS2640B 20404730
SW705 245481 SWITCH MAIN CBA RS2640B 20404730
SW706 245481 SWITCH MAIN CBA RS2640B 20404730
SW707 245481 SWITCH MAIN CBA RS2640B 20404730
SW708 245481 SWITCH MAIN CBA RS2640B 20404730
SW709 245481 SWITCH MAIN CBA RS2640B 20404730
SW710 245481 SWITCH MAIN CBA RS2640B 20404730
SW711 245481 SWITCH MAIN CBA RS2640B 20404730

Page 10 of 11

RS2640B

Symbol Stock Description Circuit Model TypeCode Drawing Notes

SW712 245481 SWITCH MAIN CBA RS2640B 20404730
SW713 245481 SWITCH MAIN CBA RS2640B 20404730
SW714 245481 SWITCH MAIN CBA RS2640B 20404730
SW715 245481 SWITCH MAIN CBA RS2640B 20404730
SW716 245481 SWITCH MAIN CBA RS2640B 20404730
SW717 245481 SWITCH MAIN CBA RS2640B 20404730
SW718 245481 SWITCH MAIN CBA RS2640B 20404730
T001 267072 TF POWER-TRANSFORMER 120V POWER AMP PCB RS2640B S 5551308A
TF001 255404 COIL, ADJUSTABLE MAIN CBA RS2640B 55103950
TF003 255405 COIL, ADJUSTABLE MAIN CBA RS2640B 55103970
TF005 260949 COIL ADJUSTABLE MAIN CBA RS2640B 55624150
TF006 255407 COIL, ADJUSTABLE MAIN CBA RS2640B 55103940
TF007 260950 COIL ADJUSTABLE MAIN CBA RS2640B 55624250
TF008 260950 COIL ADJUSTABLE MAIN CBA RS2640B 55624250
X001 252832 CRYSTAL 75KHZ MAIN CBA RS2640B 55106010
X002 NONSTK WIRE JUMPER MAIN CBA RS2640B 55079290
X401 NONSTK WIRE JUMPER MAIN CBA RS2640B 55079290
X701 260923 DISPLAY MAIN CBA RS2640B 55551110
X885 267140 WCL UL1007 HOOK-UP MAIN CBA RS2640B 20925510
Y001 245476 FILTER 10.7MHZ MAIN CBA RS2640B 20906450
Y002 245476 FILTER 10.7MHZ MAIN CBA RS2640B 20906450
Y701 231718 RESONATOR 4.194MHZ MAIN CBA RS2640B 20496690
Y702 251563 FILTER 32.768KHZ MAIN CBA RS2640B 55093470

Page 11 of 11

Instrument Exploded View

Copyrighted Thomson Inc.

CD Mechanism Exploded View

Copyrighted Thomson Inc.

Interconnect Diagram

Copyrighted Thomson Inc.

P026

++

1

P027

2

--

123456

123456

N027

P006

123

1

12

123

P024

N006

N705

N706

CDM5B DRIVER BOARD

1

2

2

3

3

4

4

P705

5

5

6

6

7

7

1

1

2

2

3

3

4

4

5

5

P706

6

6

7

7

8

8

9

9

KEY BOARD

P701

123456

123456789

P702

AUX_IN JACK

123

P516

M

N302

1234

N300

1234

CASSETTE BD

12345678910

N301

X'MER BOARD

N801B

12345

N801A

123

HEADPHONE
BOARD

123456

N701

123456789

N702

123

MAIN & POWER AMP BORAD

NJ501

1234

MAIN

+

­R

+

-

L

N516

AM ANT JACK

N001

1

12345678910

2

AM_ANT

P301

Display/Front Panel Schematic

Copyrighted Thomson Inc.

P701

123456

R725

4K7

1/16W

R700

22k

1/16W

1/16W

1/16W

1/16W

R760

R761

R762

22K

22K

22K

R712

1K

1/16W

R746

1/16W

1K

R747

1/16W

1K

R748

1/16W

1K

R749

1/16W

1K

R750

1/16W

1K

R751

1/16W

1K

R752

1/16W

1K

R753

1/16W

1K

R754

1/16W

1K

R755

1/16W

1K

R756

1/16W

1K

R757

1/16W

1K

123456789

P702

For EU version

C726

C725

100pF100pF

50V50V

R718

1/16W

1K

R717

1/16W

1K

R783

1K

1/16W

R716

1/16W

1K

R788

1K

1/16W

R784

1K

1/16W

8

1

5

2

IC702

3

ST24C01B1

6

7

4

P706

12345678

P705

1234567

SHUFFLEMIX
REPEATALL
1 DISCS
INTRO

MW
FM LW
AM PM

PROG

ST

X701

CD TUNER TAPE

AUX

RDS BASS
ATS SURROUND

MHz

KHz

1 2 3 4 5 6 7 8 9 101112131415161718192021222324252627282930313233343536373839

C707

47nF
50v

KTC3203Y

R701

330
1/4W

Q702

D701

C702

C701

100uF

6V2

47uF

10V

10V

1/2W

R726

2K

1/16W

KTC3875GR

Q705

R708

10K

1/16W

R709

D702

12k

Q703

1/16W

6V2
1/2W

Q704

KTC3198GR

R705

4k7

R706

1/16W

R714

4.7k

1/16W

1/16W

1/16W

R805

10k

10k

1/16W

1/16W

R764

R763

22K

47K

1/16W

1/16W

1/16W

1/16W

1/16W

1/16W

R769

R765

R766

R767

R768

R770

22K

47K

22K

22K

22K

22K

D721

KTC3198GR

1N4148

R707

10K

1/16W

1/16W

R771

22K

D704

L701

1N4148

100uH

D703

1N4148

C704

C705

C706

C705A

470uF

100nF

100nF

10V

50V

50V

1N4148

D730

R703

10k

1/16W

C721A

C721

4u7F

47NF

50V

10V

Q701

KTC3198GR

100nF

50V

C750

1/16
47N

1

2

3

4

5

6

7

8

9

10

11

Y701

4M19HZ

C715

C711

C712

50V

33pF

33pF
50V

C713

R704

100

1/16W

R710

47K

1/16W

Y702

33pF

32768Hz

50V

C714

50V

33pF

1UF
10V

C755

100nF

16V

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

1/16W

R734

31 32 33 34 3536 37 38 3940 41 42 4344 45 46 47 48 49 50

10K

IC701

uPD780205GF

81828384858687888990919293949596979899100

80

79

78

77

76

75

74

73

72

71

70

69

68

67

66

65

64

63

62

61

60

59

58

57

56

55

54

53

52

Power (Red)

51

R786

330

1/16W

50V

C753

100nF

R702

R790

10K

1/16W

1/16W

1/16W

1/16W

10K

10K

10K

R794

R735

R797

C708

47nF
50V

R739

68K

1/16W

1N4148

D718

1N4148

D717

1N4148

D715

1N4148

D714

1N4148

D708

1N4148

D709

1N4148

D710

1N4148

D711

D713

1N4148

1N4148

D712

1N4148

D707

P516

16V

SW704

121212121

121

2

1

1

2

3

R744 R780

7.5K 47k

1/16W 1/16W

2

SW705

12

1

C430

100nF

SW715

IR701

GP1U287R

3

10K

10uF

C751

100N
1/16

1

10K

2

R796R795

1.5k1.2k

1/16W1/16W

2

SW707SW706

121

2

R740

R728

2.7K

2.2k

1/16W

1/16W

2

1

R729

1.5k

1/16W

SW703

SW714

BASS

12

12

R792

R791

2K

8.2K

1/16W

1/16W

R743R742R799R798

3.3k2.2k1.5k1.2k

1/16W1/16W1/16W1/16W

SW712SW711SW710SW709SW708

R737R736

4.7k3.3k

1/16W1/16W

2

12

1/16W1/16W 1/16W

12

SW716

R745R759

82K1.2K 4.7K

SW717

R793

SW718

DISC SKIP

SW713

SW702

D716

C730
10V
47uF

100R
1/16

C790
1nF

50V

C791
1nF
50V

C792
1nF
50V

C793

1nF
50V

1/16W

AUX IN

R413L

39K

1/16W

1

R413R

39K

1/16W

2

3

22K22K

C414LC414R

1nF1nF

1/16W1/16W

R414L

R414R

R741

22K

SW701

NJ504

50V50V

2

1

Tuner Schematic

TP001

C004

C001

D004

C003

C050

L001

D005

TF001

12

N002

C062

C020

R014

6

C060

1

6

2

5

D003

C019

TF003

1

2

34

G

34

C018

TP002

R006

C011

R009

R007

R008

R013

R010

C015

C016

C021

RFGND
TP001G

C007

1

C010

L003

D001

L004

D002

R011

3

2

RV001

1

R097

C008

CV001

G

C009C012

R005

G

CV002

R012

2

3

4

5

C013

6

7

8

9

10

TP009

11

C014

12 13 14 15 16 17 18 19 20 21 22

R015

TP012

C022

C027

C024

C026

C025

C023

TP011

TF008

TF005

6

TP004

C099

IC001

C029

C028

34

1

2

2

1

6

34

Y001

SELECTION

CA03

C030

TF006

TP007

R017

R021

TP003

Y002

3435363738394041424344

C041

TF007

34

33

2

1

32

31

30

29

TP010

28

27

R036

26

TP005

25

X001

24

TP006

23

R031

R030

C031

C032

C033

TP008

L007

C043

6

R035

R046

R045

C036

C047

R034

C035

C034

R047

C046

C045

JP02

Q008

R056

Q009

R057

R058

Copyrighted Thomson Inc.

Cassette Audio Schematic

BIAS OSC

TP60G

TP60

REC/PLAYBACK

DECK 1

R301

56K

1/4W

R302

47k

1/4W

C303

68nF
50V

1234

N300

R304

120

1/4W

Q301

KTC3203

C304

10uF

C301

50V
33nF
50V

C302

6n8F

50V

L301

REC
78

PB

9

SW1

L302

470u

L303

470u220u

12K

R301L

1/4W

R302L

C301L

10K

1.8nF
50V

1/4W

SW1

10 11

12

C309L

C309R

SW1

45

6

1.8nF

C301R

50V

R301R

12K
1/4W

R304R

R302R

10K

R303R

1/4W

1/4W

7R5

1/4W

13 14

100nF

R304L

C302L

50V

1K2
1/4W

R305L

33K 1/4W

R303L

7R5

C303L

1/4W

100uF

50V

2n2
50V

2n2
50V

1K2

-

AMP CH1

+

+

AMP CH2

-

8 9 10 11 12 13 14

C303R

100uF

50V

100nF

C302R

50V

R305R

33K
1/4W

SW1

15

C304L

10uF

50V

C305L

220pF
25V

C305R

220pF

25V

SW1

12

3

R306R

1/4W

R307L

390K

C308L

R306L

1/4W

1uF

1K

50V

1/4W

18

C306L

47nF
50V

1617

SW1

R305

C306

100uF

22K

10V

1/4W

1234567

ALC

RIPPLE FILTER

IC300

50V
47nF

C306R

C305

22uF

C304R

50V
10uF
50V

1/4W

R307R

390K
1/4W

1K

R300

220

1/4W

C300

100uF

10V

R315R

5.6K

5.6K
1/4W

R316R

C308R

R315L

5.6K

5.6K

1/4W

R316L

1/4W

1uF

50V

1234

N302

12345678910

TAPE_MUTE/STANDBY

12V

M-GND

7V

AGND

REC-L

REC-R

L/O

R/O

REC-S

N301

M

Q302

5.6K
KTA1271Y

1/4W

R310

10K

220

10k

1/4W

1/4W

1/4W

R309

R307 R306

Q303

KTC1815

10k

1/4W

R308

Copyrighted Thomson Inc.

Carousel Motor Drive Schematic - IC001/2 FAN8082

DRAWER1 BD

PI006

COL

3

4

EMIT

RPI-574

SENSORS

TO/FROM

SLIDER1

SLIDER2

3

4

3

4

COL

EMIT

JD001

CD-RESET

CRSMTR1

CRSMTR2

DISC-SW

PLAT-SW

RPI-574

COL

EMIT

PI002

RPI-574

DRWMTR2

DRWMTR1

+V1CC

SDATA

P003

6

5

4

GND

3

2

+V1

1

PI001

KAT

2

1

ANO

KAT

2

1

ANO

R002

100

1/4W

DRAWER

MOTOR

P004

1

M

2

(CIRCLE)

P005

P008

CD-L

9

9

AGND

8

8

CD-R

7

7

6

6

5

5

GND

4

4

SCLK

3

3

+5V

2

2

1

1

Copyrighted Thomson Inc.

R003

2R2

1/4W

5678

VO2

VIN2PVCCSVCC

FAN8082

IC001

MOTOR
DRIVER

VCTL VIN1

GND VO1

1234

D001
1/2W

R004

2R2

1/4W

VO2

FAN8082

IC002
MOTOR

DRIVER

VCTL VIN1

GND VO1

1234

5V6

5678

VIN2PVCCSVCC

D002

5V6

1/2W

C004

100nF

25V

C005

1000uF

D003 D004

1N4002 1N4002

25V

L001
39uH

C002

TO/FROM
KEY DISPLAY BOARD

P009

SLIDER1

1

SLIDER2

2

PLATTER-

3

PLATTER+

4

PLAT-SW

5

DISC-SW

6

DRAW1

7

DRAW2

1

DRAWER+

2

DRAWER-

3

SCLK

4

GND

5

SDATA

6

CD-RESET

7

8

P008

N006

KAT

2

1

ANO

P006

3

3

2

2

1

1

P007

2

1

P002

1

2

3

JC001

+5V

DRAWER2

PI005

KAT

COL

3

4

ANO

EMIT

RPI-574

DRAWER POSITION

FROM

AMP BOARD

GND

+12V

TO

MAIN BOARD

CD-L

AGND

CD-R

C006R005
10nF100

2

1

50V1/4W

100nF

25V

CAROUSEL MOTOR PCB

R001

SLIDER POSITION

NOTES:

1. Unless otherwise specified:

A. All resistor values are in ohms,

1/8W

B. All Capacitor values are in F

2. Voltages are positive with respect

to ground under no signal conditions

and volume control minimum

3. Replace transistors with type

specified from replacement parts list

4. Unless otherwise stated, all voltages

taken in radio "on" position

5. * and indicates critical safety

components. Replace only with those

specified from replacement parts list

to maintain proper performances and

safety of this unit.

-+

TCM

MODULE

Carousel Mot. Drv. Schematic - IC001/2 BA6029/LB1641

Copyrighted Thomson Inc.

SLIDER1

SLIDER2

PLATTER-

PLATTER+

PLAT_SW

DISC_SW

DRW1

DRW2

12345678 1234567

DRAWER+

DRAWER-

SCLK

P008 P009

FROM

TO

GND

SDATA

CD_RESET

JC001

+5V.

DRAWER2

PI005

RPI-574

KAT

COL

3

4

ANO

EMIT

123

P006

DRAWER POSITION

GND

+12V

12

P007

P002

CD_L

123

AGND

CD_R

R005

100

C006

10nF
50V

2

1

RPI-574

COL

3

4

EMIT

PI006

DRAWER1 BD

TO/FROM

KEY DISPLAY BOARD

N006

KAT

2

123

1

ANO

AMP BOARD

MAIN BOARD

IC001

MOTOR

LB1641

BA6209N /

GND

OUT1P1VZ

12345678910

C001

22pF
50V

BA6209N /

GND

OUT1P1VZ

12345678910

C003

22pF
50V

L001

39uH

DRIVER

IN1

IN2

VCC1

VCC2P2OUT2

C002

100nF
25V

R003

D001

2R2

5V6

IC002

MOTOR

LB1641

DRIVER

IN1

IN2

VCC1

VCC2P2OUT2

D002

5V6

R004

2R2

D003

C005

1000uF
25V

1N4002

NOTES:

1. Unless otherwise specified:

A. All resistor values are in ohms,

1/8W

B. All Capacitor values are in ?F

2. Voltages are positive with respect

to ground under no signal conditions

and volume control minimum

3. Replace transistors with type

specified from replacement parts list

4. Unless otherwise stated, all voltages

taken in radio "on" position

5. * and indicates critical safety

CRSMTR1

6

CRSMTR2

5

DISC_SW

4

GND

3

PLAT_SW

R001

P004

DRWMTR2

1

DRWMTR1

C004

100nF
25V

D004

1N4002

2

+V1

DRAWER

MOTOR

M

(CIRCLE)

5V

2

1

P003

-+

JD001

TO/FROM

CAROUSEL MOTOR PCB

SLIDER POSITION

SENSORS

/GP1S58V

PI001

RPI-574

CD_RESET

SLIDER1

SLIDER2

P008

CD_L

9

9

AGND

8

8

CD_R

7

7

+V1CC

6

6

SDATA

5

5

GND

4

4

SCLK

3

3

+5V

2

2

1

1

P005

3

4

COL

3

EMIT

4

TCM

MODULE

COL

EMIT

PI002

RPI-574

/GP1S58V

KAT

ANO

KAT

2

1

ANO

2

1

100

R002

components. Replace only with those

specified from replacement parts list

to maintain proper performances and

safety of this unit.

Audio Switching/ Headphone Jack Schematic

R420

56

1/16W

50V

50V

C453R

2u2F

2u2F 50V

2u2F

C409R

C409L

P301

CD_SYNCHRO

TAPE_L

TAPE_R

RECORD_L

RECORD_R

AGND

6.8V

AGND

+10V

TAPE_MUTE

12345678910

10K

R411

1/16W

47K

D401

R410

1/16W

R412

Q410

1/4W

10K

KTC3875

9

8

7

1

3

2

6

5

4

NJ503

NJ503

NJ503

Q410L

R410L

1N4148

1/16W

4K7

KTC3875

Q410R

R410R

1/16W

4K7

C412

22UF

10V

C600

470uF

10V

6.5uH

L603L

50V

100nF

C601L

6.5uH

L602

50V

100nF

C601R

1234

1234

6.5uH

L603R

P601

P601A

H/P_IN

28

IC401

123456789

KTC3875

Q603L

KTC3875

100uF
10V

C605L

2K2

R617L

1/16W

Q603R

KTC3875

100uF

10V

C605R

180

R617R

1/4W

2K2

R616R

1/16W

R_IN4

R_IN3

50V

C402R

2u2F

R616L

180

1/4W

LOUT

ROUTVSCREF

R_IN2

R_IN1

C400R

2u2F 50V

50V

2u2F

1/16W

1.8K

R615L

25V

1.8K

R615R

1/16W

AUDIO_L

AUDIO_R

C402

100pF 50V

100pF

C403

252627

AGND

L_IN1

50V

C401R

C401L

2u2F

22uF
C604L

Q602L

R613L

22

1/16W

AGND

R612R

22uF25V

C604R

R613R

22

1/16W

R407

1K

C420

47uF 25V

TDA7440D

L_IN3

50V

2u2F

H/P_VCC

H/P_VCC

1k

1/16W

Q602R

1/16W

1K

1/16W

R408

50V

50V

5n6F

5n6F

C404R

C404L

SDA

SCL

D-GND

TREBLE(R)

TREBLE(L)

IN(R)

MUXOUT(R)

IN(L)

MUXOUTL

L_IN4

1011121314 15

50V

C410R

C410L

2u2F

2u2F

50V

50V

C402L

C453L

2u2F

R600

1/2W

47

R610L

470K
1/16W

10V

1uF

R611L

47K

1/16W

C611L

1/16W

R610R

330k

KTC3875

R611R

10V

1uF

1/16W

47K

C611R

NC2

BIN(R)

C407R

150nF

50V

AUDIO_L

AUDIO_R

161718192021222324

NC1

BOUT(R)

C408R

100nF

50V

6.8V

10V

100uF

C400

50V

C408L

100nF

BOUT(L)

R403L

5K6

1/16W

50V

C407L

150nF

BIN(L)

R403R

1/16W

5K6

Q401

KTC3203Y

C411

220uF
16V

D402

7V5

50V

L_IN2

C400L

50V

2u2F

R612L

1/16W
1k

KTC3875

SDATA

SCLK

D-GND

TUNER_L

TUNER_R

AUDIO_L

GND

AUDIO_R

N702N701

123456789

TUNER-PWR

CD_SYNCHRO

CLOCK-T

ST-MONO

DATA-T

WR-EN

H/P_MUTE

SDATA

SCLK

TAPE_MUTE

NOTES:

1. Unless otherwise specified:

A. All resistor values are in ohms,

1/4W

B. All Capacitor values are in uF

2. Voltages are positive with respect

to ground under no signal conditions

and volume control minimum

3. Replace transistors with type

specified from replacement parts list

4. Unless otherwise stated, all voltages

taken in radio "on" position

5. * and indicates critical safety

components. Replace only with those

specified from replacement parts list

to maintain proper performances and

safety of this unit.

AGND

-30V

FIL+

FIL-

+10V

123456

R401L

10K

R401R

R402L

10K

R402R

10K

1/16W

10K

1/16W

AGND

50V

100nF

R401

560

1/2W

C410

47uF

25V

N516

AUX_L

1

AGND

2

3

AUX_R

P401

1/16W

CD_L

1

AGND

2

CD_R

3

1/16W

+10V

12

C061

AGND

P101

AGND

Copyrighted Thomson Inc.

Audio Output/Power Supply Schematic

X883

X884

H/P_IN

H/P_MUTE

+10V

-30V

FIL+

FIL-

AUDIO_L

AGND

AUDIO_R

R511

10K

1/16W

JP881

1N4148

1N4148

R512

6K8

1/16W

LIVE

NEUTRAL

X885

SHIELD_GND

AMP_MUTE

D515

D516

R881

3M3

1/2W

L

N

WARNING
SEE NOTE

R502L

C502L

33K

1uF

1/16W

50V

R507L

100K

1/16W

R507R

100K

1/16W

C502R

R502R

1uF

33K

50V

1/16W

R502

470

1/16W

1/2W

2V4

D504

KTC3875GR

Q501

R510

D501

5V1

1K 1/16W

1/2W

100pF

C502

50V

1K5

R532

1/16W

L

N

WARNING
SEE NOTE

C518

100nF

+VS

STBY-GND

+VS

TDA7293

STBY-GND

WARNING

SEE NOTE

123

D514

>25V
1/2W

7

IC501

TDA7293

1

7

IC502

1

111213

BUFFER_DRIVER

-VS

8

111213

BUFFER_DRIVER

-VS

8

WARNING
SEE NOTE

C512

4700uF
50V

C516

22uF

25V

BOOT_LOADER

BOOTSTRAP

CLIP_DET

-PWVS +PWVS

15

BOOT_LOADER

BOOTSTRAP

CLIP_DET

-PWVS +PWVS

15

100uF

50V

-POWER_SUPPLY

R530

4K7
1/2W

WARNING
SEE NOTE

C514

2200uF

25V

AGND

63V

C501L

R501L

5pF

33k

50V

1/16W

OUT

14

C537

22uF
25V

R505L

D501L

2K2

1N4148

1/16W

56

C524

100nF

63V

C533

C501R

5pF

50V

OUT

14

56

C520

100nF

63V

C540

100uF

R501R

33k

50V

63V

1/16W

100nF

C538
22uF

25V

R505R

D501R

2K2

1N4148

1/16W

R510L

10
1/4W

L501L

C521L

0.5uH
330nF

50V

R512L

C505L

4R7

1NF

1/16W

50V

C518L

100nF

16V

C518R

100nF

16V

R512R

C505R

4R7

1/16W

1NF

50V

C539

C521R

330nF

50V

L501R

0.5uH

R510R

10

1/4W

L502L

5uH

L

C519L

5uH

L503L

100nF 16V

5uH

L503R

C519R

100nF

R

L502R

5uH

R505

10K

1/16W

R506R

R506L

22k

22k

1/16W

1/16W

R503

10K

1/16W

D502R

1N4148

D502L

1N4148

C503

47uF
25V

R509

10

1/4W

KTC3875GR

NJ501

16V

1234

+10V

KTA1273

Q502

12

N501

R504

1K

1/4W

Q503

+POWER_SUPPLY

C526

100nF 100V

D507

100nF

C525

100nF

100V

D506

D505

1N5402

1N5402

C528

WARNING

C527

SEE NOTE

100V100nF

100V

100nF

D508

1N5402

1N5402

C529

100nF

C530

50V

50V

D510

D509

1N4001

1N4001

D512

D511

WARNING

1N4001

1N4001

SEE NOTE

100nF
50V

C531

C532

100nF

50V

7.5V

1/2W

R885

C807

100nF

27V

D820

1.3W

50V

C513

4700uF

50V

WARNING
SEE NOTE

R886 D821

220 1/2W

D819

10k
1/4W

C806

WARNING
SEE NOTE

F503

5S_5A_125V

R531

4K7

1/2W

F504

5S_5A_125V

WARNING
SEE NOTE

RF505

WARNING

1W

0.27

SEE NOTE

1N4001

R888

1

1/4W

C805

100uF

100uF

50V

50V

R889

1

1/4W

D822

12

JW3

JW2

123

JW1

N801A

12345

JW04

JW05

1N4001

JW06

PF01

N/A

JW07

JW08

N801B

WARNING

SEE NOTE

R503L
390
1/16W

C509L

C507L

470pF
50V

C507R

470pF
50V

R503R

C509R

1N4148

D503

R525

33K

1/16W

C534

R529

10uF

10K

1/16W

50V

IN-

234

47uF

50V

IN+

C522L

1NF
50V

SGND

MUTE

STBY

910

390

1/16W

IN-

47uF

234

50V

IN+

C522R

1NF
50V

SGND

MUTE

STBY

C535

910

10uF

50V

D513

1N4148

IC503

WARNING
SEE NOTE

IN

OUT

KIA7812

GND

100nF

C515

25V

22uF

C523

16V

Copyrighted Thomson Inc.